Parts Catalog
Issued: May 27, 2008
Pronto® M71™ jr.
with SureStep™
CWD
Powered Wheelchair
Yes, you can. ™
Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the
bottom of the page or below specified charts.
Parts Catalog Usage Guide
To order call toll free 1-800-333-6900, or www.invacare.com
The information contained in this document is subject to change without notice. This catalog contains
service parts for Form No. 03-033. If you have any questions regarding this catalog, please contact one
of our Customer Service Representatives.
For Customer Service Support Call:
1-800-333-6900
For Faxed In Orders Call:
1-800-678-4682 or
1-440-366-0709
For Technical Service Call:
1-800-832-4707
Literature Can Be Found at:
www.invacare.com or
1-800-828-6272
SYMBOL DEFINITION
Examples:
A,B,C etc.
NOTE:
NLA
= Special Comments
= General information pertaining to that specific page
= No Longer Available
HARDWARE MEASUREMENTS
The measurements for the hardware will be listed as follows:
Screws, Bolts
Washers
Spacers
For your convenience, we have supplied an area for you to list your Invacare Representatives.
©2008 Invacare Corporation. Elyria, Ohio. Invacare, Yes, you can., the Medallion Design, and Pronto are registered trademarks and MK6i, MK5, NX, EX,
Diameter X Thread Count/Pitch X Length
Inside Diameter X Outside Diameter X Thickness
Inside Diameter X Outside Diameter X Length
Name Phone Numbers
SPJ, DPJ, MPJ, SureStep, and M71 are trademarks of Invacare Corporation.
Form No.
03-033
1
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
03-033
Description
A: READ THIS FIRST (THIS CATALOG IS DIFFERENT!) ...................................................... 5
Accessories - Miscellaneous .................................................................................................... 126
Accessories - Power Wheelchair Tool Kit ................................................................................ 128
Arms, Adjustable Height ........................................................................................................... 46
Back Cane Mounting Hardware - After 10/26/04 (All Depths) .................................................. 40
Back Canes and Spreader Bar - Before 10/27/04 .................................................................... 30
Back Canes and Spreader Bar Mounting Hardware - Before 10/27/04 (12-13" Seat Depths) . 34
Back Canes and Spreader Bar Mounting Hardware - Before 10/27/04 (14-15" Seat Depths) . 36
Back Canes and Spreader Bar Mounting Hardware - Before 10/27/04 (16" Seat Depth) ........ 38
Back Canes, Spreader Bar, and Push Handle - After 10/26/04 ............................................... 31
Back Upholstery - Black Nylon ................................................................................................. 42
Battery Tray and Battery Harness Assemblies ......................................................................... 54
Casters, Forks, and Hardware ................................................................................................. 50
Electronics - Joystick Options .................................................................................................. 121
Electronics - MK5 Controller Cables ........................................................................................ 105
Electronics - MK5 Display ........................................................................................................ 116
Electronics - MK5 DPJ Joystick and Mounting Hardware ........................................................ 99
Electronics - MK5 EX Controller, Programmer and Battery Charger ....................................... 103
Electronics - MK5 MPJ Joystick and Mounting Hardware ........................................................ 101
Electronics - MK6i -PLEASE READ THIS PAGE- .................................................................... 98
Electronics - Proportional Attendant Control Joystick PACM5 ................................................. 119
2
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
03-033
Description
Electronics - Quad Link (QLA) After 10/30/05 .......................................................................... 110
Electronics - Quad Link Assembly Before 10/31/05 ................................................................. 107
Electronics - R.I.M. Head Control Assembly (1500) ................................................................. 112
Electronics - R.I.M. Head Control Mounting Hardware (1500) ................................................. 114
Electronics - Sip-N-Puff/Digital Interface 1554M4/1554M5 and AUX12 and AUX34 ............... 117
Electronics - Tash and Therafin Accessories ........................................................................... 123
Frame Finish, Shroud Colors, and Upholstery Color ................................................................ 6
Frame, Side and Hardware - Non Tilt Chairs ........................................................................... 11
Frame, Side and Tilt Hardware - Tilt Chairs ............................................................................. 13
Front Rigging - Center Mount Rigging (CTMT) ........................................................................ 82
Front Rigging - Center Mount Rigging (CTMT/CTMT-L) .......................................................... 95
Front Rigging - Center Mount Rigging (CTMTJ) ...................................................................... 79
Front Rigging - Center Mount Rigging CTMTJ ......................................................................... 84
Front Rigging - Center Mount Rigging Kit (CTMTJ and CTMT) - After 10/26/04 ..................... 93
Front Rigging - Center Mount Rigging Kit (CTMTJ and CTMT) - Before 10/27/04 .................. 91
Front Rigging - Center Mount Rigging Mtg. Hdwr. (CTMTJ & CTMT) - After 10/26/04 ............ 89
Front Rigging - Center Mount Rigging Mtg. Hdwr. (CTMTJ & CTMT) - Before 10/27/04 ......... 87
Front Rigging - Footboard Assembly - 90FB ............................................................................ 56
Front Rigging - Footrest and Legrest Accessories ................................................................... 74
Front Rigging - Footrest Supports, (Hemi) - PH93M2 .............................................................. 64
Front Rigging - Footrest Supports, (Hemi) - PHW93 ................................................................ 62
3
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
03-033
Description
Front Rigging - Front Rigging Hangers and Hardware ............................................................. 60
Front Rigging - Legrest Supports, Articulating (Hemi) - PHAL4A ............................................. 66
Front Rigging - Pivot/Slide Tube and Adjustable Angle Footplates - AT5543 .......................... 71
Front Rigging - Pivot/Slide Tube and Footplate - 1650 Standard Aluminum ............................ 69
Front Rigging - Reference Chart .............................................................................................. 58
Headrest and Attaching Hardware ........................................................................................... 44
Label Locations For TRRO and TRBKTS Options ................................................................... 9
Motor, Gearbox, and Drive Wheel ............................................................................................ 51
Packaging, Literature and Decals ............................................................................................ 7
Seat Frame Mounting Hardware - After 10/26/04 .................................................................... 19
Seat Frame Mounting Hardware - Before 10/27/04 ................................................................. 17
Seat Frame, Seat Pan and Hardware, A.S.B.A. - Before 10/27/04 .......................................... 23
Seat Frame, Seat Pan and Hardware, ASBA w/ TRBKTS - Introduced 12/19/05 .................... 28
Seat Frame, Seat Pan and Hardware, ASBA w/ TRRO - Introduced 10/27/04 ........................ 26
Seat Release Hardware ........................................................................................................... 21
Shrouds and Mounting Hardware ............................................................................................. 48
SureStep Walking Beams and Hardware ................................................................................. 15
TRRO and TRBKTS Option Clarification Reference ................................................................ 10
Wheel Lock Assembly .............................................................................................................. 124
4
A: READ THIS FIRST (THIS CATALOG IS DIFFERENT!)
Form No.
03-033
5
To order call toll free 1-800-333-6900, or www.invacare.com
Frame Finish
Color
Number
Part
Number
Bottle
Size
Color
Flat Black.6 oz.104632734P
Shroud Colors
Color
Code
Shroud Color
Description
Deep Blue PearlBL
Magic BlackMB
Candy Red PearlRD
Upholstery Color
Color
Number
Color
Description
Black NylonU240
Frame Finish, Shroud Colors, and Upholstery Color
Form No.
03-033
6
To order call toll free 1-800-333-6900, or www.invacare.com
Packaging, Literature and Decals
Form No.
03-033
7
To order call toll free 1-800-333-6900, or www.invacare.com
Packaging, Literature and Decals
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1030362 Carton, Tray 1 21
1030364 Carton, Cover 1 12
40131X161 Insert, Plain Pad 1 23
1015592 Bag, Poly (72" L x 35" W x 19" D) 1 14
1115174 Carton, Corner Reinforcement 1 45
1122147 Manual, Owner's Pronto M71 Jr. 1 1A
1114808 Manual, Instruction MK5 EX/ TT-EX Electronics 1 1A
1121907 Decal, Shroud (Pronto M71 Jr.) 1 2A
A - Not Shown
NOT
E: When adjusting or replacing parts, please refer to your owner's manual for assistance.
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
8
Label Locations For TRRO and TRBKTS Options
Form No.
03-033
9
To order call toll free 1-800-333-6900, or www.invacare.com
TRRO and TRBKTS Option Clarification Reference
Form No.
03-033
10
To order call toll free 1-800-333-6900, or www.invacare.com
Side Frame and Hardware
Non Tilt Chairs
Form No.
03-033
11
To order call toll free 1-800-333-6900, or www.invacare.com
Side Frame and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1105026 Cap, Headtube 1 11
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 22
1123397-NLA Slide Tube, Seat Height Adjustment -Rear 1 23
1152528 Slide Tube, Seat Height Adjustment - Rear 1 23 D
1123524 Slide Tube, Seat Height Adjustment -Front 1 14
1026158 Locknut (5/16-18) 1 25
40117X006 Bearing (5/8") 1 26
1109198 Label Yellow Stripe 1 27
1109200 Label Marker (2) 1 18
1109199 Label Marker (1) 1 19
1109201 Label Marker (3) 1 110
1109320 Side Frame Assembly - Right 1 111 A
1109321 Side Frame Assembly - Left 1 111 A
1123398 Kit, Side Frame Hardware 1 1B,C
A - Includes items 6-10
B - Includes items 1-5
C - Not Shown
D - When replacing a "Slide Tube, Seat Height Adjustment - Rear" part # 1123397 with the part # 1152528 both sides must be
replaced simultaneously.
NOTE:
Non Tilt Chairs
Form No.
03-033
12
To order call toll free 1-800-333-6900, or www.invacare.com
Side Frame and Tilt Hardware
Tilt Chairs
Tilt Sensor Cable and Splitter Cable can be found in the MK5 Controller Cables category.
Form No.
03-033
13
To order call toll free 1-800-333-6900, or www.invacare.com
Side Frame and Tilt Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1105026 Cap, Headtube 1 21
1126151 Screw, Socket Head Cap (5/16-18 x 2") 1 42
1126107 Slide Tube, Seat Height Adjustment -Rear 1 23 A
1105038 Cap, Tube (1" Square) 1 24
1082705 Bearing, Flanged 1 45
1104846 Screw, Socket Head Shoulder (5/16 x 1-1/2") 1 16
1026158 Locknut (5/16-18) 1 67
1025736 Locknut (1/4-20) 1 18
1126112 Bracket, Cylinder 1 19
1126113 Bracket, Sensor Actuator 1 110
1095502 Package, Cable Ties (11-1/2" Long) 10 111
1126105 Cylinder, Locking with Cable & Release Handle 1 112 B
1126103 Release Handle w/ Cable Assembly 1 113
1123524 Slide Tube, Seat Height Adjustment -Front 1 214
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 215
1126121 Kit, Frame/Tilt Hardware 1 116 C
40117X006 Bearing (5/8") 1 217
1109320 Side Frame Assembly - Right 1 118 D
1109321 Side Frame Assembly - Left 1 118 D
1025195 Locknut (1/4-20) 1 119
1074642 Screw, Hex Head (1/4-20 x 1-3/8") 1 120
0062800 Bracket, Cable/Wire Mount 1 121
1140099 Switch, Drive Lockout Mercury (MK6i) 1 122 E
1104846 Screw, Socket Head Shoulder (5/16 x 1-1/2") 1 123
1012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 224
1025736 Locknut (1/4-20) 1 125
1120253 Washer, Lock Internal Tooth (#2) 1 426
1126570 Screw, Phillips Pan Head (#2-56 x 5/8") 1 227
1126122 Cable, Tilt Sensor 1 128
57007X002 Locknut (#2-56) 1 229
A - Includes items 4 and 5
B - Includes item 13
C - Includes items 1-15
D - Includes Bearings (item 17)
E - Please refer to the MK6i Electronics catalog for further information regarding electronic components.
NOTE:
Tilt Chairs
Tilt Sensor Cable and Splitter Cable can be found in the MK5 Controller Cables category.
Form No.
03-033
14
To order call toll free 1-800-333-6900, or www.invacare.com
SureStep Walking Beams and Hardware
Form No.
03-033
15
To order call toll free 1-800-333-6900, or www.invacare.com
SureStep Walking Beams and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1109025 Walking Beam, SureStep -Right 1 11 A
1109026 Walking Beam, SureStep -Left 1 11 A
40157X015 Washer (9/16 x 1 x 5/8") 1 22
1106492 Washer (1/2 x 29/32 x 1/32") 1 43
1106485 Bushing (1/2 x 5/8") 1 84
1109018 Tube, Pivot 1 15 A
1025737 Locknut (1/2-20) 1 26
1106078 Plate Reinforcement 1 17
1050161 Screw, Hex Head Cap with Patch (5/16-18 x 1") 1 18
1108066 Kit, SureStep Walking Beam Hardware 1 19 B
1105030 Bolt, Round Head Square Neck (5/16-18 x 1") 1 110
1026158 Locknut (5/16-18) 1 111
1129464 Spring, Extension 1 112
A - Includes 4 each Bushings, item 4
B - Includes items 2, 3, 6-8
NOTE:
Form No.
03-033
16
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame Mounting Hardware
Before 10/27/04
NOTE: A.S.B.A. Junior seat frame adapter is offered as an ON-Chair item only. When a replacement is
required, call Invacare’s Technical Service Department at 1-800-832-4707 for assistance.
Form No.
03-033
17
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
90162X000 Screw, Hex Head (5/16-18 x 2-1/2") 1 41
1026158 Locknut (5/16-18) 1 42
1083199 Label, Hook Tie-Down 1 43
1105038 Cap, Tube (1" Square) 1 44
Before 10/27/04
NOTE: A.S.B.A. Junior seat frame adapter is offered as an ON-Chair item only. When a replacement is
required, call Invacare’s Technical Service Department at 1-800-832-4707 for assistance.
Form No.
03-033
18
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame Mounting Hardware
After 10/26/04
NOTE: A.S.B.A. Junior seat frame adapter is offered as an ON-Chair item only. When a replacement is
required, call Invacare’s Technical Service Department at 1-800-832-4707 for assistance.
Form No.
03-033
19
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
90162X000 Screw, Hex Head (5/16-18 x 2-1/2") 1 41
1026158 Locknut (5/16-18) 1 42
1083199 Label, Hook Tie-Down 1 43
1105038 Cap, Tube (1" Square) 1 44
1031665 Screw, Socket Head Shoulder (3/8 x 1-1/2") 1 25
1028769 Locknut (5/16-18) 1 26
1128262 Spacer, Seat Frame Adapter 1 27
After 10/26/04
NOTE: A.S.B.A. Junior seat frame adapter is offered as an ON-Chair item only. When a replacement is
required, call Invacare’s Technical Service Department at 1-800-832-4707 for assistance.
Form No.
03-033
20
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Release Hardware
Form No.
03-033
21
To order call toll free 1-800-333-6900, or www.invacare.com
Seat Release Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1109219 Spring, Torsion, Right 1 11
1109220 Spring, Torsion, Left 1 12
1108239 Pin, Slotted (1/4 x 1-1/8") 1 23
1106476 Latch, Seat 1 14 A
1108068 Kit, Seat Release Hardware 1 15 B,A
1126119 Latch, Seat 1 16 C
1116983 Screw, Hex Head (5/16-18 x 1-1/2") 1 27
1071276 Nut, Hex (1/4-20) 1 18
1126116 Bracket, Cylinder Cable 1 19
1028769 Locknut (5/16-18) 1 210
1126103 Release Handle w/ Cable Assembly 1 111
1126120 Seat Release Assembly 1 112 C,D
A - Non-Tilt chairs
B - Includes items 1-4
C - Tilt chairs
D - Includes items 1-3, 6-11
NOTE:
Form No.
03-033
22
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame, Seat Pan and Hardware
Before 10/27/04
Form No.
03-033
23
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame, Seat Pan and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1024793 Screw, Hex Head (1/4-20 x 1-3/4") 1 21 A
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 42 B
1047449 Spacer (1/4 x 3/8 x 3/16") 1 43 B
1025736 Locknut (1/4-20) 1 64
1123393 Kit, Seat Pan Mounting Hardware (12-15" Deep
Seats)
1 15 C
1123394 Kit, Seat Pan Mounting Hardware (16" Deep Seat) 1 15 C
1039949 Fastener, Hook Adhesive Back (2" x 16") 1 26
1044578 Fastener, Loop Adhesive Back (2" x 16") 1 26
See Chart #7 Seat Pans 1 17
1037610 Screw, Hex Head (1/4-20 x 1-5/8") 1 48
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 49
1047449 Spacer (1/4 x 3/8 x 3/16") 1 410
1025736 Locknut (1/4-20) 1 411
1029501 Plug Button, Black (1") 1 212
1090768 Kit, Lock Handle w/Rivets (both LT & RT side) 2 113
See Chart #14, 15, & 16 A.S.B.A. Junior Seat Frame Assembly 1 114
See Chart #14, 15, & 16 A.S.B.A. Junior Seat Frame Assembly 1 115
See Chart #14, 15, & 16 A.S.B.A. Junior Seat Frame Assembly 1 116
A - 16" deep seats use a quantity of 4 each
B - 16" deep seats use a quantity of 2 each
C - Includes items 1-4
NOTE:
Before 10/27/04
Form No.
03-033
24
To order call toll free 1-800-333-6900, or www.invacare.com
A.S.B.A. Seat Frame, Seat Pan and Hardware
#7 Seat Pans
Chair Width 12"-15" Deep 16" Deep
1070513106600912" Wide
1070514106601013" Wide
1066011106602214" Wide
1066012106602315" Wide
1066013106602416" Wide
NOTE: 12"-15" seat depths are achieved by using different back cane mounting hardware.
#14, 15, and 16 Seat Frame Assembly
Item
Number
Seat
Frame
12"-16" W
12"-16" D
1070473
Seat Frame
Right
14
See Note(s) A
1070474
Seat Frame
Left
14
See Note(s) A
1121982
Seat Frame
Center
15
1121991
Seat Frame
Assembly
16
See Note(s) B
A - Seat frame includes item 13 arm lock assembly.
B - Includes items 8-15
NOTE:
Before 10/27/04
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
25
ASBA Seat Frame, Seat Pan and Hardware
TRRO Option - Introduced 10/27/04
Form No.
03-033
26
To order call toll free 1-800-333-6900, or www.invacare.com
ASBA Seat Frame, Seat Pan and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1126144 Seat Pan w/ Hook and Loop Fasteners (12-16" W x
12-18" D)
1 11 A
1024793 Screw, Hex Head (1/4-20 x 1-3/4") 1 42
1008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 33
1122652 Screw, Hex Head (5/16-18 x 5/8") 1 104
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 105
1122619 Socket, Front Arm - Right 1 16
1122620 Socket, Front Arm - Left 1 16
1126127 Rail, Side (12-18" Deep) 1 27
1121982 Frame, Center Seat 1 18
1025736 Locknut (1/4-20) 1 79
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 410
1045267 Screw, Hex Head (1/4-20 x 3/4") 1 811
1029501 Plug Button, Black (1") 1 212
1126126 Crossbar, Seat Frame (12-16" Wide) 1 413
1026907 Washer (1/4 x 1/2 x 1/16") 1 614
1068039 Pin, Pull 1 215
1126142 Socket, Rear Arm 1 216
1069724 T-Nut (5/16-18) 1 1017
1039949 Fastener, Hook Adhesive Back (2" x 16") 1 418
1044578 Fastener, Loop Adhesive Back (2" x 16") 1 418
A - Includes item 18
NOTE:
TRRO Option - Introduced 10/27/04
Form No.
03-033
27
To order call toll free 1-800-333-6900, or www.invacare.com
ASBA Seat Frame, Seat Pan and Hardware
TRBKTS Option - Introduced 12/19/05
Form No.
03-033
28
To order call toll free 1-800-333-6900, or www.invacare.com
ASBA Seat Frame, Seat Pan and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1133597 Bracket, Back Cane - Right 1 11
1133598 Bracket, Back Cane - Left 1 11
1024793 Screw, Hex Head (1/4-20 x 1-3/4") 1 42
1008495 Screw, Socket Button Head (1/4-20 x 1-1/2") 1 33
1122652 Screw, Hex Head (5/16-18 x 5/8") 1 104
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 105
1122619 Socket, Front Arm - Right 1 16
1122620 Socket, Front Arm - Left 1 16
1126127 Rail, Side (12-18" Deep) 1 27
1121982 Frame, Center Seat 1 18
1025736 Locknut (1/4-20) 1 79
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 410
1045267 Screw, Hex Head (1/4-20 x 3/4") 1 811
1029501 Plug Button, Black (1") 1 212
1126126 Crossbar, Seat Frame (12-16" Wide) 1 413
1026907 Washer (1/4 x 1/2 x 1/16") 1 614
1068039 Pin, Pull 1 215
1126142 Socket, Rear Arm 1 216
1069724 T-Nut (5/16-18) 1 1017
1039949 Fastener, Hook Adhesive Back (2" x 16") 1 418
1044578 Fastener, Loop Adhesive Back (2" x 16") 1 418
1126144 Seat Pan w/ Hook and Loop Fasteners (12-16" W x
12-18" D)
1 119 A
A - Includes item 18
NOTE:
TRBKTS Option - Introduced 12/19/05
Form No.
03-033
29
To order call toll free 1-800-333-6900, or www.invacare.com
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See Chart #1 Back Cane w/ Grip 1 11
1043871 Bar, Spreader, Black (14" Wide) 1 12
1043872 Bar, Spreader, Black (15" Wide) 1 12
1043873 Bar, Spreader, Black (16" Wide) 1 12
1032246 Grip, Cane 1 23
#1 Back Cane w/ Grip
Back
Height
Back Cane w/ Grip
10 Degree Bend
104995512"
104995613"
104995714"
104995815"
104557516"
104557617"
104557718"
104557819"
104557920"
105222721"
105223022"
NOTE: Back canes include foam grips
Back Canes and Spreader Bar
Before 10/27/04
Form No.
03-033
30
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes, Spreader Bar, and Push Handle
After 10/26/04
Form No.
03-033
31
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes, Spreader Bar, and Push Handle
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1126147 Kit, Spreader Bar Assembly (12"-16" Wide) 1 11 A,B
Cover, Spreader Bar 1 12
Insert, Spreader Bar Connector 1 23
Anti-Rattle (1") 1 24
Screw, Socket Button Head (1/4-20 x 1-1/2") 1 45
Spacer, Coved (1/4 x 11/16 x 1/2") 1 46
Tube, Spreader Bar 1 17
Locknut (1/4-20) 1 28
Plug Button, Black (1") 1 29
1127154 Kit, Back Cane Assembly with Hardware (12"-15"
Back Height)
1 110 C
Grip, Foam (4") 1 111
Handle, Push 1 112
Cane, Lower - 12"-15" Back Height 1 113
Screw, Socket Head (1/4-20 x 1-1/4") 1 214
Locknut (1/4-20) 1 215
1127155 Kit, Back Cane Assembly with Hardware (16"-19"
Back Height)
1 110 C
Grip, Foam (4") 1 111
Handle, Push 1 112
Cane, Lower - 16"-19" Back Height 1 113
Screw, Socket Head (1/4-20 x 1-1/4") 1 214
Locknut (1/4-20) 1 215
1127156 Kit, Back Cane Assembly with Hardware (20"-22"
Back Height)
1 110 C
Grip, Foam (4") 1 111
Handle, Push 1 112
Cane, Lower - 20"-22" Back Height 1 113
Screw, Socket Head (1/4-20 x 1-1/4") 1 214
Locknut (1/4-20) 1 215
1135505 Package, Foam Hand Grips (4" Long) 10 111
1126148 Kit, Spreader Bar with Headrest Bracket (12"-16"
Adj. Width)
1 116 D
Screw, Socket Button Head (1/4-20 x 1-1/4") 1 217
Locknut (1/4-20) 1 418
Folding Hinge Assembly 1 219
Cover, Spreader Bar w/ Headrest Bracket 1 120
Screw, Socket Button Head (1/4-20 x 1-1/2") 1 421
Spacer, Coved (1/4 x 11/16 x 1/2") 1 422
Anti-Rattle (1") 1 223
Insert, Spreader Bar Connector 1 224
Tube, Spreader Bar w/ Headrest Bracket 1 125
1028513 Screw, Socket Head (#10-32 x 1-1/4") 1 126
1126103 Release Handle w/ Cable Assembly 1 127
After 10/26/04
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
32
Back Canes, Spreader Bar, and Push Handle
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1086207 Nut, Square (#10-32) 1 128
1133698 Grip, Foam Hand (9" Long) 1 229
1082620 Handle, Push w/ Foam Grip, Black (12" Wide) 1 130
1082621 Handle, Push w/ Foam Grip, Black (13" Wide) 1 130
1082622 Handle, Push w/ Foam Grip, Black (14" Wide) 1 130
1082623 Handle, Push w/ Foam Grip, Black (15" Wide) 1 130
1082624 Handle, Push w/ Foam Grip, Black (16" Wide) 1 130
A - Plug Buttons are not required when stroller handles are used.
B - Includes items 2-9
C - Includes items 11-15
D - Includes items 17-25
NOTE:
After 10/26/04
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
33
Back Canes and Spreader Bar Mounting Hardware
Before 10/27/04 (12-13" Seat Depths)
Form No.
03-033
34
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes and Spreader Bar Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1037610 Screw, Hex Head (1/4-20 x 1-5/8") 1 41 A
1026900 Washer (1/4 x 23/32 x 1/16") 1 82
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 83
1025736 Locknut (1/4-20) 1 84
1121895 Bracket, Back Cane Mounting - Right
(12"-13" Deep)
1 15
1121896 Bracket, Back Cane Mounting - Left
(12"-13" Deep)
1 15
1059388 Insert, Non-Threaded Back Cane
(For Back Heights 20" and Lower)
1 26 A
1070433 Insert, Non-Threaded Back Cane
(For Back Heights 21" and Higher)
1 26
1031026 Screw w/ Lug (5/16-24 x 1-3/8") 1 27 B
1025730 Locknut (5/16-24) 1 28 B
1122276 Kit, Back Mounting Hardware
(12-13" Seat Depths with 12-19" Back Heights)
2 19 C
1122277 Kit, Back Mounting Hardware
(12-13" Seat Depths with a 20" Back Height)
2 19 D
1122278 Kit, Back Mounting Hardware
(12-13" Seat Depths with 21-22" Back Heights)
2 19 D
1006525 Cable Tie (3-7/8" L) 1 210
1045270 Bracket Protector Assembly 2 111 F
1045271 Instruction Sheet, Bracket Protector 1 1E
A - Prior to 7/9/04 new back mounting hardware must be ordered for 12-13" deep seats that use CJ brackets. The threaded
insert was replaced with a non-threaded insert for back heights 20" and lower.
B - Item 7 and 8 used for back heights 20"-22" only
C - Includes items 1-6
D - Includes items 1-8
E - Not Shown
F - Includes (2) Cable Ties, (2) Bracket Protectors, and (1) Instruction Sheet.
NOTE:
Before 10/27/04 (12-13" Seat Depths)
35
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes and Spreader Bar Mounting Hardware
Before 10/27/04 (14-15" Seat Depths)
Form No.
03-033
36
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes and Spreader Bar Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1037610 Screw, Hex Head (1/4-20 x 1-5/8") 1 41 A
1026900 Washer (1/4 x 23/32 x 1/16") 1 82
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 83
1025736 Locknut (1/4-20) 1 84
1121897 Bracket, Back Cane Mounting -Right
(14"-15" Deep)
1 15
1121898 Bracket, Back Cane Mounting -Left
(14"-15" Deep)
1 15
1059388 Insert, Non-Threaded Back Cane
(For Back Heights 20" and Lower)
1 26 A
1070433 Insert, Non-Threaded Back Cane
(For Back Heights 21" and Higher)
1 26
1031026 Screw w/ Lug (5/16-24 x 1-3/8") 1 27 B
1025730 Locknut (5/16-24) 1 28 B
1122279 Kit, Back Mounting Hardware
(14-15" Seat Depths with 12-19" Back Heights)
2 19 C
1122280 Kit, Back Mounting Hardware
(14-15" Seat Depths with a 20" Back Height)
2 19 D
1122281 Kit, Back Mounting Hardware
(14-15" Seat Depths with 21-22" Back Heights)
2 19 D
1006525 Cable Tie (3-7/8" L) 1 210
1045270 Bracket Protector Assembly 2 111
1045271 Instruction Sheet, Bracket Protector 1 1E
A - Prior to 7/9/04 new back mounting hardware must be ordered for 14-15" deep seats that use CJ brackets. The threaded
insert was replaced with a non-threaded insert for back heights 20" and lower.
B - Item 7 and 8 used for back heights 20"-22" only
C - Includes items 1-6
D - Includes items 1-8
E - Not Shown
NOTE:
Before 10/27/04 (14-15" Seat Depths)
Form No.
03-033
37
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes and Spreader Bar Mounting Hardware
Before 10/27/04 (16" Seat Depth)
Form No.
03-033
38
To order call toll free 1-800-333-6900, or www.invacare.com
Back Canes and Spreader Bar Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1037610 Screw, Hex Head (1/4-20 x 1-5/8") 1 41
1026900 Washer (1/4 x 23/32 x 1/16") 1 42
1121899 Bracket, Back Cane Mounting - Right
(16" Deep)
1 13
1121900 Bracket, Back Cane Mounting - Left
(16" Deep)
1 13
1059388 Insert, Non-Threaded Back Cane
(For Back Heights 20" and Lower)
1 24 A
1070433 Insert, Non-Threaded Back Cane
(For Back Heights 21" and Higher)
1 24 B
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 45
1025736 Locknut (1/4-20) 1 46
1031026 Screw w/ Lug (5/16-24 x 1-3/8") 1 27 C
1025730 Locknut (5/16-24) 1 28 C
1122282 Kit, Back Mounting Hardware
(16" Seat Depth with 12-19" Back Heights)
2 19 D
1122283 Kit, Back Mounting Hardware
(16" Seat Depth with a 20" Back Height)
2 19 E
1122284 Kit, Back Mounting Hardware
(16" Seat Depth with 21-22" Back Heights)
2 19 E
A - For 12"-20" back heights
B - For 21"-22" back heights
C - Item 7 and 8 used for back heights 20"-22" only
D - Includes items 1-6
E - Includes items 1-8
NOTE:
Before 10/27/04 (16" Seat Depth)
Form No.
03-033
39
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Mounting Hardware
After 10/26/04 (All Depths)
Form No.
03-033
40
To order call toll free 1-800-333-6900, or www.invacare.com
Back Cane Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1126146 Kit, Back Cane Attaching Hardware 1 17 A
Screw, Hex Head Cap with Patch (5/16-18 x 1-3/4") 1 41
Washer, Flat (21/64 x 53/64 x 7/64") 1 42
Insert, Back Cane 1 23
Spacer, Coved (3/4 x 1 x 1/2") 1 44
Washer, Flat (5/16 x 5/8 x 1/16") 1 45
Locknut (5/16-18) 1 46
A - Includes items 1-6
NOTE:
After 10/26/04 (All Depths)
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
41
#1 Back Upholstery - Black Nylon
Back Height 12" Wide 13" Wide 14" Wide 15" Wide 16" Wide
1049941104994010499391045223104522112"-13" High
1045175104994310499421045224104522214"-15" High
8881045175104517410451731045259104525716"-17" High
1045207104520610452051045260104525818"-19" High
106894710689461068945N/AN/A20" High
104515910451581045157N/AN/A21"-22" High
Back Upholstery - Black Nylon
Form No.
03-033
42
To order call toll free 1-800-333-6900, or www.invacare.com
Back Upholstery - Black Nylon
Back Upholstery Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See Chart #1 Back Upholstery - Black Nylon 1 11
1029850 Back Upholstery Hardware 2 12 A
A - Includes - Screws with Washers (#10 x 7/8") (2 ea.) and Cable Ties (2 ea.)
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
43
Headrest and Attaching Hardware
Form No.
03-033
44
To order call toll free 1-800-333-6900, or www.invacare.com
Headrest and Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
0127700 Headrest, Curved (6"W x 7"H) 1 11
0022600 Headrest, Small Adjustable, Otto Bock
(9"W x 3-1/2"H)
1 11
0022400 Headrest, Large Adjustable, Otto Bock (12"W x 6"H) 1 11
0128000 Headrest, Two-Step (8-1/2"W x 5-1/2"H) 1 11
1128754 Headrest Bracket Assembly (Offset) 1 12
1127973 Kit, Headrest Clamp Hardware 1 13 A
1028410 Screw, Socket Button Head (1/4-20 x 7/8") 1 24
1026907 Washer (1/4 x 1/2 x 1/16") 1 45
0237422-NLA Clamp, Small Bottom Half 1 16 B
0237522-NLA Clamp, Small Top Half 1 17 B
1072439 Knob, Adjustment (1-3/8" Dia., 3/4" Long Threads) 1 18
1025736 Locknut (1/4-20) 1 29
1128725 Pin, Quick Release with Lanyard 1 110
0273100 Kit, Headrest Clamp 1 111 C
0288706 Screw, Socket Head (1/4-20 x 1") 1 212
A - Includes items 4-10
B - Clamp is no longer available individually. See item 11, Clamp Assembly - Part # 0273100 for replacement.
C - Includes items 6-9 and 12.
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
45
Arms, Adjustable Height
Form No.
03-033
46
To order call toll free 1-800-333-6900, or www.invacare.com
Arms, Adjustable Height
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
8881015932 Arm Pad, Vinyl, Full Length (14" L x 2" W) - Right 1 11 A
8881015933 Arm Pad, Vinyl, Full Length (14" L x 2" W) - Left 1 11 A
8881053577 Arm Pads, Vinyl, Full Length with Screws (14" L x 2"
W)
2 11 A
8881011811 Arm Pad, Vinyl, Desk Length (9" L x 2" W) 1 11 A
8881053578 Arm Pads, Vinyl, Desk Length with Screws (9" L x
2" W)
2 11 A
1071263 Upper Arm Assembly, Adjustable Height with Plug
Buttons - Full Length
1 12
1071259 Upper Arm Assembly, Adjustable Height with Plug
Buttons - Desk Length
1 12
1027095 Plug Button, Black (7/8") 1 23
1055949 Screws, Phillips Pan Head (#10-32 x 1-1/8") 2 14
47471X074 Spring, Arm Lock 1 15
1028594 Pin, Arm Lock 1 16
1090768 Kit, Lock Handle w/Rivets (both LT & RT side) 2 17
1065936 Plug, Pivot 1 28
1067734 Plug Button, Black (5/8") 1 29
1016298 Grip, Push Handle 1 110
1068585 Arm Base Assembly, Adjustable Height - Right
(Black)
1 111
1068586 Arm Base Assembly, Adjustable Height - Left
(Black)
1 111
1025195 Locknut (1/4-20) 1 112
1068025 Clevis, Pivot 1 113
1019590 Screw, Socket Button Head (1/4-20 x 1-5/8") 1 114
1068039 Pin, Pull 1 115
1068488 Kit, Swingaway Armrest Mounting Hardware 1 116
A - Specify upholstery color U67 Black when ordering.
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
47
Shrouds and Mounting Hardware
Form No.
03-033
48
To order call toll free 1-800-333-6900, or www.invacare.com
Shrouds and Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See Chart #1 Side Shrouds with Decals 1 11
1104797 Decal, Shroud Drive/Push 1 22
1121907 Decal, Shroud (Pronto M71 Jr.) 1 23
1120033-NLA Decal, Warning 1 14
1025451 Screw, Slotted Hex Washer Head (#10-32 x 5/8") 1 85
1070587 Washer, Flat (3/16 x 5/8 x 1/16") 1 126
1028755 Screw, Phillips Pan Head (#10-32 x 5/8") 1 47
1122958 Plate, Shroud - Right 1 18
1122959 Plate, Shroud - Left 1 18
1122269 Kit, Side Shroud Hardware 2 19 A
1109035 Clamp, Shroud 1 110
1025713 Screw, Hex Head (1/4-20 x 1") 1 111
1109036 Bracket, Clamp Shroud - Right 1 112
1109037 Bracket, Clamp Shroud - Left 1 112
1026907 Washer (1/4 x 1/2 x 1/16") 1 113
1025713 Screw, Hex Head (1/4-20 x 1") 1 114
1108464 Kit, Shroud Clamp Hardware - Right 1 115 B
1108465 Kit, Shroud Clamp Hardware - Left 1 115 B
1123240 Shroud, Battery Rear with Decal (Black) 1 116
1095489 Decal, Invacare 3-D Logo (2-1/2" L) 1 217
1028755 Screw, Phillips Pan Head (#10-32 x 5/8") 1 418
1070587 Washer, Flat (3/16 x 5/8 x 1/16") 1 419
1123238 Shroud, Battery Front with Decals (Black) 1 120
1118381 Label, Warning Battery Terminal 1 121
A - Includes items 5-8
B - Includes items 10-14
NOTE:
#1 Side Shrouds with Decals
Side Magic Black Deep Blue Pearl Candy Red Pearl
112227011222741122272Right
112227111222751122273Left
Form No.
03-033
49
To order call toll free 1-800-333-6900, or www.invacare.com
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1105026 Cap, Headtube 1 11
1028550 Locknut (5/8-18) 1 12
1041444 Washer (5/8 x 1-5/16 x 1/8") 1 13
40117X006 Bearing (5/8") 1 24
1109014 Headtube, Caster - Right 1 15
1109015 Headtube, Caster - Left 1 15
1106355 Fork and Stem 1 16
1105024 Cap, Front Headtube - Right 1 17
1105025 Cap, Front Headtube - Left 1 17
1109222 Screw, Socket Button Head Cap (3/8-24 x 3/4") 1 48
1106511 Bushing (3/8 x 1/2 x 2-1/8") 1 29
1025734 Locknut (7/16-20) 1 110
1025724 Washer (15/32 x 5/8 x 3/64") 1 211
1115179 Wheel with Bearings, 6 x 2" Urethane Deep Profile 1 112
1122066 Wheels with Bearings, 6 x 2" Urethane Deep Profile 2 112
1025726 Screw, Hex Head (7/16-20 x 3-1/4") 1 113
1042489 Caster Axle Hardware (1 Pair) 2 114 B
1109016 Caster Headtube with Hardware - Right 1 115 A
1109017 Caster Headtube with Hardware - Left 1 115 A
A - Includes items 5, 7-9
B - Includes items 10, 11, and 13
NOTE:
Casters, Forks, and Hardware
Form No.
03-033
50
To order call toll free 1-800-333-6900, or www.invacare.com
Motor, Gearbox, and Drive Wheel
Form No.
03-033
51
To order call toll free 1-800-333-6900, or www.invacare.com
Motor, Gearbox, and Drive Wheel
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1116395 Motor with Gearbox and Cable Extension - Right 1 11 A
1116396 Motor with Gearbox and Cable Extension - Left 1 11 A
1123954 Motor, High Speed w/ Gearbox and Cable
Extension - Right
1 11 E
1123955 Motor, High Speed w/ Gearbox and Cable
Extension - Left
1 11 E
1038361 Kit, Motor/Brake Covers with Screws 2 12
1123528 Kit, Motor Brush - Internal (Large) 2 13
1108562 Kit, Motor Mounting Hardware 1 16 B
Screw, Socket Head Cap with Patch (M6 x 35MM) 1 34
Screw, Socket Head Cap with Patch (M6 x 20MM) 1 35
1112249 Pin, Clevis 1 17
1026034 Washer, Nylon (3/16 x 7/16 x 1/8") 1 18
1115715 Pin, Bridge 1 19
1112251 Lever, Motor Release 1 110
1040060 Tip, Black Plastic 1 111
1121978 Kit, Motor Lever and Mounting Hardware 1 112 C
1071562 Bushing, Snap 1 113
1102338 Kit, Drive Wheel with Mounting Hardware -
Pneumatic (10 x 3")
1 121 D
Key (6 MM x 6MM x 40 MM) 1 114
Washer (11/32 x 13/16 x 1/8") 1 115
Screw (M8 x 1-1/4 x 20MM) 1 116
Kit, Locking Tab Washers with Instruction Sheet 2 117
Tire, Pneumatic (10" x 3") 1 118
Tube, Inner (10" x 3") 1 119
Wheel, Drive with Bearings - Pneumatic (10" x 3") 1 120
1109005 Tire, Pneumatic (10" x 3") 1 118
1109028 Tube, Inner (10" x 3") 1 119
1102339 Kit, Drive Wheel with Mounting Hardware - Flat Free
(10 x 3")
1 121 D
Key (6 MM x 6MM x 40 MM) 1 114
Washer (11/32 x 13/16 x 1/8") 1 115
Screw (M8 x 1-1/4 x 20MM) 1 116
Kit, Locking Tab Washers with Instruction Sheet 1 117
Tire w/ Flat-Free (10" x 3") 1 118
Wheel, Drive with Tire and Bearings - Flat Free (10"
x 3")
1 120
1102342 Tire w/ Flat-Free (10" x 3") 1 118
1143143 Harness, Motor Cable Extension 1 122 F
Form No.
03-033
52
To order call toll free 1-800-333-6900, or www.invacare.com
Motor, Gearbox, and Drive Wheel
A - Chairs built Before 5/17/04. Includes item 22.
B - Includes items 4 and 5.
C - Includes items 7-11.
D - Includes items 14-17, 20.
E - Chairs built After 5/16/04. Includes item 22.
F - As of 5/15/06, harness part no. 1143143 replaced part nos. 1116389 & 1116390. The new harness is not Right/Left
dependent and can be used for either side.
NOTE:
Form No.
03-033
53
To order call toll free 1-800-333-6900, or www.invacare.com
Battery Tray and Battery Harness Assemblies
Form No.
03-033
54
To order call toll free 1-800-333-6900, or www.invacare.com
Battery Tray and Battery Harness Assemblies
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1108462 Handle, Battery Tray (Black Nylon Rod) 1 11 A,C
1126108 Handle, Battery Tray (Black Webbing) 1 11 B,C
1025354 Screw, Socket Button Head (#10-32 x 3/8") 1 22 A
1109200 Label Marker (2) 1 23
1109199 Label Marker (1) 1 24
1109201 Label Marker (3) 1 25
1035900 Decal, Transportation 1 16
1076284 Screw w/ washer (#10 x 7/8") 1 27
1080872 Strap with Buckle 1 18
1108239 Pin, Slotted (1/4 x 1-1/8") 1 29
1109221 Pin, Roll (3/16 x 1-1/8") 1 110
1108063 Handle, Release 1 111
1106482 Spring, Latch Release 1 212
1106353 Latch 1 213
1123140 Battery Tray Assembly with Labels 1 114 D
1127157 Battery Tray Assembly 1 114 F
16721X000 Locknut (1/4-20) 1 415
1102337 Screw, Hex Flange Whiz Lock(1/4-20 x 5/8") 1 216
1122212 Harness, Battery - Front 1 117 E
1122211 Harness, Battery - Rear 1 118 E
1122199 Cable, Battery Extension (100 Amp.) (Red
Connector)
1 119 G
A - Chairs built Before 10/27/04.
B - Chairs built After 10/26/04.
C - Effective 10/27/04, Battery Tray Handle has changed from a black nylon rod to a black webbing strap. Strap not used on
tilting chairs.
D - Non Tilt chairs only. Includes items 1, 3-13. Effective 10/27/04, Battery Tray Assembly now has black webbing for a
handle. Use this assembly regardless when chair was built.
E - Individual components are not available for the battery harnesses
F - Tilt chairs only. Battery Tray for tilt chairs does not require strap or labels. Includes Tray plus items 6, 8-13.
G - Both MK5 & MK6i use this Battery Extension Cable.
NOTE:
Form No.
03-033
55
To order call toll free 1-800-333-6900, or www.invacare.com
90FB Footboard Assembly
Form No.
03-033
56
To order call toll free 1-800-333-6900, or www.invacare.com
90FB Footboard Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1105027 Footboard Assembly 1 112 B,A
Cap, Tube (1" Square) 1 11
Washer, Nylon (3/8 x 3/4 x 1/16") 1 22
Washer, Flat (3/8 x 11/16 x 1/16") 1 13
Screw, Socket Head (3/8-16 x 2-1/2") 1 14
Footboard with Cover 1 15
Bushing (3/8 x 5/8 x 1/2") 1 16
Locknut, Low Profile (3/8-16) 1 17
Screw, Socket Set Flat (5/16-18 x 1") 1 18
Locknut (5/16-18) 1 19
Bracket, Footboard Support (Black) 1 110
Pin, Quick Release 1 111
1300010 Bag, Zip Lip (4" x 4") 1 113
1114833 Instruction Sheet, 2" Footboard Extension 1 114
40131X044 Carton, Shipper 1 115
1115378 Kit, 2" Footboard Extension 1 116 C
Cap, Tube (1" Square) 1 11
Washer, Nylon (3/8 x 3/4 x 1/16") 1 22
Washer, Flat (3/8 x 11/16 x 1/16") 1 13
Screw, Socket Head (3/8-16 x 2-1/2") 1 14
Bushing (3/8 x 5/8 x 1/2") 1 16
Locknut, Low Profile (3/8-16) 1 17
Bracket, Footboard Support 2" Extension 1 110
Bag, Zip Lip (4" x 4") 1 113
Instruction Sheet, 2" Footboard Extension 1 114
Carton, Shipper 1 115
A - Includes items 1-11
B - When ordering a footboard assembly for the first time that requires a 2" extension kit, items 5, 8, 9, 11 and 16 must be
ordered
C - Includes items 1-4, 6, 7, 10 and 13-15
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
57
Support Assemblies For PHW93, PH93M2 and PHAL4A
Front
Rigging
Black
Right
Black
Left
Chrome
Right
Chrome
Left
N/AN/A11147561114755PHW93
N/AN/A11229651122964PH93M2
10314381031437N/AN/APHAL4A
Pivot/ Slide Tubes with Footplates For PHW93
Chair
Width
Aluminum
(1650)
Adjustable Angle
(AT5543)
10604421123070
12"-13" Wide
Right
10604431123071
12"-13" Wide
Left
10604441123072
14"-15" Wide
Right
10604451123073
14"-15" Wide
Left
10627561074149
16" Wide
Right
10627571074150
16" Wide
Left
NOTE: Pivot/ Slide Tube Mounting Hardware is Not Included. See PHW93 Support Assembly page.
Front Rigging Reference Chart
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
58
Front Rigging Reference Chart
Pivot/ Slide Tubes with Footplates For PH93M2
Chair
Width
Aluminum
(1650)
Adjustable Angle
(AT5543)
10604301123074
12"-13" Wide
Right
10604311123075
12"-13" Wide
Left
10604321123076
14"-15" Wide
Right
10604331123077
14"-15" Wide
Left
10625721057969
16" Wide
Right
10625731057970
16" Wide
Left
Pivot/ Slide Tubes with Footplates For PHAL4A
Chair
Width
Aluminum
(1650)
Adjustable Angle
(AT5543)
10917751023905
14"-15" Wide
Right
10917761023906
14"-15" Wide
Left
10917771023907
16" Wide
Right
10917781023908
16" Wide
Left
Form No.
03-033
59
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging Hangers and Hardware
Form No.
03-033
60
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging Hangers and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1114766 Front Rigging Hanger Pin Style with Plug Button
(Hemi) (12-21" Deep) - Right
1 11 A
1114767 Front Rigging Hanger Pin Style with Plug Button
(Hemi) (12-21" Deep) - Left
1 11 A
1126150 Kit, Side Rail Cap Hardware 2 19 B
Screw, Socket Head Cap w/ Patch (1/4-20 x 1-1/2") 1 23
Spacer (1/4 x 3/8 x 29/32") 1 24
Cap, Side Rail End 1 25
Washer (1/4 x 1/2 x 1/16") 1 26
Locknut (1/4-20) 1 27
Plug Button, Black (7/8") 1 28
1126149 Kit, Front Rigging Hangers with Hardware 2 112 C
Plug Button, Black (3/4") 1 22
Screw, Socket Head Cap w/ Patch (1/4-20 x 1-1/2") 1 43
Cap, Side Rail End 1 25
Washer (1/4 x 1/2 x 1/16") 1 46
Locknut (1/4-20) 1 47
Spacer (1/4 x 3/8 x 3/16") 1 410
Front Rigging Hanger
Pin Style with Plug Button (Hemi) - Right
1 111
Front Rigging Hanger
Pin Style with Plug Button (Hemi) - Left
1 111
1134426 Package, Plug Buttons, Black (3/4") 10 12
1130582 Package, Plug Buttons, Black (7/8") 10 18
A - Includes item 2 Plug Button
B - Includes items 3-8
C - Includes items 2, 3, 5-7, 10 and 11
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
61
PHW93 (Hemi) Footrest Supports
Form No.
03-033
62
To order call toll free 1-800-333-6900, or www.invacare.com
PHW93 (Hemi) Footrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1020719 Anti-Rattle, Black 1 11
1025716 Screw, Phillips Pan Head (#10-32 x 11/16") 1 12
47565X057 Bushing (7/32 x 3/8 x 11/32") 1 13
1025735 Locknut (#10-32) 1 14
1026114 Screw, Phillips Pan Head (#10-32 x 1/2") 1 15
1114749 Release Handle (Black) - Right 1 16 A
1114750 Release Handle (Black) - Left 1 16 A
1028846 Rivnut (#10-32) 1 17
1028707 Spring, Release - Right 1 18
1028708 Spring, Release - Left 1 18
1006490 Tip, Plastic, Black 1 19
15680X012 Collar, Anti-Rattle (7/8") 1 110
1070759 Screw, Hex Head (1/4-20 x 1-1/2") 1 111
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 212
1044214 Nut, Hex with Nylon Cap (1/4-20) 1 113
1020534 Insert, Threaded 1 114
1074143 Kit, Slide Tube Mounting Hardware 1 115 C
1114755 Footrest Support Assembly, Hemi, Black - Right 1 116 B
1114756 Footrest Support Assembly, Hemi, Black - Left 1 116 B
A - Includes items 2-4
B - Includes items 1-10
C - Includes items 11-14
NOTE:
Form No.
03-033
63
To order call toll free 1-800-333-6900, or www.invacare.com
PH93M2 (Hemi) Footrest Supports
Black
Form No.
03-033
64
To order call toll free 1-800-333-6900, or www.invacare.com
PH93M2 (Hemi) Footrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1030979 Screw, Phillips Pan Head Tap (#10-32 x 3/4") 1 11
1022874 Bumper 1 12
1006490 Tip, Plastic, Black 1 13
60279X003 Locknut (#10-32) 1 14
47565X057 Bushing (7/32 x 3/8 x 11/32") 1 15
40163X008 Screw, Phillips Pan Head (#10-32 x 11/16") 1 16
40163X002 Screw, Phillips Round Head (#10-32 x 1/2") 1 17
1008935 Spring, Release - Right 1 18
1008936 Spring, Release - Left 1 18
67005X000 Rivnut (#10-32) 1 19
1114745 Handle, Release - Right 1 110
1114746 Handle, Release - Left 1 110
1027095 Plug Button, Black (7/8") 1 211
60264X001 Locknut (5/16-24) 1 112
11232X009 Screw, Lug (5/16-24 x 1-3/8") 1 113
1122964 Footrest Support Assembly, Hemi, Black - Right 1 114 A
1122965 Footrest Support Assembly, Hemi, Black - Left 1 114 A
A - Includes items 1-13
NOTE:
Black
Form No.
03-033
65
To order call toll free 1-800-333-6900, or www.invacare.com
PHAL4A (Hemi) Articulating Legrest Supports
Chrome
Form No.
03-033
66
To order call toll free 1-800-333-6900, or www.invacare.com
PHAL4A (Hemi) Articulating Legrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1030979 Screw, Phillips Pan Head Tap (#10-32 x 3/4") 1 11
1022874 Bumper 1 12
1023428 Handle, Release, Chrome - Right 1 13 F
1023431 Handle, Release, Chrome - Left 1 13 F
47565X057 Bushing (7/32 x 3/8 x 11/32") 1 14
60279X003 Locknut (#10-32) 1 15
40163X008 Screw, Phillips Pan Head (#10-32 x 11/16") 1 16
1008935 Spring, Release - Right 1 17
1008936 Spring, Release - Left 1 17
67005X000 Rivnut (#10-32) 1 18
40163X002 Screw, Phillips Round Head (#10-32 x 1/2") 1 19
1023092 Legrest Support with Handle and Bumper (Chrome)
- Right
1 110 E,E1
1023093 Legrest Support with Handle and Bumper (Chrome)
- Left
1 110 E,E1
1027097 Plug Button, Black (3/4") 1 111
1006490 Tip, Plastic, Black 1 112
1040060 Tip, Black Plastic 1 113
1037126 Handle, Release 1 114
1049527 Washer, Nylon (3/8 x 3/4 x 1/16") 1 215
1022866 Screw, Socket Button Head (3/8-16 x 3/4") 1 216
40363X000 Hex Nut (3/8"-16) 1 317
1022846 Bar, Link, Chrome 1 118
1022877 Tube Support and Drive Link - Right 1 119
1022878 Tube Support and Drive Link - Left 1 119
1022854 Screw, Slotted Head Shoulder (1/2 x 1-1/8") 1 120
10261X000 Acorn Nut (5/16"-24) 1 121
04528X002 Bracket, Release (Chrome) 1 122
1040831 Snap Ring 1 123
47328X003 Bushing, Pivot (5/16 x 7/16 x 7/8") 1 124
42326X004 Bar, Ratchet - Right/Left 1 125
1037485 Spring, Release 1 126
1037125 Cam, Legrest 1 127
1013519 Washer, Nylon (5/16 x 11/16 x 1/16") 1 128
1024911 Decal, Smartleg 1 129
1014807 Screw, Hex Head (5/16-24 x 3-1/4") 1 130
48823X008 Spring, Leaf 1 131
47328X003 Bushing, Pivot (5/16 x 7/16 x 7/8") 1 132
1025133 Spacer, Legrest Pad 1 133
04526X019 Plate, Legrest Pad 1 134
60264X001 Locknut (5/16-24) 1 135
1025104 Bracket, Legrest (Chrome) 1 136
11232X009 Screw, Lug (5/16-24 x 1-3/8") 1 137
1022848 Slide Tube, Articulating (Chrome) - Right 1 138
Chrome
Form No.
03-033
67
To order call toll free 1-800-333-6900, or www.invacare.com
PHAL4A (Hemi) Articulating Legrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1022849 Slide Tube, Articulating (Chrome) - Left 1 138
1027377 Washer (#20) 1 139
1107321 Nut, Low Cap (5/16"-24) 1 140
1031437 Legrest Support Assembly, Articulating, Hemi,
Chrome - Right
1 141 B,E,E1
1031438 Legrest Support Assembly, Articulating, Hemi,
Chrome - Left
1 141 B,E,E1
88804529X003 Pad, Legrest Vinyl - Right 1 142 A,C
88804529X004 Pad, Legrest Vinyl - Left 1 142 A,C
8881091764 Pad, Legrest Vinyl - Right/Left 1 142 A,D
1068649 Screws, Phillips Head (#10-32 x 11/16") 2 143
A - Specify upholstery color U67 black when ordering.
B - Includes items 1-40
C - For 14"-15" wide seats
D - For 16" wide seats
E - Release Handle revised 10/25/06. When a complete Legrest Assembly item #41 or a Legrest Support Tube Assembly item
#10 is ordered for chairs manufactured before 10/25/06, order the opposite side "Release Handle" item #3 to match.
E1 - Both Release Handles pictured to identify the difference. Release Handle after 10/24/06 does not require a rubber tip
F - Release Handle revised 10/25/06. For chairs manufactured before 10/25/06, order in pairs to match.
NOTE:
Chrome
68
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
Pivot/Slide Tube and 1650 Standard Aluminum Footplate
For the Following Front Riggings:
PHW93, PH93M2, PHAL4A
NOTE: Heel Loops are not included. See Footrest and Legrest Accessories page.
NOTE: For complete pivot/ slide tube and footplate assemblies, see Front Rigging Reference Chart page.
Form No.
03-033
69
To order call toll free 1-800-333-6900, or www.invacare.com
Pivot/Slide Tube and 1650 Standard Aluminum Footplate
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1048834 Pivot/Slide Tube with Plug Button 1 11 A
1041527 Pivot/Slide Tube with Plug Button (Black) 1 11 B
1041526 Pivot/Slide Tube with Plug Button (Steel) 1 11 C
1027097 Plug Button, Black (3/4") 1 22 D
1070168 Push Plug, Footplate 1 13
44200X032 Footplate, Aluminum - Extra Small (5-3/4" W x 6" L) 1 14 E
44200X059 Footplate, Aluminum - Small (6-3/4" W x 6" L) 1 14 F
44200X027 Footplate, Aluminum - Medium (7-3/4" W x 6" L) 1 14 G
1016346 Cap, Tube End (7/8") 1 15
1006981 Spring, Leaf 1 16
40120X001 Screw, Phillips Pan Head (#8-32 x 3/8") 1 27
1018133 Plug Button, Black (5/8") 1 18
A - For PHW93 Footrest
B - For PH93M2 Footrest
C - For PHAL4A Legrest
D - PH93M2 Pivot/Slide tube uses a quantity of 2 plug buttons
E - For 12"-13" wide seats
F - For 14"-15" wide seats
G - For 16" wide seats
NOTE:
For the Following Front Riggings:
PHW93, PH93M2, PHAL4A
NOTE: Heel Loops are not included. See Footrest and Legrest Accessories page.
NOTE: For complete pivot/ slide tube and footplate assemblies, see Front Rigging Reference Chart page.
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
70
Pivot/Slide Tube and Adjustable Angle Footplates AT5543
For the Following Front Riggings:
PHW93, PH93M2, PHAL4A
NOTE: Heel loops are not included. See Footrest and Legrest Accessories page.
Form No.
03-033
71
To order call toll free 1-800-333-6900, or www.invacare.com
Pivot/Slide Tube and Adjustable Angle Footplates AT5543
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1060426 Footplate, Adjustable Angle - Medium
(4-1/4" W x 8" L)
1 11
1060427 Footplate, Adjustable Angle - Large
(5-1/4" W x 8" L)
1 11
1062569 Footplate, Adjustable Angle - X-Large
(6-1/4" W x 8" L)
1 11
1029545 Screw, Socket Head Cap (1/4-20 x 3/4") 1 22
1058517 Clamp, Footplate 1 13
1082686 Nut, Hex Head (1/4-20 x 11/16") 1 24
7930333 Locknut (1/4-20) 25 15
1026907 Washer (1/4 x 1/2 x 1/16") 1 16
1048816 Screw, Nylon Adjustment (1/2-13 x 7/8") 1 17
1052102 Hinge, Footplate - Right 1 18
1052103 Hinge, Footplate - Left 1 18
7930321 Screw, Socket Button Head (1/4-20 x 1-7/8") 25 19
1026900 Washer (1/4 x 23/32 x 1/16") 1 110
1057855 Pivot/Slide Tube, Straight (9-7/8" Long - Steel) 1 111 A
1120384-NLA Pivot Slide Tube, Straight - Alum. (9-7/8" Long) 1 111 B
1091745 Pivot/Slide Tube, Straight (13-7/8" Long - Steel) 1 111 C
7930313 Washer, Nylon (5/16 x 7/8 x 1/8") 25 112
1025457 Spacer, Coved (1/4 x 3/4 x 11/32") 1 113
See Chart Item #14 Pivot/ Slide Tube with Adjustable Angle
Footplate Assemblies
1 114
A - For PHW93 footrest
B - For PH93M2 footrest
C - For PHAL4A legrest
NOTE:
Item #14 Pivot/ Slide Tube with Adjustable Angle Footplate Assemblies
Rigging
Type
Side
12-13" Wide
4-1/4" Medium
Footplate
14-15" Wide
5-1/4" Large
Footplate
16" Wide
6-1/4" X- Large
Footplate
106275610604441060442RightPHW93
106275710604451060443Left
106257210604321060430RightPH93M2
106257310604331060431Left
10917771091775N/ARightPHAL4A
10917781091776N/ALeft
For the Following Front Riggings:
PHW93, PH93M2, PHAL4A
NOTE: Heel loops are not included. See Footrest and Legrest Accessories page.
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
72
Pivot/Slide Tube and Adjustable Angle Footplates AT5543
For the Following Front Riggings:
PHW93, PH93M2, PHAL4A
NOTE: Heel loops are not included. See Footrest and Legrest Accessories page.
Form No.
03-033
73
To order call toll free 1-800-333-6900, or www.invacare.com
Footrest and Legrest Accessories
Form No.
03-033
74
To order call toll free 1-800-333-6900, or www.invacare.com
Footrest and Legrest Accessories
Heel Loops and Hardware For 1650 Standard Aluminum Footplates
Chair
Width
Heel Loop
Single #
Heel Loop
Pair #
Attaching
Hardware
Pair #
10359071035912102841212"-13" W
10359071035905102523414"-15" W
10359071035917101762116" W
Heel Loops w/ Ankle Straps and Hardware For 1650 Standard Aluminum Footplates
Chair
Width
Heel Loop w/
Ankle Strap
Single # Rt.
Heel Loop w/
Ankle Strap
Single # Lt.
Heel Loop w/
Ankle Strap
Pair #
Attaching
Hardware
Pair #
1035907103590610359091035908
12"-14" W
See Note(s) A
1035907103591810359201035919
15"-16" W
See Note(s) A
1035907103590610359091035908
14"-15" W
See Note(s) B
1035907103591810359201035919
16" W
See Note(s) B
A - For PHW93 and PH93M2 footrest only
B - For PHAL4A articulating legrest only
NOTE:
Attaching Hardware Part Number For 1650 Standard Aluminum Footplates
Part
Number
Part
Number
Consists of
2 each Screw, PPH
(1/4-20 x 2-1/4")
2 each Spacer
(1/4 x 11/32 x 1-3/4")
2 each Locknut (1/4-20)
1035907
Form No.
03-033
75
To order call toll free 1-800-333-6900, or www.invacare.com
Footrest and Legrest Accessories
Heel Loops and Heel Loops w/ Ankle Straps For AT5543 Adj. Angle Footplates
Part
Number
Part
Number
Consists of
2 each Heel Loops
4 each Screw, SHC
(10-32 x 1-1/2")
4 each Spacer
(1/4 x 5/16 x 1-3/32")
4 each Washer
(3/16 x 7/16 x 1/16")
1038245
Heel Loops w/ Hardware
Adjustable Angle Footplate (Pair)
2 each Heel Loops
w/ Ankle Straps
4 each Screw, SHC
(10-32 x 1-1/2")
4 each Spacer
(1/4 x 5/16 x 1-3/32")
4 each Washer
(3/16 x 7/16 x 1/16")
1038246
Heel Loops w/ Ankle Straps & Hardware
Adjustable Angle Footplate (Pair)
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
76
Footrest and Legrest Accessories
Form No.
03-033
77
To order call toll free 1-800-333-6900, or www.invacare.com
Footrest and Legrest Accessories
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1032243 Calf Strap w/ Hook and Loop (36" Long) 1 1A
1026987 Impact Guard, 8" Long 1 2A
See Chart Attaching Hardware Part Number For 1650
Standard Aluminum Footplates
1 1A
See Chart Heel Loops and Hardware For 1650 Standard
Aluminum Footplates
1 1A
See Chart Heel Loops and Heel Loops w/ Ankle Straps For
AT5543 Adj. Angle Footplates
1 1A
See Chart Heel Loops w/ Ankle Straps and Hardware For 1650
Standard Aluminum Footplates
1 1A
A - Not Shown
NOTE:
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
78
Front Rigging - Center Mount Rigging CTMTJ
(CTMTJ = 9-1/4" - 12" Range)
Form No.
03-033
79
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging CTMTJ
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1121990 Center Mount Rigging Assembly, Junior
(CTMTJ/CTMT-FJ) ASBA/ADJASBA (9-1/4 - 12"
Range)
1 11 A
1123021 Legrest Support Assembly, Center Mount, Junior,
Black
1 12 B
1113376 Ring, Retainer (1/4 x 1/2 x 1/64") 1 23
1113373 Pin, Angle Adjustable A.S.B.A. 1 14
1110669 Bearing, Flanged (1/2 x 13/16 x 1/2") 1 25
1121984 Support, Junior Legrest (CTMTJ/CTMT-FJ) 1 16
1113372 Rack, Center Mount Rigging Angle Adjustable 1 17
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 48
1123042 Extension Tube and Footplate Assembly
w/ Heel Loop, Junior - Right
1 19 C
1123043 Extension Tube and Footplate Assembly
w/ Heel Loop, Junior - Left
1 19 C
1123044 Extension Tube, Footrest Short
(CTMTJ/CTMT-FJ = 9-1/4" - 12" Range)
(CTMT/CTMT-F = 12-1/4" - 15" Range) (PCTMT =
10" - 13" Range)
1 110
1021421 Screw, Phillips Pan Head (1/4-20 x 2-1/4") 1 211
1006477 Spacer (1/4 x 11/32 x 1-3/4") 1 212
1121996 Heel Loop, Center Mount Rigging 1 213
1078214 Screw, Hex Head Cap w/ Patch (1/4-20 x 1/2") 1 214
1025195 Locknut (1/4-20) 1 215
1121988 Footplate CTMTJ/CTMT-FJ (5-1/4" W x 8-13/16" L)
- Right
1 116 E
1121989 Footplate CTMTJ/CTMT-FJ (5-1/4" W x 8-13/16" L)
- Left
1 116 E
1120345 Center Mount Rigging Footplate Mounting Hardware
- Right
1 117 D
1121123 Center Mount Rigging Footplate Mounting Hardware
- Left
1 117 D
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 218
1113384 Hinge, Adjustable Angle - Right 1 119
1113385 Hinge, Adjustable Angle - Left 1 119
1047449 Spacer (1/4 x 3/8 x 3/16") 1 120
1065362 Locknut (1/4-28) 1 121
1096810 Screw, Socket Head (1/4-28 x 1-3/4") 1 122
1108122 Locknut (5/16-18) 1 223
1113530 Hinge Attachment 1 124
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 125
(CTMTJ = 9-1/4" - 12" Range)
Form No.
03-033
80
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging CTMTJ
A - Includes items 2, 8 & 9
B - Includes items 3-7
C - Includes items 10-16 & 17
D - Includes items 18-25
E - Item #16 - Footplate design revised 2/28/07 to accomodate items 18 & 23. Replace footplates in pairs and order new
footplate hardware for chairs mfg. before 2/28/07.
NOTE:
(CTMTJ = 9-1/4" - 12" Range)
Form No.
03-033
81
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging (CTMT)
(CTMT = 12-1/4" - 15" Range)
Form No.
03-033
82
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging (CTMT)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1117262 Center Mount Rigging Assembly (CTMT) (CTMT-F),
ASBA/ADJASBA (12-1/4 - 15" Range)
1 11 A
1120346 Legrest Support Assembly, Center Mount, Black 1 12 B
1113376 Ring, Retainer (1/4 x 1/2 x 1/64") 1 23
1113373 Pin, Angle Adjustable A.S.B.A. 1 14
1110669 Bearing, Flanged (1/2 x 13/16 x 1/2") 1 25
1113609 Support, Center Mount Rigging Legrest 1 16
1113372 Rack, Center Mount Rigging Angle Adjustable 1 17
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 48
1123034 Extension Tube and Footplate Assembly
with Heel Loop, Short - Right
1 19 C
1123035 Extension Tube and Footplate Assembly
with Heel Loop, Short - Left
1 19 C
1123044 Extension Tube, Footrest Short
(CTMTJ/CTMT-FJ = 9-1/4" - 12" Range)
(CTMT/CTMT-F = 12-1/4" - 15" Range) (PCTMT =
10" - 13" Range)
1 110
1021421 Screw, Phillips Pan Head (1/4-20 x 2-1/4") 1 211
1006477 Spacer (1/4 x 11/32 x 1-3/4") 1 212
1121996 Heel Loop, Center Mount Rigging 1 213
1078214 Screw, Hex Head Cap w/ Patch (1/4-20 x 1/2") 1 214
1025195 Locknut (1/4-20) 1 215
1113606 Footplate, Center Mount Rigging - Right
(5-1/4" W x 9-5/8" L)
1 116 E
1113607 Footplate, Center Mount Rigging - Left
(5-1/4" W x 9-5/8" L)
1 116 E
1120345 Center Mount Rigging Footplate Mounting Hardware
- Right
1 117 D
1121123 Center Mount Rigging Footplate Mounting Hardware
- Left
1 117 D
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 218
1113384 Hinge, Adjustable Angle - Right 1 119
1113385 Hinge, Adjustable Angle - Left 1 119
1047449 Spacer (1/4 x 3/8 x 3/16") 1 120
1065362 Locknut (1/4-28) 1 121
1096810 Screw, Socket Head (1/4-28 x 1-3/4") 1 122
1108122 Locknut (5/16-18) 1 223
1113530 Hinge Attachment 1 124
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 125
A - Includes items 2, 8 & 9
B - Includes items 3-7
C - Includes items 10-16 & 17
D - Includes items 18-25
E - Item #16 - Footplate design revised 2/28/07 to accomodate items 18 & 23. Replace footplates in pairs and order new
footplate hardware for chairs mfg. before 2/28/07.
NOTE:
(CTMT = 12-1/4" - 15" Range)
83
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging CTMTJ
(CTMTJ = 9-1/4" - 12" Range)
Form No.
03-033
84
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging CTMTJ
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1121990 Center Mount Rigging Assembly, Junior
(CTMTJ/CTMT-FJ) ASBA/ADJASBA (9-1/4 - 12"
Range)
1 11 A
1123021 Legrest Support Assembly, Center Mount, Junior,
Black
1 12 B
1113376 Ring, Retainer (1/4 x 1/2 x 1/64") 1 23
1113373 Pin, Angle Adjustable A.S.B.A. 1 14
1110669 Bearing, Flanged (1/2 x 13/16 x 1/2") 1 25
1121984 Support, Junior Legrest (CTMTJ/CTMT-FJ) 1 16
1113372 Rack, Center Mount Rigging Angle Adjustable 1 17
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 48
1123042 Extension Tube and Footplate Assembly
w/ Heel Loop, Junior - Right
1 19 C
1123043 Extension Tube and Footplate Assembly
w/ Heel Loop, Junior - Left
1 19 C
1123044 Extension Tube, Footrest Short
(CTMTJ/CTMT-FJ = 9-1/4" - 12" Range)
(CTMT/CTMT-F = 12-1/4" - 15" Range) (PCTMT =
10" - 13" Range)
1 110
1021421 Screw, Phillips Pan Head (1/4-20 x 2-1/4") 1 211
1006477 Spacer (1/4 x 11/32 x 1-3/4") 1 212
1121996 Heel Loop, Center Mount Rigging 1 213
1078214 Screw, Hex Head Cap w/ Patch (1/4-20 x 1/2") 1 214
1025195 Locknut (1/4-20) 1 215
1121988 Footplate CTMTJ/CTMT-FJ (5-1/4" W x 8-13/16" L)
- Right
1 116 E
1121989 Footplate CTMTJ/CTMT-FJ (5-1/4" W x 8-13/16" L)
- Left
1 116 E
1120345 Center Mount Rigging Footplate Mounting Hardware
- Right
1 117 D
1121123 Center Mount Rigging Footplate Mounting Hardware
- Left
1 117 D
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 218
1113384 Hinge, Adjustable Angle - Right 1 119
1113385 Hinge, Adjustable Angle - Left 1 119
1047449 Spacer (1/4 x 3/8 x 3/16") 1 120
1065362 Locknut (1/4-28) 1 121
1096810 Screw, Socket Head (1/4-28 x 1-3/4") 1 122
1108122 Locknut (5/16-18) 1 223
1113530 Hinge Attachment 1 124
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 125
(CTMTJ = 9-1/4" - 12" Range)
Form No.
03-033
85
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging CTMTJ
A - Includes items 2, 8 & 9
B - Includes items 3-7
C - Includes items 10-16 & 17
D - Includes items 18-25
E - Item #16 - Footplate design revised 2/28/07 to accomodate items 18 & 23. Replace footplates in pairs and order new
footplate hardware for chairs mfg. before 2/28/07.
NOTE:
(CTMTJ = 9-1/4" - 12" Range)
Form No.
03-033
86
To order call toll free 1-800-333-6900, or www.invacare.com
Center Mount Rigging Mounting Hardware
(CTMTJ and CTMT)
Before 10/27/04
NOTE: All Center Mount Riggings before 10/27/04 use the same mounting hardware.
Form No.
03-033
87
To order call toll free 1-800-333-6900, or www.invacare.com
Center Mount Rigging Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1117264 Kit, Center Mount Rigging Mounting Hardware 1 11 A,C
Cable/Brake Assembly 1 12
Nut, Square (#10-32) 1 13
Spacer (5/16 x 3/16 x 3/4") 1 14
Pin, Quick Release (5" Long) 1 15
Screw, Socket Head (#10-32 x 1-1/4") 1 16
Cable Tie (11-1/2" Long) 1 27
Screw, Socket Head Shoulder (5/16 x 1-5/8") 1 18
Screw, Phillips Pan Head (#10-32 x 11/16") 1 29
Washer, Lock (3/16 x 5/16 x 1/16") 1 210
Locknut (1/4-20) 1 111
Housing, Ratchet 1 112
Bearing, Glide 1 213
1121079 Cable/Brake Assembly with Ratchet Housing and
Glide Bearing
1 114 B
A - Includes items 2-13
B - Includes Cable Assembly and items 9,10,12, and 13
C - Ratchet Housing Material changed from aluminum to steel as of 1/8/04
NOTE:
(CTMTJ and CTMT)
Before 10/27/04
NOTE: All Center Mount Riggings before 10/27/04 use the same mounting hardware.
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
88
Center Mount Rigging Mounting Hardware
(CTMTJ and CTMT)
After 10/26/04
NOTE: All Center Mount Riggings after 10/26/04 use the same mounting hardware.
Form No.
03-033
89
To order call toll free 1-800-333-6900, or www.invacare.com
Center Mount Rigging Mounting Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1127160 Kit, Center Mount Rigging Mounting Hardware 1 11 A
1113389 Housing, Ratchet 1 12
1025736 Locknut (1/4-20) 1 13
1113622 Cable/Brake Assembly 1 14
10141X012 Washer, Lock (3/16 x 5/16 x 1/16") 1 25
40163X008 Screw, Phillips Pan Head (#10-32 x 11/16") 1 26
1025731 Locknut (#10-32) 1 17
1071736 Screw, Socket Head Shoulder (5/16 x 1-5/8") 1 18
1095502 Package, Cable Ties (11-1/2" Long) 10 19
1056087 Screw, Socket Head (#10-32 x 1/2") 1 110
1127161 Bracket, Cable Release Mounting 1 111
1026107 Screw, Phillips Pan Head (#10-32 x 1-3/8") 1 112
1113375 Pin, Quick Release (5" Long) 1 113
1086207 Nut, Square (#10-32) 1 114
1113383 Bearing, Glide 1 215
1121079 Cable/Brake Assembly with Ratchet Housing and
Glide Bearing
1 116 B
A - Includes items 2-15
B - Includes Cable Assembly and items 2,5,6, and 15
NOTE:
(CTMTJ and CTMT)
After 10/26/04
NOTE: All Center Mount Riggings after 10/26/04 use the same mounting hardware.
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
90
Front Rigging - Center Mount Rigging Kit
(CTMTJ and CTMT)
Before 10/27/04
Form No.
03-033
91
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging Kit
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1123022 Kit, Adjustable Length Junior Center Mount Rigging
(9-1/4"-12")
1 11 A,B
Cable Tie (11-1/2" Long) 1 22
Screw, Socket Head (#10-32 x 1-1/4") 1 13
Spacer (5/16 x 3/16 x 3/4") 1 14
Nut, Square (#10-32) 1 15
Pin, Quick Release (5" Long) 1 16
Cable/Brake Assembly with Ratchet Housing and
Glide Bearing
1 17
Screw, Socket Head Shoulder (5/16 x 1-5/8") 1 18
Locknut (1/4-20) 1 19
Center Mount Rigging Assembly, Junior
(CTMTJ/CTMT-FJ) ASBA/ADJASBA (9-1/4 - 12"
Range)
1 110
Instruction Sheet, Center Mount Rigging Kit 1 1
1121009 Kit, Adjustable Length Center Mount Rigging
A.S.B.A. Short (12-1/4"-15")
1 11 A,B
Cable Tie (11-1/2" Long) 1 22
Screw, Socket Head (#10-32 x 1-1/4") 1 13
Spacer (5/16 x 3/16 x 3/4") 1 14
Nut, Square (#10-32) 1 15
Pin, Quick Release (5" Long) 1 16
Cable/Brake Assembly with Ratchet Housing and
Glide Bearing
1 17
Screw, Socket Head Shoulder (5/16 x 1-5/8") 1 18
Locknut (1/4-20) 1 19
Center Mount Rigging Assembly (CTMT) (CTMT-F),
ASBA/ADJASBA (12-1/4 - 15" Range)
1 110
Instruction Sheet, Center Mount Rigging Kit 1 1
A - Includes items 2-10 and instruction sheet
B - Instruction Sheet Not Shown
NOTE:
(CTMTJ and CTMT)
Before 10/27/04
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
92
Front Rigging - Center Mount Rigging Kit
(CTMTJ and CTMT)
After 10/26/04
Form No.
03-033
93
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging Kit
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1129462 Kit, Adjustable Length Junior Center Mount Rigging
(9-1/4-12")
1 11 A
1129461 Kit, Adjustable Length Center Mount Rigging
(12-1/4-15")
1 11 A
1113389 Housing, Ratchet 1 12
1025736 Locknut (1/4-20) 1 13
1113622 Cable/Brake Assembly 1 14
10141X012 Washer, Lock (3/16 x 5/16 x 1/16") 1 25
40163X008 Screw, Phillips Pan Head (#10-32 x 11/16") 1 26
1025731 Locknut (#10-32) 1 17
1071736 Screw, Socket Head Shoulder (5/16 x 1-5/8") 1 18
1095502 Package, Cable Ties (11-1/2" Long) 10 19
1056087 Screw, Socket Head (#10-32 x 1/2") 1 110
1127161 Bracket, Cable Release Mounting 1 111
1026107 Screw, Phillips Pan Head (#10-32 x 1-3/8") 1 112
1113375 Pin, Quick Release (5" Long) 1 113
1086207 Nut, Square (#10-32) 1 114
1113383 Bearing, Glide 1 215
1121990 Center Mount Rigging Assembly, Junior
(CTMTJ/CTMT-FJ) ASBA/ADJASBA (9-1/4 - 12"
Range)
1 116
1117262 Center Mount Rigging Assembly (CTMT) (CTMT-F),
ASBA/ADJASBA (12-1/4 - 15" Range)
1 116
1118368 Instruction Sheet, Center Mount Rigging Kit 1 1B
A - Includes items 2-16 plus instruction sheet
B - Not Shown
NOTE:
(CTMTJ and CTMT)
After 10/26/04
Form No.
03-033
To order call toll free 1-800-333-6900, or www.invacare.com
94
Front Rigging - Center Mount Rigging (CTMT/CTMT-L)
(CTMT = 12-1/4" - 15" Range) & (CTMT-L = 16" - 18-3/4" Range)
Form No.
03-033
95
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging (CTMT/CTMT-L)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1117262 Center Mount Rigging Assembly (CTMT) (CTMT-F),
ASBA/ADJASBA (12-1/4 - 15" Range)
1 11 A
1117263 Center Mount Rigging (CTMT-L) (CTMT-FL),
ASBA/ADJASBA
(16" - 18-3/4" Range)
1 11 A
1120346 Legrest Support Assembly, Center Mount, Black 1 12 B
1113376 Ring, Retainer (1/4 x 1/2 x 1/64") 1 23
1113373 Pin, Angle Adjustable A.S.B.A. 1 14
1110669 Bearing, Flanged (1/2 x 13/16 x 1/2") 1 25
1113609 Support, Center Mount Rigging Legrest 1 16
1113372 Rack, Center Mount Rigging Angle Adjustable 1 17
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 48
1123034 Extension Tube and Footplate Assembly
with Heel Loop, Short - Right
1 19 C
1123035 Extension Tube and Footplate Assembly
with Heel Loop, Short - Left
1 19 C
1123036 Extension Tube and Footplate Assembly
with Heel Loop, Long - Right
1 19 C
1123037 Extension Tube and Footplate Assembly
with Heel Loop, Long - Left
1 19 C
1123044 Extension Tube, Footrest Short
(CTMTJ/CTMT-FJ = 9-1/4" - 12" Range)
(CTMT/CTMT-F = 12-1/4" - 15" Range) (PCTMT =
10" - 13" Range)
1 110
1123045 Extension Tube, Footrest Long
(CTMT-L/CTMT-FL = 16" - 18-3/4" Range)
(PCTMT-L = 14" - 17" Range)
1 110
1021421 Screw, Phillips Pan Head (1/4-20 x 2-1/4") 1 211
1006477 Spacer (1/4 x 11/32 x 1-3/4") 1 212
1121996 Heel Loop, Center Mount Rigging 1 213
1078214 Screw, Hex Head Cap w/ Patch (1/4-20 x 1/2") 1 214
1025195 Locknut (1/4-20) 1 215
1113606 Footplate, Center Mount Rigging - Right
(5-1/4" W x 9-5/8" L)
1 116 E
1113607 Footplate, Center Mount Rigging - Left
(5-1/4" W x 9-5/8" L)
1 116 E
1120345 Center Mount Rigging Footplate Mounting Hardware
- Right
1 117 D
1121123 Center Mount Rigging Footplate Mounting Hardware
- Left
1 117 D
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 218
1113384 Hinge, Adjustable Angle - Right 1 119
1113385 Hinge, Adjustable Angle - Left 1 119
1047449 Spacer (1/4 x 3/8 x 3/16") 1 120
1065362 Locknut (1/4-28) 1 121
1096810 Screw, Socket Head (1/4-28 x 1-3/4") 1 122
(CTMT = 12-1/4" - 15" Range) & (CTMT-L = 16" - 18-3/4" Range)
Form No.
03-033
96
To order call toll free 1-800-333-6900, or www.invacare.com
Front Rigging - Center Mount Rigging (CTMT/CTMT-L)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1108122 Locknut (5/16-18) 1 223
1113530 Hinge Attachment 1 124
1021343 Screw, Socket Head Cap (5/16-18 x 1-1/4") 1 125
A - Includes items 2, 8 & 9
B - Includes items 3-7
C - Includes items 10-16 & 17
D - Includes items 18-25
E - Item #16 - Footplate design revised 2/28/07 to accomodate items 18 & 23. Replace footplates in pairs and order new
footplate hardware for chairs mfg. before 2/28/07.
NOTE:
(CTMT = 12-1/4" - 15" Range) & (CTMT-L = 16" - 18-3/4" Range)
Form No.
03-033
97
To order call toll free 1-800-333-6900, or www.invacare.com
MK6i Electronics are contained in a seperate catalog. See
Catalog titled "Electronics MK6i" Form # 06-110.
Form No.
03-033
98
To order call toll free 1-800-333-6900, or www.invacare.com
MK5 DPJ Joystick and Mounting Hardware
Form No.
03-033
99
To order call toll free 1-800-333-6900, or www.invacare.com
Loading...