Hatco SRB Series, SRBW Series, SRG Series, SRGBW Series, SRSS Series Operation Manual

SERV-RITE™

Portable Shelves and Buffet Warmers

SRB, SRBW, SRG, SRGBW, SRSS, and

SRSSBW Series

Installation and Operating Manual

I&W #07.05.204.00

Register your unit online!

See IMPORTANT OWNER INFORMATION section for details.

Do not operate this equipment unless you have read and understood the contents of this manual! Failure to follow the instructions contained in this manual may result in serious injury or death. This manual contains important safety information concerning the maintenance, use, and operation of this product. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor. Keep this manual in a safe location for future reference.

No opere este equipo al menos que haya leído y comprendido el contenido de este manual! Cualquier falla en el seguimiento de las instrucciones contenidas en este manual puede resultar en un serio lesión o muerte. Este manual contiene importante información sobre seguridad concerniente al mantenimiento, uso y operación de este producto. Si usted no puede entender el contenido de este manual por favor pregunte a su supervisor. Almacenar este manual en una localización segura para la referencia futura.

© 2010 Hatco Corporation

CONTENTS

Important Owner Information ..............................................	2	Operation...............................................................................		9
Introduction...........................................................................	2	General...............................................................................		9
Important Safety Information...............................................	3	Changing the Setpoint Temperature ................................		10
Model Description.................................................................	4	Locking/Unlocking the Digital Temperature Control		.........10
Model Designation................................................................	5	Maintenance ........................................................................		11
Specifications........................................................................	5	General .............................................................................		11
Plug Configurations ............................................................	5	Cleaning............................................................................		11
Electrical Rating Chart........................................................	5	Cleaning the Stone Surface..............................................		11
Dimensions — SRB and SRBW Models............................	6	Replacing the Heat Lamps...............................................		12
Dimensions — SRG, SRSS, SRGBW and		Troubleshooting Guide ......................................................		13
SRSSBW Models ............................................................	7	Options and Accessories...................................................		14
Installation .............................................................................	8	Limited Warranty.................................................................		15
General...............................................................................	8	Authorized Parts Distributors............................	Back Cover

IMPORTANT OWNER INFORMATION

Record the model number, serial number, voltage, and purchase date of the unit in the spaces below (specification label located on the bottom of the unit). Please have this information available when calling Hatco for service assistance.

Model No. ________________________________________

Serial No. ________________________________________

Voltage __________________________________________

Date of Purchase __________________________________

Register your unit!

Completing online warranty registration will prevent delay in obtaining warranty coverage. Access the Hatco website at www.hatcocorp.com, select the Parts & Service pull-down menu, and click on “Warranty Registration”.

Business	8:00 AM to 5:00 PM
Hours:	Central Standard Time (C.S.T.)
	(Summer Hours: June to September –
	8:00 AM to 5:00 PM C.S.T.
	Monday through Thursday
	8:00 AM to 2:30 PM C.S.T. Friday)

Telephone: [phone]

E-mail: [e-mail]

Fax:	(800)	690-2966	(Parts and Service)
	(414)	671-3976	(International)

24 Hour 7 Day Parts and Service Assistance available in the United States and Canada by calling [phone].

Additional information can be found by visiting our web site at www.hatcocorp.com.

INTRODUCTION

Hatco Serv-Rite™ Portable Shelves and Buffet Warmers are designed to keep prepared foods at optimum serving temperatures without affecting quality. They are perfect for selfserve buffet areas and customer serving points. All Serv-Rite warmers feature a thermostatically-controlled heated shelf. SRBW, SRGBW, and SRSSBW models feature an overhead halogen heat lamp.

Hatco Serv-Rite Portable Shelves and Buffet Warmers are products of extensive research and field testing. The materials used were selected for maximum durability, attractive appearance, and optimum performance. Every unit is inspected and tested thoroughly prior to shipment.

This manual provides the installation, safety, and operating instructions for Hatco Serv-Rite warmers. Hatco recommends all installation, operating, and safety instructions appearing in this manual be read prior to installation or operation of the Serv-Rite warmer.

Safety information that appears in this manual is identified by the following signal word panels:

WARNING

WARNING indicates a hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION

CAUTION indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

NOTICE

NOTICE is used to address practices not related to personal injury.

2	Form No. SRM-1110

IMPORTANT SAFETy INFORMATION

Read the following important safety information before using this equipment to avoid serious injury or death and to avoid damage to equipment or property.

WARNING

ELECTRIC ShOCK hAzARD:

•Plug unit into a properly grounded electrical receptacle of the correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.

•Turn OFF power switch, unplug power cord/turn off power at circuit breaker, and allow unit to cool before performing any maintenance or cleaning

•DO NOT submerge or saturate with water. Unit is not waterproof. Do not operate if unit has been submerged or saturated with water.

•Unit is not weatherproof. Locate unit indoors where ambient air temperature is a minimum of 70°F (21°C).

•Do not pull unit by power cord.

•Discontinue use if power cord is frayed or worn.

•Do not attempt to repair or replace a damaged power cord. Cord must be replaced by hatco, an Authorized hatco Service Agent, or a person with similar qualifications.

•Never overload extension cord. Use heavy duty, threewire extension cord only. Make sure current carrying capacity of extension cord complies with electrical rating of unit.

•Do not steam clean or use excessive water on the unit.

•This unit is not “jet-proof” construction. Do not use jetclean spray to clean this unit.

•Do not clean the unit when it is energized or hot.

•Do not allow liquids to spill into the unit.

•Do not fill SRB and SRBW models with water. They are dry heat units only, not steam table units.

•Use only Genuine hatco Replacement Parts when service is required. Failure to use Genuine hatco Replacement Parts will void all warranties and may subject operators of the equipment to hazardous electrical voltage, resulting in electrical shock or burn. Genuine hatco Replacement Parts are specified to operate safely in the environments in which they are used. Some aftermarket or generic replacement parts do not have the characteristics that will allow them to operate safely in hatco equipment.

FIRE hAzARD: Locate the unit a minimum of 1″ (25 mm) from combustible walls and materials. If safe distances are not maintained, combustion or discoloration could occur.

WARNING

Use only low pressure halogen light/heat lamps that meet or exceed National Sanitation Foundation (NSF) standards and are specifically designed for food holding areas.

Make sure food product has been heated to the proper food-safe temperature before placing on the unit. Failure to heat food product properly may result in serious health risks. This unit is for holding preheated food product only.

This unit must be serviced by qualified personnel only. Service by unqualified personnel may lead to electric shock or burn.

This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized hatco Service Agent or contact the hatco Service Department at 800-558- 0607 or 414-671-6350; fax [phone]; or International fax [phone].

CAUTION

BURN hAzARD: Some exterior surfaces on unit will get hot. Use caution when touching these areas.

Locate unit at the proper counter height in an area that is convenient for use. Location should be level to prevent unit or its contents from falling accidentally and strong enough to support the weight of the unit and contents.

Make sure to clean and sanitize the stone surface properly after deep cleaning the surface using abrasives and before placing food product on unit.

NOTICE

Do not lay unit on the side with the control panel or damage to the unit could occur.

Use non-abrasive cleaners only. Abrasive cleaners could scratch the finish of the unit, marring its appearance and making it susceptible to soil accumulation.

Do not slide pans across glass surface, use roughbottomed pans, or drop anything on glass surface. Scratching or breakage may occur. Damage to glass surface or breakage of glass caused by misuse is not covered under warranty.

Do not place anything on top of glass sneeze guard. It is not designed to be a weight-bearing component.

Do not attempt to install glass sneeze guard alone. Installation of glass sneeze guard is a two-person job.

Do not touch halogen heat lamps with bare skin. Oils from the skin will cause premature failure of the lamps.

Form No. SRM-1110	3

MODEL DESCRIPTION

All Models

All Hatco Serv-Rite™ Portable Shelves and Buffet Warmers are ideal for self-serve buffet areas and customer serving points. Each is equipped with a removable utensil tray and is designed to hold hot food at safe serving temperatures. They feature a thermostatically-controlled heated shelf, durable construction, and a 6′ (1829 mm) power cord with plug. Units are available in polished aluminum or several Designer colors.

Serv-Rite Portable Shelves and Buffet Warmers are designed for a maximum operating temperature of 200°F (93°C).

NOTE: Buffet Warmer models are available with clear glass sneeze guards or optional smoked glass sneeze guards.

Model SRB-1

The Serv-Rite Base (SRB) is a portable heated shelf. It is designed to hold either one full-size, two half-size, or three thirdsize steam table pans up to 2-1/2″ (64 mm) deep. The SRB-1 is shipped from the factory fully assembled and ready for use.

Model SRG-1

The Serv-Rite Glass Shelf (SRG) is a portable heated glass shelf. The SRG-1 is shipped from the factory fully assembled and ready for use.

Model SRSS-1

The Serv-Rite Stone Shelf (SRSS) is a portable heated stone shelf. The SRSS-1 is shipped from the factory fully assembled and ready for use.

NOTE: Stone surfaces are simulated stone.

Heated Glass

Surface = SRG-1

Heated Stone

Surface = SRSS-1

Figure 1. Model SRB-1

Model SRBW-1

The Serv-Rite Buffet Warmer (SRBW) is a heated shelf with overhead halogen heat lamps and a glass sneeze guard. It is designed to hold either one full-size, two half-size, or three third-size steam table pans up to 2-1/2″ (64 mm) deep. The SRBW-1 requires installation of the glass sneeze guard before it is ready for use.

Figure 3. Model SRG-1 and SRSS-1

Model SRGBW-1

The Serv-Rite Glass Shelf Buffet Warmer (SRGBW) is a heated glass shelf with overhead halogen heat lamps and a glass sneeze guard. The SRGBW-1 requires installation of the glass sneeze guard before it is ready for use.

Model SRSSBW-1

The Serv-Rite Stone Shelf Buffet Warmer (SRSSBW) is a heated stone shelf with overhead halogen heat lamps and a glass sneeze guard. The SRSSBW-1 requires installation of the glass sneeze guard before it is ready for use.

NOTE: Stone surfaces are simulated stone.

Heated Glass

Surface = SRGBW-1

Heated Stone

Surface = SRSSBW-1

	Figure 4. Model SRGBW-1 and SRSSBW-1
Figure 2. Model SRBW-1
4	Form No. SRM-1110

MODEL DESIGNATION

Serv-Rite

S R B - X

Quantity of Heated Bases or Surfaces

B = Heated Shelf

G = Heated Glass Shelf

SS = Heated Stone Shelf

BW = Heated Shelf Buffet Warmer

GBW = Heated Glass Shelf Buffet Warmer

SSBW = Heated Stone Shelf Buffet Warmer

Figure 5. Model Designation

SPECIFICATIONS

Plug Configurations

Units are supplied from the factory with an electrical cord and plug installed. Plugs are supplied according to the application.

WARNING

ELECTRIC ShOCK hAzARD: Plug unit into a properly grounded electrical receptacle of the correct voltage, size, and plug configuration. If plug and receptacle do not match, contact a qualified electrician to determine and install proper voltage and size electrical receptacle.

NEMA 5-15P

CEE 7/7 Schuko

AS 3112 BS-1363

Figure 6. Plug Configurations

NOTE: Receptacle not supplied by Hatco.

Electrical Rating Chart

Model	Voltage	Watts	Amps	Plug Configuration	Shipping Weight
SRB-1	120	500	4.2	NEMA 5-15P	42 lbs. (19 kg)
	230 (CE)	500	2.2	CEE 7/7 Schuko, AS 3112, or BS-1363	42 lbs. (19 kg)
SRBW-1	120	800 (1100)	6.7 (9.2)	NEMA 5-15P	68 lbs. (31 kg)
	230 (CE)	650 (950)	2.8 (4.1)	CEE 7/7 Schuko, AS 3112, or BS-1363	68 lbs. (31 kg)
SRG-1	120	350	2.9	NEMA 5-15P	35 lbs. (16 kg)
	230 (CE)	350	1.5	CEE 7/7 Schuko, AS 3112, or BS-1363	35 lbs. (16 kg)
SRGBW-1	120	650 (950)	5.4 (7.9)	NEMA 5-15P	61 lbs. (28 kg)
	230 (CE)	650 (950)	2.8 (4.1)	CEE 7/7 Schuko, AS 3112, or BS-1363	61 lbs. (28 kg)
SRSS-1	120	350	2.9	NEMA 5-15P	35 lbs. (16 kg)
	230 (CE)	350	1.5	CEE 7/7 Schuko, AS 3112, or BS-1363	35 lbs. (16 kg)
SRSSBW-1	120	650 (950)	5.4 (7.9)	NEMA 5-15P	61 lbs. (28 kg)
	230 (CE)	650 (950)	2.8 (4.1)	CEE 7/7 Schuko, AS 3112, or BS-1363	61 lbs. (28 kg)

The shaded areas contain electrical information for International models only.

*Watt and amp ratings in parentheses are for units with two optional 300 W halogen bulbs. Ratings without parentheses are for units with the standard two 150 W halogen bulbs.

Form No. SRM-1110	5