Page 1
CDM-9805R
SERVICE MANUAL
FM/MW/LW/RDS CD Receiver
3 / 03-A
68E35108S01
TO ALPINE Home Page
Page 2
<Cautions for Safe Repair Work>
r
s
The following cautions will prevent accidents in the workplace and will ensure safe products.
*The symbols indicate caution is needed to prevent injuries and damage to property.
The symbols and their meanings follow.
Warning
Caution
*The following symbols indicate two levels of cautions.
When you see this symbol, you have to be very careful.
When you see this symbol, you have to follow the instructions there.
If you ignore this symbol and handle the product incorrectly or unsafely,
serious injury or death may result.
If you ignore this symbol and handle the product incorrectly or unsafely,
injury or only material damage may result.
Warning
Do not look squarely into the laser light
coming from the pickup. Always use a designated fuse.
You may loose you sight. Use of an incorrect fuse may result in a fire.
Caution
Do not allow wiring to be caught in the Battery Caution
screw/chassis. Use the designated battery.
If wiring is caught in the screw/chassis, it may Confirm the correct polarity and seat of the
cause a short circuit, resulting in a fire. battery.
Fuse Caution
An incorrect battery or an improperly connected
or seated battery may result in a fire.
High Temperature Caution Designated Parts Caution
Touching the heat sink may cause severe burns. Look up the part list and ensure that only
designated parts are used to prevent problems or
accidents.
Reverse Power Supply Connections o
Misconnections Caution Ensure that the wiring is correct when rewiring to
Reverse power supply connections or prevent problems with ignition/breakdown.
misconnections may cause ignition problems and
smoke may result.
Soldering Caution Wear Glove
Hot solder from solder splash may cause severe Wear gloves to prevent electrical shocks or injury
burns. from the end face of the metal.
Wiring Caution
Page 3
Contents
Cabinet Assembly Parts List
CD Deck Mechanism Assembly Parts List
Electrical Parts List
Packing Assembly Parts List
Packing Method View
Specifications
Adjustment Procedures
Extension Cable
Block Diagram
Parts Layout on P.W.Boards and Wiring Diagram
Schematic Diagram
Terminal Voltage of IC/TR
Description of IC Terminal
Exploded View (Cabinet)
Exploded View (CD Deck Mechanism) (DP23S2A0)
NOTE : Due to continuing product improvement, specifications and designs are subject to
change without notice.
Page 4
Packing Assembly Parts List
TO CONTENTS
Symbol Description
Part No.
No.
101-1 03S72235F13 SCR,MCH M5X8 FLAT
101-2 36A11113W01 CAP,RUBBER(A)
101-3 03A11112W01 BOLT,HEX.M5(A)
102 15D00529K02 CASE,INNER
Packing Method View
105
103
Symbol
Part No.
Description
No.
103 15D01798K01 CARRYING,CASE
104 01T15359Y03 ASSY,ISO CONN 7873R0
105 68P02294K52 O/M AOEU AODN
101
-1
X4
B
O
T
T
O
S
M
I
D
E
104
101
101 -3
101 -2
X1
X1
102
X1
B
O
T
T
O
S
M
I
D
E
102
103
X1
104
X1
Page 5
Specifications
<FM RADIO>
Intermediate Frequency ................................................................................................................................ 10.7MHz
Frequency Range ............................................................................................................................ 87.5 to 108.0MHz
Usable Sensitivity (30 S/N, Mono, at 98.1MHz) .............................................................................................. 20.2dBf
-3dB Limiting Sensitivity (at 98.1MHz) ............................................................................................................ 20.2dBf
Residual Noise (Ref. 400Hz(WID), at 98.1MHz) ............................................................................................ 25±10dB
S/N Ratio (at 98.1MHz) ......................................................................................................................... Stereo : 50dB
Mono : 55dB
Image Rejection (at 106.1MHz) .......................................................................................................................... 40dB
IF Rejection (at 90.1MHz) ................................................................................................................................... 60dB
Distortion (Input 60dBu, at 98.1MHz) .................................................................................................................. 1.0%
Frequency Response (Ref. 400Hz, at 98.1MHz) ................................................................................. 100Hz : 0±3dB
10kHz : -12±3dB
Stereo Separation (1kHz, at 98.1MHz) ............................................................................................................... 20dB
PS Sensitivity (at 98.1MHz) ............................................................................................................................ 36.2dBf
<MW RADIO>
Intermediate Frequency ........................................................................................................................ 1st : 10.7MHz
2nd : 450kHz
Frequency Range .............................................................................................................................. 531 to 1,602kHz
Usable Sensitivity (20dB S/N, at 999kHz) ........................................................................................................... 34dB
S/N Ratio (at 999kHz) ......................................................................................................................................... 44dB
Image Rejection (at 603kHz) ............................................................................................................................... 40dB
IF Rejection (at 603kHz) ..................................................................................................................................... 50dB
Distortion (at 999kHz) .......................................................................................................................................... 1.5%
Frequency Response (Ref. 400Hz, at 999kHz) .................................................................................. 100Hz : -3±4dB
4kHz : -12+4, -8dB
<LW RADIO>
Intermediate Frequency ........................................................................................................................ 1st : 10.7MHz
2nd : 450kHz
Frequency Range .................................................................................................................................. 153 to 281kHz
Usable Sensitivity (20dB S/N, at 216kHz) ........................................................................................................... 38dB
S/N Ratio (at 216kHz) ......................................................................................................................................... 45dB
Image Rejection (at 270kHz) ............................................................................................................................... 40dB
IF Rejection (at 162kHz) ..................................................................................................................................... 50dB
Distortion (at 216kHz) .......................................................................................................................................... 1.5%
Frequency Response (Ref. 400Hz, at 216kHz) .................................................................................. 100Hz : -3±4dB
4kHz : -12+4, -8dB
<Pickup>
Wave Length .................................................................................................................................................... 795nm
Laser Power ................................................................................................................................................... CLASS I
TO CONTENTS
Page 6
<CD SECTION>
TO CONTENTS
System ....................................................................................................................... Optical (Compact Disc System)
Channel Balance (1kHz, TCD-782) ................................................................................................................... 0±3dB
Distortion (1kHz, TCD-782) ................................................................................................................................. 0.1%
Frequency Response (Ref. 1kHz, TCD-782) ......................................................................................... 17Hz : 0±3dB
127Hz : 0±2dB
10.007kHz : 0±2dB
19.997kHz : 0±4dB
S/N Ratio (TCD-782) ........................................................................................................................................... 95dB
Separation (1kHz, TCD-782) ............................................................................................................................... 55dB
De-Emphasis (Ref. 1kHz, TCD-782) .................................................................................................. 4kHz : -20±3dB
16kHz : -20±3dB
<GENERAL>
Power Supply ................................................................................................................................................ DC14.4V
Power Output (Ref. FM Mode, SP-OUT, T.H.D. 10%) /Impedance ...................................................... 16W/ch/4ohm
Pre Output (Ref. TCD-782(1KHz, 0dB), T.H.D. 1%) /Impedance ................ FRONT/REAR : 2V±2.5dBV/ch/10kohm
SUB-W(STEP+15) : 2V±2.5dBV/ch/10kohm
Dimensions (W x H x D) ................................................................................................ Chassis : 178 x 50 x 160mm
Nose : 188 x 58 x 27mm
Weight ................................................................................................................................................................. 1.5kg
NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice.
Page 7
Adjustment Procedures
(2) Connections
(3) Control Settings
Power Switch .............................................. ON Band Switch .............................. FM/MW/LW
Fader Control ........................... Center Position LOUD .................................................... OFF
Balance Control ....................... Center Position SUB-W .................................................. OFF
Treble Control .......................... Center Position Others ................................................... OFF
Bass Control ............................. Center Position
1. FM/AM SECTION
(1) Dummy Antenna Circuit
TO CONTENTS
*
*
Page 8
(4) Adjustment Procedures
Step
Description
Connection
Signal Generator
Dial Control
Test Point /
P.W.Board
Coordinates
Adjustment
1
Signal Meter
Auto
Adjustment
(FM)
Figure 3
(1)
87.5MHz ,
26dBµ
(Mod. OFF)
87.5MHz
TP002
(3-F)
TP608
(5-D)
Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP608 (Pull-Down)
for 1 second.
(2)
87.5MHz ,
26dBµ
(Mod. OFF)
87.5MHz
TP002
(3-F)
TP608
(5-D)
(SPEC)
TP002:1.5±0.1V OK
(SPEC) TP002 : others 1.5±0.1V NG
NOTE : NG : Proceed same Auto
Adjustment of step (1)
under step (3).
(3)
87.5MHz ,
21~23dBµ
(Mod. OFF)
87.5MHz
TP002
(3-F)
TP608
(5-D)
Proceed same Auto Adjustment of step
(1) under step (3).
(4)
87.5MHz ,
26dBµ
(Mod. OFF)
87.5MHz
TP002
(3-F)
TP608
(5-D)
Proceed same Auto Adjustment of step
(1) under step (4).
2
Signal Meter
Auto
Adjustment
(MW)
Figure 4
(1)
999kHz ,
34dBµ
(Mod.OFF)
999kHz
TP002
(3-F)
TP608
(5-D)
(2)
999kHz,
34dBµ
(Mod. OFF)
999kHz
TP002
(3-F)
TP608
(5-D)
(3)
999kHz ,
29~31dBµ
(Mod. OFF)
999kHz
TP002
(3-F)
TP608
(5-D)
(4)
999kHz ,
34dBµ
(Mod. OFF)
999kHz
TP002
(3-F)
TP608
(5-D)
(SPEC) TP002 :1.0 ±0.1V OK
(SPEC) TP002 : others 1.0±0.1V NG
NOTE : NG : Proceed same Auto
Adjustment of step (1)
under step (3).
TO CONTENTS
Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP608 (Pull-Down)
for 1 second.
Proceed same Auto Adjustment of step
(1) under step (3).
Proceed same Auto Adjustment of step
(1) under step (4).
Page 9
Step
Description
Connection
Signal Generator
Dial Control
Test Point /
P.W.Board
Coordinates
Adjustment
3
Signal Meter
Auto
Adjustment
(LW)
Figure 4
(1)
216kHz ,
34dBµ
(Mod. OFF)
216kHz
TP002
(3-F)
TP608
(5-D)
Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP608 (Pull-Down)
for 1 second.
(2)
216kHz ,
34dBµ
(Mod. OFF)
216kHz
TP002
(3-F)
TP608
(5-D)
(SPEC) TP002 : 1.0±0.1V OK
(SPEC)
TP002
: others 1.0±0.1V NG
NOTE : NG : Proceed same Auto
Adjustment of step (1)
under step
(3).
(3)
216kHz ,
29~31dBµ
(Mod. OFF)
216kHz
TP002
(3-F)
TP608
(5-D)
Proceed same Auto Adjustment of step
(1) under step (3).
(4)
216kHz ,
34dBµ
(Mod. OFF)
216kHz
TP002
(3-F)
TP608
(5-D)
Proceed same Auto Adjustment of step
(1) under step (4).
TO CONTENTS
Page 10
Extension Cable
* When repairing or measuring the voltage of this unit, connect with the Extension Cable as shown in below.
TO CONTENTS
Page 11
Block Diagram
TO CONTENTS
ANT001
MB4R002Z
FM
AM
MINI BUS IN
EL VOL (TDA7412)
Selector Vol. 1 Tre/Bass Vol. 2
MUTE
DIN001
RCA201
SUB-W
DP23S2AO
Tuner unit
SERVO
+B
LPF
RDS
DECODER
TUNER+B
ST-REMO
CD
I²C
Main u-COM
MINI
BUS I/F
System
Reset
BATT
Det
ACC
Det
POWER
ON+B
Mute
Driver
BUFFER
MUTE
MUTE
POWER
IC
P.ANT/
O.REM
F
JK201
R
CB801
FRONT
REAR
BATT
ACC
P-ANT
O-REM
LCD401
LCD
Driver
Key
Matrix
Rotary
Encoder
Remote
Control
Page 12
M802
TO CONTENTS
TO PARTS LIST
TO P. W. Board
MOTOR, F2510CT-12UCV
CB802
53253-0210
N. U.
100k
47k
R658
R635
0.1
C628
R638
12k
R637
N. U.
TP601
TP602
TP603
N. U.
R622
Q867
2SD1994A
0.1
0.1
C806
C805
R882
470-1/4
Q866
FMC2
TP605
1k R883
R648
R601
N. U.
TP606
R627
R602
C601
N. U.
TH602
N. U.
R610
R877
1k
R878
R685
N. U.
N. U.
N. U. N. U. N. U.
10k
100k
TH601
R607
R686 2.2k
10k
R642
R604
22k
1k
R641
22k-1/4
R606
R630
DTC124EKA
C662
1000p
Q664
DTA143EKA
R664
22k
Q612
47k-1/4
Q601
DTA124EKA
Q610
DTC124EKA
D662
DAN202K
D601
1SS133
R631
22k-1/4
R632
220-1/4
C610
330p
JK601
JAC, CK-3 5-14
10/16
E812
ZD804
HZS9C2L
1k1k1k1k000
TP610
TP609
R683
R684
R617
R666
R668
R667
R613
TP650
R672
Q605
DTC114EKA
R612
100-1/4
0.1
C606
22k
R671
1k
Q606
R673
2SA1037AK
10k
0.01
C607
3.3k
R628
DTC114EKA
2.2k
R633
C612 100p
Q611
Q607
DTC114EKA
22k
R670
D602
DAN202K
2200p
C603
TP651
TP652
TP653
Q604
FMC3
C501
470k
R640
1000pR605
E602
220/10
0.022
C611
E601
22/16
47k
R647
22k
R649
22k
R650
R639
4.7k
4.7k
R646
IC601
D784216AGF
1k1k1k
1k
270
270
R611
N. U.
R691
0
10k
R608
0
TP600
R681
1k
R682
R636
47k-1/4
1k
R618
R624
1k
R615
R645
R634
R623
1k1kN. U.
R616
R614
R619
R620
R621
R625
R626
4.7k-1/4
10k
10k
TP608
R644
47k
R609
12-2W
CB601
BTB, TMD-V15X-A1
TP604
C609
18p
XL601
12.288MHz
C608
18p
R663
22k
R662
12k
47k
R600
L602
N. U.
R660
4.7uH
SW601
RESET
SKHHLW
C602
0.022
N. U.
R880
R879
12k
Q603
N. U.
10k
R680
R676
R674
3.9k-F
R659
N. U.
E604
Q651
2.7k-1/4
C604
N. U.
N. U.
L600
4.7uH
C651
FMC2
R675
10k-F
IC652
S-80930CNMC
0.1-B
C605
0.047-B
C618
0.47-B
Q652
R629 47k
IC651 TDA3606AT
FMC2
D653
Q807
E805
1/50
R803
100k
1SS133
ZD652
HZS7B2L
C653
2SD1994A
ZD803
HZS9C2L
R808
820-1/4
R651 56k
R656
330k
33/16
E651
120kF
0.022-B
R657
C652
R654
4.7k-1/4
0.1
R655
4.7k-1/4
J-1/4
R881
Q865 N. U.
Page 13
E209
TO CONTENTS
TO PARTS LIST
TO P. W. Board
E210
L200
N. U.
SD201
N. U.
R269
E200
N. U.
R200
C200
24k
1u
1/50
1/50
L202
N. U.
N. U.
N. U.
R270
E201
IC200
N. U.
N. U.
C224
N. U.
C221
E207
10/16
N. U.
N. U.
N. U.
N. U.
E203
C226
C225
L201
N. U.
N. U.
N. U.
D200
E205
N. U.
R271
N. U.
N. U.
C222
R261 N. U.
R262 N. U.
N. U.
R272
E206
BA4560F
R201 1.1k
R202 1.1k
BA4560F
IC201
IC201
E208
22/16
N. U.
C223
N. U.
N. U.
N. U.
N. U.
E302
C300
C301
R301
IC301 N. U.
R300
10/16
10/16
10/16
10/16
N. U.
N. U.
E300
C307
0.22-TF
C308
0.22-TF
C309
0.22-TF
0.22-TF
C310
N. U.
N. U.
N. U.
N. U.
N. U.
E304
C302
C303
C304
C305
E305
E306
E307
E306
ZD304
N. U.
N. U.
C306
N. U.
E301
N. U.
Z600
E211
1/50
1/50
E212
E213
1/50
E214
1/50
C201
R205
0.12-B
6.8k
C202
0.1 K-B
C203 1000p
E807
R206
2.2k
R209
R210
2SC3421
R207
DTC124EKA
Q800
510-1/4
33/16
39k
R208 C205
Q201
1k
1k
R822
ZD800
HZS9C1L
C204
0.1 K-B
Q808
N. U.
R807
N. U.
E801
N. U.
N. U.
ZD802
N. U.
E803
N. U.
E804
E806
220/10
R821 620k
IC202
TDA7412
E218
R800
100-1/4
E810
47/16
DTC124EKA
22/16
Q810
C206
N. U.
10k
R837
100p
E217 1/50
470k
E216
10/16
0.068
C207
D800
1SS133
E808
100/16
Q804
FMC2
R263 N. U.
R264 N. U.
2SB1243
100/16
E809
Q801
R823
R203
1.1k
R204
R824
1.6k-1/4
1.6k-1/4
Q805
DTC143XKA
R825
IC203
BA4560F
1.1k
IC203
BA4560F
E215
22/16
R826
R827
1.5k-1/4
Q300
DTC124EKA
Q803
N. U.
24k-1/4
1.5k-1/4
N. U.
R828
Q806
N. U.
N. U.
E811
10k-1/4R307
N. U.
R302
R309R308
10k J
E312
PS001 PTGL05BA1R8M1
R801
N. U.
R802
N. U.
N. U.
R831
R830
N. U.
R832
N. U.
N. U.
R829
D801
N. U.
R838
10k
N. U.
R840
1/50
C311 0.22
Q802
2SB1243
24k
R833
R834
1.8k-1/4
Q809
DTC143EKA
R344
N. U.
E309
0.1/50
E311
0.22/50
E310
10/16
C314 N. U.
D305
D306
D307
D308
C313
1000p
R835
1.8k-1/4
IC302
TA8263BH
0.047
N. U.R310
3300/16
C312
E313
L603
CHOKE
CB801
WTB, IMSA9451B-16
0.01
C803
R836
1k-1/4
TP803TP804
SD600
D3A3A4
R820 10k-1/4
C802
0.022
TP802
D313
SRT14
D314
SRT14
D315
SRT14
D316
SRT14
DIN001
DIN, SKT 8P CMS-R
SRT14
SRT14
SRT14
SRT14
10k-1/4
R839
D802
MPG06G
0.1-TF
C804
C801
0.01
0.01
C800
TP801
Page 14
JK201
TO CONTENTS
TO PARTS LIST
TO P. W. Board
ASSY, CONN NLT1661
Z301
BL02RN1R2P1A
J
R218
E220
N. U.
N. U.N. U.
R212R213
N. U.
E221
R219
J
R220
J
E222
N. U.
N. U.
R224
N. U.
R225
N. U.
R226
N. U.
C208
N. U.
R230
IC204
N. U.
IC204
N. U.
R231 22k
C209 N. U.
C210
R232
22k
10p-CH
22k
IC205
N. U.
E228
E226
E227
N. U.
N. U.
N. U.
E232
2.2/50
DTC343TK
DTC343TK
E233
2.2/50
E234
2.2/50
DTC343TK
Q202
Q203
Q204
R236
R238
Z302
BL02RN1R2P1A
100
R237
100
100
R250
100
47k47k
R244R245
R251
100
R252
100
47k
R246
TP202
TP201
TP203
TP204
TP205
CB201
53253-0310
TP206
RCA201
TP207
C220 1000P
ASSY, WIRE RCA 9805R
E223
E224
E225
N. U.
R222
N. U.
N. U.
R223 J
E215 E214
R221
R216R217
E229
N. U.
IC206
N. U.
N. U.
N. U.
22k
E230
N. U.
E231
N. U.
22k
R228
N. U.
R227
N. U.
R229
N. U.
IC205
C212
N. U.
R234
R233
C211
IC206
N. U.
R235
C213
N. U.
22k
N. U.
J
J
N. U.
N. U.
DTC343TK
E235
2.2/50
E236
2.2/50
DTC343TK
DTC343TK
E237
2.2/50
Q205
Q206
Q207
R240
100
R239
100
R241
100
47k
R247
R253
100
R254
100
R255
R249 47k R248 47k
100
C214 N. U.
C215 N. U.
C216 N. U.
C217 N. U.
C218 N. U.
C219 N. U.
Page 15
MB4R002Z FM/AM UNIT
TO CONTENTS
TO PARTS LIST
TO P. W. Board
TU002
L002L003
R047
4.7uH15uH
10-1/4
TP002
R035 1k
R040 1k
R038 470
L005 4.7uH
470
R039
ANT001
ASSY, ANT CABLE ISO
SA002
DSP-201M
R045 N. U.
L004
52mH
CF002
LPF11830KH
D002
1PS226
R027 22k
C090 0.047
C089 1000p
C091 0.01-B
C094 0.01-B
R041
R042
10k
10k
C079 0.01-B
R032 0
C098
C080 0.01-B
R028 1k
N. U.
C081 0.01-B
C099
E013 220/10
R030
N. U.
E014 22/16
E015 22/16
R023 0
R024 0
R025 0
1k
C095 0.1-B
R017
R021
NJM2904M
IC012
Q074
2SA1037AK
FMC3
3.3k
Q075
1k
C071
560p
10
R046
100p
C074
2200p
R026
C076
330p 0
IC013
TC7S66F
1k
R029
22/16
E017
N. U.
N. U.
1k
R036
C002
R037
C073
C082
0.022
E016
22/16
0.022
C092
Q077
FMC3
0.1
C075
0
R022
C096
C077
E012
2.2/50
180p
C083
E018
100p
0.022
IC010
SAA6588T
470k
R018
C093
10/25-TA
R005
0
0
R006
2200p
R019
N. U.
4.7k
R020
XL002
C078
4.332MHz
27p
C085
27p
C084
IC011
BA00AST
R031 13kF
0.022-B
R033
R034
2.2kF
C072
0.1
5.6k
5.6k
R050
R013
R014
1k
R015
1k
R003
0
R004
0
100p
C086
C087 100p
N. U.
N. U.
E019
C097
220/16
1000p
C001
R043 10
R044
0-1/4
Page 16
CH101
TO CONTENTS
TO PARTS LIST
TO P. W. Board
SLW22R-1C7
R103
750-1/4
C101 3300p
R104 750-1/4
N. U.
C103
C115 3300p
Q111
2SB1261
L101
220uH
R105 100-1/4
SD100
SB040
560-1/4R106
560-1/4R107
22k
R109
68k
0.022
470/10
TP101
TP100
C116
E100
R108
C117
1500p
4.7k
R110
IC101
MC34063AML
120p
C118
Q112
FMC2
0.022
N. U.
1u
R111
C120
C119
E101 100/16
Page 17
LCD401 LCD, WTD-21544AEHU
TO CONTENTS
TO PARTS LIST
TO P. W. Board
CH401
R408 1k
R409
R410 10k
R411 10k
R412 10k
R413 10k
R414
24k
BTB, TMD-V15P-A1
1k
R401
24k
1PS226
1PS226
1PS226
1PS226
D401
D402
D403
6.8-1/4
R453
R481
R480
R451
R402 1k
R403 1k
R404 1k
R405 1k
R406 1k
Q451
N. U.
N. U.
N. U.
10-1/4
N. U.
LD480
N. U.
LD481
N. U.
R486
R452
N. U.
10-1/4
R485
N. U.
LD451
N. U.
LD463
PL451
6V-80mA
1PS226
D404
D405
R455
R457
180-1/4
180-1/4
R461
N. U.
N. U.
27-1/4
R454
220-1/4
R456
6V-80mA
PL452
LD452
LD464
6V-80mA
PL453
LD465
220-1/4
R458
LD453
BG1111C
BG1111C
LD466
BG1111C
BG1111C
LD467
BG1111C
BG1111C
R463
R462
N. U.
N. U.
R464
N. U.
LD455
LD470
LD471
N. U.
LD456
N. U.
N. U.
LD472
N. U.
N. U.
LD473
R466
R465
270-1/4
R483
R482
270-1/4
LD458
BG1111C
LD469
BG1111C
C409
0.022
3.3k-1/4
R467
R468
330-1/4
R484
4.3k-1/4
DG1111C
LD474
R469
330-1/4
BG1111C
N. U.
LD482
LD457
LD459
C410
0.022
R472
56-1/4
330-1/4
R474
120-1/4
330-1/4
MAZS180
LD461
NSCWS405T
ZD451
LD478
AA1111C
NSCWS405T
R473
56-1/4
R475
120-1/4
MAZS180
LD462
NSCWS405T
ZD452
LD479
NSCWS405T
IC401
PT6583LQ
C406 0.047-B
C407
0.047-B
R423 1k
R424 1k
R425 1k
R426 1k
R427 1k
R428 1k
R429 1k
R430 1k
R421 1k
R422 1k
C404
R407
SW401
SW404
C405
0.047-B
820p
47k
ZD401
RD6.2MB3
SW405
SW402
SW406
SW407
SW422
R419
R420
4.7k
SW408 SW411
SW414
PL454
R487 R477
J-1/4 J-1/4
SW416
SW418
SW420
SW419
6V-80mA
R447
100
R446
N. U.
4.7
RS-671
C408
D415
MA159
MA159
D416
MA159
D417
D406
1PS226
IC402
R476
N. U.
100k
SW412
SW413SW410
SW421
ENC, EC11B15243
Page 18
TP409
TO CONTENTS
TO PARTS LIST
TO P. W. Board
TP410
R434
100
TP401
TP402
TP403
TP404
R406
CB103
52207-0790
TP418
10-1/4
TP422
TP423
R334
R331
TP425
TP426
TP419
R302
10-1/4
J
R333
J
C306 C305 C304
0.1 0.1 0.022
R332
J
J
TP225
TP226
TP227
TP228
TP229
TP405
TP260
2SB1132
Q301
IC401 BA5984FP
0.1
E303
C302
E301
10/16-T
TP406
TP407
47/5.5
TP408
TP417
TP329
R301
TP330
SW105
SPPB120
M102
ASSY, MOTOR SLED 2BO
SW3
SW4
SPVG23
HD101
PICKUP,
EP21A67L
M103
ASSY, MTR SPINDOL 2BO
SW1
SW2
SPVG23
SPVG13
SPVG21
TP420
TP421
CB102
52207-1590
TP424
10k
R407
10k
R405 15k 39k
C448 C447
N. U. N. U.
0.1
C409
C449
150p-CH
R409
10k
R408
22k
100
R402
27k
R403
560p-CH
R410
10k
R401
100k
Q401
DTC124EUA
D401
MA159
C450
R411
R404
22k
E407
TP331
0.1
C308
10/16
C326
TP325
C347
0.22
C327
22p-CH
C328
R338 N. U.
R339 N. U.
C330
56p-CH
TP326
R336
E32922/10-T
N. U.
C331
39p-CH
N. U.
TP328
TP411
TP323
R325
7.5k
1.5p-CH
R335
N. U.
C332
0.1
C310
E310
10/16-T
C323
TP327
0.1
0.1
TP412
R435
100
C322
C324
C325
3900p
C311 0.01
TP413
TP414
R436
100
0.033
R323
R324 39k 10k
0.1
C346
1000p
TP415
TP416
R437
100
R345
33k
R344
33k
0.1
R343
TP322
TP321
TP320
TP319
IC301
UPD63711A
C345
1000p
C318
33k
TP318
C321
0.01
47/5.5
E317
E316
22/6.3
C320
0.1
TP316
TP315
TP311
TP306
TP305
E338
10/16-T
AN80M50RSPE1
E331
2.2/16-T
R312
N. U.
IC302
0.1
C334
E333
10/16
J
R311
0.1
C319
0.1
E337
47/5.5
J
R341
C340
N. U.
CL301
16.9MHz
N. U.
R342
C341
22p-CH
C336
M101
ASSY, MOTOR WORM 2BO
TP217
TP218
TP219
TP220
TP221
TP222
TP223
RA201
TP212
TP213
TP214
47k
R260
R261
47k
R262
R259
47k
47k
C246
0.1
R212
TP216
33k
R270
100
47k
R263 47k
R264 47k
R265 47k
R266
47k
R201
TP215
IC201
D789026GB
47k
47k
R202
R203
TP201
TP202
TP203
100x4
RA202
100x4
TP301
R250 47k
R251 47k
R252 47k
R253 47k
R254 47k
R255 47k
R256 47k
R257 47k
R258 47k
R226
N. U.
TP207
33k
CL201
4.19MHz
TP210
E239
TP206
TP208
R317
47/5.5
C240 0.1
R230 100
TP101
TP102
TP103
TP104
TP105
TP106
TP211
TP209
R229 47k
C238
0.1
R228
10k
TP204
TP205
R247
R246
J
0.01
C241
R316
220
TP302
220
C314
2200p
C315
2200p
TP303
TP107
TP108
TP109
TP110
TP111
TP112
CB101
52207-2290
TP119
TP113
TP114
TP115
TP116
TP117
TP118
Page 19
Terminal Voltage of IC/TR
TO CONTENTS
TO SCHEMATIC
IC010
1 PS 11 4.84 1 4.83 1 0.48
2 PS 12 PS 2 14.21 2 0.48
3 PS 13 2.39 3 0 3 0.48
4 2.44 14 4.76 4 8.44 4 0
5 2.05 15 0 5 1.22 5 0.48
6 PS 16 2.38 6 0.48
7 4.84 17 2.38 7 0.48
8 4.84 18 2.38 8 8.4
9 4.84 19 2.38
10 4.31 20 2.38
IC013
1 3.04 1 0 1 4.37
2 3.04 2 0.6 2 4.37
3 0 3 0 3 4.37
4 4.92 4 10.4 4 0
5 4.84 5 1.27 5 4.37
IC101
6 14.3 6 4.37
7 14.3 7 4.37
8 10.4 8 8.76
IC011
IC201
IC012
IC203
1 4.36 1 4.34 23 NC
2 4.36 2 4.34 24 NC
3 4.36 3 NC 25 4.38
4 0 4 NC 26 4.38
5 4.36 5 NC 27 4.38
6 4.36 6 NC 28 4.38
7 4.36 7 4.33 29 4.38
8 8.76 8 4.33 30 4.38
9 4.33 31 NC
10 4.33 32 NC
11 4.33 33 NC
12 4.35 34 NC
13 4.33 35 4.38
14 4.39 36 4.38
15 0 37 4.38
16 4.8 38 4.38
17 NC 39 4.38
18 3.65 40 4.38
19 0 41 NC
20 0.5 42 NC
21 0.5 43 NC
22 8.77 44 NC
AM
IC202
CD
CD
Page 20
IC302
TO CONTENTS
TO SCHEMATIC
1 0 14 3.4
2 0 15 3.3
3 6.7 16 3.5
4 4.9 17 6.7
5 6.6 18 0
6 13.7 19 6.7
7 6.7 20 13.8
8 0 21 6.6
9 6.7 22 8.5
10 8.2 23 6.7
11 3.4 24 0
12 3.3 25 NC
13 0
IC401 IC402
1 2.4 21 2.3 41 2.4 61 4.8 1 4.7
2 2.4 22 2.3 42 2.4 62 4.8 2 0
3 2.4 23 2.4 43 2.4 63 4.8 3 0
4 2.4 24 2.3 44 2.4 64 4.8 4 1.8
5 2.4 25 2.4 45 2.4 65 0
6 2.4 26 2.3 46 2.4 66 0
7 2.4 27 2.3 47 2.4 67 0
8 2.4 28 2.3 48 2.4 68 0
9 2.4 29 2.4 49 2.4 69 0
10 2.4 30 2.4 50 2.4 70 4.8
11 2.3 31 2.4 51 2.4 71 3.1
12 2.3 32 2.4 52 2.3 72 1.5
13 2.3 33 2.4 53 2.3 73 0
14 2.4 34 2.3 54 2.3 74 0
15 2.3 35 2.3 55 2.3 75 3.8
16 2.3 36 2.3 56 2.3 76 4.5
17 2.3 37 2.4 57 2.3 77 4.8
18 2.3 38 2.4 58 2.3 78 0.7
19 2.3 39 2.4 59 2.4 79 0.2
20 2.3 40 2.4 60 4.8 80 1.3
IC601-1
1 4.86 16 NC 31 0
2 4.86 17 0 32 4.92
3 1.93 18 0 33 0
4 1.31 19 4.63 34 4.93
5 0.70 20 NC 35 4.91
6 0.27 21 NC 36 4.92
7 4.88 22 0 37 4.93
8 NC 23 4.92 38 2.60
9 4.93 24 4.92 39 2.34
10 4.93 25 4.33 40 0
11 4.89 26 4.82 41 NC
12 4.93 27 0 42 0
13 4.83 28 0 43 4.91
14 0 29 4.92 44 4.94
15 NC 30 NC 45 4.93
CD
CD
Page 21
IC601-2
TO CONTENTS
TO SCHEMATIC
46 NC 66 4.92 86 NC
47 4.94 67 0/4.9 87 NC
48 0 68 3.23 88 NC
49 4.94 69 4.91 89 NC
50 4.94 70 4.78 90 NC
51 4.93 71 NC 91 NC
52 4.93 72 NC 92 NC
53 4.79 73 PS 93 NC
54 2.41 74 PS 94 NC
55 4.37 75 NC 95 NC
56 0 76 4.57 96 NC
57 0 77 3.81 97 NC
58 3.0 78 NC 98 NC
59 NC 79 4.88 99 4.9
60 0 80 4.84 100 0
61 0 81 4.92
62 NC 82 0
63 NC 83 0
64 4.93 84 0
65 4.9 85 4.92
IC651 IC652
1 0 11 0 1 4.91
2 0 12 0 2 4.92
3 0 13 0 3 0
4 3.8 14 NC 4 NC
5 4.86 15 NC 5 0
6 2.7 16 4.95
7 0 17 14.35
8 0 18 0
9 0 19 0
10 0 20 0
FAN OFF/ON
CD
CD
CD
AM
Page 22
Pin No. 12345
TO CONTENTS
TO SCHEMATIC
Q075
Q077 NC 4.84 4.95 8.41 0
Q112 NC 14.22 14.24 4.91 0
Q604 NC 4.87 4.93 4.87 0
Q651 NC 4.94 4.95 4.86 0
Q652 NC 4.93 4.94 6.1 0
Q804
Q866 0 14.16 14.25 4.71 0
NC
NC
8.41 8.43 4.88 0
1.74 8.44 0 0
0140 0
14 14 4.5 0
NOTE
FM
AM
A-MUTE OFF
A-MUTE ON
FAN ON
Pin No. E B C
Q074
Q111 14.32 13.92 7.54
Q201 0 0 3.64
Q202 0 0 0
Q203 0 0 0
Q204 0 0 0
Q205 0 0 0
Q206 0 0 0
Q207 0 0 0
Q300 0 0 3.98
Q601 4.95 4.93 0
Q605 0 0 4.64
Q606 4.87 4.86 0
Q607 0 1.62 0
Q610 0 0 8.3
Q611 0 0 0
Q612 0 0 4.94
Q664 4.9 4.9 0
Q800 9.36 14.25 8.75
Q801 13.53 14.2 14.27
Q802 13.52 14.19 14.17
Q805 0 4.82 0
Q807 9.51 14.23 8.88
Q809 0 4.85 0
Q810
Q867 9.54 14.25 8.91
8.41 8.29 0.31
8.41 7.67 8.35
0 4.9 0
0 0 4.9
NOTE
FM
AM
CD
A-MUTE OFF
A-MUTE ON
[Measuring Conditions]
1.Power Supply Voltage : DC14.4V
2.Measuring Meter : Digital Multi Meter
3.Measuring Point Reference : Between GND
4.Measuring Condition : FM : 98.1MHz
MW : 999KHz
LW : 216KHz
CD : at playing Disc
Page 23
(CD Deck Mechanism)
TO CONTENTS
TO SCHEMATIC
IC201
1 0 16 0 31 0 or 5
2 0 17 5 32 0 or 5
30 185 330
4 0 19 5 34 0-5
5 0 20 0 35 0-5
6 5 21 5 36 0-5
70 220 370
8 0 23 0 or 5 38 5
9 0 24 0-5 39 0
10 0 25 5 40 0-5
11 0 26 0-5 41 0-5
12 0 27 0-5 42 5
13 0 28 0-5 43 5
14 - 29 0 44 5
15 - 30 0-5
NOTE : - : indefinite voltage
1 0 35 0-5 69 NC
2 5 36 NC 70 5
3 5 37 0 71 0.5-4.5
4 0-5 38 NC 72 2.5
5 0-5 39 0 73 3
6 0-5 40 5 74 RF signal
7 0-5 41 NC 75 RF signal
8 0-5 42 NC 76 RF signal
9 0 43 NC 77 RF signal
10 5 44NC 78NC
11 5 45 0 79 RF signal
12 - 46 NC 80 2.5
13 0 47 NC 81 0
14 2.5 48 0 82 about 2.8
15 0 49 0 83 NC
16 - 50 NC 84 about 2.8
17 5 51 5 85 NC
18 NC 52 NC 86 about 2.9
19 NC 53 NC 87 about 2.9
20 NC 54 0 88 5
21 NC 55 0 89 2.5
22 5 56 0 90 about 2.5
23 - 57 0 91 about 2.5
24 - 58 0 92 about 2.5
25 0 59 0 93 about 2.5
26 5 60 NC 94 about 2.5
27 NC 61 0 95 about 2.5
28 NC 62 2.5±2.5 96 0
29 0-5 63 2.5±2.5 97 0.17
30 0-5 64 2.5±2.5 98 31 0-5 65 2.5±2.5 99 0
32 0-5 66 NC 100 5
33 0-5 67 NC
34 0-5 68 NC
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
IC301
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
repeat of H to L
NOTE : - : indefinite voltage
Page 24
IC302
TO CONTENTS
TO SCHEMATIC
17 10152 7 or 5 2 2.5 16 3 0 3 about 2.5 17 4 1.4 4 about 2.5 18 5 5 5 2.5 19 0
6 about 2.5 20 2.5
7 about 2.5 21 5
8 7 22 about 2.5
9 0 23 about 2.5
10 0 24 2.5
11 - 25 about 2.5
12 - 26 about 2.5
13 - 27 2.5
14 - 28 0
NOTE : - : indefinite voltage
IC401
Q301
B 3.9 B 0-5
C 2.4 C 0-2.5
E 4.5 E 0
[Measuring Conditions]
1. Power Supply Voltage : DC14.4V
2. Measuring Meter : Digital Multi Voltmeter
3. Measuring Point Reference : Between GND
4. Measuring Condition : at playing disc
Q401
repeat of H to L
repeat of H to L
Page 25
Description of IC Terminal
TO CONTENTS
TO SCHEMATIC
D784216AGF : IC601
No. Symbol I/O Terminal Description
1 ENCODER1
2 ENCODER2
3 LCD RST O RESET signal output terminal to LCD Driver (PT6583LQ).
4 LCD DI O Serial Data signal output terminal to LCD Driver (PT6583LQ).
5 LCD CE O Chip Enable signal output terminal to LCD Driver (PT6583LQ).
6 LCD CLK O Serial Clock signal output terminal to LCD Driver (PT6583LQ).
7 LCD DO I Serial Data signal input terminal from LCD Driver (PT6583LQ).
8 NC - No connect terminal.
9 VDD - Power supply terminal.
10 POWER-IC ON O STBY CONT signal output terminal to Power IC.
11 NOSE POWER O Power supply control signal output terminal of LCD Driver and Remote Control.
12 BL-LCD ON O Power supply control signal output terminal of LCD backlighting.
13 POWER CONT O Power supply control signal output terminal of Audio and Key lighting.
14 NC(PULL-DOWN) - Pull-down connect terminal.
15
16
17 GAIN SEL I Sub-W output GAIN set up input terminal.
18 V-CONT O Power supply control signal output terminal of Servo/Mechanism.
19 REMOCON I Remote Control Data input terminal.
20
21
22 Vpp - Flash Memory writing terminal.
23 SCL O Serial Clock signal output terminal to TUNER.
24 SDA I/O Serial Data signal input/output terminal to TUNER.
25 RDS SCL O RDS Clock output terminal from RDS Decoder (SAA6588T).
26 RDS SDA I/O RDS Data input/output terminal to RDS Decoder (SAA6588T).
27 E.VOL SCL O Serial Clock signal output terminal to E.VOL (TDA7412).
28 E.VOL SDA I/O Serial Data signal input/output terminal to E.VOL (TDA7412).
29 AUTO ADJ I Auto adjustment control signal input terminal. (L : Auto adjustment)
30 NC - No connect terminal.
31 LCD SEL(PULL-DOWN) - Pull-down connect terminal.
32 CD STBY O Stand-by control signal output terminal of Mechanism u-COM.
33 0 MUTE-DET I 0-bit MUTE signal input terminal.
34 CD RST O RESET signal output terminal of Mechanism u-COM.
35 CD CS O Communication control signal output terminal of Mechanism u-COM.
36 V-Link SEL I V-Link set up input terminal.
37 VDD - Power supply terminal.
38 X2
39 X1
40 GND 41 XT2(NC) - No connect terminal.
42 XT1(GND) 43 RESET I System RESET signal input terminal.
44 BATT DET I BATT detect signal input terminal. (Compulsion Stand-by)
45 ACC DET I ACC (IGNITION) detect signal input terminal.
46 NC - No connect terminal.
NC - No connect terminal.
NC - No connect terminal.
I Encoder Data input terminal.
- Main System Clock OSC input terminal. (12.288MHz)
GND connect terminal.
GND connect terminal.
Page 26
No. Symbol I/O Terminal Description
TO CONTENTS
TO SCHEMATIC
47 CHG BUS IN I Signal input terminal from CD CHANGER BUS I/F.
48 CHG BUS OUT O Signal output terminal to CD CHANGER BUS I/F.
49 DISC IN SW I DISC insert detect SW input terminal.
50 CD SRQ I Communication request signal input terminal from Mechanism u-COM.
51 AVDD - Analog power supply terminal of A/D Converter.
52 AVREF 0 - Standard voltage input terminal of A/D Converter.
53 HI-TEMP I Temperature sensor signal (Thermistor) input terminal for CD.
54 NOSE ON I FRONT Panel detect signal input terminal.
55 S-METER I Signal Meter input terminal.
56 MULTIPATH I Multipath rejection detect terminal of receiving station.
57 ADJCH I Adjoining channel signal input terminal.
58 AFC I AFC signal input terminal.
59 NC(PULL-DOWN) - Pull-down connect terminal.
60 45W/60W SEL I 45W/60W set up input terminal.
61 AVSS - GND terminal of A/D Converter.
62
63
64 AVREF 1 - Standard voltage input terminal of A/D Converter.
65 RDS MONI RxD I Serial Data input terminal from RDS Monitor Soft (P/C).
66 RDS MONI TxD O Serial Data output terminal to RDS Monitor Soft (P/C).
67 FAN-CONT O FAN control signal output terminal. (H : FAN ON, L : FAN OFF)
68
69
70
71
I
75
76 AM SD I AM SD signal input terminal.
77 SSTOP I Seek Stop signal input terminal of TUNER.
78 NC - No connect terminal.
79 FM/AM O FM/AM power switching signal output terminal. (H : FM, L : AM)
80 DAVN I Available input terminal of RDS Decoder (SAA6588T).
81 RDS CONT O
82 IF MUTE O High Speed MUTE signal output terminal at AF SW.
83 ENCODER SEL(NC) - No connect terminal.
84 IN-INT I Outernal AUDIO signal input terminal.
85 OUT REM ON(NC)
86
I
98
99 A-MUTE O AUDIO MUTE signal output terminal. (L : MUTE ON)
100 GND - GND connect terminal.
NC -
CD STS I Status signal input termminal from Mechanism u-COM.
(RXD1) - (Flash-Pro II connect terminal by UART format.)
CD CMD O Command output terminal to Mechanism u-COM.
(TXD1) - (Flash-Pro II connect terminal by UART format.)
CD SCK O Serial Clock output terminal to Mechanism u-COM.
(ASCK1) - (Flash-Pro II connect terminal by UART format.)
NC
No connect terminal.
- No connect terminal.NC
MPX MUTE signal output terminal to RDS Decoder (SAA6588T) at FM adjoining
rejection.
- No connect terminal.
Page 27
D789026GB : IC201
(
)
TO CONTENTS
TO SCHEMATIC
No. Symbol I/O Terminal Description
1 SW-D I SW-D input terminal for mechanism control.
2 SW-C I SW-C input terminal for mechanism control.
3 SW-B I SW-B input terminal for mechanism control.
4 LODM5 LODM+
6 DR MUTE O Driver IC Mute control output terminal.
7
I
12
13 VPP - Pull-down connect terminal.
14 X2
15 X1
16 VSS0 - GND connect terminal.
17 VDD0 - VDD connect terminal.
18 /RESET I Host I/F RESET signal input terminal.
19 S-CONT O Servo power supply control output terminal.
20 NC(GND) - GND connect terminal.
21 SW-A I SW-A input terminal for mechanism control.
22 NC(GND) - GND connect terminal.
23 L-ZERO I DSP L-ch 0 data signal input terminal.
24 /CS I Host I/F communication start/end signal input terminal.
25 /STBY I Host I/F STBY signal input terminal.
26 CMD I Host I/F command input terminal.
27 STS O Host I/F status output terminal.
28 SCK I Clock input terminal for Host I/F communication.
29 NC(GND) - GND connect terminal.
30 /SRQ O Host I/F status request signal output terminal.
31 R-ZERO I DSP R-ch 0 data signal input terminal.
32 ZMUTE O Host I/F 0 data signal output terminal.
33 /XTALEN O DSP crystal OSC control output terminal.
34 SI O DSP serial data output terminal.
35 SO I DSP serial data/status signal input terminal.
36 /SCK O Clock output terminal for DSP serial data.
37 NC(GND) - GND connect terminal.
38 VDD1 - VDD connect terminal.
39 VSS1 - GND connect terminal.
40 /STB O DSP data strobe signal output terminal.
41 AO O DSP command/parameter discrimination signal output terminal.
42 /RST O DSP RESET signal output terminal.
43 RFOK I DSP RFOK signal input terminal.
44 LIMIT SW I LIMIT-SW input terminal.
NC(GND) - GND connect terminal.
DP23S2A0
O Loading Motor control output terminal.
- Crystal OSC connect terminal. (4.19MHz)
Page 28
Exploded View (Cabinet)
TO CONTENTS
TO PARTS LIST
6
X2
28
30
17
17
X2
17
A
2
RCA201
F
18
ANT001
27
19
G
20
8
1
34
32
31
LCD401
SW421
CH401
35
33
29
27
CB601
12
15
23
12
JK201
CB801
E
24
G
24
C
12
F
14
X2
D
DIN001
22
6
9
X4
D
E
9
X2
13
M802
B
JK601
16
4
5
6
6
C
A
10
7
B
6
3
11
6
Page 29
Exploded View (CD Deck Mechanism)
TO CONTENTS
TO PARTS LIST
(DP23S2AO)
31
33
30
41
78
32
67
D
SW105
66
56
A
63
P
40
38
H
X2
57
X2
91
C
77
74
81
39
37
36
19
27
20
24
25
45
L
P
HD101
43
44
26
51
J
K
61
L
46
H
B
L
M103
34
23
X3
62
L
K
D
N
21
28
22
29
M102
53
29
52
68
A
M
J
G
48
47
F
F
59
E
50
M
N
60
58
90
67
X2
65
2
42
6
7
64
E
SW1
SW2
8
69
C
B
72
49
G
54
67
55
67
SW3
4
3
85
64
79
88
87
86
1
75
6
5
84
83
82
89
13
12
X2
67
X2
10
9
M101
11
SW4
Page 30
CDM-9805R
Cabinet Assembly Parts List
Note : The part that has not PART NUMBER will not be supplied.
1 01V64600Y26 ASSY,NOSE UNIT 05RN
2 - - - - - - - - - - COVER,TOP
3 - - - - - - - - - - CHAS,BASE
4 14B02859K01 INSULATOR,MAIN
5 13C02811K01 NOSE,BASE ASSY
6 03S44205G29 SCR,T-TITE M2.6X6
7 33C01797K01 FACE,PLATE
8 - - - - - - - - - - HEAT,SINK(SW)
9 03S38013W 02 SCR,T-TITE M2.6X14
10 07D00749K01 BKT,SIDE L
11 07D00749K02 BKT,SIDE R
12 03T25225Y01 SCR,GND
13 03S68555F30 SCR,WAVE M2.6X10
14 03S71677F05 SCR,T-TITE-B M3X8
15 75T25010Y33 CUSHION,SHLD5-5.5-25
16 41A03685K01 SPRING,SHIELD
17 03S44205G07 SCR,T-TITE M2.6X5
18 81D50617Y01 DP23S2AO,CD MECH
19 30T03013K03 SMCD22X120BDX6(BL)M
20 75S40755Y78 CUS,RUB 11X5XT4.5
22 - - - - - - - - - - BKT,CHAS REAR(SW )
23 77B50886Y01 MB4R002Z FM/AM UNIT(TU002)
24 09T84840F01 LUG,STYLE 18MM
27 03S71677F56 SCR,B-TITE M1.7X12
28 13D02847K05 NOSE,PIECE ASSY(L)
29 13D02810K01 NOSE,BOTTOM
30 36B02841K01 KNOB,ROTARY ASSY
31 75S40755Y94 CUS,RUB 10X2XT3
32 15B01768K01 COVER,LCD
33 26A41975Y01 REFLECTOR,SHEET
34 75T03213K02 RUBBER,ELECTRIC
35 15D01770K01 CASE,LCD ASSY
Page 31
CDM-9805R
CD Deck Mechanism Assembly Parts List
Note : The part that has not PART NUMBER will not be supplied.
1 01V43800Y84 ASSY,ARM GUIDE 280
2 - - - - - - - - - - CHASSIS,TOP
3 45B11564Y02 LEVER,LINK-TOP
4 45B11595Y02 LEVER DISC(R)
5 45B11596Y02 LEVER,DISC(L)
6 41B11613Y16 SPRING,PULL
7 15D50248Y01 GUIDE,TOP-DPS2
8 75A21286Y04 CUSHION,CLAMPER DPS2
9 07C50608Y01 BKT,MOTOR LOAD-P
10 03S40014G07 SCR,MCH M2X4
11 44B11578Y02 GEAR,(A)
12 44B11579Y02 GEAR,(B)
13 44B11580Y02 GEAR,(C)
19 27D11602Y04 CHASSIS,PICKUP
20 47A11575Y01 SHAFT,PICK
21 01V28100Y59 ASSY,SHAFT.SCREW
22 44A70590W03 GEAR,MIDDLE
23 03S72235F96 SCR,MCH M1.7X3.5(SW)
24 07B30337Y02 BKT,SPRING NUT
25 41A11606Y02 SPRING NUT
26 03S94385F18 SCR,NYLON M2X3.5
27 84T01803K01 PANEL,FPC CONT
28 41B11566Y02 SPRING,SHAFT
29 03S70494F13 SCR,P-TITE M2X6 BLK
30 - - - - - - - - - - ASSY,RIV.ARM CLAMP
31 - - - - - - - - - - LEVER,LOCK
32 07A11565Y02 PLATE,CLAMP
33 03S94385F01 SCR,NYLOK M1.7X2.3
34 43A41812Y02 TABLE,CLAMPER2
36 - - - - - - - - - - SLIDER DISC
37 45A11599Y02 LEVER,ACTUATOR
38 41B11613Y03 SPRING,PULL
39 41B11613Y05 SPRING,LEV-ACT
40 41A11609Y01 SPRING,LEVER
41 41B40574Y02 SPRING,PLATE-S
42 41B11613Y15 SPRING,PULL
43 41A11040Y02 SPRING,SLED-HOE
44 03S70494F52 SCR,P-TITE M1.4X4.5
45 43A21240Y01 SHEET,FPC PICK
46 - - - - - - - - - - ASSY,RIV CHAS BASE
47 45B40510Y02 SLIDER,LOAD
48 44B40527Y02 RACK
49 45A11601Y02 LEVER,TRIGER
50 44B11581Y02 GEAR,(D)
51 45B11594Y02 SLIDER,LOCK(L)
52 45A11592Y02 ARM,LOCK(L2)
53 03A11574Y01 SCREW,LOCK
54 45B11591Y02 ARM,LOCK(L1)
55 07A50606Y01 BKT,MOTOR WIRE-P
56 45B11593Y02 SLIDER,LOCK(R)
57 45B11607Y02 ARM,LOCK(R)
58 45A11597Y02 LEVER,SW
59 41B11613Y04 SPRING,TRIGER
60 75C30466Y04 DAMPER,DPS2
61 41B11613Y06 SPRING,PULL
62 41B11613Y07 SPRING,PULL
63 41B11613Y08 SPRING,PULL
64 41A40518Y01 SPRING,ROL
65 41A31894Y02 SPRING,SLIDER
66 - - - - - - - - - - BKT,SP-TOP
67 03A21791Y01 SCREW,M2X3.5 S-TITE
68 07B20905Y02 BKT,FPC CONT
69 30T15126W15 WIRE,PC JOINT 7P
72 41A21613Y02 SPRING,SPINDLE
74 14A30831Y01 INS,CVR
75 43A31443Y01 ROLLER,ARM DISC (C)
77 75C30466Y05 DAMPER,DPS2
78 41B11613Y14 SPLING,PULL
79 04B41345P52 WASH,1.6X3.5X0.25
81 75A21286Y02 CUSHION,CLAMPER BACK
82 44B40523Y02 GEAR,BASE
83 04A40528Y01 WASHER,FELT
84 44A40524Y02 GEAR,CLUTCH
85 41A40529Y01 SPRING,CLUTCH
86 44A40525Y02 GEAR,PINION
87 15A40526Y02 HOLDER,CLUTCH
88 43A41446Y02 SLEEVE,CLUTCH
89 04B41345P25 WASH,L. 3.1X6X0.35
90 03S44205G99 SCR,T-TITE M2X3
91 75A21286Y05 CUSHION,PWB
Page 32
CDM-9805R
Electrical Parts List
*******MAIN P.W.Board
=======IC's
IC010 51T15132Y02 SAA6588T -SE9
IC011 51T25259Y01 BA00AST -IS
IC012 51T93333F01 NJM2904M-TE3 -SE2
IC013 51T15731W10 TC7S66F-TE85L -CP
IC101 51T15510W01 IC ,MC34063AML -SPD
IC201 51T15420Y01 BA4560F-E2 -SE2
IC202 51T65381Y01 TDA7412 -QT
IC203 51T15420Y01 BA4560F-E2 -SE2
IC302 51T45409Y01 TA8263BH -ZS
IC601 51T65272Y01 IC,D784216AGF-532-QT
IC651 51T95193W01 TDA3606AT -SE9
IC652 51T65016Y19 S-80930CNMC-T2 -CP
=======Transistors
Q074 48T63420F01 TR,2SA1037AK-146 -CP
Q075 48T73888F13 TR ,CP FMC3-99
Q077 48T73888F13 TR ,CP FMC3-99
Q111 48T15511W02 CP.2SB1261-TE2 -E5
Q112 48T73888F12 TR ,CP.FMC2-99
Q201 48T62967F03 TR,DTC124EKA-T146-CP
Q202 48T62967F33 TR,DTC343TK-T146 -CP
Q203 48T62967F33 TR,DTC343TK-T146 -CP
Q204 48T62967F33 TR,DTC343TK-T146 -CP
Q205 48T62967F33 TR,DTC343TK-T146 -CP
Q206 48T62967F33 TR,DTC343TK-T146 -CP
Q207 48T62967F33 TR,DTC343TK-T146 -CP
Q300 48T62967F03 TR,DTC124EKA-T146-CP
Q601 48T62966F03 TR,DTA124EKA-T146-CP
Q604 48T73888F13 TR ,CP FMC3-99
Q605 48T62967F02 TR,DTC114EKA-T146-CP
Q606 48T63420F01 TR,2SA1037AK-146 -CP
Q607 48T62967F02 TR,DTC114EKA-T146-CP
Q610 48T62967F03 TR,DTC124EKA-T146-CP
Q611 48T62967F02 TR,DTC114EKA-T146-CP
Q612 48T62967F03 TR,DTC124EKA-T146-CP
Q651 48T73888F12 TR ,CP.FMC2-99
Q652 48T73888F12 TR ,CP.FMC2-99
Q664 48T62966F01 TR,DTA143EKA-T146-CP
Q800 48T69176F02 TR ,2SC3421-Y
Q801 48T84366F04 TR,2SB1243-QR-TV2-RD
Q802 48T84366F04 TR,2SB1243-QR-TV2-RD
Q804 48T73888F12 TR ,CP.FMC2-99
Q805 48T62967F05 TR,DTC143XKA-T146-CP
Q807 48T93828F04 TR,2SD1994A-S-TA -RD
Q809 48T62967F01 TR,DTC143EKA-T146-CP
Q810 48T62967F03 TR,DTC124EKA-T146-CP
Q866 48T73888F12 TR ,CP.FMC2-99
Q867 48T93828F04 TR,2SD1994A-S-TA -RD
=======Diodes
D002 48T85357W01 DIO,1PS226 -CP
D305 48T02162K01 DIO,SHT SRT14 -A5
D306 48T02162K01 DIO,SHT SRT14 -A5
D307 48T02162K01 DIO,SHT SRT14 -A5
D308 48T02162K01 DIO,SHT SRT14 -A5
D313 48T02162K01 DIO,SHT SRT14 -A5
D314 48T02162K01 DIO,SHT SRT14 -A5
D315 48T02162K01 DIO,SHT SRT14 -A5
D316 48T02162K01 DIO,SHT SRT14 -A5
D601 48T68828F01 DIO,1SS133 -A5
D602 48T63462F01 DIO,CP.DAN202K -96
D653 48T68828F01 DIO,1SS133 -A5
D662 48T63462F01 DIO,CP.DAN202K -96
D800 48T68828F01 DIO,1SS133 -A5
D802 48T85270W01 DIO,MPG06G -A5
SD100 48T85269W01 DIO,SHT SB040 -A5
SD600 48T68580F03 DIO,SI DSA3A4-F5
ZD401 48T62934F26 DIO,ZEN.RD6.2MB3 -CP
ZD451 48T15541Y23 DIO,ZEN MAZS180 -CP
ZD452 48T15541Y23 DIO,ZEN MAZS180 -CP
ZD652 48T83128F14 DIO,ZEN HZS 7B2L -A5
ZD800 48T83128F25 DIO,ZEN.HZS 9C1L -A5
ZD803 48T83128F26 DIO,ZEN.HZS 9C2L -A5
ZD804 48T25766W25 DIO,ZEN.HZS 9C2L -R5
=======Coils
L002 24T25164Y21 IND,FSLM2520 4R7J-CP
L003 24T16403W29 COI,IND.15R-M -CP
L004 24T35286Y01 IND,MG56 523J -DB
L005 24T25164Y21 IND,FSLM2520 4R7J-CP
L101 24T16271W13 COIL,RCR875D-221K
L600 24T65053W18 IND,LAL02VD 4R7K -R5
L602 24T65053W18 IND,LAL02VD 4R7K -R5
L603 25T01879K01 CHOKE,LAT1608-105-DB
Z301 24T35072W03 FBI,BL02RN1R2P1A -R5
Z302 24T35072W03 FBI,BL02RN1R2P1A -R5
=======Crystals
XL002 91T25806W18 XTL,4.332M -AT51-TP
XL601 91T55360Y03 XTL,AT-51 12.288M-R5
=======Filter
CF002 91T75257W02 LPF,LPF11830KH-3C-DB
=======Poly Switch
PS001 48T95226W01 TMT,PTGL05BA1R8M1-R5
=======Surge Protector
SA002 48T81909F01 PTT,DSP-201M -A1
=======Switch
SW601 40T16096W03
=======Thermistor
TH601 48T93439F06 TMT, 104 -R2
=======Capacitors
C001 08S45677W60 CAP,CER 102J-CH1H-CP
C071 08S45677W54 CAP,CER 561J-CH1H-CP
C072 08S45676W85 CAP,CER 104K-B1C -CP
C073 08S45676W65 CAP,CER.222K-B1H -CP
C074 08S45677W36 CAP,CER.101J-CH1H-CP
C075 08S45676W85 CAP,CER 104K-B1C -CP
SW ,TACT SKHHLW
(RESET)
Page 33
CDM-9805R
C076 08S45677W48 CAP,CER.331J-CH1H-CP
C077 08S45676W80 CAP,CER 223K-B1E -CP
C078 08S45676W65 CAP,CER.222K-B1H -CP
C079 08S45676W73 CAP,CER.103K-B1H -CP
C080 08S45676W73 CAP,CER.103K-B1H -CP
C081 08S45676W73 CAP,CER.103K-B1H -CP
C082 08S45676W80 CAP,CER 223K-B1E -CP
C083 08S45677W42 CAP,CER.181J-CH1H-CP
C084 08S45677W22 CAP,CER.27RJ-CH1H-CP
C085 08S45677W22 CAP,CER.27RJ-CH1H-CP
C086 08S45677W36 CAP,CER.101J-CH1H-CP
C087 08S45677W36 CAP,CER.101J-CH1H-CP
C089 08S45677W60 CAP,CER 102J-CH1H-CP
C090 08S45676W89 CAP,CER 473K-B1E -CP
C091 08S45676W73 CAP,CER.103K-B1H -CP
C092 08S45676W80 CAP,CER 223K-B1E -CP
C093 08S45676W80 CAP,CER 223K-B1E -CP
C094 08S45676W73 CAP,CER.103K-B1H -CP
C095 08S45676W85 CAP,CER 104K-B1C -CP
C096 08S45677W36 CAP,CER.101J-CH1H-CP
C101 08S45676W67 CAP,CER.332K-B1H -CP
C115 08S45676W67 CAP,CER.332K-B1H -CP
C116 08S45676W80 CAP,CER 223K-B1E -CP
C117 08S45676W63 CAP,CER 152K-B1H -CP
C118 08S45677W38 CAP,CER 121J-CH1H-CP
C119 08S60102F48 CAP,CER 105K-B1E -CP
C120 08S45676W80 CAP,CER 223K-B1E -CP
C200 08S60102F48 CAP,CER 105K-B1E -CP
C201 08S45676W74 CAP,CER 123K-B1H -CP
C202 08S45676W85 CAP,CER 104K-B1C -CP
C203 08S45677W60 CAP,CER 102J-CH1H-CP
C204 08S45676W85 CAP,CER 104K-B1C -CP
C205 08S45677W36 CAP,CER.101J-CH1H-CP
C207 08S45676W84 CAP,CER 683K-B1C -CP
C220 08S45677W60 CAP,CER 102J-CH1H-CP
C307 08T35122W17 CAP,MMTS-224-J -R5
C308 08T35122W17 CAP,MMTS-224-J -R5
C309 08T35122W17 CAP,MMTS-224-J -R5
C310 08T35122W17 CAP,MMTS-224-J -R5
C311 08S45676W93 CAP,CER 224K-B1A -CP
C312 08S45676W89 CAP,CER 473K-B1E -CP
C313 08S45677W60 CAP,CER 102J-CH1H-CP
C501 08S45677W60 CAP,CER 102J-CH1H-CP
C602 08S65128F78 CAP,CER.223K-B1H -CP
C603 08S45676W65 CAP,CER.222K-B1H -CP
C604 08S35374W01 CAP,CER 104K-B1E-CP
C605 08S65128F90 CAP,CER 473K-B1H -CP
C606 08S65128F88 CAP,CER 104K-B1H -CP
C607 08S45676W73 CAP,CER.103K-B1H -CP
C608 08S45677W18 CAP,CER.18RJ-CH1H-CP
C609 08S45677W18 CAP,CER.18RJ-CH1H-CP
C610 08S45677W48 CAP,CER.331J-CH1H-CP
C611 08S45676W80 CAP,CER 223K-B1E -CP
C612 08S45677W36 CAP,CER.101J-CH1H-CP
C618 08S60102F44 CAP,CER 474K-B1E -CP
C628 08S45676W85 CAP,CER 104K-B1C -CP
C652 08S45676W80 CAP,CER 223K-B1E -CP
C653 08S45676W85 CAP,CER 104K-B1C -CP
C662 08S45677W60 CAP,CER 102J-CH1H-CP
C800 08S45539Y04 CAP,CER 103KX7R2J-CP
C801 08S45539Y04 CAP,CER 103KX7R2J-CP
C802 08S45676W80 CAP,CER 223K-B1E -CP
C803 08S45539Y04 CAP,CER 103KX7R2J-CP
C804 08T35122W13 CAP,MMTS-104-J -R5
C805 08S35374W01 CAP,CER 104K-B1E-CP
C806 08S35374W01 CAP,CER 104K-B1E-CP
E012 23S75373W14 CAP,ELY 2R2-1H -R2
E013 23S75372W03 CAP,ELY 221-1A -H2
E014 23S75373W03 CAP,ELY 22R-1C -R2
E015 23S75373W03 CAP,ELY 22R-1C -R2
E016 23S75373W03 CAP,ELY 22R-1C -R2
E017 23S75373W03 CAP,ELY 22R-1C -R2
E018 23T15765Y88 CAP,TAN 10R-1E-E -E1
E019 23S95415W07 CAP,ELY 221-1C -R2
E100 23T55378W03 CAP,KMG 471-1A -R2
E101 23S75373W06 CAP,ELY 101-1C -R2
E207 23S75373W02 CAP,ELY 10R-1C -R2
E208 23S75373W03 CAP,ELY 22R-1C -R2
E209 23S75372W15 CAP,ELY 1R0-1H -R2
E210 23S75372W15 CAP,ELY 1R0-1H -R2
E211 23S75373W13 CAP,ELY 1R0-1H -R2
E212 23S75373W13 CAP,ELY 1R0-1H -R2
E213 23S75373W13 CAP,ELY 1R0-1H -R2
E214 23S75373W13 CAP,ELY 1R0-1H -R2
E215 23S75373W03 CAP,ELY 22R-1C -R2
E216 23S75372W04 CAP,ELY 10R-1C -R2
E217 23S75372W15 CAP,ELY 1R0-1H -R2
E218 23S75372W05 CAP,ELY 22R-1C -R2
E232 23S75372W16 CAP,ELY 2R2-1H -R2
E233 23S75372W16 CAP,ELY 2R2-1H -R2
E234 23S75372W16 CAP,ELY 2R2-1H -R2
E235 23S75372W16 CAP,ELY 2R2-1H -R2
E236 23S75372W16 CAP,ELY 2R2-1H -R2
E237 23S75372W16 CAP,ELY 2R2-1H -R2
E305 23S75372W04 CAP,ELY 10R-1C -R2
E306 23S75372W04 CAP,ELY 10R-1C -R2
E307 23S75372W04 CAP,ELY 10R-1C -R2
E308 23S75372W04 CAP,ELY 10R-1C -R2
E309 23S95415W14 CAP,ELY R22-1H -R2
E310 23S95415W03 CAP,ELY 10R-1C -R2
E311 23S95415W13 CAP,ELY R10-1H -R2
E312 23S95415W17 CAP,ELY 1R0-1H -R2
E313 23T75346W03 CAP,X-PRO 332-1C +
E601 23S75372W05 CAP,ELY 22R-1C -R2
E602 23S75372W03 CAP,ELY 221-1A -H2
E651 23S75373W04 CAP,ELY 33R-1C -R2
E805 23S75372W15 CAP,ELY 1R0-1H -R2
E806 23S75372W03 CAP,ELY 221-1A -H2
E807 23S75373W04 CAP,ELY 33R-1C -R2
E808 23S75373W06 CAP,ELY 101-1C -R2
E809 23S75373W06 CAP,ELY 101-1C -R2
E810 23S75372W07 CAP,ELY 47R-1C -R2
E812 23S75372W04 CAP,ELY 10R-1C -R2
=======Resistors
R003 06S45675W43 RES,RK JUMPER1/10-CP
R004 06S45675W43 RES,RK JUMPER1/10-CP
R005 06S45675W43 RES,RK JUMPER1/10-CP
Page 34
CDM-9805R
R006 06S45675W43 RES,RK JUMPER1/10-CP
R013 06S45674W75 RES,RK 562J 1/10 -CP
R014 06S45674W75 RES,RK 562J 1/10 -CP
R015 06S45674W57 RES,RK 102J 1/10 -CP
R017 06S45674W69 RES,RK 332J 1/10 -CP
R018 06S45675W22 RES,RK 474J 1/10 -CP
R020 06S45674W73 RES,RK 472J 1/10 -CP
R021 06S45674W57 RES,RK 102J 1/10 -CP
R022 06S45675W43 RES,RK JUMPER1/10-CP
R023 06S45675W43 RES,RK JUMPER1/10-CP
R024 06S45675W43 RES,RK JUMPER1/10-CP
R025 06S45675W43 RES,RK JUMPER1/10-CP
R026 06S45675W43 RES,RK JUMPER1/10-CP
R027 06S45674W89 RES,RK 223J 1/10 -CP
R028 06S45674W57 RES,RK 102J 1/10 -CP
R029 06S45674W57 RES,RK 102J 1/10 -CP
R030 06S45674W57 RES,RK 102J 1/10 -CP
R031 06S15593Y76 RES,RK 133F 1/10 -CP
R032 06S45675W43 RES,RK JUMPER1/10-CP
R033 06S15593Y57 RES,RK 222F 1/10 -CP
R035 06S45674W57 RES,RK 102J 1/10 -CP
R036 06S45674W57 RES,RK 102J 1/10 -CP
R038 06S45674W49 RES,RK 471J 1/10 -CP
R039 06S45674W49 RES,RK 471J 1/10 -CP
R040 06S45674W57 RES,RK 102J 1/10 -CP
R041 06S45674W81 RES,RK 103J 1/10 -CP
R042 06S45674W81 RES,RK 103J 1/10 -CP
R043 06S45674W09 RES,RK 10RJ 1/10 -CP
R044 06S35095Y08 RES,RK JUMPER 1/4-CP
R046 06S45674W09 RES,RK 10RJ 1/10 -CP
R047 06S70072F05 RES,CP .10R-J-1/4-CP
R050 06S45674W57 RES,RK 102J 1/10 -CP
R103 06S70072F50 RES,CP .751-J-1/4-CP
R104 06S70072F50 RES,CP .751-J-1/4-CP
R105 06S70072F29 RES,CP .101-J-1/4-CP
R106 06S70072F47 RES,CP .561-J-1/4-CP
R107 06S70072F47 RES,CP .561-J-1/4-CP
R108 06S45675W02 RES,RK 683J 1/10 -CP
R109 06S35084Y41 RES,RK 223F 1/8 -CP
R110 06S35084Y33 RES,RK 472F 1/8 -CP
R200 06S45674W90 RES,RK 243J 1/10 -CP
R201 06S45674W58 RES,RK 112J 1/10 -CP
R202 06S45674W58 RES,RK 112J 1/10 -CP
R203 06S45674W58 RES,RK 112J 1/10 -CP
R204 06S45674W58 RES,RK 112J 1/10 -CP
R205 06S45674W77 RES,RK 682J 1/10 -CP
R206 06S45674W65 RES,RK 222J 1/10 -CP
R207 06S45674W95 RES,RK 393J 1/10 -CP
R208 06S45675W22 RES,RK 474J 1/10 -CP
R209 06S45674W57 RES,RK 102J 1/10 -CP
R210 06S45674W57 RES,RK 102J 1/10 -CP
R218 06S64996F39 RES,RK JUMPER 1/8-CP
R219 06S64996F39 RES,RK JUMPER 1/8-CP
R220 06S64996F39 RES,RK JUMPER 1/8-CP
R221 06S64996F39 RES,RK JUMPER 1/8-CP
R222 06S64996F39 RES,RK JUMPER 1/8-CP
R223 06S64996F39 RES,RK JUMPER 1/8-CP
R230 06S55365Y97 RES,RK 223J 1/10 -CP
R231 06S55365Y97 RES,RK 223J 1/10 -CP
R232 06S55365Y97 RES,RK 223J 1/10 -CP
R233 06S55365Y97 RES,RK 223J 1/10 -CP
R234 06S55365Y97 RES,RK 223J 1/10 -CP
R235 06S55365Y97 RES,RK 223J 1/10 -CP
R236 06S45674W33 RES,RK 101J 1/10 -CP
R237 06S45674W33 RES,RK 101J 1/10 -CP
R238 06S45674W33 RES,RK 101J 1/10 -CP
R239 06S45674W33 RES,RK 101J 1/10 -CP
R240 06S45674W33 RES,RK 101J 1/10 -CP
R241 06S45674W33 RES,RK 101J 1/10 -CP
R244 06S45674W97 RES,RK 473J 1/10 -CP
R245 06S45674W97 RES,RK 473J 1/10 -CP
R246 06S45674W97 RES,RK 473J 1/10 -CP
R247 06S45674W97 RES,RK 473J 1/10 -CP
R248 06S45674W97 RES,RK 473J 1/10 -CP
R249 06S45674W97 RES,RK 473J 1/10 -CP
R250 06S45674W33 RES,RK 101J 1/10 -CP
R251 06S45674W33 RES,RK 101J 1/10 -CP
R252 06S45674W33 RES,RK 101J 1/10 -CP
R253 06S45674W33 RES,RK 101J 1/10 -CP
R254 06S45674W33 RES,RK 101J 1/10 -CP
R255 06S45674W33 RES,RK 101J 1/10 -CP
R307 06S70072F77 RES,CP .103-J-1/4-CP
R308 06S45674W81 RES,RK 103J 1/10 -CP
R309 06S45675W43 RES,RK JUMPER1/10-CP
R600 06S45674W97 RES,RK 473J 1/10 -CP
R604 06S45674W89 RES,RK 223J 1/10 -CP
R605 06S45674W97 RES,RK 473J 1/10 -CP
R606 06S45674W57 RES,RK 102J 1/10 -CP
R607 06S45674W81 RES,RK 103J 1/10 -CP
R608 06S64995F77 RES,RK 103J 1/8 -CP
R609 06T45541Y01 RES,RS 12RJ 2W -
R611 06S70072F69 RES,CP .472-J-1/4-CP
R612 06S70072F29 RES,CP .101-J-1/4-CP
R613 06S45674W57 RES,RK 102J 1/10 -CP
R614 06S64995F53 RES,RK 102J 1/8 -CP
R615 06S64995F53 RES,RK 102J 1/8 -CP
R616 06S64995F53 RES,RK 102J 1/8 -CP
R617 06S45674W57 RES,RK 102J 1/10 -CP
R618 06S45675W43 RES,RK JUMPER1/10-CP
R619 06S45674W57 RES,RK 102J 1/10 -CP
R620 06S45674W57 RES,RK 102J 1/10 -CP
R623 06S45674W57 RES,RK 102J 1/10 -CP
R624 06S45674W57 RES,RK 102J 1/10 -CP
R625 06S45674W81 RES,RK 103J 1/10 -CP
R626 06S45674W81 RES,RK 103J 1/10 -CP
R628 06S45674W69 RES,RK 332J 1/10 -CP
R629 06S45674W97 RES,RK 473J 1/10 -CP
R630 06S45674W89 RES,RK 223J 1/10 -CP
R631 06S70072F98 RES,RK 223J 1/4 -CP
R632 06S70072F37 RES,CP .221-J-1/4-CP
R633 06S45674W65 RES,RK 222J 1/10 -CP
R634 06S45674W43 RES,RK 271J 1/10 -CP
R635 06S45674W97 RES,RK 473J 1/10 -CP
R636 06S35095Y03 RES,RK 473J 1/4 -CP
R638 06S45674W83 RES,RK 123J 1/10 -CP
R639 06S45675W43 RES,RK JUMPER1/10-CP
R640 06S45675W22 RES,RK 474J 1/10 -CP
R641 06S70072F98 RES,RK 223J 1/4 -CP
Page 35
CDM-9805R
R642 06S45674W57 RES,RK 102J 1/10 -CP
R644 06S45674W97 RES,RK 473J 1/10 -CP
R645 06S45674W43 RES,RK 271J 1/10 -CP
R646 06S45674W73 RES,RK 472J 1/10 -CP
R647 06S45674W73 RES,RK 472J 1/10 -CP
R649 06S45674W89 RES,RK 223J 1/10 -CP
R650 06S45674W89 RES,RK 223J 1/10 -CP
R651 06S45674W99 RES,RK 563J 1/10 -CP
R654 06S70072F69 RES,CP .472-J-1/4-CP
R655 06S70072F69 RES,CP .472-J-1/4-CP
R656 06S64996F14 RES,RK 334J 1/8 -CP
R657 06S15593Y99 RES,RK 124F 1/10 -CP
R658 06S45675W06 RES,RK 104J 1/10 -CP
R662 06S45674W83 RES,RK 123J 1/10 -CP
R663 06S45674W89 RES,RK 223J 1/10 -CP
R664 06S35095Y03 RES,RK 473J 1/4 -CP
R666 06S45675W43 RES,RK JUMPER1/10-CP
R667 06S45675W43 RES,RK JUMPER1/10-CP
R668 06S45675W43 RES,RK JUMPER1/10-CP
R670 06S45674W89 RES,RK 223J 1/10 -CP
R671 06S45674W89 RES,RK 223J 1/10 -CP
R672 06S45674W57 RES,RK 102J 1/10 -CP
R673 06S45674W81 RES,RK 103J 1/10 -CP
R674 06S15593Y63 RES,RK 392F 1/10 -CP
R675 06S15593Y73 RES,RK 103F 1/10 -CP
R676 06S70072F63 RES,CP .272-J-1/4-CP
R680 06S45674W81 RES,RK 103J 1/10 -CP
R681 06S64995F53 RES,RK 102J 1/8 -CP
R682 06S64995F53 RES,RK 102J 1/8 -CP
R683 06S45674W57 RES,RK 102J 1/10 -CP
R684 06S45674W57 RES,RK 102J 1/10 -CP
R685 06S45674W81 RES,RK 103J 1/10 -CP
R686 06S45674W65 RES,RK 222J 1/10 -CP
R800 06S70072F29 RES,CP .101-J-1/4-CP
R803 06S45675W06 RES,RK 104J 1/10 -CP
R808 06S70072F51 RES,CP .821-J-1/4-CP
R820 06S70072F77 RES,CP .103-J-1/4-CP
R821 06S55366Y33 RES,RK 624J 1/10 -CP
R822 06S70072F46 RES,CP .511-J-1/4-CP
R823 06S70072F58 RES,CF .162-J-1/4-CP
R824 06S70072F58 RES,CF .162-J-1/4-CP
R825 06S70072F57 RES,CP .152-J-1/4-CP
R826 06S35095Y15 RES,RK 243J 1/4 -CP
R827 06S70072F57 RES,CP .152-J-1/4-CP
R833 06S45674W90 RES,RK 243J 1/10 -CP
R834 06S70072F59 RES,CP .182-J-1/4-CP
R835 06S70072F59 RES,CP .182-J-1/4-CP
R836 06S70072F53 RES,CP .102-J-1/4-CP
R837 06S45674W81 RES,RK 103J 1/10 -CP
R838 06S45674W81 RES,RK 103J 1/10 -CP
R839 06S70072F77 RES,CP .103-J-1/4-CP
R880 06S45674W83 RES,RK 123J 1/10 -CP
R881 06S35095Y08 RES,RK JUMPER 1/4-CP
R882 06S55361Y57 RES,RK 471J 1/4 -CP
R883 06S45674W57 RES,RK 102J 1/10 -CP
=======Connectors
CB201 09T25436Y03 WTB,53253-0310 -DB
CB802 09T25436Y02 WTB,53253-0210 -DB
CH101 09T25684Y22 FFC,SLW22R-1C7 -DB
*******FRONT P.W.Board
=======IC's
IC401 51T02347K01 PT6583LQ -QT
IC402 51T55628Y01 RS-671 -NE2
=======Diodes
D401 48T85357W01 DIO,1PS226 -CP
D402 48T85357W01 DIO,1PS226 -CP
D403 48T85357W01 DIO,1PS226 -CP
D404 48T85357W01 DIO,1PS226 -CP
D405 48T85357W01 DIO,1PS226 -CP
D406 48T85357W01 DIO,1PS226 -CP
D415 48T81063F01 DIO,CP.MA159 / TX-CP
D416 48T81063F01 DIO,CP.MA159 / TX-CP
D417 48T81063F01 DIO,CP.MA159 / TX-CP
=======LED's
LD452 48T25534Y01 LED,GRN BG1111C -CP
LD453 48T25534Y01 LED,GRN BG1111C -CP
LD457 48T25534Y01 LED,GRN BG1111C -CP
LD458 48T25534Y01 LED,GRN BG1111C -CP
LD461 48T45280Y01 LED,W HT NSCWS405T-E2
LD462 48T45280Y01 LED,W HT NSCWS405T-E2
LD464 48T25534Y01 LED,GRN BG1111C -CP
LD465 48T25534Y01 LED,GRN BG1111C -CP
LD466 48T25534Y01 LED,GRN BG1111C -CP
LD467 48T25534Y01 LED,GRN BG1111C -CP
LD469 48T25534Y01 LED,GRN BG1111C -CP
LD474 48T65176Y01 LED,GRN DG1111C -CP
LD478 48T45280Y01 LED,W HT NSCWS405T-E2
LD479 48T45280Y01 LED,W HT NSCWS405T-E2
LD482 48T25534Y03 LED,AMB AA1111C -CP
=======Switches
SW401 40T65353Y01
SW402 40T65353Y01
SW404 40T65353Y01
SW405 40T65353Y01
SW406 40T65353Y01
SW407 40T65353Y01
SW408 40T65353Y01
SW410 40T65353Y01
SW411 40T65353Y01
SW412 40T65353Y01
SW413 40T65353Y01
SW,TACT SKRPACE010E2
(FWD/UP)
SW,TACT SKRPACE010E2
(BWD/DN)
SW,TACT SKRPACE010E2
(5/M.I.X.)
SW,TACT SKRPACE010E2
(SOURCE/POWER)
SW,TACT SKRPACE010E2
(1/AF)
SW,TACT SKRPACE010E2
(6/SCAN)
SW,TACT SKRPACE010E2
(PLAY/PAUSE/TUNE/A.ME)
SW,TACT SKRPACE010E2
(2/NEWS)
SW,TACT SKRPACE010E2
(F/SETUP)
SW,TACT SKRPACE010E2
(T.INFO)
SW,TACT SKRPACE010E2
(3/PTY)
Page 36
CDM-9805R
SW414 40T65353Y01
SW416 40T65353Y01
SW418 40T65353Y01
SW419 40T65353Y01
SW420 40T65353Y01
SW422 40T65353Y01
=======Lamps
PL451 65T35324Y02 LAMP,GRN 6-80 -E5
PL452 65T35324Y02 LAMP,GRN 6-80 -E5
PL453 65T35324Y02 LAMP,GRN 6-80 -E5
PL454 65T35324Y02 LAMP,GRN 6-80 -E5
=======Capacitors
C404 08S45677W58 CAP,CER 821J-CH1H-CP
C405 08S45676W89 CAP,CER 473K-B1E -CP
C406 08S45676W89 CAP,CER 473K-B1E -CP
C407 08S45676W89 CAP,CER 473K-B1E -CP
C408 08T81833F08 CAP,CER 475K-B1A -CP
C409 08S45676W80 CAP,CER 223K-B1E -CP
C410 08S45676W80 CAP,CER 223K-B1E -CP
=======Resistors
R401 06S64995F86 RES,RK 243J 1/8 -CP
R402 06S45674W57 RES,RK 102J 1/10 -CP
R403 06S45674W57 RES,RK 102J 1/10 -CP
R404 06S45674W57 RES,RK 102J 1/10 -CP
R405 06S45674W57 RES,RK 102J 1/10 -CP
R406 06S45674W57 RES,RK 102J 1/10 -CP
R407 06S45674W97 RES,RK 473J 1/10 -CP
R408 06S64995F53 RES,RK 102J 1/8 -CP
R409 06S64995F77 RES,RK 103J 1/8 -CP
R410 06S64995F77 RES,RK 103J 1/8 -CP
R411 06S64995F77 RES,RK 103J 1/8 -CP
R412 06S64995F53 RES,RK 102J 1/8 -CP
R413 06S64995F77 RES,RK 103J 1/8 -CP
R414 06S64995F86 RES,RK 243J 1/8 -CP
R419 06S45674W73 RES,RK 472J 1/10 -CP
R420 06S45675W06 RES,RK 104J 1/10 -CP
R421 06S45674W57 RES,RK 102J 1/10 -CP
R422 06S45674W57 RES,RK 102J 1/10 -CP
R423 06S45674W57 RES,RK 102J 1/10 -CP
R424 06S45674W57 RES,RK 102J 1/10 -CP
R425 06S45674W57 RES,RK 102J 1/10 -CP
R426 06S45674W57 RES,RK 102J 1/10 -CP
R427 06S45674W57 RES,RK 102J 1/10 -CP
R428 06S45674W57 RES,RK 102J 1/10 -CP
R429 06S45674W57 RES,RK 102J 1/10 -CP
R430 06S45674W57 RES,RK 102J 1/10 -CP
R446 06S45674W33 RES,RK 101J 1/10 -CP
R453 06S70072F03 RES,CP .6R8-J-1/4-CP
R454 06S70072F15 RES,CP .27R-J-1/4-CP
R455 06S70072F35 RES,CP .181-J-1/4-CP
SW,TACT SKRPACE010E2
(MUTE)
SW,TACT SKRPACE010E2
(BAND)
SW,TACT SKRPACE010E2
(4/REPEAT)
SW,TACT SKRPACE010E2
(EJECT)
SW,TACT SKRPACE010E2
(DISP)
SW,TACT SKRPACE010E2
(CENTER f)
R456 06S70072F37 RES,CP .221-J-1/4-CP
R457 06S70072F33 RES,CP .151-J-1/4-CP
R458 06S70072F37 RES,CP .221-J-1/4-CP
R465 06S70072F39 RES,CP .271-J-1/4-CP
R466 06S70072F65 RES,CP .332-J-1/4-CP
R467 06S70072F41 RES,CP .331-J-1/4-CP
R468 06S70072F41 RES,CP .331-J-1/4-CP
R469 06S70072F41 RES,CP .331-J-1/4-CP
R472 06S70072F23 RES,CP .56R-J-1/4-CP
R473 06S70072F23 RES,CP .56R-J-1/4-CP
R474 06S70072F31 RES,CP .121-J-1/4-CP
R475 06S70072F31 RES,CP .121-J-1/4-CP
R477 06S35095Y08 RES,RK JUMPER 1/4-CP
R482 06S70072F39 RES,CP .271-J-1/4-CP
R483 06S70072F68 RES,CP .432-J-1/4-CP
R484 06S70072F41 RES,CP .331-J-1/4-CP
R485 06S70072F05 RES,CP .10R-J-1/4-CP
R486 06S70072F05 RES,CP .10R-J-1/4-CP
R487 06S35095Y08 RES,RK JUMPER 1/4-CP
*******DP-S MAIN P.W.Board
=======IC's
IC201 51T55329Y02 IC,D789026GB-A82 -QT
IC301 51T55156Y01 UPD63711A -QT
IC302 51T55295Y01 AN80M50RSPE1 -NE5
IC401 51T55093Y01 BA5984FP-E2 -SEA
=======Transistors
Q301 48T55462Y01 TR,2SB1132-QR-100-E2
Q401 48T94606F03 TR,DTC124EUA-T106-CP
=======Diode
D401 48T81063F01 DIO,CP.MA159 / TX-CP
=======Crystals
CL201 91T45281Y03 OSC,CER CSTCR4M19-E1
CL301 91T55147Y01 OSC,CER CSACV16M9-E1
=======Capacitors
C238 08S45676W85 CAP,CER 104K-B1C -CP
C240 08S45676W85 CAP,CER 104K-B1C -CP
C241 08S45676W73 CAP,CER.103K-B1H -CP
C246 08S45676W85 CAP,CER 104K-B1C -CP
C302 08S45676W85 CAP,CER 104K-B1C -CP
C304 08S45676W80 CAP,CER 223K-B1E -CP
C305 08S45676W85 CAP,CER 104K-B1C -CP
C306 08S45676W85 CAP,CER 104K-B1C -CP
C308 08S45676W85 CAP,CER 104K-B1C -CP
C310 08S45676W85 CAP,CER 104K-B1C -CP
C311 08S45676W73 CAP,CER.103K-B1H -CP
C314 08S45676W65 CAP,CER.222K-B1H -CP
C315 08S45676W65 CAP,CER.222K-B1H -CP
C318 08S45676W73 CAP,CER.103K-B1H -CP
C319 08S45676W85 CAP,CER 104K-B1C -CP
C320 08S45676W85 CAP,CER 104K-B1C -CP
C321 08S45676W85 CAP,CER 104K-B1C -CP
C322 08S45676W87 CAP,CER 333K-B1E -CP
C323 08S45676W85 CAP,CER 104K-B1C -CP
C324 08S45676W85 CAP,CER 104K-B1C -CP
Page 37
CDM-9805R
C325 08S45676W68 CAP,CER.392K-B1H -CP
C326 08S45676W93 CAP,CER 224K-B1A -CP
C327 08S45677W20 CAP,CER.22RJ-CH1H-CP
C328 08S45677W03 CAP,CER 1R5C-CH1H-CP
C330 08S45677W30 CAP,CER.56RJ-CH1H-CP
C331 08S45677W26 CAP,CER.39RJ-CH1H-CP
C332 08S45676W85 CAP,CER 104K-B1C -CP
C334 08S45676W85 CAP,CER 104K-B1C -CP
C336 08S45676W85 CAP,CER 104K-B1C -CP
C341 08S45677W20 CAP,CER.22RJ-CH1H-CP
C345 08S45677W60 CAP,CER 102J-CH1H-CP
C346 08S45677W60 CAP,CER 102J-CH1H-CP
C409 08S45676W85 CAP,CER 104K-B1C -CP
C449 08S45677W40 CAP,CER.151J-CH1H-CP
C450 08S45677W54 CAP,CER 561J-CH1H-CP
E239 23T45152Y02 CAP,RA 47R-05 -E5
E301 23T45152Y02 CAP,RA 47R-05 -E5
E303 23S55311W35 CAP,TAN 10R-1C-B -CP
E310 23S55311W35 CAP,TAN 10R-1C-B -CP
E316 23T45152Y02 CAP,RA 47R-05 -E5
E317 23T45152Y03 CAP,RA 22R-OJ -E5
E329 23S55311W28 CAP,TAN 22R-1A-B -CP
E331 23S55311W31 CAP,TAN.2R2-1C-A -CP
E333 23T45152Y04 CAP,RA 10R-1C -E5
E337 23T45152Y02 CAP,RA 47R-05 -E5
E338 23S55311W35 CAP,TAN 10R-1C-B -CP
E407 23T45152Y04 CAP,RA 10R-1C -E5
=======Resistors
R201 06S45674W97 RES,RK 473J 1/10 -CP
R202 06S45674W97 RES,RK 473J 1/10 -CP
R203 06S45674W97 RES,RK 473J 1/10 -CP
R212 06S45674W33 RES,RK 101J 1/10 -CP
R226 06S45674W93 RES,RK 333J 1/10 -CP
R228 06S45674W81 RES,RK 103J 1/10 -CP
R229 06S45674W97 RES,RK 473J 1/10 -CP
R230 06S45674W33 RES,RK 101J 1/10 -CP
R246 06S45675W43 RES,RK JUMPER1/10-CP
R250 06S45674W97 RES,RK 473J 1/10 -CP
R251 06S45674W97 RES,RK 473J 1/10 -CP
R252 06S45674W97 RES,RK 473J 1/10 -CP
R253 06S45674W97 RES,RK 473J 1/10 -CP
R254 06S45674W97 RES,RK 473J 1/10 -CP
R255 06S45674W97 RES,RK 473J 1/10 -CP
R256 06S45674W97 RES,RK 473J 1/10 -CP
R257 06S45674W97 RES,RK 473J 1/10 -CP
R258 06S45674W97 RES,RK 473J 1/10 -CP
R259 06S45674W97 RES,RK 473J 1/10 -CP
R260 06S45674W97 RES,RK 473J 1/10 -CP
R261 06S45674W97 RES,RK 473J 1/10 -CP
R262 06S45674W97 RES,RK 473J 1/10 -CP
R263 06S45674W97 RES,RK 473J 1/10 -CP
R264 06S45674W97 RES,RK 473J 1/10 -CP
R265 06S45674W97 RES,RK 473J 1/10 -CP
R266 06S45674W97 RES,RK 473J 1/10 -CP
R270 06S45674W93 RES,RK 333J 1/10 -CP
R301 06S70072F05 RES,CP .10R-J-1/4-CP
R302 06S70072F05 RES,CP .10R-J-1/4-CP
R311 06S45675W43 RES,RK JUMPER1/10-CP
R316 06S45674W41 RES,RK 221J 1/10 -CP
R317 06S45674W41 RES,RK 221J 1/10 -CP
R323 06S45674W81 RES,RK 103J 1/10 -CP
R324 06S45674W95 RES,RK 393J 1/10 -CP
R325 06S45674W78 RES,RK 752J 1/10 -CP
R331 06S45675W43 RES,RK JUMPER1/10-CP
R332 06S45675W43 RES,RK JUMPER1/10-CP
R333 06S45675W43 RES,RK JUMPER1/10-CP
R334 06S45675W43 RES,RK JUMPER1/10-CP
R341 06S45675W43 RES,RK JUMPER1/10-CP
R343 06S45674W93 RES,RK 333J 1/10 -CP
R344 06S45674W93 RES,RK 333J 1/10 -CP
R345 06S45674W93 RES,RK 333J 1/10 -CP
R401 06S45675W06 RES,RK 104J 1/10 -CP
R402 06S45674W33 RES,RK 101J 1/10 -CP
R403 06S64995F87 RES,RK 273J 1/8 -CP
R404 06S45674W95 RES,RK 393J 1/10 -CP
R405 06S45674W85 RES,RK 153J 1/10 -CP
R406 06S45674W81 RES,RK 103J 1/10 -CP
R407 06S45674W81 RES,RK 103J 1/10 -CP
R408 06S45674W89 RES,RK 223J 1/10 -CP
R409 06S45674W81 RES,RK 103J 1/10 -CP
R410 06S45674W81 RES,RK 103J 1/10 -CP
R411 06S45674W89 RES,RK 223J 1/10 -CP
R434 06S45674W33 RES,RK 101J 1/10 -CP
R435 06S45674W33 RES,RK 101J 1/10 -CP
R436 06S45674W33 RES,RK 101J 1/10 -CP
R437 06S45674W33 RES,RK 101J 1/10 -CP
RA201 06S45591W07 RES,ARY MNR101J 4-CP
RA202 06S45591W07 RES,ARY MNR101J 4-CP
=======Connectors
CB101 09T45435W22 FFC,52207-2290 -EQ
CB102 09T45435W15 FFC,52207-1590 -ED
CB103 09T45435W07 FFC,52207-0790 -E9
*******Miscellaneous
ANT001
CB601 09T65330Y15 BTB,TMD-V15X-A1 -DB
CB801 09T35343Y16 WTB,IMSA9451B-16 -DB
CH401 09T15298Y15 BTB,TMD-V15P-A1 -B
DIN001 09T55493W02 DIN,SKT 8P CMS-R -DT
JK201 01T02234K03
JK601 09T03156K01
LCD401
M802 59T55190Y03
SW421 40T45670W44
*******DP23S2AO
HD101 81B50360Y01 PICKUP,EP21A67L
M101 01V56100Y14
M102 01V56100Y12
ASSY,CONN NLT1661
(F/R)
JAC,CK-3.5-14 -DB (STREMO)
MOTOR,F2510CT-12UCV
(FAN MOTOR/12V-40mA)
ENC,EC11B15243 -DB
(ROTARY
ENCODER/MODE/LOUD)
ASSY,MOTOR WORM 2BO
(3.5V-80mA)
ASSY,MOTOR SLED 2BO
(3.5V-80mA)
Page 38
CDM-9805R
M103 01V56100Y11
SW1 40T15494Y01
SW2 40T15494Y02
SW3 40T15494Y07
SW4 40T15494Y01
SW105 40T71025F03
ASSY,MTR SPINDOL 2BO
(3V-90mA)
SW,DETCT SPVG23 -E6
(12cm DISC DETECT
(EJECT
POSITION/RELOAD))
SW,DETCT SPVG13 -E6
(8/12cm DISC DETECT
(INSERT/PULL OUT))
SW,DETCT SPVG21 -E6
(8cm DISC DETECT
(EJECT
POSITION/RELOAD))
SW,DETCT SPVG23 -E6
(DISC CHUCKING END
DETECT)
SW,DETCT SPPB120
(LIMIT)
Loading...