Vulcan Hart VGLT40, VGLT60 General Manual

Shown with optional spring assist cover

Item # C.S.I. Section 11420

STEAM

VGLT SERIES

GAS TILTING 2⁄3 JACKETED KETTLE

VG LT2 0 80,000 BTU/hr., 20 gallon capacity.
VG LT40 100,000 BTU/hr., 40 gallon capacity.
VG LT6 0 120,000 BTU/hr., 60 gallon capacity.

STANDARD FEATURES

Self generating gas red power burner, all welded type ■
304 stainless steel, 2⁄3 jacketed tilting steam kettle.
Fully welded hemispheric bottom kettle with type 304 ■
stainless steel jacket and liner. (Type 316 stainless steel liner
20 & 40 gallons only). Jacket tested to 50 psi (3.4 kg/cm2).
Factory charged with chemically pure water, rust inhibitor, and ■
anti-freeze for protection against freezing to -30°F.
Kettle exterior is fully insulated. ■
Kettles mounted on trunnions connected to the control and ■
gear consoles. The worm gear tilting mechanism is self
locking and allows the kettle to tilt a full 90°. Trunnion cover
with provision for faucet.
Recessed control panel located on front of kettle. Controls ■
include direct immersion thermostat, water sight glass,
cooking light, pressure gauge and electronic ignition with
ignitions indicator light.
Safety features include low water cut-off, pressure relief valve, ■
pressure switch and gas shut-off valve.
Requires a 120 volt, 60 Hz, 1 phase power supply, 3.0 amp. 6' ■
cord and plug supplied.
■3/4" rear gas connection with gas pressure regulator.
One year limited parts and labor warranty. ■

SPECIFICATIONS

Self generating gas red power burner, all welded type 304,

2

⁄3 jacketed tilting steam kettle, Vulcan-Hart Model No. ( VGLT20)
(VGLT40) (VGLT60). Fully welded hemispherical bottom kettle with
type 304 stainless steel jacket and lining. (Type 316 stainless steel
liner 20 & 40 gallons only.) Jacket tested to 50 psi (3.4 kg/cm2).
Factory charged with chemically pure water, rust inhibitor, and
antifreeze for protection against freezing to -30°F. Kettle exterior
is fully insulated. Kettles mounted on trunnions connected to the
control and gear consoles. The worm gear tilting mechanism is
self locking and allows the kettle to tilt a full 90°. Trunnion cover
with provision for faucet. Recessed control panel located on front
of kettle. Controls include direct immersion thermostat, water sight
glass, cooking light, pressure gauge and electronic ignition with
ignitions indicator light. Safety features include low water cut­off, pressure relief valve, pressure switch and gas shut-off valve.
Requires a 120 volt, 60 Hz, 1 phase power supply, 3.0 amp. 6'
cord and plug supplied. 3⁄4" rear gas connection with gas pressure
regulator.

CSA design certied. NSF listed. Meets ASME code.

SPECIFY TYPE OF GAS WHEN ORDERING.
SPECIFY ALTITUDE WHEN ABOVE 2,000 FT.

OPTIONS

Spring assist cover.
Spring assist cover with condensate ring.
Two piece hinged cover.

Correction facility package.
a. Controls protected by lockable cover (lock by others).
b. Security type tamper resistant fasteners with tack welds.
c. Perforated ue cover.
d. Stainless steel cover over draw-off with chain.

Tilting kettle strainer.

2" draw-off valve with perforated strainer.

3" draw-off valve with perforated strainer.

Type 316 stainless steel liner, 60 gallons.

Second year extended limited parts and labor warranty.

ACCESSORIES (Packaged & Sold Separately)

18" double jointed single pantry faucet.

18" double jointed double pantry faucet.

Double pantry washdown hose with 16" add-on faucet with

backow preventer.

Double pantry washdown hose with backow preventer.

Double pantry pot ller and backow preventer.

Contour measuring strip.

Triple perforated stainless steel basket assembly.

Draw-off valve strainer, solid.

Clean-up kit; includes draw-off brush, clean-up brush w/36"

handle and paddle scraper w/40" handle with nylon blade.

Stainless steel 48" wire whip.

a divisi on of IT W Food Equ ipmen t Group LLC

P.O. Box 696 ■ Louisville, KY 40201 ■ Toll-free: 1-800-814-2028 ■ Local: 502-778-2791 ■ Quote & Order Fax: [phone]

F-32051 (03/10)