Uniflame Gbt1012w, Gbt1012w-c Owner's Manual

OWNER’S MANUAL

Made from 70% Bagasse

(Environmentally Friendly Sugar

Cane Pulp By-product)

Outdoor LP Gas Barbecue Grill

Model No. GBT1012W

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

WARNING

FOR YOUR SAFETY:

1. Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

2. Read the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.

3. Failure to follow these instructions could result in ﬁre or explosion which could cause property damage, personal injury or death.

Table of Contents

Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2

Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

First Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Turning Off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Cooking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Flare ups. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Tips. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Save these instructions for future reference. If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

The use and installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas

and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

California Proposition 65: Chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

California Proposition 65: Wash your hands after handling this product.

Manufactured in China for: Blue Rhino Global Sourcing, Inc Winston-Salem, NC USA

1.800.762.1142, www.bluerhino.com

Outdoor LP Gas Barbecue Grill Model No. GBT1012W

If you smell gas -

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. Open lid.

DANGER

1. Do not store or use gasoline or other flammable liquids or vapors in the vincinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

WARNING

FOR YOUR SAFETY

4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.

DANGER

Do not leave a lit grill unattended.

DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage

to property.

WARNING: This grill is for outdoor use only and shall not be used in a building, garage or

any other enclosed area. This grill is NOT for commercial use. This is not a tabletop grill. Therefore, do not operate this grill on any type of

tabletop surface. This grill is safety certified for use in the United States and Canada only. Do not

modify for use in any other location. Modification will result in a safety hazard

and will void warranty. Do NOT operate, light or use this appliance within 8 feet of walls, structures or

buildings. Apartment Dwellers: Check with management to learn the requirements and

fire codes for using an LP gas grill in your apartment complex. If allowed, use

outside on the ground floor with an eight (8) feet clearance from walls or rails.

Do not use on or under balconies. This grill is for use with liquid propane (LP) gas only. The conversion to or

attempted use of natural gas in this LP gas grill is dangerous and will void your

warranty. LP gas characteristics:

a. LP gas is flammable and hazardous if handled improperly. Become aware of

the characteristics before using any LP gas product.

b. LP gas is explosive under pressure, heavier than air and settles and pools in

low areas.

c. LP gas in its natural state has no odor. For your safety, an odorant is added

that smells like rotten cabbage.

d. Contact with LP gas can cause freeze burns to skin.

Only tanks marked “propane” may be used with this appliance. The LP gas tank must be constructed and marked in accordance with the

Specifications for LP gas Cylinders of the U.S. Department of Transportation

(DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres

and Tubes for the Transportation of Dangerous Goods; and Commission.

LP gas tank must be arranged for vapor withdrawal. Dented or rusted LP gas tanks may be hazardous and should be checked by

your LP gas supplier prior to use. The LP gas tank should not be dropped or handled roughly. LP gas tanks must be stored outdoors out of the reach of children and must

not be stored in a building, garage, or any other enclosed area. Your tank must

never be stored where temperatures can reach over 125°F. Do not insert any tool or foreign object into the valve outlet or safety relief

valve. You may damage the valve and cause a leak. Leaking propane may result

in explosion, fire, severe personal injury or death. Do not block holes in sides or back of grill. Never attempt to attach this grill to the self-contained LP gas system of a

camper trailer, motor home or house. Do not store a spare LP gas tank under or near this appliance. The use of alcohol, prescription or non-prescription drugs may impair the

consumer’s ability to properly assemble or safely operate the appliance. Strong odors, colds, sinus congestion, etc. may prevent the detection of

propane. Use caution and common sense when testing for leaks. Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol with

this product. Your grill has been checked at all factory connections for leaks. Re-check all

connections as movement in shipping can loosen connections. Check for leaks even if your unit was assembled for you by someone else. Do not operate if gas leak is present. Gas leaks may cause a fire or explosion. You must follow all leak-checking procedures before operating. To prevent fire

or explosion hazard when testing for a leak:

a. Always perform leak test before lighting the grill and each time the tank is

connected for use.

b. Do not use or permit sources of ignition in the area while conducting a leak

test. No smoking. c. Conduct the leak test outdoors in a well-ventilated area. d. Do not use matches, lighters or a flame to check for leaks. e. Do not use grill until any and all leaks are corrected. If you are unable to stop a leak disconnect the LP gas supply. Call our

customer care at 1.800.762.1142, a gas appliance serviceman or your local LP gas supplier.

Do not use in an explosive atmosphere. Keep grill area clear and free from

combustible materials, gasoline and other flammable vapors and liquids.

Keep all combustible items and surfaces at least 36 inches (91 cm) away

from the grill at all times. DO NOT use this grill or any gas product under any overhead or near any unprotected combustible constructions.

It is essential to keep the grill’s valve compartment, burners and circulating air

passages clean. Inspect grill before each use.

Do not use the grill unless it is COMPLETELY assembled and all parts are

securely fastened and tightened. This grill should be thoroughly cleaned and inspected on a regular basis. Do not alter grill in any manner. Any alteration will void your warranty. Use only the regulator provided. Any replacement regulator shall be specified

by the manufacturer. Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The use of

any part that is not factory authorized can be dangerous. This will also void

your warranty. Do not attempt to repair or alter the hose/regulator for any “assumed” defect.

Any modification to this assembly will void your warranty and create the risk

of a gas leak and fire. Use only authorized replacement parts supplied by

manufacturer. Do not use this appliance without reading “Operating Instructions” in this

manual. Do not touch metal parts of grill until it has completely cooled (about 45 min.)

to avoid burns, unless you are wearing protective gear (pot holders, gloves,

BBQ mittens, etc.). Do not install or use in or on boats or recreational vehicles. Do not use grill in a vehicle trunk, station wagon, mini-van, sport utility vehicle

(SUV) or recreational vehicle (RV). When cooking fire extinguishing materials shall be readily accessible. In the

event of an oil/grease fire, do not attempt to extinguish with water. Use type BC

dry chemical fire extinguisher or smother with dirt, sand or baking soda. Move gas hoses as far away as possible from hot surfaces and dripping hot

grease. Do not use grill in high winds. Never lean over grill when lighting. Do not leave a lit grill unattended. Keep children and pets away from grill at all

times. Do not attempt to move grill when in use. Allow the grill to cool (approximately

45 minutes) before moving or storing. Storage of grill indoors is permissible only if the tank is disconnected, removed

from the grill and properly stored outdoors. While wearing a protective glove or mit, open grill lid carefully and slowly as

heat and steam trapped within grill can severely burn you. Do not attempt to disconnect the gas regulator from the tank or any gas fitting

while the grill is in use. Disconnect LP gas tank when not in use. Always use your grill on a hard, non-combustable, level surface. An asphalt or

blacktop surface may not be acceptable for this purpose. Do not use directly on wooden decks. Keep all electrical cords away from a hot grill. Do not use grill for indoor cooking or heating. TOXIC fumes can accumulate and

cause asphyxiation. After a period of storage and/or nonuse check for leaks and burner

obstructions. Failure to open lid while igniting the grill’s burner, or not waiting 5 minutes

to allow the gas to clear if the grill does not light, may result in an explosive

flame-up. Never operate grill without heat plate installed. Always use a meat thermometer to ensure food is cooked to a safe

temperature. Use protective gloves when assembling this product. Do not force parts together as this can result in personal injury or damage to

the product. Never cover entire cooking area with aluminum foil. Death, serious injury or damage to property may occur if the above is not

followed exactly.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

For great recipes and tips, visit recipes.uniflame.com

page no.

Parts List

Lid Handle

Lid

Warming Rack

Cooking Grid

Top Hinge (2)

Bottom Hinge (2)

Heat Plate

Burner

Side Handle (2)

Heat Plate Support (2)

Bottom Bowl

Leg Support A (2)*

55-09-327

55-10-304

55-10-305

55-10-306

55-10-100

55-09-502

55-09-234

55-10-308

55-10-309

55-10-310

55-10-311

55-10-312

Exploded View

Leg Support B (2)*

Lock

Wind Guard

Regulator/Control Knob

Left Leg

Right Leg

Foot A (2)*

Foot B (2)*

Heat Reflector

* Pre-assembled

55-10-313

55-09-537

55-09-254

55-14-720

55-10-346

55-10-314

55-10-315

55-10-316

55-14-736

Hardware

Screw

Wing Bolt

Wing Nut

Washer

Lock Washer

A B C D E F G H

J K L

M4x12 Nickel Plated Phillips Truss Head

M5x12 Nickel Plated Phillips Truss Head

M6x15 Nickel Plated Phillips Truss Head

M6x12 Zinc Plated

M4 Zinc Plated

M5 Zinc Plated

M6 Zinc Plated

ø4 Zinc Plated

ø5 Zinc Plated

ø6 Zinc Plated

ø6 Heat Resistant

ø4 Zinc Plated

ø5 Zinc Plated

2 pcs

8 pcs

4 pcs

1 pc

2 pcs

8 pcs

10 pcs

2 pcs

8 pcs

10 pcs

14 pcs

2 pcs

8 pcs

Tools Required for Assembly (Not Included)

#2 Phillips Head Screwdriver 1 pc

N O P

Lock Washer

Cotter Pin

ø6 Zinc Plated

ø5 x 30 Nickel Plated

ø1.4 x 30 Black

10 pcs

2 pcs

Assembly Instructions

Outdoor LP Gas Barbecue Grill Model No. GBT1012W

DO NOT RETURN PRODUCT TO STORE.

For assistance call 1.800.762.1142 toll free. Please have your owner’s manual and model number available for reference.

For Easiest Assembly:

• To avoid losing any small components or hardware, assemble your product on a hard level surface that does not have cracks or openings.

• Clear an area large enough to layout all components and hardware.

• When applicable, tighten all hardware connections by hand first. Once the step is completed go back and fully tighten all hardware.

• Follow all steps in order to properly assemble your product.

To complete assembly you will need:

• (1) Leak Detection Solution (Instructions on how to make solution are included in “Operating Instructions” section)

• (1) 14.1 oz or (1) 16.4 oz LP gas tank.

Attach Lid Handle and Top Hinges

Typical assembly: approximately 30 minutes.

Attach Lock and Bottom Hinges

x 4

x 2

x 4

Attach Side Handles and Heat Plate Supports

x 2

x 6

x 4

x 2

E F

x 2

x 4

x 2

x 4

x 2

x 4

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

For great recipes and tips, visit recipes.uniflame.com

page no.

Attach Legs

Attach Heat Reflector, Burner, Wind Guard and Regulator/Control Knob

Note: Once attached, the regulator/control knob will freely rotate to accomodate for the LP gas tank.

Attach Lid

x 4

Insert Warming Rack

x 1

x 2

Assembly Instructions (continued)

Outdoor LP Gas Barbecue Grill Model No. GBT1012W

Insert Heat Plate and Cooking Grid

Lock Lid

Unlock Lid

Fold Legs

Unfold Legs

+ 14 hidden pages