Uniflame Cbt916l Owner's Manual
OWNER’S MANUAL
Made from 70% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
Outdoor Charcoal Barbecue Grill
Model No. CBT916LC/0297995
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury or death.
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
First Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cooking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Flare-Ups . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Tips. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Save these instructions for future reference. If you are assembling this unit for
someone else, give this manual to him or her to read and save for future reference.
Manufactured in China for:
Blue Rhino Global Sourcing, Inc
Winston-Salem, NC USA
1.800.762.1142, www.bluerhino.com
© 2010 Blue Rhino Global Sourcing, Inc. All Rights Reserved
Blue Rhino® is a Registered Trademark of Ferrellgas, L.P. All Rights Reserved. CBT916LC-OM-101 EF
Outdoor Charcoal Barbecue Grill Model No. CBT916LC/0297995
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
WARNING:
This grill is for outdoor use only, and shall not be used in a building,
garage or any other enclosed area.
This grill is safety certified for use in the United States and/or Canada
only. Do not modify for use in any other location. Modification will result
in a safety hazard and will void the warranty.
Do NOT operate, light or use this appliance within 8 feet of walls,
structures or buildings.
Keep all combustible items and surfaces at least 36 inches (91 cm) away
from the grill at all times. DO NOT use this grill under any overhead or
near any unprotected combustible constructions.
This grill is NOT for commercial use.
Do not use grill for indoor cooking or heating. Toxic carbon monoxide
fumes can accumulate and cause asphyxiation.
Do not use gasoline, kerosene or alcohol for lighting.
Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
Do not store or use gasoline or other flammable liquids or vapors within
25 feet (7.62 m) of this appliance.
Never use charcoal that has been pre-treated with lighter fluid. Use only
a high grade plain charcoal, charcoal/wood mixture, lump charcoal or
cooking wood.
Do not alter grill in any manner. This will void the warranty.
Do not use the grill unless it is completely assembled and all parts are
securely fastened and tightened.
This grill should be thoroughly cleaned and inspected on a regular basis.
Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The
use of any part that is not factory authorized can be dangerous. This will
also void your warranty.
Do not use this appliance without reading “Operating Instructions” in
this manual.
Do not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
Never touch grates (charcoal or cooking), ashes or coals to see if they
are hot.
Do not use on wooden decks, wooden furniture or other combustible
surfaces.
Do not use in or on boats or recreational vehicles.
Position grill so wind can not carry ashes to combustible surfaces.
Do not use in high winds.
Never lean over the grill when lighting.
Do not leave a lit grill unattended. Keep children and pets away from grill
at all times.
Do not attempt to move grill when in use. Allow the grill to cool (about
45 min.) before moving or storing.
When cooking, fire extinguishing materials shall be readily accessible.
In the event of an oil/grease fire, do not attempt to extinguish with water.
Use type BC dry chemical fire extinguisher or smother with dirt, sand or
baking soda.
Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
Never add lighting fluid to hot or even warm coals as flashback may
occur causing serious injury or damage to property.
Always place your grill on a hard, non combustible, level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
Do not remove the ashes until they are completely and fully
extinguished.
Live hot briquettes and coals can create a fire hazard.
Always empty the ash catcher and grill after each use.
Do not place fuel (charcoal briquets, wood or lump charcoal) directly into
bottom of grill. Place fuel only on the charcoal pan/grid.
Do not allow charcoal to rest on the walls of grill. Doing so will greatly
reduce the life of the metal and finish of your grill.
Check to make sure the air vents are free of debris and ash before using
the grill.
Make sure ash catcher is securely and completely in place before using
the grill.
Extinguished coals and ashes should be placed a safe distance from all
structures and combustible materials.
With a garden hose, completely wet the surface beneath and around grill
to extinguish any ashes, coals or embers which may have fallen during
the cooking or cleaning process.
Always wear protective gloves when adding fuel (charcoal briquets,
wood or lump charcoal) to retain desired heat level.
Keep all electrical cords away from a hot grill.
Always use a meat thermometer to ensure food is cooked to a safe
temperature.
Never cover entire cooking area with aluminum foil.
Use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or
damage to the product.
Death, serious injury or damage to property may occur if the above is not
followed exactly.
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
3
Parts List
1
Lid Handle
2
Lid Air Vent
3
Lid
4
Cooking Grid
5
Charcoal Grid
6
Top HInge (2)
7
Bottom Hinge (2)
8
Bottom Bowl
9
Bottom Bowl Air Vent
10
Leg (4)
55-09-098
55-08-367
55-09-097
55-09-095
55-09-094
55-08-323
55-08-325
55-09-093
55-08-366
55-09-097
Exploded View
1
2
4 3
5
6
7
8
9
Hardware
A
B
C
D
E
F
Screw
Screw
Wing Nut
Wing Nut
Washer
Lock Washer
M4x12 Zinc Plated Phillips Truss Head
M5x12 Zinc Plated Phillips Truss Head
M4 Steel Plated
M5 Steel Plated
ø6.4 Heat Resistant
ø5.3 Zinc Plated
2 pcs
11 pcs
2 pcs
13 pcs
2 pcs
6 pcs
10
Tools Required for Assembly (Not Included)
#2 Phillips Head Screwdriver
G
H
Pin
Cotter Pin 2 pcs
ø5 x 30 Black Coated
2 pcs
Assembly Instructions
Outdoor Charcoal Barbecue Grill Model No. CBT916LC/0297995
1
DO NOT RETURN PRODUCT TO STORE.
For assistance call 1.800.762.1142 toll free. Please have
your owner’s manual and model number available for
reference.
For Easiest Assembly:
• To avoid losing any small components or hardware, assemble
your product on a hard level surface that does not have cracks
or openings.
• Clear an area large enough to layout all components and
hardware.
• When applicable, tighten all hardware connections by hand
first. Once the step is completed go back and fully tighten all
hardware.
• Follow all steps in order to properly assemble your product.
Typical assembly: approximately 30 minutes.
Attach Lid Handle, Top Hinges and Air Vent Set
2
3
Attach Bottom Bowl Air Vent and Bottom Hinges
4
B
D
Attach Legs
x 3
x 5
E
F
x 2
x 2
A
B
C
x 2
x 4
x 2
D
F
x 4
x 4
B
x 4
D
x 4
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
5
5
Attach Lid
Insert Chrcoal Grid and Cooking Grid
6
7
G
Locking Lid
x 2
H
x 2
Fold Legs
8
Unlocking Lid
Unfold Legs
Loading...