TRUE FOOD SERVICE EQUIPMENT, INC.
2001 East Terra Lane • O’Fallon, Missouri 63366-4434 (636) 240-2400 • FAX (636) 272-2408 • INT’L FAX (636) 272-7546 • (800) 325-6152 Parts Department (800) 424-TRUE • Parts Department FAX# (636) 272-9471
INSTALLATION MANUAL FOR GDIM (GLASS DOOR ICE MERCHANDISERS)
TABLE OF CONTENTS
|
Safety Information |
|
||||||||||||||||||
|
Safety Precautions |
|
1 |
|||||||||||||||||
|
Do’s and Don’ts |
2 |
||||||||||||||||||
|
Proper Disposal |
|
|
3 |
||||||||||||||||
|
Connecting Electricity |
4 |
||||||||||||||||||
|
Adapter Plugs |
|
4 |
|||||||||||||||||
|
Ownership |
|
|
|||||||||||||||||
|
Required Tools |
5 |
||||||||||||||||||
|
Uncrating |
|
|
5 |
||||||||||||||||
|
Locating & Installation of Leg/Castors |
6 |
||||||||||||||||||
|
Leveling Cabinet |
|
|
7 |
||||||||||||||||
|
Wire Gauge Chart |
|
8 |
|||||||||||||||||
|
Sealing Cabinet to Floor & Electrical Inst. |
9 |
||||||||||||||||||
|
Start-up and Light Switch Location |
|
|
10 |
||||||||||||||||
|
Defrost Time Clock Operation (Grasslin) |
11 |
||||||||||||||||||
|
Field Troubleshooting |
|
|
12-13 |
||||||||||||||||
GDIM-26 |
|
|
|
|
|
|
|
|||||||||||||
Maintenance, Care and Cleaning |
|
|||||||||||||||||||
|
Cleaning Condenser Coil |
14-15 |
||||||||||||||||||
GDIM-26NT |
Cabinet Cleaning |
|
|
16-17 |
||||||||||||||||
Light Bulb Replacement |
|
17 |
||||||||||||||||||
|
Warranty (U.S.A. & Canada Only!) |
|
18 |
CONGRATULATIONS!
You have just purchased the finest commercial freezer available. You can expect many years of trouble-free operation.
GDIM-49
GDIM - GLASS DOOR
ICE MERCHANDISERS
............ www.truemfg.com ............ |
#897013 |
True Food Service Equipment, Inc.
............ www.truemfg.com ............
True Food Service Equipment, Inc.
SAFETY INFORMATION
How to Maintain Your Freezer to Receive the Most Efficient and Successful Operation
You have selected one of the finest commercial freezer units made. It is manufactured under strict quality controls with only the best quality materials available. Your TRUE freezer when properly maintained will give you many years of trouble-free service.
WARNING!
Use this appliance for its intended purpose as described in this Owner Manual.
This cabinet contains fluorinated greenhouse gas covered by the Kyoto Protocol (please refer to cabinet’s inner label for type and volume,
GWP of 134a= 1,300. R404a= 3,800).
SAFETY PRECAUTIONS
When using electrical appliances, basic safety precautions should be followed, including the following:
•This freezer must be properly installed and located in accordance with the Installation Instructions before it is used.
•Do not allow children to climb, stand or hang on the shelves in the freezer. They could damage the freezer and seriously injure themselves.
•Do not touch the cold surfaces in the freezer compartment when hands are damp or wet. Skin may stick to these extremely cold surfaces.
•Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
•Keep fingers out of the “pinch point” areas; clearances between the doors and between the doors and cabinet are necessarily small; be careful closing doors when children are in the area.
NOTE
We strongly recommend that any servicing be preformed by a qualified individual.
•Unplug the freezer before cleaning and making repairs.
•Setting temperature controls to the 0 position does not remove power to the light circuit, perimeter heaters, or evaporator fans.
1 ............ |
www.truemfg.com ............ |
1 |
True Food Service Equipment, Inc.
SAFETY INFORMATION
2 ............ |
www.truemfg.com ............ |
2 |
True Food Service Equipment, Inc.
SAFETY INFORMATION
DANGER!
RISK OF CHILD ENTRAPMENT
PROPER DISPOSAL OF THE REFRIGERATOR
Child entrapment and suffocation are not problems of the past. Junked or abandoned refrigerators are still dangerous… even if they will sit for “just a few days.” If you are getting rid of your old refrigerator, please follow the instructions below to help prevent accidents.
Before You Throw Away Your Old Refrigerator or
Freezer:
•Take off the doors.
•Leave the shelves in place so that children may not easily climb inside.
Refrigerant Disposal
Your old refrigerator may have a cooling system that uses “Ozone Depleting ” chemicals. If you are throwing away your old refrigerator, make sure the refrigerant is removed for proper disposal by a qualified service technician. If you intentionally release any refrigerants you can be subject to fines and imprisonment under provisions of the environmental regulations.
USE OF EXTENSION CORDS
NEVER USE AN EXTENSION CORD! TRUE will not warranty any refrigerator that has been connected to an extension cord.
REPLACEMENT PARTS
•Component parts shall be replaced with like components.
•Servicing shall be done by authorized service personnel, to minimize the risk of possible ignition due to incorrect parts or improper service.
•Lamps must be replaced by indentical lamps only.
•If the supply cord is damaged, it must be replaced by a special cord or assembly available from the manufacturer or its service agent.
3 ............ |
www.truemfg.com ............ |
3 |
True Food Service Equipment, Inc.
SAFETY INFORMATION
WARNING!
HOW TO CONNECT ELECTRICITY
Do not, under any circumstances, cut or remove the ground prong from the power cord.
For personal safety, this appliance must be properly grounded.
The power cord of this appliance is equipped with a grounding plug which mates with a standard grounding wall outlet to minimize the possibility of electric shock hazard from this appliance.
Have the wall outlet and circuit checked by a qualified electrician to make sure the outlet is properly grounded.
If the outlet is a standard 2-prong outlet, it is your personal responsibility and obligation to have it replaced with the properly grounded wall outlet.
The freezer should always be plugged into it’s own individual electrical circuit, which has a voltage rating that matches the rating plate.
This provides the best performance and also prevents overloading building wiring circuits which could cause a fire hazard from overheated wires.
Never unplug your freezer by pulling on the power cord. Always grip plug firmly and pull straight out from the outlet.
Repair or replace immediately all power cords that have become frayed or otherwise damaged. Do not use a cord that shows cracks or abrasion damage along its length or at either end.
When removing the freezer away from the wall, be careful not to roll over or damage the power cord.
USE OF ADAPTER PLUGS
NEVER USE AN ADAPTER PLUG! Because of potential safety hazards under certain conditions, we strongly recommend against the use of an adapter plug.
The incoming power source to the cabinet including any adapters used must have the adequate power available and must be properly grounded. Only adapters listed with UL should be used.
North America Use Only!
NEMA plugs
TRUE uses these types of plugs. If you do not have the right outlet have a certified electrician install the correct power source.
4 ............ |
www.truemfg.com ............ |
4 |