Suzuki DL1000 Service Manual

Specifications and Main Features

Length of machine: 2,295 millimeters which equals 90.4 inches
Measurement of the breadth: 865 mm (34.1 in)
Measurement of the height: 1,335 mm (52.6 in)
Measurement between the front and rear wheels: 1,535 mm (60.4 in)
Height from the ground to the structure: 165 mm (6.5 in)
Height of the seat: 840 mm (33.1 in)
Mass of the machine without any fluids: 207 kg (456 lbs)
Engine make: Four-stroke, Liquid cooled, DOHC, 90-degree V-twin
Number of chambers: 2
Internal diameter of the cylinder: 98.0 mm (3.858 in)
Distance between the top and bottom dead centers: 66.0 mm (2.598 in)
Used volume: 996 cm³ (60.8 cu. in)
The means of combustion ratios: 11.3:1
System for distributing fuel: Fuel injection system
Type of air filter: Non-woven fabric element
How does the vehicle start? Via an electric starter
How is the machine lubricated? It is done through a wet sump
Sedimentation of oil: Wet multi-plate type
Number of gears in the machine: 6-speed constant mesh
Gearshift pattern: 1-down, 5-up
How much speed is reduced from the engine to the drive shaft?: rati- 1.838 (57/31)
Final ratio of reduction: rati- 2.411 (41/17)
What is the type of shocks for the front wheels: Inverted telescopic, coil spring, oil damped
What is the type of shocks for the rear wheels: Link type, coil spring, oil damped
Type of brakes installed: Disc type brakes, twin
Brakes installed rear end of the vehicle: Disc brake
What is the diameter of the front tyre: 110/80 R19M/C 59H, tubeless
What is the diameter of the rear tyre: 150/70 R17M/C 69H, tubeless
What is the charge in the battery: 12 V 43.2 kC (12 Ah)/10 HR
Fuel tank capacity: 22 L (5.8/4.8 US/Imp gal)
Engine oil capacity (oil change): 2,700 ml (2.9/2.4 US/Imp qt)
Engine oil capacity (with filter change): 2,900 ml (3.1/2.6 US/Imp qt)
Engine coolant capacity, including reserve: 2,200 ml (2.3/1.9 US/Imp qt)
Fuel recommendation: Unleaded gasoline of at least 87 pump octane
Recommended engine oil: Suzuki Performance 4 Motor Oil or oil rated SF or SG under API

Frequently Asked Questions

What type of fuel should I use for the Suzuki DL1000?

Only use unleaded gasoline having pump octane rating not less than 87. In other regions grade 91 octane and above is suitable.

How often should I change the engine oil?

You are advised to change the engine oil after every 6000 Kilometers (4000 miles), and during the first change after achieving 1000 Kilometers (600 miles)

What is the recommended tire pressure for solo and dual riding?

The front tire about 250kpa (2.50 kgf/cm²) while for the rear remains at 250kpa (2.50 kgf/cm²) for solo riding. The rear for dual riding should be at280kpa (2.80 kgf/cm²).

For the Suzuki DL1000, what is the tolerance for the compression pressure?

The upper cylinder can offer a compression pressure of 1.4 MPa, and the fault must be confined to a maximum of 200 kPa between the two.

How do I verify the engine has the correct amount of oil?

After the replacement of the oil, you are required to run the Suzuki DL1000 engine for a time period between 2-3 Minutes. You can then check if the amount of oil present is as specified.