SOLTRON S-40 Champ *** Super Operating Instructions Manual
Soltron
801233 / Index „b“ / us / 01.2004
Operating Instructions
04173
/
0
S-40 Champ *** Super
II
Identify your tanning device
For contact with customer service, please write down the device number of your tanning device.
Global Service Division
#1 Walter Kratz Drive
Jonesboro, Arkansas 72401
( (800) 445 0624
04196 / 0
III
III
“This product is in conformity with performance standards for sunlamp products under CFR21 Part 1040.”
04438 / 0
Note:
Description of
skin types see
Page 15.
4
Foreword
Foreword
Dear Customer,
The Soltron device you have purchased is a technically advanced and
powerful microcomputer control system. Your device was manufactured
with the greatest care and precision. It went through numerous quality
and safety checks in order to guarantee trouble-free, safe operation. But
you too may make a significant contribution to your long-term satisfaction
with your device. Following the tips and instructions in the instruction
manual will ensure you enjoyment and pleasure with your device.
In case of any questions, we are always at your disposition
1)
.
Your sincerely
Soltron Inc.
• Read and observe the information in this instruction manual. This will
enable you to prevent accidents and provide you with a reliable
device ready for use.
• Always observe the local and federal regulations and legal
requirements as well as the valid environmental protection
regulations.
1) ( 1-866-243-9861
5
Table Of Contents
Table Of Contents
Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Danger of damage to persons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Meaning of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Export . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Product information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Maintenance and care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Environmental protection information . . . . . . . . . . . . . . . . . . . . . . . . 14
General tanning instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Skin types . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . Fold-out page, 17
Overview, operating table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Settings during start-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Terminate tanning session . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Regulating face tanner. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Regulating surround cooling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . Fold-out page, 27
Maintenance, overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Maintenance intervals, installed lamps and order numbers . . . . . . . . 28
Cleaning/replacing UV low-pressure lamps in sunbed base . . . . . . . 33
Cleaning/replacing UV low-pressure lamps in canopy . . . . . . . . . . . 35
Cleaning/replacing UV high-pressure lamps/filter
panels in canopy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Cleaning filters in sunbed base . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Cleaning/replacing filter mats in canopy . . . . . . . . . . . . . . . . . . . . . . 41
Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Timer operation . . . . . . . . . . . . . . . . . . . see separate manual
Note:
Technical changes are reserved with respect to the illustrations and specifications in this instruction manual.
Reprinting and reproduction, in whole or in part, of this manual is only permitted with our previous written approval and
with specification of the source.
6
Safety
Safety
Safety
Description of warning signs
Danger notes, damage to persons:
Warning notes, damage to persons:
Caution notes, property damage:
CAUTION!
The word “CAUTION” with this label points out that danger for
devices, materials and the environment can be expected
here.
Important information:
Note:
This symbol does not identify safety notes, but states information for a better understanding of the processes.
Type and source of danger, e.g. “DANGER – High
voltage!”
DANGER!
Description of the consequences, e.g. “You can be
killed or injured by an electric shock!”
Countermeasures:
– Disconnect device from power supply before open-
ing.
– Do not reach into the inside or change lamps with the
device switched on.
Type and source of danger, e.g. “Warning – hot
surface!”
WARNING!
Description of the consequences, e.g. “You can burn
your hand (skin, face)!”
Countermeasures:
– Do not touch the lamps and nearby surfaces.
– Wait until lamps and surfaces have cooled down.
7
Intended use
Intended use
Intended use
The tanning device is intended exclusively for cosmetic tanning of the human skin:
• This device is used for tanning one adult person at a time.
• The user wears suitable eye protection that blocks UV radiation
during tanning.
Any other use shall be considered improper. The manufacturer cannot be
held liable for damage or injuries resulting from improper use. The operator bears the sole risk for this.
The proper use also includes compliance with the manufacturer’s instructions, operating, maintenance and regulation conditions. The device may
only be operated, maintained and repaired by persons familiar with these
tasks and that have been informed of the dangers involved.
Important notes for the studio operator
• As the operator you are responsible for informing users on possible
risks during tanning.
• All danger and safety labels attached to the device must be observed!
Do not remove them!
• No safety equipment (e.g. panel switch) may be removed or deactivated which can impair the safe operation of the device!
• The device may only be operated in proper condition!
Danger of damage to persons
DANGER – High voltage!
DANGER!
You can be killed or injured by an electric shock!
Assembly and electrical connection must comply with
the national and local regulations.
– Assembly, installation, upgrading or repair of the de-
vice may only be carried out by specially trained and
instructed personnel.
Warning – ultraviolet radiation!
WARNING!
Unprotected tanning may result in eye injuries and eye
diseases.
The unprotected eye can become inflamed on the surface, and in certain cases the retina can be damaged
by excessive radiation. Cataracts can form after frequently repeated exposure to radiation.
– Inform users to close their eyes during tanning and
use the included protective goggles that block UV
(Order No. 84592
1)
).
1) Global Service Division – see page II.
8
Danger of damage to
persons
Danger of damage to persons
Occasionally, persons using the tanning device will experience a slight
reddening of the skin – usually in small patches – after the second or third
session. This redness is often accompanied by an itching sensation. This
may be nothing more than a heat “rash” caused by heat from the lamps
within the device. It is generally very limited and caused by constant contact of the skin with the acrylic surface. It should go away within approximately 24 hours and should not reappear. This rashing can be lessened
or prevented by applying moisturizer lotion to the affected area after the
tanning session is completed.
– Follow instructions.
– The time between two tanning sessions must be at least 24 hours!
– Increasing tanning also requires an extension of the exposure time
(= radiation time) or after a certain degree of tanning has been achieved,
a further intensification is not possible. However, the radiation time may
not be extended as desired within the scope of the permissible radiation
doses! Therefore, only a certain degree of final tanning dependent on
the skin type can be achieved without endangering your health.
– Inform users about proper tanning – see page 14.
Warning – ultraviolet radiation!
WARNING!
As with natural sunlight, overexposure can cause eye
and skin injury and allergic reactions. Repeated exposure may cause premature aging of the skin and skin
cancer. Wear protective eye wear; failure to may result
in severe burns or long-term injury to eyes.
Warning – ultraviolet radiation!
WARNING!
Danger of long-term consequences.
– Nursing infants and small children through age
7 years may not use this device.
– The following applies to minors under the age of
18 years: Only use tanning devices in agreement with
a parent or guardian, or after consulting a physician.
– While there is no immediate clinical evidence of UVA
exposure and its effects upon expectant mothers, it is
strongly advised that expectant mothers be discouraged from using the tanning unit.
9
Meaning of symbols
Please read and observe ...
Meaning of symbols
Symbols for Description, Operation and Maintenance
General Symbols
Inform Customer Service
Soltron key
Do not touch, hot surface!
UV low-pressure lamp(s)
Starter for low-pressure lamp(s)
UV high-pressure lamp(s)
Filter panels
General Symbols
Cleaning and disinfectant agents
Part/article number (for orders)
Operation
Description
Press button
Press button for 2 seconds
Duration: 3 minutes
2s
e.g.
0-3 min
10
Meaning of symbols
Please read and observe ...
Loudspeaker
Headphone connection
Technical data
Maintenance
Caution, safety switch!
Unscrew/release screw with Soltron key
Tighten/lock screw with Soltron key
Two persons are required for this work step
Suction cup
Cleaning
Replacing
Clean or replace depending on soiling
Visual inspection
Filter/filter mat
Continuation of work steps on next page
End of work step
Troubleshooting
...
11
Guidelines
Please read and observe ...
Guidelines
This device was built according to UL STD 482, certified to CAN/CSA
STD C22.2 2 No. 224.
CAUTION – Air inflow and outflow
Do not change, obstruct or block the air inflow and outflow
area to the device or make any unauthorized changes to the
device. The manufacturer shall bear no liability for damage or
injuries resulting from such actions.
Export
We would like to point out that the devices are exclusively intended for
use in the US and Canada, and may not be exported to other countries
and operated there! The manufacturer shall assume no liability whatsoever in case of non-observance! We explicitly emphasize that high liability risks may occur for the exporter an/or the operator in case of nonobservance.
Equipment
The equipment of the devices differs depending on the model.
In this instruction manual all standard and optional components/functions
are taken into account which must be observed during operation and/or
when performing maintenance.
Accessories
Some accessory parts are taken into account in the maintenance schedule beginning on Page 29, however this does not automatically mean that
your device is provided with this equipment (e.g. Air Condition).
An overview of the possible accessories is provided in the sales documentation.
12
Product information
Please read and observe ...
Product information
Acrylic glass panels
The acrylic glass panels for the tanning devices are produced of acrylic
glass developed especially for this application. The acrylics used are characterized by a particularly high UV permeability and resistance, as well as
an easy-care, hygienic surface that is gentle to the skin.
The acrylic glass panels are formed to their shapes for the specific devices in a technically complex production process. Despite state-of-the-art
production know-how, the presence of minor spots, air bubbles or
streaks in the acrylic panels is unavoidable. In addition, microfine hairline
cracks can occur on the bed surface during operation.
These occurrences are material-dependent and are unavoidable in processing, however have no significant effect on the utility value and can
therefore not be recognized as defects.
CAUTION!
Cosmetics or sun screen products must be removed prior to
tanning as they can cause damage (e.g. fine cracks on the
surface) when used continuously.
Maintenance and care
Maintenance and care play a major role in deciding whether the device
meets the requirements placed on it in a satisfactory manner. The compliance with the specified maintenance intervals and the careful conducting of the maintenance and care work are therefore absolutely necessary
– see Page 29 ff.
Remount any protective devices (e.g. filter panels) after completing work.
CAUTION!
Only use original spare parts of the same type or compatible
parts! The use of other parts voids the conformity! Any liability
is excluded in case of damage or injury proven to be the result of the use of non-original spare parts.
Extreme danger! High voltage!
DANGER!
During maintenance work there is a danger of touching
live parts and receiving a fatal electrical shock.
• Disconnect device from power supply before
opening – also see Page 27.
• Do not reach behind covers, do not open the device
and do not replace lamps with the device switched
on.
13
Cleaning
Please read and observe ...
Cleaning
Acrylic glass surfaces
CAUTION!
Do not rub with a dry cloth – danger of scratching!
For fast, hygienic proper cleaning of acrylic glass surfaces,
use the specially developed fast disinfectant cleaner Antifect®.
Concentrated disinfectants or solvents (e.g. Lysoform, ethyl
alcohol or other liquids containing alcohol) may never be
used for cleaning. Other unsuitable cleaning agents that
cause damage due to chemical reactions may also not
be used!
Plastic surfaces
For cleaning the other plastic surfaces, it is best to use warm water and
a leather cloth. Never use aggressive cleaning agents containing alcohol,
e.g. the commercially available Sagrotan, or essential oils. These may
lead, in the long run, to damages not covered by the guarantee.
During cleaning a slight discoloration of the leather cloth by the rubber
seals must be expected for production-related reasons.
Note:
Prevent damage to the acrylic glass and plastic surfaces. Remove rings, watches, bracelets etc. before the start of cleaning work.
02756 / 0
14
Environmental protection
information
Please read and observe ...
Environmental protection information
Environmental Declaration – The JK Corporate Group
The JK corporate group is subject to the strict regulations of EC Directive
761/2001 and the standard DIN ISO 14001, and undergoes regular internal and external environment audits performed by trained auditors.
Environmental regulations – disposal of lamps
UV low-pressure lamps and UV high-pressure lamps contain fluorescent
materials and other waste containing mercury.
According to the national waste disposal laws and in accordance with the
municipal waste regulations, proof must be provided of the proper disposal of UV lamps.
Your local environmental agency will be happy to assist you with the disposal of UV lamps.
General tanning instructions
Who can get a tan?
Anyone who also gets a tan in natural sunlight. Persons with sensitive
skin even tan more pleasantly and with fewer worries, as the radiation
dosage can be exactly defined with sunbeds.
Certain drugs – particularly those that produce photosensitivity – may
cause individuals under the influence of this type drug to experience adverse effects and those people should avoid exposure to UV sources of
all kinds. Doctors will advice people taking these drugs to possible adverse effects.
The speed and intensity with which someone tans are dependent on the
skin type and the individual melanin quantity in the skin. No two individual
skin tones are the same. A tan to one person may be different to another
and treatment length may vary.
What is Melanin?
The brownish pigment produced by special cells in the base layer of your
skin determines the individual's tan. As the skin is exposed to the ultraviolet light, the melanin is activated and combines with protein cells that
rise to the skin's surface, thus producing a tan. The amount of melanin in
your body determines how quickly and dark you tan. The more melanin
produced and exposure time an individual has, the faster and deeper the
individual will tan.
Loading...