Prescolite SDPS6LED User Manual

InstructionSheet

M

OUNTING

PLATE

BLACK

GREEN

WHITE

J

-BOX

DRIVER

GROUND WIRE

WHITE TO WHITE

BLACK TO BLACK

WIRENUT (3)
(NOT SUPPLIED)

CHAIN

DRIVER HEAT SINK
BRACKET GROUND
WIRE

CANOPY

J

BOX GREEN

G

ROUND WIRE

MOUNTING
BRACKET

FOR SDPSLED

FIG 2

8-32 FLAT HEAD
SCREWS
(SUPPLIED)

CAPTIVE SCREW

LIGHT ENGINE
WIRE ASSEMBLY

DRIVER
WIRE ASSEMBLY

SAFETY
CABLE

FIG 3

FIG 4

InstructionSheet

Part No. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93012106

IMPORTANT SAFETY INFORMATION. READ AND FOLLOW ALL SAFETY INSTRUCTIONS. Follow label information
and instructions concerning Wet or Damp Locations, installation near combustible materials, insulation, building materials,
and proper lamping. Do not install in areas subject to combustible vapors or gases. Before wiring to power supply and
during servicing or relamping, turn off power at fuse or circuit breaker. All servicing or relamping must be performed by

qualified service personnel. Product must be grounded to avoid potential electric shock or other potential hazard.
Product must be mounted in locations and at heights and in a manner consistent with its intended use, and in
compliance with the National Electrical Code and local codes. The use of accessory equipment not recommended by

the manufacturer or installed contrary to instructions may cause an unsafe condition. Do not block light emanating from
product in whole or part, as this may cause an unsafe condition. Do not allow items such as drapes, curtains, screens or
the like to come into contact with the product or to block light from the product, as this may cause an unsafe condition.
WARNING - This product contains chemicals known to the State of California to cause cancer, birth defects, and/or other
reproductive harm. Thoroughly wash hands after installing, handling, cleaning, or otherwise touching this product.

INSTALLATION INSTRUCTIONS

SDPS6LED SERIES

1. LOOSEN SCREWS ON J-BOX HALF WAY
(SUPPLIED BY OTHERS).

2. LOCATE THE BLACK (LINE), WHITE (COMMON), &
GREEN (GROUND) WIRES IN THE FIXTURE WIRING
COMPARTMENT AND PASS THESE WIRES THROUGH
CENTER HOLE OF MOUNTING PLATE AS SHOWN IN TOP
FIGURE.

3. (DIMMING ONLY) THERE WILL BE A GRAYAND VIOLET
WIRE (1 EACH). PASS THESE THROUGH HOLE WITH
OTHER WIRES.

4. ALIGN MOUNTING PLATE TO J-BOX, ROTATE PLATE
COUNTERCLOCKWISE, AND TIGHTEN WITH SCREWS.

NOTE: THE FIXTURE SHOULD BE ALLOWED TO HANG
ON ITS CHAIN AT THIS POINT.

5. REMOVE J-BOX COVER PLATE. REMOVE APPROPRIATE
KNOCKOUT AND ASSEMBLE APPROPRIATE CONNEC­TOR FOR THE SUPPLY WIRE USED. CONNECT GROUND
WIRES TO GREEN GROUND LEADS. CONNECT WHITE
(COMMON) TO WHITE (LEADS). CONNECT POWER SUP­PLY (LINE) TO BLACK LEAD(S). (DIMMINING ONLY) CON­NECT GRAY (+) AND VIOLET (-) WIRES TO APPROPRIATE
0-10V DIMMING CONTROL PER NATIONAL ELECTRICAL
CODE AND ALL LOCAL CODES. REINSTALL J-BOX
COVER.

WARNING: DO NOT PINCH WIRES BETWEEN
J-BOX/BALLAST COVER AND J-BOX. CONSULT A
QUALIFIED ELECTRICIAN FOR ALL OTHER OPTIONS

T REQUIRE OTHER WIRING CONFIGURA

THA

6. PUSH THE SPLICES INTO THE J-BOX. HOLD UP THE FIX­TURE WHILE DOING THIS TO PREVENT STRAIN ON THE

AND WHITE WIRES.

BLACK

7. PUSH CHAIN AND GREEN BRACKET GROUND WIRE
INSIDE COVER.

8. ALIGN SIDE HOLES ON CANOPY TO SIDE HOLES ON
MOUNTING BRACKET
SCREWS SUPPLIED (FIG 3.).

ASTEN WITH FLA

AND F

TIONS.

T HEAD

-----www.prescolite.com • Prescolite TollFree Technical Support 1.888.PRS.4TEC • Hours: 8am - 5pm

CAUTION: DO NOT ATTEMPT TO MODIFY OR REWIRE

KEEP THESE INSTRUCTIONS

701 Millennium Boulevard • Greenville, SC 29607

ith representatives of

W
Copyright 2009, 10/30/09 revision, All Rights Reserved - Printed in U.S.A.

OR

ACT

F
TURE. SAFETY AND PROPER OPERATION OF
THE FIXTURE DEPEND ON THE INTEGRITY OF
THE WIRING.

ALLED WIRING ON THE FIX

-INST

Y

fices in principal cities throughout North

-

America.

InstructionSheet

C

APTIVE SCREW

L

IGHT ENGINE

W

IRE ASSEMBLY

DRIVER
WIRE ASSEMBLY

S

AFETY

CABLE

F

IG 4

DRIVER

GROUND WIRE

W

HITE TO WHITE

B

LACK TO BLACK

WIRENUT (3)
(NOT SUPPLIED)

CHAIN

D

RIVER HEAT SINK

B

RACKET GROUND

W

IRE

CANOPY

J

BOX GREEN

GROUND WIRE

MOUNTING
BRACKET

FOR SDPSLED

FIG 2

Part No. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93012106

LED ARRAY REPLACEMENT

1. REMOVE THE TRIM BY LOOSING THE CAPTIVE
SCREW.

2. DISCONNECT LIGHT ENGINE WIRE ASSY FROM DRI­VER WIRE ASSY.

3. LOOSEN AND REMOVE SAFETY CABLE FROM BOT­TOM OF REFLECTOR SUB-ASSEMBLY.

4. REMOVE (3) MOUNTING SCREWS FROM REFLEC­TOR. REPLACE LIGHT ENGINE AND SECURE WITH (3)
MOUNTING SCREWS..

5. RECONNECT SAFETY CABLE TO LOWER HOLE IN
REFLECTOR. CONNECT REPLACEMENT LIGHT.
ENGINE WIRE ASSY TO DRIVER WIRE ASSY.

6. SLIDE REFLECTOR AND LIGHT ENGINE SUB ASSEM­BLY IN PLACE.

7. TIGHTEN CAPTIVE SCREW.

LED DRIVER REPLACEMENT

1. WHILE HOLDING FIXTURE AT CANOPY, REMOVE FLAT
HEAD SCREWS ON THE SIDES. SLOWLY LOWER FIX­TURE. IT SHOULD BE ALLOWED TO HANG ON ITS
CHAIN AT THIS POINT.

2. NOTE WIRING CONNECTIONS AND DISCONNECT AS
REQUIRED. UNSCREW THE 2 DRIVER MOUNTING
SCREWS.

3. REPLACE OLD DRIVER WITH NEW ONE BY TIGHTEN­ING THE 2 DRIVER MOUNTING SCREWS. RECON­NECT ALL WIRING

4. PUSH CHAIN AND GREEN BRACKET GROUND WIRE
INSIDE COVER.

5. ALIGN SIDE HOLES ON CANOPY TO SIDE HOLES ON
MOUNTING BRACKET AND FASTEN WITH FLAT HEAD
SCREWS SUPPLIED.

www.prescolite.com • Prescolite TollFree Technical Support 1.888.PRS.4TEC • Hours: 8am - 5pm ET

CAUTION: DO NOT ATTEMPT TO MODIFY OR REWIRE

FACTORY-INSTALLED WIRING ON THE FIX­TURE. SAFETY AND PROPER OPERATION OF
THE FIXTURE DEPEND ON THE INTEGRITY OF
THE WIRING.

701 Millennium Boulevard • Greenville, SC 29607

ith representatives of

W
Copyright 2009, 10/30/09 revision, All Rights Reserved - Printed in U.S.A.

fices in principal cities throughout North

America.

InstructionSheet

DRIVER

GROUND WIRE

WHITE TO WHITE

BLACK TO BLACK

WIRENUT (3)
(NOT SUPPLIED)

CHAIN

DRIVER HEAT SINK
BRACKET GROUND
WIRE

CANOPY

JBOX GREEN
GROUND WIRE

MOUNTING
BRACKET

FOR SDPSLED

CEILING OUTLINE

FIG 2

Part No. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93012106

www.prescolite.com • Prescolite TollFree Technical Support 1.888.PRS.4TEC • Hours: 8am - 5pm ET

FULLY INSTALLED

FIXTURE

701 Millennium Boulevard • Greenville, SC 29607

ith representatives of

W
Copyright 2009, 10/30/09 revision, All Rights Reserved - Printed in U.S.A.

fices in principal cities throughout North

America.