Page 1
SECTION 3. PARTS INFORMATION
3-1. INTRODUCTION This section lists the replaceable parts of the Henny Penny
OFE-321 & 322 Open Fryers.
3-2. GENUINE PARTS Use only genuine Henny Penny parts in your fryer. Using a part of
lesser quality or substitute design may result in damage to the unit
or personal injury.
3-3. WHEN ORDERING
PARTS Once the parts that you want to order have been found in the parts
list, write down the following information:
Item Number 8
Part Number 31561 Example:
Description On/Off Switch
From the data plate, list the following information:
Product Number 01400
Serial Number 0001 Example:
Voltage 208
3-4 PRICES Your distributor has a price parts list and will be glad to inform
you of the cost of your parts order.
3-5 DELIVERY Commonly replaced items are stocked by your distributor and will
be sent to you when your order is received. Other parts will be
ordered, by your distributor, from Henny Penny Corporation.
Normally, these will be sent to your distributor within three
working days.
3-6 WARRANTY All replacement parts (except lamps and fuses) are warranted for
90 days against manufacturing defects and workmanship. If
damage occurs during shipping, notify the carrier at once so that
a claim may be properly filed. Refer to warranty in the front of this
manual for other rights and limitations.
3-7. RECOMMENDED Recommended replacement parts, stocked by your
SPARE PARTS FOR distributor, are indicated with in the parts lists. Please
DISTRIBUTORS use care when ordering recommended parts, because all
voltages and variations are marked. Distributors should
order parts based upon common voltages and equipment
sold in their territory.
206 3-1
Page 2
Figure 3-1. Electric Heat Controls
3-2 405
Page 3
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-1 ELECTRIC HEAT CONTROLS
1 26863 SPEAKER ASSY 1 2
2 24916 SPEAKER BRACKET ASSY. 1 2
3 60536 24V/230V TRANSFORMER ASSY. 1 2
4 27286RB I/O BOARD ASSY. 1 2
5 60241 425 HIGH LIMIT ASSY. 1 2
6 EF02-006 20A 250V FUSE HOLDER 2 4
6 EF02-007 15 AMP FUSE (SN: BA0608031 & below) 2 4
6 EF02-125 BREAKER-PUSH BUTTON RESET (SN: BA0608032 & after)2 4
7 14990 KIT – ELECTRIC TEMP PROBE 1 2
8 29509 KIT–E/M 24V CONTACTOR–PRIMARY 1 2
8 29510 24V MERCURY CONTACTOR (SN: BA08010019 & BEFORE) 1 2
8 65073 CONTACTOR – E/M (SN: BA08010020 & AFTER) 1 2
9* 60810 I/O BOARD TO CONTROL CABLE - 4 PIN 1 2
10* 60838 TRANSFORMER -480V TO 240V - OFE-322 - 2
11* 60847 TRANSFORMER MOUNTING BRACKET - 2
12* 19923 TRANSFORMER-LARGE--480V-240V - OFE-321 1 -
13* 60722 BLOCK – 60 AMP FUSE (208-240V FRYERS) 1 2
14* 14970 KIT-60 AMP FUSE - SET OF 3 (208-240V FRYERS) 1 2
15* 24347 ASSEMBLY – CURRENT SENSE XFORMERS 1 2
16* 27290 ASSEMBLY – CURRENT SENSE PCB 1 2
recommended parts
*not shown
814 3-3
Page 4
Figure 3-2. Side, Top, & Rear Panels
3-4 109
Page 5
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-2 SIDE, TOP, AND REAR PANELS
1 26901 TUBE, OIL RETURN LINE – OFE-322 (before 12-1-06) - 1
1 73957 TUBE, OIL RETURN LINE – OFE-322 (after 12-1-06) - 1
2 FP01-082 CONNECTOR - 3/8 TUBE TO ½ NPT SS– OFE-322 - 2
3 FP01-087 ELBOW– OFE-322 - 1
4 NS02-002 NUT, END PANEL RETAINING 6 6
5 WA01-002 FLAT WASHER 6 6
6 SC01-216 SCREW 6 6
7 60552 SIDE PANEL, RH 1 1
8 59042 TOP REAR COVER (2 WELL) - 1
8 59043 TOP REAR COVER (1 WELL) 1 -
9 SC03-005 SCREW, BOX RETAINING 2 2
10 63097 TERMINAL BLOCK – 2 POLE 1 1
11 60312 CASTER 4 IN. W/O BRAKE 2 2
12 60551 SIDE PANEL, LH 1 1
13 26877 COVER – JUNCTION BOX – 32X - CFA 1 1
14 26876 BOX – JUNCTION – 32X – CFA 1 1
15 36012 ASSY – CAPACITOR/RESISTOR 1 1
109 3-5
Page 6
Figure 3-3. Oil Filtering System
3-6 405
Page 7
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-3 OIL FILTERING SYSTEM
1 66005 FRONT PLATE 1 -
2 17320 PIPE, FRONT 1 -
3 55152 DRAIN VALVE & COUPLING ASSY. 1 2
4 60736 DRAIN VALVE EXT. (ELECT.) (SN: GM024JB
& BELOW) 1 2
4 24643 DRAIN VALVE EXT. (ELECT.) (SN: GM025JB
& ABOVE) 1 2
5 16239 ELBOW, FILTER PUMP 1 -
6 67589 ASSY – FILTER PUMP & MOTOR 1 1
6 67583 FILTER PUMP MOTOR, 1/2 HP 1 1
7 17437 FILTER PUMP 1 1
8 26966 ASSY – POT TO PUMP TUBE – OFE-321 1 -
9 16809 NUT, FILTER TO VALVE TUBE 2 -
10 16808 FERRULE, FILTER TO VALVE TUBE 2 -
11 17407 ELBOW, FILTER PUMP TUBE 1 -
12 17306 TEE 1 -
13 50715 NIPPLE 1 -
14 17308 VALVE, FILTER 1 -
15 17334 QUICK CONNECT FITTING 1 -
16 SC03-005 SCREW, PLATE RETAINING 2 -
405 3-7
Page 8
Figure 3-4. Door, Switches, Menu Card, & Control Board
3-8 1005
Page 9
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-4 DOOR, SWITCHES, MENU CARD, & CONTROL BOARD
1 67924RB 12 TIMER CONTROL BOARD ASSY. 1 2
2 60442 FILTER TO PUMP TUBE ASSY. 1 1
3 71874 RIGHT DOOR ASSY. (2 WELL) (SN: BA0604017 & above) - 1
3 60501 RIGHT DOOR ASSY. (2 WELL) (SN: BA0604016 & below) - 1
3A 17618 HINGE – DOOR – TOP - 1
3B 17620 HINGE – DOOR – BOTTOM - 1
4 52064 4 IN. SWIVEL CASTER W/ BRAKE 2 2
5 60609 DECAL, FILTER POWER SWITCH 1 1
6 60844 SWITCH GUARD, FILTER SWITCH 1 1
7 43768 FILTER SWITCH 1 1
8 60608 DECAL, MAIN POWER SWITCH 1 2
(321-SN: BA0604010 & below; 322-SN: BA0604001 & below)
8 72677 DECAL, MAIN POWER SWITCH 1 2
(321-SN: BA0604011 & above; 322-SN: BA0604002 & above)
9 60844 SWITCH GUARD, POWER SWITCH 1 2
10 72277 POWER SWITCH ASSY. 1 2
11 18227 DRAIN MICROSWITCH 1 2
11 14681 KIT – OFE-321 N/O DRAIN SWITCH-CONVERSION 1 11 14651 KIT – OFE-322 N/O DRAIN SWITCH-CONVERSION - 1
12 NS02-005 NUT 2 4
13 18818 DRAIN VALVE EXTENSION ROD 1 2
13 74193 ROD – N/O 320 DRAIN 1 2
14 SC01-058 SCREWS, COVER & BRACKET RETAINING
(6-32 X 1.5 IN.) 2 4
15 SC03-005 SCREWS, BRACKET RETAINING 2 4
16 60718 DRAIN SWITCH BRACKET (OFE-322) - 2
16 24802 DRAIN SWITCH BRACKET (OFE-321) 1 17 71875 LEFT DOOR ASSY. (2 WELL) (SN: BA0604017 & above) - 1
17 60502 LEFT DOOR ASSY. (2 WELL) (SN: BA0604016 & below) - 1
17 71870 DOOR ASSY. (1 WELL) (SN: BA0604017 & above) 1 17 60542 DOOR ASSY. (1 WELL) (SN: BA0604016 & below) 1 17A 17618 HINGE – DOOR – TOP 1 1
17B 17620 HINGE – DOOR – BOTTOM 1 1
18 61724 CFA MENU CARD 1 2
19 69289 ASSY – FILTER UNION 1 1
20* 18911 FILTER VALVE HANDLE (OFE-321) 1 -
21* 17002 DOOR MAGNET 1 2
22* 60503 BRKT – MAGNET 1 2
23* SC03-005 SCREWS 2 4
recommended parts
*not shown
109 3-9
Page 10
Figure 3-5. Baskets and Return Faucet
3-10 405
Page 11
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-5 BASKETS AND RETURN FAUCET
1 26873 FRYPOT COVER 1 2
2 21033 HALF SIZE BASKET 2 4
2 69085 HALF SIZE BASKET – FRONT & REAR HOOK 2 4
3 FP01-087 ELBOW, MALE, 3/8 IN. 1 1
4 17333 FEMALE DISCONNECT 1 1
5 17334 MALE DISCONNECT 1 1
6 70560 ASSY-RETURN FAUCET W/MALE DISCONNECT-322 - 1
7* 140124 KIT-321CFA-BSKT REST REINFRCMT 1 PER VAT
8* 140136 KIT-321CFA-BSKT REST REINF 1 PER VAT
215 3-11
Page 12
Figure 3-6. Shrouds and Pot & Counter Top
3-12 405
Page 13
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-6 SHROUDS AND POT & COUNTER TOP
1 SC03-005 SCREW, BRACKET RETAINING, BOTTOM 2 2
2 SC01-034 SCREW, BRACKET RETAINING, TOP 2 2
3 60340 BRACKET, REAR SHROUD 1 2
4 63700 REAR SHROUD ASSY. 1 -
4 26870 REAR SHROUD ASSY. - 1
5 24899 POT & COUNTERTOP ASSY. (OFE-321) 1 -
5 24896 POT & COUNTERTOP ASSY. (OFE-322) - 1
6 60322 SHROUD CONTROL VERTICAL RH 1 1
7 60328 SHROUD CONTROL UPPER MIDDLE - 2
8 SC04-003 SCREW 4 9
9 60326 SHROUD CONTROL DIVIDER - 1
10 71938 BOTTOM SWITCH GUARD (SN: BA0604017 & above) 1 10 60605 BOTTOM SWITCH GUARD (SN: BA0604016 & below) 1 -
10 69634 BOTTOM SWITCH GUARD (SN: BA0604017 & above) - 1
10 60606 BOTTOM SWITCH GUARD (SN: BA0604016 & below) - 1
11 SC1-034 SCREW 2 2
12 NS02-007 NUT 2 2
13 60324 SHROUD CONTROL VERTICAL LH 1 1
14 SC03-005 SCREW, SHROUD RETAINING 4 4
15 N02-006 NUT, SHROUD RETAINING 4 6
16 N02-006 NUT, RETAINER SECURING - 2
17 33261 REAR SHROUD RETAINER - 1
707 3-13
Page 14
Figure 3-7. Electric Heater
3-14 313
Page 15
3
9
10
8
7
7
7
7
7
5
4
4
4
10
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-7 ELECTRIC HEATER
1 30292-2 HEATING ELEMENT – 208V 7333W 3 6
1 30292-6 HEATING ELEMENT – 240V 7333W 3 6
1 30292-1 HEATING ELEMENT – 480V 7333W 3 6
2 26917 FRY BASKET SUPPORT 1 2
3 95349 ASSY-HI LIMIT HLDR/SPDR LH 1 2
4 95182 --ASSY-HEX HD SCR/SPCR #10UNF 5 10
5 93270 --CLAMP-HI LIMIT 1 2
6 95350 --WELD ASSY-HI LIMIT HLDR/SPDR L 1 2
7 95354 --RETAINER-ELEMENT SPREADER 5 10
8 SC01-288 --SCREW #8-32 X 1 HEX HD S 2 4
9 95352 ASSY- CORNER SPREADER LH 1 2
--Includes #4, 7
10 95246 ASSY- CORNER/SIDE SPRDR RH 1 2
--Includes #4, 7
recommended parts
313 3-15
Page 16
Figure 3-8. Drain Pan, Screen, and Cover
3-16 1005
Page 17
FIGURE & PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-8 DRAIN PAN, SCREEN, & COVER
1 14671 KIT – 32X SS FILTER SCREEN ASSY (INCLUDES #8) 1 1
2 65211 CRUMB CATCHER 1 1
3 65447 BOTTOM FILTER SCREEN 1 1
4 17505 FILTER ENVELOPE CLIPS 2 2
5 69118 ASSY-32X SS FILTER SCREEN PIPE 1 1
6 69289 ASSY – FILTER UNION 1 1
7 70360 STANDPIPE TUBE (SN: BA0604017 & above) 1 1
7 60377 STANDPIPE TUBE (SN: BA0604016 & below) 1 1
8 65208 NUT, FILTER - SS 1 1
9 12102 FILTER ENVELOPE PAPER 5 5
10 81123 DRAIN PAN COVER (321) (SN: 10/7/08 & AFTER) 1 -
10 71597 DRAIN PAN COVER (321) (SN: BA0604017 to 10/7/08) 1 -
10 21064 DRAIN PAN COVER (321) (SN: BA0604016 & below) 1 -
10 71599 DRAIN PAN COVER (322, SN: BA0604017 & above) - 1
10 24596 DRAIN PAN COVER (322, SN: GM046JB-BA0604016) - 1
10 60460 DRAIN PAN COVER (322, SN: GM045JB & below) - 1
11 21088 DRAIN PAN (321) (SN: BA0604016 & below) 1 11 70344 DRAIN PAN (321) (BA0604017 to BA0810007) 1 11 81120 DRAIN PAN (321) (BA0810008 & ABOVE) 1
11 66522 DRAIN PAN (322) (SN: BA0604017 & below) - 1
11 70345 DRAIN PAN (322) (SN: BA0604018 & above) - 1
12 03003 RINSE HOSE ASSY. 1 1
13 03495 DRAIN PAN DOLLY–321(SN: BN0604042 & BELOW) 1 13 03548 DRAIN PAN DOLLY–321(SN: BN0604043 & AFTER) 1 -
13 03496 DRAIN PAN DOLLY–322 (SN: BN0604031 & BELOW) - 1
13 03549 DRAIN PAN DOLLY–322 (SN: BN0604032 & ABOVE) - 1
14 17502(USE 14671) TOP FILTER SCREEN 1 1
recommended parts
If unit has 3 filter screens, use part no. 14671
109 3-17
Page 18
Figure 3-9. Autolift Feature
3-18 109
Page 19
FIGURE &. PART NO. DESCRIPTION QTY. PER UNIT
ITEM NO. 321 322
3-12 AUTOLIFT FEATURE
1 50814 FRYPOT COVER, AUTOLIFT 1 2
2 50750 FILTER VALVE, OIL RETURN 1 1
3 50764 MICROSWITCH, RIGID LEVER 1 2
4 50716 ACTUATOR, AUTOLIFT, 24V MOTOR (SN: EN040JB)
& BELOW) 2 4
4 63602 ACTUATOR, AUTOLIFT, 24V MOTOR (SN: EN041JB
UP TO BP0812001) 2 4
4 80091 ACTUATOR, AUTOLIFT, 24V MOTOR (SN: BP0812001
& ABOVE) 2 4
5 50780 TUBE, UNION TO WELL 2, FILTER SYSTEM - 1
6 50779 TUBE, UNION TO WELL 1, FILTER SYSTEM - 1
7 FP01-129 UNION, TEE, 3/8 IN. TUBE SS, FILTER SYSTEM - 1
8 50778 TUBE, PUMP TO UNION, FILTER SYSTEM - 1
9 50776 PIN, ACTUATOR CLEVIS 2 4
10 50865 BASKET HANGER ASSY. 2 4
11 31421 ...BEARING WITH SCREW 4 8
12 FP01-128 CONNECTOR (3/8 IN. TUBE TO 3/8 IN. NPT SS),
FILTER SYSTEM - 1
13* NS03-023 ...NUT, 1/4-20 ACORN CAP 4 8
14 50785 TUBE, OIL RETURN, LONG, FILTER SYSTEM - 1
14 60611 RETURN FAUCET ASSY. (WITH 17334 DISCONNECT) 1 1
15 60796RB GM 12 BUTTON CONTROL (321) 1 2
16 61562 MENU CARD, AUTOLIFT 2 4
17 NS02-005 NUT 4 8
18 50290 BASKET LIFT PCB ASSY. 1 2
19 ME50-024 SPACER 4 8
20 30614 TRANSFORMER (208/240V-PRI, 24V-SEC.) 1 2
21 59721 RETURN VALVE HANDLE - 2
22 50704 1/2 SIZE BASKET 2 4
23 50703 FULL SIZE BASKET 1 2
24 26901 TUBE, OIL RETURN LINE (before 12-1-06) 1 -
24 73957 TUBE, OIL RETURN LINE (after 12-1-06) 1 -
25* 50786 TUBE, 2.00 NIPPLE, FILTER SYSTEM - 1
26 FP01-082 CONNECTOR (3/8 TUBE TO ½ NPT SS) 1 -
27 FP01-087 ELBOW 1 1
28 17333 DISCONNECT – FEMALE (USED W/60611) 1 1
29 TS22-012 TRANSFORMER – AUTOLIFT 1 2
recommended parts
*not shown
109 3-1
Loading...