Groen SSB-5G User Manual

SMARTSTEAM100 BOILERLESS STEAMER

PROJECT NAME:

LOCATION:

ITEM NO:

MODEL SSB-5G/GF

Steamer shall be a Groen Model SSB-5G/GF SmartSteam100™ stainless steel, boilerless, convection steamer
with a self-contained atmospheric 58,000 BTU/hr gas steam generating reservoir.

CONSTRUCTION: Steamer cavity and cabinet

shall be all stainless steel construction, with removable
right and left-side panels, providing access to internal
components. Steamer shall have no side vents for
increased water/spray resistance. Steamer door shall
be all stainless steel with a strong continuous hinge
and field-reversible for left or right swing. Door shall
be insulated and provided with a one-piece, replaceable
seal. Easy-open door handle and latch shall provide
positive lock and seal when door is pushed or slammed
shut. A hidden magnetic door switch shall cut power
to blower fan and shut down power to the steam
generating reservoir when the door is opened. Pan
support racks shall be stainless steel and removable for
easy cleaning. A stainless steel condensate collection
tray shall be positioned under the cavity door.

FINISH: Cabinet exterior, including door, shall be a #3

uniform finish. Cavity interior shall be polished stainless
steel. Control panel face plate shall be smudge-resistant
polyester film, ensuring maximum ease in cleaning and
maintenance of an attractive appearance.

CSA LISTING: Steamer shall be CSA (formerly CGA)

design certified.

SANITATION: Steamer shall be designed and

manufactured to meet NSF requirements and all known
health codes. Steamer shall be NSF listed.

CONTROLS: Steamer controls shall include an

on-off rocker switch; electronic timer, with continuous
steam, timed steam and stop buttons; READY light which
indicates when cavity is warm and ready for steaming.

PERFORMANCE FEATURES: Steamer cavity

shall have a powerful, side-mounted blower to increase
steam velocity and provide efficient steam distribution
throughout the cavity and between loaded pans. Steam
generator shall deliver 11,600 BTU/hr of power input per
2-1/2” deep steam pan. Steamer shall have a steam lid
positioned over the steam generating reservoir to ensure

that adding/removing food does not lower the cavity
or water temperature. Heat up time to READY shall
typically be 15 minutes or less. Cavity is kept warm
and ready for instant steam between loads. No cavity
warm up required after READY light comes on.

ATMOSPHERIC STEAM GENERATING
RESERVOIR:

steam generating reservoir to provide atmospheric
steam to the cavity at a temperature of approximately
212° F. The high-efficiency steam generating
reservoir shall have water level sensors. Gas heater
shall have infrared burners with a firing rate of
58,000 BTU/hr. Acidic products and other commercial
chemicals shall not be used to clean the steamer. A
daily wipe down of the steamer cavity, steam lid and
floats is sufficient to maintain optimal operation of the
steamer. However, Groen Descaler or approved equal
may be required.

Steamer shall have a gas-heated

PAN CAPACITY:

Pan Size/ Type Total

12 x 20 x 1” 10

12 x 20 x 2 1/2” 5

12 x 20 x 4” 3

INSTALLATION: Each steamer shall require

natural or propane (specify) gas service via a 1/2
NPT gas supply line or approved equivalent. Each
cavity shall have (2) 3/4” NH cold water supply line
connections and a single 1-1/2” free venting drain
connection. Each steamer shall require 115 Volt,
single-phase electrical service.

WATER SUPPLY REQUIREMENTS:

Steamer must be connected to an on-site water
supply. Water supply at 30 - 60 PSIG with flow at
.75 - 1.5 GPM per cavity.

ORIGIN OF MANUFACTURE: Designed and

manufactured in the United States.

QTY:

MODEL NO:

AIA NO:

SIS NO:

5-Pan Boilerless Convection Steamer,
table top or stand-mounted, stainless
steel, self-contained, gas heated.
(Model SSB-5EF shown)

OPTIONS/ACCESSORIES:

Factory Stacking Kit
Stainless Steel Support Stand
Pan Rack Kit

(for support stand)

Flanged Foot Kit

(for support stand)

Caster Kit (for support stand)
High Altitude Kit

(above 2000’, specify)

Heat Shield Kits
4” Adjustable Legs

(table top only)

SmartSteam 100

144869 RevH

Revised 12/15

P/N 145120 REV K

SSB-5G/GF

888-994-7636, unifiedbrands.net

© 2015 Unified Brands. All Rights Reserved. Unified Brands is a wholly-owned subsidiary of Dover Corporation.