DoorKing 1601-083 Installation Manual
PLASTIC FOLDING ARM KIT
www.leedan.com info@leedan.com Toll-Free: 800-231-1414
This kit is designed for the 1600 model barrier gate operators only. Recommended for low headroom applications.
Kit Includes:
Locking Eye BoltLocking Turnbuckle
(Connected)
Arm Hinge
8 Self Tapping Screws
Pre-Crimped Eyelet
2 Plastic Arms
Cable Attachment Assembly
Cable
Cable
Clamp
Cable Eyelet
Installation
Cut Arms to Length
Note: Completed folding arm
assembly shown in the UP position
to illustrate the total height.
DoorKing Part Number
1601-083
Cut this arm
1
first for the
height
limitations.
Total Height
Determining First Arm Length
Note: Completed folding arm assembly
shown in the DOWN position to illustrate
traffic lane width.
Cut this arm second for the
2
traffic lane width.
Note: Second arm can be a
different size than the first.
Determining Second Arm Length
Traffic Lane Width
120 Glasgow Avenue
Inglewood, California 90301
U.S.A.
Installing Arms
www.leedan.com info@leedan.com Toll-Free: 800-231-1414
DoorKing Part Number
1601-083
Existing Stud
Top View of
Operator Housing
3A
Hub
Install inner arm
1
on hub.
Cable Eyelet MUST be installed in turnbuckle.
Adjust to clear hub.
Bushing
Locknut
Cut off excess cable.
Remove stud from operator housing
and assemble as shown.
Bolt Head (Inside Housing)
3A
Pre-Crimped Eyelet
Install cable. Cable MUST clear hub!
3
Cable Clamp
Washer (Inside Housing)
Operator Housing
Allow turnbuckle to
loosen or tighten.
Install eye bolt into arm
2
hinge with vise-grips.
Attach arm hinge to
inner arm with 4
self-tapping screws.
4
Install outer arm
with 4 self-tapping
screws.
Side View of
Operator Housing
Adjusting and Locking Cable Assembly
After adjusting cable tension, lock turnbuckle
with nuts to keep turnbuckle from twisting.
Lock eye bolt with nut to keep eye bolt from twisting.
Inner Arm
Rotate arm up and down. Adjust cable tension with turnbuckle
to level outer arm. Make sure that cable assembly is not binding
or twisting and everything moves freely.
Important: Do not adjust cable too tight or it will bind.
Outer Arm
1601-266-A-2-09
Copyright 2009 DoorKing, Inc. All rights reserved.
120 Glasgow Avenue
Inglewood, California 90301
U.S.A.
Loading...