120000, 150000, 200000, 210000
GB
D
DK
E
F
GR
I
N
NL
P
S
SF
Operating & Maintenance Instructions Betriebsanleitung & Wartungsvorschriften Drifts og vedligeholdelsesvejledning Instrucciones de Mantenimiento & Operación Instructions d'utilisation et de maintenance
ПдзгЯет ЛейфпхсгЯбт & УхнфЮсзузт
Istruzioni per l'uso e la manutenzione Anvisninger for bruk og vedlikehold Gebruiksaanwijzing
Instruções de operação e de manutenção Instruktionsbok
Käyttö & Huolto ohjeet
Briggs & Stratton Corporation |
|
|
Milwaukee, Wisconsin 53201 |
|
FORM NO. MS-3419-7/05 |
www.briggsandstratton.com |
♥ Copyright 2005 by Briggs & Stratton Corporation |
PRINTED IN U.S.A. |
Fig. 1 |
1 |
8 |
|
||
|
2 |
12 |
|
9 |
|
|
|
|
3 |
|
10 |
|
|
13
4
14
5
15
11
6
16
7
Fig. 2 Ê |
Ë |
Ì |
Í |
Î |
Ï |
Ð Ñ Ò
Fig. 3
Ì |
|
Ë |
Ï Ð |
|
Ê
Í
Î
Note: (This note applies only to engines used in the U.S.A.) Maintenance, replacement or repair of the emission control devices and systems may be performed by any nonroad |
GB |
engine repair establishment or individual. However, to obtain no charge repairs under the terms and provisions of the Briggs & Stratton warranty statement, any service or |
|
emission control part repair or replacement must be performed by a factory authorized dealer. |
|
ENGINE COMPONENTS
Fig. 1 Power BuiltE
Snow Models
1Snow hood fasteners to access spark plug
2Muffler
3Spark plug *
4Primer bulb
5 Engine Model |
Type |
Code |
xxxxxx |
xxxxxx |
xxxxxxxx |
6Low oil fill
7Oil drain
8Choke control
9Push / Pull safety key 10 Stop switch
11Rope handle 12 Fuel fill
13Dipstick / Oil fill
14Electric start button
15Power receptacle
16Electric starter
Record your engine Model, Type and Code numbers here for future use.
Record your date of purchase here for future use.
TECHNICAL INFORMATION
Power Ratings
The power ratings for an individual engine model are initially developed by starting with SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure) (Revision 2002805). Given both the wide array of products on which our engines are placed, and the variety of environmental issues applicable to operating the equipment, it may be that the engine you have purchased will not develop the rated horsepower when used in a piece of power equipment (actual •on8site" power). This difference is due to a variety of factors including, but not limited to, the following: differences in altitude, temperature, barometric pressure, humidity, fuel, engine lubrication, maximum governed engine speed, individual engine to engine variability, design of the particular piece of power equipment, the manner in which the engine is operated, engine run8in to reduce friction and clean out of combustion chambers, adjustments to the valves and carburetor, and other factors. The power ratings may also be adjusted based on comparisons to other similar engines utilized in similar applications, and will therefore not necessari8 ly match the values derived using the foregoing codes.
GENERAL INFORMATION
In the state of California, OHV Model Series 120000 engines are certified by the California Air Resources Board to meet emissions standards for 125 hours; Model Series 150000, 200000 and 210000 for 250 hours. Such certification does not grant the purchaser, owner or operator of this engine any additional warranties with respect to the performance or operational life of this engine. This engine is warranted solely according to the product and emissions warranties stated elsewhere in this manual.
TUNE$UP SPECIFICATIONS
Power BuiltE Snow Models
Model Series 120000
Bore . . . . . . . . . . . . . . . . . . . . . . . . . . 68 mm (2.677 in.) Stroke . . . . . . . . . . . . . . . . . . . . . . . . 56 mm (2.200 in.) Displacement . . . . . . . . . . . . . . . . . 206 cc (12.48 cu. in.)
Model Series 150000
Bore . . . . . . . . . . . . . . . . . . . . . . . . . . 75 mm (2.970 in.) Stroke . . . . . . . . . . . . . . . . . . . . . . . . 56 mm (2.200 in.) Displacement . . . . . . . . . . . . . . . . . 249 cc (15.22 cu. in.)
Model Series 200000
Bore . . . . . . . . . . . . . . . . . . . . . . . . . . 79 mm (3.120 in.) Stroke . . . . . . . . . . . . . . . . . . . . . . . . 62 mm (2.438 in.) Displacement . . . . . . . . . . . . . . . . . 305 cc (18.64 cu. in.)
Model Series 210000
Bore . . . . . . . . . . . . . . . . . . . . . . . . |
. . 84 mm (3.300 in.) |
Stroke . . . . . . . . . . . . . . . . . . . . . . . |
. 62 mm (2.438 in.) |
Displacement . . . . . . . . . . . . . . . . . |
342 cc (20.85 cu. in.) |
Valve clearance with valve springs installed and piston 6 mm past top dead center. Check when engine is cold.
Intake . . . . . . . . . . . . . . . |
0.1080.15 mm (0.00480.006 in.) |
Exhaust . . . . . . . . . . . . . . |
0.2380.28 mm (0.00980.011 in.) |
Armature air gap . . . . . . . |
0.2580.36 mm (0.01080.014 in.) |
Spark plug gap . . . . . . . . |
. . . . . . . . 0.76 mm (0.030 in.) |
SAFETY PRECAUTIONS
BEFORE OPERATING
ENGINE
•Read entire Operating & Maintenance Instructions AND the instructions for the equipment this engine powers.*
•Failure to follow instructions could result in serious injury or death.
* Briggs & Stratton does not necessarily know what equip8 ment this engine will power. For that reason, you should carefully read and understand the operating instructions for the equipment on which your engine is placed.
THE OPERATING &
MAINTENANCE INSTRUCTIONS
CONTAIN SAFETY
INFORMATION TO:
•Make you aware of hazards associated with engines
•Inform you of the risk of injury associated with those hazards, and
•Tell you how to avoid or reduce the risk of injury.
A signal word (DANGER, WARNING, or CAUTION) is used with the alert symbol to indicate the likelihood and the potential severity of injury. In addition, a hazard symbol may be used to represent the type of hazard.
DANGER indicates a hazard which, if not avoided, will result in death or serious injury.
WARNING indicates a hazard which, if not avoided, could result in death or serious injury.
CAUTION indicates a hazard which, if not avoided, might result in minor or moderate injury.
CAUTION, when used without the alert symbol,
indicates a situation that could result in damage to the engine.
WARNING
The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.
Hazard Symbols and Meanings
|
Fire |
|
|
|
|
|
|
|
|
|
Explosion |
Shock |
Hot Surface |
|
|||||
|
|
|
|
Moving Parts |
|
||||
|
|
|
|
|
|
|
|||
|
Kickback |
Toxic Fumes |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
International Symbols and Meanings
Safety Alert |
Choke |
Oil |
Fuel |
Read Operator's |
On Off |
Stop |
Fuel Shutoff |
Manual |
|
|
|
1