BMW 525i Sedan 2002, 525i Sport Wagon 2002, 530i Sedan 2002, 540i Sedan 2002, 540i Sport Wagon 2002 Owner Manual

Owner's Manual for Vehicle

525i

530i

540i

sedan

sport wagon

Congratulations, and thank you for choosing a BMW.

Thorough familiarity with your vehicle will provide you with enhanced security and control when you drive it. Therefore we have one request:

Please take the time to read this Owner's Manual and familiarize yourself with the information that we have compiled for you before starting off in your new BMW. The manual contains important data and instructions intended to assist you in obtaining maximum satisfaction from your BMW's unique array of advanced technical features. It also contains information on vehicle maintenance designed to enhance operating safety while simultaneously helping you to maintain your BMW's value throughout an extended service life.

For more detailed information refer to the supplemental manuals.

This Owner's Manual should be considered a permanent part of this vehicle. It should stay with the vehicle when sold to provide the next owner with important operating, safety and maintenance information.

This manual is supplemented by a Service and Warranty Information Booklet (US models) or a Warranty and Service Guide Booklet (Canadian models). We recommend that you read this publication thoroughly.

Your BMW is covered by the following warranties:

–New Vehicle Limited Warranty

–Limited Rust Perforation Warranty

–Federal Emissions System Defect Warranty

–Federal Emissions Performance Warranty

–California Emission Control System Limited Warranty

Detailed information about these warranties is listed in the Service and Warranty Information Booklet (US models) or in the Warranty and Service Guide Booklet (Canadian models).

We wish you an enjoyable driving experience.

BMW AG

Contents

	Overview	Cockpit 14		featuresand
		Instrument cluster	15
		Indicator and warning lamps 19
		Steering wheel with multifunction
		buttons 22
		Warning triangle 23
		First-aid kit 23		Controls
		Refueling 24
		Fuel specifications	25
		Tire inflation pressure 26

© 2001 Bayerische Motoren Werke Aktiengesellschaft

Munich, Germany

Reprinting, including excerpts, only with the written consent of BMW AG, Munich. Order No. 01 41 0 156 213

US English VIII/2001

Printed in Germany

Printed on environmentally friendly paper (bleached without chlorine, suitable for recycling).

Locks and security systems:

Keys 32

Central locking system 32 Opening and closing – via the

door lock 33

Opening and closing – via the remote control 34

Opening and closing – from the inside 37

Luggage compartment lid/ Tailgate 38

Rear window 40 Luggage compartment 42 Alarm system 42

Electric power windows 44 Sliding/tilt sunroof 46

Adjustments:

Correct sitting posture 48 Seats 48 Manually-adjusted seat 49 Electric power seats 50 Head restraints 52

BMW actice seat 52 Safety belts 53

Seat, mirror and steering wheel memory 54

Seat heating 55

Adjusting steering wheel 56 Heated steering wheel 56 Mirrors 57

Passenger safety systems:

Airbags 58

Transporting children safely 61 Vehicle Memory, Key

Memory 64

Driving:

Steering/Ignition lock 66 Starting the engine 66 Switching off the engine 68 Parking brake 68

Manual transmission 69 Automatic transmission 70 Automatic transmission with

Steptronic 73 Indicator/Headlamp flasher 76 Washer/Wiper system/Rain

sensor 76 Cruise control 78

Everything under control:

Odometer, outside temperature display 80

Tachometer 81 Energy control 81 Fuel gauge 81

Coolant temperature gauge 82 Service Interval Display 82 Check Control 83

Computer 86 Multi-Information Display

(MID) 87

Digital clock in the MID 89 Computer in the MID 91

Controls and features

Technology for safety and driving convenience:

Park Distance Control (PDC) 96 Automatic Stability Control plus Traction (ASC+T)/Dynamic Stability Control (DSC) 97

Level control system 99

Tire Pressure Monitor (RDC) 99

Lamps:

Parking lamps/Low beams 101 Instrument lighting 102

High beams/Standing lamps 102

Fog lamps 102 Interior lamps 103 Reading lamps 103

Controlling the climate for pleasant driving:

Air conditioning 104 Automatic climate control 107 Roller sun blind 112 Parked-car ventilation

system 112

Cabin convenience:

BMW Universal Transmitter 113 Glove compartment 116 Storage compartments 116 Cellular phone 117

Beverage holder 117 Ashtray, front 117 Cigarette lighter 118 Ashtray, rear 118

Loading and transporting cargo:

Through-loading system 119 Ski bag 120

sport wagon:

Luggage compartment 123 Roll-up cover 123 Partition net 123

Storage areas in the luggage compartment 124

Cargo loading 126 Roof-mounted luggage rack 127

Operation, maintenance

Special operating instructions:

Break-in procedures 130 Driving notes 131

Antilock Brake System 131 Brake system 132

Wheels and tires:

Tire inflation pressure 133 Tire condition 133

Tire replacement 134 Wheel and tire

combinations 135

Special characteristics of winter tires 136

Snow chains 136

5n

Repairs Maintenance Controls Overview

Index Data

Contents

maintenance	Under the hood:
	Hood 137
	Engine compartment
	essentials 138
	Washer fluids 139
	Engine oil	140
Operation,	Coolant 142
	System	144
	Brake fluid	143

Maintenance:

The BMW Maintenance

Laws and regulations:

Technical modifications 145 California Proposition

65 Warning 145

OBD interface socket 146

Owner service procedures

Replacement procedures:

Onboard tool kit 150 Windshield wiper blades 150 Lamps and bulbs 151 Changing a wheel 156 Battery 160

Fuses 160

Assistance, giving and receiving:

Jump-starting 162 Towing the vehicle 163

Technical data

Engine specifications 168 Dimensions 169

Weights 171 Capacities 173

Index

7n

Everything from A to Z 176

Repairs Maintenance Controls Overview

Index Data

8

Notes on the Owner's Manual

We have made every effort to ensure that you are able to find what you need in this Owner's Manual as quickly as possible. The fastest way to find certain topics is by using the detailed index at the end. If you are looking for a brief initial summary of the essentials, please turn to the first chapter.

We hope that the detailed table of contents on the preceding pages will stimulate your interest and encourage you to explore the remainder of the manual.

Should you wish to sell your BMW at some time in the future, please remember to hand over the Owner's Manual to the new owner; it is part of the vehicle.

If you have any questions, your BMW center will be glad to advise you.

Symbols used

Indicates precautions that must be followed precisely in order to avoid the possibility of personal injury and serious damage to the vehicle.<

Contains information that will assist you in gaining the optimum

benefit from your vehicle and enable you to care more effectively for your vehicle.<

Refers to measures that can be taken to help protect the environ-

ment.<

< Marks the end of a specific item of information.

* Indicates special equipment, countryspecific equipment and optional extras.

t Identifies index entries that refer to owner service procedures or topics on vehicle maintenance.

Identifies systems or components, which can either be activated or

adapted to suit an individual driver's requirements ("Vehicle Memory", "Key Memory"). Refer to page 64. Remember that activation and adjustments on some of these systems can only be performed at your BMW center.<

The individual vehicle

On buying your BMW, you have decided in favor of a model with individualized equipment and features. This Owner's Manual describes all models and equipment that BMW offers within the same group.

We hope you will understand that equipment and features are included which you might not have chosen for your vehicle. You can easily identify any differences with the aid of the asterisk * used to identify all optional equipment and accessories.

If your BMW features equipment which is not described in this Owner's Manual (car radio or telephone, for instance), Supplementary Owner's Manuals are enclosed. We ask you to read these manuals as well.

Status at time of printing

BMW pursues a policy of continuous, ongoing development designed to ensure that our vehicles continue to embody the highest quality and safety standards combined with advanced, state-of-the-art technology. For this reason, it is possible that the features described in this Owner's Manual could differ from those on your vehicle. Nor can errors and omissions be entirely ruled out. We therefore request your understanding for the fact that we are unable to recognize any legal claims based on the data, illustrations or descriptions in this manual.

9n

Repairs Maintenance Controls Overview

Index Data

10

For your own safety

Use unleaded gasoline only. Fuels containing up to and including

10 % ethanol or other oxygenates with up to 2.8 % oxygen by weight (i.e. 15 % MTBE or 3 % methanol plus an equivalent amount of co-solvent) will not void the applicable warranties covering defects in materials or workmanship. Field experience has indicated significant differences in fuel quality (volatility, composition, additives, etc.) among gasolines offered for sale in the United States and Canada. The use of poorquality fuels may result in driveability, starting and stalling problems, especially under certain environmental conditions, such as high ambient temperature and high altitude.

Should you encounter driveability problems that you suspect could be related to the fuel you are using, we recommend that you respond by switching to a recognized high-quality brand. Failure to comply with these recommendations may result in unscheduled maintenance.

Follow all applicable safety rules when you are handling gasoline.<

Important safety information!

For your own safety, use genuine parts and accessories approved by BMW.

When you purchase accessories tested and approved by BMW and Original BMW Parts, you simultaneously acquire the assurance that they have been thoroughly tested by BMW to ensure optimum performance when installed on your vehicle.

BMW warrants these parts to be free from defects in material and workmanship.

BMW will not accept any liability for damage resulting from installation of parts and accessories not approved by BMW.

BMW cannot test every product from other manufacturers to confirm that it can be used on a BMW safely and without risk to either the vehicle, its operation, or its occupants.

Original BMW Parts, BMW Accessories and other products approved by BMW, together with professional advice on using these items, are available from all BMW centers.

Installation and operation of non-BMW approved accessories such as alarms, radios, amplifiers, radar detectors, wheels, suspension components, brake dust shields, telephones (including operation of any portable cellular phone from within the vehicle without using an externally-mounted antenna) or transceiver equipment (for instance, CBs, walkie-talkie, ham radio or similar accessories) may cause extensive damage to the vehicle, compromise its safety, interfere with the vehicle's electrical system, or affect the validity of the BMW Limited Warranty. See your BMW center for additional information.<

Maintenance, replacement, or repair of the emission control

devices and systems may be performed by any automotive repair establishment or individual using any certified automotive part.<

Symbol on vehicle parts

Indicates that you should consult the relevant section of this

Owner's Manual for information on a particular part or assembly.

The following applies only to vehicles owned and operated in the US.

REPORTING SAFETY DEFECTS

11n

Controls Overview

If you believe that your vehicle has a defect that could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying BMW of North America, LLC, P.O. Box 1227, Westwood, New Jersey 07675-1227, Telephone [phone].

If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer or BMW of North America, LLC.

To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hotline.

Repairs Maintenance

Index Data

12

13

Overview

Controls and features

Operation, maintenance

Owner service procedures

Technical data

Index

Repairs Maintenance Controls Overview

Data

Index

14 Cockpit

390de788

1	Parking lamps/Low beams 101	3	Fog lamps 102		7	Rear window defroster 104, 107
2	> Turn signal 76	4	Washer/Wiper system	76	8	Horn, the entire surface
	> Standing lamps 102	5	Central locking system	32	9	Adjusting the steering wheel 56
	> High beams 102
		6	Hazard warning flashers
	> Headlamp flasher 76

> Computer 86

Instrument cluster

390us740

1 Fuel gauge 81

2Indicator lamp for turn signals 21

3Speedometer

4Indicator lamp for high beams 21

		15
			Overview
			Controls
			Maintenance
			Repairs
5	Tachometer and Energy Control 81	8 Selector lever and program display
6	Coolant temperature gauge 82	for automatic transmission* 70, 73	Data
7	Indicator and warning	9 Service Interval Display 82
	lamps 19 to 21
			Index

16 Instrument cluster

390us740

10Display for the computer (operation via the turn signal lever, refer to page 86):

>Outside temperature

>Average fuel consumption

>Cruising range

>Average speed

11Indicator lamp for Automatic Stability Control plus Traction (ASC+T)/Dynamic Stability Control (DSC)* 21

12Indicator lamp for self-leveling suspension* 20

13Odometer and trip odometer 80

14Indicator for Check Control 83

15Reset trip odometer to zero 80

16Indicator and warning lamps 19 to 21

Instrument cluster*

390us741

1	Fuel gauge 81	4	Indicator lamp for high beams 21
2	Indicator lamp for turn signals 21	5	Tachometer and Energy Control 81
3	Speedometer	6	Coolant temperature gauge 82

		17
			Overview
			Controls
			Maintenance
			Repairs
	7	Indicator and warning
		lamps 19 to 21	Data
	8	CHECK button 83
	9	Selector lever and program display
		for automatic transmission* 70, 73	Index

18 Instrument cluster*

390us741

10	Outside temperature display 80	12	Trip odometer	80	15	Service Interval Display 82
11	Indicator lamp for Automatic	13	Check Control display 83		16	Reset button for trip odometer 80
	Stability Control plus Traction	14	Odometer 80		17	Indicator and warning

	ASC+T/Dynamic Stability Control	lamps 19 to 21
	(DSC)* 21

Indicator and warning lamps	19

Technology that monitors itself

The system runs a check on the warning and indicator lamps marked by "●" each time you switch on the ignition. They each light up once for different periods of time.

If a fault should occur in one of these systems, the corresponding lamp does not go out after the engine is started or it lights up while the vehicle is moving. The following section describes how you should respond.

Red: stop immediately

Battery charge current ●

The battery is no longer being charged. This indicates a defect

in the alternator drive belt or in the charging circuit of the alternator. Please contact the nearest BMW center.

Stop and switch off the engine immediately to prevent over-

heating and serious engine damage. If the drive belt is defective, increased steering effort is also required.<

Engine oil pressure ●

May be accompanied by the message "STOP!ENGINE

OILPRESS" in the Check Control display panel*: stop the vehicle immediately and switch off the engine. Check the engine oil level; top up as required. If the oil level is correct: please contact the nearest BMW center.

Do not continue driving, as the engine could sustain serious

damage from inadequate lubrication.<

Tire Pressure Monitor (RDC)* ● Accompanied by an acoustic warning signal: a tire failure has

occurred. Reduce vehicle speed immediately and stop the vehicle. Avoid hard brake applications. Do not oversteer.

For additional information: refer to page 98

Parking brake*/

brake system hydraulic circuits ● Comes on when you engage the

parking brake.

For additional information: refer to page 68

Comes on although the parking brake is released: have the brake fluid level checked. Before continuing your journey, be sure to read the notes on pages 132 and 143

Also comes on with the message "CHECK BRAKE LININGS" in the Check Control.

Parking brake warning lamp*/ brake system hydraulic circuits for Canadian models.

Repairs Maintenance Controls Overview

Index Data

20 Indicator and warning lamps

Red: as important reminder

Parking brake*

Comes on when you engage the parking brake.

For additional information: refer to page 68

Parking brake warning lamp* for Canadian models.

Please fasten safety belts ● Accompanied by warning tone and message* in the Check

Control panel. Remains on until the safety belts are fastened.

For additional information on safety belts: refer to page 53.

Airbags ●

Please have the system inspected by your BMW center.

For additional information: refer to page 58

Yellow: please have checked at your earliest opportunity

Antilock Brake System (ABS) ●

ABS has been deactivated in response to system malfunction.

Conventional braking efficiency is available without limitations. Please have the system inspected by your BMW center.

For additional information: refer to page 131

Antilock Brake System (ABS) warning lamp for Canadian models.

Engine oil level*

Comes on while driving: the engine oil level has fallen to the

absolute minimum; refill as soon as possible. Do not drive more than approx. 30 miles (50 km) until you do. For additional information: refer to page 140

Engine oil level*

Comes on after the engine has been shut off: add engine oil at

your earliest opportunity (when you stop to refuel).

For additional information: refer to page 140

Automatic transmission* Because of a malfunction, the automatic transmission shifts

only in the emergency program. Please consult the nearest BMW center.

For additional information: refer to pages 72 and 75

Brake pads* ●

Have the brake pads checked. For additional information: refer

to page 132

Dynamic Brake Control (DBC)* ●

Malfunction in DBC system. Conventional braking efficiency

is available without limitations.

Have the system repaired by your BMW center at the earliest possible opportunity.

For additional information: refer to page 98

Dynamic Brake Control (DBC) warning lamp for Canadian models.

Tire Pressure Monitor (RDC)* ● Check the tire inflation pressure. Refer to pages 26, 98

Indicator and warning lamps

21

Self-leveling suspension* ● The level control system is inactive. Please consult the nearest

BMW center.

For additional information: refer to page 99

Automatic Stability Control plus Traction (ASC+T)/Dynamic Stability Control (DSC)* ●

ASC+T/DSC has been deactivated, either manually at the button or automatically in response to a system malfunction. In the event of a malfunction, have the system checked by your BMW center.

For additional information: refer to page 97

Engine-management system* There is a fault in the electronic engine-management system.

You can continue to drive with reduced engine output and engine speed. Please have the system inspected by your BMW center.

Service Engine Soon ●

If the indicator lamp comes on either continuously or intermittently, this indicates a fault in the emis-

sions-related electronic systems. Although the vehicle remains operational, you should have the systems checked by your BMW center at the earliest possible opportunity.

For additional information: refer to page 146

Service Engine Soon warning lamp for Canadian models.

Check Filler Cap* ●

If the indicator lamp comes on although the fuel cap is secured

correctly: this indicates a malfunction in the fuel system. Have the system inspected at your BMW center at the earliest opportunity.

Additional information: refer to page 25

Green: for your information

Turn signal

Flashes when the turn signal is on. Rapid flashing indicates a

system malfunction.

For additional information: refer to page 76

Cruise control

Lights up when the system is switched on: available for oper-

ation via the multifunction steering wheel.

For additional information: refer to page 78

Front fog lamps

Lights up whenever you switch on the front fog lamps.

For additional information: refer to page 102

Blue: for your information

High beams

Lights up when the high beams are on or the headlamp flasher

is actuated.

For additional information: refer to pages 76 and 102

Repairs Maintenance Controls Overview

Index Data

22 Steering wheel with multifunction buttons

The controls integrated within the multifunction steering wheel (MFL) and the sports steering wheel* have been designed to allow you to operate a number of accessories both quickly and safely, without taking your eyes from the road:

>selected control functions for the radio along with CD, MD and cassette player

>recirculated-air control of the air conditioner system or the heated steering wheel* (MFL only)

>the cruise control

>various phone functions* and

>voice entry*.

The controls are active only when the corresponding systems and

accessories are switched on.<

Press briefly:

Receive a phone call, initiate dialing, terminate a call.

Extended pressure: Activate/deactivate voice entry.

Switch between phone and radio, cassette, CD and MD.

Forward:

>Radio

Press briefly: station scan in FM band Extended pressure: search function

>CD/MD

Press briefly: jump to next track Extended pressure: search function in track

>Cassette

Press briefly: stop track scan or fast forward

Extended pressure: fast forward

>Phone

Scan personal phone book.

Rewind: functions as forward.

Volume

Cruise control: to select a stored setting.

Cruise control: store and accelerate (+) or decelerate and store (–).

Cruise control: activate/interrupt/deactivate.

Recirculated-air mode and automatic recirculated-air control (AUC) or heated steering wheel: activate/deactivate.

Warning triangle*

First-aid kit*

	394de053				390de716

The hazard warning triangle is readily available, stored in the onboard tool kit mounted on the inside of the luggage compartment lid/tailgate.

To open the container, loosen the wing screw.

Always observe all legal regulations requiring a warning triangle

to be carried in the vehicle.<

The first-aid kit is located under the front passenger's seat.

To remove: lift the release lever on the front (arrow) and pull the first-aid kit forward out of its support.

To store: place the back of the kit into the support, then push back until the lever engages.

23

Several of the items contained in the first-aid kit have a limited

service life. For this reason, check the expiration dates of each of the items regularly, and replace any whose expiration dates have passed. You can acquire replacements in any drugstore or pharmacy.

Always observe all legal regulations requiring a first-aid kit to be carried in the vehicle.<

Repairs Maintenance Controls Overview

Index Data

24 Refueling

394de729

Fuel filler door

Always switch off the engine before refueling, as it is not

possible to add fuel with the engine running, and attempts may also trigger the Service Engine Soon lamp.<

To open the filler door, press on the front edge.

In the event of an electrical malfunction, you can also open the fuel filler door manually:

sedan

1.Use the handle to lower the trim panel on the right side of the luggage compartment

2.Pull the button with the fuel pump

symbol.

sport wagon

1.Release the right-hand panel in the luggage compartment with the button and fold the panel down

2.Pull the button with the fuel pump symbol.

If a subwoofer* is installed, loosen the T-screw and swing the subwoofer to the side.

Always observe all safety precautions posted at the service station

when handling fuel. Never carry spare fuel containers in your vehicle. Whether empty or full, these containers can leak, cause an explosion, or lead to fire in the event of a collision.<

390de603

Simple and environmentally friendly

Open the filler cap carefully to prevent fuel from spraying out.

Fuel spray may cause injury.

Do not attempt to continue adding fuel to the last drop, as this practice can cause fuel spillage.<

Keep the filler cap in the bracket attached to the fuel filler door.

When refueling, insert the filler nozzle completely into the filler pipe. Pulling the nozzle out of the pipe during refueling

>results in premature pump shutoff

>and will reduce the effectiveness of the vapor recovery system on the pump.

Refueling

Fuel specifications

As long as the filler nozzle is used properly, the fuel tank is full whenever the nozzle shuts off the first time.

Refill early to avoid damaging the catalytic converter; never attempt

to drive to the last drop of fuel in the tank.<

Tank capacity: approximately 18.5 gal. (70 liters), with a reserve capacity of

>BMW 525i, 530i: 2.0 gal. (8 liters)

>BMW 540i: 2.5 gal. (10 liters).

After refueling, close the filler cap carefully, continuing until you hear

the detent engage. While closing, be sure not to squeeze the strap which is fastened to the cap. A loose or missing cap will activate the message "CHECK FILLER CAP" in the Check Control* or the Check Filler Cap lamp*.<

The engine uses lead-free gasoline only.

Required fuel:

>Premium Unleaded Gasoline, min. 91 AKI

AKI = Anti Knock Index

Never use leaded fuel, as it would cause permanent and irreversible

damage to the oxygen sensor and the catalytic converter.<

25

Repairs Maintenance Controls Overview

Index Data

26 Tire inflation pressure

390de697

The inflation pressures are indicated on a sticker attached to the B-pillar behind the driver's door (visible with door open).

Check tire pressures

All pressure specifications are indicated in psi (kilopascal) for tires at ambient temperature (refer also to the next pages).

Vehicles with Tire Pressure Monitor (RDC)*:

After correcting tire inflation pressures, reactivate the system, refer to page 99.

Check your tire pressures on a regular basis – at least twice a month – and before every extended

journey. Incorrect tire pressure can lead to driving instability, tire damage and accidents.

Check the inflation pressure of the spare tire also. Inflate the spare tire to the highest pressure of any tire on your vehicle.<

Comply with tire approval specifications

The inflation pressures in the tables apply to BMW approved tires sizes and tire manufacturers. Your BMW center is familiar with these pressures. Higher pressures may be specified for tires from other manufacturers.

Your vehicle is equipped with tires that not only meet US, but also European standards. We recommend the exclusive use of BMW approved tires.

Tire inflation pressure

sedan	Tires
	All pressure specifications in
	the table are indicated in psi
	(kilopascal) with cold tires
	(cold = ambient temperature)
	225/60 R 15 96 H M+S	–	–	33 (230)	41 (280)
	225/55 R 16 95 H M+S			(US/CDN)
	225/60 R 15 96 W
	225/55 R 16 95 W
	235/45 R 17 94 W/Y	29 (200)	33 (230)	33 (230)	41 (280)
525i	205/65 R 15 94 Q M+S		(outside US/CDN)
	225/60 R 15 96 Q M+S
	225/55 R 16 95 Q M+S
	235/45 R 17 94 Q M+S
	Front: 235/45 R 17 94 W/Y
	Rear: 255/40 R 17 94 W/Y
	225/55 R 16 95 H M+S	–	–	33 (230)	41 (280)
	225/55 R 16 95 W			(US/CDN)
	235/45 R 17 94 W/Y
530i	225/55 R 16 95 Q M+S	29 (200)	33 (230)	33 (230)	41 (280)
	235/45 R 17 94 Q M+S		(outside US/CDN)
	Front: 235/45 R 17 94 W/Y
	Rear: 255/40 R 17 94 W/Y

27

Repairs Maintenance Controls Overview

Index Data

28 Tire inflation pressure

	sedan	Tires
		All pressure specifications in
		the table are indicated in psi
		(kilopascal) with cold tires
		(cold = ambient temperature)
		225/55 R 16 95 W	35 (240)	39 (270)	41 (280)	48 (330)
		235/45 R 17 94 W/Y
	540i	Front: 235/45 R 17 94 W/Y	35 (240)	–	41 (280)	–
		Rear: 255/40 R 17 94 W/Y	–	39 (270)	–	48 (330)
		225/55 R 16 95 Q/T/H M+S	30 (210)	35 (240)	36 (250)	44 (300)
		235/45 R 17 94 Q/T/H M+S
		225/55 R 16 95 H M+S
		225/55 R 16 95 W
		235/45 R 17 94 W/Y	30 (210)	35 (240)	36 (250)	44 (300)
	540iA	225/55 R 16 95 Q M+S
		235/45 R 17 94 Q M+S
		Front: 235/45 R 17 94 W/Y	30 (210)	–	36 (250)	–
		Rear: 255/40 R 17 94 W/Y	–	35 (240)	–	44 (300)

Tire inflation pressure

sport	Tires
wagon	All pressure specifications in
	the table are indicated in psi
	(kilopascal) with cold tires
	(cold = ambient temperature)
	225/55 R 16 95 H M+S
	225/60 R 15 96 H M+S
	225/60 R 15 96 W	30 (210)	35 (240)	36 (250)	44 (300)
525i	225/55 R 16 95 W
	235/45 R 17 94 W/Y
	225/60 R 15 96 Q M+S
	225/55 R 16 95 Q M+S	33 (230)	38 (260)	39 (270)	46 (320)
	235/45 R 17 94 Q M+S
	225/55 R 16 95 H M+S
	225/55 R 16 95 W	30 (210)	35 (240)	36 (250)	44 (300)
540i	235/45 R 17 94 W/Y
	225/55 R 16 95 Q M+S	33 (230)	38 (260)	39 (270)	46 (320)
	235/45 R 17 94 Q M+S

29

Repairs Maintenance Controls Overview

Index Data

30