ALFA GT
SS EE RR VV II CC EE
The contents of this Supplement updates
what contained in Owner Handbook.
INDEX
SPORT FUNCTION............................................................................... 3
SCHEDULED MAINTENANCE PROGRAMME............................................... 4
ENGINE CODE - BODYWORK VERSIONS.................................................. 6
ENGINE............................................................................................. 6
PERFORMANCE ................................................................................. 7
FLUIDS AND LUBRICANTS .................................................................... 7
FUEL CONSUMPTION .......................................................................... 8
EMISSIONS................................................................................. 8
CO
2
SPORT FUNCTION
The vehicle is equipped with a system
that allows the choice between two driving styles: normal and sports.
Pressing the SPORT button fig 1 pro-
duces a sports driving setting featuring
greater responsiveness during acceleration.
This function produces:
– a more lively response by the engine;
– increased sensitivity of the accelera-
tor pedal to the supply of power.
fig. 1
AA00AA11116655mm
This function is especially useful if maximum performance is required, for example when overtaking.
The LED in the SPORT button lights up
when the function is on. Press the button again to turn the function off and restore the normal driving setting.
IMPORTANT during acceleration,
when the SPORT function is in use, it
is possible to feel steering judder, which
is typical of this sporty setting.
ACCELERATION
Accelerating violently increasing the revs
will greatly affect consumption and emissions: to contain fuel consumption acceleration should be gradual.
Using the SPORT function, fuel consumption will be slightly higher.
3
SCHEDULED MAINTENANCE PROGRAMME
Here is the Scheduled Maintenance Programme for 1.9 JTDM 170HP engine. For other information, refer to the Owner Handbook.
Thousands of km
Check tyre conditions/wear and adjust pressure if necessary
Check operation of lighting system (headlights, direction indicators, hazard
warning lights, boot, passenger compartment, glovebox lights, warning lights, etc..)
Check operation of windscreen washer system, adjust spray jets
Check position/wear of windscreen/rearscreen wiper blades
Check operation of front disk brake pad wear indicator
Check wear conditions of rear disk brake pads
Sight check the conditions of: body exterior, underbody protection,
stiff pipes and hoses (exhaust - fuel supply - brakes), rubber parts
(boots - sleeves - bushes etc.)
Sight check boot and bonnet lock cleaning conditions, lever cleaning and lubrication
Sight check for accessory drive belt conditions
Check handbrake lever stroke adjustment
Change air cleaner cartridge
Top up fluid levels (engine coolant, brakes, windscreen washer, battery, etc..)
20 40 60 80 100 120 140 160 180
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●● ●
●●●●●●●●●
●●●●●●●●●
●●
●●● ●
●●●●●●●●●
●●●●●●●●●
4
20 40 60 80 100 120 140 160 180Thousands of km
Sight check for conditions of timing gear drive toothed belt
Check operation of engine control system (through diagnosis socket)
Check gearbox oil level
Check emissions/smoke at the exhaust
Change timing gear drive belt (*)
Change accessory poly-V drive belt
Change engine oil and oil filter (diesel versions without DPF) (or every 24 months)
Change brake fluid (or every 24 months)
Change fuel filter
Change pollen filter (or every year)
Replacement of joint with filter on oil delivery to the turbocharger
Check of turbocharger operation and conditions
(*) Regardless of the km covered, the timing belt shall be replaced every 4 years for particularly demanding use (cold climates, driving in the city, idling for a long time) or in any case every
5 years.
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●●
●●
●●● ●
●
●
●● ●
5
ENGINE CODE - BODYWORK VERSION
Engine code Body work version
1.9 JTDM 170HP 937A6000
(
▲
) 5 seats version
(●) 4 seats version
ENGINE
Code type
Cycle
Number and position of cylinders
Piston bore and stroke mm
Total displacement cm
Compression ratio
Maximum horsepower (CEE):
at rpm
Maximum torque (CEE):
at rpm
Fuel
3
kW
HP
Nm
kgm
937CXZ1B 30 (
937CXZ1B 30B (●)
1.9 JTD
M 170HP
937A6000
Diesel
4 in line
82 x 90.4
1910
17.5 : 1
125
170
3750
330
33.6
2000
Diesel fuel for motor vehicles (Specification EN 590)
▲
)
6
PERFORMANCE
Maximum speed
km/h
Acceleration
from 0-100 km/h
sec.
Kilometer with standing start
sec.
1.9 JTDM170HP
216
8.2
29.0
FLUIDS AND LUBRICANTS
RECOMMENDED PRODUCTS AND THEIR SPECIFICATIONS
Use
Fluid and lubricant specifications
for correct car operation
Lubricants for
diesel engines
Lubrificants and
greases for
transmission
(❍) For periodic replacement, according to the requirements of the Scheduled Maintenance Programme or for fill-up (if any), ask Alfa Romeo
Authorized Services for the suitable product of the Selenia range.
In emergency situations when genuine products are unavailable, lubricants with at least ACEA B4 performance are allowed. However, engine
optimum performance is not guaranteed. We recommend to have the products replaced with the appropriate genuine lubricants by the Alfa Romeo
Authorized Services, as soon as possible.
Use of products with low-quality properties than ACEA B4 could cause damages to the engine that are not covered by the warranty.
Synthetic-based oils, grade SAE 5W-40
FIAT 9.55535-Z2
Synthetic-based oil, grade SAE 75W-85
Passes API GL 4 specifications
FIAT 9.55550-MZ1 qualification
For other fluids and lubricants, refer to the Owner Handbook.
Original fluids
and lubricants
(
❍
)
TUTELA
CAR MATRYX
Contractual Technical
Reference N° F108.F02
Change
According to
Service Schedule
Mechanical gearbox
and differential
7
FUEL CONSUMPTION
The fuel consumption figures given in the table below are determined on the basis of the homologation tests set down by specific Eu-
ropean directives.
Fuel consumption according to directive
1.9 JTDM 170HP
1999/100/EC (litres x 100 km)
Urban
Extraurban
Combined
CO2EMISSIONS
CO2emission level at the exhaust refer to combined consumption.
CO2EMISSIONS ACCORDING TO 1999/100/EC DIRECTIVE
1.9 JTDM 170HP
: 164 g/km
SS EE RR VV II CC EE
CCUUSSTTOOMMEERR SSEERRVVIICCEESS
TECHNICAL SERVICES - SERVICE ENGINEERING
Largo Senatore G. Agnelli. 5 -10040 Volvera - Torino (Italia)
Fiat Group Automobiles S.p.A.
Pubblicazione n. 60431926 - 1
All rights reserved. Reproduction, even in part is prohibited without written permission
from Fiat Group Automobiles S.p.A.
st
Edition - 04/2008
8.7
4.8
6.2
Loading...