Akai QXD-3100 Service manual

MICRO MUSIC SYSTEM

with REMOTE-CONTROL

QX-D3100

CONTENTS

Page

Specifications & Performance Specifications ........................................................................................... 1

Electrical Parts List ............................................................................................................................... 4

Printed Circuit Boards .......................................................................................................................... 12

Wiring Diagram .................................................................................................................................... 15

Schematic Diagrams ........................................................................................................................... 17

Alignment Set-up Procedurecs ............................................................................................................. 21

Equipment Connection Diagrams .......................................................................................................... 22

Voltage Chart ...................................................................................................................................... 24

IC Pins Description & IC Block Diagrams ............................................................................................. 26

Block Diagrams ................................................................................................................................... 29

Exploded Drawing Parts List ................................................................................................................. 31

Exploded Drawing ................................................................................................................................ 34

PRODUCT SAFETY NOTICE

Many electrical and mechanical parts in this chassis have special safety characteristics. These safety characteristics often pass unnoticed and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts that have these special safety characteristics are identified in this manual and its supplements; electrical components having such features are identified by schematic diagram and the parts list. Before replacing any of these components, read the parts list in this manual carefully. The use of substitute replacement parts that do not have the same safety characteristics as specified in the parts list may create shock, fire or other hazards.

in the

Power Supply :AC 230V 50Hz

Output Load :8 ohm non-reactive

Reference Output :50mW

Input Signal Source :IRE Loop for AM

:75 ohm dummy for FM

Modulation :30% 400 Hz for AM

:22.5 kHz Deviation 1000 Hz for FM MONO

:75 kHz Deviation for FM MPX

Remarks :7.5 kHz Pilot Tone

:67.5 kHz L + R 1000 Hz

:AC Bias

GENERAL TEST CONDITION

GENERAL

Output power:

2W x 2 (10% T

)

Power consump

ion

Ω

Power source:

AC ~120V 60 H

(USA and Can

da)

AC ~220V 50 H

(China

)

AC ~230V 50 H

(Europe)

AC ~240V 50 H

(Australia

)

AC ~110-120V/

20-240V 50/60

z (Others

)

SPECIFICATIONS

(AM) SECTION, AMPLITUDE, MODULATION

UNIT NOMINAL LIMIT

1. Tuning Range kHz 517 - 1650 517 - 1650

±8 - ±30

2. I.F. kHz 465 ±5

3. S/N 5mV/m 1.0MHz dB 36 30

4. Sens. (at S/N 20dB) 0.6MHz dB/m 54 64

1.0MHz dB/m 54 60

1.4MHz dB/m 54 60

5. I.F. Rej. 0.6MHz dB 40 30

6. Image Rej. 1.4MHz dB 40 30

7. Spurious Rejection dB 35 28

8. Bandwidth, -6dB, at 1.0MHz kHz 6 4 - 9

(Max. Sens. +6dB)

9. ACA (±9kHz) Input at 1MHz (For VDE) dB 20 15

ACA (±9kHz) Input at 1MHz (For VDE Specical) dB 20 12

10. AGC Figure Merit 100mV/m dB 50 40

11. Distortion, 5mV/m, 30% % 1 3

5mV/m, 80% % 3 6

12. 10% THD Power W 2 1.7

13. a. Tweet (2nd IF& 3rd IF) % - 15

14. Audio Fidelity, (1kHz = 0dB) 5mV/m Hz 60 - 2200 120 - 2000

15. a. Dial Cal., 600kHz kHz - ±40

1000kHz kHz - ±70

1400kHz kHz - ±70

16. Low Voltage % 80 85

17. a. Mod. Hum dB 36 30

b. Hum at Min. Vol. mV 0.5 2

TEST ITEMS

CASSETTE SECTION

Frequency Response B-257 (1KHz, 0dB)

19. Rec. / Play Frequency Response 125Hz, 6.3kHz dB - ±6

TEST ITEMS

CD SECTION

FM (40kHz 1mV) dB 0 ±3

TEST ITEMS

Specifications may be subject to change without notice.

PERFORMANCE SPECIFICATIONS

PERFORMANCE SPECIFICATIONS - CONTINUED

UNIT NOMINAL LIMIT

1. 10% Dis. Output Power (1kHz, 0dB) W 2 1.6

2. Frequency Response (100Hz-20kHz/1kHz, 0dB) dB ±2 ±4

3. De-emphasis Response (1kHz, 0dB/5kHz-4.5dB/16kHz-9dB) dB ±3 ±4 *4. Channel Balance (1kHz, 0dB) dB 0.5 3 *5. Channel Separation (1kHz, 0dB) dB 55 40 *6. T.H.D. + Noise (1kHz, 0dB) % 0.15 0.5 *7. S/N Ratio (1HF-A) (1kHz, 0dB) dB 70 60

8. Playability: Wedge PHILIPS 444A µm - 500

Black Dot PHILIPS 444A µm 600 500 Eccentricity TCD-712ABEX µm - 150 Skew Disc TCD-731RABE mm - ±0.5 Finger Print PHILIPS 444A Track - No.18

*with external "A" Weighting Filter Item 1 - 4 Test Disc "CBS SONY YEDS7"

Level Matching Tape (B118N) dB 0 Tape (B112N) (For VDE Specical) dB 0 CD (-10dB 1K) dB 0 +3/-5 AM (55% 5mV/m) dB 0 ±3

UNIT NOMINAL LIMIT

1. Tape Speed (B-111LNA) Hz 3000 3% / -3%

2. Wow & Flutter Rms (JIS R.M.S.) (B-111LNA) % 0.35 0.45

3. Fast Forwards Time Sec. 110 100 - 180

4. Rewind - Time Sec. 110 100 - 180

6. Singal to Noise in Play (B-112BN) dB 45 35

7. Separation (MTT-141N) dB 40 30

8. Cross Talk (B-121N) w/BPF dB 40 35

9. Erase Ratio w/ BPF dB 32 26

10. Play Back Distortion (B-118N) % 1 3

11. Rec. / Playback S/N Ratio (FM 1mV 75kHz Dev.) w/BPF dB 32 26

12. Rec. / Playback Level Difference (Radio) dB - ±3

13. Play Back 10% Distortion-output Per W 2 1.7 Channel (B-112BN)

14. Record Play Back Distortion (S.R.L. + 20) % 3 8

15. ALC Effect Level (55% Mod., 74dB MW) dB - ±5

16. Recovery Time Sec. - <5

17. VR Min. Hum & Noise (Motor On) w/o Tape mV 0.5 3

18. VR Max. Hum & Noise (Motor On) w/o Tape mV 30 50

125Hz dB ±3 ±6

6.3kHz dB ±3 ±6

(FM) SECTION, FREQUENCY, MODULATION

1. Tuning Range MHz 87.5 - 108.5 87.5 - 108.5

±0.5

2. I. F. MHz 10.7 10.7 ±0.3

3. Max. Sens. 90MHz dB 10 15

Max. Sens. 98MHz dB 10 15

Max. Sens. 106MHz dB 10 15

4. S/N 30dB Quieting Sens. 90MHz dB 15 22

98MHz dB 15 22

106MHz dB 15 22

5. 3 dB Limit Sens. dB 25 30

6. I.F. Rej. 90MHz dB 60 50

7. Image Rej. 106MHz dB 30 22

8. Spurious Rej. (F± 5.35MHz) dB 40 34

(Max. Sens. +6dB)

9. AM Suppression

(60dB I/P)

dB 30 20

10. AFC Hold Range kHz 450 300 - 600

11. Distortion at 1mV (Mono) % 1 3

12. Audio Fidelity, (-3dB) (Pre-emphass) (50µS) Hz 60 - 9000 120 - 6000

13. Power Out, Max. W - -

10% THD W 2 1.7

14. Low Voltage % 80 85

15. S/N Ratio at 1mV (Mono) dB 50 45

Hum (at Min. Vol.) mV 0.5 3

S/N Ratio at 46 dB (Stereo) Dev. 40 kHz 10% Pilot

(for VDE Special) dB 36 42

w/A Filter

16. Hum (at Min. Vol.) mV 0.5 3

17. Dial Calib. MHz - ±0.75

18. Modulation Hum dB 50 45

(for VDE Special) dB 48 42

19. Stereo Separation dB 26 22

20. 19kHz Leak Carrier dB 32 27

21. Stereo On (for VDE Special) dB 26 30

TEST ITEMS

PERFORMANCE SPECIFICATIONS - CONTINUED

C107,136,137,138,139 CERAMIC CAP 0.047 uF/50V +80%-20% 003-047380-050

UNIT NOMINAL LIMIT

ELECTRICAL PARTS LIST

Ref. No. Description Mfr's Part No. Qty.

PCB

CONTROL PCB PCB CD6602-01-03 (94HB) 033-006602-100 1 MAIN PCB PCB CD6602-01-01 (94HB) 033-006602-300 1 REGULATION PCB PCB CD6602-01-02 (94HB) 033-006602-300 1 RECTIFIER PCB PCB CD2390-01-04 (94V0) 033-002390-100 1

REMOTE CONTROL SECTION

REMOTE CONTROL HANDSET RC18-06 w/BATTERY 043-R11806-010 1 L.GREY COLOR (FOR CD330x/CD66xx/CDG62)

BEAT CUT AND FM MONO/ST. SECTION

RESISTORS [All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified]

R1 *CdF RESISTOR 2.2 Kohm 001-022251-016 1 R318,319 *CdF RESISTOR 3.3 Kohm 001-033251-016 2

CAPACITOR

C317 #MYLAR CAP 0.001 uF/100V +-5% 004-010250-100 1

TRANSISTOR

Q301 TRLNPNSST-TAP&TO-092 3DG1815 008-618150-000 1

SWITCH

SW202 SLIDE SW SK22F03G9 AA F30 ALE (8C-CDC-622-18) 025-220091-108 1

(Cd FREE)

CD SECTION

RESISTORS [All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified]

R101 *CdF RESISTOR 10 ohm 001-010051-016 1 R32,107,157 *CdF RESISTOR 1 Kohm 001-010251-016 3 R130 *CdF RESISTOR 10 Kohm 001-010351-016 1 R105 RESISTOR 18 Kohm 001-018351-016 1 R102,103 RESISTOR 27 Kohm 001-027351-016 2 R158 RESISTOR 5.6 Kohm 001-056251-016 1 R108 RESISTOR 91 ohm 001-091051-016 1 SR114 CHIP RESISTOR 10 Kohm +-5% 1/16W 001-310352-016 1 R124,128,139,413 *CdF RESISTOR 10 Kohm 001-010351-016 4 R126 *CdF RESISTOR 100 Kohm 001-010451-016 1 R127 *CdF RESISTOR 15 Kohm 001-015351-016 1 R106 *CdF RESISTOR 2.2 Kohm 001-022251-016 1 R123 *CdF RESISTOR 22 Kohm 001-022351-016 1 R129,131,132,133,134 *CdF RESISTOR 3.3 Kohm 001-033251-016 5 R135,137 *CdF RESISTOR 33 Kohm 001-033351-016 2 R199 *CdF RESISTOR 470 ohm 001-047151-016 1 R125,415 *CdF RESISTOR 47 Kohm 001-047351-016 2 R136,138 *CdF RESISTOR 6.8 Kohm 001-068251-016 2 R104 RESISTOR 68K 001-068351-016 1

CAPACITORS

C104,105,114,122,123,128, (F003-010380-025) CERAMIC CAP 0.01 uF/ 003-010380-050 10 130,140,145,155 50V +80%-20% C1,3,102,108,109,110,111, CERAMIC CAP 0.1 uF/16V +80%-20% 003-010480-016 13 112,117,118,904,905,906 C157 CERAMIC CAP 0.0047 uF/50V +80%-20% 003-047280-050 1 C120 CERAMIC CAP 56 pF/50V +-10% 003-056010-050 1 C133 CERAMIC CAP 0.033 uF/50V +80-20% 003-033380-050 1 C126 CERAMIC CAP 47 pF/50V +-10% 003-047010-050 1 C132 CERAMIC CAP 0.0047 uF/50V +80%-20% 003-047280-050 1

3 4

ELECTRICAL PARTS LIST - CONTINUED ELECTRICAL PARTS LIST - CONTINUED

CMS-V75BG6 (U)

(B TYPE/4mm)

Ref. No. Description Mfr's Part No. Qty.

C135 CERAMIC CAP 820 pF/50V +-10% 003-082110-050 1 C134 CERAMIC CAP 0.0027 uF/50V +-10% 003-227210-050 1

(87-A11-125-08C) (AXIAL TAPED 52mm)

C142,143 CERAMIC CAP 27 pF/50V +-5% (NPO) 003-427050-050 2

(CC45-CH1H270J/RBU04CH270J-L) C147,151 #MYLAR CAP 0.0012 uF/100V +-10% 004-012210-100 2 C127 (F004-015310-050) #MYLAR CAP 0.015 uF/ 004-015310-100 1

100V +-10% C131 #MYLAR CAP 0.0027 uF/100V +-10% 004-027210-100 1 C152 ELECT CAP 1 MFD/50V +-20% (5x11) 006-001000-50D 1 C159 ELECT CAP 2.2 MFD/50V +-20% (5x11) 006-002000-50D 1 C146,150 ELECT CAP 3.3 MFD/50V +-20% (5x11) 006-003000-50D 2 EC101, C103,115,144,199 ELECT CAP 100 MFD/10V +-20% (5x11) 006-010100-10D 5 C148,149 ELECT CAP 22 MFD/25V +-20% (5x11) 006-022000-25D 2 C106 ELECT CAP 220 MFD/10V +-20% (6.3x11) 006-022100-10D 1 C113,116,119,121,124,125, *CdF ELECT CAP 47 MFD/16V +-20% (5x11) 006-047000-16D 8 129,156

CRYSTAL

X101 CRYSTAL 16.9344 MHz HC-49/S CL=16pF ±30ppm (SDE) 009-616934-500 1

TRANSISTORS

Q101 TR PNPSST-RAD&SC-043 2SA1015-GR TOSHIBA 008-110150-000 1 Q102 TRLNPNPWR-TAP&TO-092 3DA8050 008-680500-000 1 Q103 TR NPNSST-RAD&SC-072 DTC114ES (ROHM) 008-801141-000 1

INTEGRATED CIRCUITS

IC103 ICMOTORDRIVER-04CH TA2092N (TOSHIBA) 010-832092-000 1

(87-A20-157-01J/AIWA) IC102 ICCDP-001CASP TA2109F 010-832109-000 1 IC101 ICMCU-01K-LED TC9457F-010 010-849457-001 1

DIODES

D402 DIODE IN-4148 ROHM/TELEFUNKEN TAP**50 011-004148-000 1

KEL(NS)(TAP:52mm)/NS(FAIRCHILD)/SEMTECH ZD104 ZENER IN-5232B 5.6V 1/2W (ROHM) 011-010056-120 1 D101,102 RECTIFIER IN-4001B 011-024001-000 2

INDUCTOR

L101 INDUCTOR 10 uH CEC-100K +-10% (CdF) 018-010016-000 1

SWITCH

LEAF SWITCH LSA-1120Y2 (CdF) 022-001120-002 1

WIRES

CN5 TO CD HEAD FFC CABLE 16 PINS L=85mm 4+77+4 P:1mm 040-160085-101 1

0.035x7 (TUNG HING)/E188165/KNW9606-1A MOT-1 TO MOT- JP WIRE AWG26#1007 3x3mm 40mm RED 051-673040-006 1 P3A TO P3B JP WIRE AWG28#1007 5x5mm 60mm RED 051-875060-006 1 LEAF SW TO CON101 HSG CD170-100(C) PEC 2001H-2 w/150mm 136-020170-B01 1

RED,BLACK AWG28#UL1095 SLDG 4mm

CN3 TO CD MOTOR HSG CD2997-6A(R1) JST PHR w/105mm AWG26 136-062997-200 1

#UL2651TAT/6PIN FLAT CABLE SL.3.5mm (CdF)

MISCELLANEOUS

CN5,17 FFC CONN SOCKET 16P P:1 TAIKO DENKI 6116-0101/ 135-006116-160 2

CFF7816-01-01/TOC-B16X-G2) (CdF) CD&-TLB-01-SAMG-N CD MECHANISM 153-000756-000 1

Ref. No. Description Mfr's Part No. Qty.

CON101 HEADER CTL 2 PINS PHS-02 P:2mm, 135-PHS020-020 1

STRAIGHT TYPE WHT COLOR (MARKING:HR) (CdF)

CD CONTROL SECTION

RESISTORS [All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified]

R704 *CdF RESISTOR 1 Kohm 001-010251-016 1 R705 RESISTOR 2 Kohm 001-020251-016 1 R711 *CdF RESISTOR 220 ohm 001-022151-016 1 R703,708 *CdF RESISTOR 330 ohm 001-033151-016 2 R701,702 *CdF RESISTOR 3.3 Kohm 001-033251-016 2 R706,709 *CdF RESISTOR 6.8 Kohm 001-068251-016 2

SWITCHES

SW702B TACT SWITCH 4P 5mm 100G #1102A-4/ 021-110200-002 1

EVQ PAC 05R (=021-KHH901-000)

SW701,703,704,705,706 TACT SWITCH 4P 5mm 100G #1102A-4/ 021-110200-002 5

EVQ PAC 05R (=021-KHH901-000)

MISCELLANEOUS

CED701 LEDD-G0.5IN-2.0D-C-R A505GD-D GREEN 111-000505-004 1

LY 5045-N / F1-2050AHG1 PAOG.LED LED LAMP #TLR124 3mm RED TOSHIBA 110-001240-003 1 CN701 FFC CONNECTOR 16 PINS P:1mm D100-SRV-16U/ 135-D100SR-160 1

LWFPC1.0-R-16P RIGHT-ANGLE

GENERAL SECTION

WIRE

MAIN PCB CN17 TO FFC CABLE 16 PINS L=140mm 4+132+4 040-160140-102 1 CTL PCB CN19 PITCH:1mm UL2896 0.035x0.7 (TUNG HING)

INDUCTORS

CON601 DC CABLE w/2 TURNS

CON101 DOOR SW CABLE OD:18mm, ID:10mm, T:6mm w/1.5 TURNS

AC CORD AROUND 2.5 TURN

MISCELLANEOUS

FERRITE CORE #191806100AFX/T18x6x10 032-219180-000 2

FERRITE CORE FYE-T-062/T25x15x10 032-225015-010 1

OD:25mm, ID:15mm, T:10mm

POWER TF EI-48 230V:12.4V EN/IEC (HCD213ENFN) 123-380213-140 1

FUSE #21801.6 1.6A/250V 5x20mm TIME LAG 124-016000-002 1

(CUL/SEMKO/VDE/BSI APP.)

(F134-220120-001) PLA-VDE-6'06"-VDE-MG 134-B10331-004 1

VDE APP.CORD 6.5'

POWER AMP. SECTION

RESISTORS [All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified]

R805,806,807,808 *CdF RESISTOR 1 Kohm 001-010251-016 4 R405,406,408,801,802 *CdF RESISTOR 10 Kohm 001-010351-016 5 R809,810 *CdF RESISTOR 150 ohm 001-015151-016 2 R811,812 RESISTOR 180 ohm 001-018151-016 2 R898,899 RESISTOR 2.2 ohm 001-022851-016 2 R410,411 *CdF RESISTOR 33 Kohm 001-033351-016 2 R407,813 *CdF RESISTOR 4.7 Kohm 001-047251-016 2 VR801 VR-E12M2GV050KAWSH&D 50KCx2 RK12L12C0 030-E12503-202 1

CAPACITORS

C905 CERAMIC CAP 0.1 uF/16V +80%-20% 003-010480-016 1 C807,808 CERAMIC CAP 470 pF/50V +-10% TAPING 003-047110-051 2

5 6

ELECTRICAL PARTS LIST - CONTINUED ELECTRICAL PARTS LIST - CONTINUED

ZENER IN-5237B, 8.2V, 1/2W 011-010082-120

Ref. No. Description Mfr's Part No. Qty.

C815,816 #MYLAR CAP 0.15 uF/100V +-10% 004-015410-100 2 C801,802 #MYLAR CAP 0.0027 uF/100V +-10% 004-027210-100 2 C819 ELECT CAP 0.47 MFD/50V +-20% (5x11) 006-000400-50D 1 C805,806 ELECT CAP 2.2 MFD/50V +-20% (5x11) 006-002000-50D 2 C404,403 ELECT CAP 10 MFD/50V +-20% (5x11) 006-010000-50D 2 C811,812,809,810 ELECT CAP 100 MFD/10V +-20% (5x11) 006-010100-10D 4 C820 ELECT CAP 1000 MFD/25V +-20% (12.5x20) 006-010200-25D 1 C817 ELECT CAP 330 MFD/10V +-20% (8x11.5) 006-033100-10D 1 C405,830 *CdF ELECT CAP 47 MFD/16V +-20% (5x11) 006-047000-16D 2 C813,814 ELECT CAP 470 MFD/10V +-20% (8x11.5) 006-047100-10D 2

TRANSISTORS

Q801,802 TRANSISTOR 2SK2541-T/2SK2541 (NEC) 008-902541-000 2

INTEGRATED CIRCUIT

IC801 ICAMP-POWR-ST-00002W TA8227P TOSHIBA 010-838227-000 1

POWER AMPLIFIER 2Wx2

DIODE

D401 DIODE IN-4148 ROHM/TELEFUNKEN TAP**50 011-004148-000 1

KEL(NS)(TAP:52mm)/NS(FAIRCHILD)/SEMTECH

INDUCTORS

L892,893 INDUCTOR 4.7 uH +-10% LAL04NA4R7K 018-010477-202 2 L890,891 TOROIDAL COIL 8 uH HA1205122008-1 037-512008-080 2 L894,895,896 TOROIDAL COIL 100 uH RI63-870001 (COILS) 037-870001-A00 3

SWITCH

SW203/FUNCTION SLIDE SW SK43D01G9 4P3T 025-430091-104 1

WIRE

TP1-A TO TP1-B JP WIRE AWG26#1007 5x5mm 120mm BLACK 051-675120-009 1

MISCELLANEOUS

HP1 HEADPHONE JACK STEREO 3.5mm #MSJ-2000 116-002000-351 1

(87-A60-420-01)

CON802,803 HEADER MOLEX 2 PINS 5268-02A PITCH 2.5mm 135-005268-020 2

HORIZONTAL TYPE

CON801 HEADER 3 PINS PEC #2507-WS-3 PITCH 2.5mm 135-2507WS-030 1

VERTICAL REPLACE:135-005267-030

RECTIFIER SECTION

RESISTORS [All are +-5% 1/16W(1/8W) tape & wheel resistors unless otherwise specified]

R902 *CdF RESISTOR 10 Kohm 001-010351-016 1 R901,904 *CdF RESISTOR 470 ohm 001-047151-016 2 R903 *CdF RESISTOR 4.7 Kohm 001-047251-016 1

CAPACITORS

C601,602,603,604 (F003-010380-025) CERAMIC CAP 0.01 uF/ 003-010380-050 4

50V +80%-20% C901 ELECT CAP 100 MFD/10V +-20% (5x11) 006-010100-10D 1 C605,818,821 ELECT CAP 1000 MFD/25V +-20% (12.5x20) 006-010200-25D 3 C902 ELECT CAP 470 MFD/16V +-20% (10x12.5) 006-047100-16D 1

TRANSISTORS

Q902 TRANSISTOR B1566E (LIGHTNING) 008-201566-100 1 Q901 TRLNPNPWR-TAP&TO-092 3DA8050 008-680500-000 1

DIODES

D901,902,904 DIODE IN-4148 ROHM/TELEFUNKEN TAP**50 011-004148-000 3

KEL(NS)(TAP:52mm)/NS(FAIRCHILD)/SEMTECH D903

Ref. No. Description Mfr's Part No. Qty.

D601,602,603,604 RECTIFIER J-05, 1.5A, 50V 011-020005-000 4 D907,908 RECTIFIER IN-4001B 011-024001-000 2

WIRE

RTF PCB TO MAIN PCB CON12

HSG CD268-3B(C) PEC 2507H-3 w/250mm 136-030268-C00 1 RED,NC,BLACK AWG22#UL1007 SLDG.4mm

TAPE SECTION

RESISTORS [All are +-5% 1/16W (1/8W) tape & wheel resistors unless otherwise specified]

R322 *CdF RESISTOR 10 Kohm 001-010351-016 1 R311,315 *CdF RESISTOR 12 Kohm 001-012351-016 2 R321 *CdF RESISTOR 220 ohm 001-022151-016 1 R302 RESISTOR 220 Kohm 001-022451-016 1 R314,317 RESISTOR 2.7 Kohm 001-027251-016 2 R320 RESISTOR 5.6 ohm 001-056851-016 1 VR301 SEMI-FIXED DIA.8mm 10 Kohm EVND8AA03B14 002-103085-100 1

DOUBLE CONTACT/HOR. 3PINS (CdF+) R342 *CdF RESISTOR 100 ohm 001-010151-016 1 R312,316,389 *CdF RESISTOR 1 Kohm 001-010251-016 3 R310,323 *CdF RESISTOR 10 Kohm 001-010351-016 2 R304 RESISTOR 120 ohm 001-012151-016 1 R306,307,309,313 *CdF RESISTOR 4.7 Kohm 001-047251-016 4 R305,308 RESISTOR 56 ohm 001-056051-016 2 R301,303 *CdF RESISTOR 82 Kohm 001-082351-016 2

CAPACITORS

MC319,320 #MYLAR CAP 0.01 uF/100V +-10% 004-010310-100 2 C318 #MYLAR CAP 0.0047 uF/100V +-5% 004-047250-100 1 C321 ELECT CAP 220 MFD/16V +-20% (6.3x11) 006-022101-16D 1

(SA16V221M) C314,316 #MYLAR CAP 0.01 uF/100V +-10% 004-010310-100 2 C304,310 #MYLAR CAP 0.0022 uF/100V +-5% 004-022250-100 2 C305,312 #MYLAR CAP 0.027 uF/100V +-5% 004-027350-100 2 C313,315 #MYLAR CAP 0.0047 uF/100V +-10% 004-047210-100 2 C303,307 ELECT CAP 4.7 MFD/50V +-20% (5x11) 006-004000-50D 2 C301,306,309 ELECT CAP 10 MFD/50V +-20% (5x11) 006-010000-50D 3 C302,308,326 *CdF ELECT CAP 47 MFD/16V +-20% (5x11) 006-047000-16D 3 C311 ELECT CAP 470 MFD/10V +-20% (8x11.5) 006-047100-10D 1

TRANSISTOR

Q302 TRLNPNPWR-TAP&TO-092 3DA8050 008-680500-000 1

INTEGRATED CIRCUIT

IC301 IC LS22241 AMP.CASS 010-732224-000 1

DIODES

D301,302 DIODE IN-4148 ROHM/TELEFUNKEN TAP**50 011-004148-000 2

KEL(NS)(TAP:52mm)/NS(FAIRCHILD)/SEMTECH ZD301 ZENER IN-5237B, 8.2V, 1/2W 011-010082-120 1

INDUCTOR

T301 (F012-000600-010) IFT S4B60R(B) 10mm BLK 012-000460-010 1

WIRES

FROM E/H TO CON301 HSG CD368-4B(C) PEC 2507-H-4 w/234mm BLK 136-040368-C01 1

SHIELD WIRE AWG30#UL2547/3C SLDG.2mm

CON 501 TO DECK MOTOR/ L.SW

SWITCH

HSG 5CD1-4B JST PHR-04 w/310mm BLACK,RED 136-045CD1-201 1

BLUE,YELLOW AWG28#UL1571 SLDG 4mm

CERAMIC CAP 33 pF/50V +-10% 003-033010-050

(Cd FREE)

ELECTRICAL PARTS LIST - CONTINUED ELECTRICAL PARTS LIST - CONTINUED

Ref. No. Description Mfr's Part No. Qty.

SW2 REC SWITCH 9P2T, 2mm PS92D01/PS92D01A (CdF) 024-009220-000 1

MISCELLANEOUS

CON301 HEADER 4PINS PEC #2507-WS-4 P:2.5mm 135-2507WS-040 1

VERTICAL REPLACE:135-005267-040 CASSDECK-SM-T-S03+&& TN-9ZR-219 150-000219-K00 1 w/o MOTOR,RP HEAD,E HEAD MOTOR-DC-002V-NORMAL 2V #RF-410CA-12250 151-021225-000 1 (MABUCHI) (TKS-71-A848) RP/HEAD-&&-&&&&&&&&& #6PA (CHENWEI) 152-020006-000 1 RP/HEAD-ST-TECHRECO& #TC-951(039) w/o PCB 152-020951-001 1

GOVERNORS SECTION

RESISTORS [All are +-5% 1/16W(1/8W) tape & wheel resistors unless otherwise specified]

R503 *CdF RESISTOR 1 Kohm 001-010251-016 1 R505,508,504 RESISTOR 1.5 ohm 001-015851-016 3 R506 RESISTOR 820 ohm 001-082151-016 1 R501,502,509,510 RESISTOR 8.2 ohm +-5% 2W 001-082850-002 4 R507 RESISTOR 9.1 Kohm 001-091251-016 1 VR501 SEMI-FIXED DIA.8mm 500 ohm DOUBLE CONTACT/ 002-501085-000 1

HORIZONTAL 3 PINS (CdF)

CAPACITORS

C505 CERAMIC CAP 0.001 uF/50V +80%-20% 003-210280-050 1

(UP050YF102Z) (AXIAL TAPED 52mm) C504 #MYLAR CAP 0.1 uF/50V +-10% 004-010410-050 1 C503 ELECT CAP 100 MFD/10V +-20%(5x11) 006-010100-10D 1 C506 ELECT CAP 100 MFD/16V +-20% (5x11) 006-010100-16D 1 C502 ELECT CAP 220 MFD/10V +-20%(6.3x11) 006-022100-10D 1 C501 *CdF ELECT CAP 47 MFD/16V +-20% 006-047000-16C 1

(VX SERIES/5x11)

TRANSISTOR

Q501 TRLNPNPWR-TAP&TO-092 3DA8050 008-680500-000 1

INTEGRATED CIRCUIT

IC501 IC UTC6650 MOTOR SPEED CONTROL IC 010-396650-000 1

DIODE

ZD501 ZENER WZ-033, 3.3V, 1/2W 011-010033-120 1

MISCELLANEOUS

CON501 HEADER CTL 4 PINS PHS-04 PITCH 2mm 135-PHS040-040 1

STRAIGHT TYPE WHT COLOR (MARKING:HR)

TUNER SECTION

RESISTORS[All are +-5% 1/16W(1/8W) tape & wheel resistors unless otherwise specified]

R209 RESISTOR 1.2 Kohm 001-012251-016 1 R208 *CdF RESISTOR 1 Kohm 001-010251-016 1

*CdF RESISTOR 100 Kohm 001-010451-016 1 R415 RESISTOR 150 Kohm 001-015451-016 1 R207,413 *CdF RESISTOR 330 ohm 001-033151-016 2 R201 *CdF RESISTOR 3.3 Kohm 001-033251-016 1 R71 *CdF RESISTOR 470 ohm 001-047151-016 1 R204,206 *CdF RESISTOR 4.7 Kohm 001-047251-016 2 R202 RESISTOR 68 ohm 001-068051-016 1 R203,205 RESISTOR 8.2 Kohm 001-082251-016 2

CAPACITORS

C210

Ref. No. Description Mfr's Part No. Qty.

PVC DF443DF01-A04 AM/FM 126/20pF 013-312620-003 1

WIRING TYPE (20.2x20.2x13mm) C212 CERAMIC CAP 0.1 uF/16V +80%-20% 003-010480-016 1 C220,221 CERAMIC CAP 20 pF/50V +-10% 003-020010-050 2 C205,208,213 CERAMIC CAP 0.02 uF/50V +80%-20% 003-020380-050 3 C222 CERAMIC CAP 30 pF/50V +-10% 003-030010-050 1 C204 CERAMIC CAP 330 pF/50V +-10% 003-033110-050 1 C201 CERAMIC CAP 22 pF/50V +-5% (NPO) 003-422050-050 1

(CC45-CH1H220J/RBU04CH220J-L) C209 CERAMIC CAP 24 pF/50V +-5% (NPO) 003-424050-050 1

(CC45-CH1H240JYA/RBU04CH240J-L) C203 CERAMIC CAP 4 pF/50V +-0.25pF (NPO) 003-440830-050 1

(CC45-CH1H040C/RBU04CH040C-L) MC201,202 #MYLAR CAP 0.018 uF/100V +-10% 004-018310-100 2 MC206,207 #MYLAR CAP 0.0027 uF/100V +-10% 004-027210-100 2 MC203,204,208,209 #MYLAR CAP 0.0068 uF/100V +-10% 004-068210-100 4 *CdF POLY CAP 130 pF/50V +-5% 005-013100-000 1

(B131J09P2HH33AAA) EC203,204 *CdF ELECT CAP 0.1 MFD/50V +-20% (VX/5x11) 006-000100-50C 2 EC201,208 ELECT CAP 0.47 MFD/50V +-20% (5x11) 006-000400-50D 2 EC205,206,207 ELECT CAP 1 MFD/50V +-20% (5x11) 006-001000-50D 3 EC202 ELECT CAP 220 MFD/16V +-20% (6.3x11) 006-022101-16D 1

(SA16V221M) EC209 ELECT CAP 33 MFD/16V +-20% (5x11) 006-033000-16D 1

INTEGRATED CIRCUIT

IC201 ICREVA-AFM-FR-IF-MPX TA2111N (TOSHIBA) 010-832111-001 1

DIODES

D201,202 DIODE IN-4148 ROHM/TELEFUNKEN TAP**50 011-004148-000 2

KEL(NS)(TAP:52mm)/NS(FAIRCHILD)/SEMTECH

INDUCTORS

T301 IFT S7B146R 10mm (GREEN) 012-007146-010 1 L209,210 INDUCTOR 10 mH R0002-CW68-103K-813337/ 018-010012-004 2

3A1565N T204 *CdF IFT 4A-224R, 10mm 012-002240-010 1 T202 IFT 1A1103R(B) 10mm 012-011030-010 1

AM COIL 80:40T L1=150mm,L2/3=100mm0.07x3 014-080403-150 1

10.5x32mm AN73-866846 (HERO WELL)

L206 FM COIL 3T, 5mm, DIA:0.8mm (CS58-862492) 015-030050-008 1

(2.5Tx5mmx0.8mm/HEROWELL) L203,208 FM COIL 4T, 5mm, DIA:0.8mm (CS58-862493) 015-040050-008 2

(3.5Tx5mmx0.8mm/HEROWELL) L204 INDUCTOR 10 uH CEC-100K +-10%(CdF) 018-010016-000 1 L201 INDUCTOR 4.7 uH/CEC-4R7K +-10% 018-010477-000 1

LAL03 TB 4R7K

FERRITE BAR 10x70mm (CdF) 032-010070-000 1

RESONATORS

CF204 CERAMIC FILTER L10.7MS2-A (CQ) 019-000107-029 1 CF203 CERAMIC FILTER LT-465B (SFU465B/GENFIELD) 019-000465-002 1

SWITCH

SW201/AM FM SLIDE SW SK22F03G9 AA F30 ALE (8C-CDC-622-18) 025-220091-108 1

+ 14 hidden pages

Akai QXD-3100 Service manual

Specifications and Main Features

Frequently Asked Questions

User Manual