VOLVO V70 (08-), XC70 (08-) & S80 (07-)
WIRING DIAGRAM 2014/2015A
TP 39272202 Structure week 13w46
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Data link connector in the passenger compartment
Changes introduced up to and including structure week 13w46
Any changes made to the vehicle after this date are not included in the manual. If necessary,
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from the Technical Information Shop (TIS)
at tis.volvocars.biz/tis/
We retain the right to make modifications
© Volvo Car Corporation
Table of Contents 1:4
Explanations .................................................................. 7
How to use the wiring diagrams 1:2............................... 8
Electrical distribution
Overview without Start/Stop function........................... 10
Overview with Start/Stop function................................ 11
Overview, Distribution box in engine compartment,
exc. 4-Cyl. 2.0L............................................................ 12
Overview, Distribution box in engine compartment,
4-Cyl. 2.0L ................................................................... 13
Overview, Distribution box in passenger compartment 14
Overview, Distribution box in cargo compartment ....... 15
Fuses
Distribution box in engine compartment F1-F7............. 16
Distribution box in engine compartment F8-F21........... 17
Distribution box in engine compartment F22-F31......... 18
Distribution box in engine compartment F32-F37......... 19
Distribution box in engine compartment F38 ................ 20
Distribution box in engine compartment F38-F39......... 21
Distribution box in engine compartment F39-F44......... 22
Central electronic module (CEM) F1-F3 ....................... 23
Central electronic module (CEM) F4-F14 ..................... 24
Central electronic module (CEM) F15-F24 ................... 25
Passenger compartment............................................... 26
Distribution box in passenger compartment F1-F17..... 27
Distribution box in passenger compartment F18-F24... 28
Distribution box in passenger compartment F25-F30... 29
Distribution box in cargo compartment FA1-FA11........ 30
Distribution box in engine compartment,
cold zone F1-MF2......................................................... 31
Battery PF1-PF2 ........................................................... 32
Relays
Relays in the engine compartment .............................. 33
Relays in the engine compartment .............................. 34
Relays in passenger compartment .............................. 35
Relays in cargo compartment ...................................... 36
Ground connections
Overview...................................................................... 37
31/1 - 31/6.................................................................... 38
31/7 - 31/10.................................................................. 39
31/10 - 31/15................................................................ 40
31/47 - 31/65................................................................ 41
31/66 - 31/83................................................................ 42
31/84 - 31/90................................................................ 43
31/93 - 31/XX4............................................................. 44
31/XX10 - 31/AL .......................................................... 45
Control modules
Overview locations....................................................... 46
Overview designations................................................. 47
Central Electronic Module (CEM) 1:3 .......................... 48
Data communication high speed CAN exc. 4-Cyl. ....... 51
Data communication high speed CAN, 4-Cyl. 1.6L...... 52
Data communication high speed CAN, 4-Cyl. 2.0L 1:2 53
Data communication intermediate speed CAN, LHD... 55
Data communication intermediate speed CAN, RHD .. 56
Data communication MOST......................................... 57
Data communication, LIN 1:3....................................... 58
Steering Wheel Module (SWM) ................................... 61
Group 26 Cooling system
Cooling fan, 4-Cyl. 1.6L Turbo ..................................... 62
Cooling fan, 4-Cyl. 2.0L Turbo ..................................... 63
Cooling fan, 5-Cyl. Turbo ............................................. 64
Cooling fan, 6-Cyl. ....................................................... 65
Cooling fan, 4-Cyl. 1.6L Diesel .................................... 66
Cooling fan, 4-Cyl. 2.0L Diesel .................................... 67
Cooling fan, 5-Cyl. Diesel ............................................ 68
Group 27 Engine controls
Cruise control 4-Cyl. 1.6L Turbo ...................................69
Cruise control 4-Cyl. 2.0L Turbo ...................................70
Cruise control 4-Cyl. 1.6L Diesel ..................................71
Cruise control 4-Cyl. 2.0L Diesel ..................................72
Cruise control 5-Cyl. Turbo ...........................................73
Cruise control 6-Cyl. .....................................................74
Cruise control 5-Cyl. Diesel ..........................................75
Start-/Stop function 4-Cyl. 1.6L Turbo ..........................76
Start-/Stop function 4-Cyl. 2.0L Turbo ..........................77
Start-/Stop function 4-Cyl. 1.6L Diesel..........................78
Start-/Stop function 4-Cyl. 2.0L Diesel..........................79
Start-/Stop function 5-Cyl. Diesel..................................80
Group 28 Ignition and control system
Engine management system, 4-Cyl. 1.6L Turbo 1:2.... 81
Engine management system, 4-Cyl. 2.0L Turbo 1:3.... 83
Engine management system, 5-Cyl. Turbo 1:2............ 86
Engine management system, 6-Cyl. 3.2L PZEV 1:2.... 88
Engine management system, 6-Cyl. 1:2 ...................... 90
Engine management system, 6-Cyl. Turbo 1:2............ 92
Engine management system, 4-Cyl. 1.6L Diesel 1:3 ... 94
Engine management system, 4-Cyl. 2.0L Diesel 1:3 ... 97
Engine management system, 5-Cyl. Diesel 1:3 ......... 100
Emission control 4-Cyl. 1.6L Turbo............................ 103
Emission control 4-Cyl. 2.0L Turbo............................ 104
Emission control 5-Cyl. Turbo.................................... 105
Emission control 6-Cyl. 3.2L PZEV............................ 106
Emission control 6-Cyl. 3.2L ...................................... 107
Emission control 6-Cyl. Turbo.................................... 108
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 3
Table of Contents 2:4
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. without Start/Stop ..................... 109
Power supply 4-Cyl. with Start/Stop .......................... 110
Power supply 5-Cyl. without Start/Stop ..................... 111
Power supply, 5-Cyl. with Start/Stop ......................... 112
Power supply 6-Cyl.................................................... 113
Group 33 Starting system
Starting system 4-Cyl. 1.6L Turbo without Start/Stop 114
Starting system 4-Cyl. 1.6L Turbo with Start/Stop 1:2 115
Starting system 4-Cyl. 2.0L Turbo 1:2 ....................... 117
Starting system 5-Cyl. Turbo ..................................... 119
Starting system 6-Cyl................................................. 120
Starting system 4-Cyl. 1.6L Diesel 1:2....................... 121
Starting system 4-Cyl. 2.0L Diesel 1:2....................... 123
Starting system 5-Cyl. Diesel without Start/Stop ....... 125
Starting system 5-Cyl. Diesel with Start/Stop 1:2 ...... 126
Group 35 Lighting
High and low beam, Halogen..................................... 128
High and low beam, Dual Xenon ............................... 129
Beam length adjustment, manual .............................. 130
Running/Parking light, Tail lights V70 ........................ 131
Running/Parking light, Tail lights S80 ........................ 132
Fog/Daytime running lights V70 & XC70 ................... 133
Fog/Daytime running lights S80................................. 134
Brake lights V70......................................................... 135
Brake lights S80......................................................... 136
Reversing lights V70.................................................. 137
Reversing lights S80.................................................. 138
Follow-me-home lighting LHD ................................... 139
Follow-me-home lighting RHD................................... 140
Interior lighting, LHD 1:2 ............................................ 141
Interior lighting, RHD 1:2 ........................................... 143
Active headlight ......................................................... 145
Lighting in door sill trims ............................................ 146
Auxiliary lights............................................................ 147
Lighting mug holder and floor .................................... 148
Group 36 Additional electrical equipment
Rain sensor................................................................ 149
Direction indicator and hazard warning flashers
LHD V70 .................................................................... 150
Direction indicator and hazard warning flashers
LHD S80 .................................................................... 151
Direction indicator and hazard warning flashers
RHD V70.................................................................... 152
Direction indicator and hazard warning flashers
RHD S80.................................................................... 153
Wiper/washer windshield ........................................... 154
High pressure headlight washer ................................ 155
Wiper/Washer rear window........................................ 156
Keyless vehicle 1:2 .................................................... 157
Horn ...................................................................... 159
Anti-theft alarm........................................................... 160
Parking assistance..................................................... 161
Collision warning with power brake booster............... 162
Tire pressure monitoring system (TPMS) .................. 163
Alcohol lock................................................................ 164
Group 37 Wiring and fuses
Diagnostics system .................................................... 165
Outlet 12 V ................................................................. 166
Outlet 12 V, S80......................................................... 167
Cable harness towbar/tow hitch 4-pin V70 ................ 168
Cable harness towbar/tow hitch 4-pin S80 ................ 169
Cable harness towbar/tow hitch 7-pin V70 ................ 170
Cable harness towbar/tow hitch 7-pin S80 ................ 171
Cable harness towbar/tow hitch 13-pin V70 .............. 172
Cable harness towbar/tow hitch 13-pin S80 .............. 173
Accessory USB unit (AUU) ........................................ 174
Group 38 Instruments
Seat belt reminder...................................................... 175
Driver information module.......................................... 176
Analog clock............................................................... 177
Group 39 Other, Accessories
TV ...................................................................... 178
Cellular phone 1:2...................................................... 179
Audio 1:2.................................................................... 181
Audio Premium 1:3 .................................................... 183
DAB Radio ................................................................. 186
Bluetooth Handsfree .................................................. 187
Multimedia monitor with DVD, Dual Screen (RSE),
V70 ...................................................................... 188
Multimedia monitor with DVD, Dual Screen (RSE),
S80 ...................................................................... 189
Satellite radio ............................................................. 190
Parking camera.......................................................... 191
Parking camera wide-angle, front .............................. 192
Navigation system, portable....................................... 193
Sensus Connected Touch.......................................... 194
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 4
Table of Contents 3:4
Group 43 Transmission
Transmission M66 ..................................................... 195
Automatic transmission MPS6................................... 196
Automatic transmission AWF21................................. 197
Automatic transmission AWF22................................. 198
Differential Electronic Module (DEM)......................... 199
Group 55 Parking brake
Electric parking brake ................................................ 200
Group 59 Brake system
Brake control system & DSTC ................................... 201
Group 64 Steering
Power steering EHPAS.............................................. 202
Power steering EPAS ................................................ 203
Group 76 Shock absorbers
Four-C ...................................................................... 204
Group 83 Doors and openings
Central locking front doors LHD................................. 205
Central locking front doors RHD ................................ 206
Central locking rear doors.......................................... 207
Central locking trunk lid/tailgate V70 ......................... 208
Central locking trunk lid/tailgate S80 ......................... 209
Central locking fuel filler flap...................................... 210
Signal receiver central locking ................................... 211
Power windows front doors LHD ............................... 212
Power windows front doors RHD............................... 213
Power windows rear doors ........................................ 214
Power sunroof............................................................ 215
Group 84 Exterior decorative elements, etc.
Power door mirrors LHD ............................................ 216
Power door mirrors RHD ........................................... 217
Heated door mirrors LHD........................................... 218
Heated door mirrors RHD .......................................... 219
Blind spot information system LHD............................ 220
Blind spot information system RHD ........................... 221
Heated windshield LHD ............................................. 222
Heated windshield RHD............................................. 223
Heated rear window ................................................... 224
Group 85 Interior equipment
Power driver’s seat with memory function LHD ......... 225
Power driver’s seat with memory function RHD......... 226
Power passenger seat LHD ....................................... 227
Power passenger seat RHD ...................................... 228
Heated steering wheel ............................................... 229
Heated front seats with fans ...................................... 230
Heated front seats without fans ................................. 231
Heated rear seat ........................................................ 232
Executive functions 1:2 .............................................. 233
Group 87 Climate control system
Climate control system 4-Cyl. 1.6L Turbo 1:2............ 235
Climate control system 4-Cyl. 2.0L Turbo 1:2............ 237
Climate control system 4-Cyl. 1.6L Diesel 1:2 ........... 239
Climate control system 4-Cyl. 2.0L Diesel 1:2 ........... 241
Climate control system 6-Cyl. 1:2 .............................. 243
Climate control system 5-Cyl. Turbo 1:2.................... 245
Climate control system 5-Cyl. Diesel 1:2 ................... 247
Climate control system PTC-elements....................... 249
Parking heater, auxiliary heater ................................. 250
Parking heater, remote start ...................................... 251
Refrigeration box rear seat ........................................ 252
Group 88 Internal equipment
Supplemental restraint system 1:2............................. 253
Power folding headrest .............................................. 255
Remote control garage opening................................. 256
Rear-view mirror with automatic dimming.................. 257
Connectors.............................................. 258
Branching points .................................... 306
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 5
Table of Contents 4:4
Cable harness routing in vehicle
Engine harness, 4-Cyl. 1.6L Turbo ............................. 329
Engine harness, 4-Cyl. 2.0L Turbo ............................. 329
Engine harness, 4-Cyl. Diesel 1.6 MAN .....................330
Engine harness, 4-Cyl. Diesel 1.6 AUTO ...................330
Engine harness, 4-Cyl. Diesel 2.0 ..............................331
Engine harness, 5-Cyl. Turbo ..................................... 331
Engine harness, 5-Cyl. Diesel ....................................332
Engine harness, 6-Cyl. 3.0L Turbo ............................. 332
Engine harness, 6-Cyl. 3.2L .......................................333
Engine harness, 6-Cyl. 3.2L PZEV ............................. 333
Engine compartment harness, LHD............................ 334
Engine compartment harness, RHD ........................... 334
Dashboard harness, LHD ........................................... 335
Dashboard harness, RHD........................................... 336
Floor harness, S80 LHD ............................................. 337
Floor harness, S80 RHD............................................. 338
Floor harness, V70 LHD ............................................. 339
Floor harness, V70 RHD............................................. 340
Infotainment harness, S80 LHD.................................. 341
Infotainment harness, S80 RHD ................................. 342
Infotainment harness, V70 LHD.................................. 343
Infotainment harness, V70 RHD ................................. 344
Roof harness, LHD ..................................................... 345
Roof harness, RHD.....................................................346
Heated windscreen adapter harness ..........................347
Tunnel harness ...........................................................347
Harness driver door, LHD ...........................................348
Harness driver door, RHD...........................................348
Harness passenger door, LHD ...................................349
Harness passenger door, RHD...................................349
Harness rear door, S80 LHD ......................................350
Harness rear door, S80 RHD......................................350
Harness rear door, V70 LHD ......................................351
Harness rear door, V70 RHD......................................351
Tailgate harness .........................................................352
Harness bumper, front ................................................352
Harness bumper,V70, rear..........................................353
Harness bumper,S80, rear..........................................353
Executive harnesses...................................................354
Component illustrations ......................... 355
Index 1:2 ................................................... 415
List of components 1:7 ........................... 418
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 6
Explanations
Abbreviations
Groups
Group 26 = Cooling system
Group 27 = Engine controls
Group 28 = Ignition and control system
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Group 89 = Body other
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E = Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N = Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
AWF21 = TF-80SC & TF-80SD
AWF22 = TG-81SC
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
Du-X = Dual Xenon
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HISPEED = High speed data bus
HS = High speed data bus
IR = Infrared sensor
KEYLESS = Keyless vehicle
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIDSPEED = Midspeed data bus
MIRCAM = Parking camera in rear-view mirror
MMS = Mass Movement Sensor
MS = Midspeed data bus
PANROOF = Panoramic roof
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SCR = Screened
SRS = Airbag
T = Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 7
How to use the wiring diagrams 1:2
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily contained in this manual.
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2 Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7 Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
The systems are shown in non active
status, i.e. with “key removed” and when
doors, hatches and hood are closed.
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable
harnesses and are described in the "Connectors"
section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the section "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section
"Abbreviations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 8
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 9
Electrical distribution
Overview without Start/Stop function
15/31
RD
RD
12
12
12
12
12
73/3137
73/3136
PF1
2
1
11B/27
RD-VT
RD-VT
1
2/31
R7
RD-VT
3
2
1
11A/1
11A/2
11A/4
11A/5
11A/3
1/1
1
5
2
7/240
BMS
I
U
LIN
12V
11B/17
12
BK
GY-BK
GN-VT
RD-BK
RD-BU
4/56
C1:13
RD-GY
RD-BN
C1:63
C5:1
C5:2
F17
12
F18
12
F19
12
F20
12
15/36
2/193
R4
5
2/88
R1
5
1
11C/21
1
2
CEM
CAN
LIN
12
1
1
1
1
1
2
3
1
3
2
C2:5
C1:9
RD-GN
RD-VT
RD-GN
15/32
21
21
21
21
21
21
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
F1
2
F2
2
F3
2
F4
2
F5
2
F6
VT-GN
14
74/504
74/504B
RD
VT-GN
BU
RD-GN
2
73/5075
RD-GN
RD-VT
21
21
5
3
1
2
5
3
1
2
11D/A11
11D/A12
2/16
RA2
2/82
RA1
A
31/3
RD-GN
C31W051
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 10
Electrical distribution
Overview with Start/Stop function
RD
15/31
11B/34
15/37
1
MF2
2
1
MF1
2
RD-GN
RD-VT
RD-GN
RD-GN
RD-VT
RD-VT
RD-VT
1
15/32
RD-VT
21
21
21
21
21
21
21
21
5
2
5
2
7/240
BMS
I
U
LIN
1/1
12V
3
1
3
1
1
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
11D/A11
11D/A12
2/16
RA2
2/82
RA1
BK
A
C1:63
C1:13
C5:1
C5:2
RD-BU
4/56
2
1
12
12
2
1
F17
F18
F19
F20
CEM
CAN
LIN
C2:17
C2:5
C1:9
74/504
VT-GN
14
RD
19
RD
74/504
RD
74/504B
2
RD-GN
73/5075
2
2/31
1
3
11B/27
1
1
1
1
1
1
1
2
R7
11A/1
2
2
11A/2
11A/4
2
11A/5
2
11A/3
2
5
2
11B/17
1
2
GY-BK
GN-VT
RD-BK
15/36
27
RD
MAN
RD
4
74/301
RD
73/3162
AUTO
RD
74/316
1/2
12V
73/3137
73/3136
BK
PF1
31/131
PF1
2
1
M11
2
2/246
R2
2
5
2
F10
2/166
R1
2
11A/9
RD
YE-RD
1
74/411
9/42C2:1
YE-RD
YE-RD
RD-GY
RD-BN
73/4028
YE-RD
4/31C1:4
RD-GN
RD
RD
RD
6/28:2
2/193
R4
5
2
2/88
R1
5
1
12
12
12
12
11C/24
11C/23
11C/25
11C/28
3
1
3
2
RD
BU
2
1
3
1
1
5
2
11B/12
1
3
1
2 1
2 1
2 1
2 1
2 1
2 1
2 1
1
2
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
11A/7
11A/8
C34W062
31/3
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 11
Electrical distribution
Overview, Distribution box in engine compartment, exc. 4-Cyl. 2.0L
15/31
STOSTA
73/3068
4 CYL D & I5T STOSTA
73/3160
RD-BU
4 CYL D & I5T STOSTA
5 CYL D STOSTA
4 CYL D & I5T STOSTA
4/46B:16
73/3085
4-Cyl. & I5T
RD-BU
STOSTA
74/316
2
5CYL D.
RD
RD-BU 1.6P
6 CYL
RD-VT
A
RD-BK
1.6P & MAN
AUTO
RD-BU
RD
RD-BU
RD
GY-VT
RD
GY-VT
GY-VT
BU-OG
GY-VT
RD
RD
RD
RD
RD
RD
RD
5CYL D.
BU-OG
21
5
3
1
2
5
2
21
21
21
21
21
21
21
21
21
21
21
21
21
21
5
2
2/32
3
1
3
1
11B/34
2/35
R12
11B/35
11B/39
11B/40
11B/41
11B/38
11B/37
11B/36
2/14
11A/44
11A/42
11A/43
11B/30
11B/31
11B/32
11B/33
2/22
R13
R10
R11
2/17
11B/29
11B/28
11B/27
11B/17
11B/16
11B/18
11B/19
1
1B/21
1
1B/20
1
1B/22
11B/23
11B/15
2/31
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
2/182
11B/14
11B/13
11B/11
11B/9
11B/12
11B/10
11B/8
3
R8
1
12
12
12
12
12
12
12
12
12
12
12
12
3
R7
1
11A/7
12
12
12
12
12
12
12
3
R9
1
12
12
12
12
12
12
12
5
2
5
2
5
2
C3:2
GY-BK
RD
RD
GN-VT
RD
RD
RD
RD-BK
RD-BU
RD-GN
RD-GY
RD-BN
RD
RD
RD
RD
RD
RD-VT
RD
4/56C1:63
RD
RD
4/56C1:13
9/42
4/56C5:1
4/56C5:2
15/32
15/36
15/36
RD
RD
30+
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 12
C33W002
Electrical distribution
Overview, Distribution box in engine compartment, 4-Cyl. 2.0L
15/31
RD-WH
1 2
11B/30
11B/31
11B/32
11B/33
11B/34
11B/35
11B/36
11B/37
11B/38
11B/39
11B/40
11B/41
11B/42
11B/43
11B/44
2/32
R10
1 2
1 2
1 2
1 2
1 2
12
12
12
12
12
12
12
12
12
5
3
1
2
RD AUTO
RD
4 CYL.D
GY
GY-VT
GY-VT
GY-VT
VT-RD
RD
YE-BU
73/3068
WH-BN 4 CYL.D
73/3085
RD-WH 4 CYL.D
2/22
R13
2/35
R12
2/14
R11
5
3
1
2
WH-BN
4 CYL.D
53/7011
5
3
1
2
5
3
1
2
WH-BN 4 CYL.D
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 13
C33W003
Electrical distribution
Overview, Distribution box in passenger compartment
15/36
15/31
15/37
30+
1
1
1
1
11A/5
11A/4
11A/3
11A/4
R2
R3
2/88
2/193
11C/1
11C/2
11C/3
11C/4
11C/5
11C/6
11C/7
11C/8
11C/9
11C/10
11C/11
11C/12
11C/13
11C/14
11C/15
R1
R4
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
2
2
2
2
RD-GY
RD-BN
RD-GY
RD-BN
STOSTA
STOSTA
4
5
3
2
1
4
5
3
2
1
3
5
1
2
5
3
1
2
RD
73/5117
15E
RSHEAT
RD
RD
RD
RD
11C/17
11C/18
11C/19
11C/16
11C/20
11C/21
11C/22
11C/23
11C/24
11C/25
11C/26
11C/27
11C/28
11C/29
11C/30
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
C33W004
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 14
Electrical distribution
Overview, Distribution box in cargo compartment
3
30+
15/31
15/31
12
15/37
12
11A/3
11A/5
2
RD-GN
74/504B
2
15/32
STOSTA
RD-GN
RD-GN
2
RD-GN
RD-VT
RD-GN
21
21
21
21
21
21
11D/A1
11D/A2
11D/A3
11D/A4
11D/A5
11D/A6
73/5075
RD-GN
21
21
4
3
1
2
11D/A11
11D/A12
2/16
RA2
RD-VT
4
5
2
2/82
RA1
3
1
A
C33W005
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 15
Fuses
Distribution box in engine compartment F1-F7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 4/56 Central Electronic Module (CEM)
F7 Fuse in the Central Electronic Module (CEM)
F9-F11 Fuses in the Central Electronic Module (CEM)
F23 Fuse in the Central Electronic Module (CEM)
F2 11A/2 4/56 Central Electronic Module (CEM)
F3-F6 Fuses in the Central Electronic Module (CEM)
F8 Fuse in the Central Electronic Module (CEM)
F12-F16 Fuses in the Central Electronic Module (CEM)
F22 Fuse in the Central Electronic Module (CEM)
F24 Fuse in the Central Electronic Module (CEM)
F3 11A/3 11D/A1-11D/A11 Fuses in distribution box cargo compartment - 60
F4 11A/4 2/193 Relay, comfort functions
4/56 Central Electronic Module (CEM)
11C/1-11C/15 Fuses in distribution box passenger compartment
11C/21-11C/22 Fuses in distribution box passenger compartment
F5 11A/5 2/88 Relay, 15-feed
4/56 Central Electronic Module (CEM)
11C/23-11C/25 Fuses in distribution box passenger compartment
11C/26-11C/30 Fuses in distribution box passenger compartment
F7 11A/7 9/42 PTC-element - 100
continues
-
-
relay in CEM
-
relay in CEM
relay in CEM
-
-
-
-
2/193
-
2/193
-
2/88
2/88
2/88
50
50
60
60
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 16
Fuses
Distribution box in engine compartment F8-F21
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F8 11B/8 9/7 Heated windshield 2/81A 40
F9 11B/9 6/1 Wiper Motor Module (WMM) - 30
F10 11B/10 4/7 Combustion Preheater Module (CPM)
4/106 Control module, remote parking heater start
F11 11B/11 4/31 Passenger compartment fan control module
6/28 Motor, passenger compartment fan
F12 11B/12 2/81B Relay, heated windshield, driver's side
9/7 Heated windshield
F13 11B/13 4/16 Brake Control Module (BCM), pump - 40
F14 11B/14 4/16 Brake Control Module (BCM), valves - 20
F15 11B/15 6/104 Washer motor headlights 2/182 20
F16 11B/16 10/1 Lamp housing, front left
10/2 Lamp housing, front right
F17 11B/17 4/56 Central Electronic Module (CEM)
F17-F20 Fuses in the Central Electronic Module (CEM)
F18 11B/18 4/16 Brake Control Module (BCM) - 5
F19 11B/19 4/99 Speed dependent power steering control module
6/163 Electric power steering module (EPAS)
6/164 Electrohydraulic power steering module (EHPAS)
F20 11B/20 4/28 Transmission Control Module (TCM), AWF21
4/28 Transmission Control Module (TCM), AWF22
4/28B Transmission Control Module (TCM) MPS6
4/46 Engine Control Module (ECM)
4/9 Supplemental restraint system module (SRS)
F21 11B/21 9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
continues
-
-
-
-
2/81A
2/81B
-
-
-
-
-
-
-
-
-
-
-
-
-
-
25
40
40
10
20
5
10
10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 17
Fuses
Distribution box in engine compartment F22-F31
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F22 11B/22 - --
F23 11B/23 3/111 Light Switch Module (LSM) - 5
F27 11B/27 2/17 Relay, horn
2/31 Relay, 15-feed
2/81A Relay, heated windshield, passenger side
2/182 Relay, headlight washer motor
4/56 Central Electronic Module (CEM)
6/104 Washer motor headlights -
F28 11B/28 2/64 Relay, auxiliary lights
4/56 Central Electronic Module
10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
F29 11B/29 2/17 Relay, horn
16/10 Horn 1
16/11 Horn 2
F30 11B/30 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
F31 11B/31 4/28 Transmission Control Module (TCM) - 15
continues
-
-
-
-
2/17, 2/31,
2/182,
2/81A
2/64
2/64
2/64
2/17
2/17
-
-
5
20
15
10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 18
Fuses
Distribution box in engine compartment F32-F37
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F32 11B/32 8/3 Electromagnetic clutch, climate control system
6/73 Coolant pump, Start/Stop, 4-Cyl. 2.0L Diesel
F33 11B/33 2/14 Relay, glow plug system
2/22 Relay, climate control system
4/46 Engine Control Module (ECM)
F34 11B/34 2/35 Relay, starter motor
6/25 Starter motor
F35 11B/35 4/109 Control module glow plug, 5-Cyl. Diesel
20/3-6 Spark plug with ignition coil, 4-Cyl.
4/46 Engine Control Module (ECM), 4-Cyl. 2.0L Diesel
20/3-8 Spark plug with ignition coil, 5- & 6-Cyl.
20/16 Capacitor 6-Cyl.
F36 11B/36 4/46 Engine Control Module (ECM), 4-, 5-, 6-Cyl. - 10
4/46 Engine Control Module (ECM), 4-Cyl. 2.0L Diesel - 20
4/46 Engine Control Module (ECM), 5-Cyl. Diesel - 15
F37 11B/37 7/17 Mass airflow sensor (MAF), 4-Cyl. Turbo
8/111 Control valve fuel flow, 4-Cyl. 1.6L Diesel
8/121 Radiator valve, 4-Cyl. Turbo
8/167 Bypass solenoid, 4-Cyl. Turbo
6/197 Bypass solenoid, 4-Cyl. 2.0L Diesel
7/17 Mass airflow sensor (MAF), 4-Cyl. 2.0L Diesel
8/197 Radiator valve, 4-Cyl. 2.0L Diesel
8/6-10 Injection valves, 5-Cyl. Turbo
8/98 Control valve fuel pressure, 5-Cyl. Diesel
8/111 Control valve fuel flow, 5-Cyl. Diesel
7/17 Mass airflow sensor (MAF), 5-Cyl.Diesel
4/46 Engine Control Module (ECM), 6-Cyl.
8/6-11 Injection valves, 6-Cyl.
7/17 Mass airflow sensor (MAF), 6-Cyl.
continues
2/22
2/14
-
2/22
2/35
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
5
30
10
20
10
10
15
15
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 19
Fuses
Distribution box in engine compartment F38
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 8/18 EVAP valve, 4-Cyl. 1.6L
8/28 Turbocharger control valve, 4-Cyl. 1.6L
8/19 Solenoid, variable valve timing, intake, 4-Cyl. 1.6L Turbo
8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. 1.6L Turbo
8/159 Bypass valve, 4-Cyl. 1.6L Turbo
7/17 Mass air flow sensor MAF, 5-Cyl. Turbo
7/35 Oil level sensor, 5-Cyl. Turbo
8/3 Electromagnetic clutch climate control system, 5-Cyl. Turbo
8/28 Turbocharger control valve, 5-Cyl. Turbo
8/81 Solenoid, variable valve timing, exhaust, 5-Cyl. Turbo
8/117 Solenoid, variable valve timing, intake, 5-Cyl. Turbo
8/159 Bypass valve, 5-Cyl. Turbo
7/35 Oil level sensor, 5-Cyl. Diesel
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel
8/28 Turbo control valve, 5-Cyl. Diesel
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel
8/157 Turbocharger control valve, 5-Cyl. Diesel
8/164 Electric piston cooling valve, 5-Cyl. Diesel
4/46 Engine Control Module (ECM), 6-Cyl.
6/139 Upper actuator motor, intake manifold, 6-Cyl.
6/140 Lower actuator motor, intake manifold, 6-Cyl.
8/3 Electromagnetic clutch, climate control system, 6-Cyl.
8/28 Turbo control valve, 6-Cyl.
8/68 Relief valve, 6-Cyl. Turbo
8/117 Solenoid, variable valve timing, intake, 6-Cyl.
8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo
8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo
11B/ 38 continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 20
Fuses
Distribution box in engine compartment F38-F39
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 7/82 Rear oxygen sensor, 4-Cyl. 2.0L Turbo
8/117 Solenoid, variable valve timing, intake, 4-Cyl. 2.0L Turbo
8/118 Solenoid, variable valve timing, exhaust, 4-Cyl. 2.0L Turbo
8/159A Bypass valve, 4-Cyl. 2.0L Turbo
8/180 Engine oil pump solenoid, 4-Cyl. 2.0L Turbo
8/200 Vacuum regulator, turbo wastegate control, 4-Cyl. 2.0L Turbo
7/82 Rear oxygen sensor, 4-Cyl. 2.0L Diesel
8/113 Bypass valve, EGR cooling, 4-Cyl. 2.0L Diesel
8/199 Vacuum regulator, turbo bypass control, 4-Cyl. 2.0L Diesel
8/200 Vacuum regulator, turbo wastegate control, 4-Cyl. 2.0L Diesel
F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. 1.6L Turbo
7/82 Rear heated oxygen sensor, 4-Cyl. 1.6L Turbo
7/15 Front heated oxygen sensor, 5-Cyl. Diesel -
7/15 Front heated oxygen sensor, 4-Cyl. 2.0L Turbo
7/104 Rear oxygen sensor, 4-Cyl. 2.0L Turbo
7/15 Front heated oxygen sensor, 5-Cyl. Turbo
7/215 Rear heated oxygen sensor, 5-Cyl. Turbo
8/18 EVAP valve, 5-Cyl. Turbo
7/15 Front oxygen sensor, bank 1, 6-Cyl.
7/82 Rear oxygen sensor, bank 1, 6-Cyl.
7/104 Rear heated oxygen sensor bank 2, 6-Cyl. 3.2L
8/18 EVAP valve, 6-Cyl.
continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
10
15
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 21
Fuses
Distribution box in engine compartment F40-F44
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F40 11B/40 6/73 Coolant pump, Start/Stop, 5-Cyl. Turbo
6/179 Electric oil pump
9/32 PTC resistor crankcase ventilation, 5-Cyl. Turbo
9/38 Heated fuel filter, Diesel
20/3-6 Spark plug and ignition coil, 4-Cyl. 2.0L Turbo - 15
6/73 Coolant pump, Start/Stop, 4-Cyl. Turbo 2/14 10
F41 11B/41 6/67 Pump fuel leakage control 6-Cyl.
6/179 Electric oil pump
7/200 Sensor, coolant temperature
9/32 PTC-resistor, crankcase ventilation 5 Cyl. Diesel
4/109 Glow plug control module, 4-Cyl. 2.0L Diesel
8/3 Electromagnetic clutch, climate control system, 4-Cyl. 2.0L Diesel
8/180 Engine oil pump solenoid, 4-Cyl. 2.0L Diesel
F42 11A/42 4/109 Glow plug control module - 70
6/113 Coolant water pump, 4-Cyl. 2.0L - 50
F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo - 60
4/71 Cooling fan control module, 4-Cyl. Diesel, 5-Cyl. Diesel, 6-Cyl. - 80
F44 11A/44 6/163 Electric power steering module (EPAS)
6/164 Electrohydraulic power steering module (EHPAS)
2/32
-
-
-
-
-
-
-
-
-
-
-
-
20
5/10
15
100
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 22
Fuses
Central electronic module (CEM) F1-F3
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 2/16 Relay, rear window wiper
6/32 Rear window wiper motor
F3 3/27 Switch unit, power passenger seat
3/176 Power window switches, driver’s door
3/291 Tailgate closing switch, V70
4/52 Power Seat Module (PSM)
10/25 Ceiling light, cargo compartment, V70
10/29 Glove compartment lighting
10/97 Left-hand front courtesy lighting
10/102 Right-hand front courtesy lighting
10/122 Left-hand rear courtesy lighting
10/123 Right-hand rear courtesy lighting
10/127 Lighting, cargo compartment, left-hand side, S80
10/128 Lighting, cargo compartment, right-hand side, S80
10/261 Ground illumination lighting, driver’s side
10/294 Ground illumination lighting, left rear
10/295 Ground illumination lighting, right rear
17/45 Alcolock outlet
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle
continues
-
2/16
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
7.5
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 23
Fuses
Central electronic module (CEM) F4-F14
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F4 5/1 Driver Information Module (DIM) - 5
F5 4/80 Forward Sensing Module (FSM)
7/203 Forward-aimed radar (FLR)
19/4 Analog clock
F6 4/76 Remote control unit for garage door opener
7/149 Rain Sensor Module (RSM)
10/22 Ceiling light
10/114 Left-hand front vanity mirror lighting
10/115 Right-hand front vanity mirror lighting
10/150 Rear reading light
F7 3/4 Steering wheel switch left (SWSL)
3/130 Steering Wheel Module (SWM)
3/131 Steering wheel switch right (SWSR)
F8 6/37 Lock motor, fuel filler cover - 10
F9 4/148 Heated Steering Wheel Module (HSWM)
6/127 Washer motor
F10 6/127 Washer motor - 15
F11 6/8 Central locking motor, trunk lid - 10
F12 6/141 Motor folding head restraint left
6/142 Motor folding head restraint right
8/59 Rear left head restraint solenoid
8/60 Rear right head restraint solenoid
F13 4/83 Fuel pump control module
6/33 Fuel pump
F14 3/112 Climate Control Module (CCM) - 5
continues
-
-
-
-
-
-
-
-
-
3/130
-
3/130
-
-
-
-
-
-
relay in CEM
relay in CEM
10
7.5
7.5
15
10
20
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 24
Fuses
Central electronic module (CEM) F15-F24
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F15 4/102 Steering Column Lock Module (SCL) relay in
CEM
F16 16/35 Siren Control Module (SCM)
17/13 Data link connector
F18 4/9 Supplemental restraint system module (SRS)
7/93 Occupant Weight Sensor (OWS)
F19 4/80 Forward Sensing Module (FSM)
4/125 Closing velocity module (CVM)
7/203 Forward-aimed radar (FLR)
F20 3/65 Switch, heated rear seat
7/51 Accelerator pedal sensor
8/48 Auto-dimming rearview mirror
9/42 PTC-element
F21 3/281 Infotainment Control Module (ICM)
4/124 Accessory USB unit (AUU)
16/1 Integrated Audio Module (IAM)
F22 3/9 Contact brake light - 5
F23 4/33 Sunroof Module (SRM) - 20
F24 3/1 Ignition switch
16/65 Immobilizer antenna unit (IAU)
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
5
10
5
7.5
15
5
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 25
Fuses
Passenger compartment
11 Fuse in extra fuse holder, passenger compartment
No. Fuse function via A
1 19/4 Analog clock - 5
I05166
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 26
Fuses
Distribution box in passenger compartment F1-F17
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F1 11C/1 11C/16-20 Fuses in distribution box passenger compartment
16/105 Audio module (AUD)
F4 11C/4 2/249 Relay heated steering wheel
4/148 Heated Steering Wheel Module (HSWM)
F7 11C/7 17/19 12 V outlet, cargo compartment - 15
F8 11C/8 3/126 Driver Door Module (DDM) - 20
F9 11C/9 3/127 Passenger Door Module (PDM) - 20
F10 11C/10 3/129 Right rear door module (RDM) - 20
F11 11C/11 3/128 Left rear door module (LDM) - 20
F12 11C/12 4/93 Keyless Vehicle Module (KVM) - 20
F13 11C/13 4/52 Power Seat Module (PSM) - 20
F14 11C/14 3/27 Switch unit, power passenger seat - 20
F15 11C/15 Spare --
F16 11C/16 3/281 Infotainment Control Module (ICM)
4/156 Accessory Connectivity Unit (ACU)
F17 11C/17 16/36 TV receiver
16/105 Audio module (AUD)
16/145 Remote Digital Audio Receiver (RDAR)
16/162 Digital Audio Broadcast Module (DABM)
continues
-
-
-
2/249
-
-
-
-
-
-
40
5
10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 27
Fuses
Distribution box in passenger compartment F18-F24
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F18 11C/18 3/281 Infotainment Control Module (ICM)
4/124 Accessory USB unit (AUU)
16/1 Integrated Audio Module (IAM)
16/159 Control module, cellular phone handsfree (accessory)
F19 11C/19 16/60 Phone Module (PHM) - 5
F20 11C/20 16/109 DVD Player/control module - 7,5
F21 11C/21 4/33 Sunroof Module (SRM)
6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), temperature, left side
6/96 Damper Motor Module (DMM), temperature, right side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/159 Air Quality Sensor (AQS)
F22 11C/22 9/1 Outlet 12V front
9/25 Outlet 12V rear
16/45 Portable navigation system
27/8 Camera, wide angle front
F23 11C/23 9/15 Control module, right rear seat heater
4/131 Control module back massage left
4/147 Rear Seat Module (RSX)
F24 11C/24 9/14 Control module, left rear seat heater
4/133 Control module back massage right
continues
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
5
15
15
15
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 28
Fuses
Distribution box in passenger compartment F25-F30
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F25 11C/25 2/141 Refrigeration box relay
4/131 Control module back massage left
4/133 Control module back massage right
F26 11C/26 9/13 Seat Heating Module (SHM), passenger side - 15
F27 11C/27 9/12 Seat Heating Module (SHM), driver’s side - 15
F28 11C/28 4/86 Parking Assistance Module (PAM)
4/110 Trailer Module (TRM)
4/120 Parking Assistance Camera module (PAC)
F29 11C/29 4/82 Differential Electronic Module (DEM) - 15
F30 11C/30 4/84 Suspension Module (SUM)
9/24 Refrigeration box
-
-
-
-
-
-
-1 0
15
5
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 29
Fuses
Distribution box in cargo compartment FA1-FA11
15/32 Distribution box in cargo compartment
No. No. Fuse function via A
FA1 11D/A1 4/115 Park Brake Module (PBM) - 30
FA2 11D/A2 4/115 Park Brake Module (PBM) - 30
FA3 11D/A3 2/82 Relay, heated rear window
4/56 Central Electronic Module (CEM)
9/2 Heated rear window, V70
16/141 Interference filter, rear window, left, S80
FA4 11D/A4 17/39 13-pin outlet, tow hitch cable harness - 15
FA5 11D/A5 4/116 Power Operated Tailgate Module (POT)
4/147 Rear Seat Module (RSX)
FA6 11D/A6 4/147 Rear Seat Module (RSX) - 20
FA11 11D/A11 4/110 Trailer Module (TRM)
17/19 12 V outlet, cargo compartment
-
2/82
2/82
2/82
-
-
-4 0
30
30
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 30
Fuses
Distribution box in engine compartment, cold zone F1-MF2
MF1
MF2
F10 F11 F12
R2
2/246
F6
I013222 15/37
D1 F9 R1
2/166
F1
F2 F3 F4 F5
15/37 Distribution box cold zone in engine compartment, Start/Stop function
No. No. Fuse function via A
F1 11A/1 9/42 PTC-element - 100
F2 11A/2 4/56 Central Electronic Module (CEM) - 50
F3 11A/3 2/88 Relay, 15-feed rear
11C/21-11C/22 Fuses in distribution box passenger compartment
F4 11A/4 2/193 Relay, comfort functions
11C/23-11C/30 Fuses in distribution box passenger compartment
F5 11A/5 15/32 Distribution box in cargo compartment - 60
F6 11A/6 4/31 Passenger compartment fan control module
6/28 Motor, passenger compartment fan
F7 11A/7 Spare --
F8 11A/8 Spare --
F9 11A/9 6/25 Starter motor 2/35 30
F10 11A/10 Diode D1 -5 0
F11 M11 Secondary battery 2/246 70
F12 11B/12 4/56 Central Electronic Module (CEM) - 15
MF1 MF1 11A/1-11A/8 Main fuses in distribution box in
engine compartment (15/31)
MF2 MF2 11A/1-11A/8 Fuses in distribution box in cold zone
engine compartment (15/37)
-
2/193
-
2/88
-
-
- 175
- 175
60
60
40
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 31
Fuses
Battery PF1-PF2
PF1
PF2
1/1 Battery
No. Fuse function via A
PF1 11A/1-11A/7 Fuses in the engine compartment distribution box
11B/8-11B/14 Fuses in the engine compartment distribution box
11B/16-11B/22 Fuses in the engine compartment distribution box
11B/23 Fuses in the engine compartment distribution box
11B/27-11B/32 Fuses in the engine compartment distribution box
11B/33 Fuses in the engine compartment distribution box
11B/34 Fuses in the engine compartment distribution box
11B/35-11B/41 Fuses in the engine compartment distribution box
11A/42-11A/44 Fuses in the engine compartment distribution box
15/37 Distribution box cold zone in engine compartment, Start/Stop
function
PF2 6/25 Starter motor
6/26 Alternator Control Module (ACM)
-
-
2/31
-
-
2/32
-
2/32
-
-
-
-
150
150
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 32
Relays
Relays in the engine compartment
15/31 Distribution box engine compartment
Pos Relay function
R7 2/31 Relay, 15-feed
R8 2/17 Relay, horn
R9 2/182 Relay, headlight washer motor
I019466 15/31
15/31 Distribution box engine compartment
Pos Relay function
R10 2/32 Main relay, engine management system
R11 2/14 Relay, diesel filter heater, 5-Cyl. Diesel
2/14 Relay, coolant pump, 4-Cyl. 1.6L Turbo MAN
R12 2/35 Relay, starter motor
R13 2/22 Relay, climate control system
1
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 33
Relays
Relays in the engine compartment
F10 F11 F12
R2
2/246
MF1
MF2
15/37 Distribution box engine compartment
Pos Relay function
R1 2/166 Battery relay
R2 2/246 Secondary battery relay
D1 F9 R1
2/166
R1
2
5
4
3
2/81A
F1
F2 F3 F4 F5
5
4
2 1
3
2/81B
F6
I013222 15/37
R2
1
15/46
15/46 Relay box engine compartment
Pos Relay function
R1 2/81A Relay, heated windshield passenger side
R2 2/81B Relay, heated windshield driver’s side
H01546A
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 34
Relays
Relays in passenger compartment
15/36 Distribution box in passenger compartment
Pos Relay function
R1 2/88 Relay, 15-feed
R2 2/249 Relay, heated steering wheel
R4 2/193 Relay, comfort functions
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 35
Relays
Relays in cargo compartment
Relay in extra holder cargo compartment
Relay function
2/141 Refrigeration box relay
15/32 Distribution box in cargo compartment
Pos Relay function
RA1 2/82 Relay, heated rear window
RA2 2/16 Relay, rear window wiper
2/64 Relay, auxiliary lights
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 36
Ground connections
Overview
31/95
31/3
31/2
31/4
31/
XX14
31/
XX10
31/XX4
31/131
RHD
31/89
31/88
31/90
31/AL
31/131
LHD
31/96
31/1
31/83
31/65
31/66
31/115
31/7
31/84
31/68
31/47
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 37
31/107
31/
INFOT
31/48
C32G001
Ground connections
31/1 - 31/6
31/1 Ground connection, PTC
9/42 PTC-Element
31/2 Left wheel housing
4/71 Cooling fan control module
31/3 Body, battery
1/1 Battery
7/240 Battery monitoring sensor (BMS)
31/4 Engine
31/XX4 Ground connection
31/6 Bottom rail, left
3/27 Switch unit, power passenger seat, RHD
3/74 Left-hand front door lock unit
3/76 Lock unit, rear left door
3/126 Driver Door Module (DDM), LHD
3/127 Passenger Door Module (PDM), RHD
3/128 Left rear door module (LDM)
3/176 Switch, driver’s door power window, LHD
3/273 Lock contact, left front door
3/275 Lock contact, left rear door
4/52 Power Seat Module (PSM), LHD
9/12 Seat Heating Module (SHM), driver’s side, LHD
9/13 Seat Heating Module (SHM), passenger side, RHD
10/72 Front ashtray lighting, LHD
10/161 Lighting, mug holder, LHD
10/286 Lighting, floor driver’s side, LHD
10/287 Lighting, floor passenger side, LHD
16/1 Integrated Audio Module (IAM), RHD
16/159 Control module, cellular phone handsfree, RHD
19/4 Analog clock, LHD
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 38
Ground connections
31/7 - 31/10
31/7 Bottom rail, left
3/271 Contact, immobilizer, clutch pedal, LHD
3/284 Diagnostic contact, brake light, LHD
3/281 Infotainment Control Module (ICM), RHD
4/56 Central Electronic Module (CEM), RHD
4/156 Accessory Connectivity Unit (ACU), RHD
7/51 Accelerator pedal sensor, LHD
7/93 Occupant Weight Sensor (OWS), RHD
7/175 Occupant weight sensor, seat belt reminder, RHD
8/51 Igniter side airbag front driver’s seat, LHD
8/52 Igniter side airbag front passenger seat, RHD
9/13 Seat Heating Module (SHM), passenger side, RHD
16/1 Integrated Audio Module (IAM), RHD
16/36 Television module (TVM), RHD
16/109 DVD player/control module. RHD
16/123 Auxiliary equipment input (AUX), LHD
16/145 Remote Digital Audio Receiver (RDAR), RHD
16/162 Digital Audio Broadcast Module (DABM), RHD
31/10 Bottom rail, left
3/6 Switch, hazard warning flashers
3/173 Switch, trunk lid/tailgate private lock
4/31 Passenger compartment fan control module
4/33 Sunroof control module
4/80 Forward Sensing Module (FSM)
4/102 Steering Column Lock Module (SCL)
4/119 Remote Keyless Entry (RKE)
4/119.2 Remote Receiver Module (RRX)
4/125 Closing velocity module (CVM)
6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), temperature, left side
6/96 Damper Motor Module (DMM), temperature, right side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/149 Rain Sensor Module (RSM)
7/159 Air Quality Sensor (AQS)
7/199 Ultrasonic sensor
8/48 Auto-dimming rearview mirror
10/22 Ceiling light
10/29 Glove compartment lighting
Continues
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 39
Ground connections
31/10 - 31/15
31/10 Bottom rail, left (continued)
10/114 Left-hand front vanity mirror lighting
10/115 Right-hand front vanity mirror lighting
17/13 Data link connector
17/45 Alcolock outlet
26/8 Alcolock charging cradle
31/15 Bottom rail, right
3/27 Switch unit, power passenger seat, LHD
3/65 Switch, heated rear seat, RHD
3/75 Right-hand front door lock unit
3/77 Lock unit, rear right door
3/126 Driver Door Module (DDM), RHD
3/127 Passenger Door Module (PDM), LHD
3/129 Right rear door module (RDM)
3/156 Gear Selector Module (GSM), RHD
3/176 Switch, driver’s door power window, RHD
3/274 Lock contact, right front door
3/276 Lock contact, right rear door
4/52 Power Seat Module (PSM), RHD
8/134 Solenoid, reverse interlock, manual
9/1 Front 12 V outlet
9/12 Seat Heating Module (SHM), driver’s side, RHD
9/13 Seat Heating Module (SHM), passenger side, LHD
9/25 Rear 12 V outlet, RHD
10/72 Front ashtray lighting, RHD
10/161 Lighting, mug holder, RHD
10/286 Lighting floor driver’s side, RHD
10/287 Lighting floor passenger side, RHD
16/45 Navigation system portable, RHD
19/4 Analog clock, RHD
27/8 Camera, wide angle front
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 40
Ground connections
31/47 - 31/65
31/47 Rear bumper abutment, left
2/16 Rear window wiper relay, V70
3/35 Switch, handle, trunk lid/tailgate
4/110 Trailer Module (TRM), S80
4/115 Park Brake Module (PBM)
4/116 Power Operated Tailgate Module (POT), V70
6/8 Lock unit, trunk lid/tailgate
6/32 Rear window wiper motor, V70
6/149 Tailgate closing motor, V70
9/2 Heated rear window, V70
10/3 License plate lighting
10/17 Lamp housing, rear right V70
10/18 Lamp housing, rear left
10/19 Auxiliary brake light V70
31/48 Rear bumper abutment, right
2/141 Refrigeration box relay
4/93 Keyless Vehicle Module (KVM)
6/37 Lock motor, fuel filler cover
9/24 Refrigeration box
17/19 12V outlet, cargo compartment
31/65 Rear seat riser, left-hand side 1
3/35 Switch, handle, trunk lid/tailgate
4/82 Differential Electronic Module (DEM)
4/110 Trailer Module (TRM), V70
6/8 Lock unit, trunk lid/tailgate
6/141 Motor folding head restraint left
8/59 Rear left head restraint solenoid, S80
9/14 Control module, rear left seat heater
10/3 License plate lighting
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 41
Ground connections
31/66 - 31/83
31/66 Rear seat riser, left-hand side 2
4/83 Fuel pump control module
6/33 Fuel pump
31/67 Rear seat riser, right side 1
4/84 Suspension Module (SUM)
4/86 Parking Assistance Module (PAM)
6/142 Motor folding head restraint right
8/60 Rear right head restraint solenoid, S80
9/15 Control module, rear right seat heater
31/68 Rear seat riser, right side 2
6/35 Fuel pump, auxiliary heater
9/38 Electrically heated fuel filter
31/83 Bottom rail, left
3/111 Light Switch Module (LSM)
3/112 Climate Control Module (CCM)
3/130 Steering Wheel Module (SWM)
3/131 Steering wheel switch right (SWSR)
3/272 Parking brake contact
3/281 Infotainment Control Module (ICM)
4/124 Accessory USB unit (AUU)
4/148 Heated Steering Wheel Module (HSWM)
5/1 Driver Information Module (DIM)
9/42 PTC-element
16/60 Phone Module (PHM)
16/65 Immobilizer Antenna Unit (IAU)
17/13 Data link connector
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 42
Ground connections
31/84 - 31/90
31/84 Bottom rail, right
3/271 Contact, immobilizer, clutch pedal, RHD
3/281 Infotainment control module (ICM), LHD
3/284 Diagnostic contact, brake light, RHD
4/56 Central Electronic Module (CEM), LHD
4/156 Accessory Connectivity Unit (ACU), LHD
7/51 Accelerator pedal sensor, RHD
7/93 Occupant Weight Sensor (OWS), LHD
7/175 Weight sensor passenger seat, seat belt reminder, LHD
8/51 Igniter side airbag front driver’s seat, RHD
9/13 Seat Heating Module (SHM), passenger side, LHD
16/1 Integrated Audio Module (IAM), LHD
16/36 Television module (TVM), LHD
16/109 DVD player/control module, LHD
16/123 Auxiliary equipment input (AUX), LHD
16/145 Remote Digital Audio Receiver (RDAR), LHD
16/162 Digital Audio Broadcast Module (DABM), LHD
31/88 Engine ignition coils
20/3 Spark plug with ignition coil, 4-Cyl. Turbo
Spark plug with ignition coil, 5-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl.
20/4 Spark plug with ignition coil, 4-Cyl. Turbo
Spark plug with ignition coil, 5-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl.
20/5 Spark plug with ignition coil, 4-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl. Turbo
20/6 Spark plug with ignition coil, 4-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl. Turbo
31/89 Engine ignition coils
20/5 Spark plug with ignition coil, 5-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl.
20/6 Spark plug with ignition coil, 5-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl.
20/7 Spark plug with ignition coil, 5-Cyl. Turbo
Spark plug with ignition coil, 6-Cyl.
Spark plug with ignition coil, 6-Cyl. Turbo
20/8 Spark plug with ignition coil, 6-Cyl.
Spark plug with ignition coil, 6-Cyl. Turbo
20/16 Capacitor, 6-Cyl.
31/90 Engine ignition coils
20/3 Spark plug with ignition coil, 6-Cyl. Turbo
20/4 Spark plug with ignition coil, 6-Cyl. Turbo
20/16 Capacitor, 6-Cyl. Turbo
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 43
Ground connections
31/93 - 31/XX4
31/93 Left wheel housing 2
4/99 Speed dependent power steering control module
6/1 Wiper Motor Module (WMM)
6/104 Washer motor headlights
7/4 Brake fluid level sensor
7/5 Washer fluid level sensor
9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
10/1 Lamp housing, front left
16/35 Siren Control Module (SCM)
31/94 Right wheel housing 2
4/7 Combustion Preheater Module (CPM)
4/106 Control module, remote parking heater start
10/2 Lamp housing, front right
16/10 Horn 1
16/11 Horn 2
31/95 Left wheel housing 3
4/56 Central Electronic Module (CEM), RHD
6/163 Electric power steering module (EPAS)
6/164 Electrohydraulic power steering module (EHPAS)
31/96 Right wheel housing 3
3/62 Hood alarm contact
4/56 Central Electronic Module (CEM), LHD
7/73 Coolant level sensor
7/203 Forward-aimed radar (FLR)
15/46 Relay box in engine compartment
31/107 Roof, rear
4/120 Parking Assistance Camera module (PAC)
31/115 Roof, left, A-Pillar
9/7 Heated windshield
31/131 Start/stop function
1/2 Secondary battery
9/42 PTC-Element
31/XX4 Engine - Body
31/4 Ground connection
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 44
Ground connections
31/XX10 - 31/AL
31/XX10 Left wheel housing 1
3/10 Reversing light contact
3/282 Switch indicator 1st gear, I5D
4/28 Transmission Control Module (TCM), AWF21 & AWF22
4/28B Transmission Control Module (TCM), MPS6
4/46 Engine Control Module (ECM)
4/109 Glow plug control module
6/73 Coolant pump
6/139 Upper actuating motor, intake manifold
6/140 Lower actuating motor, intake manifold
6/179 Electric oil pump
7/200 Sensor, coolant temperature
7/243 Gear position sensor neutral position
8/3 Electromagnetic clutch, climate control system, 4-Cyl.
8/78 Pressure monitor power steering, 4-Cyl. Turbo
9/32 PTC resistor, crankcase ventilation
9/38 Electrically heated fuel filter, 4-Cyl. Diesel
20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo
31/XX14 Left wheel housing 3 (ABS)
4/16 Brake Control Module (BCM)
31/TRM Accessories
2/141 Refrigeration box relay
3/65 Switch, heated rear seat
3/104 Switch, sun curtain rear
3/324 Switch, rear seat adjustment, left-hand side
3/325 Switch, rear seat adjustment, right-hand side
3/299 Switch, passenger seat adjustment, rear seat
3/330 Switch, rear seat massage and ventilation, left
3/331 Switch, rear seat massage and ventilation, right
4/131 Control module back massage left
4/110 Trailer Module (TRM), Accessory
4/133 Control module back massage right
4/147 Rear Seat Module (RSX)
9/24 Refrigeration box
17/19 12 V outlet, cargo compartment
10/288 Lighting, overhead console
17/37 4-pin outlet, tow hitch cable harness
17/38 7-pin outlet, tow hitch cable harness
17/39 13-pin outlet, tow hitch cable harness
31/INFOT Infotainment
16/1 Integrated Audio Module (IAM), LHD
16/105 Audio module (AUD)
16/159 Control module, cellular phone handsfree, LHD
31/AL Auxiliary lights
10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 45
Control modules
Overview locations
RKE
EFCM
RRX
C33C001
SCU
ACU
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 46
Control modules
Overview designations
Unit Designation Unit Designation
ACM 6/26 Alternator Control Module (ACM) PBM 4/115 Park Brake Module (PBM)
AQS 7/159 Air Quality Sensor (AQS) PDM 3/127 Passenger Door Module (PDM)
AUD 16/105 Audio module (AUD) PHM 16/60 Phone Module (PHM)
BCM 4/16 Brake Control Module (BCM) PSM 4/52 Power Seat Module (PSM)
CCM 3/112 Climate control module (CCM) RCM 27/4 Right Camera Module (RCM)
CEM 4/56 Central Electronic Module (CEM) RDAR 16/145 Remote Digital Audio Receiver
(RDAR)
CPM 4/7 Combustion Preheater Module
(CPM)
CVM 4/125 Closing velocity module (CVM) RKE 4/119 Remote Keyless Entry (RKE)
DABM 16/162 Digital Audio Broadcast Module
(DABM)
DDM 3/126 Driver Door Module (DDM) RSM 7/149 Rain Sensor Module (RSM)
DEM 4/82 Differential Electronic Module (DEM) SAS 4/68 Steering Wheel Angle Sensor
DIM 5/1 Driver Information Module (DIM) SCL 4/102 Steering Column Lock Module (SCL)
DMM Damper Motor Module (DMM) SCM 16/35 Siren Control Module (SCM)
ECM 4/46 Engine Control Module (ECM) SHM 9/12 Seat Heating Module (SHM) driver’s
EFCM 4/71 Cooling fan control module 9/13 Seat Heating Module (SHM) passen-
FLR 7/203 Forward-aimed radar (FLR) SRM 4/33 Sunroof control module
FSM 4/80 Forward Sensing Module (FSM) SRS 4/9 Supplemental restraint system
GSM 3/156 Gear Selector Module (GSM) SUM 4/84 Suspension Module (SUM)
IAM 16/1 Integrated Audio Module (IAM) SWM 3/130 Steering Wheel Module (SWM)
ICM 3/281 Infotainment Control Module (ICM) TCM 4/28 Transmission Control Module (TCM)
KVM 4/93 Keyless Vehicle Module (KVM) TRM 4/110 Trailer Module (TRM)
LCM 27/3 Left Camera Module (LCM) WMM 6/1 Wiper Motor Module (WMM)
LDM 3/128 Left rear door module (LDM) 4/31 4/31 Passenger compartment fan control
LSM 3/111 Light Switch Module (LSM) 4/33
OWS 7/93 Occupant Weight Sensor (OWS) 4/71 4/71 Cooling fan control module
PAM 4/86 Parking Assistance Module (PAM) 17/13 17/13 Data link connector
RDM 3/129 Right rear door module (RDM)
RRX 4/119.2 Remote Receiver Module (RRX)
Module (SAS)
side
ger side
module (SRS)
module
4/33 Sunroof control module
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 47
Control modules
Central Electronic Module (CEM) 1:3
1
11A/2
2
30+
1
11A/1
2
15+
15/31
1
11B/17
2
GY-BK
RD-BU
RD-BK
C5:1
4/56
CEM
CAN
LIN
F7
2
1
F23
2
1
F9
2
1
F10
2
1
F21
1
C3:61
GN-WH
C3:75
RD-BN
C1:65
VT-GN
C1:76
GY
C3:65
2
GY-YE
3/130C1:8, 3/4:1
4/33:1
6/127:2, 4/148:1
6/127:1
16/1C2:1,4/124C1:1
3/281C1:1
C1:48
C1:10
C4:6
C2:43
C4:9
C2:11
C2:5
C2:43
C4:6
C2:46
YE-BU
BU-BK
GY-BN
GY-BN
VT
GN-VT
BU
GY-BN
GY-BN
GY-BK
6/1:1,6/1:4
2/182:2
4/119:2
4/93C4:14
7/199:2
6/36:4
15/36
4/93C4:14
4/119:2
10/294:2,10/295:2,
10/262:2,10/261:2
BN
C2:18
C3:44
C1:2
GY-BN
BK-RD
10/122:2,10/123:2
4/119.2:2
2/81A
A B
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 48
C34W001
Control modules
Central Electronic Module (CEM) 2:3
GY-BK
A B
RD-BU
C5:2
4/56
CEM
CAN
LIN
F1
1
F3
1
F4
1
F5
1
F6
1
C2:64
2
2
2
2
2
C2:70
C3:56
C3:62
C3:63
C4:18
RD-GY
BU-WH
BU-WH
RD-WH
GY-VT
BU-WH
2/16:1, 2/16:5,6/32:1
10/127:2, 10/128:2,3/27,10/261:1,
3/176:1, 4/52,3/291:5,10/25:4,10/294:1
10/122:1,10/123:1
10/29:1,10/102:1,26/6:1,26/7:1,17/45
5/1:3
4/80C1:8, 7/203:1,19/4:4
7/149:1,
10/22C1:4, 10/114:1, 10/115:1,
10/22C1:6,10/150A:2,10/150A:1
F8
2
1
F11
2
1
C2:62
C2:63
YE-BU
GY-BN
6/37:2
6/8:1
C1:63
F12
2
1
2
1
F13
F14
2
1
2
1
C2:71
C2:76
C3:73
C4:19
C4:20
C3:76
BN-BU
YE-OG
RD
RD-BN
BN
YE-BU
6/141,6/142,8/59,8/60
4/83:4
3/112:1
4/119.2:1,4/119:1
7/199:3
4/102:2
F15
F16
2
1
F22
2
1
F24
2
1
F18
2
1
F19
2
1
F20
2
1
C1:60
C3:68
C2:55
C3:74
C3:66
C2:72
C1:74
C3:5
C2:58
C4:11
C3:67
RD
RD
RD-WH
RD-VT
RD-GN
RD-GN
GY-OG
GY-OG
BU-RD
BU
BU-RD
16/35:3
17/13:16
3/9:1
3/1:1,16/65:1
4/9C2:43
9/13:11
7/203:10
4/80C1:16, 4/125:5
7/51:6
8/48:1
9/42C1:1,3/65:1
C34W002
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 49
Control modules
Central Electronic Module (CEM) 3:3
4/56
C1:3
73/3036
73/3033
73/3153
73/3034
4/46
10/1:2
4/46
4/46
2/193:1
2/17:2
4/99:2
2/31:2
10/2:1
7/123:3
10/1:1
7/5:1
3/10:1
7/123:2
3/62:1
7/4:1
7/73:1
16/35:2
7/123:1
10/2:3
10/2:2
10/2:5
10/2:9
10/1:3
10/1:9
10/1:5
15/37,15/31
6/36:4
10/1:8
10/2:8
7/119:5
7/119:1
7/119:4
7/121:5
7/121:1
7/121:4
7/240:2
10/17
10/57:1
10/56:1
RHD RHD RHD RHD
BK-OG BK-OG BK-OG BK-OG
73/3030
LHD
BK-RD
31/96
BK-OG
RHD
BK-RD
LHD
BN-WH
BU-GN
VT-BN
VT-OG
VT-GN
VT-GN
BU
GN-VT
BU-GY
GN
GN-OG
VT
BU
BN-GN
BU-OG
GY-VT
BK-GN
YE-RD
WH-VT
BU-GN
YE-VT
YE-OG
VT-OG
YE-RD
GY-BN
BU-RD
RD
GN-VT
YE
BU
YE-GN
GN-BN
BU-RD
YE-GN
GN-BN
GN-VT
GN-BK
GN-OG
BU-RD
GN-OG
C1:4
C1:5
C1:6
C1:9
C1:11
C1:12
C1:13
C1:15
C1:16
C1:18
C1:28
C1:29
C1:34
C1:39
C1:40
C1:42
C1:47
C1:52
C1:64
C1:66
C1:72
C1:73
C1:75
C1:55
C1:71
C2:17
C2:11
C1:19
C1:20
C1:36
C1:53
C1:35
C2:36
C2:53
C2:35
C1:49
C2:69
C1:56
C1:57
C1:54
CEM
CAN
LIN
C2:2
C2:4
C2:5
C2:6
C2:8
C2:9
C2:10
C2:15
C2:16
C2:23
C2:24
C2:26
C2:27
C2:28
C2:29
C2:30
C2:33
C2:34
C2:41
C2:42
C2:44
C2:45
C2:47
C2:48
C2:49
C2:50
C2:51
C2:52
C2:54
C2:59
C2:60
C2:73
C2:74
C3:1
C3:2
C3:3
C1:41
C3:4
C3:10
C3:12
C3:13
C3:14
C3:19
C3:20
C3:37
C3:38
C3:39
C3:42
C3:43
C3:46
C3:47
C3:48
C3:49
C3:55
C3:69
C4:1
C4:2
C4:3
C4:4
C4:10
C4:14
C2:65
YE-RD
GY-BN
BU
GY-BU
GY-BN
YE-GY
GN
GN-OG
GN-OG
BN
GY-YE
BN-GN
BU-WH
YE
GN-BK
YE-OG
YE-VT
YE-OG
GY-BN
GY-BN
GY-OG
VT-WH
YE-BK
YE-VT
VT-GN
WH-BU
GN-BU
VT-GN
BN-GN
VT-BN
VT-BN
GN-BN
GY-VT
BN-BU
GY-YE
BU
BU-WH
GY
VT-GY
BU-WH
GY
BU-RD
GY-YE
YE-OG
GN-OG
WH-BN
VT-BK
BU-GN
GY-BN
GY-BU
GY
GN-BK
GN-VT
GY-BK
BU-RD
OG
YE-GY
VT-OG
VT-WH
GY-RD
GY-BK
2/82:2
2/16:2
2/88:2
4/115:8
4/56C2:43
10/19:1
6/57:3,4/110C2:3,10/19:2
6/33:6
7/51:1
9/13:11,7/175:1
10/3:3,4/93C5:18,3/35:3,4/116
3/284:1
4/93C4:15
6/56:4
6/55:4
6/8:3,4/116C2:5
6/33:2
7/51:2
4/46
3/271:1
10/18
3/9:2
10/17,10/18
10/3:1,10/3:2
10/17,10/18
10/17,10/46
6/33:1
7/51:3
10/17,10/18
10/18,4/110C2:3
10/17:2
10/17,10/18,10/18
10/17:2
7/12:5
7/12:1
3/1:2
4/46
3/1:3
3/1:4
3/130C1:10
3/6:3
4/9C2:1, 16/60C1:17
7/12:4
7/12:2
3/6:1
8/134:1
7/12:3
9/42C1:2
3/173:1,4/56C3:44
4/102:4
16/65:2
3/130C1:7
3/111:6
10/102:3, 10/97:2,26/6,26/7
3/272:1,10/263:1,10/241,10/289
10/150:2, 10/22:6, 10/22:7
10/243,19/4,10/242,10/244
10/161,10/286,10/287,10/288
4/33:6
10/19:2
10/22:1
4/33:2
7/149:3
10/22C1:12
LHD
BK-GN
BK-GN
RHD
31/93
31/84 31/7
C34W003
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 50
Control modules
Data communication high speed CAN exc. 4-Cyl.
4/46
ECM
5 CYL T
CAN
4/46
ECM
6 CYL
CAN
4/46
ECM
5 CYL D
CAN
C34W004
B:41
B:54
B:41
B:54
B:40
B:53
CAN
GN-BK
BU-BK
GN-BK
FOUR C
3
4
GN-BK
22 23
GN-BK
4/56
CVM
73/4005
73/4037
73/4056
BU-BK
74/409
BU-BK
BU-BK
FOUR C
4/125
CAN
GN-BK
BU-BK
4WD
4WD
4/82
45 44
4/80
74/504
Ag
Ag
GN-BK
BU-BK
GN-BK
BU-BK
MAN
MAN
AUTO
AUTO
6/164
BU-BK
GN-BK
73/3021
73/3022
EPS
4/16
MAN
12
BCM
13
CAN
19 18
BU-WH
GN-OG
7 8
BU-BK
CAN
Ag
GN-BK
BU-BK
Ag
C2:3
BU-BK
C2:2
GN-BK
73/3140
73/3015
73/3014
GN-BK
BU-BK
GN-BK
2 1
AUTO
BU-BK
GN-BK
74/301
73/3139
74/520
74/504
74/511
DEM
CAN
C1:4
BU-BK
1 2
BU-BK
4WD
3
C1:2
GN-BK
GN-BK
4WD
4
W/O 4WD
W/O 4WD
73/5155
3/130
GN-BK
BU-BK
BU-BK BU-BK
FSM
CAN
12
BU-BK
GN-BK
73/5154
SWM
4/68
SAS
CAN
GN-BK
73/5016
BU-BK
GN-BK
17
16
73/5098
BU-BK
GN-BK
3
4
4/115
PBM
ACC
ACC
GN-BK
17/13
5/1
73/5097
BU-BK
74/412
12
11
GN-BK
BU-BK
GN-BK
BU-BK
21
22
DIM
CAN
BU-BK
GN-BK
GN-BK
BU-BK
6
14
C3:7
C3:6
4
3
74/901
73/4006
BU-BK
GN-BK
GN-BK
8
BU-BK
7
CEM
73/4038
73/4057
4/28
TCM
6
BU-BK
AUTO
MAN
14
CAN
AWF21
7/164
GN-OG
23
BSC
CAN
BU-WH
4/9
16/105
AUD
C1:27
C1:28
C5:10
C5:22
ANC
BU-BK
73/5011
GN-BK
74/561
BU-BK ANC
GN-BK
GN-BK
AUTO
Ag
BU-BK
GN-BK
Ag
AUTO
AUTO
BU-BK MAN
GN-BK
GN-BK
73/5015
W/O ANC
ANC
W/O ANC
GN-BK
1 2
BU-BK
GN-BK
ANC
73/5012
4/86
CAN
73/5180
BU-BK BU-BK
GN-BK GN-BK
73/5181
BU-BK
GN-BK
C1:6
C1:15
PAM
CAN
FOUR C
74/518
4/84
21
GN-BK
C1:15
C1:16
SUM
CAN
BU-BK
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 51
Control modules
Data communication high speed CAN, 4-Cyl. 1.6L
4/46
ECM
4 CYL D
1.6L
CAN
4/46
ECM
4 CYL T
1.6L
CAN
CAN
GN-BK
BU-BK
GN-BK
FOUR C
3
4
GN-BK
22 23
GN-BK
4/56
CVM
73/4005
73/4037
73/4056
BU-BK
74/409
BU-BK
BU-BK
FOUR C
4/125
CAN
4/80
A:40
A:52
BU-BK
BU-BK
GN-BK
AUTO
AUTO
4/28B
TCM
MPS6
CAN
2 5
6/164
EPS
CAN
C2:3
C2:2
45 44
GN-BK
74/504
BU-BK
73/3021
GN-BK
MAN
BU-BK AUTO
GN-BK
BU-BK
GN-BK
73/3022
73/5155
4/16
C1:12
GN-BK
BU-BK
BU-BK
GN-BK
C1:13
BCM
CAN
C1:19
GN-OG
7 8
GN-OG
C1:18
BU-WH
74/504
BU-WH
MAN
AUTO
GN-BK
BU-BK
AUTO
73/3139
AUTO
BU-BK
GN-BK
73/3140
74/301
2
1
MAN
73/3014
73/3015
MAN
GN-BK
MAN
BU-BK
Ag
B:54
B:41
Ag
BU-BK
GN-BK
AUTO
AUTO
GN-BK
73/5015
7/164
23
BSC
4/9
CAN
C1:27
C1:28
BU-BK
73/5011
GN-BK
16/105
AUD
C5:10
C5:22
ANC
74/561
BU-BK ANC
GN-BK
3/130
GN-BK
BU-BK
BU-BK
1 2
FSM
CAN
12
BU-BK
GN-BK
73/5154
SWM
4/68
SAS
CAN
73/5016
BU-BK
GN-BK
GN-BK
W/O ANC
ANC
BU-BK
W/O ANC
GN-BK
ANC
73/5012
4/86
GN-BK
73/5098
GN-BK
ACC
BU-BK
ACC
GN-BK
17/13
3
4
4/115
17
PBM
16
CAN
73/5180
BU-BK BU-BK
GN-BK GN-BK
73/5181
BU-BK
GN-BK
C1:6
C1:15
PAM
CAN
BU-BK
5/1
GN-BK
BU-BK
GN-BK
BU-BK
73/5097
74/412
21
12
22
11
DIM
CAN
FOUR C
74/518
4/84
BU-BK
GN-BK
GN-BK
BU-BK
6
14
21
C1:15
C3:7
C3:6
74/901
8
7
GN-BK
SUM
CAN
CEM
4
3
73/4006
BU-BK
GN-BK
73/4038
GN-BK
73/4057
BU-BK
BU-BK
C1:16
C34W005
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 52
Control modules
Data communication high speed CAN, 4-Cyl. 2.0L 1:2
4/46
ECM
4 CYL
2.0P
CAN
Ag
A:95
Ag
A:76
WH-BU
WH
WH-BU
WH
MAN & EHPAS
MAN & EHPAS
AUTO & EHPAS
AUTO & EHPAS
73/3014
EHPAS
73/3015
WH-BU
WH
EHPAS
WH
73/3139
WH
6/164
EPS
CAN
C2:3
WH-BU EHPAS
WH-BU
C2:2
WH EHPAS
2
74/301
1
GN-BK
BU-BK
A
B
4/28
TCM
22
WH
73/3140
AUTO
WH-BU
AUTO
23
AWF22
CAN
4/46
ECM
4 CYL
2.0D
Ag
CAN
Ag
C33W011
A:95
A:76
WH-BU
WH
WH
WH
AUTO & EHPAS
MAN & EHPAS WH-BU
AUTO & EHPAS
MAN & EHPAS
MAN & EPAS WH-BU
MAN & EPAS
EPAS
WH
EPAS
WH-BU
AUTO & EPAS
WH-BU
WH
AUTO & EPAS
73/3016
73/3017
EPAS
WH EPAS WH
EPAS
WH-BU
74/323
2
1
EPAS
3
EPAS WH-BU
2
6/163
CAN
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 53
Control modules
Data communication high speed CAN, 4-Cyl. 2.0L 2:2
CAN
GN-BK
BU-BK
DIM
CAN
3
4
4/56
4/125
CVM
CAN
4/80
45 44
74/504
BU-BK
GN-BK
73/3021
73/3022
73/5155
4/16
C1:12
BU-BK
GN-BK
BU-BK
GN-BK
A
C1:13
BCM
C1:19
CAN
C1:18
B
BU-WH
GN-OG
7 8
74/504
BU-WH
GN-OG
3/130
GN-BK
BU-BK
FSM
CAN
12
GN-BK
SWM
73/5015
BU-BK
73/5154
SAS
CAN
73/5016
73/5098
BU-BK
GN-BK
3
4
ACC
ACC
BU-BK
GN-BK
GN-BK
17/13
73/5097
BU-BK
74/412
12
11
4/115
17
16
21
22
PBM
CAN
BU-BK
GN-BK
GN-BK
BU-BK
6
14
GN-BK
BU-BK
GN-BK
BU-BK
73/4006
BU-BK
GN-BK
73/4038
73/4057
GN-BK
GN-BK
GN-BK
22 23
73/4005
BU-BK BU-BK
73/4037
GN-BK
BU-BK
73/4056
BU-BK
74/409
CEM
C3:7
C3:6
4
3
74/901
5/1
8
7
C33W012
7/164
23
BSC
CAN
BU-BK
4/9
16/105
AUD
C1:27
C1:28
C5:10
C5:22
ANC
BU-BK
73/5011
GN-BK
74/561
BU-BK ANC
GN-BK
BU-BK
1 2
GN-BK
ANC
GN-BK
73/5180
BU-BK BU-BK
BU-BK
GN-BK GN-BK
GN-BK
ANC
BU-BK
73/5012
4/86
PAM
C1:6
CAN
73/5181
GN-BK
C1:15
FOUR C
74/518
4/84
21
GN-BK
C1:15
C1:16
SUM
CAN
BU-BK
GN-BK
GN-BK
FOUR C
BU-BK
BU-BK
FOUR C
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 54
Control modules
Data communication intermediate speed CAN, LHD
4/93
KVM
C4:4
C4:3
-OG
VT-OG
GY KEYLESS
KEYLESS
73/5001
VT-OG VT-OG
73/5002
VT-OG
VT-OG
GY-OG
74/507
GY-OG
VT-OG
3/126
DDM
C2:3
1 2
Au GY-OG
GY-OG
73/5005
73/5006
C2:15
VT-OG
Au
VT-OG
GY-OG
VT-OG
GY-OG
VT-OG VT-OG
4/52
74/30
W/O DPOW
73/5003
GY-OG
12 11
2 1
WH
C2:4
PSM
VT-OG
GN
4/56
CEM
CAN CAN CAN CAN CAN CAN
HEATER
VT-OG
GY-OG
C1:30
GY-OG
C1:31
VT-OG HEATER
74/504
56
57
73/3019
GY-OG
73/3020
74/9
C1:6
D:4
VT-OG
VT
GY
6
11
BK
GN
4/7
C1:11
BK
GN
D:7
CPM
CAN
CAN
C2:1
W/O DPOW
GY-OG
73/5004
73/5084
C2:3
4/110
TRM
GY-OG
GN
C1:5
CAN
C2:2
VT-OG
73/5085
WH
C1:12
GY-OG
VT-OG
POT
VT-OG
4/116
GY-OG
GY-OG
GY-OG GY-OG
VT-OG
GY-OG
3/127
PDM
C2:3
GY-OG
1 2
Au
GY-OG
C2:15
VT-OG
74/508
Au
VT-OG
73/5009
73/5010
74/409
GY-OG
VT-OG
C34W039
19
20
16/60
GY-OG
VT-OG
C1:12
3/281
ICM
C1:10
GY-OG
73/4034
TELE
GY-OG
PHM
1452
8
#70
CAN
C1:9
VT-OG
74/401
73/4001
73/4035
TELE
VT-OG
C1:11
3
6
9
GY-OG
VT-OG
3/112
CCM
C°/F°
CAN
GY-OG
91 0
2 3
VT-OG
73/4002
17/13
GY-OG
CAN
VT-OG
GY-OG
62
5/1
VT-OG
DIM
CAN
3
11
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 55
Control modules
Data communication intermediate speed CAN, RHD
4/56
C1:31
HEATER
VT-OG HEATER
GY-OG
73/3020
74/9
C1:6
D:4
C34W038
CEM
CAN
VT-OG
GY-OG
73/3019
VT-OG
GY-OG
6
11
BK
GN
BK
GN
CPM
CAN
C1:30
GY-OG
VT-OG
C1:11
D:7
4/7
74/504
56
57
74/508
GY-OG
VT-OG
3/126
DDM
C2:3
1 2
Au GY-OG
GY-OG
73/5009
73/5010
CAN
C2:15
VT-OG Au
VT-OG
74/30
4/52
GY-OG
VT-OG
C2:4
73/5004
GY-OG
VT-OG
11 12
1 2
GN
WH
PSM
CAN
73/5003
C2:3
VT-OG
GY-OG
KEYLESS
KEYLESS
GY-OG
VT-OG
4/93
KVM
CAN
C4:3
KEYLESS
GY-OG
73/5001
C4:4
KEYLESS
VT-OG
73/5002
GY-OG
VT-OG
C2:2
GY-OG
VT-OG
73/5085
4/116
4/110
TRM
-OG
VT TRAILER
CAN
C2:1
GY-OG
TRAILER
73/5084
TAILOPEN
TAILOPEN
VT-OG
GY-OG
C1:12
C1:5
POT
CAN
GY-OG
VT-OG
3/127
PDM
CAN
C2:3
GY-OG
Au
1 2
Au
GY-OG
73/5005
C2:15
VT-OG
Au
74/507
Au
VT-OG
73/5006
16/60
VT-OG
GY-OG
PHM
1452
#70
CAN
3
6
9
8
74/409
20
19
73/4034
C1:12
C1:11
GY-OG
GY-OG TELE
VT-OG
TELE
VT-OG
3/281
ICM
C1:9
VT-OG
73/4035
CAN
VT-OG
C1:10
GY-OG
GY-OG
74/401
73/4002
VT-OG
GY-OG
10 9
17/13
VT-OG
VT-OG
VT
GY
GY-OG
73/4001
GY-OG
3
CAN
11
-OG
-OG
GY-OG
VT-OG
3/112
2
3
2
6
CCM
C°/F°
CAN
5/1
DIM
CAN
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 56
Control modules
Data communication MOST
16/1
IAM
16/109
RSE
O
OG
O
OG
O
OG
C3:2
C3:1
3/281
O
C4:2
OG
C2:1
ICM
C4:1
C2:2
OG
O
OG
O
O
OG
C4:1
16/60
PHM
74/404
C4:2
OG
O
2 1
OG
OOO
OG
OG
O OG
O
OG
16/105
AUD
C2:1
C2:2
16/36
TVM
C1:1
C1:2
O
O
OG
OG
O
OG
16/145
RDAR
C3:1
C3:2
OG
O
OG
1
2
16/145A
OG
OG
OG
16/162
DABM
C3:1
C3:2
O
OG
C31W063
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 57
Control modules
Data communication, LIN 1:3
7/199
IMS
LIN
2
6/1 LHD
WMM
6/1 RHD
WMM
MM
7/149
RSM
1
LIN
3
GY-RD
LIN
4
LIN
74/901
7
VT
YE-BU
YE-BU
GY-RD
YE-RD
C1:47
C4:9
C1:48
C4:10
16/35
2
4/56
SCM
LIN
CEM
LIN
BUS 8
BUS 0
LIN
LIN
BUS 1
LIN
BUS 2
LIN
BUS 3
CAN
C3:49
C3:48
C3:47
C3:46
C2:8
C2:43
C3:44
3/111
LSM
LIN
6
GN-VT
GN-BK
GY-BN
W/O KEYLESS
GY
GY-BU
GY-BN
3/281
ICM
LIN
C1:3
GN-OG
C1:6
C1:7
3/130
16/65
2
4/102
4
4/119.2
2
SWM
LIN
IAU
LIN
SCL
LIN
RRX
7/240
BMS
I
U
LIN
2
GN-BK
C1:49
LIN
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 58
C33W015
Control modules
Data communication, LIN 2:3
4/28
TCM
74/301
BN-VT
4/28
LIN
AWF21
6/113
4/46
4 CYL D
4/46
5 CYL.T
4/46
4 CYL T
7Ag
CWP
LIN
ECM
1.6L
LIN
ECM
LIN
ECM
1.6 L
4/28B
TCM
MPS6
BN-VT BN-VT BN-VT BN-VT
Ag
17
LIN
WH-GN 4-CYL 2.0P
2
A:37
BU-BN
A:92
A:41
BU-BN
BU-BN
Ag
11
TCM
LIN
AWF22
6/26
ACM
74/411
10
BN-VT
13
BN-VT
74/403
22
BN-VT
3/156
2
GSM
LIN
73/3065
4/109
GCU
WH-GN
C2:12
Ag
LIN
4/46
A:75
Ag
ECM
4 CYL
2.0 P
2.0 D
LIN
A:93
74/307
4
WH-GN
4/46
A:92
2
ECM
7/200
CATD
6 CYL.
LIN
LIN
BU-BN
73/3141
BU-BN
3.2PZEV
Ag
BU-BN BU-BN
G
LIN
C2:1
BU-BN
3.0T & 3.2P
73/3095
3.2PZEV 3.2PZEV
4/46
ECM
5 CYL.D
BU-BN
A:88 Ag
3/176
LIN
LIN
BLIS
RHD
RHD
BLIS
BLIS
GN-WH
GN-WH
GN-WH
GN-WH
3/126
DDM
C2:4
LIN
GN-WH
73/5019
6/62
LCM
LIN
3
LIN
5
LHD
LHD
RHD
3/128
LDM
74/507
Au
74/509
GN-WH
4
GN-WH
7
LIN
20
GN-WH
GN-WH
3/127
PDM
3/129
LIN
C1:20
RDM
LIN
20
C2:4
GN-WH
GN-WH
GN-WH
GN-WH
BLIS
6/63
LHD
LHD
RHD
74/510
7
RCM
LIN
GN-WH
5 C1:20
74/508
Au
4
C34W006
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 59
Control modules
Data communication, LIN 3:3
9/14
SHM
LIN
A:2
74/501
73/5021
WH-GN
RSHEAT
LIN
3
BN-VT BN-VT
18
FSHEAT FSHEAT
WH-GN
RSHEAT RSHEAT RSHEAT
15
74/409
LIN
WH-GN
LHD
FSHEAT
4
WH-GN
RHD
WH-GN
9/13 9/12 3/65
BN-VT
RHD
SHM SHM
LIN
4
BN-VT
LHD
74/401
3/112
CCM
WH-GN
WH-GN
LIN
4 5
1 2
BN-VT BN-VT BN-VT
16
BN-VT
73/4010
74/409
9/15
SHM
8/48
LIN
MIRROR
HUS ECC
3
BN-VT
74/412
2
74/901
9
7/90
HUS
LIN
2
BN-VT BN-VT
11
73/4047
BN-VT
74/417
WH-GN
3 2
BN-VT
BN-VT
RSHEAT
LIN
A:2
4/6
6/96
DMM
YE
YE
S3
LIN
6/102
DMM
YE
LIN
6/103
DMM
GN
LIN
6/48
DMM
S1
C33W017
GN GN
LIN
6/95
DMM
GN
LIN
C66W017
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 60
Control modules
Steering Wheel Module (SWM)
C1:30
C1:31
15/31
4/56
1
11A/2
2
RD-BU
CEM
CAN
LIN
30+
1
11A/1
2
RD-BK
C5:1 C5:2
3/156
1
GSM
LIN
F7
1
2
2
2/93
F9
5
4
GN-RD
GY
C3:61
C3:48
C3:12
10
11
GN-BK
BU-WH
GN-VT
GN-WH
GY
C1:5
C1:1
C1:8
C1:4
C1:3
C1:7
3/130
SWM
CAN
4/68
WIPER
TURN
LIN
SAS
CAN
C4:4
C4:5
C4:3
C4:7
C4:1
1
3/359
3/4
SWSL
2
1
3
LIN
3/131
SWSR
1
2
3
LIN
3/360
+
3
1
-
3
2
2
LIN
RHD
73/4016
4/148
HSWM
1
LIN
4/9
SRS
CAN
BK
C1:65
BK
6
Au
Au
Au
Au
GN-OG
73/4017
BK
3
5
2
C2:8
C2:9
C2:11
C2:10
BK RHD
LHD
BU
YE-GY
YE-BU
OG
BN-OG
OG
OG-BK
C1:10
C1:6
C1:2
C1:9
C6:2
C6:1
C2:8
C2:7
C2:2
C2:1
C4:6
C4:2
C4:8
C5:2
C5:1
C3:6
C3:5
C3:4
C3:3
C3:2
C3:1
3/281
ICM
C1:10
C1:9
C2:1
0
C2:2
0
CAN
LIN
74/411
C1:3
15
YE-RD YE-RD
BK
LIN
3/37
2
1
1
2
1
TEMP SENSOR
-
+
2
HSW
8/123
6
5
4
3
2
1
1
2
1
2
1
2
31/83
C33W093
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 61
Group 26 Cooling system
Cooling fan, 4-Cyl. 1.6L Turbo
30+
15/31
1
11A/43
2
RD-WH
1
4/71
7/16
7/8
P
1Au
Au 2
1
2
3
4
2
BN
GN-BN
GY-BN
YE
WH-BU
74/301
14
13
15
BN
GN-BN
GY-BN
A:12
A:33
B:37
B:51
B:31
B:8 VT
4/46
Ag
Ag
Ag
Ag
Ag
Ag
ECM
4 CYL T
1.6 L
CAN
B:54
Ag
B:41
Ag
BK-BU
31/2
C33W018
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 62
Group 26 Cooling system
Cooling fan, 4-Cyl. 2.0L Turbo
30+
15/31
1
11A/43
2
GY
1
4/71
7/16
7/8
P
1Au
Au 2
2
3
1
4
2
GN-BN
GY-BN
BN
YE
WH-BU
74/301
13
15
14
GN-BN
GY-BN
BN
B:2
B:17
A:4
A:42
A:23
B:55 VT
4/46
Ag
Ag
Ag
Ag
Ag
Ag
ECM
4 CYL T
2.0 L
CAN
A:95
Ag
A:76
Ag
BK-BU
31/2
C33W019
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 63
Group 26 Cooling system
Cooling fan, 5-Cyl. Turbo
30+
15/31
1
11A/43
2
RD-WH
1
4/71
7/16
7/8
P
4/46
1
Au
Au
2
GN-BN
2
1
BN
3
GY-BN
4
2
VT
BK-BU
74/301
13
14
15
YE
BN-GN
GN-BN
BN
GY-BN
A:68
A:13
B:49
B:53
B:31
B:8
Ag
Ag
Ag
Ag
Ag
Ag
ECM
5 CYL T
CAN
B:54
Ag
B:41
Ag
31/2
C31W067
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 64
Group 26 Cooling system
Cooling fan, 6-Cyl.
30+
15/31
1
11A/43
2
RD-WH
1
4/71
7/16
7/8
P
4/46
1
Au
Au
2
1
BN
2
GN-BN
3
GY-BN
4
2
VT
BK-BU
74/301
14
13
15
YE
BU
BN
GN-BN
GY-BN
A:68
A:13
B:53
B:51
B:31
B:8
Ag
ECM
Ag
6 CYL
CAN
Ag
Ag
Ag
B:54
Ag
Ag
B:41
Ag
31/2
C31W068
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 65
Group 26 Cooling system
Cooling fan, 4-Cyl. 1.6L Diesel
30+
15/31
1
11A/43
2
RD-WH
4/46
4 CYL D
ECM
1.6 L
1
4/71
7/8
P
7/16
1
2
3
1Au
Au
2
BN
GN-BN
GY-BN
74/301
14
13
15
GY-BN
BN
GN-BN
GY-BN
A:45
A:33
A:21
73/3145
YE
BN-GN
4
2
VT
C:15
C:19
CAN
A:13
A:40
A:52
BK-BU
31/2
C33W020
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 66
Group 26 Cooling system
Cooling fan, 4-Cyl. 2.0L Diesel
30+
15/31
1
11A/43
2
GY
4/46
4 CYL D
2.0 L
ECM
1
4/71
7/8
P
7/16
1
2
3
1Au
Au
2
BN
GN-BN
GY-BN
4
2
74/301
14
13
15
BK-YE
BN-GN
VT
BN
GN-BN
GY-BN
A:23
A:4
A:42
B:2
B:17
B:55
Ag
Ag
Ag
CAN
A:95
A:76
BK-BU
31/2
C33W021
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 67
Group 26 Cooling system
Cooling fan, 5-Cyl. Diesel
30+
15/31
1
11A/43
2
RD-WH
1
4/71
7/16
7/8
P
1Au
Au
2
1
2
3
4
2
BN
GN-BN
GY-BN
74/301
14
13
15
VT
YE
BN-GN
BN
GN-BN
GY-BN
GY-BN GY-BN
STOSTA STOSTA
A:32
A:9
B:16
B:23
B:8
73/3145
A:68
4/46
Ag
ECM
Ag
5 CYL D
Ag
Ag
CAN
Ag
Ag Ag
B:40
Ag
B:53
BK-BU
31/2
C33W022
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 68
Group 27 Engine controls
Cruise control 4-Cyl. 1.6L Turbo
MAN
7/123
7/51
4
RHD
BK-BU
73/5072
15/31
2
Au
1
Au
3
Au
1
2
3
6
5
LHD
74/504
BK
73/5071
30+
1
2
GY-BK
BN-GN
WH-VT
GN
GN-OG
YE-OG
VT-GN
BU-RD
R7
2/31
31
11B/17
BU-WH
17
BK-BU
BU-WH
RHD
C1:63
C1:34
C1:52
C1:16
C1:30
C1:31
C2:16
C2:34
C2:52
C2:58
C3:6
C3:7
4/56
3/284
2
BK-OG
LHD
2 5
GN-VT
1
F20
2
74/504
1
1
11A/1
11B/27
2
2
RD-BK
C1:13 C5:1
CEM
CAN
LIN
C2:26
C2:41
BN-GN
1
MAN
GY-BN
42
1
VT-WH
11A/2
F7
3/9
7/31
N
F22
2
WH
1
2
BN BN
7/124
1
2
RD-BU
C5:2
C3:61
C3:48
1
2
73/4016
C2:55 C2:45
RD-WH
1
31/83
2
73/3100
73/3101
LHD
RHD
4/28B
BK
B:41
B:54
1
VT-RD
3
YE-VT
2
GN-BK
GN-WH
GN-BK
BK
BK
TCM
CAN
MPS6
74/301
20
4/46
Ag
Ag
BK
RHD
LIN
ECM
CAN
WH
4/16
45
46
26
38
27
BCM
CAN
34
33
12
13
3/130
SWM
CAN
C1:8
C1:7
C1:2
73/4017
GY-BN GY-BN
MAN MAN
Ag
LIN
74/301
BN-VT BN-VT BN-VT BN-VT
17
5
2
14
GY-BN
AUTO
B:13
C3:1
C3:3
C3:4
74/411
11
10
74/412
74/411
15 16
18 17
BN-BU
BN-BU
4 5
WH
BN
74/403
GY-BU
GY-BU
73/3102
73/3103
22
4/80
10
9
FSM
CAN
ACC
WH
BN
2
1
3
2
1
3/4
2
7/32
1
N
2
SWSL
LIN
3/156
GSM
LIN
31/84
BK-BU
RHD
BK-OG
LHD
31/7
4/50
74/301
ETA
M
GN-VT
YE-VT
BU-WH
BN
BU-GN
YE-VT
BU-WH
19
1
Au
Au
4
Au
2
Au
6
3
Au
5
Au
B:26
A:81
A:58
A:19
A:50
A:74
A:6
Ag
4 CYL T
Ag
Ag
Ag
Ag
Ag
Ag
1.6 L
7/203
BN-BU
2 3
74/321
BN-BU
18 9
FLR
CAN
GY-BU
5/1
GY-BU
DIM
CAN
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 69
2
6
C34W007
Group 27 Engine controls
Cruise control 4-Cyl. 2.0L Turbo
7/51
4
RHD
BK-BU
73/5072
BK-BU
RHD
15/31
1
2
3
6
5
LHD
74/504
BK
73/5071
BK-OG
LHD
30+
1
2
GY-BK
GN-OG
YE-OG
VT-GN
BU-RD
R7
2/31
31
11B/17
BU-WH
17
BK-BU
BU-WH
RHD
74/301
4/50
ETA
M
C1:63
C1:30
C1:31
C2:16
C2:34
C2:52
C2:58
C3:6
C3:7
19
4/56
3/284
2
BK-OG
LHD
2 5
GN-VT
1
F20
2
1
2
Au
5
6
Au
Au
4
3
Au
1
1
11A/1
11B/27
2
2
RD-BK
C1:13 C5:1
CEM
CAN
LIN
C2:26
BN-GN
1
F7
1
VT-WH
3/9
BU-WH
YE-VT
BU-GN
BU-WH
VT-WH
GN-VT
YE-VT
7/31
N
11A/2
F22
2
WH
1
2
BN BN
7/124
1
2
RD-BU
C5:2
C3:61
C3:48
1
2
73/4016
C2:55 C2:45
RD-WH
1
31/83
2
73/3100
73/3101
LHD
RHD
4/28
BK
A:76
A:95
A:14
B:81
B:76
B:40
B:43
B:41
B:42
1
3
2
GN-WH
GN-BK
BK
4/46
Ag
Ag
Ag
4 CYL T
Ag
Ag
Ag
Ag
Ag
Ag
VT-RD
YE-VT
GN-BK
BK
RHD
TCM
CAN
LIN
AWF22
ECM
CAN
2.0 L
WH
C1:8
C1:7
C1:2
BK
73/4017
Ag
Ag
Ag
45
46
26
38
27
3/130
13
BN-VT BN-VT
23
22
24
25
18
GY-BN
A:41
A:92
A:73
4/16
BCM
CAN
SWM
CAN
LIN
73/3065
GN-BN
WH-GN
34
33
12
13
C3:1
C3:3
C3:4
74/301
11
7/203
BN-BU
15 16
18 17
74/412
BN-BU
4 5
74/411
BN-BU
2 3
74/321
BN-BU
FLR
73/3102
WH
BN
73/3103
74/411
BN-VT BN-VT
10
4/80
10
9
GY-BU
GY-BU
GY-BU
5/1
GY-BU
18 9
74/403
22
ACC
FSM
CAN
DIM
BN-VT
2
1
WH
BN
2
1
3
2
6
3/4
2
7/32
1
N
2
SWSL
LIN
3/156
GSM
LIN
31/84
31/7
CAN
CAN
C34W008
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 70
Group 27 Engine controls
Cruise control 4-Cyl. 1.6L Diesel
7/123
7/51
4
RHD
BK-BU
73/5072
BK-BU
RHD
15/31
Au
2
1
Au
3
Au
1
2
3
6
5
LHD
74/504
BK
73/5071
15/31
BK-OG
LHD
8/111
30+
1
2
GY-BK
BN-GN
MAN
WH-VT
MAN
GN
MAN
GN-OG
YE-OG
VT-GN
BU-RD
17
BU-WH
1
2
M
R7
2/31
31
11B/17
C1:63
C1:34
C1:52
C1:16
C1:30
C1:31
C2:16
C2:34
C2:52
C2:58
BU-WH
BK-BU
RHD
R10
2/32
11B/37
WH
1
2AuAu
2 5
GN-VT
4/56
1
F20
2
C3:6
C3:7
3/284
2
BK-OG
LHD
30+
31
2 5
WH
1
1
11A/1
11B/27
2
2
RD-BK
C1:13 C5:1
CEM
CAN
LIN
C2:26
C2:41
BN-GN
1
GY-BN MAN
42
74/504
74/301
19
1
11B/30
2
GY-VT
WH-BU
11A/2
F7
1
3/9
VT-WH
GY-BN
MAN
4/28B
5
2
73/3051
7/31
N
2
F22
2
74/301
20
BU-WH
TCM
CAN
LIN
MPS6
WH
1
BN BN
2
73/3101
7/124
1
2
RD-BU
C5:2
C3:61 GN-WH
LHD
1
2
73/4016
BK
31/83
C2:55 C2:45
RD-WH
1
MAN
GY-BN
GY-BN
14
AUTO
73/3100
1
3
2
GN-BK C3:48
BK
RHD
4/46
A:52
A:40
C:42
C:8
A:28
B:4
VT-RD
YE-VT
GN-BK
BK
BK
RHD
ECM
CAN
4 CYL D
1.6 L
WH
3/130
C1:8
C1:7
C1:2
73/4017
B:30
B:37
B:28
B:51
4/16
45
46
26
38
27
BCM
CAN
34
33
12
13
SWM
CAN
LIN
BU-WH BU-WH
YE-VT
BU-GN
YE
GY
73/3125
7/203
C3:1
C3:3
C3:4
BN-BU
15 16
18 17
74/412
BN-BU
4 5
74/411
BN-BU
2 3
74/321
BN-BU
FLR
CAN
18 9
GY-BU
GY-BU
GY-BU
GY-BU
73/3102
WH
BN
73/3103
1 B:42
Au
Au
2
Au
3
Au
4
5
Au
10
9
5/1
4/50
4/80
ETA
M
FSM
CAN
DIM
CAN
7/32
1
WH
N
BN
2
3/4
SWSL
1
2
3
LIN
2
1
2
6
31/84
31/7
C34W009
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 71
Group 27 Engine controls
Cruise control 4-Cyl. 2.0L Diesel
7/51
31/84
15/31
MAN
7/123
4
LHD
RHD
BK
BK-BU
73/5072
73/5071
BK-BU
BK-OG
LHD
RHD
30+
Au
2
1
Au
3
Au
1
2
3
6
5
74/504
15/31
3/156
GSM
8/111
31/7
1
2
GY-BK
BN-GN
WH-VT
GN
GN-OG
YE-OG
VT-GN
BU-RD
LIN
R7
2/31
31
11B/17
BU-WH
17
BK-BU
BU-WH
RHD
R10
2/32
2
BN-VT
2 5
GN-VT
4/56
C1:63
F20
C1:34
C1:52
C1:16
C1:30
C1:31
C2:16
C2:34
C2:52
C2:58
C3:6
C3:7
2
BK-OG
LHD
31
2 5
74/403
22
12Au
Au
C1:13 C5:1
1
2
C2:26
3/284
74/504
30+
BN-VT
1
1
11A/1
11B/27
2
2
RD-BK
1
CEM
CAN
LIN
C2:41
BN-GN
1
VT-WH
GY-BN
42
GY-BN
MAN
74/301
19
4/28
23
22
1
11B/30
2
GY-VT
74/411
10 11
GN-VT
GN-BN
F7
3/9
BN-VT
7/31
N
11A/2
2
F22
2
74/301
20
BU-WH
TCM
CAN
LIN
AWF22
WH
1
BN BN
2
7/124
1
2
RD-BU
C5:2
C3:61 GN-WH
1
2
LHD
73/4016
BK
31/83
C2:55 C2:45
RD-WH
1
MAN
GY-BN
GY-BN
18
AUTO
2513A:92
GN-BN
24
WH-GN
BN-VT
73/3051
74/301
BN-VT
73/3100
73/3101
1
3
2
GN-BK C3:48
BK
RHD
4/46
A:95
A:76
A:14
A:41
A:73
A:63
B:92
B:93
VT-RD
YE-VT
GN-BK
BK
BK
RHD
ECM
CAN
4 CYL D
2.0 L
WH
3/130
C1:8
C1:7
C1:2
73/4017
B:76
B:40
Ag
B:43
Ag
B:42
Ag
4/16
45
46
26
38
27
SWM
CAN
LIN
BCM
CAN
YE-VT
BU-GN
BU-WH
VT-WH
YE
7/203
34
33
12
13
C3:1
C3:3
C3:4
BN-BU
15 16
18 17
74/412
BN-BU
4 5
74/411
BN-BU
2 3
74/321
BN-BU
18 9
FLR
CAN
GY-BU
GY-BU
GY-BU
GY-BU
73/3102
WH
BN
73/3103
1 B:81
2
5
6
3
10
9
5/1
4/50
Au
Au
Au
4/80
ETA
M
FSM
CAN
DIM
CAN
7/32
1
WH
N
BN
2
3/4
SWSL
1
2
3
LIN
2
1
2
6
C34W010
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 72
Group 27 Engine controls
Cruise control 5-Cyl. Turbo
7/51
4
RHD
BK-BU
73/5072
BK-BU
15/31
1
2
3
6
5
LHD
74/504
BK
73/5071
BK-OG
30+
1
2
GY-BK
GN-OG
YE-OG
VT-GN
BU-RD
R7
2/31
31
11B/17
C1:63
C1:31
C2:16
C2:34
C2:52
C2:58
BU-WH
17
BU-WH
RHD
C1:30
C3:6
C3:7
BK-BU
2 5
GN-VT
4/56
F20
3/284
2
BK-OG
LHD
4/50
C1:13 C5:1
1
2
CEM
C2:26
ETA
M
1
11A/1
11B/27
2
RD-BK
CAN
LIN
BN-GN
1
74/301
19
1Au
Au
2
3
Au
5
Au
6
Au
Au
4
1
2
1
C2:41
VT-WH
GY-BN
MAN
11A/2
F7
C2:45
3/9
74/504
YE-VT
BU-GN
YE-VT
BU-WH
BU-RD
GN-VT
7/31
N
F22
42
BU-WH
2
1
2
1
2
RD-BU
C5:2
1
2
C2:55
RD-WH
1
2
73/3100
WH
BN BN
73/3101
7/124
C3:61 GN-WH
1
VT-RD
3
YE-VT
2
GN-BK
GN-BK C3:48
LHDBKRHD
BK
RHD
73/4016
BK
4/28
TCM
BK
CAN
LIN
GY-BN
MAN
AWF21
20
74/301
31/83
4/46
B:41
Ag
Ag
B:54
Ag
B:26
Ag
A:75
Ag
A:74
Ag
A:17
Ag
A:48
Ag
A:65
Ag
A:67
Ag
WH
3/130
C1:8
C1:7
C1:2
73/4017
7
14
6
5
GY-BN
MAN
ECM
5 CYL T
CAN
Ag
45
46
26
38
27
SWM
BN-VT
B:13
4/16
BCM
CAN
34
33
12
13
CAN
LIN
74/301
GY-BN
C3:1
C3:3
C3:4
74/411
BN-VT BN-VT BN-VT
11
10
AUTO
7/203
WH
BN-BU
15 16
18 17
74/412
BN-BU
4 5
74/411
BN-BU
2 3
74/321
BN-BU
18 9
FLR
73/3102
BN
73/3103
74/403
22
GY-BU
GY-BU
GY-BU
GY-BU
10
5/1
9
4/80
FSM
CAN
DIM
WH
BN
1
2
3
3/4
SWSL
2
2
1
7/32
1
2
LIN
3/156
GSM
LIN
2
6
N
31/84
RHD
LHD
31/7
CAN
CAN
C34W011
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 73
Group 27 Engine controls
Cruise control 6-Cyl.
7/51
4
RHD
BK-BU
73/5072
15/31
1
2
3
6
5
LHD
74/504
BK
73/5071
30+
1
2
GY-BK
GN-OG
YE-OG
VT-GN
BU-RD
R7
2/31
31
11B/17
C1:63
C1:31
C2:16
C2:34
C2:52
C2:58
BU-WH
17
BU-WH
RHD
C1:30
C3:6
C3:7
BK-BU
2 5
GN-VT
4/56
F20
3/284
2
BK-OG
LHD
C1:13 C5:1
1
2
CEM
C2:26
1
11A/1
11B/27
2
RD-BK
CAN
LIN
BN-GN
1
74/301
19
3/130
4/16
45
46
26
38
27
SWM
CAN
BCM
CAN
34
33
73/3102
WH
BN
WH
BN
2
1
7/32
N
73/3103
12
13
7/31
N
1
2
73/3100
WH
BN BN
WH
73/3101
7/124
1
1
1
VT-RD
3
YE-VT
2
GN-BK
11A/2
2
2
RD-BU
C5:2
3/4
F7
1
2
F22
C3:61 GN-WH
1
2
LHDBKRHD
73/4016
BK
RHD
C1:8
GN-BK C3:48
C1:7
C1:2
BK
73/4017
LIN
C3:1
C3:3
C3:4
1
2
3
SWSL
LIN
4/28
2
2
1
3/156
GSM
LIN
VT-WH
C2:45
3/9
RD-WH
BU-WH
C2:55
1
2
31/83
TCM
BK
CAN
LIN
74/301
7
BN-VT
14
6
5
74/411
BN-VT BN-VT BN-VT
11
AWF21
GY-BN
4/46
B:41
ECM
6 CYL
B:13
Ag
B:54
B:26
Ag
Ag
Ag
Ag
74/403
10
22
4/80
FSM
10
9
BN-BU
GY-BU
15 16
18 17
74/412
BN-BU
4 5
GY-BU
CAN
74/411
31/84
BK-BU
RHD
BK-OG
LHD
31/7
CAN
BN-BU
2 3
GY-BU
74/321
5/1
BN-BU
4/50
ETA
M
GY-BU
7/203
1
2
3
Au
Au
4
Au
5
6
Au
YE-VT
BU-GN
BU-OG
GN-VT
YE
BU-RD
A:75
A:74
A:17
A:67
A:48
A:65
Ag
Ag
Ag
Ag
Ag
Ag
18 9
FLR
CAN
DIM
CAN
2
6
C34W012
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 74
Group 27 Engine controls
Cruise control 5-Cyl. Diesel
7/51
31/84
15/31
MAN
7/123
4
LHD
RHD
BK
BK-BU
73/5072
73/5071
BK-OG
BK-BU
LHD
RHD
Au
Au
Au
1
2
3
6
5
31/7
30+
1
2
GY-BK
BN-GN
2
1
WH-VT
3
GN
GN-OG
YE-OG
VT-GN
BU-RD
74/504
8/111
4/50
11B/17
BU-WH
17
BU-WH
ETA
M
R7
2/31
31
C1:63
C1:34
C1:52
C1:16
C1:30
C1:31
C2:16
C2:34
C2:52
C2:58
C3:6
C3:7
BK-BU
RHD
M
7/31
1
N
2
1
1
1
11A/2
2 5
GN-VT
4/56
F20
C1:13 C5:1
1
2
11B/27
2
2
RD-BK
1
F7
2
2
RD-BU
C5:2
11A/1
CEM
CAN
1
F22
3/9
2
C2:55 C2:45
RD-WH
1
2
42
BU-WH
3/284
2
BK-OG
LHD
C2:26
LIN
1
C2:41
BN-GN
GY-BN
MAN
74/301
VT-WH
74/504
19
15/31
R10
2/32
1
31
2
11B/37
73/3051
1
VT-BK VT-BK GY-VT
2AuAu
GN-BU
1
Au
Au
4
2
Au
Au
3
6
Au
BU-GN
YE-VT
YE-VT
BU-WH
VT-WH
73/3100
WH
BN BN
73/3101
7/124
C3:61
1
3
2
LHD
RHD
73/4016
VT-RD
YE-VT
GN-BK
GN-WH
GN-BK C3:48
BK
BK
RHD
BK
4/28
TCM
BK
CAN
LIN
31/83
GY-BN
MAN
AWF21
74/301
20
B:53
B:40
B:34
30+
1
11B/30
2 5
2
B:55
A:45
A:47
A:23
A:51
A:38
A:30
WH
C1:8
C1:7
C1:2
73/4017
GY-BN
MAN
4/46
ECM
Ag
Ag
Ag
Ag
5 CYL D
CAN
Ag
Ag
Ag
Ag
Ag
Ag
3/130
7
14
6
5
45
46
26
38
27
SWM
BN-VT
Ag
B:48
4/16
BCM
CAN
34
33
12
13
CAN
LIN
74/301
C3:1
C3:3
C3:4
74/411
BN-VT BN-VT BN-VT
11
GY-BN
10
AUTO
74/321
7/203
BN-BU
15 16
18 17
74/412
BN-BU
74/411
BN-BU
2 3
BN-BU
FLR
CAN
WH
BN
74/403
4 5
18 9
73/3102
73/3103
22
GY-BU
GY-BU
GY-BU
GY-BU
7/32
1
WH
N
BN
2
3/4
SWSL
1
2
3
LIN
3/156
2
GSM
LIN
4/80
FSM
10
9
2
1
CAN
5/1
DIM
CAN
2
6
C34W013
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 75
Group 27 Engine controls
Start-/Stop function 4-Cyl. 1.6L Turbo
RD
74/316
1
RD
15/31
11B/34
1
2/35
2
3
R12
1
YE
C34W063
RD
73/3137
73/3136
PF1
2
1
6/25
RD-VT
RD-VT
RD-VT
74/302
C1:1
M
1/1
7/240
BMS
I
U
LIN
12V
BU-WH
1
BU-WH
C2:1
2
15/37
74/316
BK
31/3
GY-VT
5
2
2/166
GY-VT
MF1
R1
2
RD-BU
1
2
1
11A/9
1
3
5
RD-BU
73/3157
RD-BU
2
RD-BU
73/3160
F10
M11
2
2
1
YE-VT
3
MF2
2
A
1
1
2/246
R2
2
5
3
1
1
2
RD
RD
4
YE-VT
15/31_11B/33:2
11B/12
RD
RD
74/301
27
A:90
A:5
11B/27
1
4/46
ECM
CAN
Ag
Ag
4 CYL T
1.6 L
LIN
RD
GN-VT
4/56
GN-RD
C1:13
CEM
CAN
2/31
1
2
3
R7
2
5
5
1
11B/17
2
74/504
19
6/26
C1:1
2
RD RD
2
1
11B/20
C2:17
ACM
G
LIN
C2:1
1/2
12V
A:41
Ag
B:9
Ag
B:11
Ag
B:49
Ag
B:24
Ag
B:18
Ag
A:54
Ag
B:7
Ag
B:40
Ag
73/3094
BU-BN
BN-VT
WH-BU
YE-OG
GY-BU
RD-GN
GN-VT
BK-YE
BK
VT-WH
31/131
7/251
7/243
1
NEUTRAL
2
3
4
1
2
3
POS.
BN-VT
WH-BU
YE-OG
7/251
1
VAC
2
P
3
31/XX10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 76
Group 27 Engine controls
Start-/Stop function 4-Cyl. 2.0L Turbo
RD
74/316
1
RD
15/31
2/35
3(30)
R12
1(86)
YE
RD
73/3137
73/3136
PF1
2
1
6/25
RD-VT
RD-VT
RD-VT
C1:1
M
1/1
7/240
BMS
I
U
LIN
12V
BU-WH
C2:1
2
15/37
74/316
BK
GY-VT
5
2
2/166
GY-VT
MF1
R1
11A/9
2
WH-BN
BN-GN
GN-VT
C1:13
4/56
CEM
CAN
7/251
1
VAC
2
P
3
C1:1
12V
5
6/26
ACM
G
LIN
BU-BN
WH-BU
YE-OG
R7
2
74/504
19
BN-VT
GY-BN
5(87)
1
11B/17
2
C2:1
BK
31/131
18
2/31
11B/27
1
74/301
27
11
11A/1
2
2
RD
MF2
1
2
1
1
F10
5
3
WH-BN
2
M11
2
2
1
1
1
2/246
R2
2
5
3
1
1
11B/12
2
RD
RD
73/3157
WH-BN
YE-VT
RD
4/46
ECM
2
WH-BN
3
YE-VT
A
15/31_11B/33:2
RD
4
A:68
CAN
Ag
A:65
LIN
Ag
1
11A/2
2
RD
Ag
Ag
Ag
Ag
Ag
Ag
Ag
1
2
3
11A/44
1/2
A:75
A:10
A:27
A:78
A:74
A:43
A:41
4 CYL T
2.0 L
7/251
1
2
3
4/28
TCM
AWF22
2(85)
1
11B/20
2
RD
BN-VT
WH-BU
YE-OG
C2:17
BU-BN
73/3141
C34W064
31/3
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 77
Group 27 Engine controls
Start-/Stop function 4-Cyl. 1.6L Diesel
RD
74/316
1
RD
15/31
11B/34
1
2/35
2
3
R12
1
YE
C34W037
RD
73/3137
73/3136
PF1
2
6/25
RD-VT
RD-VT
1
74/302
C1:1
M
RD-VT
1
1/1
BU-WH
1
BU-WH
C2:1
7/240
BMS
I
U
LIN
12V
2
15/37
74/316
BK
GY-VT
5
31/3
2
2/166
R1
GY-VT
MF1
11A/9
2
RD-BU
2/31
11B/27
1
MF2
1
F10
5
3
1
2
1
RD-BU
2
M11
2
2
1
1
1
2/246
R2
2
5
74/301
3
1
1
11B/12
2
RD
RD
27
RD
73/3157
RD-BU
YE-VT
RD
4/46
ECM
2
RD-BU
73/3160
3
YE-VT
A
15/31_11B/33:2
4/28B
TCM
4
RD
C:3
CAN
A:16
LIN
4 CYL D
Ag
GY-BN
AUTO
C:8 14
1.6 L
2
A:37
A:27
A:19
A:25
A:24
B:49
B:31
A:21
A:43
A:31
1
3
1/2
R7
2
5
74/504
19
6/26
C1:1
ACM
G
LIN
12V
BU-BN
GY-BU MAN
GN-VT
RD-GN
VT-WH
MAN
MAN
MAN
C2:1
BK
73/3094
BK-YE
31/XX10
73/3145
GY-BN GY-BN
WH-BU
BN-VT
5
1
11B/17
2
31/131
7/243
1
NEUTRAL
3
2
4
MPS6
POS.
7/251
RD RD
3
2
1
2
1
11B/20
2
C2:17
YE-OG
WH-BU
BN-VT
GN-RD
GN-VT
C1:13
4/56
CEM
CAN
7/251
3
VAC
2
P
1
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 78
Group 27 Engine controls
Start-/Stop function 4-Cyl. 2.0L Diesel
RD
74/316
1
RD
15/31
2/35
3(30)
1(86)
R12
YE
C34W014
RD
73/3137
73/3136
PF1
2
6/25
RD-VT
RD-VT
1
C1:1
M
RD-VT
1
1/1
BU-WH
C2:1
7/240
BMS
I
U
LIN
12V
2
15/37
74/316
BK
GY-VT
5
31/3
2
2/166
R1
GY-VT
MF1
11A/9
2
RD-BU
GN-VT
4/56
BN-GN
C1:13
CEM
CAN
2/31
11B/27
1
74/301
27
11
11A/1
2
2
RD
MF2
1
F10
5
3
1
2
1
RD-BU
2
M11
2
2
1
1
1
2/246
R2
2
5
3
1
1
11B/12
2
RD
RD
73/3157
RD-BU
YE-VT
RD
4/46
ECM
2
RD-BU
73/3160
3
YE-VT
A
15/31_11B/33:2
4
RD
4/28
TCM
GY-BN
AUTO
A:68
A:65
A:41 18
Ag
CAN
Ag
LIN
4-CYL.D
2.0L
Ag
1
11A/2
2
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
1
2
3
11A/44
RD
1/2
A:75
A:10
A:27
A:44
A:9
A:7
A:51
A:78
A:49
A:50
R7
5
6/26
C1:1
ACM
G
LIN
12V
BU-BN
YE-GN MAN
GN-VT
GY-BU
BK-GY
BN-VT
YE-OG
WH-BU
2
MAN
MAN
MAN
5(87)
1
11B/17
2
74/504
19
C2:1
BK
31/131
2
3
1
4
1
2
3
7/243
NEUTRAL
POS.
2.0L
7/251
VAC
P
2(85)
1
11B/20
2
RD
C2:17
BU-BN
73/3141
AWF22
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 79
Group 27 Engine controls
Start-/Stop function 5-Cyl. Diesel
RD
74/316
1
RD
15/31
11B/34
1
2/35
2
3(30)
R12
1(86)
YE
C34W015
RD
73/3137
73/3136
PF1
2
6/25
1
RD-VT
RD-VT
C1:1
M
RD-VT
1/1
1
7/240
BMS
I
U
LIN
12V
C2:1
74/316
2
15/37
BK
GY-VT
5
31/3
2
2/166
R1
GY-VT
MF1
11A/9
2
RD-BU
3
2
1
C1:13
C2:17
GN-RD
4/56
CEM
CAN
7/251
VAC
P
BU-WH
11B/27
1
MF2
1
F10
5
2
3
1
1
RD-BU
73/3157
RD-BU
2
M11
2
2
1
YE-VT
1
1
2/246
R2
2
5
3
1
1
11B/12
2
RD
RD
RD
74/504
19
12V
1/2
BK
31/131
RD
4/46
ECM
2
RD-BU
3
YE-VT
A
15/31_11B/33:2
4/28
TCM
AWF21
4
RD
B:31
CAN
Ag
B:43
Ag
LIN
GY-BN
AUTO
B:48 5
Ag
5 CYL D
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
2/31
1
2
3
74/504
19
A:88
B:56
B:57
B:47
B:35
B:10
B:42
B:8
A:86
A:28
R7
2
5
6/26
C1:1
ACM
G
LIN
BU-BN
GY-BU MAN
GN-VT
YE-GN
GY-BN
73/3145
GY-BN
WH-BU
BN-VT
MAN
MAN
MAN
RD RD
C2:1
1
3
2
4
GY-BN
5(87)
1
11B/17
2
7/243
NEUTRAL
POS.
GN-VT
7/251
3
2
1
2(85)
1
11B/20
2
YE-OG
WH-BU
BN-VT
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 80
Group 28 Ignition and control system
Engine management system, 4-Cyl. 1.6L Turbo 1:2
30+
15/31
GY-VT
A
RD-BU
73/3160
6/73
31/XX10
1
11B/30
2
1
11B/33
2
RD
RD-BU
73/3091
RD
STOSTA
1
2
STOSTA
BK-YE
73/3094
BK-YE
7/17
1
11B/40
2
RD
1
R10
2
1
R11
2
1
11B/36
2
BU-BN
2/32
3
5
2/14
3
5
1
11B/35
2
YE-GY
1
11B/37
2
WH
1
11B/38
2
GY-BU
STOSTA
GY-BU
WH
3
WH
73/3039
8/121
8/167
MAF
GY-BU
73/3053
GY-BU
2
1
2
4
5
8/159
8/77
8/6
8/7
8/8
WH
8/9
2
1
7/25
7/16
1
2AuAu
1
3AuAu
2Au
GY-OG
BU
YE-VT
1
8/28
2
GY-BU Ag
2
Ag
1
WH-BU
YE-BU YE-BU
2
1
2
BU-OG BU-OG
1
2
VT-GY VT-GY
1
2
YE-OG YE-OG
1
GY-OG
1
2
74/310
1
2
3
4
5
6
7
8
YE
WH-BU
WH
YE-VT
BK-GN
VT-BN
GN-VT
GN-BU GN-BU
GY-YE GY-YE
GN-VT GN-VT
BU BU
OG-WH
WH-OG
STOSTA
A:10
A:36
A:55
A:95
A:28
A:1
A:2
A:3
A:77
A:25
A:52
A:26
A:76
A:27
A:53
A:96
A:12
A:33
A:18
A:45
A:46
A:29
A:4
73/3004
Ag
YE-GY
3
Ag
BK-BU
ETA
M
QLT
P
P
2
Ag
1
Ag
3
YE-GY
Ag
2
Ag
1
Ag
3
YE-GY
Ag
2
Ag
Ag
YE-GY
3
Ag
2
Ag
1
1
Au
Au
4
Au
2
Au
6
3
Au
5
Au
12Au
Au
12Au
Au
3
P
4
2
1
1
2
3
3
2
1
Au
1
Au
3
2
Au
73/3058
GN-VT
YE-VT
BU-WH
BN
BU-GN
YE-VT
BN-GN
BN-BU
WH-BN
VT-OG
BU-WH
YE-GN
GY-OG
GN-BU
GN-WH
BU-OG
GY-YE
WH-VT
VT-BN
BN-BU
BU
GN-BN
BU-GY
BU-BN
BU-BN
BK-BU
BK-BU
BK-BU
WH-VT
YE-BU
BU-OG 1
GN-VT
A:70
A:94
A:69
A:93
A:81
A:6
A:58
A:19
A:50
A:74
A:85
A:61
A:84
A:60
A:21
A:8
A:11
A:30
A:13
A:82
A:37
A:35
A:7
A:20
A:22
A:83
A:31
31/88
BK-BU
20/3
20/4
20/5
20/6
4/50
7/23
7/24
7/165
7/35
7/140
7/81
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 81
4/46
Ag
Ag
Ag
ECM
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
CAN
Ag
4 CYL T
1.6 L
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
B
C
C33W042
Group 28 Ignition and control system
Engine management system, 4-Cyl. 1.6L Turbo 2:2
A
4/46
ECM
CAN
4 CYL T
1.6 L
RD
GY-VT
B:27
Ag
4/28B
15/31
1
11B/20
2
TCM
Ag
AUTO
B:15
Ag
B:51
Ag
B:37
Ag
B:31
Ag
B:25
Ag
B:30
Ag
B:14
Ag
CAN
11
MPS6
VT-BN
VT-BN
VT-BN
GY-BN
MAN
AUTO
73/3064
20
GN-BN
BN
GY-BN
BN-WH BN-WH
VT-BN
VT-OG
GN-BN
13
BN
14
GY-BN
15
3
VT-BN
18
VT-OG
10
VT-BN
GY-BN
MAN
7/8
2
1
3
74/301
AUTO
MAN
74/504
P
7/51
4
VT-BN
32
42
MAN
7/123
1
2
3
6
5
14
GY-BN
B:13
3/284
BU-WH
YE-OG
BK-WH
WH
1
74/504
2
BU-WH
B:26
Ag
YE-OG
B:45
Ag
B:34
WH-BU
Ag
WH
B:35
Ag
19
29
7
6
GY-BN
MAN
Au
Au
Au
17
18
2
1
2
1
3
1
11B/17
2
GY-BK
BN-GN
WH-VT
GN
GN-OG
YE-OG
VT-GN
BU-RD
BU-WH
30+
C1:63
C2:41
C1:34
C1:52
C1:16
C1:3
C1:5
C1:6
C2:16
C2:34
C2:52
C2:58
3
RD
4/56
BN-GN
YE-OG
1
52
GN-VT
1
F20
2
2/31
R7
CEM
CAN
LIN
74/511
RD
17
1
11B/27
2
YE-OG
3
C2:76 C2:26
74/514
1
11A/2
2
RD-BU
C5:2 C1:13
1
F13
2
C2:45
VT-WH
3/9
1
F22
2
C2:55
RD-WH
1
2
74/301
B:54
Ag
B:41
Ag
73/5072
BK-BU
BK-BU
RHD
RHD
BK
BK-OG
LHD
LHD
73/5071
74/507
WH
17 18
BK-WH BK-WH
4/83
YE-OG
5
YE-OG
4
1
BK-YE
B
C
PEM
7/6
P
BU-BN
BK-YE
BK-YE
BK-YE
1
B:29
Ag
B:1
Ag
B:2
Ag
B:4
Ag
2
LHD
RHD
73/3005
B:6
Ag
B:5
Ag
BK-YE BK-YE
BK-BU
BK-OG
WH
3
2
6/62
MEM
M
M
x
M
MEM
X
Y
6
3
y
YE-GY
WH-BN
F
6/33
46 12
M
BU-BN
BU-BN
73/3094
31/XX10
31/84
3
31/7
5
BK-YE
31/66
C33W043
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 82
Group 28 Ignition and control system
Engine management system, 4-Cyl. 2.0L Turbo 1:3
30+
15/31
GY-VT
Au
3
2
1
3
2
1
3
2
3
2
1
1
2
1
2
1Ag
Ag
2
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
YE-BU
YE-VT
BU-GY
BU
GN-OG
1
2
1
2
1
2
GN-WH
YE-VT
GY-VT
VT-RD
BK-YE
VT-RD
VT-RD
VT-RD
Au
Au
74/317
53/723
1
11B/30
2
53/722
1
11B/37
2
WH
2/32
R10
2
1
1
11B/36
2
1
11B/38
2
7/17
3
3
MAF
1
2
4
5
8/166
5
8/18
1
1
8/175
11B/35
2
11B/40
2
GY-BU
8/180
WH
WH
WH
GY-BU
8/200
GY-BU
8/159
7/16
7/25
YE-GY
GY-BU
1Au
2
1
2
3
VT-RD
53/720
20/3
20/4
20/5
20/6
GN
WH-BN
GY-BU
YE-WH
GY-YE
YE-OG
BU-GY
YE-OG HP
YE
BN
1
2
3
BK-YE
BK-YE
GN-WH
YE-VT
GY-VT
BK-YE
MP
31/89
WH-VT
YE-BU
BU-OG 1
GN-VT
31/88
B:4
B:5
B:19
B:20
B:69
B:57
B:72
B:73
B:58
B:66
B:65
B:17
B:21
B:36
B:53
B:50
B:51
B:52
B:2
B:6
4/46
Ag
Ag
Ag
ECM
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
CAN
4 CYL T
2.0 L
Ag
Ag
Ag
Ag
A
B
YE-VT
BU-GN
BU-WH
VT-WH
GN-VT
YE-VT
VT-OG
WH-BN
BU-WH
YE-GN
GY-OG
GN-BU
BU-OG
GY-YE
BK-WH
BN-BU
WH-RD
BU
GN-BN
BU-GY
BU-BN
BU-BN
B:81
B:76
B:40
B:43
B:41
B:42
A:100
A:101
B:1
B:16
A:49
B:29
B:28
B:44
B:59
B:60
A:20
A15
A:30
A:48
B:45
B:30
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
B
C34W016
C
53/800
4/50
7/24
7/165
7/35
7/140
7/81
OLS
P
P
ETA
M
YE-GY
YE-GY
P
12Au
1
2
Au
5
6
Au
4
Au
3
Au
Au
3
4
2
1
1
2
3
2
1
Au
1
Au
3
2
Au
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 83
Group 28 Ignition and control system
Engine management system, 4-Cyl. 2.0L Turbo 2:3
RD
30+
1
11B/17
2
3
1
52
2/31
R7
11B/27
A
B
4/46
GY-VT
YE-BU
A:63
Ag
A:39
Ag
4/28
TCM
15/31
1
11B/20
2
1
2
1
11A/42
2
1
11A/2
2
ECM
CAN
4 CYL T
2.0 L
CEM
CAN
LIN
RD
RD-BU
C5:2 C1:13
1
F13
2
C2:76 C2:26
1
F22
2
C2:55 C2:45
C1:63
C1:5
C2:16
C2:34
C2:52
C2:58
RD
GN-VT
4/56
1
F20
2
GY-BN
A:41
Ag
A:77
Ag
A:25
Ag
A:4
Ag
A:23
Ag
A:42
Ag
B:30
Ag
Ag
18
CAN
AWF22
73/3064
VT-RD
74/301
GN-BN
BN
GY-BN
VT-BN VT-BN
GN-BN
13
BN
14
GY-BN
15
18
2
74/301
VT-BN
VT-BN VT-BN
7/8
2
P
1
3
VT-BN
32
6/113
13
Ag Ag
7/51
4
CWP
1
2
3
6
5
GY-BK
M
GN-OG
YE-OG
VT-GN
BU-RD
BU-WH
3/284
2
1
BN-GN
YE-OG
VT-WH
3/9
RD-WH
1
BU-WH
A:14
Ag
YE-OG
A:12
Ag
A:53
GN-BU
Ag
YE-GN
A:34
Ag
A:95
Ag
A:76
Ag
19
29
7
6
BK-BU
BK-BU
BK
BK-OG
RHD
RHD
LHD
LHD
73/5072 73/5071
BU-WH
YE-OG
BK-WH
WH
74/504
17
18
2
1
74/507
WH
17 18
BK-WH BK-WH
YE-OG
74/511
4/83
17 3
YE-OG
5
74/514
YE-OG
4
BK-YE
1
2
PEM
WH
A:97
BK-YE
Ag
A:98
BK-YE
Ag
A:99
BK-YE
Ag
Ag
Ag
B:77
B:82
73/3012
RHD
LHD
3
2
MEM
M
M
x
M
MEM
X
Y
6/62
6
3
y
YE-GY
F
6/33
WH-BN
46 12
BK-YE
M
BK-YE
BK-BU
BK-OG
3
5
BK-YE
B
C
BU-BN
BU-BN
31/XX10
31/84
31/7
31/66
C33W045
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 84
Group 28 Ignition and control system
Engine management system, 4-Cyl. 2.0L Turbo 3:3
4/46
ECM
8/77
8/6
8/7
8/8
8/9
7/248
2
1
2
1
2
1
2
1
2
1
GN-BU
WH-BU
YE-BU
GN-BU
BU-OG
GY-YE
GN-VT
VT-GY
BU
YE-OG
B:93
B:92
B:90
B:89
B:79
B:80
B:84
B:85
B:95
B:94
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
CAN
4 CYL T
2.0 L
1
P
2
3
GY-VT
GN-BN
YE-WH
B:34
B:49
B:33
Ag
Ag
Ag
6/181
7/274
CBM
P
2
Au
Au
4
Au
3
Au
51Au
M
1
2
3
OG
OG-YE
OG-BU
OG-GY
OG-GN
GN-BN
BU-GY
BU
B:74
B:75
B:15
B:78
A:11
B:35
B:27
B:54
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
C33W046
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 85
Group 28 Ignition and control system
Engine management system, 5-Cyl. Turbo 1:2
30+
15/31
OLLEV
11B/30
YE-GN
73/3012
73/3094
1
2
1
2
9/32
1
11B/40
2
BK-YE
BK-YE
BK-YE
R10
2(85)
1(86)
1
11B/36
2
2/32
3(30)
5(87)
1
11B/35
2
YE-GY
31/88
1
11B/38
2
GY-BU
31/89
1
11B/37
2
BK-RD
73/3004
73/3053
WH
73/3039
BK-OG
BK-OG
BK-RD
BK-RD
BK-RD
7/6
P
GY-BU
1
GY-BU
7/35
QLT
7/156
P
7/165
P
7/16
7/17
MAF
3
7/24
7/23
7/25
20/3
31
20/4
20/5
31
20/6
31
20/7
31
4/50
ETA
7/81
P
WH
WH
WH
WH
WH
M
8/28
8/10
1
2
3
RD-VT
GY-VT
GY-BU
1
BU-BN
2
BU-GN
3
1
2
3
4
1
4
3
2
8/6
8/7
8/8
8/9
1Au
Au 2
1
2
Au
5
4
1
Au
Au
2
1
Au
Au
2
Au
Au
Au
4
YE-GY
2
4
YE-GY
2
1 3 YE-BU
4
YE-GY
2
YE-GY
4
2
YE-GY
4
2
Au
1
2
Au
Au
3
5
Au
6
Au
4
Au
1
2
3
OLLEV
OLLEV
BU-BN
GY
2
1
2
1
2
1
2
1
2
1
2
1
BU
BN-GN
BN-GN
73/3165
BU-BN
GN-BN
GY
GY-OG
YE
BN-GN
BU-GY
BU
YE-VT
VT-BN
VT-OG
GY-BK
YE-RD
GN-RD
GN-BN
YE-VT
GY-VT
73/3058
73/3166
YE-BU
GN-BU
GY-YE
VT-GY
YE-OG
BU-RD
WH
73/3161
VT-BK
BU-OG
GN-VT
GY-BK
BU-BN W/O OILLEV
YE-VT
BU-GN
YE-VT
BU-WH
BU-RD
GN-VT
BU
BU-BN
GN
GY
BU-RD
A:63
A:21
A:46
A:47
A:71
A:37
A:72
A:95
A:78
A:82
A:80
A:83
A:79
A:73
A:68
A:13
A:66
A:14
A:70
A:22
A:42
A:19
A:43
A:20
A:6
A:30
A:11
A:61
A:57
A:59
A:56
A:60
A:16
A:75
A:74
A:17
A:48
A:65
A:67
A:24
A:69
A:23
4/46
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
ECM
Ag
Ag
Ag
CAN
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
5 CYL T
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
A
B
C33W047
BU-BN
31/XX10
BU-BN
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 86
C
D
Group 28 Ignition and control system
Engine management system, 5-Cyl. Turbo 2:2
A
B
4/46
ECM
CAN
5 CYL
T
RD-VT
GY-VT
B:27
Ag
B:16
Ag
B:13
Ag
B:15
Ag
4/28
GY-BN
5
VT-BN
RD-VT
TCM
CAN
AWF21
11
VT-BN
73/3064
15/31
74/301
AUTO
VT-BN
VT-BN MAN
74/301
GY-BN GY-BN MAN
GN-BN
B:49
Ag
BN
B:53
Ag
GY-BN
B:31
Ag
B:30
B:14
VT-BN
VT-OG
Ag
Ag
20
GN-BN
13
BN
14
GY-BN
15
VT-BN
18
VT-OG
10
7/8
2
P
1
3
7/51
4
1
11B/20
2
VT-BN
32
RD
74/504
42
1
2
3
6
5
1
11B/17
2
GY-BK
GY-BN
GN-OG
YE-OG
VT-GN
BU-RD
BU-WH
30+
MAN
C1:63
C2:41
C1:5
C1:6
C2:16
C2:34
C2:52
C2:58
3
RD
4/56
1
52
GN-VT
1
F20
2
2/31
R7
CEM
CAN
LIN
RD
1
11B/27
2
1
11A/2
2
RD-BU
C5:2 C1:13
1
F13
2
C2:76C2:26
1
F22
2
C2:55 C2:45
3/284
2
1
BN-GN
YE-OG
VT-WH
3/9
RD-WH
1
BU-WH
B:26
Ag
YE-OG
B:21
Ag
B:34
BK-WH
Ag
WH
B:35
Ag
19
29
7
6
BK-BU
BK-BU
BK
BK-OG
RHD
RHD
LHD
LHD
73/5072 73/5071
B:54
Ag
B:41
Ag
B:2
BK-YE
Ag
B:4
BK-YE
Ag
B:6
BK-YE
Ag
Ag
Ag
73/3012
B:3
B:5
BK-YE BK-YE
RHD
BK-BU
LHD
BK-OG
73/3094
BU-WH
YE-OG
BK-WH
WH
74/504
17
18
2
1
74/507
WH
17 18
WH
BK-WH BK-WH
YE-OG
6/62
3
2
MEM
2
17 3
74/511
4/83
YE-OG
5
74/514
YE-OG
4
BK-YE
1
PEM
6
3
M
M
X
y
x
YE-GY
M
F
MEM
Y
6/33
WH-BN
46 12
M
3
5
BK-YE
C
D
BU-BN
BU-BN
31/XX10
31/84
31/7
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 87
31/66
C33W048
Group 28 Ignition and control system
Engine management system, 6-Cyl. 3.2L PZEV 1:2
30+
15/31
11B/30
7/200
1
2
11B/41
2
YE-BU BK-YE
CATD
73/3133
P
QLT
BU-BN
1
2
3
4
1
Ag
Ag
2
Ag
3
73/3010
GY
BU-BN
8/6
WH
8/7
WH
8/8
WH
8/9
WH
8/10
WH
R10
2
1
1 1
11B/38
2
2/32
3
5
1
11B/35
2
11
11B/36
11B/37
2
2
7/156
7/166
73/3053
BU-BN
8/11
WH
WH
7/17
1
MAF
WH
2
3Au
4
5
7/16
Au
1
2
Au
3
1
73/3004
BK-RD
BK-RD
YE-GY
BK-OG
BK-RD
BK-RD
BK-RD
BK-OG
31/88
BK-RD
31/89
BK-YE
73/3094
BK-YE
BK-YE
BK-YE
20/16
2
20/3
43
20/7
43
20/5
20/8
20/4
43
20/6
4
7/81
6/139
2
6/140
2
1
+
1
YE-GY
1
YE-GY
1
YE-GY
3 4 BU-OG
1
YE-GY
YE-GY
1
YE-GY
1
3
1
P
2
3
M
M
1
3
1
3
73/3009
2
1
2
1
2
1
2
1
2
1
2
1
YE-GY
73/3058
GY-BU
BU
GY-BU
GN
GY-BU
4/50
7/25
ETA
M
7/23
7/24
RD-VT
GY-VT
BU-BN
GY-BU
GY GY
BU-RD
BU-OG
GN-BU
GY-YE
VT-GY
YE-OG
BU-RD
GN-WH
1Au
Au
2
GN-BN
VT-BN
YE-VT
BU-GY
BU
YE
BU
1
2
3Au
4
Au
Au
5
6
Au
1Au
2
Au
1
Au
2
Au
73/3039
YE-VT
YE-RD
GN-RD
VT-BK
VT-OG
GY-BK
GY-BK
VT-BN 43
YE-BU
GN-VT
BU
WH-BN
BU-GN
YE-VT
BU-GN
BU-OG
GN-VT
YE
BU-RD
A:21
A:46
A:47
A:71
A:63
A:73
A:78
A:82
A:80
A:83
A:79
A:81
A:30
A:6
A:22
A:70
A:66
A:14
A:68
A:13
A:75
A:74
A:17
A:67
A:48
A:65
A:43
A:20
A:61
A:42
A:19
A:60
A:59
A:58
A:57
A:56
A:24
A:23
A:69
A:38
A:39
4/46
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
ECM
Ag
Ag
Ag
CAN
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
6 CYL
3.2PZEV
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
A
B
31/XX10
GY-BU
WH
C
D
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 88
C33W052
Group 28 Ignition and control system
Engine management system, 6-Cyl. 3.2L PZEV 2:2
A
B
4/46
ECM
CAN
6 CYL
3.2PZEV
RD
RD-VT
GY-VT
B:27
Ag
B:16
Ag
73/3064
VT-BN
B:15
Ag
B:13
GY-BN
Ag
74/301
GN-BN
B:51
Ag
BN
B:53
Ag
GY-BN
B:31
Ag
B:30
B:14
VT-BN
VT-OG
Ag
Ag
15/31
1
11B/20
2
VT-BN
32
74/301
VT-BN
7/8
GN-BN
13
BN
14
GY-BN
15
VT-BN
18
VT-OG
10
2
P
1
3
7/51
4
1
A:5
3
30+
11B/17
2
4/28
1
2
6
5
1
3
RD RD
C1:63
GY-BK
VT-BN
A:11
TCM
CAN
AWF21
C1:5
C1:6
GN-OG
C2:16
YE-OG
C2:34
VT-GN
C2:52
BU-RD
C2:58
2 5
4/56
2/31
R7
GN-VT
1
F20
2
1
11B/27 11A/2
2
CEM
CAN
LIN
1
2
RD-BU
C5:2 C1:13
1
F13
2
C2:76 C2:26
1
F22
2
C2:55 C2:45
3/284
2
1
BU-WH
BN-GN
YE-OG
VT-WH
3/9
RD-WH
1
BU-WH
B:26
Ag
YE-OG
B:21
Ag
B:34
BK-WH
Ag
WH
B:35
Ag
19
29
7
6
BK-OG
BK-BU
BK-BU
RHD RHD
RHD
LHD
LHD
73/5072 73/5071
B:54
Ag
B:41
Ag
B:2
BK-YE
Ag
B:4
BK-YE
Ag
B:6
BK-YE
Ag
LHD
73/3012 73/3094
B:5
Ag
B:3
Ag
BK-YE
BK-YE
BK-BUBKBK-OG
BU-WH
YE-OG
BK-WH
WH
74/504
17
18
74/507
YE-OG
2
1
WH
BK-WH
Au
Au
17 18
Au
Au BK-WH
74/511
4/83
17 3
YE-OG
5
74/514
YE-OG
4
BK-YE
1
PEM
6
WH
C1:3
C1:2
6/62
MEM
M
M
y
x
M
F
MEM
X
Y
6/33
3
YE-GY
WH-BN
46 12
M
3
2
BK-YE
5
BK-YE
C
D
GY-BU
WH
31/XX10
31/84
31/7
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 89
31/66
C33W053
Group 28 Ignition and control system
Engine management system, 6-Cyl. 1:2
30+
15/31
11B/30
1
7/156
2
7/166
R10
2/32
2
3
5
1
11
1
1
BK-RD
YE-GY
BK-OG
BK-RD
BK-RD
BK-RD
BK-OG
BK-RD
73/3053
WH
20/3
20/7
20/5
20/8
20/4
20/6
11B/38
2
11B/35
2
11B/37
2
31/88
11B/36
2
73/3004
WH
BK-RD
31/89
BK-YE
73/3094
BK-YE
BK-YE
31/XX10
1
P
2
3
4
1
Ag
QLT
Ag
2
Ag
3
BU-BN
7/17
MAF
1
7/16
20/16
2
1
+
43
43
43
4
7/81
P
6/139
2
M
6/140
2
M
RD-VT
GY-VT
BU-BN
73/3009
73/3010
GY
BU-BN
8/6
WH
8/7
WH
8/8
WH
8/9
WH
8/10
WH
8/11
WH
2
3Au
4
5
Au
1
2
Au
1
YE-GY
1
YE-GY
1
YE-GY
3 4 BU-OG
1
YE-GY
2
1
2
1
2
1
2
1
2
1
2
1
4/50
YE-GY
73/3058
YE-GY
1
YE-GY
1
3
1
2
3
GY-BU
1
3
1
3
BU
GY-BU
GN
GY-BU
7/25
ETA
M
7/23
7/24
BU-BN
GY-BU
GY GY
BU-RD
BU-OG
GN-BU
GY-YE
VT-GY
YE-OG
BU-RD
GN-WH
1Au
Au
2
GN-BN
VT-BN
YE-VT
BU-GY
BU
YE
BU
1
2
3Au
4
Au
Au
5
6
Au
1Au
2
Au
1
Au
2
Au
73/3039
YE-VT
YE-RD
GN-RD
VT-OG
GY-BK
VT-BN 43
YE-BU
GN-VT
BU
WH-BN
BU-GN
GY-BU
WH
YE-VT
BU-GN
BU-OG
GN-VT
YE
BU-RD
VT-BK
GY-BK
A:21
A:46
A:47
A:71
A:63
A:73
A:78
A:82
A:80
A:83
A:79
A:81
A:30
A:6
A:22
A:70
A:66
A:14
A:68
A:13
A:75
A:74
A:17
A:67
A:48
A:65
A:43
A:20
A:61
A:42
A:19
A:60
A:59
A:58
A:57
A:56
A:24
A:23
A:69
A:38
A:39
4/46
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
ECM
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
6 CYL
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
CAN
3.2P
A
B
C33W054
C
D
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 90
Group 28 Ignition and control system
Engine management system, 6-Cyl. 2:2
A
B
4/46
ECM
CAN
6 CYL
3.2P
1
11B/20
2
VT-BN
32
2
1
3
RD
7/8
P
RD-VT
GY-VT
B:27
Ag
B:16
Ag
15/31
74/301
73/3064
VT-BN
B:15
Ag
B:13
GY-BN
Ag
GN-BN
B:51
Ag
BN
B:53
Ag
GY-BN
B:31
Ag
B:30
B:14
VT-BN
VT-OG
Ag
Ag
74/301
13
14
15
18
10
VT-BN
GN-BN
BN
GY-BN
VT-BN
VT-OG
7/51
4
1
A:5
2
3
6
5
30+
11B/17
2
4/28
1
GY-BK
VT-BN
TCM
CAN
AWF21
GN-OG
YE-OG
VT-GN
BU-RD
RD
3
C1:63
A:11
C2:16
C2:34
C2:52
C2:58
C1:5
C1:6
1
1
11B/27 11A/2
1
2 5
4/56
2/31
R7
GN-VT
1
F20
2
2
RD
2
RD-BU
C5:2 C1:13
1
F13
2
1
F22
2
CEM
CAN
LIN
C2:76 C2:26
C2:55 C2:45
3/284
2
1
BU-WH
BN-GN
YE-OG
VT-WH
3/9
RD-WH
1
BU-WH
B:26
Ag
YE-OG
B:21
Ag
B:34
BK-WH
Ag
WH
B:35
Ag
19
29
7
6
BK-OG
BK-BU
BK-BU
RHD RHD
RHD
LHD LHD
LHD
73/5072 73/5071
B:54
Ag
B:41
Ag
B:2
BK-YE
Ag
B:4
BK-YE
Ag
B:6
BK-YE
Ag
73/3012
B:5
Ag
B:3
Ag
BK-YE BK-YE
BK-BUBKBK-OG
73/3094
BU-WH
YE-OG
BK-WH
WH
74/504
17
18
74/507
YE-OG
2
1
WH
BK-WH BK-WH
17 18
74/511
4/83
17 3
YE-OG
5
74/514
YE-OG
4
1
PEM
WH
C1:3
C1:2
6/62
MEM
M
M
X
y
x
M
F
MEM
Y
6
YE-GY
6/33
46 12
3
WH-BN
M
3
2
BK-YE
5
BK-YE
C
D
GY-BU
WH
31/XX10
31/84
31/7
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 91
31/66
C33W055
Group 28 Ignition and control system
Engine management system, 6-Cyl. Turbo 1:2
30+
15/31
11B/30
1
2
R10
2/32
2
3
5
1
11
1
1
11B/38
11B/37
11B/35
2
11B/36
2
2
2
7/156
7/166
P
QLT
73/3053
WH
WH
7/17
MAF
3
7/16
20/16
2
20/3
43
20/7
43
20/5
20/8
20/4
43
20/6
4
7/81
31/90
31/89
BK-OG
BK-OG
YE-GY
BK-OG
BK-RD
BK-RD
73/3004
BK-RD
BK-OG
BK-RD
31/88
P
8/28
GY-BU
GY-BU
73/3039
GY-BU
8/68
BU-BN
1
2
3
4
1
GY
Ag
2
Ag
BU-BN
3
Ag
7/165
P
8/6
WH
8/7
WH
8/8
WH
8/9
WH
8/10
WH
8/11
WH
4
Au
5
1
2
Au
1
2
Au
YE-GY
1
+
YE-GY
1
1
YE-GY
1
YE-GY
3 4 BU-OG
1
YE-GY
YE-GY
1
YE-GY
1
3
1
2
3
2
1
2
1AuAu
73/3010
3
2
1
4
73/3058
2
1
2
1
2
1
2
1
2
1
2
1
73/3009
GY
7/25
6/120
ETA
M
1
2
7/23
7/24
RD-VT
GY-VT
BU-BN
GY-BU
GY GY
BU-RD
BU-OG
GY-OG
BU-BN
GN-BN
BU-BN
GN-BU
GY-YE
VT-GY
YE-OG
BU-RD
GN-WH
Au
Au
VT-BN
YE-VT
BU-GY
BU
YE
BU
1
2
3Au
4
5
6
1
2
1
2
Au
Au
Au
Au
Au
VT-BK
Au
Au
GY-BK
VT-BN 43
YE-BU
GN-VT
GY
BU-BN
BU-GN
YE-BU
GY-BU
WH
YE-VT
GN-BN
YE-RD
GN-RD
VT-OG
GY-BK
YE-OG
YE-VT
BU-GN
BU-OG
GN-VT
YE
BU-RD
A:21
A:46
A:47
A:71
A:63
A:72
A:45
A:37
A:73
A:78
A:82
A:80
A:83
A:79
A:81
A:30
A:22
A:70
A:66
A:14
A:68
A:13
A:75
A:74
A:17
A:67
A:48
A:65
A:43
A:20
A:61
A:42
A:19
A:60
A:59
A:58
A:57
A:56
A:24
A:23
A:69
A:95
A:87
A:6
4/46
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
ECM
Ag
Ag
CAN
Ag
Ag
6 CYL T
3.0 L
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
A
B
C
D
C33W056
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 92
Group 28 Ignition and control system
Engine management system, 6-Cyl. Turbo 2:2
A
B
4/46
ECM
CAN
6 CYL T
3.0 L
30+
1
11B/17
2
4/28
5
1
2
3
6
5
GY-BK
VT-BN
TCM
CAN
AWF21
GN-OG
YE-OG
VT-GN
BU-RD
RD
1
1
11B/27 11A/2
1
3
C1:63
11
2 5
4/56
2/31
R7
GN-VT
1
F20
2
RD
2
2
RD-BU
C5:2 C1:13
1
F13
2
1
F22
2
CEM
C1:5
C1:6
C2:16
C2:34
C2:52
C2:58
CAN
LIN
C2:76 C2:26
C2:55 C2:45
1
VT-BN
32
RD
11B/20
2
7/8
2
P
1
3
RD-VT
GY-VT
B:27
Ag
B:16
Ag
15/31
74/301
VT-BN
GY-BN
GN-BN
BN
GY-BN
VT-BN
VT-OG
73/3064
74/301
13
14
15
18
10
VT-BN
GN-BN
BN
GY-BN
VT-BN
VT-OG
B:15
Ag
B:13
Ag
B:51
Ag
B:53
Ag
B:31
Ag
B:30
Ag
B:14
Ag
7/51
4
3/284
2
1
BU-WH
BN-GN
YE-OG
VT-WH
3/9
RD-WH
1
BU-WH
B:26
Ag
YE-OG
B:21
Ag
B:34
BK-WH
Ag
WH
B:35
Ag
19
29
7
6
BK-BU
BK-BU
BK-OG
BK
RHD RHD
RHD
LHD LHD
LHD
73/5072 73/5071
B:54
Ag
B:41
Ag
B:2
BK-YE
Ag
B:4
BK-YE
Ag
B:6
BK-YE
Ag
73/3012
B:5
Ag
B:3
Ag
BK-YE BK-YE
BK-BU
BK-OG
73/3094
BU-WH
YE-OG
BK-WH
WH
74/504
17
18
2
1
74/507
WH
17 18
WH
BK-WH BK-WH
3
2
6/62
MEM
M
X
YE-OG
x
17 3
74/511
4/83
YE-OG
5
74/514
YE-OG
4
1
PEM
6
3
M
y
M
F
MEM
Y
YE-GY
6/33
46 12
WH-BN
M
3
2
BK-YE
5
BK-YE
C
D
GY-BU
WH
31/XX10 31/84
31/7
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 93
31/66
C33W057
Group 28 Ignition and control system
Engine management system, 4-Cyl. 1.6L Diesel 1:3
30+
15/31
1
2
1
11A/42
2
RD-VT
11B/30
2/32
2(85)
1(86)
1
11B/40
2
YE-GN
R10
3(30)
5(87)
1
11
2
2
11B/38
11B/36
GY-BU
GY-BU
BU-BN
2
11B/37
73/3051
WH WH
8/6
8/7
8/8
8/9
7/25
7/190
7/191
7/16
7/17
WH
MAF
1
2
1
2
12Au
4/46
GY-VT
Ag
1
Ag
2
Ag
1
Ag
2
Ag
1
Ag
2
Ag
1
Ag
2
1
Au
2
Au
3
Au
Au
Au
Au
Au
Au
5
2
4
3
GN-BU
YE-BU
GY-YE
BU-OG
VT-GY
GN-VT
YE-OG
BU
GY-VT
GN-BN
YE-VT
BN
WH-BN
YE-GY
GY-VT
YE
BN-GN
YE-VT
BU-GY
BU
A:28
C:47
C:48
C:23
C:24
C:11
C:12
C:35
C:36
C:13
C:20
C:22
C:26
C:17
B:46
B:33
C:15
C:19
C:31
B:47
B:53
ECM
CAN
4 CYL D
1.6 L
4/109
43 85
74/307
GCU
1 67
YE-BU
VT-WH
4 3 2 1
YE-BU
VT-WH
1 1
2
BU-BN
BU-BN
1 1
BK-YE
GY-VT
GY-VT
9/38
1
2
BK-YE
73/3094
8/111
7/6
P
7/172
BK-YE
BK-YE
VT-GN
YE-RD
8/113
8/28
1
WH
M
2AuAu
7/154
1
2
2
1
Au
2
Au
3
Au
7/174
dP
GY-VT
BN-BU
GY-VT
1
Au
2
Au
3
Au
GY-BU
1
Au
2
BN-WH
Au
Au
GY-BU
1
2
Au
WH-OG
WH-BU
VT-WH
GN
BU-BN
GN-OG
GY-VT
BN-BU
BK-YE
BK-YE
BK-YE
B:15
C:45
B:11
B:16
B:4
B:45
B:20
C:44
B:38
C:16
B:40
C:1
C:7
C:9
A:3
A:4
A:53
73/3012
20/25
BK-YE
BU-BN
20/23
20/24
20/22
BU-BN
31/XX10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 94
A
B
C33W036
Group 28 Ignition and control system
Engine management system, 4-Cyl. 1.6L Diesel 2:3
4/46
ECM
CAN
4 CYL D
1.6 L
4/28B
TCM
14
GY-BN
C:8
AUTO
CAN
11
MPS6
A:19
VT-BN
VT-BN
GY-BN GY-BN
MAN
C:6
BN-WH
VT-BN VT-BN
A:22
C:42
BU-WH
A:44
BK-WH
A:23
WH
73/3064
20
3
18
19
7
6
74/301
VT-BN
BN-WH
15/31
74/301
VT-BN
MAN
1
11B/20
2
VT-BN
32
AUTO
7/51
4
BU-WH
BK-WH
WH
3/284
2
RD
74/504
7/123
1
11B/17
2
GY-BN
42
Au
Au
Au
1
2
3
6
5
74/504
1
30+
17
2
1
2
1
3
GY-BK
MAN
BN-GN
MAN
WH-VT
MAN
GN
MAN
GN-OG
YE-OG
VT-GN
BU-RD
BU-WH
31
RD
C1:65
C2:41
C1:34
C1:52
C1:16
C1:3
C1:5
C2:16
C2:34
C2:52
C2:58
BN-GN
2 5
4/56
2/31
R7
GN-VT
1
F20
2
RD
CEM
CAN
LIN
1
11B/27
2
C2:26
C2:76
YE-OG
1
2
RD-BU
C5:2 C1:45
1
F13
2
C2:45
VT-WH
11A/2
3/9
RD-WH
2
1
F22
2
C2:55
1
A
B
A:40
A:52
A:2
A:5
73/5072 73/5071
BU-BN
BU-BN
BK-BU
BK-BU
RHD
RHD
RHD
BK-BU
BK
LHD
LHD
BK-OG
31/7
BK-OG
LHD
74/507
WH
17 18
WH
BK-WH BK-WH
6/62
3
2
MEM
74/514
M
M
y
x
M
F
MEM
X
Y
3
YE-OG
6/33
46 12
M
3
BK-YE
31/66 31/84
5
C34W043
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 95
Group 28 Ignition and control system
Engine management system, 4-Cyl. 1.6L Diesel 3:3
4/46
ECM
7/193
7/81
7/162
P
4/50
ETA
8/17
3Au
1
2
2
4
3
1
3
2
1
Au
Au
Au
Au
Au
1
3
5
4
2
Au
Au
Au
Au
1Au
2
3
4
5
GY
VT-BN
BU
BU
B:36
B:25
B:52
CAN
73/3163
BU
Au
Au
Au
Au
Au
Au
Au
Au
Au
BU-WH
BU-WH
73/3125
GN-BN
WH-BN
GY-OG
GY
GN-OG B:35
BU-BN
YE-VT
BU-GN
YE
GY
BU-WH
GY-OG
WH-OG
YE-BU
WH-VT
B:39
B:34
B:22
B:50
B:24
B:42
B:30
B:37
B:28
B:51
B:26
B:18
4 CYL D
1.6 L
B:9
B:6
7/8
3
1
2
GY-BN
BN
GN-BN
P
74/301
15
14
13
GY-BN
73/3145
GY-BN
BN
GN-BN
A:21
A:45
A:33
C33W038
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 96
Group 28 Ignition and control system
Engine management system, 4-Cyl. 2.0L Diesel 1:3
15/31
GN
30+
1
11B/30
2
1
11A/42
2
YE-GN
2/32
2
1
11B/33
1
2
R10
3
5
1
11B/41
2
1
2
11B/36
GY-BU
BU-BN
11B/38
2/22
2
1
111
2
2
2
11B/39
11B/37
VT-WH
WH
GY-BU
R13
5
3
11B/35
1
2
1
2
11B/40
8/111
8/197
53/800
WH
8/98
7/25
7/190
7/191
7/16
7/17
MAF
1
2
1
2
12Au
4/46
YE-BU
GN-OG
GY
-VT
74/317
3
2
1
GN-VT
GN-BU
VT-GY
GY
WH
WH-GN
YE-GY
YE-GY
BN
WH-BN
YE-GY
GY-VT
BK-YE
BN-GN
BU-GY
GN-OG
BU
YE-VT
GY-VT
YE-VT
GN-BN
1
2
1
2
1
2
3
GY-VT
Au
2
Au
YE-VT
1
Au
GN-WH
Au
Au
Au
Au
Au
5
4
1
2 3
A:39
A:19
A:63
B:92
B:93
B:87
B:88
A:89
A:100
A:101
B:36
B:21
B:6
A:37
A:56
A:35
A:54
B:2
B:17
B:20
B:19
B:4
B:5
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
ECM
CAN
4 Cyl D
2.0L
4/109
C1:1
17
YE-GN
2 1
BU
C2:10
GCU
C2:6
YE-BU
1 1
74/301
53/717
BU
74/307
BK-BU
C2:9
C2:5
BU-BN
VT-WH
1 1
BK-BU
C2:3
GY-VT
C2:2
53/722
7/15
2
BU
GY-BU
1
3
4
8/199
8/200
53/720
GY-BU
GY-BU
8/113
GN-BN
YE-GN
VT-BN
1
2
1
2
1
2
WH-OG
YE-OG
GY-BU
GN-BN BN-GN
5
6
B:91
B:11
B:26
B:65
B:66
B:57
Ag
Ag
Ag
Ag
Ag
74/307
YE-GN
9/38
BK-YE
73/3094
8/180
WH
VT-WH
6/197
21
Ag
1
2
3
M
7/138
P
7/165
P
BK-YE
BK-BU
BK-YE
7/82
2
1
BN-GN
1
Ag
2
Ag
3
Ag
3
Au
Au
1
Au
2
Au
4
3
4
7/232
P
7/174
dP
BN-BU
GY-BU
WH-GN
BU
BU-GN
WH-BN
GN-BN
73/3012
3
1
2
4
1
2
1
Au
2
Au
3
Au
WH-OG
GN
YE-GN
Au
BU
Au
GY-YE
BU
WH-BN
GY-OG
YE-OG
BN-BU
GY-BU
GN-OG
BK-YE
BK-YE
BK-YE
B:58
B:35
B:44
B:28
B:29
B:68
A:45
A:58
A:13
A:48
B:27
B:47
B:37
B:45
B:12
B:30
A:97
A:98
A:99
B:86
B:24
B:9
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
20/25
BK-YE
BK-YE
BU-BN
20/23
20/24
20/22
BU-BN
31/XX10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 97
A
B
C34W042
Group 28 Ignition and control system
Engine management system, 4-Cyl. 2.0L Diesel 2:3
4/46
ECM
CAN
4 CYL D
2.0 L
4/28
TCM
18
GY-BN
A:41
Ag
AUTO
AWF22
A:77
Ag
Ag
Ag
Ag
Ag
Ag
VT-BN
AUTO
GY-BN GY-BN
MAN
A:62
VT-BN
A:12
YE-OG
A:14
BU-WH
A:53
GN-BU
A:34
YE-GN
CAN
20
18
29
19
7
6
74/301
2
VT-BN
73/3064
VT-BN
15/31
74/301
VT-BN
1
11B/20
2
AUTO
VT-BN
32
AUTO
7/51
4
BU-WH
BK-WH
WH
3/284
2
RD
74/504
7/123
1
11B/17
2
GY-BN
42
Au
Au
Au
1
2
3
6
5
74/504
1
30+
2
1
3
BU-WH
18
17
2
1
GY-BK
MAN
BN-GN
MAN
WH-VT
MAN
GN
MAN
GN-OG
YE-OG
VT-GN
BU-RD
31
RD
C1:65
C2:41
C1:34
C1:52
C1:16
C1:5
C2:16
C2:34
C2:52
C2:58
BN-GN
2 5
4/56
2/31
R7
GN-VT
1
F20
2
RD
CEM
CAN
LIN
1
11B/27
2
C2:26
C2:76
YE-OG
1
2
RD-BU
C5:2 C1:45
1
F13
2
C2:45
VT-WH
11A/2
3/9
RD-WH
2
1
F22
2
C2:55
1
A
B
A:95
A:76
B:77
B:82
73/5072 73/5071
BU-BN
BU-BN
31/84
BK-BU
BK-BU
RHD
RHD
RHD
BK-BU
BK
LHD
LHD
BK-OG
31/7
BK-OG
LHD
74/507
WH
17 18
WH
BK-WH BK-WH
6/62
3
2
MEM
17 3
74/511
4/83
YE-OG
5
74/514
YE-OG
4
BK-YE
1
PEM
6
3
M
M
y
x
YE-GY
M
F
MEM
X
Y
6/33
WH-BN
46 12
BK-YE
M
3
5
BK-YE
31/66
C33W040
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 98
Group 28 Ignition and control system
Engine management system, 4-Cyl. 2.0L Diesel 3:3
15/31
11B/32
30+
1
2
31
11B/33:2
VT-GN
2/14
R11
2 5
7/21
8/114
1
3
2
Au
5
Au
4
Au
2
1
Au
Au
3
BN-GN
BN-BU
VT
GY-BU
BN-VT
WH-OG
VT-GN
WH-BU
A:85
B:38
B:8
B:23
B:70
B:71
B:13
B:39
B:62
4/46
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
6/73
73/3012
1
M
2
BK BK-YE
31/XX10
7/35
OLS
4/50
ETA
8/120
7/251
VAC
P
7/8
P
7/140
1
Ag
2
Ag
1
2
5
Au
6
Au
3
Au
3
P
2
1
BU-OG
GY-YE B:59
YE-VT
BU-GN
BU-WH
VT-WH
YE
BK-WH
BN-BU A:32
WH-RD
A:28
A:43
B:60
B:81
B:76
B:40
B:43
B:42
ECM
Ag
Ag
Ag
Ag
Ag
CAN
Ag
Ag
Ag
4 CYL D
2.0L
Ag
2
Ag
1
Ag
5
Ag
4
Ag
3
1
2
3
GY-BN
BN
GN-BN
7/248
74/301
P
15
14
13
1
Ag
Ag
2
Ag
3
3
1
2
8/6
8/7
8/8
8/9
GY-BU
BN-VT
VT
GN-BK
GN
BN-VT
WH-BU
YE-OG
3
6
GN-VT
5
VT-GN VT-GN
2
Au
Au
GY-BN
4
Au
GY-YE
1
3
6
GN-VT
5
Au
VT-GN
2
Au
4
Au
1
3
6
GN-RD
5
Au
GY-VT
2
Au
4
Au
1
3
6
GN-VT
5
Au
GY-VT
2
Au
4
Au
1
GY-BN
BN
GN-BN
GY-VT
GN-BN
YE-VT
73/3150
73/3152
GN-BU
YE-BU
GN-VT
73/3151
GY-YE
BU-OG
YE-WH
WH-GN
VT-GY
GN-VT
GY-VT
YE-OG
GN-BN
YE-OG
BU
YE-BU
YE-GN
B:72
B:73
B:14
B:83
A:11
A:78
A:50
A:49
A:42
A:23
A:47
B:22
B:33
B:89
B:90
B:31
B:32
B:53
B:54
B:80
B:79
B:50
B:49
B:85
B:84
B:34
B:51
B:18
B:94
B:95
B:52
B:25
A:4
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
C34W036
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 99
Group 28 Ignition and control system
Engine management system, 5-Cyl. Diesel 1:3
30+
15/31
1
11B/30
2
8/6
8/7
4/109
2/32
2
1
1
11A/42
1
2
2
11B/35
YE-GY
RD-VT
11 1 0 97 6
GCU
12 3 4 5
YE-BK
YE-BK
YE-BK
YE-BK
YE-BK
R10
3
5
1
1
2
2
11B/36
11B/41
BU
GN-BN
2/14:5
BU
BU-GY
73/3131
74/301 74/504
BU
9/32
1
1
1
1
2
2
2
11B/39
11B/38
-BU
GY
VT-WH
11B/37
VT-BK
73/3051
17 21
2
BK-BU
73/3108
VT-WH
VT-BK
BU BU
9/38
Au
Au
7
BU
1
BK-OG BK-OG
3
4
2
7/15
74/512
8/8
8/9
8/10
7/25
7/190
7/191
7/16
7/17
2Au
6
1
5
MAF
Au
Au
Au
73/3039
1
2
1
2
12Au
1
2
3
Au
Au
Au
Au
Au
1Au
2
1
2
1
2
1
2
1
2
Au
Au
Au
4
3
2
1
Au
Au
Au
Au
Au
Au
Au
Au
Au
GN-BN
YE-VT
GY-VT
YE-GY 7/191B
GY-VT
8/113
7/35
QLT
8/164
8/98
8/111
M
RD-VT
GY-VT
GN-BU
YE-BU
GY-YE
BU-OG
GY
VT-GY
GN-YE
YE-OG
BU
BU-RD
74/317
BN
VT-OG
2.4 L
BU-GY
YE-VT
BU
BU-RD
GN-BK
BU-BK
YE-GN
VT-GN
WH-OG
YE-RD
VT-GN
Ag
1
Ag
2
Ag
3
1
2
1Au
2
1
2
3
2
1
1
2AuAu
A
Ag
Ag
Ag
B
ECM
CAN
5 CYL D
4/46
A:25
Ag
A:1
Ag
A:73
Ag
A:49
Ag
A:27
Ag
A:3
Ag
A:26
Ag
A:2
Ag
A:74
Ag
A:50
Ag
YE-GY Au
GY-VT
A:56
A:40
A:62
A:29
A:53
A:31
A:32
A:63
A:79
A:5
A:24
A:85
A:60
A:61
A:84
A:82
A:91
A:44
A:46
A:58
A:67
A:69
A:93
A:45
A:8
A:9
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
GN-BN
YE-VT
GY-VT
1
Au
2
YE
BN-GN
BN-GN
BN-YE
GY-BU
GY-YE
BU-GN
GY-BU
YE-RD
VT-BK
Au
GY
VT-BK
GN-BU
1 1
1
20/22
20/23
20/24
8
74/512
GN-BN
31/68
1 1
20/25
BK-YE BK-YE
73/3094
20/26
31/XX10
TP 39272202 V70(08-), XC70(08-) & S80(07-) 2014 © Volvo Car Corporation 2013 100
C
C34W035