Uniflame Gbc1117wb, Gbc1117wrs Owner's Manual

Loading...

OWNER’S MANUAL

Outdoor LP Gas Barbecue Grill

Model No. GBC1117W Series

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

WARNING

FOR YOUR SAFETY:

1.Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

2.Read the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.

3.Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury or death.

4.This instruction manual contains important information necessary for the proper assembly and safe use of the appliance.

5.Read and follow all warnings and instructions before assembling and using the appliance.

6.Follow all warnings and instructions when using the appliance.

7.Keep this manual for future reference.

DANGER

If you smell gas -

1.Shut off gas to appliance.

2.Extinguish any open flame.

3.Open lid.

4.If odor continues, keep away from the appliance and immediately call your fire department.

Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death.

WARNING

FOR YOUR SAFETY:

1.Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.

2.An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

DANGER

Never operate this appliance unattended.

3AVE THESE INSTRUCTIONS FOR FUTURE REFERENCE

If you are assembling this unit for someone else,

GIVE THIS MANUAL TO HIM OR HER TO READ AND SAVE FOR FUTURE REFERENCE

Made from 75% Bagasse

(Environmentally Friendly Sugar

Cane Pulp By-product)

Table of Contents

Important Safeguards 0AGE %XPLODED 6IEW (ARDWARE 3 Assembly Instructions Installling LP Gas Tank 9 Insert and Secure LP Gas Tank 9 Connect LP Gas Tank 9 Disconnect LP Gas Tank 9 /PERATING )NSTRUCTIONS 9 Checking for Leaks 9 /PERATING -AIN "URNERS 9 Cleaning and Care Product Registration Limited Warranty Troubleshooting

4HE USE AND INSTALLATION MUST CONFORM WITH LOCAL CODES OR IN THE ABSENCE OF LOCAL CODES WITH EITHER THE National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2,or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, AS APPLICABLE

#ALIFORNIA 0ROPOSITION #OMBUSTION BY PRODUCTS PRODUCED WHEN USING THIS PRODUCT CONTAIN CHEMICALS KNOWN TO THE 3TATE OF #ALIFORNIA TO CAUSE CANCER BIRTH DEFECTS AND OTHER REPRODUCTIVE HARM

#ALIFORNIA 0ROPOSITION 7ASH YOUR HANDS AFTER HANDLING THIS PRODUCT

Manufactured in China for: Blue Rhino Global Sourcing, Inc

7INSTON 3ALEM .# 53! s WWW BLUERHINO COM

¥ "LUE 2HINO 'LOBAL 3OURCING )NC !LL 2IGHTS 2ESERVED

 

UniFlame® IS A 2EGISTERED 4RADEMARK OF "LUE 2HINO 'LOBAL 3OURCING )NC !LL 2IGHTS 2ESERVED

'"# 7?S /- %3

Outdoor LP Gas Barbecue Grill Model No. GBC1117W Series

DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

WARNING:

This grill is for outdoor use only, and shall not be used in a building, garage, or any other enclosed area.

Do NOT operate, light or use this appliance within ten (10) feet (3.05 m) of walls, structures or buildings.

For residential use only. This grill is NOT for commercial use.

This grill is not intended for and should never be used as a heater. TOXIC fumes can accumulate and cause asphyxiation.

This grill is safety certified for use in the United States and/or Canada only. Do not modify for use in any other location. Modification will result in a safety hazard.

Apartment Dwellers: Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a ten (10) foot (3.05 m) clearance from any structure. Do not use on or under balconies.

This grill is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in this LP gas grill is dangerous and will void your warranty.

LP gas Characteristics:

a.LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any LP gas product.

b.LP gas is explosive under pressure, heavier than air, and settles and pools in low areas.

c.LP gas in its natural state has no odor. For your safety, an odorant is added that smells like rotten cabbage.

d.Contact with LP gas can cause freeze burns to skin.

LP gas tank needed to operate. Only tanks marked “propane” may be used.

The LP gas tank must be constructed and marked in accordance with the Specifications for LP gas Cylinders of the U.S. Department of

Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

LP gas tank must be arranged for vapor withdrawal.

The LP gas tank must have a listed overfilling prevention device (OPD).

Only use LP gas cylinders equipped with a cylinder connection device compatible with the connection for outdoor cooking appliances.

The LP gas tank must have a tank collar to protect the tank valve.

Never use an LP gas tank with a damaged body, valve, collar, or footing.

Dented or rusted LP gas tanks may be hazardous and should be checked by your LP gas supplier prior to use.

The LP gas tank should not be dropped or handled roughly.

LP gas tanks must be stored outdoors out of the reach of children and must not be stored in a building, garage, or any other enclosed area. Your tank must never be stored where temperatures can reach over 125°F.

Do not insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury or death.

Do not block holes in sides or back of grill.

Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the relief valve and allow gas to escape.

Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane.

If grill is not in use, the gas must be turned off at the supply tank and disconnect.

Do not store a spare LP gas tank under or near this appliance.

Never fill the tank beyond 80 percent full.

A fire causing, serious injury or damage to property may occur if the above is not followed exactly.

Never attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home or house.

The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.

Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and common sense when testing for leaks.

Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol with this product.

Your grill has been checked at all factory connections for leaks. Recheck all connections as described in the “Operating Instructions” section of the manual, as movement in shipping can loosen connections.

Check for leaks even if your unit was assembled for you by someone else.

Do not operate if gas leak is present. Gas leaks may cause a fire or explosion.

You must follow all leak-checking procedures before operating. To prevent fire or explosion hazard when testing for a leak:

a.Always perform leak test before lighting the grill and each time the tank is connected for use.

b.No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.

c.Conduct the leak test outdoors in a well-ventilated area.

d.Do not use matches, lighters, or a flame to check for leaks.

e. Do not use grill until any and all leaks are corrected.

If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

Minimum clearance from sides and back of unit to combustible construction is 36 inches (91.4 cm). Do not use this appliance under any type of overhang or roof.

It is essential to keep the grill’s valve compartment, burners, and circulating air passages clean. Inspect grill before each use.

Do not alter grill in any manner. Any alteration will void your warranty.

Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.

Do not build this model of grill in any built-in or slide in construction. Ignoring this warning could cause a fire or an explosion that can damage property and cause serious bodily injury or death.

This grill should be thoroughly cleaned and inspected on a regular basis. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or leaks, the hose must be replaced prior to the appliance being put into operation.

Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified by the manufacturer.

Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The use of any part that is not factory authorized can be dangerous. Doing so will also void your warranty.

Do not operate this appliance without reading “Operating Instructions” in this manual.

Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).

Do not install or use in or on boats or recreational vehicles.

When cooking, fire extinguishing materials shall be readily accessible. In the event of an oil/grease fire, do not attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda.

Do not use grill in high winds.

Never lean over the grill when lighting.

Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

Do not leave grill unattended while preheating or burning off food residue on high. If grill has not been cleaned, a grease fire can occur that may damage the product.

Do not place empty cooking vessels on the appliance while in operation.

Use caution when placing anything on the grill while the appliance is in operation.

Do not attempt to move grill when in use. Allow the grill to cool before moving or storing.

LP gas tank must be properly disconnected and removed prior to moving this grill.

Storage of grill indoors is permissible only if the tank is disconnected, removed from the grill and properly stored outdoors.

Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

Do not attempt to disconnect the gas regulator from the tank or any gas fitting while the grill is in use.

Always place your grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.

Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

Keep all electrical cords away from a hot grill.

All electrical accessories (such as rotisserie) must be electrically grounded in accordance with local codes, or National Electrical Code, ANSI / NFPA 70 or Canadian Electrical Code, CSA C22.1. Keep any electrical cords and/or fuel supply hoses away from any hot surfaces.

After a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion, wear or cuts to the hose.

Failure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flame-up.

Never operate grill without heat plates installed.

Always use a meat thermometer to ensure food is cooked to a safe temperature.

Use protective gloves when assembling this product.

Do not force parts together as this can result in personal injury or damage to the product.

Never cover entire cooking area with aluminum foil.

Maximum load for side shelf is 22 lbs.

Deaths, serious injury or damage to property may occur if the above is not followed exactly.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

PAGE NO

3

For great recipes and tips, visit recipes.uniflame.com

 

 

 

Parts List

1

#OOKING 'RID

 

 

 

 

2

(EAT 0LATE

 

 

 

 

3

Temperature

 

Gauge*

 

 

4

Lid*

7"

723

 

 

 

 

 

5

Warming Rack

 

 

 

 

6

4OWEL "AR

 

 

 

 

7

4OOL (OOK

 

 

 

 

8

Left Side Shelf

 

 

 

 

9

Side Shelf

 

3UPPORT !

 

 

 

 

 

10

Side Shelf

 

3UPPORT "

 

 

11

Grill Body

7"

Assembly*

723

 

12

"URNER

 

 

 

 

13

Control Knob

 

"EZEL

 

 

 

 

 

14

#ONTROL +NOB

 

 

 

 

15

QCC Clip*

 

 

 

 

16

2EGULATOR (OSE

 

Assembly*

 

 

17

Lighting Rod

 

 

 

 

18

Right Side Shelf

 

 

 

 

19

"OTTLE #AP /PENER

 

 

 

 

20

Left Cart Frame

 

 

 

 

21

Front Cart Frame

7"

723

 

 

 

 

 

22

Right Cart Frame

7"

723

 

 

 

 

 

23

Grease Tray

 

 

 

 

24

,0 'AS 4ANK (EAT

 

Shield

 

 

 

 

 

25

Bottle Cap Cup

 

 

 

 

26

Base

 

 

 

 

27

LP Gas Tank

 

Retainer Bolt*

 

 

28

,OCKING 7HEEL

 

 

 

 

29

7HEEL

 

Exploded View

 

 

1

 

3

 

 

 

 

 

 

2

 

4

 

 

 

 

7

6

9

11

5

 

8

12

 

 

10

 

 

10

13

 

18

 

 

 

6

 

 

17

9

 

14

 

 

16

 

 

 

 

 

 

15

 

19

24

 

20

23

22

21

25

27

28

26

29

* Pre assembled

Hardware

A

3CREW

-X .ICKEL 0LATED 0HILLIPS 4RUSS (EAD

33 pcs

 

 

 

 

 

 

 

B

Wing Bolt

-X .ICKEL 0LATED

PC

 

 

 

 

 

 

 

C

Washer

.ICKEL 0LATED

PCS

 

 

 

 

 

 

 

Tools Required for Assembly (Included)

0HILLIPS (EAD 3CREWDRIVER PC

- 7RENCH

PC

Outdoor LP Gas Barbecue Grill Model No. GBC1117W Series

Assembly Instructions

1

DO NOT RETURN PRODUCT TO STORE.

 

2

Attach Wheels

For assistance call 1.800.762.1142 TOLL FREE 0LEASE HAVE

Note: ,OCKING WHEELS LOCATED IN BACK

YOUR OWNER S MANUAL AND MODEL NUMBER AVAILABLE FOR

 

REFERENCE

Note: The model number can be found on the back or side of the cart

ASSEMBLY

&OR %ASIEST !SSEMBLY

s 4O AVOID LOSING ANY SMALL COMPONENTS OR HARDWARE ASSEMBLE YOUR PRODUCT ON A HARD LEVEL SURFACE THAT DOES NOT HAVE CRACKS OR OPENINGS

s #LEAR AN AREA LARGE ENOUGH TO LAYOUT ALL COMPONENTS AND HARDWARE

s 7HEN APPLICABLE TIGHTEN ALL HARDWARE CONNECTIONS BY HAND FIRST /NCE THE STEP IS COMPLETED GO BACK AND FULLY TIGHTEN ALL HARDWARE

s &OLLOW ALL STEPS IN ORDER TO PROPERLY ASSEMBLE YOUR PRODUCT

4O COMPLETE ASSEMBLY YOU WILL NEED

s ,EAK $ETECTION 3OLUTION )NSTRUCTIONS ON HOW TO MAKE SOLUTION ARE INCLUDED IN THE h/PERATING )NSTRUCTIONSv SECTION OF this manual)

s 0RECISION &ILLED ,0 'AS 'RILL 4ANK WITH !CME 4YPE EXTERNAL THREADED VALVE CONNECTION GALLON SIZE

4YPICAL ASSEMBLY APPROXIMATELY ONE HOUR

 

 

 

3 Attach Left and Right Cart Frames

4 Attach Front Cart Frame

A

x 6

A

x 4

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

PAGE NO

 

 

For great recipes and tips, visit recipes.uniflame.com

 

 

 

 

 

 

 

 

 

 

 

 

 

 

5 Attach Bottle Cap Opener and Bottle Cap Cup

6 Attach Temperature Gauge and Lighting Rod

B

x 1

A

x 2

 

 

 

7 Attach Grill Body Assembly

 

8 Place Lighting Rod

A

x 4

C

x 4

 

 

 

Outdoor LP Gas Barbecue Grill Model No. GBC1117W Series

Assembly Instructions (continued)

9

Attach LP Gas Tank Heat Shield

10

Attach Towel Bars and Tool Hooks

 

Note: 4OOL HOOKS ARE ATTACHED TO BOTTOM OF LEFT SIDE SHELF

A

x 4

A

x 4

C

x 4

 

 

 

 

 

11

Attach Side Shelf Assemblies

12

Attach QCC Clip

Note: ,EAVE MM OF BOLT THREADS EXPOSED

 

A

x 8

C

x 4

A

x 1

 

 

 

 

Uniflame Gbc1117wb, Gbc1117wrs Owner's Manual

Contact 1.800.762.1142 for assistance. Do not return to place of purchase. For great recipes and tips, visit recipes.uniflame.com

 

 

 

 

Insert Warming Rack

13

Insert Heat Plates, Cooking Grids, Control Knobs

14

 

 

 

 

 

15 Insert Grease Cup

PAGE NO

Outdoor LP Gas Barbecue Grill Model No. GBC1117W Series

Assembly Instructions (continued)

16 Fold Side Shelves

Unfold Side Shelves

+ 16 hidden pages