Sony HXR-MC1500C, HXR-MC1500P, HXR-MC2000E, HXR-MC2000J, HXR-MC2000N Service Manual

SERVICE MANUAL

HXR-MC1500C/MC1500P/MC2000E/MC2000J/MC2000N/MC2000U

SERVICE NOTE (Check the following note before the service.)

Revision History

Published by Sony Techno Create Corporation

Sony Corporation

983454111.pdf

Ver. 1.0 2010.11

Digital HD Video Camera Recorder

The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.

Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.

9-834-541-11

US Model

Canadian Model

AEP Model

E Model

Chinese Model

Japanese Model

Ver. Date History Contents

S.M. Rev.

issued

1.0 2010.11 Official Release — —

2010K08-1

© 2010.11

HXR-MC1500C/MC1500P/MC2000E/

MC2000J/MC2000N/MC2000U

– ENGLISH –

1-1. POWER SUPPLY DURING REPAIRS
1-2. PRECAUTION ON REPLACING THE VC-614 BOARD
1-3. PRECAUTION ON REPLACING THE MS-452 BOARD
1-4. SELF-DIAGNOSIS FUNCTION
1-5. METHOD OF COPING WITH SHIFT LENS ERROR

‒JAPANESE‒

1-1. 修理時の電源供給について
1-2. VC-614基板交換時の注意
1-3. MS-452基板交換時の注意
1-4. 自己診断機能
1-5. シフトレンズエラーの対処方法

HXR-MC1500C/MC1500P/MC2000E/MC2000J/MC2000N/MC2000U

2-1

2. REPAIR PARTS LIST

Follow the disassembly in the numerical order given.

IDENTIFYING PARTS

Link

ACCESSORIES ASSEMBLY

(ENGLISH)

NOTE:

• -XX, -X mean standardized parts, so they may have some differences from the original
one.

• Items marked “*” are not stocked since they are seldom required for routine service.
Some delay should be anticipated when ordering these items.

• The mechanical parts with no reference number in the exploded views are not sup­plied.

• Due to standardization, replacements in the parts list may be different from the parts
specified in the diagrams or the components used on the set.

• CAPACITORS:

uF: μF

• COILS

uH: μH

• RESISTORS

All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable

• SEMICONDUCTORS

In each case, u: μ, for example:
uA...: μA... , uPA... , μPA... ,
uPB... , μPB... , μPC... , μPC... ,
uPD..., μPD...

(JAPANESE)

【使用上の注意】

• ここに記載されている部品は,補修用部品であるため, 回路図及びセットに付いてい
る部品と異なる場合があります。

• -XX,-Xは標準化部品のため,セットに付いている部品と異なる場合があります。

•*印の部品は常備在庫しておりません。

• コンデンサの単位でuFはμFを示します。

• 抵抗の単位Ωは省略してあります。

 金  被：金属被膜抵抗。
 サンキン：酸化金属被膜抵抗。

• インダクタの単位でuHはμHを示します。

• 半導体の名称でuA...,uPA..., uPB...,uPC...,uPD...等はそれぞれμA.. .,μPA...,μPB...,
μPC...,μPD...を示します。

The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.

Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.

• Color Indication of Appearance Parts
Example:
(SILVER) : Cabinet’s Color
(Silver) : Parts Color

qj MS-452 Board

2 Grip Belt Bracket (F)

4 Shoulder Pad Assy

qf Handle Plate (A)

qd Handle Plate (C)

qs Handle Assy

6 Frame (R)

3 Grip Base

5 Cabinet (R) Section

[Disassembly]
[Exploded View]

• MO-028 Board

• SP-053 Board

qh VC Block Section

[Disassembly]
[Exploded View]

• IF-171 Board

• MM-097 Board

• US-017 Board

• VC-614 Board

• FP-1149 Flexible Board

• FP-1176 Flexible Board

• FP-1180 Flexible Board

• FP-1214 Flexible Board

• FP-1296 Flexible Board

qk Cabinet (L) Section

[Disassembly]
[Exploded View]

• JS-037 Board

• JK-398 Board

qg Battery Panel Section

[Disassembly]
[Exploded View]

• BA-012 Board

• DC-114 Board

• HP-158 Board

q; Handle Cover Assy

• FP-793 Flexible Board

qa Handle Lower Cover

• MC-201 Board

1 Grip Section

[Disassembly]
[Exploded View]

• NS-023 Board

7 Lens Section

[Disassembly]
[Exploded View]

• CM-114 Board

• EC-004 Board

• LD-269 Board

• FP-1294 Flexible Board

• FP-1295 Flexible Board

9 View Finder/

LCD Panel Section

[Disassembly]
[Exploded View]

• BH-002 Board

• HI-079 Board

• RE-042 Board

• PD-427 Board

• FP-1293 Flexible Board

8 Microphone Holder

(93000) Assy

View Position

Right View

Left View

Front View

Bottom View

Top Vi ew

Back View

• Abbreviation
CH : Chinese model
CND : Canadian model
J : Japanese model

図面番号で部品を指定するときは基板名
又はブロックを併せて指定してください。

お願い

• 外装部品色表示
例：
 (SILVER) ：セットの色を表す。
 (Silver) ：部品の色を表す。

0

印の部品，または0印付の点線で囲ま
れた部品は，安全性を維持するために，
重要な部品です。
従って交換時は，必ず指定の部品を使用
してください。

HXR-MC1500C/MC1500P/MC2000E/MC2000J/MC2000N/MC2000U

2-2

NOTE FOR REPAIR

• Make sure that the flat cable and flexible board are not cracked of
bent at the terminal.

Do not insert the cable insufficiently nor crookedly.

• When remove a connector, don’t pull at wire of connector. It is possible
that a wire is snapped.

• When installing a connector, don’t press down at wire of connector.

It is possible that a wire is snapped.

• Do not apply excessive load to the gilded flexible board.

Cut and remove the part of gilt
which comes off at the point.
(Be careful or some

pieces of gilt may be left inside)

NOTE FOR DISCONNECTING THE HARNESS (COAXIAL CABLE)

When disconnecting the harness (COAX IAL CABL E ), do not pull the
harness part but pull off the connector body with tweezers etc.

Harness
(coaxial cable)

Tweezers etc.

– JAPANESE –

– ENGLISH –

修理時の注意

• フラットケーブルおよびフレキシブル基板の端子面に欠け，折れ等
がないことを確認する。

 また，コネクタへの接続は，差し込み不足や斜め差しにならないよ

うに注意する。

• コネクタを取り外す時に，線材部（極細）を持って引っ張ると断線す
る恐れがありますので，絶対に線材部（極細）を持って引っ張らない
でください。

• 線材部（極細）を押さえながらコネクタを差し込むと，線材部（極細）
が断線する恐れがありますので，絶対に線材部（極細）には負担をか
けないでください。

• 金メッキされているフレキシブル基板には，強い負担をかけないで
ください。

వ┵ߩ೸߇ࠇߚࡔ࠶ࠠㇱߪࠞ࠶࠻ߒߡ
㒰෰ߒߡߊߛߐ޿ޕ
㧔ࡔ࠶ࠠ⎕ ߇ࠦࡀࠢ࠲ౝߦᱷߞߡ޿ࠆ
႐ว߽޽ࠆߩߢᵈᗧߒߡߊߛߐ޿㧕

ハーネス（同軸ケーブル）の交換について

ハーネス(同軸ケーブル)を引き抜く際は、ハーネス部を引かず、
ピンセット等でコネクタ部を引いてください。

ࡇࡦ࠮࠶࠻╬

ࡂ࡯ࡀࠬ
หゲࠤ࡯ࡉ࡞

HXR-MC1500C/MC1500P/MC2000E/MC2000J/MC2000N/MC2000U

2-3

2-1. EXPLODED VIEWS

2-1-1. OVERALL SECTION-1

Ref. No. Part No. Description

Ref. No. Part No. Description

1 3-284-044-01 BASE, GRIP
* 2 3-284-047-01 BRACKET (F), GRIP BELT
3 3-284-046-01 FRAME, GRIP
4 1-834-808-11 CABLE, FLEXIBLE FLAT (FFC-337)
5 X-2187-984-1 PAD ASSY, SHOULDER

6 4-263-650-11 SHEET (JAPAN)

(MC2000E/MC2000J/MC2000N/MC2000U)

6 4-263-650-21 SHEET (JAPAN) (MC1500C/MC1500P)

#37 3-080-206-31 SCREW, TAPPING, P2
#49 2-630-005-31 SCREW (M2), NEW TRUSTER, P2
#100 3-080-203-51 SREW (M2), LOCK ACE, P2
#103 7-685-794-09 SCREW +PTT 2.6X10 (S)
#104 7-682-548-09 SCREW +B 3X8

1. Remove to numerical order (1 to 5) in the left figure.

DISASSEMBLY

1 #100 X 3 → #37 X 4

Screw

#37

#100

#100

#100

#104

#100

#103

#49

#49

#37

1 Grip Section

(See Page 2-4)

5 Cabinet (R) Section

(See Page 2-5)

Overall Section-2
(See Page 2-6)

3 1

4 5

6

2

2 3

4

Be careful not to be break
the flexible flat cable.

Be careful not to be break
the flexible flat cable.

2 #103 X 4

Top View Right ViewLeft View

#100

#37

#100

Left View

#103

Right View

Bottom View Top View

#104

#49

#100

#100

5 #104 X 4 → #49 X 3 → #100 X 2

4 Two Screws (including Shoulder Pad Assy)

Bottom View

#37:M2.0 X 6.0 (Tapping)

(Black)
3-080-206-31

6.0

2.0

#49:M2.0 X 4.0

(Black)
2-630-005-31

4.0

2.0

#100: M2.0 X 6.0

(Black)
3-080-203-51

6.0

2.0

#103: M2.6 X 10.0

(Silver)
7-685-794-09

10.0

2.6

#104: M3.0 X 8.0

(Black)
7-682-548-09

8.0

3.0

HXR-MC1500C/MC1500P/MC2000E/MC2000J/MC2000N/MC2000U

2-4

2-1-2. GRIP SECTION

Ref. No. Part No. Description

Ref. No. Part No. Description

51 4-263-758-01 CABINET, GRIP
52 3-289-560-01 BELT, GRIP
53 1-480-479-11 SWITCH BLOCK, CONTROL (ZM90500)
* 54 4-263-759-01 BRACKET (B), GRIP BELT
55 1-487-447-11 SWITCH BLOCK, CONTROL (PS94000)

* 56 4-263-760-01 PLATE, SS RETAINER
57 A-1799-382-A NS-023 BOARD, COMPLETE

#37 3-080-206-31 SCREW, TAPPING, P2

Screw

A

A

51

52

#37

#37

#37

#37

53

55

56

54

57

Flexible board

Fold

#37:M2.0 X 6.0 (Tapping)

(Black)
3-080-206-31

6.0

2.0

HXR-MC1500C/MC1500P/MC2000E/MC2000J/MC2000N/MC2000U

2-5

2-1-3. CABINET (R) SECTION

ns : not supplied

Ref. No. Part No. Description

Ref. No. Part No. Description

101 3-283-972-01 RING, ORNAMENTAL
102 X-2560-614-1 CABINET (R) ASSY (925)

* 103 3-283-971-01 BRACKET (UPPER), LR
* 104 3-283-969-01 BRACKET, CHASSIS

105 1-834-807-11 CABLE, FLEXIBLE FLAT (FFC-336)

106 A-1799-370-A SP-053 BOARD, COMPLETE
107 A-1799-371-A MO-028 BOARD, COMPLETE

SP901 1-858-324-41 SPEAKER (1.6CM)

#37 3-080-206-31 SCREW, TAPPING, P2
#49 2-630-005-31 SCREW (M2), NEW TRUSTER, P2
#105 2-891-494-31 SCREW (M2), NEW TRUSTER, P2

Screw

#49

#37

#37

#37

ns

SP901

Reinforced plate side

Reinforced plate side

#105

MO-028

#37

101

102

103

104

105

106

107

#37:M2.0 X 6.0 (Tapping)

(Black)
3-080-206-31

6.0

2.0

#49:M2.0 X 4.0

(Black)
2-630-005-31

4.0

2.0

#105: M2.0 X 4.0

(Red)
2-891-494-31

4.0

2.0