Outdoor Leisure Products
Assembly and owner’s manual
Smoke Hollow Model
30168E
Important safeguards |
Warning |
|
|
Household type. |
Outdoor use only. |
Do not immerse in water . |
Keep extension cord connection dry |
Unplug from outlet when not in |
and off the ground. |
use before cleaning. |
Do not touch hot surfaces during use. |
Do not move smoker while unit |
Do not use smoker when raining. |
is hot. |
Read all of these instructions and |
|
keep them in a safe place for future |
|
reference. |
Failure to follow these instructions could result in fire, electric shock, personal injury or death.
Save this manual and read all instructions and warnings!
Warning
Read and follow all assembly and operating, care and maintenance instructions in this manual to avoid personal injury or property damage. The purpose of this symbol( )is to call your attention to possible hazards as you assemble and use your smoker. Please pay close attention to the information that follows the symbol.
¾This smoker is designed for outdoor use only. Do not operate this smoker indoors or in an enclosed area.
¾Keep this smoker away from swimming pools, hot tubs, etc. Do not use this smoker in the rain or on wet surfaces. if the smoker has been exposed to moisture can result in electric shock.
¾To protect against electrical shock do not immerse cord, controller, plug or heat element in water or any other liquid.
¾Do not touch hot surfaces, Use handles or knobs,Do not leave smoker unattended when in use.
¾Smoker should be placed in an area where children and pets cannot come into contact with it. When in use, close supervision should be used.
¾To prevent accidental electric shock, this smoker should always be used on a GFCI (Ground Fault Circuit Interrupter) outlet or circuit.do not plug this appliance into an indoor circuit.
¾Always use a 3-wire grounded outlet wired for 120 volts which is GFCI protected at 15 or 20 amps. If in doubt, contact a qualified electrician. Do not operate any other appliances or electrical devices on the same circuit as the smoker.
¾Proper clearance of 5 feet between the smoker and combustible material should be maintained at all times when this smoker is in use.
¾Do not place on or near a hot gas or electric burner, or in a heated oven.
¾Use smoker on hard, level, non-combustible, stable surface (concrete, ground, etc.). Never use smoker on wooden or other surfaces that could burn.
¾A drip pan, ash guard or mat designed for use with smokers for easy clean up of drippings that can cause discoloration or surfaces will not prevent fires from occuring on wooden or other combustible surfaces.
¾For household use only. Do not use this product for other than its intended purpose.
¾Before plugging unit into electric outlet, smoker should be completely set up with wood in place, liquid in water pan and food on grills. Always unplug the cord from the outlet when finished cooking.
¾Smoker should be located in an outdoor area that is protected from the wind.
¾The use of accessory attachments not recommended by the appliance manufacturer may cause injuries
¾Do not use an extension cord unless absolutely necessary. If you must use an extension cord, the following precautions should be used:
Use the shortest length possible 12/3 or 14/3 grounded-type extension cord with a rating of at least 15 amps.
1
Save this manual and read all instructions and warnings!
Warning
The cord should be marked with suffix letter “W-A” and with a tag stating “Suitable for Use with Outdoor Appliances.”
Keep cord connection dry and off the ground. Do not allow cord to touch hot surfaces and place it in such a manner so it will not be tripped over or tugged on by children or pets.
¾ Do not operate this smoker if:
The cord or plug is damaged.
The electric element has been damaged in any manner.
The smoker has malfunctioned.
The smoker has been exposed to moisture or if grease and drippings were not cleaned from the element after each use. Refer to “Care and Maintenance” section of this manual.
The GFCI circuit trips when the electric element is plugged into the electric outlet.
¾Extreme caution must be used when moving an appliance containing hot oil or other hot liquids.
¾Use caution when reaching into or under smoker. Always wear oven mitts/gloves to protect your hands from burns. Avoid touching hot surfaces.
¾Use extreme caution when adding liquid to the water pan being careful not to spill any liquid onto the electric element. Follow instructions in “Adding Water During Cooking” section of this manual.
¾Water pan should always be used when smoking. Do not allow liquid in water pan to completely evaporate. Check water pan periodically and add water if level is low. Follow instructions in “Adding Water During Cooking” section of this manual.
¾Always attach plug to appliance first, then plug cord into the wall outlet,to disconnect,turn any control to “off”, then remove plug from wall outlet.
¾Unplug the smoker from electric outlet when not in use. Allow smoker to cool completely before cleaning. Make sure embers, coals or ashes are completely extinguished in a noncombustible metal container.
¾Do not use smoker if the electric element has been exposed to moisture. Do not clean electric element with a water spray or the like. Failure to adhere to this safety warning could result in the electric element shorting out and in some cases, exploding. Clean the electric element as instructed in the “Care and Maintenance” section of this manual.
¾Use caution when assembling or operating your smoker to avoid cuts and scrapes from sharp edges of metal parts.
¾Store the smoker indoors in a dry location that is out of the reach of children.
¾Use caution when lifting or moving the smoker to avoid strains and back injuries.
¾We recommend that you have a fire extinguisher designed for use with electrical appliances on hand. Consult your local authority to determine the proper size and type of fire extinguisher.
¾Failure to follow safety warnings and guidelines in this manual could result in personal injury or property damage.
2
Electric Smoker Assembly Instructions
Assembly Step 1- Identifying 30166E parts
Check your package contents for these parts, make sure you have all of the parts listed below. If not, please call us at 866-475-5180
Hardware bags(30168E): |
|
|
|
|
|
|
Heat indicator(1set) |
|
Name plate(1set) |
|
Air vent tube |
||
A: 1/4-20x5/8” bolts(8) |
D: 10-24 x1/2” bolts(2) |
C014 |
|
C021 |
|
(1 set) C015 |
Part no: C016 |
10-24 flange nuts (2) |
|
|
|
|
|
|
|
|
|
|
||
|
Part no: C019 |
|
|
|
|
|
B: 10-24 x1” bolts(2) |
E: 10-24 x3 1/4” bolts(2) |
|
10-24 flange nuts (2) |
||
10-24 lock washer (2) |
||
Part no: C017 |
||
Part no: C020 |
||
|
C:10-24x5/8” bolts(4) Part no: C018
Side handles (2pcs) C003
Cooking grids (3pcs) 340400A
Door handle and spacers (1set)C005
Wood chip box with lid (1 set) C006
Water pan (1pc) C007
Protective mesh
C008
Replacement door assembly(1set) C002
Heat element (1 set) C010
Controller (1 set) C009
3
Smoker cabinet (1 set) C001
Side rack supports (8pcs) 3A0800A
Grease cup (1pc) C012
Legs (4pcs)
C011
Loading...