Samsung SRL3928B, SRL39WEB, SRL3926B, SRL39NEB, SRL3916B Service Manual
...
FREEZER/REFRIGERATOR
Model : SRL3928B(A)/39WEB(A)
SRL3926B(A)/39NEB(A)
SRL3916B(A)/39NMB(A)
SRL3626B(A)/36NEB(A)
SRL3616B(A)/36NMB(A)
GREEN
FREEZER / REFRIGERATOR
1. Precautions
2. Product Specifications
3. Electrical part specifications
4. Setting Temperature
5. Circuit Diagram
6. Functions & Operating
7. Functions of
8. Circuit Descriptions
9. Diagnosis of disorder
10. Parts List
11. Disassembly &
12. PCB Circuit Diagram
Downloaded from www.Manualslib.com manuals search engine
1. Precautions
Warning : Please abide by the following precautions in order to conduct the maintenance procedures in a safety fashion.
1-1. Caution when you replacing compressor.
•Do not smoke. Remove all the possible ignition sources and then replace compressor in wellaired places.
•Don’t use welding machines if R600a refrigerant does not exposed.
•In the case of gas leakage, always open the windows.
•When cutting the SUCTION, DISCHARGE pipe of the compressor, always take caution of the inner pressure of the remaining gas.
1-2. Take out the power plug
• Always take out the power plug from the 
outlet when doing repairs.
1-3. Be careful of electric shocks
• When inspecting the circuit, don’t touch the 
battery charger and be careful of electric
shocks.
1-4. Use proper components
• Always use the component labeled in the 
service component chart when replacing
components for repairs.
1-5. Use proper tools
• Always use proper tools for repairs. If worn 
out tools are used, it would cause defects in
tuning and electrical contact, leading to accidents.
1-6. When doing repairs, inspect the POWER CORD or whether there is fire in the lead wire 
and make sure they are replaced.
1-7. Cutting of LEAD-WIRE
• For connecting the lead-wire that has been cut 
off, use soldering or connector and always
disconnect the vinyl tapes.
1-8. Check for disconnection
• After completing the assembly, always measure 
the disconnection resistance level, and turn on
the power after checking it is above 1MΩ .
1-9. Earth
• Check the status of earthing and repair the 
incomplete ones.
1-10. Be careful of children
• There is always the possibility of danger when doing repairs so make sure that children can’t come nearby.
Cleaning : After completing repairs, clean the surrounding area and the refrigerator and tell the consumer about the repairs being made.
This appliance contains a small amount of the refrigerant isobutane(R600a), a natural gas with high
environmental compatibility but which is also 
combustible. When transporting and installing the appliance, care should be taken to ensure that no parts of the refrigerating circuit are damaged.
Refrigerant squirting out of the pipes could ignite or cause an eye injury. If damage occurs nevertheless, avoid any flames or potential sources of ignition, and air the room in which the appliance is standing for several minutes.
•In order to avoid the creation of a flammable gas-air mixture if a leak in the refrigerating circuit occurs, the size of the room in which the appliance may be sited depends upon the amount of refrigerant used. The room must be 1m3 in size for every 8 g of refrigerant R600a inside the appliance. The amount of refrigerant contained in your particular appliance is shown on the identification plate inside the appliance.
•Never start up an appliance showing any signs damage. If in doubt, consult your dealer.
Refers to prohibition.
Refers to prohibition of dismantling.
Refers to prohibition of contact.
Refers to guidelines which have to be followed.
Refers to detaching the power plug from the outlet.
Refers to earth connection for preventing electric shocks.
Refers to possibility of death or serious injury of a person.
Warning
Refers to possibility of injury of a person or damage to
property.
Caution
Samsung Electronics |
2 |
Downloaded from www.Manualslib.com manuals search engine
2. Product Specifications
Model |
|
|
|
SR-L3928B(A) |
SR-L3926B(A) |
SR-L3916B(A) |
|||||
|
|
|
SR-L39NEB(A) |
SR-L39NMB(A) |
|||||||
|
|
|
SR-L39WEB(A) |
SR-L3626B(A) |
SR-L3616B(A) |
||||||
|
|
|
|
|
|
SR-L36NEB(A) |
SR-L36NMB(A) |
||||
Capacity |
Net |
Total |
345 |
350/325 |
350/325 |
||||||
(ISO) |
(Liter) |
Freezer |
104 |
104/104 |
104/104 |
||||||
|
|
Refrigerator |
241 |
246/221 |
246/221 |
||||||
Dimension |
Width(mm) |
|
595 |
595 |
595 |
||||||
|
Depth(mm) |
Recessed type |
631 |
631 |
631 |
||||||
|
Bar type |
663 |
663 |
663 |
|||||||
|
|
||||||||||
|
Height(mm) |
|
1920 |
1920/1820 |
1920/1820 |
||||||
Net weight (kg) |
|
|
76 |
76/73 |
76/73 |
||||||
Cooling technology |
|
|
No-frost |
|
No-frost |
|
No-frost |
||||
Freezer performance |
|
|
|
(4-STAR) |
|
|
(4-STAR) |
|
|
(4-STAR) |
|
|
|
|
|
|
|||||||
|
|
|
|
|
|||||||
Control&Display |
Temperature control type |
|
Electronic |
|
Electronic |
Semi electronic |
|||||
Temperature display type |
|
Digital |
|
Digital |
|
LED |
|||||
|
|
|
|
||||||||
|
Power off |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Super Freezer |
|
|
|
|
|
|
|
|
|
|
Function |
VAC |
|
|
|
|
|
|
|
|
|
|
|
ECO |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Alarming display for power failure |
|
|
|
|
|
|
|
|
|
|
|
Alarming melody for door open |
|
|
|
|
|
|
|
|
|
|
REFRIGERATOR COMPARTMENT |
|
|
|
|
|
|
|
|
|
||
Water dispenser(4.2L/Child lock) |
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
Shelf |
Tempered glass shelf |
|
Optional |
|
Optional |
|
Optional |
||||
|
Transparent plastic |
|
Optional |
|
Optional |
|
Optional |
||||
Vegetable/Salad bin(Moisture controller) |
2 |
2 |
2 |
||||||||
Interior lamp |
Incandescent lamp |
|
Optional |
|
Optional |
|
|
|
|||
|
Fluorescent lamp |
|
Optional |
|
Optional |
|
|
|
|||
Door storage |
Can-carry |
|
|
Optional |
|
Optional |
|
Optional |
|||
|
Door pocket |
Transparent/White |
|
Optional |
|
Optional |
|
Optional |
|||
|
|
Dairy pocket |
|
1EA |
|
1EA |
|
1EA |
|||
|
|
|
|
|
|
||||||
|
|
Deep bottle storage |
|
1EA |
|
1EA |
|
1EA |
|||
|
|
|
|
|
|
||||||
|
|
Egg tray |
|
1EA |
|
1EA |
|
1EA |
|||
|
|
|
|
|
|
||||||
FREEZER COMPARTMENT |
|
|
|
|
|
|
|
|
|
|
|
Drawer |
Transparent / White |
|
Optional |
|
Optional |
|
Optional |
||||
Ice tray |
Twist / Normal tray(2EA) |
|
Optional |
|
Optional |
|
Optional |
||||
Blowing agent |
|
|
|
Cyclo Pentane |
|
Cyclo Pentane |
|
Cyclo Pentane |
|||
Refrigerant |
|
|
|
|
R600a(65g) / R134a(155g) |
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
3 |
|
|
|
|
|
|
|
Samsung Electronics |
|||
Downloaded from www.Manualslib.com manuals search engine
3. Electrical part specification & standard
|
|
ITEM |
|
|
STANDARDS |
|
|
||||
|
|
|
|
|
|
|
|||||
|
|
|
|
|
SR-L3928B(A)/L39WEB(A), SR-L3926B(A)/L39NMB(A) |
|
|||||
|
|
Model |
SR-L3916B(A)/L39NMB(A), SR-L3626B(A)/L36NEB(A) |
|
|||||||
|
|
|
|
|
|
|
SR-L3616B(A)/L36NMB(A) |
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Power source |
230-240V/50Hz |
|
230V/50Hz |
|
220V/50Hz |
127V/60Hz |
|||
|
|
|
|
Model |
DK4A1Q-L1U |
|
DK172Q |
-L2U |
DK172P-L2U |
||
| <![if ! IE]> <![endif]>cycle |
|
|
(R600a) |
|
(R134a) |
(R134a) |
|||||
|
|
|
|
||||||||
Compressor |
starting type |
|
|
R.S.C.R |
|
|
|||||
| <![if ! IE]> <![endif]>Refrigeration |
|
|
Oil charging |
SUNISO-2GSD/265cc |
|
|
|
FREOL 15c/265cc |
|
||
|
|
|
|
|
|
|
|
|
|
||
Evaporator |
|
|
Split fin.Tube Type |
|
|
||||||
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
||
|
|
Condenser |
|
|
Natural Convection Type |
|
|
||||
|
|
|
|
|
|
|
|
|
|
||
|
|
Dryer |
|
|
Molecular Sieve XH-9 |
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Capilary tube |
|
|
I.D 0.75 |
L4,000mm |
|
|
|||
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
Freezer |
|
|
502AT |
|
|
||
|
|
|
|
|
|
|
|
|
|
||
|
|
Sensor |
Refrigerator |
|
|
502AT |
|
|
|||
|
|
Defrost |
|
|
502AT |
|
|
||||
|
|
|
|
|
|
|
|
||||
|
|
|
|
Room TEMP. |
|
|
502AT |
|
|
||
|
|
|
|
Defrost |
310W/240V |
|
|
310W/220V |
310W/127V |
||
|
|
|
|
Lamp |
2W/240V |
|
|
2W/220V |
2W/127V |
||
|
|
Heater |
|
|
For Only Fluorescent Lamp |
|
|
||||
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
Disc-Duct |
7W/240V |
|
|
7W/220V |
7W/127V |
||
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
Suct-Duct |
15W/240V |
|
|
15W/220V |
15W/127V |
||
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
Cover-EVAP,RE |
7W/240V |
|
|
7W/220V |
7W/127V |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Fuse |
Defrost |
|
|
250V/10A, 72 4 |
|
|
|||
|
|
|
|
|
|
|
|||||
| <![if ! IE]> <![endif]>parts |
|
|
Defrost Time |
6 19hr(Vary According To The Environmental Conditions) |
|
||||||
|
|
|
|
|
|
|
|
|
|||
|
|
Defrosting |
4hr |
10min(At The First Operating Cycle) |
|
||||||
|
|
|
|
||||||||
| <![if ! IE]> <![endif]>Electrical |
|
|
Rest Time |
|
|
7min 2min |
|
|
|||
|
|
|
|
|
|
|
|
|
|
||
Over-Load |
Running |
350VAC/3.5 |
|
350VAC/5 |
250VAC/12 |
||||||
|
|
Capacity |
|
||||||||
|
|
|
|
Model |
4TM213PHBYY-53 |
|
4TM232SHBYY-53 |
4TM435PHBYY -53 |
|||
|
|
Protector |
On Temp |
69 |
|
|
69 |
|
69 |
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
Off Temp |
125 |
|
135 |
|
125 |
|
|||
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
||
|
|
PTC-Relay |
Model |
|
|
J531Q35E330M385-2 |
J531Q33E100M200-2 |
||||
|
|
|
|
|
|
|
|
|
|
||
|
|
Resistance |
|
|
33 |
20% |
10 |
20% |
|||
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
OSLAM DELUX S/E11W(Fluorescent Lamp) |
|
|||||
|
|
Lamp |
|
|
|
|
|
||||
|
|
Refrigerator |
|
KE257024025(240V/25W) |
(130V/25W) |
||||||
|
|
|
|
|
|
|
(Incandescent Lamp) |
(Incandescent Lamp) |
|||
|
|
|
|
|
|
|
|
||||
|
|
Damper(Ge- |
Freezer |
|
|
220 240VAC, 50/60Hz |
110VAC, 50/60Hz |
||||
|
|
ared)-motor |
|
MN71MNBA6(M2LA49Z) |
JX71MLBA6 |
||||||
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Door Switch |
|
|
H3005CL, 250VAC/25W |
|
|
||||
|
|
|
|
|
|
|
|
|
|
||
|
|
Motor Fan |
Freezer |
IS3210-SNL5C |
|
IS3210SNF7F |
IS3210SNP6C |
||||
|
|
|
|
|
|
|
|
|
|
|
|
Samsung Electronics |
|
|
|
|
|
|
4 |
||||
Downloaded from www.Manualslib.com manuals search engine
4. Setting Temperature of the Fridge/Freezer
|
|
|
|
|
ELECTRONIC |
SEMI-ELECTRONIC |
|
|||
|
|
ITEM |
|
|
|
|
|
|
||
|
|
|
SR-L3928B(A)/L39WEB(A) |
SR-L3916B(A)/L39NMB(A) |
||||||
|
|
|
|
SR-L3926B(A)/L39NEB(A) |
||||||
|
|
|
|
SR-L3616B(A)/L36NMB(A) |
||||||
|
|
|
|
SR-L3626B(A)/L36NEB(A) |
||||||
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
Type |
Type |
ON( |
) |
OFF( ) |
ON( |
) |
OFF( |
) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
-14 |
|
-20 |
|
|
|
|
Warm |
-14 |
|
-20 |
|
|
|
|
|
<![if ! IE]> <![endif]>Freezer |
|
|
-15 |
|
-21 |
|
|||
|
|
|
|
|
|
|
|
|||
|
F-Sensor |
|
|
|
|
|
|
|
|
|
|
Normal |
-18 |
|
-24 |
-17 |
|
-23 |
|
||
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
-20 |
|
-26 |
|
| <![if ! IE]> <![endif]>Temperature |
|
|
Cold |
-22 |
|
-28 |
|
|
|
|
|
|
|
-22 |
|
-28 |
|
||||
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
Type |
Type |
ON( |
|
OFF( |
ON( |
) |
OFF( |
) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
6.5 |
|
5.5 |
|
|
<![if ! IE]> <![endif]>Refrigerator |
|
Warm |
6.5 |
|
5.5 |
|
|
|
|
|
|
|
5.5 |
|
4.5 |
|
||||
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
||
|
|
F-Sensor |
|
|
|
|
|
|
|
|
|
|
Normal |
4.5 |
|
3.5 |
4.5 |
|
3.5 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
3.5 |
|
2.5 |
|
|
|
|
Cold |
1.5 |
|
0.5 |
|
|
|
|
|
|
|
|
2.5 |
|
1.5 |
|
|||
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
5 |
Samsung Electronics |
Downloaded from www.Manualslib.com manuals search engine
5. Circuit Diagram
5-1. ELECTRONIC MODEL(SR-L3928B(A)/L39WEB(A)/ SR-L3926B(A)/L39NEB(A)) for Fluorescent Lamp Option
DA68-00476A |
Samsung Electronics |
6 |
Downloaded from www.Manualslib.com manuals search engine
5-2. ELECTRONIC MODEL (SR-L3928B(A)/L39WEB(A)/L3926B(A)/L39NEB(A)/ SR-L3626B(A)/L36NEB(A)) for Incandescent Lamp Option
DA68-00476C |
7 |
Samsung Electronics |
Downloaded from www.Manualslib.com manuals search engine
5-3. SEMI-ELECTRONIC MODEL (SR-L3916B(A)/L39NMB(A)/ |
SR-L3916B(A)/L36NMB(A)) |
DA68-00476E |
Samsung Electronics |
8 |
Downloaded from www.Manualslib.com manuals search engine
6. Function & Operating Instruction
6-1. Product Dimension
MODEL |
A |
B |
C |
D |
HANDLE |
Remarks |
||
SR-L3928B/L39WEB |
1,920 |
1114.5 |
1,169 |
631 |
RECESS |
“Y” “Z” |
ELECTRONIC |
|
SR-L3926B/L39NEB |
1,920 |
1114.5 |
1,169 |
631 |
RECESS |
“Y” |
||
|
||||||||
SR-L3626B/L36NEB |
1,820 |
1014.5 |
1,169 |
631 |
RECESS |
“Y” |
SEMI |
|
SR-L3916B/L39NMB |
1,920 |
1114.5 |
1,169 |
631 |
RECESS |
“Y” |
||
ELECTRONIC |
||||||||
SR-L3616B/L36NMB |
1,820 |
1014.5 |
1,169 |
631 |
RECESS |
“Y” |
||
|
||||||||
SR-L3928A/L39WEA |
1,920 |
1114.5 |
1,169 |
663 |
BAR |
“Y” “Z” |
ELECTRONIC |
|
SR-L3926A/L39NEA |
1,920 |
1114.5 |
1,169 |
663 |
BAR |
“X” |
||
|
||||||||
SR-L3626A/L36NEA |
1,820 |
1014.5 |
1,169 |
663 |
BAR |
“X” |
SEMI |
|
SR-L3916A/L39NMA |
1,920 |
1114.5 |
1,169 |
663 |
BAR |
“X” |
||
ELECTRONIC |
||||||||
SR-L3616A/L36NMA |
1,820 |
1014.5 |
1,169 |
663 |
BAR |
“X” |
||
|
||||||||
|
|
|
|
|
|
|
|
|
9 |
|
|
|
|
|
Samsung Electronics |
||
Downloaded from www.Manualslib.com manuals search engine
6-2. Part Name & Disassembly
•Tray disassembly
Pull it out by following the arrow.
Take out food stuffs and pull it out by following the arrow.
Take out the water bottle with the bottom latch pressed.
• Ice compartment |
• Vegetable/Salad |
• Freezer compartment |
|
compartment |
|
Samsung Electronics |
10 |
Downloaded from www.Manualslib.com manuals search engine
6-3. Circulation of Refrigerant
Compressor 
Back cluster pipe 
Cluster pipe 
Hot pipe 
Dryer 
Capillary tube 
Evaporator 
Accumulator 
Suction pipe 
Compressor
11 |
Samsung Electronics |
Downloaded from www.Manualslib.com manuals search engine
6-4. Cool Air Circulation
Samsung Electronics |
12 |
Downloaded from www.Manualslib.com manuals search engine
7. Functions of Refrigerator
7-1. 7-Segments Display Function
Section |
|
|
Function |
|||
|
|
|
|
|
||
Initial POWER |
|
Notch setting |
Blink setting temperature of freezer until temperature reaches below |
|||
ON (Power s/w, |
|
(YES) |
TFSET_ON +3 |
|||
instantaneous |
|
Notch setting |
-- displayed (until the notch control is operated) |
|||
electricity failure) |
|
(NO) |
||||
|
|
|
|
|||
|
|
|
|
|
||
Stabilization of the temperature in |
Blink if temperature goes above TFSET_ON +3 . |
|||||
the freezer (Since the setting |
||||||
Display the setting temperature if the temperature goes below TFSET_ON +2 |
||||||
temperature have reached) |
||||||
|
|
|
||||
|
|
|
|
|
||
|
|
|
Display Blinking continuously ignoring temperature of freezer if displayed state of freezer before |
|||
Defrosting |
defrosting was |
Blinking . Display Setting temperature of freezer continuously ignoring temperature of |
||||
freezer if displayed state of freezer before defrosting was Setting temperature of freezer . |
||||||
(precooling+defrosting+pause) |
||||||
|
|
|
Maintain temperature constantly while it reaches TFSET_OFF point When you return to the operating |
|||
|
|
|
cycle. |
|
|
|
|
|
|
|
|
||
Super |
|
Blink if temperature goes above TFSET_ON +3 |
||||
|
Display the setting temperature if the temperature goes below TFSET_ON +2 |
|||||
|
|
|
||||
|
|
|
|
|||
Forced freezing |
Display “ |
”(Forced Freezing) |
|
|||
|
|
|
|
|
||
Forced defrosting |
Display “ |
”(Forced Defrosting) |
||||
|
|
|
|
|
||
|
|
|
If you push “REF. TEMP.” button indicative LAMP of refrigerator starts to |
|||
Display function of the |
light up and blink the setting temperature of refrigerator. |
|||||
If you do not input the KEY, it is blinked 5 times for 5 seconds at 0.5- |
||||||
temperature of refrigerator |
||||||
second interval and automatically converted to the displayed state of |
||||||
|
|
|
||||
|
|
|
setting temperature of refrigerator. |
|||
|
|
|
|
|
||
|
|
|
If you push “FRE. TEMP.” button indicative LAMP of freezer starts to light |
|||
Display function of |
up and blink the setting temperature of freezer. |
|||||
If you do not input the KEY, it is blinked 5 times for 5 seconds at 0.5- |
||||||
the temperature of freezer |
||||||
second interval and automatically converted to the displayed state of |
||||||
|
|
|
||||
|
|
|
setting temperature of freezer. |
|||
|
|
|
|
|
|
|
References |
|
|
|
|
||
1)TFSET-ON : “Setting temperature of freezer +3
”
2)TFSET-OFF : “Setting temperature of freezer -3
”
7-2. Function of Thermostatic Control
A.Function of controlling the temperature of freezer
1)You can control the temperature of freezer from -17
to -25
at 1
interval by pushing the control button of the temperature of freezer.(FRE. TEMP.)
2)Temperature is displayed in following order -19
-20
-21
-22
-23
-24
-25
-17
-18
whenever you push the control button of temperature.
3)The temperature of freezer is automatically set to be
-19
on initial POWER ON.
Section |
Power |
1 time push |
2 time push |
3 time push |
4 time push |
5 time push |
6 time push |
7 time push |
8 time push |
9 time push |
|
|
|
|
|
|
|
|
|
|
|
7 Segment |
|
–19˚C |
–20˚C |
–21˚C |
–22˚C |
–23˚C |
–24˚C |
–25˚C |
–17˚C |
–18˚C |
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
Controlled |
|
–19˚C |
–20˚C |
–21˚C |
–22˚C |
–23˚C |
–24˚C |
–25˚C |
–17˚C |
–18˚C |
temperature of freezer |
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
13 |
|
|
|
|
|
|
|
Samsung Electronics |
||
Downloaded from www.Manualslib.com manuals search engine
B.Function of controlling the temperature of refrigerator
1) You can control the temperature of refrigerator from 6
to 1
at 1
interval by
pushing the control button of the temperature of refrigerator.
2) Temperature is displayed in following order 4
3
2
1
6
5
whenever you push the control button of temperature.
3) The temperature of refrigerator is automatically set to be
4
on initial POWER ON.
Section |
power on |
1 time push |
2 time push |
3 time push |
4 time push |
5 time push |
6 time push |
note |
|
|
|
|
|
|
|
|
|
7 Segment |
|
4˚C |
3˚C |
2˚C |
1˚C |
6˚C |
5˚C |
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
Controlled |
|
4˚C |
3˚C |
2˚C |
1˚C |
6˚C |
5˚C |
|
temperature of freezer |
|
|
||||||
|
|
|
|
|
|
|
|
C.SUPER Function
1)Press “SUPER” button briefly so that the LED lights up. The Freezer temperature will decrease and the appliance will switch to the lowest temperature.
2)The displayed state is circulated in following order, SUPER is selected 
SUPER is released
SUPER is selected, whenever you push the SUPER button one time.
Section |
Initial power on |
1 time push |
2 time push |
note |
|
|
|
|
|
Dispaly change |
“SUPER” |
“SUPER” |
“SUPER” |
|
Lamp off |
Lamp ON |
Lamp off |
|
|
|
|
|||
|
|
|
|
|
3)If you select the ECO function while SUPER function is working, SUPER function is released and ECO function begins to work.
4)If you select SUPER function, Compressor(and Fan) will be operating continuosly until the temperature of freezer reaches -25
. (10 seconds after selection)
5)If the temperature does not reach -25
after working for 2 hours, compressor will be turned off automatically for 25minutes, and then compressor will be turned on antomatically until the temperature of freezer reaches -25
and this function will repeat for 8 hours.
6)If the commencing condition of defrosting is reached during super function, a defrosting cycle will be postponed until the next 25minutes delay time.
D.ECO Function
1)You can select or release this function by pushing the ECO button.
2)If you select the SUPER function while ECO function is working, ECO function will be released and SUPER function will begin to work.
3)If you select the function of controlling the temperature of freezer compartment or fresh food compartment while ECO function is working, ECO function will be released.
4)If you select the ECO function, the temperature of freezer and refrigerator will be controlled as -17
and 6
, respectively.
E.VACATION Function
1)You can select or release this function by pushing the VAC button.
2)If you select the VAC function, the temperature of refrigerator will not be controlled and DAMPER will be maintained as closed state. So that, cool air will not be supplied to the refrigerator.
3)VAC function does not affect setting up of the temperature of freezer.
4)If you push the button of controlling the temperature of refrigerator while VAC function is working, VAC function will be released automatically.
Samsung Electronics |
14 |
Downloaded from www.Manualslib.com manuals search engine
7-3. Initial Function
A.Initial function of first POWER ON
1)If power is pressed (POWER S/W ON), it will begin to make a self diagnosis and light all DISPLAY for 2 seconds if normal condition is confirmed
2)After lighting DISPLAY ON, 7-Segment will be displayed as
-- .
3)Defrosting HEATER is set to be ON forcibly for 3 seconds irrespective of the evaporator temperature.
4)After turning the defrosting HEATER ON for 3 seconds, turn off the defrosting HEATER and turn COMP. ON and keep it up for 5 minute irrespective of temperature of refrigerator.
5) After turning COMP. ON, operate DAMPER-MOTOR for control of refrigerator and confirm the zero point and 60Hz/50Hz and then control as considering the temperature condition of refrigerator.
6)At this moment, if it does not confirm the zero point due to the disorder of the some part of DAMPER-MOTOR, COMP. will be stoped immediately and display self diagnosis.
7-4. Defrosting Function
A. Common function
1) The period of defrosting is |
set to be 19 |
hours according to the COMP intergrated criterion. |
||
Previous standard means |
the following |
conditions : frequency of |
opening and closing of the DOOR |
|
of refrigerator must be less than one time, the |
temperature of refrigerator and the temperature of |
|||
freezer did not increase above TRSET ON+6 |
and TFSET ON+4 |
, respectively and special |
||
functional button (VAC,SUPER,ECO)was |
not selected. Besides the predescribed condition, |
|||
the period of defrosting will be 6 hours and 50 minutes unconditionally.
2)If power is turned off and then is turned on again, the commencement of defrosting will be after 4 hours of the running time of compressor.
3)The COMP and FAN during defrosting, will stop and DAMPER-MOTOR will swing continuously.
4)At a pause time, DAMPER-MOTOR.
5)With the exception of 19 hours in the period of defrosting, will also swing the Pre_Cooling will be executed by operating the COMP forcibly for 50 minutes before execution of defrosting.
6)You are recommended to have a pause time after completion of HEATING.
7)The HEATING for defrosting will be controlled by SENSOR. If SENSOR is out of order or the temperature of EVAP is higher than HEATER ON temperature, HEATING will be skipped and ref only has a pause time.
B.Defrosting Function while SUPER function is working
1)The operation of defrosting while SUPER function is working will be delayed until the compressor running time is to be 2 hours.
2)If the SUPER function is released by pushing the button before completion of SUPER function, the defrosting function will be operating including the worked time of COMP. operation which was worked by SUPER function.
3)If SUPER function is selected while defrosting function is working, DISPLAY will be set to be SUPER ON condition immediately, but SUPER function will be working after completion of defrosting function.
C.HEATER ON/OFF during defrosting
1)The temperature of defrosting HEATER ON
|
General defrosting |
Forced defrosting |
|
|
|
Note |
|
|
|
|
|
|
|
|
|
|
|
|
below -5 |
below -5 |
|
|
Same under all defrosting condition |
|||
|
|
|
|
|
|
|
|
|
|
2) The temperature of defrosting HEATER OFF |
|
|
|
|
|
||
|
Section |
6 hours and |
|
19 hours |
|
4 hours |
Note |
|
|
50 minutes |
|
|
|||||
|
|
|
|
|
|
|
|
|
|
OFF |
12 |
|
12 |
|
|
12 |
|
|
|
|
|
|
|
|
|
|
|
OFF |
12 |
|
12 |
|
|
12 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
15 |
|
|
|
|
|
Samsung Electronics |
||
Downloaded from www.Manualslib.com manuals search engine
7-5. TEST Function
TEST function is for examination of product and PCB, process control and service.
After confirmation of function of product by selecting TEST S/W, You must reboot the POWER and operate self-diagnosis function.
A.Forced operating function
1)If you push REF. TEMP. and FRE. TEMP. button simultaneously for 5 seconds, COMP will begin to work immediately and 
will be displayed on the 7 SEGMENTS.
2)If the forced operation is selected, COMP. will work immediately without the delay of 5 minute. At this time, despite of running of defrosting the defrosting will stop.
3)If the forced operation is selected, COMP. will be working as PULL DOWN for 28 hours but the temperature of refrigerator will be controlled by REF. TEMP. button.
4)During the forced operation, SUPER function does not work. If you select the SUPER function, SUPER LAMP will be turned off immediately within 0.2 second after turning on the LAMP.
B.Forced defrosting function
1)If you push REF. TEMP. and FRE. TEMP. button simultaneously for 5 seconds only once during the forced defrosting, COMP will begin to set to be OFF and 
will be displayed on the 7 SEGMENTS.
2)If the temperature of evaporator sensor is below -5
during the forced defrosting, heating will not work and will begin to work as delay time immediately.
C.TEST release function
1)If you push REF. TEMP. and FRE. TEMP. button simultaneously for 5 seconds only once during the forced defrosting, the forced TEST function will be converted immediately to the previous temperature setting state immediately and 
will disappear on the DISPLAY.
7-6. The compensating function for electricity failure
A.NOTCH SAVE function
1) Whenever you push one of the SUPER, ECO, VAC, FRE.TEMP. and REF.TEMP. Button, the
current state will be saved and set to be the NOTCH and DISPLAY state which value was memorized
as the one at rebooting point of POWER, respectively.
2)If the evaporator temperature at the inititial POWER ON state is less than the general defrosting OFF temperature, a clause1) will begin to work. If the evaporator temperature at the inititial POWER ON state is above the defrosting OFF temperature, the NOTCH of FRE.TEMP. and REF.TEMP.
will be set to be -19
and 4
, and SUPER, ECO and VAC function does not selected.
Samsung Electronics |
16 |
Downloaded from www.Manualslib.com manuals search engine
Loading...