Pioneer PDPS-50 Service manual
PDP-S50
SPEAKER SYSTEM
PDP-S50 XIN/E5
ORDER NO.
RRV3471
This service manual is intended for qualified service technicians; it is not meant for the casual do-ityourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to
properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the
warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk
trying to do so and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to
cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 – Proposition 65
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2006
T – ZZM AUG. 2006 Printed in Japan
1
23
4
1.REASSEMBLY AND DISASSEMBLY PRECAUTIONS
A
The grille ASSY is attached to the baffle using double-sided
self-adhesive tape. To avoid damaging the cabinet, work with
the speaker on top of a blanket or similar, face the grille ASSY
When reattaching the grille ASSY, use double-sided self-adhesive tape in the locations shown in the diagram and press the
grille ASSY into place.
upward.
There is slot in the lower part of the speaker. To detach it, first
push up the lower part by inserting a screwdriver(-) into slot.
Taking care not to damage the grille and baffle, lift the grille a
LOCATIONS TO FIX DOUBLE-SIDED
SELF-ADHESIVE TAPE
little bit at a time with hand. Though they are attached tight at
center position, do more cafully.
GRILLE ASSY
B
(32)
Tape
(SEH1077 x2)
Slot
Tape
(SEH1094 x2)
Tape
(SEH1088 x2)
C
Screwdriver(-)
Grille ASSY
Baffle
D
*Be careful not to damage the grille ASSY by bending too much.
Grille ASSY
Baffle
E
Grille ASSY
Grille ASSY
(Back Side)
Baffle
Baffle
F
2
1234
PDP-S50
1
234
The woofer is attached to the baffle by 4 internal screws. To
detach it, first remove the baffle from cabinet by unfastening
external 16 screws. Then unfasten those screws. When attaching it, face its plus terminal downward.
When changing it, stick the felt(SED1123 4pcs.) on the specified position of the woofer frame.
16 SCREWS
(BPZ40P100FTB)
The tweeter is attached to the baffle by 2 internal screws. To
detach it, first remove the baffle from cabinet. Then unfasten
those screws. When attaching it, face its plus terminal (bigger
terminal) rightward.
A
B
Baffle
LOCATIONS TO FIX FELT
Felt
(SED1123)
C
D
E
Felt
(SED1123)
1
F
PDP-S50
2
3
4
3
Loading...