Philips GC3116 Service Manual

Steam Iron Elance

GC3116

Philips Domestic Appliances and Personal Care

Service Manual

PRODUCT INFORMATION

Features

- Colour Creamy Orange

- Careeza soleplate

- Tank capacity (300 ml)

- Steam rate (30 g/min)

- Shot of steam (75 g/min)

- Vertical steam (75 g/min)

- Permanent Anti-Calc

- Integrated cord winder

- Cord length : 2 m.

Safety Information

- This product meets the requirements regarding
interference suppression on radio and TV.

- After the product has been repaired, it should function
properly and has to meet the safety requirements and
legal regulations as officially laid down at this moment.

TECHNICAL INFORMATION

Voltage : 220 - 240 V
Frequency : 50 - 60 Hz
Power consumption : 1900 W

Water advice

Suitable for tap water use. However if the tap water in your
area is very hard, we advise you to mix it with a equal portion
of distilled water or to use distilled water only.

Cleaning of the Iron

Use only the Calc clean button for cleaning of the Iron.
Never use vinegar, starch or chemically descaled water.

Soleplate

Careeza is a multi layer chemical substance that gives an
excellent gliding over various fabrics and better care for the
garments.

Vertical Steam

When the iron is kept in a vertical position, the shot of steam
(S.O.S) button can be used to iron hanging fabrics such as
curtains.

Published by Philips Domestic Appliances and Personal Care Printed in the Netherlands © Copyright reserved Subject to modification

04/01

DISASSEMBLY ADVICE

GC3116

DIAL 1

BACKPLATE 2

CORD SET 4

BALL SWIVEL 5

Remove Screw A (1x)

Remove BACKPLATE 2
Remove Screw B (2x) cord clamping

INLAY 6

LAMP ASSY 10

FILLING DOOR 7

STEAM SLIDER 8

LAMP COVER 9

SOS KNOB 12

SPRAY KNOB 13

TANK SEAL 14

remove Screw A (1x)
remove BACKPLATE 2
remove Screw B (2x) cord clamping
remove INLAY 6

DOSING UNIT 15

remove Screw A (1x)
remove BACKPLATE 2
remove Screw B (2x) cord clamping
remove INLAY 6
remove Screw C (2x)
remove Screw D (2x)
remove DOSING UNIT 15

TANK 19

THERMOSTAT BUSH 20

remove Screw A (1x)
remove BACKPLATE 2
remove Screw B (2x) cord clamping
remove INLAY 6
remove Screw C (2x)
remove Screw D (2x)
remove DOSING UNIT 15
remove Screw E (2x)
remove HOUSING 16
remove Screw F (2x)
remove TANK 19

HEAT SHIELD 21

remove Screw A (1x)
remove BACKPLATE 2
remove Screw B (2x) cord clamping
remove INLAY 6
remove Screw C (2x)
remove Screw D (2x)
remove DOSING UNIT 15
remove Screw E (2x)
remove HOUSING 16
remove Screw F (2x)
remove TANK 19
remove Screw G (1x)
remove HEAT SHIELD 21

COVER 22

SOS SEAL 23

DOSING SEAL 24

SOLEPLATE ASSY 25

HOUSING 16

RATTLE SPRING 17

PUMP ASSY 18

remove Screw A (1x)
remove BACKPLATE 2
remove Screw B (2x) cord clamping
remove INLAY 6
remove Screw C (2x)
remove Screw D (2x)
remove DOSING UNIT 15
remove Screw E (2x)
remove HOUSING 16

remove Screw A (1x)
remove BACKPLATE 2
remove Screw B (2x) cord clamping
remove INLAY 6
remove Screw C (2x)
remove Screw D (2x)
remove DOSING UNIT 15
remove Screw E (2x)
remove HOUSING 16
remove Screw F (2x)
remove TANK 19
remove Screw G (1x)
remove HEAT SHIELD 21
remove Screw H (2x)
remove COVER 22

2-4