Oreck BB1005 User Manual

73063-01 REV B
SIMPLY AMAZING
®
USERS GUIDE
COMPACT
CANISTER
VACUUMS
B
B
B
B
1
0
0
5
•IMPORTANT•
SAVE THIS BOOKLET!
Includes:
• Safety Warnings
• Parts List
• Operating Instructions
• Maintenance
• Warranty
• Trouble Diagnosis
• Accessories List
2 31 4 5
6
7
12
17
8 9
13
14 15 16
10
18 19 20
11
1
BEFORE OPERATING CLEANER, READ ALL
INSTRUCTIONS IN THIS
MANUAL CAREFULLY.
Table of Contents
Safeguards, Important Electrical Information,
mportant Safety Instructions . . . . . . . . . . . . . . . . . . . . page 5-2
I
Warranty, Parts List, Accessories . . . . . . . . . . . . . . . . . page 5-3
Assembly, Polarized Plug Notice, To Operate,
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . page 5-4
Maintenance & Customer Service,
Troubleshooting Guide . . . . . . . . . . . . . . . . . . . . . . . . . page 5-5
Safeguards
The fuse carrier is red and hinged to the plug. Do not use the plug if it is different.
If necessary, you may contact customer service for replacement fuse covers.
MOTOR PROTECTION SYSTEM: If fine materials such as soot, cement, plaster dust, copy machine powder, etc. are picked up, the bag surface may seal and cause the motor to shut off to avoid over-heating. If this happens, turn the switch off then turn off the wall socket and/or unplug the cleaner. Replace filter bag. Check and clear any clogs in hose or accessories. After approximately 30 min. the motor will have cooled and the cleaner will be ready to use.
Note: The cleaner must remain unplugged for 30 minutes for motor to cool and system to reset.
IMPORTANT
SAFETY INSTRUCTIONS
When using an electrical appliance, basic
precautions should always be followed,
including the following:
READ ALL INSTRUCTIONS BEFORE
USING THIS V
ACUUM CLEANER
WARNING: Unplug cord from electrical outlet before servicing.
IMPORTANT: Make sure filter bag is in place. Do not operate cleaner without filter bag. Damage to motor may occur.
• Be sure bag gasket is in place. If the white bag gasket is damaged or lost, replace at once.
• For best results, change disposable filter bag regularly even if it is not completely full. An extremely dirty bag or a bag close to full will affect the suction of the cleaner and can create excessive motor heat that could damage the motor. A good practice is to change filter bag every 30 days even if it is not full.
• Do not pick up moist material or liquids.
• Clean your vacuum cleaner with a damp (not wet) cloth in the disposable bag cavity and the outside of canister unit.
IMPORTANT: DO NOT REMOVE the dirt retaining flap
• attached on the back of the front plate. It must be left in place for the unit to operate properly and to ensure cleaning
fectiveness.
ef
Important Electrical Information
The wires in the main lead are coloured in accordance with the following code:
Blue - Neutral Brown - Live
If the colours of the wires in the main lead of this appliance do not correspond with the coloured markings identifying the terminals in your plug, proceed as follows:
The wire which is coloured blue must be connected to the terminal marked with the letter N or coloured black. The wire coloured brown must be connected to the terminal marked with the letter L or coloured red. Do not make any connection to the terminal marked E or or
coloured green and yellow.
This appliance is double insulated and no earth connection is necessary.
If you remove the plug from power supply cord, dispose of it. A shock hazard could result if incorrect plug is inserted into a 13
socket outlet.
AMP
or same size replacement
When changing fuse, use 5 fuse.
Never use the plug without the fuse cover fitted in place.
AMP
2
WARNING
To reduce the risk of fire,
electric shock, or injury:
• Do not leave appliance unattended when plugged in. Unplug from outlet when not in use and before servicing.
• Do not use outdoors or on wet surfaces.
• Do not allow to be used as a toy. Close attention is necessary when used by or near children.
• Use only as described in this manual.
• Do not use with damaged cord or plug. If appliance is not working as it should, has been dropped, damaged, left outdoors, or dropped into water, return it to a service center or call customer service at:
• Do not pull or carry by cord, use cord as a handle, close door on cord, or pull cord around sharp edges or corners. Do not run appliance over cord. Keep cord away from heated surfaces.
• Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.
• Do not handle plug or appliance with wet hands.
• Do not put any object into openings. Do not use with any opening blocked; keep free of dust, lint, hair and anything else that may reduce air flow
Keep hair
• away from openings and moving parts.
• Do not use to pick up anything that is burning or smoking, such as cigarettes, matches, or hot ashes.
• Do not use without filter bag assembly in place.
• Turn off all controls before unplugging.
• Use extra care when cleaning on stairs.
Do not use to pick up flammable or combustible
• liquids, such as gasoline, or use in areas where they may be present.
, loose clothing, fingers and all parts of body
0845 603 0153.
.
SAVE THESE INSTRUCTIONS
Household Use Only
W
arranty
ORECK MANUFACTURING COMPANY: (Oreck Manufacturing Company, 21180 Johnson Road; Long Beach, MS, USA 39560, gives you the following limited warranty for this product only if it was originally purchased for residential use, not resale from Oreck or an Oreck Authorized Retail Dealer.)
Oreck will repair or replace, free of charge, to the original purchaser, any part that is found to be defective in material or workmanship within three (3) years of the date of purchase; ten (10) years on housing. This limited warranty applies to normal domestic use. Any commercial use of this product will void this limited warranty.
This limited warranty does not cover the replacement of expendable or consumable parts such as belts, brushes, bulbs, disposable bags and other parts subject to normal wear unless they are defective in material or workmanship.
This limited warranty does not apply to any part subjected to accident, abuse, commercial use, alteration, misuse, damage caused by act of God, the use of voltages other than indicated on the serial number displayed on this product or service of this product by other than Oreck or a participating Factory Authorized Service Center.
Oreck does not authorize any person or representative to assume or grant any other warranty obligation with the sale of this product.
Oreck’s limited warranty is valid only if you retain proof of purchase from Oreck or an Oreck Authorized Retail Dealer for this product. If you purchase this product from any other source, your purchase is “AS IS,” which means Oreck grants you no warranty, and that you, not Oreck, assume the entire risk of the quality and performance of this product, including the entire cost of any necessary servicing or repairs of any defects.
This warranty in addition to your statutory and other legal rights.
*Reconditioned units carry a 6 month warranty from date of purchase.
Parts List
1. Adjustable shoulder strap
2. Long, extendable, flexible hose
3. Crevice tool
4. Upholstery tool
5. Horsehair bare floor and wall tool
6. Horsehair dusting brush
7. Adjustable extension wand
8. On-board tool caddy
9. Paper filter bags
10. Tool adapter tube for fitting tools directly to vacuum when
l HEPA filter (not shown) l Scent cartridge (not shown)
2
not using hose.
1
6
4
8
3
10
5
7
9
Accessories (Sold Separately)
Replacement Hypo-Allergenic Filter Bags (12 pk. with 1 Micro Filter)
Replacement Micro Filter Part No. 72005-01
Replacement HEPA Filter Part No. HF1000
Replacement White Bag Gasket
Wheel Kit Part No. 09-73069-01
Vinyl Tool Rack Part No. CADDYBB
Fresh Air®Scent Cartridges Notes of Vanilla
®
8pk. Part No. FA1PK Spring Mullberries®8pk. Part No. FA2PK Blooming Jasmine®8pk. Part No. FA3PK
To order new parts or accessories call:
0845 603 0153
3
Part No. PKBB12DW
Part No. 72017-02
Assembly
IMPORTANT: DO NOT
EMOVE the dirt
R retaining flap
ttached on the
a back of the front
late. It must be left
p in place for the unit to operate properly and to ensure
leaning
c effectiveness.
For Easy Cord Storage
fig. 12 Wrap cord around the cord wrap and cord dump located
on bottom of the canister. To release cord, twist the cord dump.
Blower Port
fig. 13 Remove HEPA Filter cover and filter at back of machine.
Firmly insert flexible hose into blower port.
Maintenance
WARNING: Unplug cord from electrical outlet before servicing.
Attach Caddy and Insert Tools
fig. 1 Locate caddy clip slots at top rear corners of canister
handle. Place appliance on firm, non-slip surface or hold in your lap. Grasp handle firmly. Place one of caddy clip tabs inside slot on one side of handle and stretch the other tab around handle until the opposite tab inserts in slot.
fig. 2 Insert crevice tool, brush and fabric tool into caddy in
spaces provided.
fig. 3 Caddy will lift up 90° to allow access to the HEPA filter
cover.
Attach Shoulder Strap
fig. 4 Clamp one end of shoulder strap in front slot located at
front of handle.
fig. 5 Clamp opposite end of shoulder strap in slot at back of
handle.
fig. 6 Adjust length by pulling strap through clip.
IMPORTANT: Before using shoulder strap, pull both ends to be
sure it is secure.
To Operate
Plug cord into electrical outlet.
Power Switch
fig. 7 Push power switch to “ON” (I) position.
Hose and Tool Installation
fig. 8 The flexible hose uses a Shurlock®locking system that
prevents hose removal unless intended. To install hose, align “J” slot in hose coupling with tab inside the suction port. Insert hose into suction port. Twist collar clockwise to lock hose coupling in port. Twist counterclockwise and pull to remove hose.
fig. 9 The adjustable extension wand and cleaning tools
supplied with your Oreck XL Compact Canister Vacuum lock together with friction. T lock tightly when installing. Twist and pull to remove.
fig.10 When installing tools directly to blower or suction port
without using hose, tool adapter tube must be used.
Adjustable Extension W
fig. 11T
o adjust extension wand, press release button and pull inner tube to desired length. Tube will lock when button is released. To shorten length, press release button and push inner tube.
and
wist and push to be sure they
Changing the Filter Bag
fig. 14 Use only genuine ORECK XL filter bags. Stand unit on
its back. Twist knob counterclockwise to release and lift out front plate.
fig. 15 Remove used bag and insert fresh bag. The cardboard
rim fits smoothly into the recessed top. Align tabs on front plate with slots in housing and replace the front plate. Close unit by turning knob clockwise.
fig. 16 IMPORTANT: The white bag gasket glued in the housing
must be in place or unit will not operate properly. Replace if needed.
NOTE: The disposable inner filter bag must be replaced once a
month even if it is not full. Change it more often if it is used in extremely dirty areas.
power of your vacuum by changing the bag often.
Replacing the Micro Filter
Remove filter bag by following the Changing the Filter Bag instructions.
fig. 17 Remove old micro filter from bottom inside unit. Replace
with new filter.
NOTE: A replacement filter is supplied in each package of 12
ORECK XL filter bags or you may order filters separately.
Using a HEPA-Filter and Scent Cartridge
fig. 18 Remove HEPA Filter cover at back of machine by
pressing down in top slot and folding back the cover. Lift cover to remove.
fig. 19 Insert Fresh Air®Scent Cartridge on tab located in center
of the filter cover.
fig. 20 Place the HEPA Filter in the filter cover.
fig. 18 Replace the HEPA Filter assembly on the canister by
placing the bottom lip of the cover in the inside slot of the canister and closing the cover until the top latch is locked.
NOTE: It is recommended to replace the scent cartridge when
the inner filter bag is replaced.
Replace the HEPA often if vacuum is used to pick up fine particles or in extremely dirty areas.
4
filter every
Increase the cleaning
6 months. Replace more
Maintenance and Customer Service
our ORECK COMPACT CANISTER VACUUM is a product of
Y precise engineering. The motor bearings are permanently
ubricated and should not be oiled. If you require additional
l information or have problems with your ORECK appliance, you may call ORECK customer service or write to:
elephone: 0845 603 0153
T
Oreck UK P.O. Box 107
xeter
E
X2 8ZQ
E Attention: Oreck Customer Service
Please specify the model number and serial/code number which can be found on the data plate on the bottom of the vacuum.
Save your sales or purchase slip. Should your ORECK appliance require warranty service in the U.S.A., present this slip to the Authorized Service Center as your proof of purchase date, or, in Canada, call customer service.
Troubleshooting Guide
PROBLEM POSSIBLE SOURCE AREASTOCHECK
Cleaner Will Not Run
acuum W
V Not Pick Up Or Has Low Suction
ools/Wands
T
ill Not Stay
W Together
ill
1.Not plugged in properly
2.No electricity in wall outlet.
3.Motor protector tripped.
4.Needs service.
1.Filter bag is full.
2.Hose/wand tool is clogged.
3.Air leak due to missing or damaged gasket.
1.Proper friction fit not being obtained.
1. Be sure cleaner is firmly plugged into wall outlet.
2. Check electrical source–fuse or circuit breaker.
3. See Motor Protection System page 2.
4. Take to service center or call for nearest service center.
1. Replace filter bag. See “Changing the Filter Bag,” page 4.
2. Remove obstructions.
Replace gasket
3. See page 4.
1. Push and turn.
ALL OTHER SERVICING SHOULD BE DONE BY AN ORECK AUTHORIZED SERVICE CENTER.
CALL CUSTOMER SERVICE HOT LINE
0845 603 0153
Whenever calling, please be sure to have your model and serial number from data plate.
5
6
73063-01 REV B 06/05 ECN# R-8022
2005 Oreck Holdings, LLC.
© authority of Oreck Holdings, LLC.
All rights reserved.
All word marks, logos, product configurations, and registered trademarks are owned and used under the
Loading...