Masterbuilt 20070112 Owner's Manual
ASSEMBLY, CARE & USE MANUAL
WARNING & SAFETY INFORMATION
COLD SMOKER MODEL 20070112
THIS PRODUCT IS FOR OUTDOOR USE ONLY
Masterbuilt Manufacturing, Inc.
1 Masterbuilt Ct.
Columbus, GA 31907
Customer Service 1-800-489-1581
www.masterbuilt.com
Manual Code: 9807100051 011212-04JH
Approximate assembly time : 10 minutes
Tools required for assembly: Phillips Head screwdriver, Wrench
CARBON MONOXIDE HAZARD WARNING
Burning wood chips gives off carbon
monoxide, which has no odor
and can cause death.
DO NOT burn wood chips inside homes,
vehicles, tents, garages or any enclosed areas.
Use only outdoors where it is
well ventilated.
This manual contains important
information necessary for the proper
and safe use of this unit.
Read and follow all warnings
and instructions before using
smoker and during use.
Keep this manual for future reference.
Some parts may have sharp edges;
handle with care.
Failure to follow these warnings and instructions properly could result in personal injury or death.
GENERAL WARNINGS AND SAFETY INFORMATION
READ ALL INSTRUCTIONS
When using electrical appliances, basic safety precautions should always be followed including
the following:
• For outdoor use only. Do not operate in an enclosed area.
• Unit MUST be on the ground. Do not place unit on tables or counters. Do NOT move unit across
uneven surfaces.
• Do not lift unit by lid handle.
LIMITED WARRANTY
Masterbuilt warrants its products to be free from defects in material and workmanship under proper
assembly, normal use and recommended care for 90 days from the date of original retail purchase.
Masterbuilt warranty does not cover paint fi nish as it may burn off during normal use.
Masterbuilt warranty does not cover rust of the unit.
Masterbuilt requires reasonable proof of purchase for warranty claims and suggests that you keep your
receipt. Upon the expiration of such warranty, all such liability shall terminate.
Within the stated warranty period, Masterbuilt, at its discretion, shall repair or replace defective components
free of charge with owner being responsible for shipping. Should Masterbuilt require return of component(s)
in question for inspection Masterbuilt will be responsible for shipping charges to return requested item.
This warranty excludes property damage sustained due to misuse, abuse, accident, damage arising out of
transportation, or damage incurred by commercial use of this product.
• Do not plug in cold smoker until fully assembled and ready for use.
• Use only approved grounded electrical outlet.
• Do not use during an electrical storm.
• Do not expose cold smoker to rain or water at anytime.
To protect against electrical shock do not immerse cord or plug in water or other liquid.
•
•
Do not operate any appliance with a damaged cord or plug, or after appliance malfunctions or has been
damaged in any manner. Contact Masterbuilt Customer Service for assistance at 1-800-489-1581.
• Keep a fi re extinguisher accessible at all times while operating cold smoker.
• Do not let cord touch hot surfaces if hanging.
• Do not place on or near a hot gas or electric burner, or in a heated oven.
eep children and pets away from electric smoker at all times. Do not allow children to use cold
• K
smoker. Close supervision is necessary should children or pets be in area where cold smoker is
being used.
• Fuel, such as charcoal briquettes or heat pellets, are not to be used in cold smoker.
• Never use cold smoker as a heater (READ CARBON MONOXIDE HAZARD).
• Use cold smoker only on a level, stable surface to prevent tipping.
• Cold smoker is HOT during operation and remains HOT for a period of time following use.
This expressed warranty is the sole warranty given by Masterbuilt and is in lieu of all other warranties,
expressed or implied including implied warranty, merchantability, or fi tness for a particular purpose.
Neither Masterbuilt nor the retail establishment selling this product, has authority to make any warranties or
to promise remedies in addition to or inconsistent with those stated above.
Masterbuilt’s maximum liability, in any event, shall not exceed the purchase price of the product paid by
the original consumer/ purchaser. Some states do not allow the exclusion or limitation of incidental or
consequential damages. In such a case, the above limitations or exclusions may not be applicable.
California residents only: Not withstanding this limitation of warranty, the following specifi c restrictions
apply; if service, repair, or replacement of the product is not commercially practical, the retailer selling the
product or Masterbuilt will refund the purchase price paid for the product, less the amount directly
attributable to use by the original buyer prior to the discovery of the nonconformity. Owner may take the
product to the retail establishment selling this product in order to obtain performance under warranty.
This expressed warranty gives you specifi c legal rights, and you may also have other rights which vary from
state to state.
Go Online www.masterbuilt.com
or complete and return to
Attn: Warranty Registration
Masterbuilt Mfg. Inc.
1 Masterbuilt Court - Columbus, GA 31907
• Do not touch HOT surfaces.
• Do not allow anyone to conduct activities around cold smoker during or following its use until
the unit has cooled.
The use of alcohol, prescription or non-prescription drugs may impair the user’s ability to properly
•
assemble or safely operate cold smoker.
WARNINGS & IMPORTANT SAFEGUARDS CONTINUED ON PAGE 2
1
Name: _________________________________Address :__________________________City:_______________
State/Province: ________ Postal Code: ________________Phone Number: (_____) - ____________
E-mail Address:_______________________________________
Model Number: ____________________ Serial Number: ____________________
Purchase Date: _____- ______-_______ Place of Purchase: ____________________________________
14
TROUBLESHOOTING GUIDE
SYMPTOM CAUSE POSSIBLE SOLUTION
GENERAL WARNINGS AND SAFETY INFORMATION
Power light wont come Not plugged into wall Check wall connection
House fuse or Ground Fault Circuit Interrupter (GFCI) tripped
Make sure other appliances are not
operating on the same electrical
circuit. Check household fuses or
reset (GFCI)
Unit malfunctioning Contact Masterbuilt at 1.800.489.1581
Unit takes excessive amount of
time to heat up (longer than 6070 min)
Unit plugged into an extension
cord
Set unit so an extension cord does
not have to be used
Lid not closed properly Close door securely
Unit malfunctioning Contact Masterbuilt at 1.800.489.1581
Smoker docking tube not
secured
Mount hook nut not tightened Tighten nut.
Mount hook threads stripped Contact Masterbuilt at 1.800.489.1581
No smoke No wood chips Add wood chips
Unit plugged into an extension
cord
Set unit so an extension cord does
not have to be used
Unit malfunctioning Contact Masterbuilt at 1.800.489.1581
Chip tube not resting properly into
grooves in unit
Wood chip screen not set properly, contacting unit element.
Check for wedged wood chips.
Reset wood chip screen properly on
chip tube
• Avoid bumping or impacting cold smoker when in use.
• Never move when attached to smoker or when smoker is in use. Allow cold smoker to cool
completely before moving or storing.
• To disconnect, turn switch to “OFF” position then remove plug from outlet.
• Unplug from outlet when not in use and before cleaning. Allow unit to cool completely before
adding/removing wood chip tube.
• Dispose of cold ashes by placing them in aluminum foil, soaking with water and discarding in a
non-combustible container.
• Do not store cold smoker with HOT ashes inside unit. Store only when all surfaces are cold.
• Accessory attachments not supplied by Masterbuilt Manufacturing, Inc. are not recommended
and may cause injury.
• The use of accessory attachments not recommended by the appliance manufacturer may
cause injuries.
• Never use cold smoker for anything other than its intended purpose. This unit is not for com-
mercial use.
• Always use cold smoker in accordance with all applicable local, state and federal fi re codes.
• Longer extension cords are available and may be used if care is exercised in their use.
Power light is on, unit isn’t heating
Element malfunctioning Contact Masterbuilt at 1.800.489.1581
WOOD SMOKING GUIDE FOR MEATS
WOOD FLAVOR POULTRY FISH HAM BEEF PORK LAMB
Hickory
Pungent, smoky, bacon-like fl avor
Mesquite
Sweet and delicate fl avor
Alder
Delicate, wood smoke fl avor
Pecan
Bold and hearty fl avor
Maple
Sweet, subtle fl avor
Apple
Sweet, delicate fl avor
• If a longer extension cord is used, the marked rating should be at least as great as the
electrical rating of the appliance.
• The extension cord must be a grounding -type 3-wire cord.
• Outdoor extension cords must be used with outdoor use products and are marked with suffi x
“W” and with the statement “Suitable for Use with Outdoor Appliances.
• CAUTION - To reduce the risk of electric shock, keep extension cord connection dry and off the
ground.
• Do not clean this product with a water spray or the like.
• Longer detachable power-supply cord or extension cords are available and may be used if care
is exercised in their use. If a longer detachable power-supply cord or extension cord is used:
1. The marked electrical rating of the cord set or extension cord should be at least as great as
the electrical rating of the appliance; and
2. The cord should be arranged so that it will not drape over the counter top or tabletop where
it can be pulled by children or tripped over intentionally.
• Store product indoor when not in use – out of the reach of children.
Cherry
Sweet, delicate fl avor
13
SAVE THESE INSTRUCTIONS
2
Loading...