Hyundai HYW4000P User Manual
OPERATOR’S MANUAL
* IMPORTANT SAFETY INSTRUCTIONS
HYW2500P - HYW3000P - HYW4000P
Licensed by Hyundai Corporation, Korea
table of contents
Introduction
4 Using the Operating Manual
Product Identification
5 Pressure Washer
5 Engine
Safety
6 Understanding the Machine Safety Decal
7 Safety Rules
7 Hazard Symbols and Meanings
Petrol Washer Components
14 Component Chart
Assembly
15 Unpack the Pressure Washer
15 Attach Handle
Pre-Operation Checklist
16 Follow the Checklist Below
16 Connect Hose and Water Supply to Pump
Hyundai Power Equipment
Starting Your Washer
17 How to Start your Pressure Washer
Shutting Down Your Washer
21 How to Shut Down your Pressure Washer
Quick Release Nozzles
22 How to Use Different Nozzles
22 Change Nozzles
22 Usage Tips
2
table of contents
Using Black Soap Nozzle
Apply Detergent 23
Troubleshooting
Petrol Engine Troubleshooting Chart 24
Pump Troubleshooting Chart 25
Storage
Winter Storage 26
Long Term Storage 26
Protect Fuel System 26
Other Storage Tips 27
Parts Breakdown
Pressure Washer (HYW2500P) 28
Pressure Washer (HYW3000P) 29
Pressure Washer (HYW4000P) 30
Standard Pump (HYW2500P) 31
AR Pump (HYW3000P / HYW4000P) 32
Declaration of Conformity
Declaration 34
Maintenance Schedule
Schedule 35
www.hyundaipowerequipment.co.uk
3
Hyundai Power Equipment
introduction
Attention: Read through the complete
manual prior to the initial use of your
pressure washer.
Using the Operating manual
The operating manual is an important part of your pressure washer and
should be read thoroughly before initial use, and referred to often to make
sure adequate safety and service concerns are being addressed.
Reading the instruction manual thoroughly will help avoid any personal
injury or damage to your machine. The information in this manual will offer
you the most effective tools for cleaning as well as the safest. By knowing
how best to operate this machine you will be better positioned to show
others who may also operate the unit.
This manual contains information for the complete range of pressure
washers and is placed in an order, starting from the safety requirements, to
the operating functions of your machine. You can refer back to the manual
at any time to help troubleshoot any specific operating functions, so store it
with the machine at all times.
Notice
Actual pressure released at the point of discharge may vary by machine
due to varying factors including: Volume of water being fed to the machine
by the water source, the inclusion of a Chemical injector in the line, or
variations in Engine performance.
4
product identification
Record Identification Numbers
Pressure Washer
If you need to contact an Authorized Dealer or Customer Service line for
information on servicing, always provide the product model and identifica-
tion numbers.
You will need to locate the model and serial number for the machine and
record the information in the places provided below.
Date of Purchase:
Dealer Name:
Dealer Phone:
Product Identification Numbers
Model Number:
Serial Number:
Engine
Model Number:
www.hyundaipowerequipment.co.uk
5
Hyundai Power Equipment
safety
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
WARNING – When using this product basic precautions should always
be followed, including the following:-
1. Read all the instructions before using the product.
2. To reduce the risk of injury, close supervision is necessary when a
product is used near children.
3. Know how to stop the product and bleed pressures quickly. Be
thoroughly familiar with the controls.
4. Stay alert – watch what you are doing.
5. Do not operate the product when fatigued or under the influence of
alcohol or drugs.
6. Keep operating area clear of all persons
7. Do not overreach or stand on unstable support. Keep good
footing and balance at all times.
8. Follow the maintenance instructions specified in the manual.
6
Understanding the Machine Safety Labels
The machine safety label shown below is placed on your machine
to draw attention to potential safety hazards.
WARNING!
Do not leave unit running longer than 1 minute
without using or the pump will overheat
Do not let unit freeze.
safety
Always wear eye protection.
High pressure sprays can cause serious bodily
injury. Use with Caution.
Warranty is void if you exceed preset pressure
causing severe damage to pump and unloader.
Do not use pressure washer in enclosed space
without ventilation. Carbon Monoxide Kills.
www.hyundaipowerequipment.co.uk
7
Hyundai Power Equipment
safety
Save these Instructions
Safety Rules
This is the safety alert symbol. It is used
to alert you to potential personal injury
hazards. Obey all safety
messages that follow this symbol to avoid
possible injury or death.
The safety alert symbol ( ) is used with a signal word (DANGER,
CAUTION, WARNING), a pictorial and/or a safety message to alert you to
hazards.
DANGER indicates a hazard which, if not avoided, will result in death or
serious injury.
WARNING indicates a hazard which, if not avoided, could result in death
or serious injury.
CAUTION indicates a hazard which, if not avoided, might result in minor
or moderate injury.
NOTICE indicates a situation that could result in equipment damage.
Follow safety messages to avoid or reduce the risk of injury or
death.
Hazard Symbols and Meanings
ExPLOSiON
kickbAck
fALL fLUid iNjEcTiON MOviNg PARTS REAd MANUAL
fiRE ELEcTRic ShOck TOxic fUMES
hOT SURfAcE fLyiNg ObjEcTS SLiPPERy
8
safety
DANGER
Risk of electrocution.
Contact with power source can cause electric shock
or burn.
• NEVER spray near power source.
WARNING
Fuel and its vapors are extremely flammable and
explosive.
Fire or explosion can cause severe burns or death.
When Adding or Draining Fuel
• Turn pressure washer OFF and let it cool at least 2 minutes before
removing fuel cap. Loosen cap slowly to release pressure in tank.
• Fill or drain fuel tank outdoors.
• DO NOT overfill tank. Allow space for fuel expansion (25mm from top).
• If fuel spills, wait until it evaporates before starting engine.
• Keep fuel away from sparks, open flames, pilot lights, heat, and other
ignition sources.
• DO NOT light a cigarette or smoke.
When Starting Equipment
• Ensure spark plug, exhaust, fuel cap, and air cleaner are in place.
• DO NOT crank engine with spark plug removed.
When Operating Equipment
• DO NOT tip engine or equipment at angle which causes fuel to spill.
• DO NOT spray flammable liquids.
When Transporting or Repairing Equipment
• Transport/repair with fuel tank EMPTY or with fuel shutoff valve OFF.
• Disconnect spark plug wire.
When Storing Fuel or Equipment with Fuel in Tank
• Store away from furnaces, stoves, water heaters, clothes dryers, or
other appliances that have pilot light or other ignition source because
they can ignite fuel vapors.
www.hyundaipowerequipment.co.uk
9
Hyundai Power Equipment
safety
WARNING
Engine exhaust fumes contain carbon monoxide, an
odourless, colourless, poison gas.
Breathing carbon monoxide can cause headache,
fatigue, dizziness, vomiting, confusion, seizures, nausea,
fainting or death.
Some chemicals or detergents may be harmful if inhaled
or ingested, causing severe nausea, fainting, or
poisoning.
• ONLY operate pressure washer outdoors.
• Do not allow exhaust gas from entering a confined area through
windows, doors, ventilation intakes or other openings.
• DO NOT start or run engine indoors or in an enclosed area, even if
windows and doors are open.
• Use a respirator or mask whenever there is a chance that vapours may
be inhaled.
• Read all instructions with the mask so you are certain the mask will
provide the necessary protection against inhaling harmful vapours.
WARNING
Starter cord kickback (rapid retraction) can result in
bodily injury. Kickback will pull hand and arm toward
engine faster than you can let go.
Broken bones, fractures, bruises, or sprains could
result.
• NEVER pull starter cord without first releasing spray gun pressure.
• When starting engine, pull cord slowly until resistance is felt and then
pull rapidly to avoid kickback.
• After each starting attempt, where engine fails to run, always point
spray gun in safe direction and squeeze spray gun trigger to release
high pressure.
• Firmly grasp spray gun with both hands when using high pressure
spray to avoid injury when spray gun kicks back.
10
safety
WARNING
Use of pressure washer can create puddles and
slippery surfaces.
Kickback from spray gun can cause you to fall.
• Operate pressure washer from a stable surface.
• The cleaning area should have adequate slopes and drainage to
reduce the possibility of a fall due to slippery surfaces.
• Be extremely careful if you must use the pressure washer from
scaffolding or any other similar location.
• Firmly grasp spray gun with both hands when using high pressure
spray to avoid injury when spray gun kicks back.
WARNING
Contact with exhaust area can result in serious burns.
Exhaust heat/gases can ignite combustibles, structures or
damage fuel tank causing a fire.
• DO NOT touch hot parts and AVOID hot exhaust gases.
• Allow equipment to cool before touching.
• Keep at least 5 feet (1.5 m) of clearance on all sides of pressure
washer including overhead.
WARNING
Risk of eye injury.
Spray can splash back or propel objects.
• Always wear safety goggles when using this equipment or in vicinity
of where equipment is in use.
• Before starting the pressure washer, be sure you are wearing
adequate safety goggles.
• NEVER substitute safety glasses for safety goggles.
www.hyundaipowerequipment.co.uk
11
Loading...