Honda F210 Owner's Manual
Thank you for purchasing a Honda tiller.
This manual covers operation and maintenance of the F210 tiller. All informa-
tion in this’ publication is based on the latest product information available
at the time of approval for printing.
Honda motor Co., Ltd. reserves the right to make changes at any time without
notice and without incurring any obligation.
No part of this publication may be reproduced without written permission.
This manual should be considered a permanent part of the. tiller and should
remain with the tiller if it is sold..
Pay special attention to statements preceded by the following words:
m Indicates a strong possibility of severe personal injury or loss of
life if instructions are not followed.
CAUTION: Indicates a possibility of personal injury or equipment damage
if instructions are not followed.
NOTE: Gives helpful information.
If a problem should arise, or if you have any questions about the tiller,
consult an authorized Honda dealer.
m The Honda tiller is designed to give safe and dependable service if
operated according to instructions. Read and understand the Owner’s Manual
before operating the tiller. Failure to do so could result in personal injury or
equipment damage.
i IMPORTANT NOTICE yl]
This tiller is not equipped with a spark arrester Operation on forest
bush or grass covered land may be illegal in some states. Check local laws
and regulations before operation.
1
CONTENTS
1. WARNING LABEL LOCATIONS
2. TILLER SAFETY
3. COMPdNENT IDENTIFICATI'ON
4. PRE-OPERATION CHECK
5. STARTING THE ENGINE
6. TILLER OPERATION
7. STOPPING THE ENGINE
8. MAINTENANCE
9. TRANSPORTING/STORAGE
10. TROUBLESHOOTING
ll.SPECIFICATIONS
12. WARRANTY SERVICE (FOR U.S.A.).
........................................
...................................
......................................
..................................
..............
.....................................
........................................
................
............................
...............................
.:.
....................................
....
.....................
..................
.;.
...........
:.
: .. 6
..
;.
3
4
5
9
11
13
14
21
22
23.
24
2
1. WARNING LABEL LoCATIONS
n
IIEAD OWNER’S MANUAL FIRST mR SAA OPERATION.
WEXNAUST GASES ARE POISONOUS AVOID INHALATION.
n
GASOLINE IS FLAMMABLE AND EXPLOSIVE. STOP
FOR SPUlEll FUEL OlblEAKAGE BEFORE STARTING.
II
WOU NOT TILT TILLER EXCESSIVELY OR FULL MAY SPILL
(MAIN CLUTCH )
E OIL FILLER CAP
BEFORE
STARTING.
lFll1 UP TO UPPER MARK
1 OIL FILLER CAP
3
2. TILLER SAFETY
Kmm
To ensure safe operation -
l
READ THIS OWNERS MANUAL CAREFULLY.
l
Never permit anyone to operate the tiller without proper instruction.
l
Know how to stop the tiller quickly and understand the operation of all the
controls.
l
Keep children and pets at a safe distance when tilling.
l
Wear close-fitting clothing and sturdy, nonslip shoes that completely enclose the feet.
l
Make sure that all fasteners are properly secured.
l
When tilling on an incline, keep the fuel tank less than half full to minimize
fuel spillage.
l
Always stop the engine before cleaning the tines or making adjustments.
l
Do not operate the tiller with any of its covers removed.
l
Keep a firm hold on the handlebars; they may tend to lift during clutch
engagement.
l
Clear the area to be tilled by picking up any stones, wire, glass, large sticks,
metal, etc.
l
If the til!er strikes an object while tilling, stop the engine and check for
damage.
l
Stop the engine whenever you leave the tiller. Never allow it to idle
unattended.
4
THROTTLE LEVER
3. COMPONENT IDENTIFICATION
AIR CLEANER
FUEL TANK CAP
ENGINE SWITCH
SPARK PLUG CAP
TRANSMISSION OIL
FILLER CAP
ENGINE OIL
FILLER CAP
ENGINE OIL
DRAIN BOLT
FUEL VALVE
FRONT WHEEL
RECOIL STARTER
\ \\
CLUTCHLEVER
ROiOR
- DRAG BAR
TRAhiSMlSSlON OIL LEVEL
CHECK BOLT
4. IPRE-OPERATION CHECK
1. Engine oil level
CAUTION:
l
Engine oil is a major factor affecting engine performance and service life.
Non-detergent or vegetable oils are not recommended.
l
Be sure to check the tiller on a level surface with the engine stopped.
Use Honda 4-stroke oil, or an equivalent high detergent, premium quality
motor oil certified to meet or exceed
U.S. automobile manufacturer’s re-
quirements for Service Classification
SE or SF. (Motor oils classified SE or
SF will show this designation on the
container.)
SAE low-40 is recommended for
general, all-temperature use. If single
-xl 0
viscosity oil is used, select the appro-
priate viscosity for the average tem-
perature in your area.
1. Remove the oil filler cap and wipe the dipstick clean.
2. Insert the dipstick into the oil filler hole, but do not screw it in.
3. If the oil level is low, add enough recommended oil to bring it to the upper
level mark on the dipstick.
20 40 60 80
Ambient temperature
IOO’F
CAUTION: Running the engine with insufficient .oil can cause serious engine
damage.
OIL FILLER CAP
OIL FILLER HOLE
I
UPPER
I
LEVEL
\
_ LOWER.
LEVEL
6
2. Transmission gear oil
Place the tiller on a level surface and remove the transmission oil filler cap.
The oil should be level with the lower edge of the oil filler hole.
Add high quality engine oil if the level is low.
TRANSMISSION OIL FILLER CAP
TRANSMlSSlbN OIL LEVEL
CHECK BOLT
3. Air cleaner
Check cleaner for dirt or obstruction of elements.
AIR CLEANER COVER
4. Fuel
Use any regular grade. automotive gasoline (unleaded gasoline is preferred)
with a pump octane rating of 86 or higher.
Never use an oil/gasoline mixture or dirty gasoline. Avoid getting dirt, dust or
water in the fuel tank.
CAUTION: Gasoline substitutes are not recommended; they may be harmful
to fuel system components.
-
l
Gasoline is extremely flammable and explosive under certain conditions.
Refuel in a well ventilated area with the engine stopped.
l
Do not smoke or allow flames or sparks in the area where the engine is
refueled or where gasoline is stored.
l
Do not overfill the tank and make sure the filler cap is securely closed
after
refueling.
l
Be careful not to spill fuel when refueling. Fuel vapor or spilled fuel may
ignite. If any fuel is spilled, make sure the area is dry before starting the
engine.
Fuel tank capacity: 0.9 !Z (0.95 US qt)
8
FUEL FILLER CAP
FUEL FIL-LER HOLE
Loading...