Hobart C44AW Parts List

Download

CATALOG OF

REPLACEMENT PARTS

MODEL C44A, C44AW, & C54A

SERIES DISHWASHERS

C44A ML-104047 R-L ML-104050 L-R

C44AW ML-104082 R-L ML-104083 L-R

C54A ML-104199 R-L ML-104198 L-R

PRIOR MLS COVERED IN THIS MANUAL:

C44A

ML-38898 R-L ML-38899 L-R

C44AW ML-103946 R-L ML-103947 L-R

A product of HOBART CORPORATION 701 S. RIDGE AVENUE TROY, OHIO 45374-0001

FORM 17820 Rev. E (February 205)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

F-17820 Rev. E (February 2015) - 2 - © HOBART 2015

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

Table of Contents

5 CONDUIT WATERPROOF 7 CONTROL BOX

9 COMPONENT PANEL (CONTROL BOX) W/O 120 V. PILOT CIRCUIT 13 COMPONENT PANEL (CONTROL BOX) 120 V. PILOT CIRCUIT 17 WASH MOTOR AND PUMP UNIT 19 CONVEYOR DRIVE UNIT (C44A SERIES 1/4 HP.) 21 CONVEYOR DRIVE UNIT (C54A, C44A & AW SERIES 1/6 HP.) 23 CONVEYOR DRIVE TRAIN 25 CONVEYOR DRIVE - MOTOR PARTS (VON WEISE - 1/4 HP.) 27 CONVEYOR DRIVE - MOTOR PARTS (BISON - 1/4 HP.) 29 TRACK AND CRADLE (WASH SECTION) 33 WASH ARMS & TUBES (WASH SECTION - PREVIOUS CONSTRUCTION) 35 WASH ARMS & TUBES (WASH SECTION) 37 FILL & OUTSIDE RINSE PIPING (PREVIOUS CONSTRUCTION) 41 FILL & OUTSIDE RINSE PIPING (CURRENT CONSTRUCTION) 45 INSIDE METALLIC RINSE PIPING 47 INSIDE NON-METALLIC RINSE PIPING (C44A AND AW SERIES) 49 ACTUATOR MECHANISM & RINSE DRAIN-OFF PAN 53 DRAIN UNIT (WASH SECTION) 55 DOOR, CURTAINS, BAFFLES, AND STRAINERS 59 VENT HOOD 61 EXTENDED HOOD 63 MISCELLANEOUS (WASH SECTION) 67 LOW WATER PROTECTION (STEAM HEAT/WASH TANK) 69 STEAM COIL HEAT 71 PIPING / STEAM COILS 73 STEAM INJECTOR HEAT 75 CONTROL BOX - GAS HEAT 79 GAS BURNER AND FLUE 81 GAS HEAT COMPONENTS 85 ELECTRIC HEAT 87 DISH RACKS 89 TABLE LIMIT SWITCH

- 3 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONDUIT WATERPROOF

F-17820 Rev. E (February 2015) - 4 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONDUIT WATERPROOF

ILLUS. PL-55488

13 FE-007-01 Conn Straight "Sealtite"(1/2 Male Thd x 3/8 Flex Cnd)(No P/N Non Metallic)...........................2

15 FE-007-05 Conn 45 Deg "Sealtite"(1/2 Male Thd x 1/2 Flex Cnd)(Non Metallic use FE-024-61)

16 FE-007-04 Conn Straight "Sealtite" (1/2 Cable x 1/2 Flex Cnd)(Non Metallic use FE-024-57)....................1

17 FE-008-10 1/2 Gasket Assy (No P/N Non-Metallic).....................................................................................2

18 FE-007-01 Conn Straight "Sealtite" (1/2 Male Thd x 3/8 Flex Cnd)(No P/N Non Metallic)..........................1

20 FE-007-02 Conn - 45 Deg "Sealtite" (1/2 Male Thd x 3/8 Flex Cnd)(No P/N Non Metallic).........................1

22 FE-006-07 Lock Nut 1/2 (Cnd).....................................................................................................................1

23 FE-008-10 1/2 Gasket Assy......................................................................................................................AR

24 FE-007-05 Conn - 45 Deg "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)(Non Metallic use FE-024-61)

25 FE-007-07 Conn - 90 Deg "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)(Non Metallic use FE-024-65)

26 FE-006-07 Lock Nut 1/2 (Cnd).....................................................................................................................1

27 FE-008-10 1/2 Gasket Assy.........................................................................................................................2

28 00-294947-1 Grounding Strap - Holes 1" Dia & 1" Dia (No P/N Non Metallic)................................................1

29 00-294947-3 Grounding Strap - Holes 1 1/8 Dia & 1 3/8 Dia (No P/N Non Metallic).......................................1

30 FE-007-05 Conn - 45 Deg "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)(Non Metallic use FE-024-61)

31 FE-007-07 Conn - 90 Deg "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd) (Non Metallic use FE-024-65)

32 FE-008-10 1/2 Gasket Assy (No P/N Non Metallic).....................................................................................1

33 FE-007-04 Conn - Straight Sealtite" (1/2 Cable x 1/2 Flex Cnd)(Non Metallic use FE-024-57)

PART NO. NAME OF PART AMT.

1 00-329817 Label Temperature (Low Temp).................................................................................................1

2 00-329818 Label Temperature (High Temp)................................................................................................1

3 00-294947-2 Grounding Strap Holes 1 1/8 Dia and 7/8 Dia (No P/N Non Metallic)........................................1

4 FE-007-07 Conn 90 Deg "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)(Non Metallic use FE024-65)

...................................................................................................................................................2

5 FE-008-10 1/2 Gasket Assy......................................................................................................................AR

6 FE-008-33 Conn 90 Deg "Sealtite" (1 Male Thd x 1 Flex Cnd)(Non Metallic use FE-024-67).....................2

8 FE-008-12 Gasket.....................................................................................................................................AR

...................................................................................................................................................2

...................................................................................................................................................1

...................................................................................................................................................2

- 5 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONTROL BOX

F-17820 Rev. E (February 2015) - 6 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONTROL BOX

ILLUS. PL-55293

10 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................2

11 00-437041-3 Thermometer (8 Ft) (Rinse)........................................................................................................1

12 00-437041-4 Thermometer (11 Ft) (Wash)......................................................................................................1

13 00-415207-2 Fan Cooling (230 V)(Machines W/O 120 V pilot circuit).............................................................1

14 00-355504-1 Fan (115 V)(Machines W/ 120 V pilot circuit).............................................................................1

15 00-87711-241-2 Switch - Rocker (DPDT) (Conveyor Dwell)(Machines W/ 120 V pilot circuit).............................1

16 00-87711-192-2 Switch - Rocker (On/Off) (Conveyor Dwell)(Machines W/O 120 V pilot circuit).........................1

17 00-87711-228-1 Switch - Rocker (Motor On/Off)..................................................................................................1

18 00-87711-241-2 Switch - Rocker (On/Off) (Timer)(Machines W/ 120 V pilot circuit)............................................1

19 00-87711-192-2 Switch - Rocker (On/Off) (Timer)(Machines W/O 120 V pilot circuit).........................................1

20 00-271840 Label - Timer..............................................................................................................................1

21 00-87711-198-2 Switch - Rocker (Power On/Off)(115 V)(Machines W/ 120 V pilot circuit)..................................1

22 00-87711-198-6 Switch - Rocker (Power On/Off) (240 V)(Machines W/O 120 V pilot circuit)..............................1

23 00-107218 Coupling - Thermometer Bulb....................................................................................................2

24 00-435072 Gasket........................................................................................................................................1

25 WS-022-01 Washer.......................................................................................................................................6

26 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................6

27 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................6

28 00-274962 Label - Instruction (C44A Series)...............................................................................................1

29 00-436354 Label - Instruction (C44AW Series)............................................................................................1

30 00-475088 Label - Instruction (C54A Series)...............................................................................................1

31 00-812850 Label - Control Box (W/O Conveyor Dwell).............................................................................AR

32 00-812852 Label - Control Box (Conveyor Dwell).....................................................................................AR

33 WS-012-40 Washer (SST).............................................................................................................................4

34 FP-053-05 Pipe Locknut 1/2 NPSL (SST)....................................................................................................2

35 WL-006-42 Lockwasher #6 Medium.............................................................................................................3

36 NS-011-07 Mach Nut 6-32 Hex....................................................................................................................3

37 00-274947 Grommet....................................................................................................................................1

PART NO. NAME OF PART AMT.

1 SC-066-05 Mach Screw 10-24 x 3/8 Phil Truss Hd......................................................................................2

2 00-436755-1 Cover - Control Box....................................................................................................................1

3 00-274884 Guard - Fan................................................................................................................................1

4 00-256154 Circuit Breaker (Machines W/O 120 V pilot circuit)....................................................................1

5 00-271069 Control Box (Give Elec Spec, Model, S/N)(Machines W/O 120 V pilot circuit)..........................1

6 00-435505-1 Control Box (Give Elec Spec, Model, S/N)(Machines W/ 120 V pilot circuit).............................1

7 00-274948 Shield.........................................................................................................................................1

8 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................1

9 00-328137 Shield.........................................................................................................................................1

FE-021-12 Plug - 1/2 Knockout (Plastic)...................................................................................................AR

FE-023-26 Plug - 1 Knockout (Plastic)......................................................................................................AR

- 7 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX) W/O 120 V. PILOT CIRCUIT

F-17820 Rev. E (February 2015) - 8 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX) W/O 120 V. PILOT CIRCUIT

ILLUS. PL-50622

10 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B.............................................................AR

11 WL-007-12 Lockwasher #10 External Shakeproof.....................................................................................AR

12 00-294325-003-1 Block - Terminal......................................................................................................................AR

*13 00-294325-004-1 Terminal Block............................................................................................................................1

14 SD-037-21 Self-Tapping Screw 8-32 x 1 Phil Fil Hd, Type F (Use with #12 on 3 Ph Machines)

15 SD-008-36 Self-Tapping Screw 8-18 x 7/18 Phil Rd Hd, Type B(Use with #13 or 12 on 1 Ph Mach)

16 00-118544-2 Lug - Grounding.........................................................................................................................1

17 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................1

18 WL-007-12 Lockwasher #10 External Shakeproof........................................................................................1

19 00-87713-041-1 Contactor 40 Amp 3 Pole (Electric Heat)...................................................................................1

20 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

21 00-205113-2 Relay 3 PDT...............................................................................................................................1

22 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................1

23 00-271066 Bracket.......................................................................................................................................1

24 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B.................................................................2

25 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

26 00-87714-007-3 Relay DPDT...............................................................................................................................1

27 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

28 00-87713-049-2 Contactor (Machines W/Vent Fan Control)................................................................................1

29 00-271066 Bracket.......................................................................................................................................1

30 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B.................................................................2

31 00-205113-2 Relay 3 PDT...............................................................................................................................1

32 00-205113-2 Relay 3 PDT...............................................................................................................................1

33 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

34 00-87714-031-1 Relay Time Delay.......................................................................................................................1

35 SD-034-70 Self-Tapping Screw 1/4-20 x 1 Slotted Hex Washer Hd............................................................1

36 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

37 00-294500-17 Transformer 24 V (Gas Heat).....................................................................................................1

38 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

39 00-294436-5 Fuse Block (Gas Heat)...............................................................................................................1

40 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B (Gas Heat)..............................................2

41 FE-022-45 5 Amp Fuse 300 V (Gas Heat)...................................................................................................1

42 00-294500-18-1 Transformer (150 VA) Pilot Control............................................................................................1

43 00-294500-18-2 Transformer (250 VA) Pilot Control (Machines W/Blower Dryer or Condenser)........................1

44 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................4

45 00-274629-2 Thermostat - Solid State (230 V)................................................................................................1

46 SC-098-07 Mach Screw 4-40 x 1 3/4 Rd Hd (SST)......................................................................................3

47 WS-028-12 Washer.......................................................................................................................................3

48 00-271065 Base Plate..................................................................................................................................1

49 00-87714-028-2 Time Delay Relay (Machines W/Vent Fan Control)....................................................................1

50 SD-014-26 Self-Tapping Screw 6-32 x 3/4 Slotted Pan Hd, Type D............................................................2

51 00-87714-028-2 Relay Time Delay.......................................................................................................................1

52 SD-014-26 Self-Tapping Screw 6-32 x 3/4 Slotted Pan Hd, Type D............................................................2

53 00-294677-3 Clamp - Wire (3/4 ID).................................................................................................................3

54 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................3

55 FE-022-74 Fuse (0.6 Amp) (500 V) (380-480 V Mach W/O Blower Dryer or Condenser)...........................2

PART NO. NAME OF PART AMT.

1 00-294325-013-1 Terminal Block............................................................................................................................1

2 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

3 00-87713-040-1 Contactor 30 Amp 3 Pole (Machines W/Conveyor Dwell)..........................................................1

4 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

5 00-294677-2 Clamp - Wire (1/2 ID).................................................................................................................1

6 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................1

7 00-294325-003-1 Block - Terminal......................................................................................................................AR

8 SD-037-21 Self-Tapping Screw 8-32 x 1 Phil Hd, Type F.........................................................................AR

9 00-118544-2 Lug - Grounding......................................................................................................................AR

...................................................................................................................................................2

- 9 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX) W/O 120 V. PILOT CIRCUIT

ILLUS. PL-50622

56 FE-022-86 Fuse (0.8 Amp) (500 V) (380-480 V Mach W/Blower Dryer and/or Condenser)........................2

57 00-294676 PCB - Terminal & Fuse..............................................................................................................1

58 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B.................................................................4

59 00-294677-4 Clamp - Wire (1 ID)....................................................................................................................3

60 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

61 00-87713-040-1 Contactor 30 Amp, 3 Pole..........................................................................................................1

62 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

63 WL-007-12 Lockwasher #10 External Shakeproof........................................................................................6

64 SC-053-05 Mach Screw 10-24 x 3/8 Truss Hd, Slotted................................................................................6

65 00-294500-021-1 Transformer 24 & 120 V Secondary (Gas Heat)........................................................................1

66 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................4

67 00-205113-2 Relay 3 PDT...............................................................................................................................1

68 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................1

69 00-186748 Relay Mounting..........................................................................................................................1

70 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B.................................................................2

PART NO. NAME OF PART AMT.

* Single point electrical connection, 3 Ph, or 200-240 V, 1 Ph machines W/O single

point electrical connection. Electric heat only

F-17820 Rev. E (February 2015) - 10 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 11 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX) 120 V. PILOT CIRCUIT

F-17820 Rev. E (February 2015) - 12 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX) 120 V. PILOT CIRCUIT

ILLUS. PL-51065

10 00-294325-015-1 Block - Terminal.........................................................................................................................1

11 SD-037-21 Self-Tapping Screw 8-32 x 1 Phil Hd, Type F............................................................................2

12 00-118544-2 Lug - Grounding.........................................................................................................................1

13 SD-035-77 Self-Tapping Screw 1/4-20 x 3/8 Phil Pan Hd, Type TT.............................................................1

14 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

15 00-118544-2 Lug - Grounding (Electric Heat)..................................................................................................1

16 SD-035-77 Self-Tapping Screw 1/4-20 x 3/8 Phil Pan Hd, Type TT.............................................................1

17 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

18 00-294325-015-1 Block - Terminal (200-240 V, 380-480 V, 3 Ph Electric Heat)....................................................2

19 00-294325-004-1 Block - Terminal (Not Shown) (200-240 V, 1 Ph, Electric Heat) (SPEC)...................................2

20 SD-037-21 Self-Tapping Screw 8-32 x 1 Fil Phil Hd Type F (Use W/Item 18 on 3 Ph Machines)

21 SD-008-36 Self-Tapping Screw 8-18 x 7/8 Phil Rd Hd Type B (Use W/Item 19 on 1 Ph Machines)

22 00-87713-041-2 Contactor 40 Amp 3 Pole (Electric Heat)...................................................................................1

23 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

24 00-294677-5 Clamp - Wire (1 1/2 ID)..............................................................................................................2

25 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

26 00-205113-1 Relay - 3 PDT (1CR, 3CR, & 4CR)............................................................................................3

27 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................3

28 00-294677-4 Clamp - Wire (1 ID)....................................................................................................................2

29 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

30 00-87714-007-2 Relay - DPDT (115 V)................................................................................................................1

31 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

32 00-112527 Contactor (Machines W/Vent Fan Control)................................................................................1

33 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

34 00-437103 Bracket - Relay Mounting...........................................................................................................1

35 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

36 WL-014-07 Lockwasher #10 External Shakeproof (SST).............................................................................2

37 00-437070-1 Plug On Module (Machines W/Vent Fan Control)......................................................................1

38 00-87714-36 Relay Time Delay (Variable) (Machines W/Vent Fan Control)...................................................1

39 SD-036-13 Self-Tapping Screw 1/4-20 x 1 1/4 Hex Washer Hd, Type T.....................................................1

40 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

41 00-294500-46-1 Transformer (150 VA) Pilot Control............................................................................................1

42 00-294500-46-2 Transformer (300 VA) Pilot Control............................................................................................1

43 00-294500-46-3 Transformer (500 VA) Pilot Control............................................................................................1

44 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil Bind Hd, Type B (Use W/Item 41 or 42)..........................4

45 WL-014-07 Lockwasher #10 External Shakeproof (SST) (Use W/Item 41 or 42).........................................4

46 SD-035-77 Self-Tapping Screw 1/4-20 x 3/8 Phil Pan Hd, Type TT (Use W/Item 43).................................4

47 WL-007-15 Lockwasher 1/4 External Shakeproof (Use W/item 43)..............................................................4

48 00-87714-36 Relay Time Delay (Variable)......................................................................................................1

49 00-294677-5 Clamp - Wire (1 1/2 ID)..............................................................................................................2

50 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

51 00-435508 Base Plate..................................................................................................................................1

52 00-274629-1 Thermostat - Solid State (120 V)................................................................................................1

53 SC-098-07 Mach Screw 4-40 x 1 3/4 Rd Hd(SST).......................................................................................3

54 WS-028-12 Washer.......................................................................................................................................3

55 00-87714-031-2 Relay Time Delay (5 Sec)..........................................................................................................1

PART NO. NAME OF PART AMT.

1 00-294325-013-5 Block - Terminal.........................................................................................................................1

2 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

3 00-87713-041-2 Contactor 40 Amp 3 Pole (Machines W/Conveyor Dwell)..........................................................1

4 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

5 00-294325-013-4 Terminal - Block (Machines W/Vent Fan Control)......................................................................1

6 00-437101 Bracket - Vent Fan Control.........................................................................................................1

7 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

8 WL-014-07 Lockwasher #10 External Shakeproof (SST).............................................................................2

9 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

...................................................................................................................................................2

- 13 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX) 120 V. PILOT CIRCUIT

ILLUS. PL-51065

56 SD-036-13 Self-Tapping Screw 1/4 -20 x 1 1/4 Hex Washer Hd, Type T....................................................1

57 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

58 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................4

59 FE-022-39 Fuse (1.5Amp)(250 V)(60 Hz Machines W/O Blower Dryer or Condenser)...............................1

60 FE-021-19 Fuse (3.2 Amp)(125 V)(50 Hz & 50/60 Hz W/Blower Dryer and/or Condenser)........................1

61 FE-023-25 Fuse (5 Amp)(125 V)(380-480 V Gas Heat W/Blower Dryer and/or Condenser).......................1

62 00-294676 PCB - Terminal & Fuse..............................................................................................................1

63 00-294677-4 Clamp - Wire (1 ID)....................................................................................................................3

64 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................3

65 00-87713-040-2 Contactor - 30 Amp, 3 Pole........................................................................................................1

66 SD-008-25 Self-Tapping Screw 10-16 x 1/2 Phil Pan Hd, Type B................................................................2

67 SC-053-05 Mach Screw 10-24 x 3/8 Truss Hd, Slotted................................................................................6

68 WL-007-12 Lockwasher #10 External Shakeproof........................................................................................6

69 00-205113-1 Relay - 3 PDT (5CR)..................................................................................................................1

70 00-437102 Bracket - Relay Mounting...........................................................................................................1

71 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B.................................................................2

72 WL-014-05 Lockwasher #8 External Shakeproof (SST)...............................................................................2

73 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil Pan Hd, Type B..................................................................2

74 00-294500-021-1 Transformer 24 & 120 V Secondary (Gas Heat)........................................................................1

75 00-437070-1 Plug On Module..........................................................................................................................1

76 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil Bind Hd, Type B.................................................................4

77 SD-036-13 Self-Tapping Screw 1/4-20 x 1 1/4 Hex Washer Hd, Type T.....................................................1

78 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

PART NO. NAME OF PART AMT.

F-17820 Rev. E (February 2015) - 14 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 15 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

WASH MOTOR AND PUMP UNIT

F-17820 Rev. E (February 2015) - 16 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

WASH MOTOR AND PUMP UNIT

ILLUS. PL-55489

10 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

11 00-274227-2 Clamp.........................................................................................................................................1

12 SC-041-05 Cap Screw 1/4-16 x 5/8 Hex Hd. (SST).....................................................................................2

13 WL-007-16 Lockwasher 1/4..........................................................................................................................2

14 00-812069 Bracket - Motor Support.............................................................................................................1

15 NS-015-01 Nut 1/4-20 Hex (SST).................................................................................................................2

16 00-274230-1 Motor (1 Ph., 60 Hz.) (2 Hp.)......................................................................................................1

17 00-274230-2 Motor (3 Ph., 60 Hz.) (2 Hp.)......................................................................................................1

18 00-274230-3 Motor (1 Ph., 50 Hz.) (2 Hp.)......................................................................................................1

19 00-274230-4 Motor (3 Ph., 50 Hz.) (2 Hp.)......................................................................................................1

20 00-274227-3 Adapter.......................................................................................................................................1

21 00-274227-6 Seal - Shaft.................................................................................................................................1

22 00-274227-7 Impeller & Sleeve (60 Hz.)(C44A & C54A Series).....................................................................1

23 00-274227-10 Impeller & Sleeve (50 Hz.)(C44A & C54A Series).....................................................................1

24 00-274227-12 Impeller & Sleeve (60 Hz.)(C44AW Series)...............................................................................1

25 00-274227-7 Impeller & Sleeve (60 Hz.)(C44AW Series)...............................................................................1

26 00-274227-4 Gasket........................................................................................................................................1

27 00-119051 Gasket........................................................................................................................................2

28 00-812776 Plate - Support...........................................................................................................................2

29 00-274227-5 Stud.........................................................................................................................................AR

30 00-274227-1 Pump Shell (Incls. Items 29)......................................................................................................1

31 00-274246 Shroud........................................................................................................................................1

32 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................10

33 NS-015-11 Nut 5/16-18 Hex (SST).............................................................................................................10

PART NO. NAME OF PART AMT.

1 00-328362 Strainer - Pump..........................................................................................................................1

2 00-119050 Gasket........................................................................................................................................1

3 00-749586 Hose - Discharge........................................................................................................................1

4 00-542337 Clamp - Hose.............................................................................................................................2

5 00-270968 Gasket - Wash Pipe...................................................................................................................1

6 00-270970 Tube - Discharge........................................................................................................................1

7 SC-041-29 Cap Screw 3/8-16 x 7/8 Hex Hd. (SST).....................................................................................4

8 WS-06-44 Washer.......................................................................................................................................4

9 WL-006-22 Lockwasher 5/16 Light...............................................................................................................4

- 17 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE UNIT

(C44A SERIES 1/4 HP.)

F-17820 Rev. E (February 2015) - 18 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE UNIT

(C44A SERIES 1/4 HP.)

ILLUS. PL-50731

10 SC-120-72 Cap Screw 5/16-18 x 4 1/2 Hex Hd............................................................................................1

11 WS-029-05 Washer (SST).............................................................................................................................4

12 00-270935 Spring - Overload.......................................................................................................................1

13 NS-032-33 Stop Nut 1/4-28 Flexloc..............................................................................................................1

14 00-289256 Actuator - Switch........................................................................................................................1

15 SC-041-10 Cap Screw 5/16-18 x 5/8 Hex Hd...............................................................................................3

16 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................3

17 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................3

18 WS-029-05 Washer (SST).............................................................................................................................1

19 SC-027-24 Mach Screw 6-32 x 1 1/2 Rd Hd................................................................................................2

20 WL-010-22 Lockwasher #6 External Shakeproof..........................................................................................2

21 WS-002-06 Washer.......................................................................................................................................4

22 NS-010-06 Mach Nut 6-32 Hex....................................................................................................................2

23 00-270933-1 Bracket - Anti-Jam Switch..........................................................................................................1

24 00-87711-060-1 Switch - Interlock (Incls Items 19, 20, 21, & 22).........................................................................1

25 00-274231-11 Key - Woodruff #605..................................................................................................................1

26 00-274231-57 Key - 3/16 x 3/16 x 1 1/8 Lg (Bison)...........................................................................................1

27 00-270929-1 Bracket - Motor...........................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-270930-1 Motor - Conveyor Drive (208-240/480 V, 60 Hz, 3 Ph) (Incls Item 26).......................................1

2 00-270930-2 Motor - Conveyor Drive (208-240 V, 60 Hz, 1 Ph) (Incls Item 26)..............................................1

3 00-270930-3 Motor - Conveyor Drive (200-240 V, 50 Hz, 1 Ph) (Incls Item 26)..............................................1

4 00-270930-4 Motor - Conveyor Drive (200-240/380-415 V, 50 Hz, 3 Ph) (Incls Item 26)...............................1

5 SC-041-30 Cap Screw 3/8-16 x 1 Hex Hd (SST).........................................................................................4

6 WL-006-29 Lockwasher 3/8 Hi-Collar...........................................................................................................4

7 NS-015-13 Nut 3/8-16 Hex (SST).................................................................................................................4

8 00-271083 Spacer - Overload......................................................................................................................1

9 00-270927 Pilot Bearing...............................................................................................................................1

00-103881-38 Lubricant - Gear Case.............................................................................................................AR

- 19 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE UNIT

(C54A, C44A & AW SERIES 1/6 HP.)

F-17820 Rev. E (February 2015) - 20 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE UNIT

(C54A, C44A & AW SERIES 1/6 HP.)

ILLUS. PL-55294

10 00-437044-2 Motor-Conveyor Dr (208-240 V.,60 Hz.,1 Ph)(Incls #27, 28, & 29)(C44A Series).....................1

11 00-437044-3 Motor-Conveyor Dr (200-240 V.,50 Hz.,1 Ph)(Incls #27, 28, & 29)(C44A Series).....................1

12 00-437044-4 Motor-Conveyor Dr (200-240/380-415 V.,50 Hz.,3 Ph)(Incls #27 & 28)(C44A Series)

13 00-328379-1 Seal - Oil (Output Shaft-Shown).................................................................................................1

14 00-328379-2 Seal - Oil (Motor Dr Shaft)..........................................................................................................1

15 00-474423 Flinger........................................................................................................................................1

16 00-274231-57 Key - 3/16 x 3/16 x 1 1/8 Lg.......................................................................................................1

17 BB-005-19 Ball Bearing - Fafnir #H202PP...................................................................................................1

18 BB-020-18 Bearing - Ball..............................................................................................................................1

19 SC-027-24 Mach. Screw 6-32 x 1-1/2 Slotted Rd. Hd. (Brass)....................................................................2

20 WL-010-22 Lockwasher #6 External Shakeproof..........................................................................................2

21 WS-002-06 Washer.......................................................................................................................................4

22 NS-010-06 Mach. Nut 6-32 Hex...................................................................................................................2

23 00-87711-060-1 Switch - Interlock (Incls. Items 13 thru 16).................................................................................1

24 00-087711-260-2 Switch - Interlock........................................................................................................................1

25 FE-022-84 Strain Relief 1/2 NPT..................................................................................................................1

26 SC-067-05 Mach. Screw 8-32 x 1/2 Hex Hd. (SST).....................................................................................2

27 00-474488 Bracket - Switch.........................................................................................................................1

28 NS-031-16 Stop Nut 10-24 Hex (SST).........................................................................................................2

29 SC-127-89 Mach. Screw 10-24 x 3/4 Phil. Rd. Hd. (SST)............................................................................2

30 00-270927 Pilot Bearing...............................................................................................................................1

31 NS-032-33 Stop Nut 1/4 -28 Flexloc.............................................................................................................1

32 00-289256 Actuator - Switch........................................................................................................................1

33 00-271083 Spacer - Overload......................................................................................................................1

34 WS-029-05 Washer (SST).............................................................................................................................4

35 00-436017 Bracket - Overload.....................................................................................................................1

36 SC-120-72 Cap Screw 5/16-18 x 4 1/2 Hex Hd............................................................................................1

37 00-270935 Spring - Overload.......................................................................................................................1

38 SC-041-10 Cap Screw 5/16-18 x 5/8 Hex Hd. (SST)...................................................................................2

39 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

40 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

41 00-328027 Bracket - Motor...........................................................................................................................1

42 SC-041-31 Cap Screw 3/8-16 x 1-1/4 Hex Hd. (SST)..................................................................................4

43 WL-006-29 Lockwasher 3/8 Hi-Collar...........................................................................................................4

44 NS-015-13 Nut 3/8-16 Hex (SST).................................................................................................................4

PART NO. NAME OF PART AMT.

1 00-328002-1 Motor-Conveyor Dr (208-240/480 V.,60 Hz.,3 Ph)(Incls #27, 28 & 29)(C44AW Series)

...................................................................................................................................................1

2 00-328002-2 Motor-Conveyor Dr (208-240 V.,60 Hz.,1 Ph)(Incls #27, 28, & 29)(C44AW Series)

...................................................................................................................................................1

3 00-328002-3 Motor-Conveyor Dr (200-240 V.,50 Hz.,1 Ph)(Incls #27, 28, & 29)(C44AW Series)

...................................................................................................................................................1

4 00-328002-4 Motor-Conveyor Dr (200-240/380-415 V.,50 Hz.,3 Ph)(Incls #27 & 28)(C44AW Series)

...................................................................................................................................................1

5 00-437044-6 Motor-Conveyor Dr (208-240/480 V.,60 Hz.,3 Ph)(Incls #27, 28, & 29)(C54A Series)

...................................................................................................................................................1

6 00-437044-7 Motor-Conveyor Dr (208-240 V.,60 Hz.,1 Ph)(Incls #27, 28, & 29)(C54A Series).....................1

7 00-437044-8 Motor-Conveyor Dr (200-240 V.,50 Hz.,1 Ph)(Incls #27, 28, & 29)(C54A Series).....................1

8 00-437044-9 Motor-Conveyor Dr (200-240/380-415 V.,50 Hz.,3 Ph)(Incls #27 & 28)(C54A Series)

...................................................................................................................................................1

9 00-437044-1 Motor-Conveyor Dr (208-240/480 V.,60 Hz.,3 Ph)(Incls #27, 28, & 29)(C44A Series)

...................................................................................................................................................1

- 21 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE TRAIN

F-17820 Rev. E (February 2015) - 22 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE TRAIN

ILLUS. PL-55301

10 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

11 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

12 00-270937 Shaft - Crank..............................................................................................................................1

13 00-436879 Spacer - Bearing........................................................................................................................1

14 BB-021-19 Ball Bearing - Hoover NSK 6003................................................................................................1

15 00-328083 Coupling - Motor (C44AW & C54A Series)(C44A 1/6 Hp Motor)...............................................1

16 00-270931 Coupling - Motor (C44A Series 1/4 HP Motor)...........................................................................1

17 00-274228-2 Insert Coupling Service (LoveJoy)..........................................................................................AR

18 00-274228-1 Insert Coupling Service (Browning).........................................................................................AR

19 00-270939 Seal Lower Housing...................................................................................................................1

20 00-12430-40 Key 3/16 Sq x 3/4 Lg..................................................................................................................1

21 00-270942 Gasket........................................................................................................................................1

22 00-274749 Housing Assy (Incls Items 12 thru 14, 19, & 23 thru 25)............................................................1

23 BB-021-19 Ball Bearing - Hoover NSK 6003................................................................................................1

24 00-270940 Seal - Upper Housing.................................................................................................................1

25 00-274748 Seal - Labyrinth..........................................................................................................................1

26 00-527042 Adhesive..................................................................................................................................AR

27 00-522696 Solvent....................................................................................................................................AR

PART NO. NAME OF PART AMT.

1 NS-032-35 Stop Nut 5/16-18 Flexloc............................................................................................................1

2 00-474660 Slide - Drive Crank.....................................................................................................................1

3 SC-041-20 Cap Screw 5/16-18 x 2 1/8 Hex Hd............................................................................................1

4 WS-005-32 Washer (SST).............................................................................................................................1

5 00-12430-39 Key 3/16 Sq x 3/8 Lg..................................................................................................................1

6 00-270943 Arm - Crank................................................................................................................................1

7 SC-050-01 Set Screw 1/4-20 x 1/2 Square Hd Cup Pt.................................................................................2

8 SC-041-13 Cap Screw 5/16-18 x 1 Hex Hd (SST).......................................................................................4

9 WS-017-08 Washer (SST).............................................................................................................................4

- 23 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE - MOTOR PARTS

(VON WEISE - 1/4 HP.)

F-17820 Rev. E (February 2015) - 24 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE - MOTOR PARTS

(VON WEISE - 1/4 HP.)

ILLUS. PL-50734

10 00-274231-03 Ball Bearing................................................................................................................................1

11 00-274231-02 Washer.......................................................................................................................................1

12 00-274231-21 Seal............................................................................................................................................1

13 00-274231-23 Spacer Kit - Motor......................................................................................................................1

14 00-274231-22 Ball Bearing................................................................................................................................1

15 00-274231-01 Motor - 60 Hz, 3 Ph....................................................................................................................1

16 00-274231-25 Motor - 50/60 Hz, 1 Ph...............................................................................................................1

17 00-274231-29 Motor - 50 Hz, 3 Ph....................................................................................................................1

18 00-274231-07 Gasket........................................................................................................................................1

19 00-274231-20 Bushing......................................................................................................................................1

20 00-274231-15 Needle Bearing...........................................................................................................................1

21 00-274231-19 Shaft...........................................................................................................................................1

22 00-274231-18 Gear - 60 Hz...............................................................................................................................1

23 00-274231-27 Gear - 50 Hz...............................................................................................................................1

24 00-274231-15 Needle Bearing...........................................................................................................................1

25 00-274231-17 Gear - 60 Hz...............................................................................................................................1

26 00-274231-26 Gear - 50 Hz...............................................................................................................................1

27 00-274231-10 Output Shaft...............................................................................................................................1

28 00-274231-08 Screw - Socket Head..................................................................................................................8

29 00-274231-16 Case...........................................................................................................................................1

PART NO. NAME OF PART AMT.

*1 00-274231-13 Cover..........................................................................................................................................1

*2 00-274231-12 "O" Ring......................................................................................................................................1

*3 00-274231-05 Bearing (Flanged).......................................................................................................................1

*4 00-274231-09 Woodruff Key..............................................................................................................................1

5 00-274231-24 Washer.......................................................................................................................................6

6 00-274231-14 Gear - Output.............................................................................................................................1

7 00-274231-06 Retaining Ring............................................................................................................................2

8 00-274231-04 Washer - Thrust..........................................................................................................................5

9 00-274231-05 Bearing (Flanged).......................................................................................................................1

* Refer to #1 thru 4, for Conveyor Drive Motor and Gear Case

- 25 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE - MOTOR PARTS

(BISON - 1/4 HP.)

F-17820 Rev. E (February 2015) - 26 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONVEYOR DRIVE - MOTOR PARTS

(BISON - 1/4 HP.)

ILLUS. PL-50735

10 00-274231-53 Screw - Torx...............................................................................................................................9

11 00-274231-54 Seal - Motor Shaft......................................................................................................................1

12 00-274231-47 Gasket........................................................................................................................................1

13 00-274231-48 Gear Assy - Output Shaft (Incls #14).........................................................................................1

14 00-274231-56 Ball Bearing................................................................................................................................1

15 00-274231-46 Seal - Output Shaft.....................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-274231-45 Housing Assy (Incls Needle Bearings).......................................................................................1

2 00-274231-49 Ball - 1/4 Dia...............................................................................................................................5

3 00-274231-50 Gear Assy - Intermediate...........................................................................................................1

4 00-274231-51 Gear Assy - High Speed.............................................................................................................1

5 00-274231-52 Stop Device Kit (Set of Spacer Washers)..................................................................................1

6 00-274231-44 Adaptor Assy (Incls Needle Bearings)........................................................................................1

7 00-274231-40 Motor - 60 Hz, 3 Ph (Incls #6 thru 11)........................................................................................1

8 00-274231-41 Motor - 50/60 Hz, 1 Ph (Incls #6 & 11).......................................................................................1

9 00-274231-42 Motor - 50 Hz, 3 Ph (Incls #6 & 11)............................................................................................1

00-270930-1 Motor - Conveyor Dr (208-240/480 V,60 Hz,3 Ph)(Incls #1 thru 7, 10 thru 15)..........................1

00-270930-2 Motor - Conveyor Dr (208-240 V,60 Hz,1 Ph)(Incls #1 thru 6, 8, & 10 thru 15).........................1

00-270930-3 Motor - Conveyor Dr (200-240 V,50 Hz,1 Ph)(Incls #1 thru 6, 8, & 10 thru 15).........................1

00-270930-4 Motor - Conveyor Dr (200-240/380-415 V,50 Hz,3 Ph)(Incls #1 thru 6 & 9 thru 15)

...................................................................................................................................................1

- 27 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

TRACK AND CRADLE

(WASH SECTION)

F-17820 Rev. E (February 2015) - 28 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

TRACK AND CRADLE

(WASH SECTION)

ILLUS. PL-55295

10 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................8

11 NS-015-11 Nut 5/16-18 Hex (SST)............................................................................................................AR

12 WS-017-08 Washer (SST)..........................................................................................................................AR

13 WL-006-23 Lockwasher 5/16 Helical (SST)...............................................................................................AR

14 00-271074 Baffle - Lower (R-L Only)............................................................................................................1

15 WL-006-28 Lockwasher 3/8 Medium (Qty for 20 x 20 racks)........................................................................6

16 NS-046-09 Stop Nut 3/8-16 Elastic (Qty for 20 x 20 racks)..........................................................................6

**17 Order one of 00-436927-00001 Cradle & Dog Assy. R-L (Standard Racks Only) or

18 00-436704-1 Dog (Front R-L) (Rear L-R) (Qty for 20 x 20 racks)....................................................................3

19 00-436704-2 Dog - Not Shown (Front L-R) (Rear R-L) (Qty for 20 x 20 racks)...............................................3

20 00-436703-1 Dog (Front R-L)(Rear L-R)(Service for "Z" Bent Cradles Only)(Qty for 20x20 racks)

21 00-436703-2 Dog (Front L-R)(Rear R-L)(Service for "Z" Bent Cradles Only)(Qty for 20x20 racks)

22 00-270983 Spacer (Qty for 20 x 20 racks)...................................................................................................6

23 00-473231 Slider - Large..............................................................................................................................4

24 SC-041-14 Cap Screw 5/16-18 x 1 1/8 Hex Hd (SST).................................................................................8

25 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................8

26 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................8

27 00-436928 Cradle.........................................................................................................................................1

28 00-271012 Baffle - Cradle Upper...............................................................................................................AR

29 SC-041-13 Cap Screw 5/16-18 x 1 Hex Hd (Mounts Front Track)...............................................................2

30 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)..................................................................................10

31 WS-017-01 Washer (SST)...........................................................................................................................20

32 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................14

33 NS-015-11 Nut 5/16-18 Hex (SST).............................................................................................................14

34 00-437047 Deflector - Silverware.................................................................................................................1

35 SC-127-91 Mach Screw 1/4-20 x 5/8 Flat Hd (SST).....................................................................................2

36 WS-003-47 Washer (SST).............................................................................................................................2

37 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

38 NS-015-01 Nut 1/4-20 Hex (SST).................................................................................................................2

39 00-328789 Rack Track (C54A).....................................................................................................................2

40 SC-041-12 Cap Screw 5/16-18 x 7/8 Hex Hd...............................................................................................4

41 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................4

42 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................8

43 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................8

44 00-328793 Cradle (C54A)............................................................................................................................1

45 00-274559 Screw - Connecting (C54A)........................................................................................................2

46 WS-017-01 Washer (SST).............................................................................................................................4

47 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

48 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

49 SC-041-31 Cap Screw 3/8-16 x 1 1/4 Hex Hd..............................................................................................2

50 WS-018-04 Washer (SST).............................................................................................................................2

51 00-436704-1 Dog (Front R-L) (Rear L-R) (C54A)............................................................................................1

52 00-436704-2 Dog (Front L-R) (Rear R-L) (C54A)............................................................................................1

53 00-270983 Spacer........................................................................................................................................2

54 NS-046-09 Stop Nut 3/8-16 Elastic...............................................................................................................2

55 WL-006-28 Lockwasher 3/8 Helical..............................................................................................................2

PART NO. NAME OF PART AMT.

1 00-436873-1 Rack Track.................................................................................................................................2

*2 Rack Track (Not Available) Order...........................................................................................AR

3 00-270977 Roller..........................................................................................................................................4

4 WS-018-04 Washer (SST).............................................................................................................................4

5 WS-018-04 Washer (Qty for 20 x 20 racks)..................................................................................................6

6 SC-041-31 Cap Screw 3/8-16 x 1 1/4 Hex Hd (Qty for 20 x 20 racks).........................................................6

7 SC-041-10 Cap Screw 5/16-18 x 5/8 Hex Hd............................................................................................AR

8 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................8

9 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................8

00-436927-00002 Cradle & Dog Assy. L-R (Standard Racks Only.........................................AR

...................................................................................................................................................3

- 29 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

TRACK AND CRADLE

(WASH SECTION)

ILLUS. PL-55295

56 00-473231 Slider - Large (C54A).................................................................................................................2

57 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................4

58 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

59 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

60 00-328795-1 Support - Tank (C54A)...............................................................................................................1

61 00-328790 Drive Bracket (C54A).................................................................................................................1

62 SC-041-12 Cap Screw 5/16-18 x 7/8 Hex Hd...............................................................................................4

63 WS-017-01 Washer (SST).............................................................................................................................2

64 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

65 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

PART NO. NAME OF PART AMT.

00-328794 Cradle Dog Assy (C54A) (Incls nos. 44 and 49 thru 59)............................................................1

* 00-436968 Rack Track Assy. (Incls. Items 1 & 23 thru 26) Qty 2

** And Rack Track Assy. (Incls. Items 1 & 23 thru 26) Aslo req'd Item 29 & 31

F-17820 Rev. E (February 2015) - 30 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 31 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

WASH ARMS & TUBES

(WASH SECTION - PREVIOUS CONSTRUCTION)

F-17820 Rev. E (February 2015) - 32 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

WASH ARMS & TUBES

(WASH SECTION - PREVIOUS CONSTRUCTION)

ILLUS. PL-55502

10 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

11 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

12 00-289760 Latch...........................................................................................................................................1

13 00-67500-110 "O" Ring......................................................................................................................................1

14 SC-053-42 Mach. Screw 1/4-20 x 5/8 Slotted Truss Hd. (SST)................................................................AR

15 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

16 NS-015-01 Nut 1/4-20 Hex (SST)..............................................................................................................AR

17 SC-041-05 Cap Screw 1/4-20 x 5/8 Hex Hd (SST)...................................................................................AR

18 WS-022-01 Washer....................................................................................................................................AR

19 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

20 NS-015-01 Nut 1/4-20 Hex (SST)..............................................................................................................AR

21 00-185732 Bracket....................................................................................................................................AR

22 SC-041-01 Cap Screw 1/4-20 x 3/4 Hex Hd (SST)......................................................................................1

23 WS-022-01 Washer.......................................................................................................................................2

24 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................1

25 NS-015-01 Nut 1/4-20 Hex (SST).................................................................................................................1

26 SC-041-09 Cap Screw 5/16-18 x 1/2 Hex Hd...............................................................................................2

27 NS-031-19 Stop Nut 1/4-20 Elastic (SST)....................................................................................................2

28 00-271031 Bracket.......................................................................................................................................1

29 WS-017-08 Washer (SST).............................................................................................................................2

30 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

31 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

32 00-274057 Wash Pipe (26 1/8 Door Height)................................................................................................1

33 00-274721 Wash Pipe (32 1/8 Door Height)................................................................................................1

34 SC-041-18 Cap Screw 5/16-18 x 1 3/4 Hex Hd (SST).................................................................................4

35 WS-017-08 Washer (SST).............................................................................................................................8

36 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

37 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

38 00-270968 Gasket - Wash Pipe...................................................................................................................1

39 00-67500-110 "O" Ring......................................................................................................................................1

40 00-475087 Plug - Wash Arm.....................................................................................................................AR

41 00-271034 Catch - Adjustable......................................................................................................................1

42 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

43 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

44 WS-017-08 Washer (SST).............................................................................................................................2

45 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................2

46 00-274222 Support - Adjustable...................................................................................................................1

47 SC-041-13 Cap Screw 5/16-18 x 1 Hex Hd (AW Series).............................................................................2

48 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST) (A Series)...................................................................2

49 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

50 WS-017-08 Washer (SST).............................................................................................................................2

51 NS-015-11 Nut 5/16-18 Hex (SST)............................................................................................................AR

52 00-271035 Wash Arm - Lower (A Series).....................................................................................................1

53 00-437065 Wash Arm - Lower (AW Series).................................................................................................1

54 00-475087 Plug - Wash Arm.....................................................................................................................AR

55 00-436945 Wash Arm - Upper (R-L & L-R) (AW Series)..............................................................................1

56 00-436947-1 Hanger (AW Series)...................................................................................................................1

57 SC-041-50 Cap Screw 1/4-20 x 1/2 Hex Hd (AW Series)............................................................................2

58 WL-006-17 Lockwasher 1/4 Medium (AW Series)........................................................................................2

59 00-271040 Wash Arm - Upper (R-L) (A Series)...........................................................................................1

60 00-271831 Wash Arm - Upper (L-R) (A Series)...........................................................................................1

PART NO. NAME OF PART AMT.

1 00-271026 Hanger - Upper Wash Arm......................................................................................................AR

2 SC-053-42 Mach. Screw 1/4-20 x 5/8 Slotted Truss Hd. (SST)................................................................AR

3 WS-022-01 Washer....................................................................................................................................AR

4 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

5 NS-015-01 Nut 1/4-20 Hex (SST)..............................................................................................................AR

6 00-271029 Guide - Upper Wash Arm...........................................................................................................1

7 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................2

8 WS-017-01 Washer (SST).............................................................................................................................2

9 WS-017-08 Washer (SST).............................................................................................................................2

- 33 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

WASH ARMS & TUBES

(WASH SECTION)

F-17820 Rev. E (February 2015) - 34 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

WASH ARMS & TUBES

(WASH SECTION)

ILLUS. PL-55296

10 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

11 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

12 00-289760 Latch...........................................................................................................................................1

13 00-67500-110 "O" Ring......................................................................................................................................1

14 SC-041-01 Cap Screw 1/4-20 x 3/4 Hex Hd (SST)......................................................................................1

15 WS-022-01 Washer.......................................................................................................................................2

16 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................1

17 NS-015-01 Nut 1/4-20 Hex (SST).................................................................................................................1

18 SC-041-01 Cap Screw 1/4-20 x 3/4 Hex Hd (SST)......................................................................................2

19 NS-031-19 Stop Nut 1/4-20 Elastic (SST)....................................................................................................2

20 00-812817 Bracket.......................................................................................................................................1

21 WS-017-08 Washer (SST).............................................................................................................................2

22 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

23 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

24 00-329595 Wash Pipe (26 1/8 Door Height)................................................................................................1

25 00-329597 Wash Pipe (32 1/8 Door Height)................................................................................................1

26 00-475589 Plug - Wash Arm.....................................................................................................................AR

27 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

28 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

29 WS-017-08 Washer (SST).............................................................................................................................8

30 SC-041-18 Cap Screw 5/16-18 x 1 3/4 Hex Hd (SST).................................................................................4

31 00-270968 Gasket - Wash Pipe...................................................................................................................1

32 00-67500-110 "O" Ring......................................................................................................................................1

33 00-475589 Plug - Wash Arm.....................................................................................................................AR

34 00-67500-127 "O" Ring...................................................................................................................................AR

35 00-436939-2 Catch - Adjustable (RH).............................................................................................................1

36 00-436939-1 Catch - Adjustable (LH)..............................................................................................................1

37 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

38 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

39 WS-017-08 Washer (SST).............................................................................................................................2

40 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................2

41 00-274222 Support - Adjustable...................................................................................................................1

42 SC-041-13 Cap Screw 5/16-18 x 1 Hex Hd (AW Series).............................................................................2

43 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST) (A Series)...................................................................2

44 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

45 WS-017-08 Washer (SST).............................................................................................................................2

46 NS-015-11 Nut 5/16-18 Hex (SST)............................................................................................................AR

47 00-749405 Wash Arm - Lower (A Series).....................................................................................................1

48 00-749418 Wash Arm - Lower (AW Series).................................................................................................1

49 00-67500-127 "O" Ring...................................................................................................................................AR

50 00-749419 Wash Arm - Upper (R-L & L-R) (AW Series)..............................................................................1

51 00-436947-1 Hanger (AW Series)...................................................................................................................1

52 SC-041-50 Cap Screw 1/4-20 x 1/2 Hex Hd (AW Series)............................................................................2

53 WL-006-17 Lockwasher 1/4 Medium (AW Series)........................................................................................2

54 00-749406 Wash Arm - Upper (R-L) (A Series)...........................................................................................1

55 00-749407 Wash Arm - Upper (L-R) (A Series)...........................................................................................1

PART NO. NAME OF PART AMT.

1 00-271026 Hanger - Upper Wash Arm......................................................................................................AR

2 SC-125-85 Mach Screw 1/4 20 X 5/8 Truss Hd (SST)..............................................................................AR

3 WS-022-01 Washer....................................................................................................................................AR

4 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

5 NS-015-01 Nut 1/4-20 Hex (SST)..............................................................................................................AR

6 00-436007 Guide - Upper Wash Arm...........................................................................................................1

7 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................2

8 WS-017-01 Washer (SST).............................................................................................................................2

9 WS-017-08 Washer (SST).............................................................................................................................2

- 35 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

(PREVIOUS CONSTRUCTION)

F-17820 Rev. E (February 2015) - 36 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

(PREVIOUS CONSTRUCTION)

ILLUS. PL-51069

10 00-186925 Screen - Line Strainer................................................................................................................1

11 00-328247 Gauge - Water Pressure............................................................................................................1

12 00-436319 Petcock 1/4 ................................................................................................................................1

13 00-63262-31 Flange & Nipple..........................................................................................................................1

14 00-271023 Piping - Inside.............................................................................................................................1

15 NS-015-01 Nut 1/4-20 Hex (SST)(CRS76A,66A/AW & CPW90A,80A/AW).................................................1

16 00-271006-1 Solenoid Valve 3/8 (120 V.) (Incls. #18 & 20) (Fill)....................................................................1

17 00-271006-2 Solenoid Valve 3/8(208-240 V)(Incls #19 & 20)(Fill)(Used W/O 120 V pilot circuit)

18 00-271839-1 Coil - Solenoid Valve..................................................................................................................1

19 00-271839-2 Coil - Solenoid Valve..................................................................................................................1

20 00-271837 Service Kit - 3/8 Solenoid Valve.................................................................................................1

21 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil. Truss Hd., Type T (C54A,44A,&AW)................................4

22 00-271008 Vacuum Breaker (3/8 In.)...........................................................................................................1

23 00-274233 Service Kit - Vacuum Breaker....................................................................................................1

24 00-271007 Fill Piping - Outside....................................................................................................................1

25 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................2

26 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

27 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

28 WL-006-17 Lockwasher 1/4 Medium (CRS76A,66A/AW & CPW90A,80A/AW)...........................................1

29 00-271009 Fill Piping....................................................................................................................................1

31 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................2

32 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

33 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

34 00-435074 Piping - Common Connection....................................................................................................1

35 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................2

36 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

37 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

38 FE-008-10 1/2 Gasket Assy (C54A,44A,&AW)............................................................................................2

39 FE-006-07 Lock Nut 1/2 (Cnd.) (C54A,44A,&AW).......................................................................................1

40 00-63262-6 Flange & Nipple..........................................................................................................................1

41 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

42 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

43 WS-029-05 Washer (SST).............................................................................................................................2

44 SC-041-10 Cap Screw 5/16-18 x 5/8 Hex Hd. (SST)...................................................................................2

45 00-271002-1 Solenoid Valve 3/4 (120 V.) (Incls. #47 & 49) (Rinse)................................................................1

46 00-271002-2 Solenoid Valve 3/4(208-240 V)(Incls #48 & 49)(Rinse)(W/O 120 V pilot circuit)........................1

47 00-271839-1 Coil - Solenoid Valve (120 V.)....................................................................................................1

48 00-271839-2 Coil - Solenoid Valve (208-240 V.).............................................................................................1

49 00-271838 Service Kit - 3/4 Solenoid Valve.................................................................................................1

50 00-271001 Piping - Final Rinse....................................................................................................................1

51 00-119244 Cap & Stud Assy (CRS76A,66A/AW & CPW90A,80A/AW).......................................................1

52 00-67500-31 "O" Ring (CRS76A,66A/AW & CPW90A,80A/AW).....................................................................1

53 00-119254 Retainer - Cap & Stud (CRS76A,66A/AW & CPW90A,80A/AW)...............................................1

54 00-122674 Float Assy (C54A,44A,&AW)......................................................................................................1

55 FE-006-45 Connector - Straight 1/2 (Thinwall) (C54A,44A,&AW)................................................................1

56 FE-024-49 Connector - Straight 1/2 (Thinwall) (C54A,44A,&AW)................................................................1

PART NO. NAME OF PART AMT.

1 00-277112 Vacuum Breaker (3/4)................................................................................................................1

2 00-118270 Service Kit - Vacuum Breaker (Float & Seal Assy.)...................................................................1

3 FP-015-23 Elbow 3/4 x 90 Deg. (Brass).......................................................................................................1

4 FP-041-88 Nipple 3/4 x 5 Lg. TBE (Brass)...................................................................................................1

5 FP-042-12 Nipple 3/4 x 8 1/4 Lg. TBE (Brass).............................................................................................1

6 00-271022 Bracket.......................................................................................................................................1

7 00-186922 Line Strainer (3/4) (Incls. #8, 9, & 10)........................................................................................1

8 00-186923 Plug - Branch..............................................................................................................................1

9 00-186924 Gasket - Branch Plug.................................................................................................................1

...................................................................................................................................................1

- 37 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

(PREVIOUS CONSTRUCTION)

ILLUS. PL-51069

57 FE-006-05 Lock Nut 1/2 (C54A,44A,&AW)..................................................................................................1

58 00-112007 Gasket (C54A,44A,&AW)...........................................................................................................1

59 00-288465 Lid & Gasket Assy. (Incls. #58)(C54A,44A,&AW)......................................................................1

60 NS-018-28 Jam Nut 1/2-20 Hex (C54A,44A,&AW)......................................................................................1

61 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)(C54A,44A,&AW)..................................................1

62 WS-010-40 Washer - Thrust (C54A,44A,&AW).............................................................................................1

63 00-270926 Junction Box - Auto Fill (RH) (R-L) (C54A,44A,&AW)................................................................1

64 00-67500-72 "O" Ring (C54A,44A,&AW).........................................................................................................1

65 00-112467 Retainer - Float (C54A,44A,&AW)..............................................................................................1

66 00-328486 Probe & Switch Assy(2 Wire)(Water Level)(Incls #54,64,65)(Order 2 jumpers 328758)

67 RR-010-13 Retaining Ring (C54A,44A,&AW)...............................................................................................1

68 00-893294 Valve - Pressure Regulating (3/4 In.) Valve - Pressure Regulating 3/4"....................................1

69 00-289091-1 Kit - Service................................................................................................................................1

70 00-67500-12 "O" Ring......................................................................................................................................1

71 00-67500-12 "O" Ring......................................................................................................................................2

PART NO. NAME OF PART AMT.

...................................................................................................................................................1

F-17820 Rev. E (February 2015) - 38 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 39 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

(CURRENT CONSTRUCTION)

F-17820 Rev. E (February 2015) - 40 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

(CURRENT CONSTRUCTION)

ILLUS. PL-55302

10 00-271839-2 Coil - Solenoid Valve..................................................................................................................1

11 00-271837 Service Kit - 1/2 Solenoid Valve.................................................................................................1

12 00-271008-2 Vacuum Breaker 3/8...................................................................................................................1

13 00-274233 Service Kit - Vacuum Breaker....................................................................................................1

14 00-329609 Fill Piping - Outside....................................................................................................................1

15 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................2

16 00-67500-12 "O" Ring......................................................................................................................................1

17 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

18 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

19 00-328765 Adapter - Elbow..........................................................................................................................1

20 00-435972-2 Piping - Inside (RH)....................................................................................................................1

21 00-435972-1 Piping - Inside (LH).....................................................................................................................1

22 00-812946-1 Piping Sub-Assy R-L..................................................................................................................1

23 00-812946-2 Piping Sub-Assy L-R..................................................................................................................1

24 00-435967 Plate - Fill Piping........................................................................................................................1

25 00-435974 Bracket - Fill Piping....................................................................................................................1

26 SC-041-12 Cap Screw 5/16-18 x 7/8 Hex Hd...............................................................................................2

27 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................2

28 WS-029-05 Washer (SST).............................................................................................................................6

29 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

30 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................4

31 00-271002-1 Solenoid Valve 3/4 (120 V)(Incls #33 & 35)...............................................................................1

32 00-271002-2 Solenoid Valve 3/4 (208-240 V) (Incls #34 & 35).......................................................................1

33 00-271839-1 Coil - Solenoid Valve..................................................................................................................1

34 00-271839-2 Coil - Solenoid Valve..................................................................................................................1

35 00-271838 Service Kit - 3/4 Solenoid Valve.................................................................................................1

36 00-328764 Adapter Elbow 3/4 x 90 Deg.......................................................................................................1

37 00-277112-3 Vacuum Breaker.........................................................................................................................1

38 00-118270 Service Kit - Vacuum Breaker (Float & Seal Assy)....................................................................1

39 00-893294 Valve - Pressure Regulating (3/4 In.) Valve - Pressure Regulating 3/4"....................................1

40 00-289091-1 Kit - Repair (Pressure Regulating Valve)...................................................................................1

41 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T (C54A, 44A, & AW)...............................4

42 00-288465 Lid & Gasket Assy (Incls # 43)(C54A, 44A, & AW)....................................................................1

43 00-112007 Gasket (C54A, 44A, & AW)........................................................................................................1

44 FE-006-07 Lock Nut 1/2 (Cnd)(C54A, 44A, & AW)......................................................................................1

45 NS-018-28 Jam Nut 1/2-20 Hex (C54A, 44A, & AW)...................................................................................1

46 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)(C54A, 44A, & AW)...............................................1

47 WS-010-40 Washer - Thrust (C54A, 44A, & AW)..........................................................................................1

48 00-270926 Junction Box - Auto Fill (RH) (R-L)(C54A, 44A, & AW)(C54A, 44A, & AW)...............................1

49 00-67500-72 "O" Ring (C54A, 44A, & AW)......................................................................................................1

50 00-112467 Retainer - Float (C54A, 44A, & AW)...........................................................................................1

51 00-328486 Probe & Switch Assy(Water Level)(Incls #49, 50, & 54)(C54A, 44A, & AW).............................1

52 RR-010-13 Retaining Ring (C54A, 44A, & AW)............................................................................................1

53 FE-008-10 1/2 Gasket Assy (C54A, 44A, & AW).........................................................................................2

54 00-122674 Float Assy (C54A, 44A, & AW)...................................................................................................1

55 FE-006-45 Connector - Straight 1/2 (Thinwall)(C54A, 44A, & AW)..............................................................1

PART NO. NAME OF PART AMT.

1 00-186922 Line Strainer (3/4) (Incls #2, 3, & 4)...........................................................................................1

2 00-186923 Plug - Branch..............................................................................................................................1

3 00-186924 Gasket - Branch Plug.................................................................................................................1

4 00-186925 Screen - Line Strainer................................................................................................................1

5 00-328247 Gauge - Water Pressure............................................................................................................1

6 00-436319 Petcock 1/4 ................................................................................................................................1

7 00-271006-1 Solenoid Valve 3/8 (120 V) (Incls #9 & 11)................................................................................1

8 00-271006-2 Solenoid Valve 3/8 (208-240 V)(Incls #10 & 11)(Used W/O 120 V pilot circuit).........................1

9 00-271839-1 Coil - Solenoid Valve..................................................................................................................1

- 41 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

(CURRENT CONSTRUCTION)

ILLUS. PL-55302

56 FE-024-49 Connector - Straight 1/2 (Thinwall)(C54A, 44A, & AW)..............................................................1

57 FE-006-05 Lock Nut 1/2 ..............................................................................................................................1

58 NS-015-01 Nut 1/4-20 Hex (SST)(CRS76A, 66A/AW & CPW90A, 80A/AW)...............................................1

59 00-119244 Cap & Stud Assy (CRS76A, 66A/AW & CPW90A, 80A/AW).....................................................1

60 00-67500-31 "O" Ring (CRS76A, 66A/AW & CPW90A, 80A/AW)...................................................................1

61 00-119254 Retainer - Cap & Stud (CRS76A, 66A/AW & CPW90A, 80A/AW).............................................1

62 WL-006-17 Lockwasher 1/4 Medium (CRS76A, 66A/AW & CPW90A, 80A/AW).........................................1

PART NO. NAME OF PART AMT.

F-17820 Rev. E (February 2015) - 42 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 43 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

INSIDE METALLIC RINSE PIPING

F-17820 Rev. E (February 2015) - 44 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

INSIDE METALLIC RINSE PIPING

ILLUS. PL-55304

10 00-328805-1 Final Rinse Inside Piping (R-L) (26 1/8 Door Height)(C54A Series)..........................................1

11 00-328805-2 Final Rinse Inside Piping (L-R) (26 1/8 Door Height)(C54A Series)..........................................1

12 00-328812-1 Final Rinse Inside Piping (R-L) (32 1/8 Door Height)(C54A Series)..........................................1

13 00-328812-2 Final Rinse Inside Piping (L-R) (32 1/8 Door Height)(C54A Series)..........................................1

14 00-328058-1 Lower Rinse Arm (R-L) 6 Nozzles (Incls 20, 33, & 40)(C44AW Series).....................................1

15 00-328058-2 Lower Rinse Arm (L-R) 6 Nozzles (Incls 20, 33, & 40)(C44AW Series).....................................1

16 00-271027-1 Lower Rinse Arm (R-L) 5 Nozzles (Incls 20, 33, & 41)(C44A Series)........................................1

17 00-271027-2 Lower Rinse Arm (L-R) 5 Nozzles (Incls 20, 33, & 41)(C44A Series)........................................1

18 00-328807-1 Lower Rinse Arm (R-L) 5 Nozzles (Incls 20, 33, & 42)(C54A Series)........................................1

19 00-328807-2 Lower Rinse Arm (L-R) 5 Nozzles (Incls 20, 33, & 42)(C54A Series)........................................1

20 FP-030-27 Lock Nut 1/2 NPSL Pipe (Brass)................................................................................................1

21 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................1

22 FP-030-27 Lock Nut 1/2 NPSL Pipe (Brass)................................................................................................1

23 00-437063-1 Upper Rinse Arm (R-L) 6 Nozzles (Incls 22, 36, & 38)(C44AW Series).....................................1

24 00-437063-2 Upper Rinse Arm (L-R) 6 Nozzles (Incls 22, 36, & 38)(C44AW Series).....................................1

25 00-271088-1 Upper Rinse Arm (R-L) 6 Nozzles (Incls 22, 36, & 37)(C44A Series)........................................1

26 00-271088-2 Upper Rinse Arm (L-R) 6 Nozzles (Incls 22, 36, & 37)(C44A Series)........................................1

27 00-328808-1 Upper Rinse Arm (R-L) 6 Nozzles (Incls 22, 36, & 39)(C54A Series)........................................1

28 00-328808-2 Upper Rinse Arm (L-R) 6 Nozzles (Incls 22, 36, & 39)(C54A Series)........................................1

29 SC-053-18 Mach Screw 5/16-18 x 7/8 Truss Hd (SST)................................................................................2

30 00-67500-12 "O" Ring......................................................................................................................................1

31 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................2

32 00-119127 Pipe Plug 1/8 Sq Hd...................................................................................................................1

33 FP-029-08 Pipe Cap 1/2 (Brass)..................................................................................................................1

34 SC-127-93 Mach Screw 5/16-18 x 1/2 Truss Hd (SST)................................................................................1

35 00-274058 Bracket.......................................................................................................................................1

36 FP-029-08 Pipe Cap 1/2 (Brass)..................................................................................................................1

37 00-81812 Nozzle - Rinse (Brass) (078 Dia Orifice)(C44A Series)..............................................................6

38 00-81812-3 Nozzle - Rinse (Brass) (036 Dia Orifice)(C44AW Series)..........................................................6

39 00-81812-4 Nozzle - Rinse (Brass) (094 Dia Orifice)(C54A Series)..............................................................6

40 00-328059 Nozzle - Rinse (Brass) (041 Dia Orifice)(C44AW Series)..........................................................6

41 00-22731-3 Nozzle - Rinse (SST) #50 Drill (070 Dia Orifice)(C44A Series)..................................................5

42 00-22731-2 Nozzle - Rinse (SST) (093 Dia Orifice)(C54A Series)................................................................5

43 00-67500-12 "O" Ring (C54A Series)..............................................................................................................2

44 00-328806 Connector - Rinse Piping (C54A Series)....................................................................................1

45 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd (C54A Series)....................................................................2

46 WL-006-23 Lockwasher 5/16 Medium (SST) (C54A Series)........................................................................2

47 NS-015-11 Nut 5/16-18 Hex (C54A Series)..................................................................................................2

48 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

49 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

50 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................1

51 SC-125-28 Mach Screw 10-24 x 1 Truss Hd (SST)......................................................................................1

52 NS-031-16 Stop Nut 10-24 Hex (SST).........................................................................................................1

53 00-122402-2 Flange (C54A Series).................................................................................................................1

54 00-276407 Gasket - Rinse Pipe (C54A Series)............................................................................................1

55 SC-127-94 Mach Screw 5/16-18 x 7/8 Truss Hd (SST)(C54A Series).........................................................2

56 WS-029-05 Washer (C54A Series)...............................................................................................................2

57 WL-006-23 Lockwasher 5/16 Medium (SST) (C54A Series)........................................................................2

58 NS-015-11 Nut 5/16-18 Hex (C54A Series)..................................................................................................2

PART NO. NAME OF PART AMT.

1 00-271004 Final Rinse Outside Piping (R-L)................................................................................................1

2 00-329610-2 Final Rinse Outside Piping (L-R)................................................................................................1

3 00-67500-12 "O" Ring......................................................................................................................................2

6 00-271010-1 Final Rinse Inside Piping (R-L) (26 1/8 Door Height) (C44A & AW)..........................................1

7 00-271010-2 Final Rinse Inside Piping (L-R) (26 1/8 Door Height) (C44A & AW)..........................................1

8 00-274707-1 Final Rinse Inside Piping (R-L) (32 1/8 Door Height) (C44A & AW)..........................................1

9 00-274707-2 Final Rinse Inside Piping (L-R) (32 1/8 Door Height) (C44A & AW)..........................................1

- 45 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

INSIDE NON-METALLIC RINSE PIPING

(C44A AND AW SERIES)

F-17820 Rev. E (February 2015) - 46 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

INSIDE NON-METALLIC RINSE PIPING

(C44A AND AW SERIES)

ILLUS. PL-55305

10 00-435070 Mixer - Spiral..............................................................................................................................1

11 00-274531-1 Tube - Inside Rinse (6 1/8 Lg)....................................................................................................1

12 00-274708 Tube - Inside Rinse (32 1/8 Door Height)...................................................................................1

13 00-274536 Tube - Inside Rinse (26 1/8 Door Height)...................................................................................1

14 SC-053-50 Mach Screw 10-24 x 1 1/2 Truss Hd (SST)................................................................................1

15 WL-006-07 Lockwasher #10 Helical (SST)...................................................................................................1

16 NS-011-18 Mach Nut 10-24 Hex (SST)........................................................................................................1

17 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................1

18 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................1

19 SC-053-15 Mach Screw 5/16-18 x 1/2 Truss Hd (SST)................................................................................1

20 00-274058 Bracket.......................................................................................................................................1

21 00-185781 Elbow - 1/2" x 90 Deg (PVC)......................................................................................................1

22 00-436355 Lower Rinse Arm (R-L) 6 Nozzles - C44AW (Incls Items 19 & 26)............................................1

23 00-436355-2 Lower Rinse Arm (L-R) 6 Nozzles - C44AW (Incls Items 19 & 26)............................................1

24 00-274534 Lower Rinse Arm (R-L) 5 Nozzles - C44A (Incls Items 26 & 27)................................................1

25 00-274534-2 Lower Rinse Arm (L-R) 5 Nozzles - C44A (Incls Items 26 & 27)................................................1

26 00-328059-2 Nozzle - Rinse (SST)..................................................................................................................6

27 WL-006-16 Lockwasher 1/4 Helical (SST)....................................................................................................2

28 NS-015-01 Nut 1/4-20 Hex (SST).................................................................................................................2

29 00-274570 Bracket.......................................................................................................................................1

30 SC-128-05 Mach Screw 1/4-20 x 1/2 Fil Hd (SST).......................................................................................2

31 00-276380-2 Cap - Lower Rinse Arm..............................................................................................................1

32 00-22731-6 Nozzle - Rinse (SST) (.035 Dia Orifice).....................................................................................5

33 WL-006-16 Lockwasher 1/4 Helical (SST)....................................................................................................2

34 NS-015-01 Nut 1/4-20 Hex (SST).................................................................................................................2

35 00-274532-1 Bracket (R-L)..............................................................................................................................1

36 00-274532-2 Bracket (L-R)..............................................................................................................................1

37 SC-024-06 Mach Screw 1/4-20 x 1/2 Fil Hd (SST).......................................................................................2

38 00-276380-2 Cap - Lower Rinse Arm..............................................................................................................1

39 00-274535 Upper Rinse Arm (R-L) 6 Nozzles - C44A (Incls Items 28 & 35)................................................1

40 00-274535-2 Upper Rinse Arm (L-R) 6 Nozzles - C44A (Incls Items 28 & 35)................................................1

41 00-436356 Upper Rinse Arm (R-L) 6 Nozzles - C44AW (Incls Items 29 & 35)............................................1

42 00-436356-2 Upper Rinse Arm (L-R) 6 Nozzles - C44AW (Incls Items 29 & 35)............................................1

43 00-81812-2 Nozzle - Rinse (SST) (.078 Dia Orifice).....................................................................................6

44 00-81812-6 Nozzle - Rinse (SST) (.036 Dia Orifice).....................................................................................6

45 FP-085-51 Tee 1/2 x 1/2 x 1/2 NPT Schedule 80 PVC................................................................................2

46 00-274531-2 Tube (1 1/4 Lg)...........................................................................................................................1

47 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

48 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

49 00-274533 Flange........................................................................................................................................1

50 SC-053-18 Mach Screw 5/16-18 x 7/8 Truss Hd (SST)................................................................................2

51 00-67500-12 "O" Ring......................................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-329608-1 Final Outside Rinse Piping (R-L)................................................................................................1

2 00-329608-2 Final Outside Rinse Piping (L-R)................................................................................................1

3 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd............................................................................................2

4 00-119127 Pipe Plug 1/8 Sq Hd...................................................................................................................2

5 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

6 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

7 00-67500-12 "O" Ring......................................................................................................................................2

8 00-274533 Flange........................................................................................................................................1

9 00-185781 Elbow - 1/2" x 90 Deg (PVC)......................................................................................................1

- 47 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

ACTUATOR MECHANISM & RINSE DRAIN-OFF PAN

F-17820 Rev. E (February 2015) - 48 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

ACTUATOR MECHANISM & RINSE DRAIN-OFF PAN

ILLUS. PL-55297

10 00-436828-1 Rinse Pan Assy (L-R).................................................................................................................1

11 00-328326 Flange & Nipple Assy.................................................................................................................1

12 00-475056 Flange & Nipple Assy - 1"..........................................................................................................1

13 00-436827 Gasket........................................................................................................................................1

14 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

15 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

16 00-328803 Pan Rinse (C54A)......................................................................................................................2

17 00-120115 Retainer - Seal...........................................................................................................................2

18 00-77621-2 Ring - Sealing.............................................................................................................................1

19 00-120603 Gasket - Seal Retainer...............................................................................................................2

20 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

21 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd...........................................................................................4

22 WS-017-08 Washer (SST).............................................................................................................................8

23 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

24 00-328798 Flowback Pipe (C54A)................................................................................................................1

25 00-120603 Gasket - Seal Retainer...............................................................................................................1

26 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................4

27 WS-017-08 Washer (SST).............................................................................................................................8

28 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

29 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

30 NS-029-01 Wing Nut 1/4 -20 (Qty for 1 mech;Qty varys w/type & side loader option).................................2

31 WL-006-17 Lockwasher 1/4 Medium (Qty for 1 mech;Qty varys w/type & side loader option).....................2

32 WS-017-06 Washer (Qty for 1 mech;Qty varys w/type & side loader option)................................................2

33 SC-053-42 Mach Screw 1/4-20x5/8 Truss Hd(SST)(Qty for 1 mech;Qty varys w/type & side

34 00-270996 Insulator - Switch (Qty for 1 mech;Qty varys w/type & side loader option)................................1

35 NS-031-50 Stop Nut 6-32 Hex (SST) (Qty for 1 mech;Qty varys w/type & side loader option)....................2

36 00-749347 Switch - Reed Encapsulated (Qty for 1 mech;Qty varys w/type & side loader option)

37 00-290160 Magnet (Dot Toward Switch)(Qty for 1 mech;Qty varys w/type & side loader option)

38 00-290159 Retainer - Magnet (Qty for 1 mech;Qty varys w/type & side loader option)...............................1

39 SC-127-26 Mach Screw 6-32 x 3/8 Rd Hd (SST)(Qty for 1 mech;Qty varys w/type & side loader)

40 PC-005-07 Cotter Pin 3/32 x 1/2 (Qty for 1 mech;Qty varys w/type & side loader option)...........................1

41 NS-031-50 Stop Nut 6-32 Hex (SST)(Qty for 1 mech;Qty varys w/type & side loader option).....................2

42 WL-006-23 Lockwasher 5/16 Medium (SST)(Qty for 1 mech;Qty varys w/type & side loader option)

43 WS-017-08 Washer (Qty for 1 mech;Qty varys w/type & side loader option)................................................2

44 NS-015-11 Nut 5/16 -18 Hex (Qty for 1 mech;Qty varys w/type & side loader option).................................2

45 00-813534 Shroud (Qty for 1 mech;Qty varys w/type & side loader option)................................................1

46 00-435808 Actuator (C44A/AW & C54A,Front L-R;RS & PW,Rear R-L)(Previous Construction)

47 00-435809 Actuator (C44A/AW & C54A,Front R-L;RS & PW,Rear L-R)(Previous Construction)

48 00-436955 Actuator (C44A/AW & C54A, R-L) (Current Construction).........................................................1

49 00-436027 Actuator (C44A/AW & C54A, L-R) (Current Construction).........................................................1

50 PC-005-07 Cotter Pin 3/32 x 1/2...................................................................................................................1

51 FP-085-06 Elbow 3/4 Hose Male to 3/4 Male Pipe Thd (PVC)....................................................................1

52 00-534177 Clamp - Hose #12......................................................................................................................1

53 00-271013-2 Hose - Drain (L-R)......................................................................................................................1

54 00-271013-1 Hose - Drain (R-L)......................................................................................................................1

55 00-534177 Clamp - Hose #12......................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-812922-1 Strainer.......................................................................................................................................1

2 00-276407 Gasket - Rinse Pipe...................................................................................................................1

3 00-122402-2 Flange........................................................................................................................................1

4 SC-041-12 Cap Screw 5/16 -18 x 7/8 Hex Hd..............................................................................................2

5 WS-029-05 Washer (SST).............................................................................................................................2

6 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

7 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

8 00-545595 Sealer (1/8 Rd)........................................................................................................................AR

9 00-436828-2 Rinse Pan Assy (R-L).................................................................................................................1

loader).....................................................................................................................................AR

...................................................................................................................................................1

...................................................................................................................................................2

................................................................................................................................................AR

- 49 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

ACTUATOR MECHANISM & RINSE DRAIN-OFF PAN

ILLUS. PL-55297

56 00-270948 Final Rinse Fitting.......................................................................................................................1

57 00-270949 Spacer - Final Rinse Fitting........................................................................................................1

58 00-271077 Strainer (L-R)..............................................................................................................................1

59 00-274258 Strainer (R-L)..............................................................................................................................1

60 FE-024-31 Cover - Electric Box....................................................................................................................1

61 00-274256 Rinse Pan Assy (R-L).................................................................................................................1

62 00-271843 Rinse Pan Assy (L-R).................................................................................................................1

PART NO. NAME OF PART AMT.

F-17820 Rev. E (February 2015) - 50 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 51 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DRAIN UNIT

(WASH SECTION)

F-17820 Rev. E (February 2015) - 52 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DRAIN UNIT

(WASH SECTION)

ILLUS. PL-51072

10 WL-006-07 Lockwasher #10 Medium (Use in wash on machines with RS or PW).......................................1

11 WS-023-34 Washer (Use in wash on machines with RS or PW)..................................................................1

12 00-271070 Drain Lever (L-R) (Use in wash on machines with RS or PW)...................................................1

13 00-119116 Axle - Drain Lever (Use in wash on machines with RS or PW)..................................................1

14 WL-006-17 Lockwasher 1/4 Medium (Use in wash on machines with RS or PW)........................................1

15 NS-015-01 Nut 1/4 -20 Hex (SST) (Use in wash on machines with RS or PW)...........................................1

16 00-274147 Lift Rod - Drain (Use in wash on machines with RS or PW)......................................................1

17 WS-017-08 Washer (Use in wash on machines with RS or PW)..................................................................1

18 00-79410 Pull Rod Assy - Upper (Use in wash on machines with RS or PW)...........................................1

19 NS-018-06 Jam Nut 5/16 -18 Hex (Use in wash on machines with RS or PW)............................................1

20 00-16269 Nut - Pull Rod Adjustor (Use in wash on machines with RS or PW)..........................................1

21 NS-018-06 Jam Nut 5/16 -18 Hex (Use in wash on machines with RS or PW)............................................1

22 00-289519 Pull Rod Assy - Lower (Use in wash on machines with RS or PW)...........................................1

23 NS-015-11 Nut 5/16 -18 Hex (Use in wash on machines with RS or PW)...................................................1

24 WL-006-23 Lockwasher 5/16 Medium (SST) (Use in wash on machines with RS or PW)...........................1

25 00-67500-118 "O" Ring (Use in wash on machines with RS or PW).................................................................1

26 SC-041-17 Cap Screw 5/16 -18 x 1 1/2 Hex Hd (SST) (Use in wash on machines with RS or PW)

27 00-77466 Plug - Drain (Use in wash on machines with RS or PW)............................................................1

28 WS-017-08 Washer (Use in wash on machines with RS or PW)..................................................................1

29 PC-005-02 Cotter Pin 1/16 x 1/2 (SST) (Use in wash on machines with RS or PW)...................................2

30 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

31 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................1

32 WS-017-01 Washer (SST).............................................................................................................................2

33 00-270952 Retainer......................................................................................................................................1

34 WS-017-01 Washer (SST).............................................................................................................................2

35 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................1

36 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

37 00-119099-2 Tube - Overflow (C44A Before S/N 1056958) (C54A Before S/N 1056964)..............................1

38 00-67500-120 "O" Ring......................................................................................................................................1

39 00-289464 Gasket - Drain............................................................................................................................1

40 00-270947 Sleeve - Drain Body...................................................................................................................1

41 00-289465 Drain Body..................................................................................................................................1

42 00-270946 Drain Body (With 3/4 -14 FPT Port on Side)..............................................................................1

43 FP-028-32 Pipe Plug 2 Sq Hd......................................................................................................................1

44 WS-006-44 Washer.......................................................................................................................................6

45 WL-006-28 Lockwasher 3/8 Helical..............................................................................................................6

46 SC-041-30 Cap Screw 3/8 -16 x 1 Hex Hd (SST)........................................................................................6

47 WS-022-01 Washer.......................................................................................................................................1

48 WS-022-01 Washer (Use in wash on machines with RS or PW)..................................................................1

49 00-106283 Sleeve - Drain Valve Body (Use in wash on machines with RS or PW).....................................1

50 00-328813 Bushing - Drain...........................................................................................................................1

51 SC-041-10 Cap Screw 5/16 -18 x 5/8 Hex Hd (Use in wash on machines with RS or PW).........................2

52 WL-006-23 Lockwasher 5/16 Medium (SST) (Use in wash on machines with RS or PW)...........................2

53 NS-015-11 Nut 5/16 -18 Hex (Use in wash on machines with RS or PW)...................................................2

PART NO. NAME OF PART AMT.

1 SC-021-22 Mach Screw 10-24 x 3/8 Rd Hd (SST).......................................................................................1

2 WL-006-07 Lockwasher #10 Helical (SST)...................................................................................................1

3 WS-023-34 Washer.......................................................................................................................................1

4 00-271070 Drain Lever (L-R)........................................................................................................................1

5 00-119116 Axle - Drain Lever.......................................................................................................................1

6 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................1

7 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................1

8 00-270953 Lift Rod Overflow (C44A Before S/N 1056957) (C54A Before S/N 1056964)............................1

00-918536 Lift Rod Overflow (C44A Starting S/N 851056957) (C54A Stating S/N 851056964)

...................................................................................................................................................1

9 SC-021-22 Mach Screw 10-24 x 3/8 Rd Hd (SST)(Use in wash on machines with RS or PW)...................1

...................................................................................................................................................1

00-119099-3 Tube Overflow (C44A Starting S/N 1056957) (C54A Starting S/N 1056964).........................AR

- 53 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DOOR, CURTAINS, BAFFLES, AND STRAINERS

F-17820 Rev. E (February 2015) - 54 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DOOR, CURTAINS, BAFFLES, AND STRAINERS

ILLUS. PL-55298

10 00-120266-1 Curtain Rod.............................................................................................................................AR

11 00-185864 Catch - Door...............................................................................................................................1

12 PC-005-02 Cotter Pin 1/16 x 1/2 (SST)........................................................................................................1

13 00-12114 Pin..............................................................................................................................................1

14 00-271084 Splash Curtain (26 1/8 Door Height)..........................................................................................2

15 00-271084-2 Splash Curtain (32 1/8 Door Height)..........................................................................................2

16 00-120266-1 Curtain Rod................................................................................................................................2

17 00-120152-55 Splash Curtain Assy (Incls Items 14 & 16) (26 1/8 Door Height)............................................AR

18 00-120152-56 Splash Curtain Assy (Incls Items 15 & 16) (32 1/8 Door Height)............................................AR

19 00-112378-49 Door Slide (26 1/8 Door Height).................................................................................................2

20 00-112378-50 Door Slide (32 1/8 Door Height).................................................................................................2

21 00-271834 Bracket.......................................................................................................................................1

22 00-271833 Baffle - RH Lower (L-R Operation).............................................................................................1

23 SC-041-05 Cap Screw 1/4 -20 x 1/8 Hex Hd (SST).....................................................................................3

24 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................3

25 WS-017-06 Washer (SST).............................................................................................................................6

26 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................3

27 00-328065 Actuator - Lift Drain....................................................................................................................1

28 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................2

29 00-328065 Actuator - Lift Drain....................................................................................................................1

30 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................2

31 00-270996 Insulator - Switch........................................................................................................................1

32 00-290160 Magnet.......................................................................................................................................1

33 00-290159 Retainer - Magnet.......................................................................................................................1

34 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................2

35 00-749347 Switch - Reed Encapsulated......................................................................................................1

36 Door (26 1/8)(NLA-Order either #38 or 39 & #29 to convert to present style)............................1

37 Door (32 1/8)(NLA-Order either #38 or 39 & #29 to convert to present style)............................1

38 00-328064-7 Door (26 1/8)..............................................................................................................................1

39 00-328079-7 Door (32 1/8)..............................................................................................................................1

40 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd (SST).....................................................................................4

41 WS-017-06 Washer (SST).............................................................................................................................8

42 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

43 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

44 WS-022-01 Washer.......................................................................................................................................9

45 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................9

46 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................9

47 00-271049-1 Baffle - Vertical (26-1/8 Door Height).........................................................................................3

48 00-274720-1 Baffle - Vertical (32-1/8 Door Height).........................................................................................3

49 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

50 SC-041-50 Cap Screw 1/4 -20 x 1/2 Hex Hd................................................................................................4

51 WS-022-01 Washer.......................................................................................................................................4

52 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

53 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

54 00-271832 Baffle - LH Lower........................................................................................................................1

55 SC-053-41 Mach Screw 1/4 -20 x 1/2 Truss Hd (SST).................................................................................2

PART NO. NAME OF PART AMT.

1 00-271043-1 Baffle - Unloading (R-L)..............................................................................................................1

2 00-271048 Baffle - Loading (L-R Steam or Electric Heat, C44A Series)......................................................1

3 00-271048-2 Baffle - Loading (L-R Gas Heat, C44A Series) (L-R, C44AW, & C54A Series).........................1

4 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................2

5 00-271046 Baffle - Loading (R-L Steam or Electric Heat, C44A Series)......................................................1

6 00-271046-2 Baffle - Loading (R-L Gas Heat, C44A Series) (R-L, C44AW, & C54A Series).........................1

7 00-271047-1 Baffle - Unloading (L-R)..............................................................................................................1

8 00-120151-1 Splash Curtain (10-C1)............................................................................................................AR

9 00-120151-1 Splash Curtain (10-C1) (Gas Heat, C44A Series or All Heats, C54A, & C44AW Series)

...................................................................................................................................................1

- 55 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DOOR, CURTAINS, BAFFLES, AND STRAINERS

ILLUS. PL-55298

56 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

57 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

58 00-271100 Bucket - Strainer.........................................................................................................................1

59 00-271845 Strainer - Front...........................................................................................................................1

60 00-271847 Strainer - Rear (Not Shown).......................................................................................................1

61 00-271084 Splash Curtain (26 1/8 Door Height) (C54A)..............................................................................1

62 00-271084-2 Splash Curtain (32 1/8 Door Height) (C54A)..............................................................................1

63 00-120266-1 Curtain Rod................................................................................................................................1

PART NO. NAME OF PART AMT.

00-120152-00001 Splash Curtain Assy (Incls. Items 9 & 10)...............................................................................AR

F-17820 Rev. E (February 2015) - 56 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 57 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

VENT HOOD

F-17820 Rev. E (February 2015) - 58 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

VENT HOOD

ILLUS. PL-51074

10 00-75621 Vent Stack Assy.........................................................................................................................1

11 SC-053-02 Mach Screw 10-24 x 1/2 Truss Hd (SST)...................................................................................8

12 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................8

13 00-435799 Drip Shield Assy.........................................................................................................................1

14 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

15 NS-036-12 Stop Nut 3/8 -24 Elastic..............................................................................................................1

16 00-75623 Damper - Vent Stack..................................................................................................................1

17 00-435794-1 Vent Hood Assy (Incls Items 13 thru 16, 18, 19, & 20)..............................................................1

18 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

19 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

20 00-64919 Shaft - Damper...........................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-80553 Drip Shield Assy.........................................................................................................................1

2 00-79467-2 Vent Hood Assy..........................................................................................................................1

3 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd (SST)...................................................................................11

4 NS-031-19 Stop Nut 1/4 -20 Elastic (SST).................................................................................................11

5 NS-036-12 Stop Nut 3/8 -24 Elastic..............................................................................................................1

6 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

7 00-75623 Damper - Vent Stack..................................................................................................................1

8 00-64919 Shaft - Damper...........................................................................................................................1

9 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

- 59 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

EXTENDED HOOD

F-17820 Rev. E (February 2015) - 60 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

EXTENDED HOOD

ILLUS. PL-55299

10 00-75621 Vent Stack Assy.........................................................................................................................1

11 SC-053-02 Mach Screw 10-24 x 1/2 Truss Hd (SST)...................................................................................8

12 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................8

13 00-435799 Drip Shield Assy.........................................................................................................................1

14 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

15 NS-036-12 Stop Nut 3/8 -24 Elastic..............................................................................................................1

16 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

17 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

18 00-75623 Damper - Vent Stack..................................................................................................................1

19 00-64919 Shaft - Damper...........................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-80553 Drip Shield Assy.........................................................................................................................1

2 00-79463-2 Extended Hood Assy..................................................................................................................1

3 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd (SST)...................................................................................13

4 NS-031-19 Stop Nut 1/4 -20 Elastic (SST).................................................................................................13

5 NS-036-12 Stop Nut 3/8 -24 Elastic..............................................................................................................1

6 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

7 00-75623 Damper - Vent Stack..................................................................................................................1

8 00-64919 Shaft - Damper...........................................................................................................................1

9 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

- 61 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

MISCELLANEOUS

(WASH SECTION)

F-17820 Rev. E (February 2015) - 62 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

MISCELLANEOUS

(WASH SECTION)

ILLUS. PL-55498

10 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

11 SC-053-02 Mach Screw 10-24 x 1/2 Truss Hd (SST)...................................................................................4

12 00-270925 Bracket (RH)...............................................................................................................................1

13 SC-041-12 Cap Screw 5/16 -18 x 7/8 Hex Hd..............................................................................................2

14 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

15 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

16 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd (SST).....................................................................................2

17 WS-003-49 Washer (SST).............................................................................................................................2

18 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

19 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

20 00-288465 Lid & Gasket Assy (Incls Item 21)..............................................................................................1

21 00-112007 Gasket........................................................................................................................................1

22 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T...............................................................4

23 00-270923-2 Box - Junction (RH)....................................................................................................................1

24 FE-008-44 Connector 45 Deg (3/4 Male Thd x 3/4 Thinwall).......................................................................2

25 FE-008-11 Gasket - Electrical......................................................................................................................2

26 FE-006-06 Lock Nut 3/4 ..............................................................................................................................2

27 FE-007-32 Connector - Conduit 3/4 TS........................................................................................................2

28 00-271057 Cap - Wireway............................................................................................................................2

29 SD-007-38 Self-Tapping Screw 8-18 x 1/4 Phil. Bndg. Hd., Type B.............................................................2

30 00-294677-3 Clamp - Wire (3/4 ID)..............................................................................................................AR

31 NS-047-94 Lock Nut 3/16 Washer Type (SST).........................................................................................AR

32 00-271056 Wireway - Horizontal..................................................................................................................1

33 WS-017-06 Washer (SST).............................................................................................................................3

34 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................3

35 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................3

36 00-72937 Speed Nut 4-40..........................................................................................................................2

37 00-328804 Wireway - Horizontal (C54A Series)...........................................................................................1

38 WS-017-06 Washer (SST).............................................................................................................................2

39 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

40 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

41 00-271061 Support.......................................................................................................................................2

42 SC-127-55 Mach Screw 4-40 x 3/8 Rd Hd (SST).........................................................................................2

43 00-274252 Wire Raceway (C54A Series).....................................................................................................2

44 00-271055 Wireway - Vertical......................................................................................................................2

45 SC-114-15 Mach Screw 10-24 x 3/8 Rd Hd (SST).......................................................................................2

46 WL-006-07 Lockwasher #10 Helical (SST)...................................................................................................2

47 WS-019-06 Washer.......................................................................................................................................4

48 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

49 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

50 WS-019-19 Washer.......................................................................................................................................2

51 00-436798 Panel - Front Trim (C44A/AW)...................................................................................................1

52 00-328809 Panel - Front Trim (C54A)..........................................................................................................1

53 00-288946-2 Foot - Adjustable (1 1/2 to 2 3/4)................................................................................................4

54 00-119244 Cap & Stud Assy........................................................................................................................1

55 00-67500-31 "O" Ring......................................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-274232 Conduit - PVC (26 1/8 Door Height) (Incls Item 4).....................................................................1

2 00-274709 Conduit - PVC (32 1/8 Door Height) (Incls Item 4)..................................................................AR

3 00-122577-2 Wire Tie......................................................................................................................................2

4 00-271044 Bracket.......................................................................................................................................2

5 SC-041-50 Cap Screw 1/4 -20 x 1/2 Hex Hd................................................................................................1

6 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

7 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

8 FE-009-07 Lock Nut 1 1/4............................................................................................................................2

9 00-287625 Splash Shield (26 1/8 Door Height)............................................................................................2

- 63 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

MISCELLANEOUS

(WASH SECTION)

ILLUS. PL-55498

56 00-119254 Retainer - Cap & Stud................................................................................................................1

57 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................1

58 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................1

59 00-436888 Cover - Panel Notch...................................................................................................................2

60 SC-066-05 Mach Screw 10-24 x 3/8 Phil Truss Hd......................................................................................2

61 WS-019-06 Washer.......................................................................................................................................2

62 NS-031-16 Stop Nut 10-24 Hex (SST).........................................................................................................2

63 00-288465 Lid & Gasket Assy (Incls Item 64)..............................................................................................1

64 00-112007 Gasket........................................................................................................................................1

65 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T...............................................................4

66 00-270923-1 Box - Junction (LH).....................................................................................................................1

67 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd (SST).....................................................................................2

68 WS-003-49 Washer (SST).............................................................................................................................2

69 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

70 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

71 PB-004-08 Plug Button 7/8 (Heyco 2703).................................................................................................AR

72 00-270922 Bracket (LH)...............................................................................................................................1

73 SC-041-12 Cap Screw 5/16 -18 x 7/8 Hex Hd..............................................................................................2

74 WS-017-08 Washer (SST).............................................................................................................................2

75 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

76 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

PART NO. NAME OF PART AMT.

F-17820 Rev. E (February 2015) - 64 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 65 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

LOW WATER PROTECTION

(STEAM HEAT/WASH TANK)

F-17820 Rev. E (February 2015) - 66 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

LOW WATER PROTECTION

(STEAM HEAT/WASH TANK)

ILLUS. PL-51077

10 00-67500-72 "O" Ring......................................................................................................................................1

11 00-271112-1 Box - Steam Heat.......................................................................................................................1

12 WS-010-40 Washer - Thrust.......................................................................................................................AR

13 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)...........................................................................AR

14 NS-018-28 Jam Nut 1/2 -20 Hex...............................................................................................................AR

15 00-288465 Lid & Gasket Assy (Incls Item 16)..............................................................................................1

16 00-112007 Gasket........................................................................................................................................1

**17 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

**18 00-119244-2 Cap..........................................................................................................................................AR

19 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T...............................................................4

**20 WS-003-47 Washer (SST)..........................................................................................................................AR

**21 00-67500-31 "O" Ring...................................................................................................................................AR

**22 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

PART NO. NAME OF PART AMT.

1 00-67500-72 "O" Ring...................................................................................................................................AR

*2 00-328495 Probe & Switch Assy (2 Wire) (Water Level) (Includes Items 3, 4, & 5)..................................AR

3 00-122674 Float Assy................................................................................................................................AR

4 00-112467 Retainer - Float........................................................................................................................AR

5 RR-010-13 Retaining Ring.........................................................................................................................AR

6 RR-010-13 Retaining Ring............................................................................................................................1

7 00-112467 Retainer - Float...........................................................................................................................1

8 00-186091 Probe & Switch Assy (4 Wire)(Temperature & Water Level)(Includes #6, 7, & 9).....................1

9 00-122674 Float Assy...................................................................................................................................1

00-294357-1 Housing - Connector (Nat)......................................................................................................AR

00-294357-2 Housing - Connector (Black)...................................................................................................AR

00-65890-29 Connector - Insulated..............................................................................................................AR

* 436927-1 (R/L) or 436927-2 (L/R) Cradle and Dog Assy(Std. Racks Only)(Incls

5,6,15,16,18,19,22,and 27)

** Used on CRS76A & CRS66A/AW in place of Items #1 thru 5 in wash tank

- 67 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

STEAM COIL HEAT

F-17820 Rev. E (February 2015) - 68 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

STEAM COIL HEAT

ILLUS. PL-51102

10 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

11 00-118316 Steam Trap (0-20 PSI)...............................................................................................................1

12 00-118317 Steam Trap (21-50 PSI).............................................................................................................1

13 FP-049-15 Elbow 3/4 x 90 Deg (SST)..........................................................................................................1

14 FP-054-27 Nipple 3/4 x 1 3/8 TBE (SST).....................................................................................................1

15 FP-077-29 Elbow 3/4 x 45 Deg (SST)..........................................................................................................1

16 FP-054-28 Nipple 3/ x 1 1/2 TBE (SST).......................................................................................................1

17 FP-054-27 Nipple 3/4 x 1 3/8 TBE (SST).....................................................................................................1

18 FP-050-14 Union 3/4 (Grd Seat) (SST)........................................................................................................1

19 FP-054-44 Nipple 3/4 x 2 1/2 TBE (SST).....................................................................................................1

20 FP-049-15 Elbow 3/4 x 90 Deg (SST)..........................................................................................................1

21 FP-054-28 Nipple 3/4 x 1 1/2 TBE (SST).....................................................................................................1

22 WS-013-45 Washer.......................................................................................................................................1

23 FP-052-09 Pipe Plug 3/4 Sq Hd (SST).........................................................................................................2

PART NO. NAME OF PART AMT.

1 FP-052-09 Pipe Plug 3/4 Sq Hd (SST).........................................................................................................1

2 00-274547 Coil - Steam (Side Inlet).............................................................................................................1

3 00-329243 Coil - Steam................................................................................................................................1

4 FP-080-17 Pipe 3/4 x 2 TBE (1-1/2 RTOE) (SST).......................................................................................1

5 FP-053-09 Lock Nut 3/4 NPSL (SST)..........................................................................................................1

6 WS-013-45 Washer.......................................................................................................................................1

7 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

8 FP-036-12 Nipple 3/4 x 7 3/4 TBE...............................................................................................................1

9 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

- 69 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

PIPING / STEAM COILS

F-17820 Rev. E (February 2015) - 70 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

PIPING / STEAM COILS

ILLUS. PL-51078

10 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

11 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

12 FP-036-13 Nipple 3/4 x 7 3/8 TBE...............................................................................................................1

13 FP-036-12 Nipple 3/4 x 7 3/4 TBE (Used on Side Inlet Construction).........................................................1

14 00-270329-1 Solenoid Valve (120 V) (Incls Items 16 & 18).............................................................................1

15 00-270329-2 Solenoid Valve (240 V)(Incls #17 & 18)(Used on machines W/O 120 V pilot circuit)

16 00-270318-1 Coil - Solenoid Valve (120 V).....................................................................................................1

17 00-270318-2 Coil - Solenoid Valve (240 V)(Used on machines W/O 120 V pilot circuit)................................1

18 00-270336 Service Kit - Solenoid Valve.......................................................................................................1

19 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

20 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

21 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

22 00-186922 Line Strainer 3/4 (Brass) (Incls Items 23 thru 25).......................................................................1

23 00-186923 Plug - Branch..............................................................................................................................1

24 00-186924 Gasket - Branch Plug.................................................................................................................1

25 00-186925 Screen - Line Strainer................................................................................................................1

26 FP-059-76 Nipple 3/4 x 2 1/4 TBE (Used on Side Inlet Construction).........................................................1

27 FP-059-22 Nipple 3/4 x 1 3/4 TBE...............................................................................................................1

28 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

29 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

30 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................7

31 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................7

32 00-328776 Plate - Outer...............................................................................................................................1

33 00-271109 Gasket - Mounting......................................................................................................................1

34 00-435026 Gasket........................................................................................................................................1

35 00-328777 Plate - Inner................................................................................................................................1

36 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd...........................................................................................7

37 WS-017-08 Washer (SST)...........................................................................................................................14

38 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

39 FP-036-05 Nipple 3/4 x 3 TBE.....................................................................................................................1

40 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

41 FP-087-48 Nipple 3/4 x 8 TBE.....................................................................................................................1

42 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

43 FP-053-09 Lock Nut 3/4 NPSL (SST)..........................................................................................................1

44 WS-013-45 Washer.......................................................................................................................................1

45 WS-013-45 Washer.......................................................................................................................................1

46 FP-080-17 Pipe 3/4 x 2 TBE (1-1/2 RTOE) (SST).......................................................................................1

47 00-289721 Bracket - Air Baffle.....................................................................................................................1

48 WS-003-49 Washer (SST).............................................................................................................................1

49 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................1

50 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................1

PART NO. NAME OF PART AMT.

1 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................7

2 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................7

3 00-435027 Plate...........................................................................................................................................1

4 00-435026 Gasket........................................................................................................................................1

5 00-271109 Gasket - Mounting......................................................................................................................1

6 00-271108 Plate - Mounting.........................................................................................................................1

7 WS-017-08 Washer (SST)...........................................................................................................................14

8 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd...........................................................................................7

9 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

...................................................................................................................................................1

- 71 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

STEAM INJECTOR HEAT

F-17820 Rev. E (February 2015) - 72 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

STEAM INJECTOR HEAT

ILLUS. PL-51079

10 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

11 00-74696 Check Valve 3/4.........................................................................................................................1

12 FP-059-14 Nipple 3/4 x 4 1/2 TBE...............................................................................................................1

13 00-270329-1 Solenoid Valve 3/4 (120 V) (Incls Items 15 & 17).......................................................................1

14 00-270329-2 Solenoid Valve 3/4 (240 V) (Incls #16 & 17)(Used on mach W/O 120 V pilot circuit)

15 00-270318-1 Coil - Solenoid Valve (120 V).....................................................................................................1

16 00-270318-2 Coil - Solenoid Valve (240 V)(Used on machines W/O 120 V pilot circuit)................................1

17 00-270336 Service Kit - Solenoid Valve.......................................................................................................1

18 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

19 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

20 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

21 00-186922 Line Strainer 3/4 (Incls Items 22, 23, & 24)................................................................................1

22 00-186923 Plug - Branch..............................................................................................................................1

23 00-186924 Gasket - Branch Plug.................................................................................................................1

24 00-186925 Screen - Line Strainer................................................................................................................1

25 00-435027 Plate...........................................................................................................................................1

26 00-435026 Gasket........................................................................................................................................1

27 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd...........................................................................................7

28 WS-017-08 Washer (SST)...........................................................................................................................14

29 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................7

30 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................7

31 00-288671 Heater - Water............................................................................................................................1

32 FP-054-44 Nipple 3/4 x 2 1/2 TBE (SST).....................................................................................................1

33 FP-049-15 Elbow 3/4 x 90 Deg (SST)..........................................................................................................1

34 FP-059-76 Nipple 3/4 x 2 1/4 TBE...............................................................................................................1

35 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-271110 Piping - Steam Injector (Incls Items 2, 31, & 32)........................................................................1

2 FP-085-05 Nipple 1 x 10 1/2 STOE (SST)...................................................................................................1

3 FP-054-32 Nipple 3/4 x 4 3/8 Lg TBE (SST)................................................................................................1

4 00-271109 Gasket - Mounting......................................................................................................................1

5 00-271108 Plate - Mounting.........................................................................................................................1

6 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

7 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

8 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

9 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

...................................................................................................................................................1

00-538850-2 Sealer - Pipe............................................................................................................................AR

00-545595 Sealer (1/8 Rd)........................................................................................................................AR

- 73 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONTROL BOX - GAS HEAT

F-17820 Rev. E (February 2015) - 74 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONTROL BOX - GAS HEAT

ILLUS. PL-51080

10 SD-009-05 Self-Tapping Screw 6-32 x 5/16 Phil Rd Hd,Type F...................................................................1

11 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................1

12 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................1

13 00-119244 Cap & Stud Assy........................................................................................................................1

14 00-67500-31 "O" Ring......................................................................................................................................1

15 00-119254 Retainer - Cap & Stud................................................................................................................1

16 00-294325-014-1 Block Terminal............................................................................................................................2

17 SD-009-17 Self-Tapping Screw 8-32 x 5/8 Phil Pan Hd, Type F..................................................................4

18 00-436757 Gas Heat Box (Shown) (Use W/Item 42)...................................................................................1

19 00-435022 Gas Heat Box (Use W/Item 41)..................................................................................................1

20 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................7

21 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................7

22 WS-017-06 Washer (SST).............................................................................................................................7

23 00-114247-1 Drive Rivet..................................................................................................................................2

24 00-526454 Foam Tape (1 Wide x 1/8 Thk)................................................................................................AR

25 00-274514-1 Bracket.......................................................................................................................................1

26 SC-067-07 Mach Screw 10-24 x 1/2 Hex Hd SST........................................................................................2

27 00-87711-221 Switch - Door SPDT...................................................................................................................1

28 00-270280 Insulator - Door Switch...............................................................................................................1

29 SC-112-90 Mach Screw 4-40 x 1 Pan Hd.....................................................................................................2

30 WL-003-03 Lockwasher #4 Helical...............................................................................................................2

31 NS-009-02 Mach Nut 4-40 Hex....................................................................................................................2

32 00-271122 Bracket - Thermostat..................................................................................................................1

33 00-271123 Protector - High Limit..................................................................................................................1

34 00-328758 Jumper Wire - Socket Type Connector (Use W/Item 33)...........................................................2

35 00-293946 Sleeve - Lead.............................................................................................................................1

36 SC-021-08 Mach Screw 6-32 x 3/8 Rd Hd (SST).........................................................................................2

37 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................2

38 00-435046 Control Plate...............................................................................................................................1

39 SC-018-01 Mach Screw 10-24 x 3/8 Pan Hd................................................................................................3

40 WL-014-07 Lockwasher #10 External Shakeproof (SST).............................................................................3

41 00-435023-1 Lid - Gas Heat Box (W/O Notches)............................................................................................1

42 00-436101-1 Lid - Gas Heat Box (Shown) (W/Notches)..................................................................................1

43 WS-029-79 Washer....................................................................................................................................AR

44 WL-006-07 Lockwasher #10 Helical (SST)................................................................................................AR

45 SC-067-07 Machine Screw 10-24 x 1/2 Hex Hd SST................................................................................AR

46 00-435375 Data Plate (LP Gas)...................................................................................................................1

47 00-435374 Data Plate (Natural Gas)............................................................................................................1

48 00-435024 Eye - Box....................................................................................................................................1

49 NS-035-25 Lock Nut 3/4 -16 Palnut..............................................................................................................1

50 00-274524 Blower Motor (240 V)(Used on machines W/O 120 V pilot circuit).............................................1

51 00-274524-2 Blower Motor (120 V).................................................................................................................1

52 SC-113-26 Mach Screw 1/4 -20 x 5/8 Hex Hd..............................................................................................4

53 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................4

54 WS-003-48 Washer - M6 Flat........................................................................................................................4

55 SC-113-26 Mach Screw 1/4 -20 X 5/8 Hex Hd.............................................................................................2

PART NO. NAME OF PART AMT.

1 00-436745 Gasket-Lid..................................................................................................................................1

2 00-436102 Bracket - Lid Mounting (Use W/Item 42)....................................................................................1

3 00-274569 Plate - Restrictor (12 Holes) (Marked NG 60 Hz) (Shown).....................................................AR

4 00-436065 Plate - Restrictor (16 Holes) (Marked NG & LP 60 Hz or 60 Hz)(Nat or LP Gas)...................AR

5 00-436763 Plate - Restrictor (24 Holes) (Marked NG 50 Hz)....................................................................AR

6 00-436765 Plate - Restrictor (28 Holes) (Marked LP 50 Hz).....................................................................AR

7 00-435539 Plate-Adjusting...........................................................................................................................1

8 00-436853 Ignitor Board 24 VAC.................................................................................................................1

9 Self-Tapping Screw 6-32 x 3/4 Phil Pan Hd, Type F.......................................................................................4

- 75 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

CONTROL BOX - GAS HEAT

ILLUS. PL-51080

56 WS-003-48 Washer - M6 Flat........................................................................................................................2

57 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................2

58 00-529390 Foam Tape (3/4 Wide x 1/16 Thk)...........................................................................................AR

59 00-328650 Air Inlet Channel (Nat Gas)........................................................................................................1

60 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T...............................................................2

61 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................2

62 00-271146 Cable - High Voltage..................................................................................................................1

63 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................3

PART NO. NAME OF PART AMT.

00-294357-1 Housing - Connector (Nat)......................................................................................................AR

00-294357-2 Housing - Connector (Black)...................................................................................................AR

00-294677-3 Clamp - Wire (3/4 ID).................................................................................................................3

NS-031-16 Stop Nut 10-24 Hex (SST).........................................................................................................3

00-526408 Foam Tape..............................................................................................................................AR

00-436766 Lid Assy (Natural Gas) (Incls Items 1, 23, 41, & 47)..................................................................1

00-436767 Lid Assy (Natural Gas) (Incls Items 1, 23, 42, & 47)..................................................................1

00-436768 Lid Assy (LP Gas) (Incls Items 1, 23, 42, & 46).........................................................................1

F-17820 Rev. E (February 2015) - 76 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 77 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

GAS BURNER AND FLUE

F-17820 Rev. E (February 2015) - 78 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

GAS BURNER AND FLUE

ILLUS. PL-55300

10 SC-121-43 Cap Screw 7/16 -14 x 1 3/4 Hex Hd........................................................................................AR

11 WS-021-07 Washer....................................................................................................................................AR

12 WL-019-77 Lockwasher 7/16 Medium.......................................................................................................AR

13 NS-047-97 Nut 7/16 -14 Hex.....................................................................................................................AR

14 00-435952 Flange - Immersion Tube...........................................................................................................1

15 00-436100 Gasket - Immersion Tube...........................................................................................................2

16 SC-066-06 Mach Screw 10-24 x 1/2 Phil Truss Hd (SST)............................................................................5

17 00-274496-1 Shroud........................................................................................................................................1

18 00-274520 Insulation....................................................................................................................................1

19 00-274544 Shroud Assy (Incls Items 16, 17, 18, & 21)................................................................................1

20 00-274520 Insulation....................................................................................................................................1

21 00-274498-1 Liner - Shroud.............................................................................................................................1

22 00-274565 Flue............................................................................................................................................1

23 NS-015-01 Nut 1/4 -20 Hex (SST)..............................................................................................................11

24 WL-006-17 Lockwasher 1/4 Helical (SST)..................................................................................................11

25 WS-017-06 Washer (SST)...........................................................................................................................11

PART NO. NAME OF PART AMT.

1 SC-041-14 Cap Screw 5/16 -18 x 1 1/8 Hex Hd (SST).............................................................................AR

2 WS-017-08 Washer (SST)..........................................................................................................................AR

3 WL-006-22 Lockwasher 5/16 Light............................................................................................................AR

4 NS-015-11 Nut 5/16 -18 Hex.....................................................................................................................AR

5 00-274495 Tube - Immersion (W/"O" Ring Sealing Flange).........................................................................1

6 00-435952 Flange - Immersion Tube...........................................................................................................1

7 00-67500-123 "O" Ring......................................................................................................................................1

8 00-67500-122 "O" Ring......................................................................................................................................2

9 00-436087 Tube - Immersion (W/Gasket Sealing Flange)...........................................................................1

- 79 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

GAS HEAT COMPONENTS

F-17820 Rev. E (February 2015) - 80 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

GAS HEAT COMPONENTS

ILLUS. PL-51081

10 00-436792 Electrode Ignition - Natural Gas (Dim 3 1/8) (Marked 665).....................................................AR

11 00-436067 Electrode Ignition - LP Gas (Dim 3 3/8) (Marked 662)............................................................AR

12 Plate - Mounting (Not Available) (Order Items 14 & 16).............................................................1

13 Gasket (Not Available) (Order Items 14 & 16)............................................................................1

14 00-435960-2 Plate - Spacer (Shown)...........................................................................................................AR

15 00-435960-1 Plate - Spacer (W/O Mounting Holes).....................................................................................AR

16 00-435961 Gasket (Service)......................................................................................................................AR

17 00-291988-3 Valve - Gas Cock.......................................................................................................................1

18 NS-018-28 Jam Nut 1/2 -20 Hex...............................................................................................................AR

19 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)...........................................................................AR

20 WS-010-40 Washer - Thrust.......................................................................................................................AR

21 SC-041-14 Cap Screw 5/16 -18 x 1 1/8 Hex Hd (SST).............................................................................AR

22 WS-017-08 Washer (SST)..........................................................................................................................AR

23 WL-006-22 Lockwasher 5/16 Light............................................................................................................AR

24 NS-015-11 Nut 5/16 -18 Hex.....................................................................................................................AR

25 00-67500-72 "O" Ring...................................................................................................................................AR

26 00-328495 Probe & Switch Assy (2 Wire)(Water Level)(Includes Items 28, 29, & 30)..............................AR

27 00-186091 Probe & Switch Assy (4 Wire)(Temp & Water Level)(Includes Items 28, 29, & 30)...................1

28 00-112467 Retainer - Float........................................................................................................................AR

29 RR-010-13 Retaining Ring.........................................................................................................................AR

30 00-122674 Float Assy................................................................................................................................AR

*31 Bracket - Orifice Natural Gas (Dim 3/4)(Marked NG)..............................................................AR

**32 00-436761 Bracket - Orifice LP Gas Only (Dim 1/2) (Marked NAT/LP)....................................................AR

33 00-435591 Bracket - Orifice.......................................................................................................................AR

34 SC-121-43 Cap Screw 7/16 -14 x 1 3/4 Hex Hd...........................................................................................4

35 WL-019-77 Lockwasher 7/16 Medium..........................................................................................................4

36 WS-021-07 Washer.......................................................................................................................................8

37 NS-047-97 Nut 7/16 -14 Hex........................................................................................................................4

38 Cover - Adjusting (No Longer Available)....................................................................................2

39 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................2

40 00-435701-1 Angle Fitting Natural Gas #20 Drill (.161)...................................................................................1

41 00-435701-2 Angle Fitting LP Gas #43 Drill (.089)..........................................................................................1

42 00-435836-2 Tube - Aluminum (2 1/8 Lg)........................................................................................................1

43 00-435836-1 Tube - Aluminum (2 1/4 Lg) (Nat Gas).......................................................................................1

44 00-63262-34 Flange & Nipple (Dim 1 15/16 )..................................................................................................1

45 00-63262-33 Flange & Nipple (Dim 2 1/16 ) (Nat Gas)...................................................................................1

46 00-63262-32 Flange & Nipple..........................................................................................................................1

47 SC-041-17 Cap Screw 5/16 -18 x 1 1/2 Hex Hd (SST)................................................................................2

48 WS-017-08 Washer (SST).............................................................................................................................4

49 WL-006-22 Lockwasher 5/16 Light...............................................................................................................2

50 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

51 FP-028-07 Pipe Plug 1/4 Sq Hd...................................................................................................................1

52 FP-086-62 Tee 3/8 x 1/4 x 3/8 Reducing.....................................................................................................1

53 FP-086-63 Nipple 3/8 x 1 3/8.......................................................................................................................1

54 00-435706-1 Regulator - Natural Gas.............................................................................................................1

55 00-435706-2 Regulator - LP Gas.....................................................................................................................1

PART NO. NAME OF PART AMT.

1 FP-015-10 Elbow - Street 3/8 x 90 Deg.......................................................................................................1

2 FP-040-22 Nipple 3/8 x 2 TBE (Use W/two 2" Valves; Ref Item 6)...........................................................AR

3 FP-040-18 Nipple 3/8 x 1 (Use W/two 2 1/2" Valves; Ref Item 5).............................................................AR

4 FP-076-07 Nipple 3/8 x 1 1/2 (Use W/one 2" Valve and one 2 1/2 " Valve Combination)........................AR

5 Gas Valve (Dim 2 1/2 )(Not Available)(Order Items 2, 3, or 4 & Item 6 as rqd)......................AR

6 00-436118 Gas Valve (Dim 2)......................................................................................................................2

7 SC-093-03 Mach Screw 8-32 x 3/8 Phil Pan Hd (SST)................................................................................2

8 WL-014-05 Lockwasher #8 External Shakeproof (SST)...............................................................................2

9 00-435028 Electrode Ignition - Natural Gas (Dim 3) (Marked 659)...........................................................AR

- 81 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

GAS HEAT COMPONENTS

ILLUS. PL-51081

56 FP-035-58 Nipple 3/8 x 2 3/4.......................................................................................................................1

57 FP-026-14 Bushing - 1/2 to 3/8....................................................................................................................1

***58 00-67500-31 "O" Ring...................................................................................................................................AR

***59 WS-003-47 Washer (SST)..........................................................................................................................AR

***60 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

***61 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

***62 00-119244-2 Cap..........................................................................................................................................AR

63 00-328649 Bracket - Orifice (Nat Gas) (Shown) (Dim 1/2) (Marked NAT)...................................................1

***64 00-436761 Bracket - Orifice (LP Gas Only) (Dim 1/2) (Marked LP).............................................................1

65 00-435702 Connector - Male 7/16................................................................................................................1

66 00-435762 Gasket........................................................................................................................................2

PART NO. NAME OF PART AMT.

00-508454 Sealer (1/8 Rd)........................................................................................................................AR

00-526408 Foam Tape..............................................................................................................................AR

00-546292 Sealer - Pipe............................................................................................................................AR

00-65890-29 Connector - Insulated.................................................................................................................2

00-435538 Wire Harness - Ignitor Board......................................................................................................1

* NLA, Order Items 1, 2, 6, 10, 40, 43, 45, 63, & 65 & Part No

** Orifice bracket use previously on Nat & LP Gas Heat Machines prior

*** Used on CRS76A, 66A/AW, or CPW90A/AW machines in place of Item 26

F-17820 Rev. E (February 2015) - 82 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

NOTES

- 83 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

ELECTRIC HEAT

F-17820 Rev. E (February 2015) - 84 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

ELECTRIC HEAT

ILLUS. PL-55303

10 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

11 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

12 SC-041-13 Cap Screw 5/16 -18 x 1 Hex Hd (SST)......................................................................................6

13 WS-029-05 Washer (SST)...........................................................................................................................12

14 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................6

15 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................6

16 00-112467 Retainer - Float........................................................................................................................AR

17 00-67500-72 "O" Ring...................................................................................................................................AR

18 00-186091 Probe & Switch Assy (4 Wire)(Temp & Water Level) (Includes Items 16, 19, & 20)

19 RR-010-13 Retaining Ring.........................................................................................................................AR

20 00-122674 Float Assy................................................................................................................................AR

**21 00-328495 Probe & Switch Assy (2 Wire)(Water Level)(Includes Items 16, 19, & 20)..............................AR

22 00-271109 Gasket - Mounting......................................................................................................................1

23 00-271118-1 Plate - Mounting.........................................................................................................................1

***24 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

***25 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

***26 WS-003-47 Washer (SST)..........................................................................................................................AR

***27 00-67500-31 "O" Ring...................................................................................................................................AR

***28 00-119244-2 Cap..........................................................................................................................................AR

29 00-271122 Bracket - Thermostat..................................................................................................................1

30 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................2

31 00-474512-1 Box - Electric Heat......................................................................................................................1

32 00-293946 Sleeve - Lead.............................................................................................................................1

33 00-271123 Protector - High Limit (Order Item 32 As Required)...................................................................1

34 SC-021-08 Mach Screw 6-32 x 3/8 Rd Hd (SST).........................................................................................2

35 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................2

36 00-328758 Jumper Wire - Socket-Type Connector (Use W/Item 33)...........................................................2

37 00-271168 Insulator - Terminal (Above 250 V)............................................................................................1

38 00-474574-2 Lid Assy (Incls Item 39)..............................................................................................................1

39 00-474569 Gasket - Electric Heat Box.........................................................................................................1

40 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................6

41 WS-010-40 Washer - Thrust.......................................................................................................................AR

42 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)...........................................................................AR

43 NS-018-28 Jam Nut 1/2 -20 Hex...............................................................................................................AR

44 00-293598 Gasket - Heater Mounting..........................................................................................................1

PART NO. NAME OF PART AMT.

*1 Heater - Tank Electric (Flat Ribbon Type) (Not Available; See ** Below)...............................AR

2 00-435990-1 Heater - Tank Electric (208 V, 60 Hz/200 V, 50 Hz) (3 Ph)........................................................1

3 00-435990-2 Heater - Tank Electric (240 V, 50/60 Hz) (3Ph)..........................................................................1

4 00-435990-3 Heater - Tank Electric (208 V, 60 Hz/200 V, 50 Hz) (1 Ph)........................................................1

5 00-435990-4 Heater - Tank Electric (240 V, 50/60 Hz) (1 Ph).........................................................................1

6 00-435990-5 Heater - Tank Electric (480 V, 60 Hz) (3 Ph)..............................................................................1

7 00-435990-6 Heater - Tank Electric (380 V, 50 Hz) (3 Ph)..............................................................................1

8 00-SC-041-13 Cap Screw 5/16 -18 x 1 Hex Hd (SST)......................................................................................2

9 00-WS-017-08 Washer.......................................................................................................................................2

...................................................................................................................................................1

00-526454 Foam Tape..............................................................................................................................AR

00-545595 Sealer ( 1 /8 Rd)......................................................................................................................AR

00-294357-1 Housing - Connector (Nat)......................................................................................................AR

00-294357-2 Housing - Connector (Black)...................................................................................................AR

00-65890-29 Connector - Insulated.................................................................................................................2

* Order tubular-type heater, #2 thru 7, as rqd & either wiring kit 436074 (3 Ph) or

wiring kit 436075 (1 Ph)

** Must order two jumper wires, Part #328758

*** Used on CRS76A, CRS66A/AW, CPW90A, or CPW80A/AW machines in place

of #21 in wash tank

- 85 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DISH RACKS

F-17820 Rev. E (February 2015) - 86 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

DISH RACKS

ILLUS. PL-51083

PART NO. NAME OF PART AMT.

1 00-315191 Rack - Peg (Packaged)..............................................................................................................1

2 00-315193 Rack - Combination (Packaged)................................................................................................1

00-295288 Peg Type Tray Rack (P1400).....................................................................................................1

00-892671 Rack Assy (250TX) (Tray & Bun Pans) (Packaged)..................................................................1

- 87 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

TABLE LIMIT SWITCH

F-17820 Rev. E (February 2015) - 88 -

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

TABLE LIMIT SWITCH

ILLUS. PL-53222

10 WS-023-06 Washer.......................................................................................................................................2

11 WL-006-06 Lockwasher 10 Light..................................................................................................................2

12 SC-053-02 Mach. Screw 10-24 x 1/2 Truss Hd. SST...................................................................................2

13 087326 Plate - Actuator...........................................................................................................................1

14 00-812936 Bracket - Interlock Switch...........................................................................................................1

15 FE-004-24 Cover - Junction Box..................................................................................................................1

16 FE-003-19 Box - Junction.............................................................................................................................1

17 SC-066-06 Mach. Screw 10-24 x 1/2 Phil. Truss Hd. (SST).........................................................................2

18 WL-006-06 Lockwasher 10 Light..................................................................................................................2

19 NS-011-18 Mach. Nut 10-24 Hex SST.........................................................................................................2

20 087332 Hinge Assy.................................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-277559 Bracket.......................................................................................................................................1

2 00-064165-00003 Spring - Connection....................................................................................................................1

3 FE-006-37 Elbow 90 Deg.Short (1/2 Male Thd. x 1/2 Thinwall)...................................................................2

4 00-087711-060-1 Switch - Interlock........................................................................................................................1

5 SC-027-24 Mach. Screw 6-32 x 1-1/2 Slotted Rd. Hd. (Brass)....................................................................2

6 WS-002-06 Washer.......................................................................................................................................2

7 NS-010-06 Mach. Nut 6-32 Hex...................................................................................................................2

8 WL-014-03 Lockwasher 6 External Shakeproof............................................................................................2

9 00-081921 Mach. Screw 10-24 x 1/2 Trimmed Hex Hd...............................................................................2

078752-4 Retainer (7/16")..........................................................................................................................1

ML-103368-0000Z Table Limit Switch Assembly (Incls items 1 thru 20)..................................................................1

- 89 - F-17820 Rev. E (February 2015)

C-Line A Models C44A - (ML's - 38898, 38899, 104047, 104050) C54A (ML's - 104198, 104199) REPLACEMENT PARTS

FORM 17820 Rev. E FEBRUARY 2015 PRINTED IN U.S.A.

Hobart C44AW Parts List

Specifications and Main Features

Frequently Asked Questions

User Manual