Giles EOF-20-20 Service Manual

Giles Enterprises, Inc.

2750 Gunter Park Drive West • Montgomery, AL 36109 USA Fax: (334) 272-3561 • Internet: www.gilesent.com

Service Hotline (Toll Free): 1-800-554-4537 (USA & Canada Only)

Form No. 60347 (Release date: 11/99)(Revision date: 11/06/07)(Rev. B)

EOF-20/20

Operations & Service Manual

FOODSERVICE EQUIPMENT

LIMITED WARRANTY

• Subject to the terms and conditions of this Limited Warranty as herein stated, all Giles Enterprises, Inc., Foodservice Equipment and parts purchased new from an authorized Giles Enterprises, Inc., representative are warranted as to defects in material or workmanship for a period of 12 months from the date of installation, provided, however, that with regard to labor costs in connection with this warranty, see below. All installations must be made by a qualified installing agency in accordance with all applicable codes and/or regulations in the jurisdiction in which installed. Limited warranty coverage is extended to the original owner only and is void if the unit is resold.

• During the Limited Warranty period, Giles Enterprises, Inc. will replace or recondition, at its factory, any part or parts of this unit which Giles Enterprises, Inc. inspectors judge defective, provided the unit has been subjected to normal usage, properly installed, operated and serviced. This Limited Warranty does not cover cosmetic damage, and damage due to acts of God, accident, misuse, alteration, negligence, abuse of the Giles Foodservice Equipment or the use of unorthodox repair methods. All parts replaced under this Limited Warranty carry only the unexpired term of this Limited Warranty. Limited Warranty service may be furnished only by an authorized Giles Enterprises, Inc., representative.

• If Limited Warranty service is requested, Giles Enterprises, Inc., will send factory-authorized service representatives to repair, recondition, replace or inspect units of its manufacture with such labor being rendered without cost to owner for ninety (90) days from the date of installation. Otherwise, service, including labor and transportation charges or other expenses, in connection with the removal or installation of any part or parts supplied under this Limited Warranty, are specified on the original sales contract between the purchaser and the authorized Giles Enterprises, Inc., representative.

• Giles Enterprises, Inc. reserves the right to change or improve its equipment and parts in any way without obligation to alter such equipment or parts previously manufactured.

• Giles Enterprises, Inc. makes no further warranties, express or implied including implied warranties of merchantability or fitness for a particular purpose, and has no other obligation or liability not specifically stated herein.

• Repair or replacement as provided under this limited warranty is the exclusive remedy. Giles Enterprises, Inc., shall not be liable for any incidental or consequential damages for breach of any express or implied warranty on this product, except to the extent prohibited by applicable law. Any implied warranty of merchantability or fitness for a particular purpose on this product is limited in duration to the duration of this limited warranty.

• Used Giles Enterprises, Inc., Foodservice Equipment or parts or Giles Enterprises, Inc., Foodservice Equipment or parts not purchased from an authorized Giles Enterprises, Inc., representative, carry no warranties, express or implied.

iii

Table Of Contents

Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Safety Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii

Specific Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . viii

1. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1-01. Construction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1-02. Standard Features. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1-03. Optional Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1-04. Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

1-04.1. Overall Dimensions for EOF 20/20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

1-04.2. Regulatory Listings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

1-04.3. Basket Size . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

1-04.4. Vat Size and Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

1-04.5. Shipping Specifications (Crated) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

2. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

2-01. Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

2-02. Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

2-03. Electrical Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

2-03.1. EOF 20/20 Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

2-04. Electrical Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

2-04.1. Electrical Connections Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

2-05. Ventilation of Fryer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

3. Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

3-01. EOF-20 Basket Elevator and Baskets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

3-02. EOF-20 Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

3-03. EOF-20 Left Lower Cabinet Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

3-04. EOF-20 Right Lower Cabinet Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

3-05. EOF-20 Basket Elevator and Baskets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

3-06. Filter Pan Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

3-07. Accessories (Included) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

3-08. Accessories (Not Included) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

4. Unit Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

4-01. Settings before each test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

4-02. Power test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

4-03. Heating Element test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

4-04. Filter Pump Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

4-05. Perform Boil Out Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

4-06. Clean Filter Pan. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

EOF 20/20

Table Of Contents

EOF 20/20

5. Fryer Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

5-01. Cooking Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

5-01.1. Buttons and Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

5-01.2. Programming the Cooking Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

5-01.3. Programming a Cooking Time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

5-01.4. Start a cooking time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

5-01.5. Cancel the currently running cooking time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

5-01.6. Manually lowering and raising the cooking basket (Basket Elevator Only) . . . . . . . . . . . . . 38

5-01.7. Displaying remaining cooking time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

5-01.8. Displaying the actual temperature of the liquid shortening . . . . . . . . . . . . . . . . . . . . . . . . . 39

5-02. Cooking Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

5-03. Filtering Liquid Shortening . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

5-04. Removal of Liquid Shortening . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

5-05. Normal Shut-Down . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

5-06. Emergency Shut-Down. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

6. Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

6-01. Boil-Out Procedure (Cleaning the Fry Pot) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

6-02. Cleaning the Filter Pan and replacing Filter Paper after Boil Out . . . . . . . . . . . . . . . . . . . . . 56

6-03. Cleaning the Filter Pan and replacing the Filter Paper daily . . . . . . . . . . . . . . . . . . . . . . . . . 57

7. Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

7-01. Temperature Control System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

7-02. Oil Filtration System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61

7-03. Basket Elevator System (Basket Elevator Option Only) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

8. Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63

8–01. Parts Ordering and Service Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63

8-02. EOF-20 Left Control Panel & Front Header. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64

8-03. EOF-20 Left Front Lower Cabinet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66

8-04. EOF-20 Left Rear Lower Cabinet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68

8-05. EOF-20 Right Control Panel & Front Header. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70

8-06. EOF-20 Right Front Lower Cabinet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

8-07. EOF-20 Right Rear Lower Cabinet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

8-08. Filter Pan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

9. Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

9-01. Wiring Diagram EOF-20/20 Left Fryer 208-240/60/3 Computer . . . . . . . . . . . . . . . . . . . . . . 80

9-02. Wiring Diagram EOF-20/20 Right Fryer 208-240/60/3 Computer . . . . . . . . . . . . . . . . . . . . . 82

9-03. Wiring Diagram EOF-20/20 Left Fryer 480/60/3 Computerr . . . . . . . . . . . . . . . . . . . . . . . . . 84

9-04. Wiring Diagram EOF-20/20 Right Fryer 480/60/3 Computer . . . . . . . . . . . . . . . . . . . . . . . . 86

Table Of Contents

EOF 20/20

Table Of Contents

EOF 20/20

Notes:

vii

Safety

EOF 20/20

Safety Overview

Safety

The instructions contained in this manual have been prepared to aid you in learning the proper procedures for installing and servicing your unit.

Throughout this manual, safety precautions are identified through the use of the safety alert symbol and three signal words: DANGER, WARNING, and CAUTION. All safety alert information precedes the step(s) to which they apply. Suggested, recommended, or other noteworthy information is identified through the use of NOTES. Additionally, certain words are used to indicate a specific meaning or to add emphasis.

The following words are used as indicated throughout the manual:

Shall: understood to be mandatory. Should: understood to be advisory. May: understood to be permissive. Will: indicates a future event/condition to occur.

(Safety Alert Symbol) Used in conjunction with signal words (DANGER, WARNING, or CAUTION) to alert you of potential per- sonal injury hazards, immediately preceding precautionary measures that pertain to subsequent step(s). Obey all safety messages that follow these symbols to avoid possible injury or death. Failure to adhere to safety precautions identified by the safety alert symbol may also void the warranty.

• Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

Use of this is limited to the most extreme situations.

DANGER

• Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

WARNING

• Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.

Also used to alert against unsafe practices.

CAUTION

• When used without the safety alert symbol, CAUTION indicates a potentially hazardous situation

which, if not avoided, may result in equipment/property damage, and void the warranty.

CAUTION

NOTE:

•Identifies suggested, recommended, or other noteworthy information.

viii

Safety

EOF 20/20

• Turn off the unit and unplug the power cord before cleaning or performing maintenance.

• DO NOT hose down the unit’s interior or exterior with water.

• Failure to comply with these DANGER notices will result in death or serious injury, equipment/property damage,

and void the warranty.

DANGER

For your safety, please observe the following precautions when operating or servicing this unit. Read the following important safety information to avoid personal injury and/or damage to the equipment.

Specific Safety Precautions

• Consult a qualified electrician to ensure that:

•• all electrical specifications and codes are met.

•• circuit breakers and wiring are of sufficient rating and gauge.

• The unit must be properly grounded and all electrical specifications must be met during installation.

• Improper installation, adjustment, alteration, service or maintenance could result in death or serious injury, equipment/property damage, and void the warranty.

• DO NOT use or store gasoline or other flammable liquids or vapors in the vicinity of this or any other electrical appliance!

• Failure to comply with WARNING notices could result in death or serious injury and equipment/property damage

and void the warranty.

WARNING

• The unit must remain in the upright (vertical) position.

• Exercise care when removing the wooden crate from around the unit.

• DO NOT operate the unit unless you fully understand the components and their intended functions (see Section

3).

• The unit and its parts are HOT!

Exercise caution when operating, loading/unloading food, cleaning or servicing. Wearing of thermal oven mitts is recommended.

• Failure to comply with CAUTION notices may result in minor or moderate injury, equipment/property damage,

and void the warranty.

CAUTION

Safety

EOF 20/20

• Food products must be maintained at a temperature of 150°F (65.5°C) minimum or in accordance with local or

state health regulations.

• Fryers must be adequately and properly grounded. Improper grounding may result in electrical shock.

Always refer to your local electrical code to ensure proper grounding of this or any other electrical equipment. Always consult with an electrician or other qualified service person to ensure breakers and wiring are of sufficient rating and gauge for the equipment being operated.

• Giles Electric Fryers are available from the factory wired for various voltages, phase and hertz. Check the rating

plate on the front of the fryer to determine the correct power supply.

• Ensure the fry kettle is positioned in a secure, safe location with the casters in the locked position.

• Consult an electrician to ensure all electrical specifications have been met and the unit is properly grounded. The

wiring diagrams contained in this manual should aid your electrician in the installation of your fryer.

• Due to the high temperature of shortening in your fryer during cooking, it is extremely important the user exer-

cise caution in the operation of this equipment to avoid personal injury.

• Before attempting to operate the unit, refer to Section 3 to familiarize yourself with the various control functions.

• Be careful not to puncture the filter paper when using the brush to unclog the Drain Valve.

• Allow the unit to cool down a minimum of 15 minutes before cleaning or servicing.

CAUTION

• The electronic components of the Control Panel are impact-sensitive. Exercise care around the Control Panel to

maintain proper operation.

• DO NOT install the unit next to combustible walls and materials. Failure to maintain safe distances may result in

fire.

• During cleaning of the unit:

•• DO NOT steam clean.

•• DO NOT use products containing chlorine.

•• DO NOT use abrasive products, steel wool or scouring pads.

•• DO NOT use oven cleaner.

• Failure to comply with these CAUTION notices may result in equipment/property damage and void the warranty.

• Failure to comply with these CAUTION notices may violate local health codes.

• DO NOT Modify, Alter or Add Attachments to this Equipment!

CAUTION

Safety

EOF 20/20

NOTE:

• If the crate in which the unit is shipped is damaged upon receipt, immediately inspect the unit and notify the car-

rier of any damage to the unit.

• To aid the electrician, an electrical wiring diagram is contained in this manual. Refer to the wiring diagram during

installation or servicing.

• Comply with all appropriate state and/or local heath regulations regarding the cleaning and sanitation of equip-

ment.

Introduction

EOF 20/20

Congratulations on the purchase of your new Giles equipment, Model EOF-20/20 manufactured by Giles Enterprises, Inc., Montgomery, Alabama (USA), hereafter referred to as "Giles". Every unit is thoroughly inspected and tested prior to shipment. Proper care and maintenance will ensure years of trouble-free service.

To help protect your investment in this state-of-the-art cooking equipment, we recommend you take a few moments to familiarize yourself with the installation, cleaning and maintenance procedures contained in this manual. Adherence to these recommended procedures minimizes the potential for costly “Down-Time” and equipment repairs. Please retain this manual for future reference.

Temperature Controller -used to control the temperature of the cooking oil and the cooking time.

Oil Filtration System

-used to extend the life of cooking oil.

1. Introduction

1-01. Construction

1-02. Standard Features

Model EOF-20/20, exterior and fry vats are constructed of stainless steel.

Automatic Basket Lift -used to automatically lift cooked product from hot cooking oil at the end of the cooking cycle.

1-03. Optional Features

Introduction

EOF 20/20

1-04. Specifications

1-04.1. Overall Dimensions for EOF 20/20

INCHES [MILLIMETERS]

Introduction

EOF 20/20

EOF-20

508

4 1/2

114

110

EOF-20

mmin

mm mm

9.00

Length

Height

Width

1-04.2. Regulatory Listings

UL (US and Canada) UL Sanitation

1-04.3. Basket Size

Model

Basket Size Volume

cubic inch cubic meter

811 0.01318.50

5.5

469.9 139.7

228.6

1-04.4. Vat Size and Capacity

Length

(Inside)

Width

(Inside)

Height

(Top of element to oil

level line

Liquid Shortening Capacity

(Bottom of Vat to Oil level)

In mm Lbs Kg Gal Lt

Model

EOF 20/20

Model

1-04.5. Shipping Specifications (Crated)

Net Weight

Crated Size Volume

Length Width Height

In mm In mm In

401884

1930 50 1270 61

1549

Lbs Kg

Cubic

Meters

Cubic

Feet

3.8134.1

Introduction

EOF 20/20

Notes:

Installation

EOF-20/20

2. Installation

1. Keep the appliance and surrounding area free and clear from combustible materials. {(3")(7.6cm) for

Fryer.}

2. Please note wiring diagrams for this appliance are located in the rear of this manual. Ensure the

wiring diagram corresponds with the model being operated.

3. Please ensure this appliance is electrically grounded in accordance with local codes, or in the absence

of local codes, with the National Electrical Code, ANSI/NFPA NO. 70-1999.

4. Please provide adequate room for servicing and proper operation of this appliance. Also, provide

adequate ventilation in the operating area where necessary.

5. Always consult with an electrician or other qualified individual prior to installation.

6. Ensure voltage and amperage supplied to the unit are as specified on the fryer’s rating plate.

7. Make sure this unit is in a secure position and will not move. Locking casters are supplied on this

unit--use them!

8. This appliance is to be installed, used and maintained in accordance with the Standard for Ventilation

Control, and Fire Protection of Commercial Cooking Operations, NFPA 96-1994.

Compliance with the above steps will help to ensure safe and proper installation of your fryer. If you have any questions concerning these procedures, contact your local Giles distributor or other qualified service person.

This section provides a summary of the procedures necessary for proper installation of your new unit. To prevent personal injury or equipment damage, please ensure the following steps are taken.

2-01. Location

• DO NOT MODIFY, ALTER OR ADD ATTACHMENTS TO THIS EQUIPMENT

CAUTION

Installation

EOF-20/20

Your Giles Fryer may arrive enclosed by a wooden crate. The Fryer is secured to a wooden platform by means of high-tensile strength strapping.

1. Carefully cut and remove the plastic shipping wrap and the strapping mentioned above.

2. Use pliers to loosen wire hooks which secure the wooden crate around the fryer. Remove the wood-

en crate.

3. Carefully remove the fryer from the shipping platform. Your new fryer is extremely heavy, the uncrat-

ed weight for the EOF-20/20 is 584 lbs (265 kg), only use a fork lift when lifting this equipment, refer to 2-03.

2-02. Unpacking

• Exercise care when lifting or moving the unit.

• Exercise care when removing the wooden crate from around the unit.

• Failure to comply with these CAUTION notices may result in minor or moderate injury, equip-

ment/property damage, and void the warranty.

CAUTION

NOTE:

• If crate is damaged, immediately inspect the unit and notify the carrier of any damage to the

unit.

EOF-20/20EOF-20/20

2-04. Electrical Connections

1. Install appropriate Circuit Breakers in Main Breaker Box! See Table 2-04.

2. Connect Flexible Conduit from Main Breaker Box to Quick Disconnect Box.

3. Connect Flexible Conduit from Quick Disconnect Box to the Fryer. Allow enough Conduit so Fryer can be moved away from the wall for cleaning and servicing. See Figure 2-05.1.

4. Open Fryer Door and remove Service Box Cover. See Figure 2-05.1.

5. Connect the electrical ground wire between the Terminal Block Ground Lug and a proper earth ground.

6. Route appropriate size Power Wires to the Fryer.

7. Connect the Power Wires to the appropriate Terminal Blocks located in the Service Box. See Figure 2-

04.1.

8. Reinstall Service Box Cover and close the Fryer Door.

2-03. Electrical Requirements

The EOF-20/20 is available from the factory in the voltages and phases listed below. Check the rating plate on the rear of the fryer to determine the correct power supply.

• Fryers must be adequately and properly grounded. Improper grounding may result in electrical

shock. Always refer to your local electrical code to ensure proper grounding of this or any other electrical equipment. Always consult with an electrician or other qualified service person to ensure breakers and wiring are of sufficient rating and gauge for the equipment being operated.

CAUTION

2-03.1. EOF-20 Electrical Specifications

Voltage Phase Watts

Circuit Breaker

required

Amps

L1 L2 L3

208 1 24,000 115 115 --- 150

208 3 24,000 72 46 72 80

240 1 24,000 100 100 --- 125

240 3 24,000 68 44 68 75

480 3 24,000 34 22 34 50

EOF-20/20 EOF-20/20

2-05. Ventilation of Fryer

Consult a professional ventilation or heating and air conditioning company for assistance in designing a Ventilation hood for this unit.

NOTE:

•Guidelines for proper ventilation system requirements differ from location to location. Always

consult with local authorities to ensure compliance.

2-04.1. Electrical Connections Diagram

Flexible Conduit

Terminal Blocks

Service Box

Power Wires from Quick-

Disconnect Box

Service Box Cover

Power Wires from Quick-

Disconnect Box

Ground Lug

Terminal Blocks

Service Box

Service Box Cover

Flexible Conduit

EOF-20/20

Overview

The following section provides a brief overview of the components, functions, and accessories of the unit. Please review this section carefully before proceeding any further.

Filter Pan Assembly

Figure 3-08.

EOF-20 Control

Panel

Figure 3-05.

EOF-20 Baskets and Basket Hanger Figure 3-07.

EOF-20 Baskets and Basket Lift

Figure 3-04.

EOF-20 Lower Cabinet Area

Figure 3-06.

3. Overview

Overview

EOF-20/20

3-01. EOF-20 Basket Elevator and Baskets

Overview

EOF-20/20

• Always use Oven Mitts when using any of these parts. Parts will become very hot during nor-

mal use.

CAUTION

3-01. Basket Elevator (Optional) and Baskets

Item Description Function

1 Basket Carrier (2)

Used to hold the basket in the correct position when the basket is lifted or lower by the elevator.

2 Elevator (2) Used to lower and lift the basket from the Fry Pot.

3 Crumb Screen

Used inside the Fry Pot to prevent excess breading or product from contacting the Heating Elements.

4 Basket (2) Used for cooking product.

Overview

EOF-20/20

3-02. EOF-20 Control Panel

EOF 20/20

Overview

3-02. EOF-20 Control Panel

Item Description Function

1 Power Switch

The Power Switch is used to turn power ON or OFF to the unit.

2 Heat Switch

The Heat Switch is used to turn the power to the elements ON or OFF. Place the Heat Switch in the OFF position when programming the controller or shutting down the unit. Place in the ON position when ready to heat the oil.

3 Controller

The Electronic Controller is used for setting a cooking temperature and cooking times.

4 High-Limit Indicator

The Red High-Limit Indicator Light is illuminated as a result of power being shut off to the fryer’s heating elements by the built-in solid-state control circuit as a safeguard against overheating. Should this light come on during operation, refer to the Troubleshooting, Section 7, of this manual. NEVER ATTEMPT TO COOK IF THE HIGH-LIMIT LIGHT IS ON!

5 Heat Indicator Light

The Orange Heat Indicator Light will be on when the Heat Switch is in the ON position and the heating elements are heating the oil. The light will go on and off at various times as the oil temperature is maintained.

6 Power Indicator Light

The Green Power Light is on whenever the fryer’s Power Switch is in the ON position.

7 Elevator Switch

The Elevator Switch is used to turn the Elevator power on or off. If the switch is ON the Elevator will lower when a cooking cycle starts and rise when a cooking cycle ends. If the switch is OFF the Elevator will not operate.

Overview

EOF-20/20

3-03. EOF 20 Left Lower Cabinet Area

Overview

EOF 20/20

3-03. EOF-20 Left Lower Cabinet Area

Item Description Function

1 Drain Valve Handle

Used to drain the Fry Pot. Always ensure the Handle is closed and locked prior to adding cooking oil or boil out solution. Your fryer will not heat if this Drain Valve Handle is not completely closed and locked.

ALWAYS ENSURE THE HEAT SWITCH IS IN THE OFF POSITION BEFORE OPENING THIS VALVE. FAILURE TO COMPLY WITH THIS DANGER NOTICE COULD RESULT IN A FIRE, CAUSING DEATH OR SERIOUS INJURY AND/OR EQUIPMENT/PROPERTY DAMAGE AND VOID THE WARRANTY.

NEVER DRAIN OIL FROM MORE THAN ONE FRY POT AT A TIME INTO THE FILTER PAN. THIS WILL CAUSE THE FILTER PAN TO OVERFLOW. ALWAYS REMOVE OIL FROM THE FILTER PAN BEFORE DRAINING ANOTHER FRY POT.

WARNING

DANGER

2 Pump Oil Return Handle Used when Filtering to return oil to the Fry Vat.

Filter Pan Quick

Disconnect

Used to connect filter pan to fryer pump.

Overview

EOF 20/20

3-04. EOF 20 Right Lower Cabinet Area

Overview

EOF 20/20

3-04. EOF-20 Left Lower Cabinet Area

Item Description Function

1 Drain Valve Handle

NEVER DRAIN OIL FROM MORE THAN ONE FRY POT AT A TIME INTO THE FILTER PAN. THIS WILL CAUSE THE FILTER PAN TO OVERFLOW. ALWAYS REMOVE OIL FROM THE FILTER PAN BEFORE DRAINING ANOTHER FRY POT.

WARNING

DANGER

2 Pump Oil Return Handle Used when Filtering to return oil to the Fry Vat.

Discharge Hose Quick

Disconnect

Used to connect discharge hose to fryer.

Overview

EOF 20/20

3-05. EOF-20 Basket Hanger and Baskets

+ 72 hidden pages

Giles EOF-20-20 Service Manual

Specifications and Main Features

Frequently Asked Questions

User Manual