®
CATEYE VELO 5
VELO 5
CATEYE VELO 5
MODE
INSTALLING THE UNIT
6
2
3
1
3
3
CAT EYE VELO 5
CAT EYE VELO 8
CYCLOCOMPUTER
Model CC-VL500/CC-VL800
English
U.S. Pat. Nos. 4642606, 5236759 and Pat. Pending
VELO 8
CATEYE VELO 8
A B
3
4
2 3
5
4
Copyright© 2003 CAT EYE Co., Ltd.
CCVL5/8-031030 066600280
SET
(on Back)
F
G
6
5mm
4
3
Caution
• Do not concentrate on the computer operations while riding. Always be sure to ride safety.
• Be sure to securely mount the magnet, sensor and bracket on your bicycle, and periodically check to see if any
parts have loosened.
• Used batteries are harmful if swallowed by mistake. They must be disposed in accordance with local regulations.
• Do not leave the main unit exposed to direct sunlight. Never disassemble the main unit.
• For cleaning of the main unit or accessories, use diluted neutral detergent on a soft cloth, and then wipe it off with
a dry cloth. Do not use paint thinner, benzine or alcohol since such chemicals may damage the surface.
Package Contents
1 Bracket
2 Wire
3 Sensor
4 Magnet
5 Nylon Ties 7
IMPORTANT!
Correct positions of the sensor and the magnet:
A
When rotating the front wheel, the magnet's 4 center must be aligned with the sensor's 3 marking line.
B
The distance between the sensor 3 and the magnet 4 must be less than 5mm.
Name of Parts
Speed 0.0 (4.0) to 299.9 km/h [0.0 (3.0) to 185.0 mph]
Mode Symbol Indicates the mode currently selected.
1
Pace Arrow* Indicates if the current speed is faster or slower than the average speed.
Speed Scale
Sub Display (selected function)
Battery Case Cover
Contact
*The Pace Arrow feature is only available on the VELO8. Pace Arrows are not displayed on the VELO5.
Display function
• Tm* [Elapsed Time] 0:00'00" to 9:59'59"
• Dst [Trip Distance] 0.00 to 999.99 km [mile]
• Av* [Average Speed]
•
Mx [Maximum Speed] 0.0 (4.0) to 299.9 km/h [0.0(3.0) to 185.0 mph]
• Cal*
• Odo [Total Distance] 0.0 to 9999.9 km [mile]
• [Clock] 0:00' to 23:59'[1:00'to 12:59']
*
This feature is only available on the VELO8. No measurement is done on the VELO5.
Start/Stop of Measuring
The unit starts measuring automatically when you start pedaling, and stops measuring when your come to a stop.
The upper display always shows the Current Speed.
Shift of Lower Display
Each time you press the MODE button, a different data value appears on the lower line.
Power Saving Function
If the main unit does not receive a signal after about 10 minutes, the main unit enters Power Saving Mode and
displays the clock count only. To re turn to normal display, press the MODE button or start your bicycle again to
cancel the Power Saving function.
Data Reset
When a screen with the
and the measured data will return to zero. However, the Odometer (total distance) and Clock do not return to zero.
How to Set Clock
In the clock mode, press SET button on the back, and the display enters clock setting mode.
*If Km/h has been selected for speed scale, it becomes 24-hour clock.
If mph has been selected, it becomes 12-hour clock.
How to Change Tire Size
Display the Total Distance (Odo) and press the SET button to change the tire size. You can select a tire size in two
ways: Either select from among preset sizes
Maintenance
• If the contact of the unit or the bracket gets wet, dry it off with a cloth. If they become rusty, it will cause speed
detection error.
• If the gaps between the buttons and the unit get clogged with mud or sand, wash them away with water.
Troubleshooting
No display.
Has the battery in the main unit run down?
Incorrect data appears.
Current speed does not appear.(First, short-circuit the contact of the main unit a few times with a piece of metal. If current
speed appears, the main unit is working fine and the cause should be attributed to the bracket or the sensor.)
Is the clearance between the sensor and the magnet too large?
Are the magnet's center and the sensor's marking line aligned?
Is the cord broken?
Is there anything sticking on the contact of the main unit or the bracket?
Current speed disappears when using in the rain.
Replacing Battery
If the screen becomes dim, it is the time to replace the battery.
*Insert a new lithium battery (CR2032) with the (+) mark facing up.
1 After replacing the battery, perform the all-clear operation. Follow SETTING to select the measurement unit & tire
size and set the clock display to the current time.
Specification
Battery ---------------------- Lithium Battery CR2032 x 1(battery life: approx. 3 years)
Microcomputer ------------- 4-bit 1-chip (Crystal controlled oscillator)
Display ---------------------- Liquid crystal display
Sensor ---------------------- No-contact magnetic sensor
Tire Sizes ------------------- Tire sizes of 16, 18, 20, 22, 24, 26, 700C, and 27 inches, or tire peripheral lengths from 100 to 299
Working Temperature ------ 0°C - 40°C
Length of Wire ------------- 70cm
Dimension/Weight --------- 1-7/8" x 1-25/32" x 23/32" (48 x 45 x 18 mm) / 1.06 oz ( 30 g)
*The specifications and design are subject to change without notice.
(The corresponding value is indicated on the lower line.)
(
Faster Slower)
0.0 to 299.9 km/h [ 0.0 to 185.0 mph]
(Measurable up to 27 hrs or 999.99 km/h)
[Calorie Consumption]
Replace it with a new one.
Do all clear operation.
Re-adjust the positions of the magnet and the sensor. (The clearance should be less than 5mm.)
Even if the outside of the cord looks normal, there could be damage.
Replace the bracket and sensor set with a new one.
Clean the contact with a cloth.
Wipe any water or dirt from the contacts and apply a water repellent silicon grease. Do not apply standard grease,
as it may cause damage to the bracket.
0.0 to 9999.9 kcal (estimated from speed data)
e
Reset
mark in the OPERATION FLOW is displayed, continue pressing the MODE button
f
c
or enter the tire’s circumference directly in increments of 1 cm.
g
(*The life of the factory-loaded battery might be shorter than this.)
cm (Initial value: 26 in.)
5
d
1
5
6
Click
SETTING
1
●Calorie Consumption *1(VELO8)
The calorie consumption data is only the accumulated value that is
calculated from the speed data of every second. It differs from the
actual consumed calorie.
7
km/h
Speed 10 km/h 20 km/h 30 km/h
Kcal per hour
67.3 kcal 244.5 kcal 641.6 kcal
mph
Speed 10 mph 20 mph 30 mph
Kcal per hour
155.2 kcal 768.2 kcal 2297.2 kcal
SETTING
All Clear
SET + MODE
2 buttons
SET
MODE
PUSH!
Wheel Size
L (cm)
102
106
119
120
134
135
152
162
177
179
175
178
179
191
189
192
196
192
191
195
195
190
207
210
200
201
202
205
206
207
207
208
Tire size
57-559
32-630
18-622
20-622
23-622
25-622
28-622
32-622
37-622
40-522
Tire size
ETRTO
47-305
47-406
47-507
23-571
37-590
40-559
47-559
50-559
54-559
57-559
14 x 1.50
14 x 1.75
16 x 1.50
16 x 1.75
18 x 1.50
18 x 1.75
20 x 1.75
20 x 1-3/8
22 x 1-3/8
22 x 1-1/2
24 x 1
24 x 3/4 Tubular
24 x 1-1/8
24 x 1-1/4
24 x 1.75
24 x 2.00
24 x 2.125
26 x 7/8
26 x 1(59)
26 x 1(65)
26 x 1.25
26 x 1-1/8
26 x 1-3/8
26 x 1-1/2
26 x 1.40
26 x 1.50
26 x 1.75
26 x 1.95
26 x 2.00
26 x 2.10
26 x 2.125
26 x 2.35
OPERATION FLOW
Reset
Tm
0:00'00" - 9:59'59"
Dst
0.00 - 999.99 km [mile]
26 x 3.00
27 x 1
27 x 1-1/8
27 x 1-1/4
27 x 1-3/8
650 x 35A
650 x 38A
650 x 38B
700 x 18C
700 x 19C
700 x 20C
700 x 23C
700 x 25C
700 x 28C
700 x 30C
700 x 32C
700C Tubular
700 x 35C
700 x 38C
700 x 40C
Reset
Tm
Dst
Av
Mx
Cal
Odo
Clock
L (cm)
217
215
216
216
217
209
212
211
207
208
209
210
211
214
217
216
213
217
218
220
0
Select km/h or mph
Select km/h
Tire Size
27" x 1-1/4
Tire Size
Quick Setting Size
27"
Detailed Setting Size
L = 216 (cm)
cm
MODE
MODE
(2 sec.)
km/h
START
START
VELO 8
MODE
mph
km/h
26 700c 27 [205] 16 18 20 22 24
MODE
MODE MODE
MODE
MODE MODE
MODE MODE
MODE
(2 sec.)
e
SET
Data Reset
VELO 5
SET
SETTING
END
SETTING
END
SET
SETTING
END
Reset
MODE
(2 sec)
#169-9550
Bracket Sensor Kit
ba
#166-5150
SET
Lithium Battery (CR2032)
#169-9691N
Standard Magnet
#169-9560
Heavy Duty Wire and Bracket Sensor Kit
#169-9302
c
[#169-9307]
Center Mount Bracket Kit [Long]
#169-9303
Bracket Sensor Kit for Aero Bar
d
#169-9304
Stem Mount Bracket Kit
MODE
(2 sec.)
SET
#169-9690
Hi-Power Wheel Magnet (both for normal
spoke & aero spoke)
#169-9760
Magnet for Composit Wheel
Tm
Dst
Av
Mx
Cal
0
VELO8
MODE
Current Speed
0.0 (4.0) - 299.9 km/h
[0.0 (3.0) - 185.0 mph]
BATTERY
Close
Open
CR2032
Reset
Av
0.0 - 299.9 km/h
[0.0 - 185.0 mph]
Mx
0.0 (4.0) - 299.9 km/h
[0.0 (3.0) - 185.0 mph]
Reset
Cal
0.0 - 9999.9 kcal
a
All Clear
Reset
*1
Odo
0.0 - 9999.9 km [mile]
Clock
0:00' - 23:59'
[1:00' - 12:59']
g
VELO5
MODE
Clock Setting
SET
Setting Time
3:10
MODE
SET
MODE
SET
MODE
(km/h 0 - 23)
[mph 1 - 12]
MODE
SETTING
SET
END
(00 - 59)
MODE
MODE
LIMITED WARRANTY
2-Year Warranty for Main Unit Only
(Accessories/Attachments and Battery Consumption excluded)
If trouble occurs during normal use, the part of the Main Unit will be repaired or replaced free of charge.
The service must be performed by Cat Eye Co., Ltd. To return the product, pack it carefully and remember
to enclose the warranty certificate with instruction for repair. Please write or type your name and address
clearly on the warranty certificate. Insurance, handling and transportation charges to our service shall be
borne by person desiring service.
GARANTIE LIMITEE
(Address for service)
2-8-25, Kuwazu, Higashi Sumiyoshi-ku, Osaka 546-0041 Japan
Service & Research Address for United States Consumers:
Attn.: CAT EYE Customer Service Section
CAT EYE Service & Research Center
1705 14th St. 115 Boulder, CO 80302
Phone : 303-443-4595
Toll Free : 800-5CATEYE
Fax : 303-473-0006
URL: http://www.cateye.com
f
Loading...