Alpine CDE-9827-R, CDE-9827-RM, CDE-9827-RR, CDE-9828-RB Service manual

CDE-9828RB/CDE-9827R/

SERVICE MANUAL

FM/MW/LW/RDS CD Receiver

3 / 04-A
68E36331S01

Q.S.

CDE-9827RM/CDE-9827RR

(CDE-9828RB)

TO ALPINE Home Page

<Cautions for Safe Repair Work>

r

s

- 2 -

The following cautions will prevent accidents in the workplace and will ensure safe products.
*The symbols indicate caution is needed to prevent injuries and damage to property.
The symbols and their meanings follow.

Warning

Caution

*The following symbols indicate two levels of cautions.

When you see this symbol, you have to be very careful.

When you see this symbol, you have to follow the instructions there.

If you ignore this symbol and handle the product incorrectly or unsafely,
serious injury or death may result.

If you ignore this symbol and handle the product incorrectly or unsafely,
injury or only material damage may result.

Warning

Do not look squarely into the laser light
coming from the pickup. Always use a designated fuse.

You may loose you sight. Use of an incorrect fuse may result in a fire.

Caution

Do not allow wiring to be caught in the Battery Caution
screw/chassis. Use the designated battery.

If wiring is caught in the screw/chassis, it may Confirm the correct polarity and seat of the
cause a short circuit, resulting in a fire. battery.

Fuse Caution

An incorrect battery or an improperly connected
or seated battery may result in a fire.

High Temperature Caution Designated Parts Caution

Touching the heat sink may cause severe burns. Look up the part list and ensure that only

designated parts are used to prevent problems or
accidents.

Reverse Power Supply Connections o
Misconnections Caution Ensure that the wiring is correct when rewiring to

Reverse power supply connections or prevent problems with ignition/breakdown.
misconnections may cause ignition problems and
smoke may result.

Soldering Caution Wear Glove

Hot solder from solder splash may cause severe Wear gloves to prevent electrical shocks or injury
burns. from the end face of the metal.

Wiring Caution

Contents

- 3 -

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

Packing Assembly Parts List
Packing Method View
Specifications

5 , 6

Extension Cable
Adjustment Procedures

8 to 11

Block Diagram
Parts Layout on P.W.Boards and Wiring Diagram
Schematic Diagram
Terminal Voltage of IC/ TR
Description of IC Terminal

13 to 18
19 to 26
27 to 34
35 to 39

Exploded View (Cabinet)

4
4

7

12

40

Exploded View (CD Deck Mechanism) (DP23S27R)

NOTE : Due to continuing product improvement, specifications and designs are subject to
change without notice.

41

Packi ng Assembly P art s List

TO CONTENTS

- 4 -

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

Symbol SymbolDescription

Part No. Part No.

Description

No. No.

101-1 03S60820Y16 SCR,MC H 5X8 ZN A #1 104 01T75373Y02 ASSY,ISO CONN 9825R
101-2 03A60836Y01 SCR,CUS 5X7 ZN A $1 104 01T75373Y01 ASSY,ISO CONN 9823R
101-3 01T04296K01 I SO/JASO ANT ADAPTER %1 104 01T75373Y01 ASSY,ISO CONN 9823R
101-4 36A02449K01 CAP ,RUBBER(A) &1 104 01T75373Y01 ASSY,ISO CONN 9823R
102 15D00529K02 CASE,INNER 105 68P02294K95 O/M AOEU AOD N
103 15D01798 K03 CARRYING,CASE

NOTE : #1 : F or CDE-9828RB M odel Onl y, $1 : For CDE-9827R Model O nl y, %1 : For CDE -9827RM M odel Onl y,
&1 : F or CDE -9827RR Model O nl y, Others : Com m on.

Packing Method View

101 -2

101 -4

X1

103

105

101

-1

X4

B

O

T

T

O

S

M

I

D

E

104

101

101 -3

X1

X1

102

B

O

T

T

O

S

M

I

D

E

102

104

103

X1

X1

X1

Specifications

<FM RADIO>

Intermediate Frequency ......................................................................................................................... 10.7±0.1MHz

Frequency Range ............................................................................................................................ 87.5 to 108.0MHz

Usable Sensitivity (Mono, 30dB S/N, at 98.1MHz) .......................................................................................... 20.2dBf

-3dB Limiting Sensitivity (at 98.1MHz) ............................................................................................................ 23.2dBf

Residual Noise (Ref. 400Hz (NARROW), at 98.1MHz) ................................................................................ 28±10dB

S/N Ratio (at 98.1MHz) ......................................................................................................................... Stereo : 55dB

Mono : 58dB

Image Rejection (at 106.1MHz) .......................................................................................................................... 40dB

IF Rejection (at 90.1MHz) ................................................................................................................................... 60dB

Distortion (Input 60dBu, at 98.1MHz) .................................................................................................................. 1.0%

Frequency Response (Ref. 400Hz, at 98.1MHz) ................................................................................. 100Hz : 0±3dB

10kHz : -10±3dB

Stereo Separation (1kHz, at 98.1MHz) ............................................................................................................... 20dB

PS Sensitivity (at 98.1MHz) ............................................................................................................................ 36.2dBf

<MW RADIO>

Intermediate Frequency ................................................................................................................... 1st. IF : 10.7MHz

2nd. IF : 450kHz

Frequency Range .............................................................................................................................. 531 to 1,602kHz

Usable Sensitivity (20dB S/N, at 999kHz) ........................................................................................................... 36dB

S/N Ratio (at 999kHz) ......................................................................................................................................... 44dB

Image Rejection (at 1,404kHz) ............................................................................................................................ 50dB

IF Rejection (at 603kHz) ..................................................................................................................................... 60dB

Distortion (at 999kHz) .......................................................................................................................................... 1.5%

Frequency Response (Ref. 400Hz, at 999kHz) ............................................................................. 100Hz : -3+3,-4dB

2.5kHz : -3+4, -8dB

<LW RADIO>

Intermediate Frequency ................................................................................................................... 1st. IF : 10.7MHz

2nd. IF : 450kHz

Frequency Range ................................................................................................................................. 153 to 281kHz

Usable Sensitivity (20dB S/N, at 216kHz) ........................................................................................................... 42dB

S/N Ratio (at 216kHz) ......................................................................................................................................... 44dB

Image Rejection (at 270kHz) ............................................................................................................................... 50dB

IF Rejection (at 162kHz) ..................................................................................................................................... 60dB

Distortion (at 216kHz) .......................................................................................................................................... 1.5%

Frequency Response (Ref. 400Hz, at 216kHz) ............................................................................. 100Hz : -3+3,-4dB

2.5kHz : -3+4, -8dB

<Pickup>

Wave Length .................................................................................................................................................... 795nm

Laser Power ................................................................................................................................................... CLASS I

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

TO CONTENTS

- 5 -

CDE-9828RB/CDE-9827R/

TO CONTENTS

- 6 -

CDE-9827RM/CDE-9827RR

<CD SECTION>

System ....................................................................................................................... Optical (Compact Disc System)

Channel Balance (1kHz) ......................................................................................................... CD : TCD-782 : 0 ±3dB

MP3 : SCD-5100 (FOLDER4-128kbps) : 0±3dB

WMA : SCD-5100 (FOLDER10-128kbps) : 0±3dB

Distortion (1kHz) ........................................................................................................................ CD : TCD-782 : 0.1%

MP3 : SCD-5100 (FOLDER4-128kbps) : 0.1%

WMA : SCD-5100 (FOLDER10-128kbps) : 0.1%

Frequency Response (Ref. 1kHz) ................................................................................ CD : TCD-782 : 17Hz : 0 ±3dB

127Hz : 0±2dB

10.007kHz : 0±2dB

19.997kHz : -2±4dB

MP3 : SCD-5100 (FOLDER4-128kbps) : 17Hz : 0±3dB

127Hz : 0±2dB

10.007kHz : 0±2dB

19.997kHz : -2±4dB

WMA : SCD-5100 (FOLDER10-128kbps) : 17Hz : 0±3dB

127Hz : 0±2dB

10.007kHz : 0±2dB

19.997kHz : -2±4dB

S/N Ratio ................................................................................................................................... CD : TCD-782 : 95dB

MP3 : SCD-5100 (FOLDER4-128kbps) : 95dB

WMA : SCD-5100 (FOLDER10-128kbps) : 95dB

Separation ................................................................................................................................. CD : TCD-782 : 55dB

MP3 : SCD-5100 (FOLDER4-128kbps) : 55dB

WMA : SCD-5100 (FOLDER10-128kbps) : 55dB

De-Emphasis (Ref. 1kHz) ......................................................................................... CD : TCD-782 : 4kHz : -20 ±3dB

16kHz : -20±3dB

<GENERAL>

Power Supply ................................................................................................................................................ DC14.4V

Power Output (Ref. CD Mode/SP-OUT, T.H.D. 10%)/Impedance ........................................................ 16W/ch/4ohm

Pre Output (Ref. CD (TCD-782 (0dB/1kHz)), T.H.D. 1%, /Impedance ................................... 2V±2.5dBV/ch/10kohm

SUB-W OFF Mode, Rear PRE-OUT Mode)

Dimensions (W x H x D) ................................................................................................. Chassis : 178 x 50 x 160mm

Nose : 188 x 58 x 27mm

Weight ................................................................................................................................................................. 1.6kg

NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice.

Extension Cable

* When repairing or measuring the voltage of this unit, connect with the Extension Cable as shown in below.

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

TO CONTENTS

- 7 -

Adjustment Procedures

(2) Connections

1. FM/MW/LW SECTION

(1) Dummy Antenna Circuit

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

TO CONTENTS

- 8 -

Step

Description

Connectio

n

Signal Generator

Dial Control

Test Point /
P.W.Board

Coordinates

Adjustment

1

Signal Meter
Auto
Adjustment
(FM)

Figure 3

(1)

87.5MHz ,
26dBµ

(Mod. OFF)

87.5MHz

TP002

(3-F)

TP511

(3-B)

Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP511 (Pull-Down)
for 2~3 seconds.

(2)

87.5MHz ,
26dBµ

(Mod. OFF)

87.5MHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (2).
(SPEC) TP002 : 1.5±0.1V OK
(SPEC) TP002 : others 1.5±0.1V NG

NOTE : NG : Proceed same Auto

Adjustment of step (1)
under step (3).

(3)

87.5MHz ,

21~23dBµ

(Mod. OFF)

87.5MHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (3).

(4)

87.5MHz ,
26dBµ

(Mod. OFF)

87.5MHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (4).

2

Signal Meter
Auto
Adjustment
(MW)

Figure 4

(1)

999kHz ,

34dBµ

(Mod. OFF)

999kHz

TP002

(3-F)

TP511

(3-B)

Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP511 (Pull-Down)
for 2~3 seconds.

(2)

999kHz ,

34dBµ

(Mod. OFF)

999kHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (2).
(SPEC) TP002 : 1.0±0.1V OK
(SPEC) TP002 : others 1.0±0.1V NG

NOTE : NG : Proceed same Auto

Adjustment of step (1)
under step (3).

(3)

999kHz ,

29~31dBµ

(Mod. OFF)

999kHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (3).

(4)

999kHz ,

34dBµ

(Mod. OFF)

999kHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (4).

CDE-9828RB/CDE-9827R/

TO CONTENTS

- 9 -

CDE-9827RM/CDE-9827RR

(3) Control Settings

Power Switch .............................................. ON Band Switch .............................. FM/MW/LW

Fader Control ........................... Center Position MX ............................................... Non Effect

Balance Control ....................... Center Position Others ................................................... OFF

(4) Adjustment Procedures

Step

Description

Connection

Signal Generator

Dial Control

Test Point /
P.W.Board

Coordinates

Adjustment

3

Signal Meter
Auto
Adjustment
(LW)

Figure 4

(1)

216kHz ,

34dBµ

(Mod. OFF)

216kHz

TP002

(3-F)

TP511

(3-B)

Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP511 (Pull-Down)
for 2~3 seconds.

(2)

216kHz ,

34dBµ

(Mod. OFF)

216kHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (2).
(SPEC) TP002 : 1.0±0.1V OK
(SPEC) TP002 : others 1.0±0.1V NG

NOTE : NG : Proceed same Auto

Adjustment of step (1)
under step (3).

(3)

216kHz ,

29~31dBµ

(Mod. OFF)

216kHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (3).

(4)

216kHz ,

34dBµ

(Mod. OFF)

216kHz

TP002

(3-F)

TP511

(3-B)

Proceed same Auto Adjustment of step
(1) under step (4).

4

FM ST
Separation
(Roll OFF)
Adjustment

Figure 5

(1)——

—

Set up of Adjustment Mode :
Push SOURCE/POWER +

3 at the same time.

(2)

98.1MHz, 72dBµ
(Mod. 400Hz,

Dev. 75kHz,

Stereo, 1kHz,

Lch only)

98.1MHz

Audio Output

(RCA)

Push Preset Switches (1~5), and
observe value of separation.
Select Preset Switch of maximum
separation.
(SPEC) : separation : more than 20dB.

(3)——

—

Cancel Adjustment Mode :
Push SOURCE/POWER +

3 at the same time.

5

Stereo Blend
(Roll OFF)
Adjustment
(Lch)

Figure 5

(1)——

—

Set up of Adjustment Mode :
Push SOURCE/POWER +

F at the same time.

(2)

98.1MHz, 46dBµ
(Mod. 400Hz,

Dev. 75kHz,

Stereo, 1kHz,

Lch only)

98.1MHz

Audio Output

(RCA)

Push Preset Switches (1~6), and
observe value of blend.
(SPEC) : Blend : 8±6dB.

(3)——

—

Cancel Adjustment Mode :
Push SOURCE/POWER +

F at the same time.

6

Limitting
Adjustment

Figure 6

(1)——

—

Set up of Adjustment Mode :
Push SOURCE/POWER +

UP at the same time.

(2)

98.1MHz, 24dBµ

(Mod. 400Hz,

Dev. 75kHz)

98.1MHz

Audio Output

(RCA)

Push Preset Switches (1~5), and
observe value of limitting.
(SPEC) : Limitting : -3dB.

(3)——

—

Cancel Adjustment Mode :
Push SOURCE/POWER +

UP at the same time.

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

TO CONTENTS

- 10 -

Step

Description

Connection

Signal Generator

Dial Control

Test Point /
P.W.Board

Coordinates

Adjustment

7

Noise Level
Adjustment

Figure 6

(1)——

—

Set up of Adjustment Mode :
Push SOURCE/POWER +

UP at the same time.

(2)

98.1MHz,

72 --> -20dBµ

(Mod. OFF)

98.1MHz

Audio Output

(RCA)

Rotary encoder is turned and noise level
is adjustment.
(SPEC) : Noise Level : 28±10dB.

(3)——

—

Cancel Adjustment Mode :
Push SOURCE/POWER +

UP at the same time.

CDE-9828RB/CDE-9827R/

TO CONTENTS

- 11 -

CDE-9827RM/CDE-9827RR

Block Diagram

TO CONTENTS

- 12 -

ANT

CDE-9828RB/CDE-9827R/

CDE-9827RM/CDE-9827RR

DP23S27R

DIMMER

MX.IND

Cent.f.IND

RF

AM

PLL

Steering

Remote

VDD /PWR-ON/Audio+B
CD Servo+B/TUNER+B

IF

E2PROM

2

I

C

I/F circuit

OEM

System REG. IC

SHIFT REGISTER

LCD401

MUTIL-CHIP TUNER

MPX Selector Vol. 1 Tre/Bass Vol. 2

I2C

CD

RDS decoder

I2C

I2C

Main u-Com

BATT DET

ACC DET

Acc DET

LCD/Key

Driver

Key

Matrix

DSP

Reset

Rotary

Encoder

MUTE

MUTE

MUTE

Mute

Driver

Buffer

Buffer

IN-INT

#1

DIMMER

NOTE : #1 : For CDE-9828RB Model Only,

POWER
IC

P.ANT

+

O.REM

Others : Common.

DIMMER

RCA302

SUB W

JK302

Front

JK302

Rear

CB802

Front

Rear

BATT

ACC

P.ANT

O.REM

IN-INT

R564

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

- 19 -

1k

AUTO ADJ

TP511

R558 10k

R559 10k

R574 270

R575 270

47k

R567

R555 1k

R542 100

R578 100

R562 100

R563 100

R565 1k

R566 1k

15k

R568

100k

TH501

R557

22k

R560 1k

R561 1k

IC581

N.U.

R586

R587

N.U.

R589 3.3k-1/4

N.U.

22k

R582

Q582

C581

N.U.

Q581

N.U.



IC502

N.U.

R504

N.U.

N.U.

R511



E501

N.U.

R523

UN2211

D581

N.U.



0-1/4

R588



C583

2200p-B

R505

N.U.

C502

N.U.

N.U.

R519

IC502

N.U.

C501

N.U.

C584

100p-CH



N.U.

R506

Q502

N.U.



D502

N.U.



N.U.



D503
N.U.



R524 N.U.

R525 N.U.

Q503

N.U.

Q504

N.U.

R584

JAC, CK-3.5-14

R512



N.U.

R520

N.U.

R507

N.U.



1k

JK581

D501

N.U.

N.U.

N.U.

R514

R515

R513



N.U.

R521

N.U.

R526 N.U.

R527 N.U

R581



N.U.

R583

R530 4.7k

R554 4.7k

R531 330

R573 JP

R534 1k

R533 1k

R532 330

IC501

M30626FHPGP



N.U.

C507

R508

1k

R510 470k

22k

R509

R517 47k

C503

XL501

0.01-B

6.0MHz

C504

27p-CH

C505

27p-CH

R553 1k

R537 1k

R535 1k

R552 1k

R536 1k

R502 22k

R590 22k

R501 47k

R518 22k

R550 1k

R551 1k

R522

JP

R579

22k

R570

27k-F

R569

3.9k-F

IC560

S-80930CNMC-T2

R571

2.7k-1/4
C560

R577 JP

R580 47k-1/4

TXD TP503

PGM TP501

RESET TP502

VSS TP507

VCC TP508

RXD TP504

SCLK TP505

BUSY TP506

SW501

SKHHLW

C561

0.047-B

0.1-B

E502

330/6.3

Z502

BK2125HM102

C506

0.022-B

R500

N.U.

C582

0.1-B

R585

N.U.

C513 N.U.

IC504

N.U.

N.U.

R516 47k

R503 100k

TP510 GND

TP509 VDD

R800

12

Q505

XN1A311

R538 10k

R591

0

R539 22k

E503

22/16

R547 1k

R548 1k

R541 10k

CB501

BTB,TMD-V15X-A1

R549 1k

R609 2.7k

R546 1k

R544 N.U.

R545 1k

C508 N.U.

R543 1k

R540 1k

R208

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

- 20 -

220

R210

220

C204

2200p

C205
2200p

R206

N.U.

E203

4.7/35

R248

1k

R249

1k

E205

4.7/35

E206
47/6.3

C208 0.1-B

E208
47/6.3

R212
N.U.

C210

0.1

R216 1k

R201 2.7K

R202 2.7K

Z203

BK2125HM102

BK2125HM102

E210

220/6.3

C243

1000p

IC201

TC94A04AFD

R214

Z204

Z205

820k

R213

C219

BK2125HM102



01

R215

1M

1k

XL201

10p

C212

33868MHz

10p

C214

C213

N.U.

E201

C202

22/16

22k

R204

C244

N.U.

C201



01

1000P

E212

47/16

E214

47/16

E213 47/16

BK215HM102

E215

47/63

Z201

R207

22k

C206 0.1

Z202

BK2125HM102

R255

0

C255

1000p

E204
22/16

C209

0.1

E202

3.3/50

E207

3.3/50

E209

3.3/50

E211

3.3/50

R203

R205

1k

1k

R209

R211

C203

4700p

C207

4700p

1k

C211

4700p

C215

1k

4700p

BA4560F

IC302

BA4560F

IC301

R301

R303

C833

N.U.

N.U.

11k

IC301

BA4560F

R302

11k

11k

IC302

BA4560F

N.U.

E304

R304

11k

C200

E305



2.2/50

E303

3.3/50

E308



2.2/50

E310



2.2/50

E314



2.2/50

E319



2.2/50

E321

2.2/50

R305

220-1/8

SW301

Q301

XN0F256

56k

R315

56k

R316

R320

220-1/8

R328

220-1/8

Q302

XN0F256

56k

R317

56k

R318

R341

220-1/8

R344

220-1/8

Q304

XNOF256

56k

R319

56k

R322

R353

220-1/8

R309

100-1/8

R321

100-1/8

R327

100-1/8

R335

100-1/8

R345

100-1/8

R352

100-1/8

N.U.

JK302

ASSY,CONN NLT1661

TP201

TP202

TP203

TP204

TP205

CB302

53253-0310

N.U.

C317 100p

C318

D317

1PS226

RCA302

ASSY,WIRE RCA 9828R

D803

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

- 21 -

C824

0.22-B

S1G-6904

E826

470/10

220/6.3 E801

0.47-B C810

0.1-B C803

0.1–B C804

0.22-B C805

N.U. C806

0.1-B C802

R804

30k-1/4

C801

0.1-B

E802

D801

S1G-6904

220/16

R805 N.U.

Q825

XN1A311

IC801

D808

S1G–6904

C825

0.22–B

C826

3.3k

R802

N.U.

Q803

3.3k

R803

UN221L

R801 10k–1/4

S1G–6904 D802

IC802

AN7705SP

C807 0 022

C808 0.33

E829 330/6.3

E827 220/10

C820 0.022

R845

N.U.

R831

R832

2.2

2.2

Q804

2SD1994A

1/50

E828

Q805

2SD1994A

ZD804

HZS9C1L

R833

620–1/4

Q824

XN1A312

D309

1SS355

R354

N.U.

R362

100-1/4

R361

10k

#1

#1

#1

IC307

#1 TA8273H

$1, %1, &1
TA8263BH

E311

47/16

Q307

UN2212

R355

330

$1, %, &1 SRT14

D301 MPG06G

D302 MPG06G

#1

$1, %, &1 SRT14

$1, %, &1 SRT14

$1, %, &1 SRT14

D303 MPG06G

D304 MPG06G

C835

100p–CH

Q810

XN1A312

Q814

XN1A311

Q306

ZD823 HZS9C3L

E326 10/16

E327 10/16

E328 10/16

Q823

N.U.

R825

390-1/4

XN1A312

E325
10/16

Q826

2SD1994A

Q822

XN1A312

C309

0.22–TF

C311 0.22–TF

C312 0.22–TF

C313 0.22–TF

1/50

E322

R357 10k

E323 10/16

E324

0.22/50

C310 0.047–B

C811

0.022–B

C307 N.U.

E815

3500/16

C308

0.22–B

$1, %, &1 SRT14

$1, %, &1 SRT14

$1, %, &1 SRT14

$1, %, &1 SRT14

D305 #1 MPG06G

D306 #1 MPG06G

D307 #1 MPG06G

D308 #1 MPG06G

DIN801

N.U.

N.U.

F801

N.U.

R805

N.U.

R811

N.U.

R820

Q305

UN2211

Q809

UN2212

R812

3.9kF–1/4

R817

R816

D806

1.8kF-1/4

MA165

C809 0.1–B

ZD801

HZS6c3L

0.1-B

C827

R809

N.U.

R829

47kF–1/4

R808

N.U.

N.U.

R810

27kF–1/4

R814

R807

Q813

2SB1243

2.2

R813

R819



2.2k–1/4

DTC143XKA

10k–1/4

Q815

2.2

R828

2.2k–1/4

R826

2.2

E823 1/50

R830 100k

0.01

C814

R821

390–1/4

CB801

53253–0210

C815

0.22–B

M801

ZD803

HZS11A1L

MOTOR, DF251R–12LC–07

E816 22/16

C812 0.01

C816 0.01

CB802

(MSA9451B–16)

0.01

C817

0.01

C821

Q817

2SD874A

R815

Q818

XN1A312

2.2

10k

R601

C601

MA152WK

Q601

UN211L

47k

R604

R602

10k–1/4

C601

0.022–B

(# Model Only $1, %1, &1 N.U.)

R602

UN2212

R603

10k–1/4

1

C602

L802

CHOKE

D807

DSCA3A4

CH101

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

- 22 -

SFW22R-1STE1

Q104

C101

0.022-B

XN1A311

D106

D107

S1G-6904

S1G-6904

R109

N. U.

R105

2.2

Q107

R108

2SD1994A

2.2

C105

0.022-B

ZD101

1/50

E103

D101 MA2S728

D102 MA2S728

D103 MA2S728

D104 MA2S728

IC102

N. U.

R102 10k

R103 47k

R101 47k

R104 33k

R110

R112 47k

R114 47k

R113 47k

TC74HCT7007AFTP2

C111

0.022-B

D105 MA2S728

Q103

XN1A312

0.1

C103

0.1

C106

Q102

25B1243

IC101

10k

R106

220

R107

Q105

E105 N.U.

C102 2200p

UN2211

NJU7223DL1

E101

4.7/35

C104 0.022-B

E102

100/16

HZS6B1L

Q101

2SD1994A

R111

1k-1/4

Q108

N. U.

E821

C819

470/10

470k

R824

Q106

XN1A312

0.222-B

E104

47/16

TP003
ANT IN

CB002

52465–3291

R001

ASSY, ANTCABLE ISO28R

L006

0.027uH

N U.

L007

0.039uH

TV001

ANT001

C013

C014

R003 100

R004 100

C217 1-B

C218 1-B

C223 1-B

C224 1-B

L801

SA001

DSP-201M

L001

4.7uH

L002

52mH

C015

62p–CH

18p-CH

L003

15uH

39p-CH

R002

10- 1/4

C011

2200p

D001

Z001 NFM21HC102R1H

C010

R005 220-1

C008

0.047-B

E001 N.U.

1PS226

0.022–B

C012

2200p

C001

C009

1000p-CH

R008 4.7k

N.U.

L004 4.7uH

0.01

C002

0.1

C017

R007 100k

R217 100k

L005

4.7uH

C003

C005

C004

0.01-B

0.01-B

0.01-B

TP002

C006
1000p

R006
470k

C007 0.022-B

R818

0

Q819

2SA1037AK

3.3k

R822

E817

Q820

R823

1.5k-1/4

UN211H

E818 N.U.

E819 N.U.

E820 N.U.

Q821

UN2211

220/10

C216

0.1-B

0-1/4

N.U.

E805

C818 0.022-B

IC051 TC7S66F

Q052

XN1A311

100p

C066

R058

24k

Q051

UN2211

R053

C065

0

0.022

C053

330p

C054

1-B

C055 2200p

R062

33k

E052

22/16

10

R054

N. U.

C056

0.1

C057

0

R066

C077

1000p

C051
560p

E051

2.2//50

N.U.

C060

R051

0

R052

N.U.

IC052

SAA6588T

C058

0.022

R064

R063 470k

N.U.

R065

C059

2200p

XL051

4.332MHz

27p

C061

C062

C052

0.1

R055

R056 5.6k

R057 5.6k

1k

R059

1k

R060



0

R061

0

4.7k

N. U.

27p

C063

C064 N.U.

C225 N.U.

C226 N.U.

C227 N.U.

C228 N.U.

C229 1-B

C230 1-B

R225 220

R226 220

Q221

C221

0.022-B

UN2212

L1001 BK1608HM102

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

- 23 -

L1014

BK1608HM102

C1002

33p

0.01

C1218

0.01

C1217

L1018

BK1608HM102

N.U.

L1031

N.U.

L1009

C1211

100p

C1003

1000P

D1005

R1004

1SV172

C1018

4.7

4.7
R1044

R1043

0.1

C1221

C1047

56K

L1005

C1015

3p

C1037

L1007

68uH

68P

D1002

KV1410

R1013 100k

C1215

N.U.

C1034

0.1

15P

10/16

E1015

R1034

C1016

10

100P

XL1001

10.25MHz

0.1

C1039

C1059 N.U.

C1044

0.022

C1045

0.022

C1046

0.022

C1048

10p

C1049 10p

R1019

4.7k

C1033

0.01

TP1002

C1031

0.022

0.01

C1017

C1052

10P

0.1

C1210

BK1608HM102

22

2.2k

R1007

R1009

2.2k

C1030

1000P

C1014

22K

R1015

0.01

10K

C1050

C1016

R1038 10

C1054

0.01

TP1001

R1024

680

R1005

C1057

0.01

C1011 0.1-B

C1213 N.U.

C1214 0.01

C1001

0.022

D1013

1SV172

4700p

C1012

22

C1005

C1004

33p

33p

R1037 56k

D1004 KV1410

C1006

2p

C1008 N.U.
C1009 10p

5kH

VT1001

C1007

L1002 BK1608HM102

R1020 100k

L1013

BK1608HM102

5p

0.01

C1010

10/16

E1014

C1038 0.1

1k

R1008

1mH

L1006

1u

1u

C1026

R1023

Q1004

FC18

L1019

0.68uH

R1010 1M

L1017 BK1608HM102

Q1003

R1012

3SK195

10

0.01

R1017

C1051

5.6k

VT1003

D1003

KV1410

R1011

4.7k

1u

C1029

C1013 0.01

VT1002

5kH

100

5kH

R1018

C1032

68P

1p

C1035

C1036

22p

0.1-B

CF1002

E1006

10/16

CF1001

1u

C1058

SFELA10M7

IFT1001

R1050

IFT1 F/A 5PG

C1055

SFELA10M7

N.U.

L1021

R1217

0.82uH

12k

100p

C1056 0.022

IFT1002

IFT2 AM 5PG

E1007

10/16

0.1-B

C1019

E1008 10/16

C1020 0.1-B

IC1001

TDA7518

CF1003

SFELA10M7

C1222 0.1

XL1002
450kHz

C1021 0.022

E1011 10/16

C1061 0.47

C1022 3900p

C1060 0.47

10

R1045

C1223

22/16

0.1

E1012

0.01

C1024

C1025

0.01

120p

C1023

C1027

0.1-B

L1010 1mH

E1201
22/16

0.1

C1224

0.1

C1225

L1020

2.2uH

TP1201

C1216 0.68-B

C1216 1000P

C1205 0.1-B

C1208 0.1-B

C1201

0.015-B

C1040

C1041 2200P

0.01
R1028 100k

C1042 1000P

C1043

R1029 56K

0.01

R1030 5.6k

IC1002

TP1209

0.01

1000P

C1220

CB1001

IMSA60298-17Z

C1053

CB1002

53309-3291

E1205 10/16

NJM2904M

TP1206

R1216

1.1k-1/4

R1215

1.1k-1/4

IC1002

NJM2904M

R1218

1.1K

2.2K

R1211

10/16

E1204

%1LCD,WTD-22158ABHU-CU

TO CONTENTS

TO PARTS LIST

TO P. W. BOARD

- 24 -

LCD401#1, $1LCD,WTD-22158ACHU-CU

&1LCD,WTD-22158ADHU-CU

N.U.

C411 100p-CH

R438

22k

Q454

R434

UN2212

R431 1k

R433 1k

R432 10k

C410

0.047-B

IC403

TC74VHC595FT

1k

N.U.

R435

R402 1k

R403 1k

C409

C401

D400 1PS226

D401 1PS226

D402 1PS226

D403 1PS226

D404 1PS226

D405 1PS226

R455
$1, 220-1/4
%1 390-1/4

#1, %1 180-1/4

R481

#1 680-1/4

$1, %1 N.U.

R480

#1 680-1/4

R451

#1 680-1/4

LD480

#1 DB1111C

LD481

#1 DB1111C

R404 1k

R405 1k

R406 1k

Q451

#1 2SD1328

$1, %1, &1

N.U.

R476

#11.2k

$1, %1,&1N.U.

&1 560-1/4

&1 560-1/4

$1, %1 N.U.

R452

#1 680-1/4

$1, %1 N.U.

&1 560-1/4

$1, %1 N.U.

$1, %1 N.U.

&1 BR1111C

LD451

#1 DB1111C

&1 BR1111C

$1, %1 N.U.

&1 BR1111C

LD463

#1 DB1111C

&1 BR1111C

R477

R487

R467

R466

&1 560-1/4

$1, %1 N.U.

$1, %1 N.U.

#1 200-1/4

#1 200-1/4

&1 390-1/4

330-1/4

#1, $1, %1 BG1111C

R483

R484

330-1/4

&1 390-1/4

#1, $1, %1 330-1/4

LD474

LD450

$1AA1111C

&1 BR1111C

&1 BR1111C

$1 AA1111C

#1, %1 BG1111C

#1, %1 BG1111C

&1 J-1/4

$1, %1 N.U.

&1 J-1/4

$1, %1 N.U.

R457

#1 220-1/4

$1, &1270-1/4

%1 150-1/4

LD456

220-1/4

#1, $1, %1

&1 390-1/4

R458

220-1/4

LD452

&1 BR1111C

$1 AA1111C

#1, %1 BG1111C

LD453

$1 AA1111C

&1 BR1111C

#1, %1 BG1111C

LD464

&1 BR1111C

$1 AA1111C

#1, %1 BG1111C

LD466

&1 BR1111C

$1 AA1111C

#1, %1 BG1111C

LD465

&1 BR1111C

$1 AA1111C

#1, %1 BG1111C

LD467

$1 AA1111C

#1, %1 BG1111C

R461

#1 180-1/4

$1, &1220-1/4

&1 N.U.

R459

#1, $1, %1

270-1/4

&1330-1/4

R460

270-1/4

%1 N.U.

R462

#1, $1 220-1/4

&1 330-1/4

LD455

&1 BR1111C

$1 AA1111C

#1 BG1111C

&1 BR1111C

#1, %1BG1111C

LD454 $1AA1111C

LD470

$1 AA1111C

#1 BG1111C

&1 BR1111C

LD471

LD468

#1 BG1111C

$1 AA1111C

&1 BR1111C

&1 BR1111C

#1, %1 BG1111C

R465

#1, $1,%1

270-1/4

&1 330-1/4

R463

R464

#1, $1 220-1/4

%1 N.U.

LD456

%1 N.U.

LD472

%1 N.U

$1 AA1111C

&1 BR1111C

R453

%1 N.U.

#1 180-1/4

&1 330-1/4

 #1 BG1111C

 #1 BG1111C

.LD473

$1 36-1/4

%1 27-1/4

$1, &1 220-1/4

%1 N.U.

$1 AA1111C

$1 AA1111C

#1 BG1111C

$1 AA1111C

#1, &1 N.U.

PL451

#1, &1 N.U.

$1, %1 6V-80mA

R482

270-1/4

&1 BR1111C

%1 N.U.

LD458

BG1111C

%1 N.U.

&1 BR1111C

PL454

 %1 6V-80mA

 #1, $1, &1 N.U.

LD469

BG1111C

%1 N.U.

&1 BR1111C

R468

270-1/4

R472

#1, $1, %1

270-1/4

&1 330-1/4

R469

R454

 N.U.

#1, $1, &1

%1 27-1/4

PL452

R448

$136-1/4

#1, %1, &1 N.U.

R449

$136-1/4

#1, %1, &1 N.U.

R450

$1 36-1/4

#1, %1, &1 N.U.

470

471

4.7k-1/4

4.7k-1/4
R479 N.U.

R478 N.U.

LD476

%1 6V-80mA

#1, $1, &1 N.U.

LD459

#1, $1, %1 AA1111C

PL453

%1 6V-80mA

#1, $1, &1 N.U.

LD475

#1, $1, %1

AA1111C

Q452

2SD601A

R436

4.7k

BR1111C

 &1 BR1111C

LD460

BR1111C

PL456 N.U.

PL455 N.U.

&1 BR1111C

Q453

2SD601A

R437

4.7k

56-1/4

R474

120-1/4

LD461

NSCWS405T

ZD451 MAZS180

ZD452 MAZS180

LD478

NSCWS405T

0.022-B

R473

56-1/4

R475

120-1/4

LD462

NSCWS405T

LD479

NSCWS405T

C402

R401
24K



C400

0.1-B

R408 N.U.

R409 10k

R410 10k

R411 10k

R412 1k

R413 1k

R415 1k

R414

24K

0.022-B

CH401

BTB, TMD-V15P-A1

IC401

PT6583LQ

SW421

ENC, EC11E1564411

C406 0.047-B

C407 0.047-B

R423 1k

R424 1k

R425 1k

R426 1k

R427 1k

R428 1k

R429 1k

R430 1k

R421 1k

R422 1k

C404 820p

R407 47k

C405

0.047-B

SW404

ZD401

RD6.2MB3

SW401

R419

SW403

C403

4.7k

100k

R420

SW405

SW402

SW406

SW407

SW409

SW401-420 : SKRPACE010

N.U.

R447

N.U.

R446

N.U.

N.U.

IC402

N.U.

C408

SW410

SW414

SW408

SW415

SW412

SW413

SW411

SW416

SW417

SW418

SW419

SW420

D415

MA159

MA159

D416

D417

MA159

N.U.

D406