EN
User manual
Oven
ZOB10501
Contents
Safety information _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 2
Product description _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 4
Before first use _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 4
Daily use _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 5
Using the accessories _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 5
Additional functions _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 6
Safety information
Before the installation and use, read this manual carefully:
• For your personal safety and the safety of your property
• For the respect of the environment
• For the correct operation of the appliance.
Always keep these instructions with the appliance also if
you move or sell it.
The manufacturer is not responsible if incorrect installation or use results in damage.
Children and vulnerable people safety
• This appliance can be used by children aged from 8
years and above and persons with reduced physical,
sensory or mental capabilities or lack of experience
and knowledge if they have been given supervision or
instruction concerning use of the appliance in safe way
and understand the hazards involved. Children shall
not play with the appliance.
• Keep all packaging away from children. There is the
risk of suffocation or physical injury.
• WARNING: Keep children and animals away from the
appliance when the door is open or the appliance is in
the operation, because it becomes hot. There is the risk
of injury or other permanent disability.
• If the appliance has Child Lock or Key Lock (Control
Lock) function, use it. It prevents children and animals
from accidental operation of the appliance.
General safety
• Do not change the specifications of this appliance.
There is the risk of injury and damage to the appliance.
• Do not let the appliance stay unattended during operation.
• Switch off the appliance after each use.
Helpful hints and tips _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 6
Care and cleaning _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 9
What to do if… _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 11
Installation _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 12
Environment concerns _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 13
Subject to change without notice.
Installation
• Only an approved electrician can install and connect
the appliance. Contact an approved service centre. This
is to prevent the risks of structural damage or physical
injury.
• Make sure that the appliance is not damaged because
of transport. Do not connect a damaged appliance. If
necessary, contact the supplier.
• Remove all packaging, stickers and layers from the appliance before first use. Do not remove the rating plate.
It can invalidate the guarantee.
• Fully obey the laws, ordinances, directives and standards in force in the country where you use the appliance (safety regulations, recycling regulations, electrical or gas safety rules etc.).
• Make sure that the appliance is disconnected from the
power supply during the installation.
• Be careful when you move the appliance. The appliance
is heavy. Always use safety gloves. Do not pull the appliance by the handle.
• The electrical installation must have an isolation device
which lets you disconnect the appliance from the
mains at all poles. The isolation device must have a
contact opening width of minimum 3 mm.
• You must have correct isolation devices: line protecting cut-outs, fuses (screw type fuses removed from the
holder), earth leakage trips and contactors.
• The shock protection parts must be fixed in such a way
that they cannot be undone without tools.
• Some parts of the appliance carry current. Close the
appliance with furniture and make sure that there are
no free spaces. It prevents electrical shock because you
cannot accidentally touch dangerous parts.
2
www.zanussi.com
• Before the installation, make sure that the kitchen cabinet has the recess dimensions applicable.
• Make sure that the appliance is installed below and adjacent safe structures.
• Keep the minimum distances to the other appliances
and units.
• Install the appliance with its back and one side close to
the higher appliance. The other side must be close to
appliance with the same height.
• The appliance cannot be positioned on a base.
Electrical connection
• The appliance must be earthed.
• Make sure that the electrical data on the rating plate
agree with your domestic power supply.
• Information on the voltage is on the rating plate.
• Always use a correctly installed shockproof socket.
• When you connect electrical appliances to mains sockets, do not let cables touch or come near the hot appliance door.
• Do not use multi-way plugs, connectors and extension
cables. There is the risk of fire.
• Do not replace or change the mains cable. Contact the
service centre.
• Make sure not to squash or cause damage to the mains
plug (if applicable) and cable behind the appliance.
• Make sure that the mains connection is accessible after
the installation.
• Do not pull the mains cable to disconnect the appliance. Always pull the mains plug – if applicable.
Use
• The appliance is only for domestic use. Do not use the
appliance for commercial and industrial use.
• Only use the appliance for domestic cooking tasks.
This is to prevent physical injury to persons or prevent
damage to property.
• Do not use the appliance as a work surface or storage
surface.
• Do not put flammable products or items that are wet
with flammable products, and/or fusible objects (made
of plastic or aluminium) in, near or on the appliance.
There is the risk of explosion or fire.
• The interior of the appliance becomes hot during use.
There is the risk of burns. Do not touch the heating ele-
www.zanussi.com
ments in the appliance. Use gloves when you insert or
remove the accessories or pots.
• Be careful when you remove or install the accessories
to prevent damage to the oven enamel.
• Always stay away from the appliance when you open
the door while the appliance is in operation. Hot steam
can release. There is the risk of skin burns.
• Discoloration of the enamel has no effect on the performance of the appliance so it is not a defect in the
sense of the warranty law.
• To prevent damage or discoloration to the enamel:
– Do not put any objects directly on the appliance
floor and do not cover it with aluminium foil.
– Do not put water directly into the hot appliance.
– Do not keep moist dishes and food in the appliance
after you finish the cooking.
• Do not use this appliance if it is in contact with water.
Do not operate the appliance with wet hands.
• Do not apply pressure on the open door.
• Always close the appliance door when you cook, even
while grilling.
Care and cleaning
• Before maintenance, switch off the appliance and disconnect the appliance from the power supply.
• Before maintenance, make sure that the appliance is
cold. There is the risk of burns. There is the risk that
the glass panels can break.
• Keep the appliance clean at all times. A build-up of fats
or other foodstuff can result in a fire.
• Regular cleaning prevents the surface material from deteriorating
• Use a deep baking tray for very moist cakes to prevent
that fruit juices cause stains that can be permanent.
• For your personal safety and the safety of your property, only clean the appliance with water and a soap. Do
not use flammable products or products that can cause
corrosion.
• Do not clean the appliance with steam cleaners, highpressure cleaners, sharp objects, abrasive cleaning
agents, abrasive sponges and stain removers
• If you use an oven spray, follow the instructions from
the manufacturer.
• Do not clean the glass door with abrasive cleaning
agents or metal scraper. Heat resistant surface of the
inner glass can break and shatter.
3
• When the door glass panels are damaged they become
weak and can break. You must replace them. Contact
the service centre.
• Be careful when you remove the door from the appliance. The door is heavy!
• Do not clean catalytic enamel (if applicable).
Risk of fire
• Open the door carefully. The use of ingredients with alcohol can cause a mixture of alcohol and air. There is
the risk of fire.
• Do not let sparks or open flames come near the appliance when you open the door.
• Do not put flammable products or items that are wet
with flammable products, and/or fusible objects (made
of plastic or aluminium) in, near or on the appliance.
Oven lamp
• The type of light bulb or halogen lamp used for this appliance is only for household appliances. Do not use it
for house lighting.
Product description
1 32
5
4
3
8
2
1
7
Knob for the oven functions
1
Knob for the temperature
2
Temperature indicator
3
4
5
6
• If it becomes necessary to replace the lamp, use one of
the same power and specifically designed for household appliances only.
• Disconnect the appliance from the power supply before
the replacement of the oven lamp. There is the risk of
electrical shock.
Service centre
• Only an approved engineer can repair or work on the
appliance. Contact an approved service centre.
• Use only original spare parts.
Disposal of the appliance
• To prevent the risk of physical injury or damage
– Disconnect the appliance from the power supply.
– Cut off the mains cable and discard it.
– Discard the door catch. This prevents children or
small animals from being closed inside of the appliance. There is the risk of suffocation.
Grill
4
Oven lamp
5
Acqua cleaning container
6
Rating plate
7
Shelf positions
8
Oven accessories
• Wire shelf
For cookware, cake tins, roasts.
• Standard deep grill/roasting pan
To bake and roast or as a pan to collect fat.
• Grill trivet
To roast and grill.
Use the trivet only with the roasting pan.
Before first use
Warning! Refer to "Safety information" chapter.
4
Initial cleaning
• Remove all accessories and removable shelf supports
(if applicable).
www.zanussi.com
• Clean the appliance before first use.
Important! Refer to the chapter "Care and cleaning".
Preheating
Preheat the empty appliance to burn off the remaining
grease.
1.
Set the function
and the maximum temperature.
Daily use
2. Let the appliance operate for 45 minutes.
3.
Set the function
4. Let the appliance operate for 15 minutes.
Accessories can become hotter than usually. The appliance can emit an odour and smoke. This is normal. Make
sure that the airflow is sufficient.
and the maximum temperature.
Warning! Refer to "Safety information" chapter.
Activating and deactivating the appliance
1. Turn the oven functions control knob to an oven
function.
2. Turn the temperature control knob to a temperature.
Oven functions
Oven function Application
Off position The appliance is off.
Conventional Cooking
Bottom Heat
Top Heat To finish cooked dishes. Only the top heating element operates.
Grilling
Fast Grilling
To bake and roast on one oven level. The top and bottom heating elements oper-
To bake cakes with crispy or crusty bottom. Only the bottom heating element op-
To grill flat food items in small quantities in the middle of the shelf. To make
To grill flat food items in large quantities. To make toast. The full grill element
Using the accessories
The temperature indicator comes on while the temperature in the appliance increases.
3. To deactivate the appliance, turn the oven functions
control knob and the temperature control knob to the
Off position.
ate at the same time.
erates.
toast.
operates.
Warning! Refer to "Safety information" chapter.
Trivet and grill/roasting pan
Warning! Be careful when you remove the
accessories from a hot appliance. There is a risk of
burns.
To grill flat food items and to make toast:
www.zanussi.com
Put the trivet in the grill/roasting pan so that the supports
point down.
5
Put the grill/roasting pan in the oven at the necessary level.
Additional functions
Cooling fan
When the appliance operates, the cooling fan activates automatically to keep the surfaces of the appliance cool. If
you deactivate the appliance, the cooling fan continues to
operate until the temperature in the appliance cools down.
Helpful hints and tips
• The appliance has five shelf levels. Count the shelf levels from the bottom of the appliance floor.
• The appliance has a special system which circulates
the air and constantly recycles the steam. With this
system you can cook in a steamy environment and
keep the food soft inside and crusty outside. It decreases the cooking time and energy consumption to a
minimum.
• Moisture can condense in the appliance or on the door
glass panels. This is normal. Always stand back from
the appliance when you open the appliance door while
cooking. To decrease the condensation, operate the appliance for 10 minutes before cooking.
• Clean the moisture after each use of the appliance.
• Do not put the objects directly on the appliance floor
and do not put aluminium foil on the components
when you cook. This can change the baking results and
cause damage to the enamel.
Baking cakes
• Do not open the oven door before 3/4 of the set cooking time is up.
Baking and roasting table
Safety thermostat
Incorrect operation of the appliance or defective components can cause dangerous overheating. To prevent this,
the oven has a safety thermostat which interrupts the power supply. The oven activates again automatically when
the temperature drops.
• If you use two baking trays at the same time, keep one
empty level between them.
Cooking meat and fish
• Use a dripping pan for very fatty food to prevent the
oven from stains that can be permanent.
• Leave the meat for approximately 15 minutes before
carving so that the juice does not seep out.
• To prevent too much smoke in the oven during roasting, add some water into the dripping pan. To prevent
the smoke condensation, add water each time after it
dries up.
Cooking times
Cooking times depend on the type of food, its consistency, and volume.
Initially, monitor the performance when you cook. Find the
best settings (heat setting, cooking time, etc.) for your
cookware, recipes and quantities when you use this appliance.
CAKES
Conventional Cooking
TYPE OF DISH
Whisked recipes 2 170 45-60 In a cake mould
Shortbread dough 2 170 20-30 In a cake mould
Buttermilk cheesecake 1 170 70-80 In a 26 cm cake mould on a wire shelf
6
Shelf posi-
tion
Temp [°C]
Cooking time
[min]
Notes
www.zanussi.com
TYPE OF DISH
Conventional Cooking
Shelf posi-
tion
Temp [°C]
Cooking time
[min]
Notes
Apple cake (Apple pie) 2 170 80-100 In two 20 cm cake moulds on a wire
1)
shelf
Strudel 3 175 60-80 In a baking tray
Jam-tart 2 170 30-40 In a 26 cm cake mould
Sponge cake 2 170 50-60 In a 26 cm cake mould
Christmas cake/Rich
2 160 90-120
In a 20 cm cake mould
1)
fruit cake
Plum cake 1 175 50-60
In a bread tin
1)
Small cakes 3 170 20-30 In a baking tray
Biscuits/pastry strips 3 140 30-35 In a baking tray
Meringues 3 120 80-100 In a baking tray
Buns 3 190 15-20
In a baking tray
1)
Eclairs 3 190 25-35 In a baking tray
Plate tarts 2 180 45-70 In a 20 cm cake mould
Rich fruit cake 1 160 110-120 In a 24 cm cake mould
Victoria sandwich 1 170 50-60
1) Preheat the oven for 10 minutes.
In a 20 cm cake mould
1)
BREAD AND PIZZA
Conventional Cooking
TYPE OF DISH
Shelf posi-
tion
Temp [°C]
White bread 1 190 60-70
Rye bread 1 190 30-45 In a bread tin
Pizza 1 230-250 10-20
Scones 3 200 10-20
1) Preheat for 10 minutes.
Cooking time
[min]
Notes
1-2 pieces, 500 gr per piece
In a baking tray or deep roasting pan
In a baking tray
FLANS
Conventional Cooking
TYPE OF DISH
Shelf posi-
tion
Temp [°C]
Pasta flan 2 200 40-50 In a mould
www.zanussi.com
Cooking time
[min]
Notes
1)
1)
1)
7
TYPE OF DISH
Conventional Cooking
Shelf posi-
tion
Temp [°C]
Cooking time
[min]
Notes
Vegetable flan 2 200 45-60 In a mould
Quiches 1 180 50-60
Lasagne 2 180-190 25-40
Cannelloni 2 180-190 25-40
1) Preheat for 10 minutes.
In a mould
In a mould
In a mould
MEAT
Conventional Cooking
TYPE OF DISH
Shelf posi-
tion
Temp [°C]
Beef 2 200 50-70 On a wire shelf
Pork 2 180 90-120 On a wire shelf
Veal 2 190 90-120 On a wire shelf
English roast beef, rare 2 210 50-60 On a wire shelf
English roast beef, me-
2 210 60-70 On a wire shelf
dium
English roast beef, well
2 210 70-75 On a wire shelf
done
Shoulder of pork 2 180 120-150 With rind
Shin of pork 2 180 100-120 Two pieces
Lamb 2 190 110-130 Leg
Chicken 2 220 70-85 Whole
Turkey 2 180 210-240 Whole
Duck 2 175 120-150 Whole
Goose 2 175 150-200 Whole
Rabbit 2 190 60-80 Cut in pieces
Hare 2 190 150-200 Cut in pieces
Pheasant 2 190 90-120 Whole
Cooking time
[min]
Notes
1)
1)
1)
8
www.zanussi.com
FISH
Conventional Cooking
TYPE OF DISH
Trout/Sea bream 2 190 40-55 3-4 fish
Tuna fish/Salmon 2 190 35-60 4-6 fillets
Shelf posi-
tion
Temp [°C]
Grilling
Preheat the empty oven for 10 minutes, before
cooking.
Quantity Grilling Cooking time [min]
TYPE OF DISH Pieces [g] Shelf position Temp [°C] 1st side 2nd side
Fillet steaks 4 800 4 max. 12-15 12-14
Beef steaks 4 600 4 max. 10-12 6-8
Sausages 8 - 4 max. 12-15 10-12
Pork chops 4 600 4 max. 12-16 12-14
Chicken (cut in 2) 2 1000 4 max. 30-35 25-30
Kebabs 4 - 4 max. 10-15 10-12
Breast of chicken 4 400 4 max. 12-15 12-14
Hamburger 6 600 4 max. 20-30 -
Fish fillet 4 400 4 max. 12-14 10-12
Toasted sandwiches 4-6 - 4 max. 5-7 -
Toast 4-6 - 4 max. 2-4 2-3
Cooking time
[min]
Notes
Information on acrylamides
Important! According to the newest scientific knowledge, if
you brown food (specially the one which contains starch),
Care and cleaning
Warning! Refer to "Safety information" chapter.
• Clean the front of the appliance with a soft cloth with
warm water and a cleaning agent.
• To clean metal surfaces use a usual cleaning agent.
• Clean the oven interior after each use. Then you can remove dirt more easily and it does not burn on.
• Clean stubborn dirt with a special oven cleaner.
www.zanussi.com
acrylamides can pose a health risk. Thus, we recommend
that you cook at the lowest temperatures and do not brown
food too much.
• Clean all oven accessories after each use and let them
dry. Use a soft cloth with warm water and a cleaning
agent.
• If you have nonstick accessories, do not clean them
using aggressive agents, sharp-edged objects or a
dishwasher. It can destroy nonstick coating.
9
Stainless steel or aluminium appliances:
Clean the oven door with a wet sponge only. Dry it
with a soft cloth.
Do not use steel wool, acids or abrasive materials, as they
can cause damage to the oven surface. Clean the oven
control panel with the same precautions.
Cleaning the door gasket
• Regularly do a check of the door gasket. The door gas-
ket is around the frame of the oven cavity. Do not use
the appliance if the door gasket is damaged. Contact
the Service Centre.
• To clean the door gasket, refer to the general informa-
tion about cleaning.
Acqua cleaning
The Acqua cleaning procedure uses steam to help remove
remaining fat and food particles from the oven.
1. Put 300 ml of water into the Acqua cleaning container
at the bottom of the oven.
2.
Set the oven function
3. Set the temperature to 90 °C.
4. Let the appliance operate for 30 minutes.
5. Deactivate the appliance and let it cool down.
6. When the appliance is cool, clean the inner surfaces
of the oven with a cloth.
Warning! Make sure that the appliance is cool
before you touch it. There is a risk of burns.
.
Oven lamp
Warning! Be careful when you change the oven
lamp. There is a risk of electrical shock.
Before you change the oven lamp:
• Deactivate the oven.
• Remove the fuses in the fuse box or deactivate the cir-
cuit breaker.
Put a cloth on the bottom of the oven to prevent
damage to the oven light and glass cover.
Always hold the halogen lamp with a cloth to prevent
grease residue from burning on the lamp.
1. Turn the glass cover counterclockwise to remove it.
2. Clean the glass cover.
3. Replace the oven light bulb with an applicable 300
°C heat-resistant oven light bulb.
Use the same oven lamp type.
10
4. Install the glass cover.
Cleaning the oven door
The oven door has two glass panels. You can remove the
oven door and the internal glass panel to clean it.
The oven door can close if you try to remove the internal glass panel before you remove the oven door.
1
Open the door fully
and hold the two door
hinges.
3
Close the oven door to
the first opening position
(halfway). Then pull forward and remove the door
from its seat.
5
Release the locking
system to remove the internal glass panel.
2
Lift and turn the levers
on the two hinges.
4
Put the door on a soft
cloth on a stable surface.
90°
6
Turn the two fasteners
by 90° and remove them
from their seats.
www.zanussi.com
2
1
7
Carefully lift (step 1)
and remove (step 2) the
glass panel.
Clean the glass panel with water and soap. Dry the glass
panel carefully.
Installing the door and the glass panel
When the cleaning is completed, install the glass panel
and the oven door. Do the above steps in the opposite sequence.
The screen-printing zone must face the inner side of the
door. Make sure that after the installation the surface of
the glass panel frame on the screen-printing zones is not
rough when you touch it.
Make sure that you install the internal glass panel in the
seats correctly. Refer to the illustration.
What to do if…
Warning! Refer to "Safety information" chapter.
Problem Possible cause Remedy
The appliance does not operate. The appliance is not activated. Activate the appliance. Refer to the
chapter "Daily Use".
The appliance does not operate. The fuse in the fuse box is released. Do a check of the fuse. If the fuse is
released more than one time, contact
a qualified electrician.
The oven lamp does not operate. The oven lamp is defective. Replace the oven lamp.
Steam and condensation collect on
the food and in the oven.
You left the dish in the oven for too
long.
Do not keep the dishes in the oven
for longer than 15-20 minutes after
the cooking ends.
If you cannot find a solution to the problem yourself, contact your dealer or the service centre.
We recommend that you write the data here:
Model (MOD.) .........................................
Product number (PNC) .........................................
Serial number (S.N.) .........................................
www.zanussi.com
The necessary data for the service centre is on the rating
plate. The rating plate is on the front frame of the oven
cavity.
11
Installation
Warning! Refer to "Safety information" chapter.
Building In
558
548
20
600
min. 550
20
min. 560
573
580
min. 550
20
min. 560
6
589
594
A
B
Electrical installation
Important! The manufacturer is not responsible if you do
not follow the safety precautions from the chapter "Safety
information".
This appliance is supplied without a main plug and a main
cable.
Applicable types of cables for Europe:
• Minimum size Cable/flex: 1,5mm²
• Cable/ flex type: H07 RN-F, H05 RN-F, H05 RRF, H05
VV-F, H05 V2V2-F (T90), H05 BB-F
• Fuse 13 A
Applicable types of cables for UK only
Connection via Min. size Cable/flex Cable/flex type Fuse
• 13 A socket outlet
• 13 A spur box
12
2,5 mm² Three core butyl insulated 13 A min.
www.zanussi.com
Connection via Min. size Cable/flex Cable/flex type Fuse
Oven Control Circuit 2,5 mm² PVC/PVC twin and earth 15 A min.
20 A min.
Environment concerns
The symbol on the product or on its packaging
indicates that this product may not be treated as
household waste. Instead it should be taken to the
appropriate collection point for the recycling of electrical
and electronic equipment. By ensuring this product is
disposed of correctly, you will help prevent potential
negative consequences for the environment and human
health, which could otherwise be caused by inappropriate
waste handling of this product. For more detailed
information about recycling of this product, please contact
your local council, your household waste disposal service
or the shop where you purchased the product.
Packaging material
The packaging material is environmentally-friendly
and recyclable. Plastic parts are marked with international
abbreviations such as PE, PS, etc. Dispose of the packaging material in the containers provided for this purpose at
your local waste management facility.
www.zanussi.com
13
14
15
www.zanussi.com/shop
397216701-B-442011
Loading...