Supra Comp, Santera, Launch SL, Legacy, Launch SSV Owner's Manual
...
5820 Hwy 411 South, Maryville, Tennessee 37801 (865) 856-3035
© 2002 Skier’s Choice, Inc.
1
Revised 2-20-02 EHJ
Table of Contents
Section I Introduction 3
Section II Boating Safety 5
Section III Boating Rules 9
Section IV Boat Specificatioins 13
Section V Operating Information 19
Section VI Starting & Operation 21
Section VII Instrument Panel 25
Sectioin VIII Equipment & Options 33
Sectiion IX Service & Maintenance 45
Section X Cleaning, Care & Storage 51
Section XI Winterization & Dry Storage 53
Section XII Technical Information 55
Section XIII Trailer Your Boat 57
Section XIV Supra Warranty 61
Section XV Index 65
Boat Information
Hull Identification Number:______________________________________
Date of Purchase:_____________________________________________
Dealer’s Phone Number:________________________________________
Registration Number:__________________________________________
Engine Serial Number:_________________________________________
Trailer Serial Number:__________________________________________
Revised 2-20-02 EHJ
2
© 2002 Skier’s Choice, Inc.
Section I
Introduction
Introduction
Supra inboard ski boats are manufactured by Skier’s Choice, Inc. in Maryville, Tennessee and
distributed throughout the United States and the world.
This manual provides an overview for operating your Supra boat. It should be considered a
permanent part of your Supra boat, and contains important information on Safety , Boating Rules,
Proper Operation and Maintenance of your boat. Should the boat be sold, this manual will
provide the same important information to the next owner .
Be sure to read and understand all aspects of Boating Safety and Operation before using your
boat. If you have any questions, your dealer can provide the information you need to have a
safe and pleasurable boating experience.
All information, illustrations and specifications
in this manual are based on the latest product
information available at the time of printing.
Supra may discontinue models and equipment
or change specifications and designs without
any notice and without incurring obligation.
This manual contains information about
several Supra models. Some information may not apply to your boat since standard and optional
equipment may vary from model to model.
As you read through this manual, you will find CAUTION, WARNING and DANGER symbols
which require special attention. Please read them carefully! They may tell you how to avoid
problems and/or endangering yourself, your passengers, and other boaters. PLEASE REVIEW
ALL SAFETY INFORMATION.
A maintenance schedule and accessory information are included to assure trouble-free operation
of your boat. Should service problems arise, remember that your Supra dealer knows your boat
best and is interested in your total satisfaction.
Thank you for purchasing a Supra boat. We hope your ownership results in an enjoyable and
rewarding boating experience. Be safe and enjoy the fun!
Comp, Legacy, Santera, Launch, Launch SL, Launch SS, Launch SSV, Sunsport, and Sunsport V
are registered trademarks of Skier’s Choice, Inc.
Trademarks
All other product names are copyright and registered trademarks/trade names of their respective owners.
© 2002 Skier’s Choice, Inc.
© 2002 Skier’s Choice, Inc.
3
Revised 2-20-02 EHJ
4
© 2002 Skier’s Choice, Inc.
Section II
Boating Safety
Important Safety Information!
Your safety, as well as the safety of others with and around
you, is a direct result of how you operate and maintain your
boat. Read and comprehend this manual. Make sure that
you understand all the controls and operating instructions
before attempting to operate the boat. Improper operation is
extremely dangerous.
The basic safety rules are outlined in this section of the
manual. Additional precautions throughout the manual are
noted by the following symbols.
This symbol indicates a potentially hazardous circumstance,
which, if not avoided, may result in minor or moderate injury .
It may also be used to alert against unsafe practices.
This symbol indicates a potentially hazardous situation, which,
if not avoided, could result in death or serious injury.
Boating Safety
Boating Safety starts with a thorough understanding of your
equipment and its proper operation. In addition to careful
review of this manual, you should be aware as well that there
are many sources of information available. Skier’s Choice
urges you to pursue additional training, such as safety and
seamanship courses offered by the U.S. Coast Guard
Auxiliary and the U.S. Power Squadron.
The following is a listing of just some of the agencies and
organizations that offer safety training or information:
- American Red Cross, National HQ
17th & D Streets NW
Washington, DC 20006
(202) 639-3686
www.redcross.org
- USA Waterski
799 Overlook Drive
Winter Haven, FL 33884
(941) 324-4341
www.usawaterski.org
This symbol indicates an imminently hazardous situation,
which, if not avoided, will result in death or serious injury.
This is limited to the most extreme situations.
The precautions listed in this manual and on the boat are
not all-inclusive. If a procedure, method, tool or part is
not specifically recommended by Skier’s Choice, you
must satisfy yourself that it is safe for you and others,
and that the boat will not be damaged or made unsafe as
a result of your decision.
REMEMBER: ALWAYS USE COMMON SENSE WHEN
OPERA TING, SERVICING OR REPAIRING THE BOAT!
In addition to everyday safety, failure to observe safety
recommendations may result in severe personal injury or
death to you or to others. Use caution and common sense
when operating your boat. Don’t take unnecessary chances!
Be certain that all boat passengers are aware of this
information and conform to boat safety principles.
- Boat Owners Association of the United States (BOAT/US)
880 South Pickett Street
Alexandria, VA 22304
(703) 823-9550
www.boatus.com
- National Safe Boating Council
2550 M Street NW, Suite 425
Washington, DC 20037
(202) 296-4588
www.safeboatingcouncil.org
- U.S. Coast Guard Auxiliary Commandant (G-NAB)
2100 Second Street SW
Washington, DC 20593-0001
(800) 336-2628
www.cgaux.org
- U.S. Power Squadron
www.usps.org
- On-Line Basic Boating Safety Course available
at:www.boatsafe.com
Federal law requires certain safety equipment to be on-board
at all times. In addition, responsible boaters carry other
equipment in case of emergency . Check with the local boating
authorities for any additional requirements over and above
the federal stipulations.
5© 2002 Skier’s Choice, Inc.
Safety Equipment
General Safety Precautions
Y our Supra has been equipped at the factory with most of the
federally required safety equipment for
1, 16’-to-26’). This equipment includes:
- UL-approved Marine Fire Extinguisher, T ype A-BC (2 lbs.),
good for solids, liquids, and electrical fire
- ABYC-approved Marine Mufflers with water injection
- USCG-approved Marine Flame Arrestor
- USCG-approved Engine Box Ventilation with spark-less
power blower
- ABYC-approved Electric Horn sound warning device
- USCG-approved inland lighting
Federal law also requires at least a Type I, II or III Personal
Flotation Device (PFD) for each person on board or being
towed on water skis or other recreational equipment. In
addition, one throwable Type IV PFD must also be on board.
As the owner, obtaining the appropriate PFDs is your
responsibility. Y our Supra dealer can—and will be happy to
assist you.
NOTE: Requirements for coastal waters and inland waters
differ. Check with the local authorities for more
information.
A responsible owner will avoid potential problems on an outing
by having additional equipment on board. Normally, this
equipment is dependent on the body of water and the length
of the trip.
We suggest the following—as a minimum. Y our Supra dealer
can also assist you with additional recommendations.
- An anchor with at least 75-feet of line
- A manual bailing device for removing water
- A combination oar/boat hook
- A day-and-night visual distress signal
- A first aid kit and manual
- An airway breathing tube
- A waterproof flashlight
- A set of local navigation charts
- Mooring lines and fenders
- Extra engine oil
- A tool kit
- A portable AM/FM radio or weather radio
inland waters (Class
Failure to adhere to these precautions may result
in severe injury or death to you and/or others.
- Improper operation is extremely dangerous. Operators
must read and understand all operating manuals supplied
with the boat before operation.
- On-board equipment must always conform to the
governing federal, state, and local regulations.
- Small children in the bow of the boat should be
accompanied by an adult at all times.
- Never stand or allow passengers to stand while the boat
is moving. You or others may be thrown from the boat.
- Never operate the boat while under the influence of
alcohol or other drugs.
- Gasoline vapors can explode. Before starting engine,
open engine box, check engine compartment for gasoline
vapors, and operate blower for at least 4 minutes. Run
blower below cruising speed.
- Leaking fuel is a fire and explosion hazard. Inspect
system regularly. Examine fuel tanks for leaks or
corrosion at least annually.
- Never override or modify the engine safety shut-off switch
or engine neutral starting safety switch in any way.
- Never remove or modify components of the fuel system
in any way except for maintenance by qualified personnel.
T ampering with fuel components may cause a hazardous
condition.
- Never allow any type of spark or open flame on board. It
may result in fire or explosion.
- It is the owner’s responsibility to check tightness of the
Rad-A-Cage Tower bolts BEFORE each use.
- The Rad-A-Cage Tower is designed to pull a single (1)
individual. DO NOT climb or sit on the Rad-A-Cage T ower .
Rope may loop on inverted tricks. DO NOT sit behind
the pulling point of the Rad-A-Cage Tower.
Boating-related accidents are generally caused by the
operator’s failure to follow basic safety rules or written
precautions. Most accidents can be avoided if the operator
is completely familiar with the boat, its operation, and can
recognize potentially hazardous situations before an accident
occurs.
- T o avoid serious personal injury, DO NOT be on or about
the swim platform while engine is running and keep away
from rear of boat while engine is running.
- T o avoid serious personal injury , DO NOT operate engine
while anyone is on or about the swim platform or in the
water near the boat.
6
© 2002 Skier’s Choice, Inc.
General Safety Precautions (continued)
- The tow bar is not designed for vertical extensions. Any
modifications to the tow bar or its mountings may result
in damage to the boat and injury to the user.
Skiing Safety
Skiers are obligated to be as aware of the fundamental safety
rules as well as the boat operator. If you are new to water
skiing, seek certified training before starting. You will find it
especially helpful to join a local ski club, USA Waterski, or
similar organization when possible.
- Rear storage area is located above the gas tank and is
not designed for ballast. Weight limit is 150 lbs. equally
distributed.
- The Rad-A-Cage Tower may strike low objects. Check
clearance height around docks, shore, overhanging
objects, bridges and power lines.
- DO NOT pull past 45 degrees of the centerline of the
boat. Failure to follow this rule could result in the boat
capsizing.
Always remember that the majority of water skiing injuries
are the result of impacts with other objects, so always look
where you are going and be aware of what is going on around
you.
Failure to adhere to these warnings may result in severe
injury or death to you and/or others.
- Every skier must always wear a USCG-approved personal
flotation device.
- Maintain a distance of at least 100 feet from all other
objects, including other boats, piers, rafts, mooring and
navigational buoys, pilings, abutments, or any other items.
- Always have an experienced driver and observer in the
boat when skiing.
- Never ski in shallow water, close to shore, or in water
where you do not know the depth or what is beneath the
surface.
- Never put your arm, head, or any other part of your body
through the handle-bridle of the ski line nor wrap the line
around any part of the body at any time.
- Never ski at night, or directly in front of other boats.
- Never jump from a boat that is moving at any speed, nor
enter or exit the water when the engine is running (ON).
- Make sure that everyone knows and uses approved skiing
hand signals and common skiing courtesy.
Ski Pylon Extensions
The use of a ski pylon extension or extensions in excess of
7-feet vertical is not recommended by Supra on our
products. If you elect to use merchandise such as these,
be aware that they could create excessive stress on your
boat and subjectively cause damages not covered by the
warranty.
7© 2002 Skier’s Choice, Inc.
Warning Plates and Labels
Read and note ALL warning plates and labels from bow to
stern that appear on the boat, including these!
8
© 2002 Skier’s Choice, Inc.
Section III
Boating Rules
Basic Boating Rules
Y ou should be aware of these rules and follow them whenever
you encounter another vessel on the water.
The rules presented in this manual are condensed and have
been provided as a convenience only. Consult your local
U.S. Coast Guard Auxiliary (USCGA) or Department of Motor
Vehicles (DMV) for a complete set of rules governing the
waters in which you will be using your boat. If you plan to
travel—even for a short trip—you would be well served to
contact the regional USCGA or DMV in the area where you
will be boating.
Review and understand all local and state laws.
Any time two vessels on the water meet one another, one
vessel has the right-of-way. It is called the stand-on vessel.
The vessel which does NOT have the right-of-way is called
the give-way or burdened vessel.
These rules determine which vessel has the right-of-way , and
accordingly, what each vessel should do.
The vessel with the right-of-way has the duty to continue its
course and speed, except to avoid an immediate collision.
When you maintain your direction and speed, the other vessel
will be able to determine how best to avoid you.
Encountering Other Vessels
There are three main situations in which you may encounter
other vessels and you must observe the Steering Rules in
order to avoid a collision. These are:
- Meeting (you are approaching another vessel head-on)
- Crossing (you are traveling across the other vessel’s path)
- Overtaking (you are passing or being passed by another
vessel)
Using the following illustration in which you are the boat in
the center, you should give right-of-way to all vessels shown
in the white area. In this instance, you are the give-way vessel.
All vessels in the shaded area must yield to you as you are
the stand-on vessel. Both you and the meeting vessel must
alter course to avoid each other.
The vessel which does not have the right-of-way has the duty
to take positive and timely action to stay out of the way of the
stand-on vessel. Normally, the give-way vessel should not
cross in front of the stand-on vessel. Slow down or change
directions briefly and pass behind the other vessel. Y ou should
always move in such a way that the stand-on operator can
see what you are doing.
This rule is called Rule 2 in the International Rules and says,
“In obeying and construing these rules due regard shall be
had to all dangers of navigation and collision, and to any
special circumstances, which may render a departure from
the above rules necessary in order to avoid immediate
danger.”
If you are meeting another power vessel head-on, and you
are close enough to run the risk of collision, neither of you
has the right-of-way . Both of you should alter course to avoid
an accident. You should keep the other vessel on your port
(left) side. This rule doesn’t apply if both of you can clear
each other by continuing your set course and speed.
9© 2002 Skier’s Choice, Inc.
When two power-driven vessels are crossing each other’s
path close enough to run the risk of collision, the vessel
that views the crossing vessel to the starboard (right) side
must give-way.
If the other vessel is to the port (left) side, maintain your
course and direction, provided the other vessel gives you
the right-of-way as it should.
All vessels which are fishing with nets, lines or trawls are
considered under International Rules to be fishing vessels.
Boats with trolling lines are not considered fishing vessels.
Fishing vessels have the right-of-way, regardless of
position. These vessels, however, cannot impede the
passage of other vessels in narrow channels.
Sailing vessels should normally be given the right-of-way.
The exceptions to this are:
- When the sailing vessel is overtaking the power-driven
vessel, the power-driven vessel has the right-of-way.
- Sailing vessels should keep clear of any fishing vessel.
- In a narrow channel, a sailing vessel should not
hamper the safe passage of a power-driven vessel
which can navigate only in such a channel.
If you are passing another vessel, you are the give-way
vessel. This means that the other vessel is expected to
maintain its course and speed. You must stay out of its
way as you clear it, altering course and speed as
necessary.
Conversely, if you are being passed by another vessel, you
should maintain your speed and direction so that the other
vessel can steer itself around you.
There are three other rules to always remember when
driving your boat around other vessels.
When navigating in narrow channels, you should keep to
the right when it is safe and practical to do so. If the
operator of a power-driven vessel is preparing to go around
a bend that may obstruct the view of other water vessels,
the operator should sound a prolonged blast on the whistle
or horn—four to six seconds.
If another vessel is around the bend, it too should sound
the whistle or horn. Even if no reply is heard, however, the
vessel should still proceed around the bend with caution.
The waters of the United States are marked for safe
navigation by the lateral system of buoyage. The markers
and buoys you will encounter have an arrangement of
shapes, colors, numbers and lights to show which side of
the buoy a boater should pass when navigating in a
particular direction.
The markings on these buoys are oriented from the
perspective of being entered from seaward while the boater
is going towards the port. This means that red buoys are
passed on the starboard (right) side when proceeding from
open water into port, and black buoys are to port (left) side.
When navigating out of port, your position to the buoys
should be reversed: red buoys to port and black buoys to
starboard.
Many boating bodies of water are entirely within the
boundaries of a single state. The Uniform State Waterway
Marking Systems has been devised for these waters. This
system uses buoys and signs with distinctive shapes and
colors to show regulatory or advisory information.
These markers are white with black letters and orange
borders. The information signifies speed zones, restricted
areas, danger areas and general information.
Remember: Markings may vary by geographic location.
Always consult local boating authorities before driving your
boat in unfamiliar waters.
(See examples of buoys and markers next page.)
If you navigate these type of waters, you should carry a
portable air horn, which are available from local marine
supply stores.
10
© 2002 Skier’s Choice, Inc.
11© 2002 Skier’s Choice, Inc.
Revised 2-20-02 EHJ
12
© 2002 Skier’s Choice, Inc.
Section IV
Boat Specifications
Comp
Boat Specifications:
Overall Length w/o Platform 19’ 11.5”
Overall Length w/Platform 21’ 8”
Overall Length w/Trailer 23’ 8”
Width (Beam) 91”
Draft 21”
Weight - Boat Only 2,500 lbs.
Weight - Boat & Trailer 3,350 lbs.
Capacity - Passenger 8
Capacity - Weight 1,100 lbs.
Capacity - Fuel 27 gals.
Engine 320 HP, V-8
© 2002 Skier’s Choice, Inc.
13
Revised 2-20-02 EHJ
Santera
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 24”
Weight - Boat Only 3,250 lbs.
Weight - Boat & Trailer 4,350 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 40 gals.
Engine 320 HP, V-8
Legacy
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
14
© 2002 Skier’s Choice, Inc.
Launch
Boat Specifications:
Overall Length w/o Platform 20’ 11”
Overall Length w/Platform 22’ 7”
Overall Length w/Trailer 24’ 9”
Width (Beam) 98”
Draft 24”
Weight - Boat Only 3,450 lbs.
Weight - Boat & Trailer 4,705 lbs.
Capacity - Passenger 13
Capacity - Weight 1,775 lbs.
Capacity - Fuel 37 gals.
Engine 320 HP, V-8
Launch SL
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
15© 2002 Skier’s Choice, Inc.
Launch SS
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
Launch SSV
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 24”
Weight - Boat Only 3,250 lbs.
Weight - Boat & Trailer 4,350 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 40 gals.
Engine 320 HP, V-8
16
© 2002 Skier’s Choice, Inc.
Sunsport
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
Sunsport V
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 24”
Weight - Boat Only 3,250 lbs.
Weight - Boat & Trailer 4,350 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 40 gals.
Engine 320 HP, V-8
17© 2002 Skier’s Choice, Inc.
18
© 2002 Skier’s Choice, Inc.
Section IV
Boat Specifications
Comp
Boat Specifications:
Overall Length w/o Platform 19’ 11.5”
Overall Length w/Platform 21’ 8”
Overall Length w/Trailer 23’ 8”
Width (Beam) 91”
Draft 21”
Weight - Boat Only 2,500 lbs.
Weight - Boat & Trailer 3,350 lbs.
Capacity - Passenger 8
Capacity - Weight 1,100 lbs.
Capacity - Fuel 27 gals.
Engine 320 HP, V-8
© 2002 Skier’s Choice, Inc.
13
Revised 2-20-02 EHJ
Santera
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 24”
Weight - Boat Only 3,250 lbs.
Weight - Boat & Trailer 4,350 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 40 gals.
Engine 320 HP, V-8
Legacy
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
14
© 2002 Skier’s Choice, Inc.
Launch
Boat Specifications:
Overall Length w/o Platform 20’ 11”
Overall Length w/Platform 22’ 7”
Overall Length w/Trailer 24’ 9”
Width (Beam) 98”
Draft 24”
Weight - Boat Only 3,450 lbs.
Weight - Boat & Trailer 4,705 lbs.
Capacity - Passenger 13
Capacity - Weight 1,775 lbs.
Capacity - Fuel 37 gals.
Engine 320 HP, V-8
Launch SL
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
15© 2002 Skier’s Choice, Inc.
Launch SS
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 22”
Weight - Boat Only 3,050 lbs.
Weight - Boat & Trailer 4,150 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 34 gals.
Engine 320 HP, V-8
Launch SSV
Boat Specifications:
Overall Length w/o Platform 21’ 8”
Overall Length w/Platform 23’ 10”
Overall Length w/Trailer 25’ 8”
Width (Beam) 95”
Draft 24”
Weight - Boat Only 3,250 lbs.
Weight - Boat & Trailer 4,350 lbs.
Capacity - Passenger 11
Capacity - Weight 1,500 lbs.
Capacity - Fuel 40 gals.
Engine 320 HP, V-8
16
© 2002 Skier’s Choice, Inc.
Loading...