Component Replacement
- electrical -
TM
Xperia
C3 Dual
S55t, S55u, D2502
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
Xperia
D2533
TM
C3
CONTENTS
1 Replaceable Components ............................................................. 3
2 Component Placing ........................................................................ 5
3 Additional Repair info .................................................................... 6
4 Revision History ........................................................................... 11
For general information about electrical repair related issues, refer to
1220-1336: Generic Repair Manual - electrical
Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction
Do not remove shield can lids (Heat pasta are added and RF performance will be damaged)
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
2(11)
1 Replaceable Components
EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN ‘COMMENTS’ BELOW
COMPONENT LOCATION
P = Primary side
S = Secondary side
REPAIR METHOD
HA = Hot Air (removal & mounting)
ST = Soldering Tool (removal & mounting)
HA/ST = Hot Air for removal - Soldering Tool for mounting
BGA =BGAStation
BH = Bottom Heater
ADDITIONAL INFORMATION
Ö1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s).
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
3(11)
Position Component Part no. Comments
B3500 Mic 3.76 Silicon SGP5 1276-0991
L2200
L3610 Ferrite B 0.0 Ohm 0.0 A 600ohm 0402 0.3A 0.7oh 1000-0132
L3611 Ferrite B 0.0 Ohm 0.0 A 600ohm 0402 0.3A 0.7oh 1000-0132
R1306 Resistor 0.01 Ohm +/-1% 200.0 mW (1.6x0. 1238-2147
S5200 Input Switch Side Push/vol and on/off sw 1252-4327
V7800 LED flash LED 2.03mmx1.63mmx0.70mm 1277-7270
X1300 Conn BtB Plug 4p HIROSE/BM22 1281-9973
X2200 Conn USB B Receptacle 5p 1268-3388
X2802 Conn Coax Receptacle 1p 1237-5326
X2803 Conn Coax Receptacle 1p 1237-5326
X2805 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
X2806 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
X2807 Conn Coax Receptacle 1p 1261-3585
X4100 Card Conn Micro SD 1256-8507
X8003 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
X8600 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
X8601 Conn Leaf Spring Plug 1p Antenna/GND Spr 1239-2123
X9511 Conn Coax Receptacle 1p 1237-5326
X9512 Card Conn SIM Dual uSIM reader (block) 1283-9287
X9513 Card Conn SIM Dual uSIM reader (Shieldin 1281-8718
X9514 Card Conn SIM Dual uSIM reader (block) 1283-9287
Filter 220ohm 0603 2A 0.05ohm Bead
1001-1896
S HA+BH Ö1
P HA+BH Ö2
S HA+BH Ö3
S HA+BH Ö3
S HA+BH Ö4
P HA+BH Ö5
S HA+BH Ö6
S HA+BH Ö7
P HA+BH or BGA Ö8
S HA+BH Ö9
S HA+BH Ö10
S HA+BH Ö11
S HA+BH Ö11
S HA+BH Ö12
P HA+BH or BGA Ö13
S HA+BH Ö14
S HA+BH Ö15
S HA+BH Ö15
S HA+BH Ö16
P HA+BH Ö17
P HA+BH Ö17
P HA+BH Ö17
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
4(11)
2 Component Placing
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only – icon not shown on hard-copies.
Primary side
Secondary side
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
5(11)
3 Additional Repair info
1
B3500
Replace if no audio from secondary mic
Protect the BtB connectors with capton tape!
When replacing protect secondary mic with capton
tape!
2
L2200
Replace if open circuit (USB charger or data transfer
not working)
Protect the USB connector with capton tape!
3
L3610, L3611
Replace if open circuit (Vibrator not working)
Protect the BtB connector with capton tape!
4
R1306
Replace if open circuit (Phone dead)
Protect the BtB connector with capton tape!
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
6(11)
Repair Actions: Additional Repair Info
5
S5200
Replace if open circuit 1-2 when pushed (Reset not
working)
Protect the SIM connectors with capton tape!
6
V7800
Replace if Flash LED not working
Protect the BtB connector with capton tape!
7
X1300
Replace if mechanical damaged. (Phone dead or power
off)
8
X2200
Replace if mechanical damaged (USB charger or data
transfer not working)
Protect the sensor with capton tape!
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
7(11)
Repair Actions: Additional Repair Info
9
X2802
Replace if open circuit 1-2 (No or bad network, main
antenna)
Protect the RF and BtB connectors with capton tape!
10
X2803
Replace if open circuit 1-2 (Bad network, diversity
antenna)
Protect the USB and BtB connectors with capton tape!
11
X2805, X2806
Replace if mechanical damaged (Bad network, diversity
antenna)
Protect the RF and BtB connectors with capton tape!
12
X2807
Replace if mechanical damaged (No or bad network,
main antenna)
Protect the RF and BtB connectors with capton tape!
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
8(11)
Repair Actions: Additional Repair Info
13
X4100
Replace if mechanical damaged (No SD card )
14
X8003
Replace if mechanical damaged ( no or bad WLAN/ BT)
Protect the RF connector with capton tape!
15
X8600, X8601
Replace if mechanical damaged (No or bad NFC)
16
X9511
Replace if open circuit 1-2 ( no or bad WLAN/ BT)
Protect the BtB connector with capton tape!
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
9(11)
Repair Actions: Additional Repair Info
17
X9512, X9513, X9514
Replace if mechanical damaged (No network, restart, No
SIM card inserted)
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
10(11)
4 Revision History
Rev. Date Changes / Comments
1 2014-08-07 Initial release
2 2014-08-22 Added D2502 and D2533
1290-7624 Rev 2
Sony Mobile Communications AB – Company Internal
11(11)
Loading...