Sony Playstation 3 Service Manual

SM-PS3-0093E-02

CECHG series

PLAYSTATION

®

BOARD SERVICE MANUAL

3 SEM-001

2nd edition Level 3

CS Department

Published in Japan C 2007. 10

Reproduction Prohibited

1.5 k



0.15 F

AC voltmeter (0.75 V)

To Exposed Metal Parts on Set

Earth Ground

BD/DVD/CD drive

rear-side view

here

CECHG series

SAFETY CHECK-OUT

After correcting the original service problem, perform the following safety checks before releasing the set to the customer:

1. Check the area of your repair for unsoldered or poorly soldered connections. Check the entire board surface for solder splashes and bridges.

2. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors.

3. Look for unauthorize d re placement parts, particu larly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement.

4. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement.

5. Check the power cable for cracks and abrasion. Recommend the replacement of any such power cable to the customer.

6. ChecktheB+voltagetoseeitisatthevaluesspecied.

7. Check the metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage.

Check leakage as described below.

LEAKAGE TEST

The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers.). Leakage current can be measured by any one of three methods.

1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments.

2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)

CAUTION

Ensure that this product is disconnected from the power plug before the laser protective housing is removed.

CLASS 1M LASER RADIATION WHEN OPEN DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.

This label is located on the BD/DVD/CD Drive laser protective housing inside the enclosure.

SPECIAL COMPONENT NOTICE

The components identified by mark contain confidential information. Strictly follow the instructions whenever the components are repaired and/or replaced.

CAUTION:

The use of optical instruments with this product will increase eye hazard.

CAUTION

Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.

WARNING!!

WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION, BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 25 cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICK-UP BLOCK.

Fig. A. Using an AC voltmeter to check AC leakage.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK

OR DOTTED

!

LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

CAUTION

Risk of Explosion if Battery is replaced by an Incorrect Type. Dispose of Used Batteries According to the Instructions.

Lithium Batteries

If an equipment is provided with a replaceable lithium battery, the following applies:

– if the battery is placed in an OPERATOR ACCESS AREA,

there shall be a warning close to the battery or in both the operating and the service instructions:

ATTENTION AU COMPOSANT AYANT RAPPORT

À LA SÉURITÉ!!

– if the battery is placed elsewhere in the equipment, there shall

be a warning close to the battery or in the service instructions.

LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE

SUR LES DIAGRAMMES SCHÉMATIQUES ET LA

!

LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

– 2 –

Reproduction Prohibited

CECHG series

TABLE OF CONTENTS

1. CIRCUIT DIAGRAM

1-1. CWI-002 Board (1/3) ................................... 1-2

1-2. CWI-002 Board (2/3) ................................... 1-3

1-3. CWI-002 Board (3/3) ................................... 1-4

1-4. SEM-001 Board (1/20) ................................. 1-5

1-5. SEM-001 Board (2/20) ................................. 1-6

1-6. SEM-001 Board (3/20) ................................. 1-7

1-7. SEM-001 Board (4/20) ................................. 1-8

1-8. SEM-001 Board (5/20) ................................. 1-9

1-9. SEM-001 Board (6/20) ............................... 1-10

1-10. SEM-001 Board (7/20) ............................... 1-11

1-11. SEM-001 Board (8/20) ............................... 1-12

1-12. SEM-001 Board (9/20) ............................... 1-13

1-13. SEM-001 Board (10/20) ............................. 1-14

1-14. SEM-001 Board (11/20) ............................. 1-15

1-15. SEM-001 Board (12/20) ............................. 1-16

1-16. SEM-001 Board (13/20) ............................. 1-17

1-17. SEM-001 Board (14/20) ............................. 1-18

1-18. SEM-001 Board (15/20) ............................. 1-19

1-19. SEM-001 Board (16/20) ............................. 1-20

1-20. SEM-001 Board (17/20) ............................. 1-21

1-21. SEM-001 Board (18/20) ............................. 1-22

1-22. SEM-001 Board (19/20) ............................. 1-23

1-23. SEM-001 Board (20/20) ............................. 1-24

2. PRINTED WIRING BOARDS

2-1. CWI-002 Board (Side A) .............................. 2-1

2-2. CWI-002 Board (Side B) .............................. 2-2

2-3. SEM-001 Board (Side A) ............................. 2-3

2-4. SEM-001 Board (Side B) ............................. 2-4

3. ELECTRICAL PARTS LIST

CWI-002 Board ............................................ 3-1

SEM-001 Board ............................................ 3-1

– 3 –

Reproduction Prohibited

SECTION 1

CIRCUIT DIAGRAM

Note on Schematic Diagram:

• All capacitors are in mF unless otherwise noted.

pF: mmF 50 WV or less are not indicated except for

electrolytics and tantalums.

• All resisto rs are in W and otherwise specied.

• % : indicates tolerance.

1

/4 W or less unless

CECHG series

Note:

T h e c o m p o n e n t s identified by mark dotted line with mark !

are critical for safety.

Replace only with part

number specied.

!

or

Note:

Les composants identiés

par une marque ! sont

critiques pour la sécurité.

Ne les remplacer q u e

par une piéce portant le numéro spécié.

1-1

Reproduction Prohibited

BLUETOOTH MODULE

CWI-002 BOARD (1/3)

IC100

IC101

IC100

C100

C101

C102

R100

C103

C104

R101

JL120

JL121

JL122

JL123

JL109 JL111

JL108 JL110

JL103

R103

R104

C109

C108

C111

C112

JL112

R114

R126

C110

C116

R116

IC101

R117

R124

R118

R122

R119

R138

R106

R108

R107

R110

R109

R112

R111

R115

R113

R125

R120

R121

C107

JL104

JL105

JL118

JL119

R131

R105

C106

R129

R139

R130

R132

R102

C105

ANT100

ANT2

CL101

C115

R127

C114

JL113

JL114

JL115

JL116

JL117

R123

R128

D101

CN100

1-1. CWI-002 BOARD (1/3)

CECHG series

1-2

The components identied by

mark

or dotted line with mark

!

are critical for safety.

!

Replace only with part number specied.

Les composants identiés par une

marque

sont critiques pour

!

la sécurité. Ne les remplacer que par une piéce portant le numéro spécié.

Reproduction Prohibited

WIRELESS LAN MODULE

CWI-002 BOARD (2/3)

IC200

IC201

IC202

IC200

R211

R200

R212

R215

R214

C200

R209 R210

R201

R202

R203

R259

R258

R257

R240

R206

C228

C227

JL215

JL220

JL221

R254

Q200

R216

C206 C212 C221 C222

R248

L201

Q201

C210

C211

C225

R217

R218

R219

C213 C216

C226 C214

R260

R256

C209

C208

C203

C204

C205

C201

R220

R247

R241

R242

R243

R244

R245

R246

CN200

JL219

JL210

JL203

JL204

JL205

JL211

JL212

JL213

JL214

JL218

JL206

JL207

R232

R233

IC202

C207

IC201

C223

C229

R252

R253

R251

R204

R205

ANT200

ANT2

C217

R221

C219

C218

CN201

R222

C220

C202

D200

R249

R213

1-2. CWI-002 BOARD (2/3)

CECHG series

1-3

The components identied by

mark

or dotted line with mark

!

are critical for safety.

!

Replace only with part number specied.

Les composants identiés par une

marque

sont critiques pour

!

la sécurité. Ne les remplacer que par une piéce portant le numéro spécié.

Reproduction Prohibited

CWI-002 BOARD (3/3)

CN301

R316

C300

C301

LF300

LF301

LF302

JL301

R325

C302

R317

C303

1-3. CWI-002 BOARD (3/3)

CECHG series

1-4

Reproduction Prohibited

SEM-001 BOARD (1/20)

IC1001

CL1001

CL1002

CL1003

IC1001

CL1004

CL1005

IC1001

R1006

R1007

R1018

C1005

CL1006

R1008

R1009

R1010

R1011

R1012

R1013

R1014

R1015

C1003

R1016

C1004

R1017

Q1001

R1024

CN1001

R1005

Q1002

CL1011

CL1012

R1025

R1026

CL1007

CL1008

R1023

CL1009

IC1001

R1027

IC1001

IC1002

C1001

R1003

R1004

C1002

R1002

IC1001

CL1010

IC1001

1-4. SEM-001 BOARD (1/20)

CECHG series

1-5

Reproduction Prohibited

SEM-001 BOARD (2/20)

CL1101

R1106

R1101

R1105

C1144

R1109 R1111

C1180

R1116

R1118

C1195

C1197

R1119

CL1103

R1117

R1120

C1196

C1198

R1121

L1101

C1192

C1193

C1194

CL1104

R1110

R1112

C1181

R1102

R1107

C1145

CL1102

C1107 C1115 C1123 C1129 C1135 C1149C1140 C1156 C1163 C1170

C1108 C1116 C1124 C1130 C1136 C1150C1141 C1157 C1164

C1106

FB1101

FB1102

C1114 C1122 C1128

C1109 C1117 C1125 C1131

C1134 C1162C1148 C1167 C1173

C1478 C1479

C1139 C1112 C1120

C1132C1126 C1137 C1146 C1153 C1160

C1480

C1105 C1113

C1121 C1127 C1138C1133

C1103 C1110 C1118

C1104 C1111 C1119

C1101

C1102

R1103

FB1103

FB1104

C1151 C1158

C1168 C1174 C1176 C1178 C1182 C1186 C1188

C1169 C1175 C1177 C1179 C1183 C1187 C1189 C1190 C1191

C1142

R1104

C1152

C1159

C1143

C1147 C1154 C1161 C1166

C1165 C1172

C1402 C1411 C1420 C1429 C1440

C1401

C1448

C1405 C1414 C1423 C1432 C1443

C1406 C1415 C1424 C1433

C1407 C1416 C1425 C1434

C1408 C1417 C1426 C1435 C1439 C1447 C1455 C1462

C1409 C1418 C1452 C1459 C1469 C1473 C1475

C1410 C1428 C1445 C1460 C1466 C1470 C1474 C1476 C1477

C1451 C1458

C1403 C1412 C1421 C1430 C1441 C1449 C1456 C1463 C1467 C1471

C1404 C1413 C1422 C1431 C1442 C1450 C1457 C1464 C1468 C1472

C1171

R1108

1-5. SEM-001 BOARD (2/20)

CECHG series

1-6

Reproduction Prohibited

SEM-001 BOARD (3/20)

R1237

C1516

CL1201

IC1201

C1295

R1221

R1223

R1222

R1224

R1216

R1217

R1219

R1220

Q1202

C1287

C1284

C1282

C1280

C1278

C1275

C1273

C1272

C1515

C1513

C1504

R1225

R1226

R1227

R1228

R1229

R1230

R1231

R1232

R1233

R1234

R1235

R1236

FB1201

C1514

C1292

C1281

C1271

R1207

R1204

R1205

CL1202

R1208

Q1201

C1274

C1276

C1279

C1277

R1211

C1395

R1321

R1322

R1324

R1316

R1317

R1319

R1320

Q1302

R1323

C1387

C1384

C1382

C1380

C1378

C1375

C1373

C1372

C1615

R1325

R1326

R1327

R1328

R1329

R1330

R1331

R1332

R1333

R1334

R1335

R1336

C1613

C1604

R1307

CL1302

R1308

C1371

FB1301

C1614

C1392

C1381

R1311

C1379

R1304

R1305

C1377

C1376

C1374

Q1301

C1503

R1337

CL1301

C1616

C1603

C1505 C1507

C1213 C1216 C1219 C1222 C1225 C1228 C1231 C1234 C1237 C1240 C1214 C1217 C1220 C1223 C1226 C1229 C1232 C1235 C1238 C1241

C1506 C1508

C1215 C1218 C1221 C1224 C1227 C1230 C1233 C1236 C1239 C1242

C1509 C1511

C1243 C1246 C1249 C1252 C1255 C1258 C1261 C1264 C1267 C1244 C1247 C1250 C1253 C1256 C1259 C1262

C1265

C1268

C1510 C1512 C1245 C1248 C1251 C1254 C1257 C1260 C1263 C1266 C1269 C1270

C1605 C1607

C1313 C1316 C1319 C1322 C1325 C1328 C1331 C1334 C1337 C1340 C1314 C1317 C1320 C1323 C1326 C1329 C1332 C1335 C1338 C1341

C1606 C1608

C1315 C1318 C1321 C1324 C1327 C1330 C1333 C1336 C1339 C1342

C1609 C1611 C1343 C1346 C1349 C1352 C1355 C1358 C1361 C1364 C1367 C1344 C1347 C1350 C1353 C1356 C1359 C1362 C1365 C1368

C1610 C1612

C1345 C1348 C1351 C1354 C1357 C1360 C1363 C1366 C1369 C1370

IC1201

IC1202

IC1301

IC1302

R1203

R1303

1-6. SEM-001 BOARD (3/20)

CECHG series

1-7

Reproduction Prohibited

SEM-001 BOARD (4/20)

IC2001

R2061

IC2001

R2071

R2072

R2073

IC2001

R2067

R2068

IC2001

C2001

R2001

R2003

R2076

R2002

C2003

R2004

R2007

R2036

R2051

R2058

R2065

R2066

R2064

R2063

R2057

R2059

R2079

C2005

C2004

R2080

R2077

R2075

R2054

R2052

R2053

R2005

IC2001

R2062

IC2001

R2069

IC2001

R2070

1-7. SEM-001 BOARD (4/20)

CECHG series

1-8