Installation and Assembly:
In-wall Mount for up to 40" Flat Panel Displays
Models: IM740P, IM740P-S
Max UL Load Capacity: 80 lb (36.3 kg)
2300 White Oak Circle • Aurora, Il 60502 • (800) 865-2112 • Fax: (800) 359-6500 • www.peerlessmounts.com
ISSUED: 12-04-07 SHEET #: 095-9280-5 08-08-11
Note: Read entire instruction sheet before you start installation and assembly.
WARNING
•Do not begin to install your Peerless product until you have read and understood the instructions and warnings contained in this Installation Sheet. If you have any questions regarding any of the instructions or warnings, please call Peerless customer care at 1-800-865-2112.
•This product should only be installed by someone of good mechanical aptitude, has experience with basic building construction, and fully understands these instructions.
•Make sure that the supporting surface will safely support the combined load of the equipment and all attached hardware and components.
•Never exceed the Maximum UL Load Capacity.
•If mounting to wood wall studs, make sure that mounting screws are anchored into the center of the studs. Use of an "edge to edge" stud fi nder is highly recommended.
•Always use an assistant or mechanical lifting equipment to safely lift and position equipment.
•Tighten screws fi rmly, but do not overtighten. Overtightening can damage the items, greatly reducing their holding power.
•This product was designed and intended to be mounted to the following supporting surfaces checked below with the hardware included in this product as specifi ed in the installation sheet. To mount this product to an alternative supporting surface, contact Peerless customer care at 1 800 865-2112.
•This product was designed to be installed on the following wall construction only;
WALL CONSTRUCTION |
ADDITIONAL HARDWARE REQUIRED |
x Wood Stud |
None |
Wood Beam |
Contact Customer Service (not evaluated by UL) |
Solid Concrete |
Contact Customer Service (not evaluated by UL) |
Cinder Block |
Contact Customer Service (not evaluated by UL) |
Metal Stud |
Contact Customer Service (not evaluated by UL) |
Brick |
Contact Customer Service (not evaluated by UL) |
Other or unsure? |
Contact Customer Service (not evaluated by UL) |
Tools Needed for Assembly
•stud fi nder ("edge to edge" stud fi nder is recommended)
•phillips screwdriver
•drill
•5/32" and 1/8" bit for wood stud wall
•level
Table of Contents |
|
Parts List................................................................................................................................................................................. |
3 |
Installation to Wood Stud Wall................................................................................................................................................ |
4 |
Installing Articulating Arm to In-wall Box................................................................................................................................. |
5 |
Attaching Display.................................................................................................................................................................... |
5 |
Cable Management ................................................................................................................................................................ |
6 |
2 of 7 |
ISSUED: 12-04-07 SHEET #: 095-9280-5 01-11-12 |
Visit the Peerless Web Site at www.peerlessmounts.com |
For customer care call 1-800-865-2112 |
Before you begin, make sure all parts shown are included with your product.
Parts may appear slightly different than illustrated.
Parts List |
|
IM740P |
IM740P-S |
|
|
Description |
Qty. |
Part # |
Part # |
A |
in-wall box |
1 |
095-P1536 |
095-C4536 |
B |
#10 x 1.5" wood screw |
2 |
500-2002 |
500-2002 |
C |
mounting cover plate |
2 |
095-P1533 |
095-C4533 |
D |
ribbed rivet |
4 |
590-1296 |
590-1296 |
E |
cable bushing |
2 |
590-1295 |
590-1295 |
F |
cable management clips |
4 |
590-1166 |
590-1166 |
G |
plastic finishing cap |
2 |
590-1123 |
590-1123 |
H |
cable tie |
4 |
590-1168 |
590-1168 |
AA |
Articulating Arm for |
1 |
PA740 |
PA740-S |
22" - 40" screens |
A
B C D E F G H
AA
PA740, PA740-S
ARTICULATING ARM
(SEE INSTRUCTION FOR CONTENTS INCLUDED WITH PA740 OR PA740-S)
3 of 7 |
ISSUED: 12-04-07 SHEET #: 095-9280-5 01-11-12 |
Visit the Peerless Web Site at www.peerlessmounts.com |
For customer care call 1-800-865-2112 |