Opel Corsa 2009.5 Owner Manual
Contents
Introduction .................................... 2
In brief ............................................ 6
Keys, doors and windows ............ 19
Seats, restraints ........................... 33
Storage ........................................ 50
Instruments and controls ............. 66
Lighting ........................................ 93
Infotainment system ................... 101
Climate control ........................... 104
Driving and operating ................. 111
Vehicle care ............................... 135
Service and maintenance .......... 175
Technical data ........................... 190
Customer information ................ 211
Index .......................................... 212
2 Introduction
Introduction
Introduction 3
Vehicle specific data
Please enter your vehicle's data on
the previous page to keep it easily
accessible. This information is
available under the sections "Service
and Maintenance" and "Technical
data" as well as on the identification
plate.
Introduction
Your vehicle is a designed
combination of advanced technology,
safety, environmental friendliness
and economy.
This Owner's Manual provides you
with all the necessary information to
enable you to drive your vehicle
safely and efficiently.
Make sure your passengers are
aware of the possible risk of accident
and injury which may result from
improper use of the vehicle.
You must always comply with the
specific laws and regulations of the
country that you are in. These laws
may differ from the information in this
Owner's Manual.
When this Owner's Manual refers to
a workshop visit, we recommend your
Opel Service Partner.
All Opel Service Partners provide
first-class service at reasonable
prices. Experienced mechanics
trained by Opel work according to
specific Opel instructions.
The customer literature pack should
always be kept ready to hand in the
vehicle.
Using this manual
■ The "In brief" section will give you
an initial overview.
■ The table of contents at the
beginning of this manual and within
each chapter shows where the
information is located.
■ The index will enable you to search
for specific information.
■ This Owner's Manual depicts lefthand drive vehicles. Operation is
similar for right-hand drive vehicles.
■ The Owner's Manual uses the
factory engine designations. The
corresponding sales designations
can be found in the chapter
"Technical data".
■ Directional data, e.g. left or right, or
front or back, always relate to the
direction of travel.
■ Depending on the model variant,
country variant, integrated special
equipment and accessories, the
scope of equipment in the vehicle
can differ from the items mentioned
in this Owner's Manual.
■ Display messages and interior
labelling are written in bold letters.
Danger, Warnings and
Cautions
9 Danger
Text marked 9 Danger provides
information on risk of fatal injury.
Disregarding this information may
endanger life.
4 Introduction
9 Warning
Text marked 9 Warning provides
information on risk of accident or
injury. Disregarding this
information may lead to injury.
Caution
Text marked Caution provides
information on possible damage to
the vehicle. Disregarding this
information may lead to vehicle
damage.
Symbols
Page references are indicated with
3. 3 means "see page".
We wish you many hours of
pleasurable driving.
Adam Opel GmbH
Introduction 5
6 In brief
In brief
Initial drive information
Vehicle unlocking
Turn the key in the driver's door lock
to the front or press button q to
unlock the doors and load
compartment. Open the doors by
pulling the handles. To open the
tailgate, pull the button under the
tailgate moulding.
Radio remote control 3 19, Central
locking system 3 21, Load
compartment 3 24.
Seat adjustment
Seat positioning
Pull handle, slide seat, release
handle.
Seat adjustment 3 35, Seat position
3 34.
In brief 7
Seat backrests
Turn handwheel. Do not lean on seat
when adjusting.
Seat adjustment 3 35, Seat position
3 34, Folding front passenger seat
backrest 3 36.
Seat height
Lever pumping motion
up = higher
down = lower
Seats 3 35, Seat position 3 34.
Head restraint adjustment
Press release button, adjust height,
engage.
Head restraints 3 33.
8 In brief
Seat belt
Pull out the seat belt and engage in
belt buckle. The seat belt must not be
twisted and must fit close against the
body. The backrest must not be tilted
back too far (maximum approx. 25 °).
To release belt, press red button on
belt buckle.
Seat belts 3 37, Airbag system
3 39, Seat position 3 34.
Mirror adjustment
Interior mirror
Swivel the lever on the underside to
reduce dazzle.
Interior mirror 3 28, Automatic antidazzle interior mirror 3 28.
Exterior mirrors
Setting with four-way switch in version with manual window operation
First select the relevant exterior mirror
then use the control to adjust.
In brief 9
Setting with four-way switch in version with electronic window operation
First select the relevant exterior mirror
then use the control to adjust.
Electric adjustment 3 26, Convex
exterior mirrors 3 26, Folding
exterior mirrors 3 27, Heated
exterior mirrors 3 28.
Steering wheel adjustment
Unlock lever, adjust steering wheel,
then engage lever and ensure it is
fully locked. Do not adjust steering
wheel unless vehicle is stationary and
steering wheel lock has been
released.
Airbag system 3 39, Ignition
positions 3 112
10 In brief
Instrument panel overview
In brief 11
1 Side air vents ...................... 109
2 Light switch .......................... 93
Instrument illumination ......... 98
Rear fog light ......................... 97
Front fog lights ..................... 97
Headlight range
adjustment ........................... 94
3 Turn and lane-change
signals, headlight flash,
low beam and high beam ..... 96
Exit lighting .......................... 100
Parking lights ........................ 97
Cruise control ....................... 81
4 Remote control on
steering wheel ...................... 66
5 Horn ...................................... 67
Driver airbag ......................... 40
6 Instruments .......................... 72
7 Windscreen wiper,
windscreen washer system ... 68
Trip computer ........................ 87
8 Centre air vents ................... 109
9 Info-Display ........................... 81
Trip computer ........................ 87
Electronic climate control
system ................................. 106
10 Left heated seat .................... 36
Heated steering wheel .......... 67
Tyre deflation detection
system ................................. 161
Parking assist ...................... 126
Hazard warning flashers ....... 96
Central locking system .......... 21
Electronic stability program . 124
Airbag deactivation ............... 43
Right heated seat .................. 36
11 Front passenger airbag ......... 40
12 Glovebox .............................. 50
13 Infotainment system ............ 101
14 Climate control system ........ 104
15 Cigarette lighter ..................... 71
Power outlet .......................... 71
16 Ashtray .................................. 71
17 Ignition switch with
steering wheel lock ............. 112
18 Accelerator pedal ................ 111
19 Brake pedal ......................... 123
20 Clutch pedal ........................ 111
21 Steering wheel adjustment .... 66
22 Bonnet release lever ........... 136
12 In brief
In brief 13
Exterior lighting
Turn light switch:
= Off
7
= Side lights
8
= Headlights
9
Press
= Front fog lights
>
= Rear fog lights
r
Lighting 3 93.
Headlight flash, high beam and low beam
headlight flash = pull lever
high beam = push lever
low beam = push or pull lever
High beam 3 94, Headlight flash
3 94, Automatic light control
3 93.
Turn and lane-change signals
right = lever up
left = lever down
Turn and lane-change signals
3 96, Parking lights 3 97.
14 In brief
Hazard warning flashers
Operated with the ¨ button.
Hazard warning flashers 3 96.
Horn
Press j.
Washer and wiper systems
Windscreen wiper
= fast
&
= slow
%
= timed interval wipe or
$
automatic wiping with rain
sensor
= off
§
For a single swipe when the
windscreen wiper isoff, press the
lever down.
Windscreen wiper 3 68, Wiper
blade replacement 3 140.
In brief 15
Windscreen and headlight washer systems
Pull lever.
Windscreen and headlight washer
system 3 68, Washer fluid 3 139.
Rear window wiper and washer system
Wiper on = push lever
Wiper off = push lever again
Wash = push lever and hold
Rear window wiper and washer
system 3 69, Wiper blade
replacement 3 140, Washer fluid
3 139.
Climate control
Heated rear window, heated exterior mirrors
Heating is operated by pressing the
Ü button.
Heated rear window 3 30.
16 In brief
Demisting and defrosting the windows
Air distribution to l.
Set temperature control to warmest
level.
Set fan speed to highest level.
Cooling n on.
Press button V.
Climate control system 3 104.
Transmission
Manual transmission
Reverse: with the vehicle stationary,
wait 3 seconds after depressing
clutch pedal and then pull up the
button on the selector lever and
engage the gear.
If the gear does not engage, set the
lever to neutral, release the clutch
pedal and depress again; then repeat
gear selection.
Manual transmission 3 118.
Manual transmission automated
N = neutral
= drive
o
+ = higher gear
- = lower gear
A = switch between automatic and
manual mode
R = reverse gear (with selector
lever lock)
Manual transmission automated
3 119.
In brief 17
Automatic transmission
P = park
R = reverse
N = neutral
D = drive
The selector lever can only be moved
out of P or N when the ignition is on
and the foot brake is depressed
(Selector lever lock). To engage P or
R, push button on selector lever.
The automatic transmission is
available in two versions 3 115.
Starting off
Check before starting off
■ Tyre pressure and condition
3 160, 3 204.
■ Engine oil level and fluid levels
3 137.
■ All windows, mirrors, exterior
lighting and number plates are free
from dirt, snow and ice and are
operational.
■ Proper position of mirrors, seats,
and seat belts 3 26, 3 34,
3 38.
■ Brake function at low speed,
particularly if the brakes are wet.
Starting the engine
Turn key to position 1. Move the
steering wheel slightly to release the
steering wheel lock. Operate clutch
and brake, automatic transmission in
P or N, do not accelerate; for diesel
engines, turn the key to position 2 for
preheating and wait until control
indicator ! goes out; turn key to
3 and release key.
Starting the engine 3 112.
18 In brief
Parking
■ Always apply parking brake.
Manual parking brake without
pressing release button. Apply as
firmly as possible on a downhill
slope or uphill slope. Operate foot
brake at the same time to reduce
operating force.
■ Switch off the engine and ignition.
Turn the ignition key to 0 and
remove. Turn the steering wheel
until the steering wheel lock is felt
to engage.
For vehicles with automatic
transmission, the key can only be
removed when the selector lever is
in the P position.
■ If the vehicle is on a level surface or
uphill slope, engage first gear or set
the selector lever to P before
switching off the ignition. On an
uphill slope, turn the front wheels
away from the kerb.
If the vehicle is on a downhill slope,
engage reverse gear or set the
selector lever to P before switching
off the ignition. Turn the front
wheels towards the kerb.
■ Lock the vehicle with button p on
the radio remote control.
Activate the anti-theft alarm system
3 25.
■ Do not park the vehicle on an easily
ignitable surface. The high
temperature of the exhaust system
could ignite the surface.
■ Close windows and sunroof.
■ The engine cooling fans may run
after the engine has been switched
off 3 136.
■ After running at high engine speeds
or with high engine loads, operate
the engine briefly at a low load or
run in neutral for approx. 30
seconds, before switching off in
order to protect the turbocharger.
Keys, locks 3 19,
Laying the vehicle up for a long period
of time 3 135.
Keys, doors and windows 19
Keys, doors and windows
Keys, locks ................................... 19
Doors ........................................... 24
Vehicle security ............................ 24
Exterior mirrors ............................ 26
Interior mirrors ............................. 28
Windows ...................................... 29
Roof ............................................. 31
Keys, locks
Keys
Replacement keys
The key number is specified in the
Car Pass or on a detachable tag.
The key number must be quoted
when ordering replacement keys as it
is a component of the immobiliser
system.
Locks 3 172
Key with foldaway key section
Press button to extend. To fold the
key, first press the button.
Car Pass
The Car Pass contains security
related vehicle data and should
therefore be kept in a safe place.
When the car is taken to a workshop,
this vehicle data is needed in order to
perform certain operations.
Radio remote control
Used to operate:
■ Central locking system,
■ Anti-theft locking system,
■ Anti-theft alarm system,
■ Power windows.
20 Keys, doors and windows
The radio remote control has a range
of approx. 5 metres (16 ft). This range
can be affected by outside influences.
The hazard warning flashers confirm
operation.
Handle with care, protect it from
moisture and high temperatures and
avoid unnecessary operation.
Fault
If the central locking system cannot
be operated with the radio remote
control, it may be due to the following:
■ Range exceeded,
■ Battery voltage too low,
■ Frequent, repeated operation of the
radio remote control while not in
range, which will require resynchronisation,
■ Overload of the central locking
system by operating at frequent
intervals, the power supply is
interrupted for a short time,
■ Interference from higher-power
radio waves from other sources.
Unlocking 3 21.
Radio remote control battery replacement
Replace the battery as soon as the
range reduces.
Batteries do not belong in household
waste. They must be disposed of at
an appropriate recycling collection
point.
Key with foldaway key section
Extend the key and open the unit.
Replace the battery (battery type CR
2032), paying attention to the
installation position. Close the unit
and synchronise.
Key with fixed key section
Have the battery replaced by
a workshop.
Radio remote control synchronisation
After replacing the battery, unlock the
door with the key in the driver's door
lock. The radio remote control will be
synchronised when you switch on the
ignition.
Memorised settings
When locking the vehicle the last
settings are automatically saved
specifically for the key being used:
■ Electronic climate control,
■ Info-Display,
■ Infotainment system,
■ Instrument panel illumination.
The saved settings are automatically
used when that key is used for
unlocking.
Keys, doors and windows 21
Central locking system
Unlocks and locks doors, load
compartment and fuel filler flap.
A pull on an interior door handle
unlocks the entire vehicle and opens
the door.
Note
In the event of an accident of
a certain severity, the vehicle
unlocks automatically.
Unlocking
Central locking system with key activation
Turn the key in the driver's door lock
to the front.
Central locking system with radio remote control
Press button q.
Two settings are possible: To unlock
only the driver's door, press button
q once, to unlock the entire vehicle,
press button q twice. Vehicle
personalization 3 91.
Locking
Close doors, load compartment and
fuel filler flap. If the driver's door is not
closed properly, the central locking
system will not work.
Central locking system with key activation
Turn the key in the driver's door lock
rearwards.
22 Keys, doors and windows
Central locking system with radio remote control
Press button p.
Central locking button
Press button m: the doors are locked
or unlocked.
The LED in the button m illuminates
for approx. 2 minutes after locking
with the radio remote control.
If the doors are locked from the inside
whilst driving, the LED remains lit.
If the key is in the ignition, locking is
only possible if all doors are closed.
Fault in radio remote control
Unlocking
Turn key in the driver's door lock as
far as it will go. The entire vehicle is
unlocked when the driver's door is
opened. To open the other doors,
switch on the ignition and press the
central locking button.
Locking
Close the driver's door, open the
passenger door, press central locking
button m. The vehicle is locked.
Close the passenger door.
Keys, doors and windows 23
Fault in central locking system
Unlocking
Turn key in the driver's door lock as
far as it will go. The other doors can
be opened by pulling the interior
handle (not possible if the anti-theft
locking system is active). The load
compartment and fuel filler flap
remain locked. To deactivate the antitheft locking system, switch on the
ignition 3 25.
Locking
Insert key into opening above lock on
inside of door and operate lock by
lifting until it clicks. Then close the
door. The procedure must be carried
out for each door. The driver's door
can also be locked from the outside
with the key. The fuel filler flap and
tailgate cannot be locked.
Automatic locking
This security feature can be
configured to automatically lock all
doors, load compartment and fuel
filler flap as soon as the vehicle is
driven. Vehicle personalization
3 91.
Child locks
9 Warning
Use the child locks whenever
children are occupying the rear
seats.
Using a key or suitable screwdriver,
turn button on rear door lock to the
horizontal position: door cannot be
opened from inside.
24 Keys, doors and windows
Doors
Load compartment
Opening
Pull the button underneath the
moulding.
9 Warning
Do not drive with the tailgate open
or ajar, e.g. when transporting
bulky objects, since toxic exhaust
gases could enter the vehicle.
Note
The installation of certain heavy
accessories onto the tailgate may
affect its ability to remain open.
Closing
Use the interior handle.
Do not press the button under the
moulding while closing as this will
unlock it again.
Vehicle security
Anti-theft locking system
9 Warning
Do not use the system if there are
people in the vehicle! The doors
cannot be unlocked from the
inside.
The system deadlocks all the doors.
All doors must be closed or the
system cannot be activated.
If the ignition was on, the driver's door
must be opened and closed once so
that the vehicle can be secured.
Unlocking the vehicle disables the
mechanical anti-theft locking system.
This is not possible with the central
locking button.
Keys, doors and windows 25
Activating with the remote control
Press p again at the latest 10
seconds after locking.
Anti-theft alarm system
The anti-theft alarm system
incorporates and is operated in
conjunction with the anti-theft locking
system.
It monitors:
■ Doors, load compartment, bonnet,
■ Ignition.
Unlocking the vehicle deactivates
both systems simultaneously.
Light-emitting diode (LED)
During the first 10 seconds of antitheft alarm system activation:
LED
illuminates
LED
flashes
quickly
After the first 10 seconds of anti-theft
alarm system activation:
LED flashes
slowly
= Test, ignition delay,
= Door, load
compartment or
bonnet open, or
system fault.
= System active.
Seek the assistance of a workshop in
the event of faults.
Alarm
When triggered, the alarm gives off
an acoustic signal (horn) and a visual
signal (hazard warning flashers). The
number and duration of which are
stipulated by legislation.
The alarm siren can be silenced by
pressing any button of the radio
remote control or by switching on the
ignition. The anti-theft alarm system is
deactivated at the same time.
Immobiliser
The system checks whether the
vehicle is allowed to start with the key
being used. If the transponder in the
key is recognised, the engine can be
started.
The electronic immobiliser activates
itself automatically after the key has
been removed from the ignition
switch.
26 Keys, doors and windows
If the control indicator A flashes
when the ignition is on, there is a fault
in the system; the engine cannot be
started. Switch off the ignition and
then repeat the start attempt.
If the control indicator continues
flashing, attempt to start the engine
using the spare key and seek the
assistance of a workshop.
If control indicator illuminates after
the engine has started, there is a fault
in the engine electronics or
transmission electronics 3 77,
3 117, 3 122, or there is water in the
diesel fuel filter 3 86.
Note
The immobiliser does not lock the
doors. You should always lock the
vehicle after leaving it and switch on
the anti-theft alarm system 3 21,
3 25.
Exterior mirrors
Convex shape
The convex exterior mirror reduces
blind spots. The shape of the mirror
makes objects appear smaller, which
will affect the abilty to estimate
distances.
Electric adjustment
Setting with four-way switch in version with manual window operation
First select the relevant exterior mirror
then use the control to adjust.
Setting with four-way switch in version with electronic window operation
First select the relevant exterior mirror
then use the control to adjust.
Keys, doors and windows 27
Folding
For pedestrian safety, the exterior
mirrors will swing out of their normal
mounting position if they are struck
with sufficient force. Reposition the
mirror by applying slight pressure to
the mirror housing.
Corsa OPC: For pedestrians safety,
the exterior mirrors of the Corsa OPC
are released from the holder if they
are bumped. Fit mirror housing to
holder with latching lugs and engage
by striking gently.
Manual
The exterior mirrors can be folded in
by pressing gently on the outer edge
of the housing.
28 Keys, doors and windows
Heated
Operated by pressing the Ü button.
Heating works with the engine
running. It is switched off
automatically after a short time.
Interior mirrors
Manual anti-dazzle
To reduce dazzle, adjust the lever on
the underside of the mirror housing.
Automatic anti-dazzle
Dazzle from following vehicles at
night is automatically reduced.
Keys, doors and windows 29
Windows
Manual windows
The door windows can be opened or
closed with the window winders.
Power windows
9 Warning
Take care when operating the
power windows. Risk of injury,
particularly to children.
Keep a close watch on the
windows when closing them.
Ensure that nothing becomes
trapped in them as they move.
Power windows can be operated:
■ with ignition on,
■ within 5 minutes of switching
ignition off,
■ within 5 minutes of switching
ignition key to position 1.
After switching off the ignition, the
window operation is disabled, when
the driver's door is opened, then
closed and locked.
Operate the control to open or close
the window.
For vehicles with automatic feature
pull or press the switch again to stop
window movement.
Safety function
If the window glass encounters
resistance above the middle of the
window during automatic closing, it is
immediately stopped and opened
again.
In the event of closing difficulties due
to frost or the like, operate the switch
several times to close the window in
stages.
30 Keys, doors and windows
Operating windows from outside
Depending on the equipment level,
the windows can be operated
remotely from outside the vehicle.
Press q or p until all windows have
opened or closed.
Overload
If the windows are repeatedly
operated at short intervals, the
window operation is disabled for
some time.
Fault
If the windows cannot be opened or
closed automatically, activate the
window electronics as follows:
1. Close doors.
2. Switch on ignition.
3. Close the window completely and
operate the button for a further
5 seconds.
4. Open the window completely and
operate the button for a further
1 second.
5. Repeat for each window.
Heated rear window
Operated by pressing the Ü button.
Heating functions with the engine
running and is switched off
automatically after a short time.
Depending on the engine type, the
heated rear window comes on
automatically when the diesel particle
filter is being cleaned.
Sun visors
The sun visors can be folded down or
swivelled to the side to prevent
dazzling.
If the sun visors have integral mirrors,
the mirror covers should be closed
when driving.
Loading...