MINOURA LiveRide FG220 Instruction Manual

Indoor Bike Trainer

[Applicable Wheel Size]

650c – 700c
26 – 29 inch

[Applicable Wheebase Size]

930 – 1,200mm

(ver.1.1 2016/12)

(Shown with 700c road bike)

Caution

Contact

• This trainer is designed for use only on stable or indoor surfaces. The trainer is not
designed to be used in muddy or off road conditions. Getting dirt in the resistance unit
may cause damage. Using muddy or dirty tires will cause premature wear on the rollers.

• Using 24" or smaller wheels may put undue stress on the unit and will alter the angle of
the bicycle signicantly.

• When setting up the FG220 pedal slowly at rst to make sure the rear wheel stays on
the roller and is positioned properly.

If you need help, please contact the shop first where you originally purchased this product or call the distributors
in your country. The distributors list can be found on our web site.

MINOURA North American Tech Center MINOURA Japan Headquraters

(for U.S. residents ONLY)

Hayward, California, U.S.A. 1197-1 Godo, Anpachi, Gifu 503-2305 Japan
Phone: [phone] (8 am - 5 pm, Mon - Fri, PST) Phone: [phone]
Fax: [phone] Fax: [phone]
Email: [e-mail] Email: [e-mail]
Web: www.minoura.jp

(for ALL customers)

MADE IN JAPAN

Important Notes

• For use with a standard 2-wheel bike with the wheel size between 650c and 700c or 26 and 29 inch
and the wheelbase size between 930 and 1,200mm.
Any longer wheelbase bike such as a tandem or long-tail or other types of bike such as recumbent
or folding bike won't t FG220.

• The front hub is 100mm width and equipped with 9mm standard or 15mm Thru Axle type. Any other
hub size cannot be used. Boost Hub and 12mm Thru Axle can be used by replacing the front fork
mount with the optional one.

• Do NOT grasp the brake lever after removing the front wheel on the bike equipped with a hydraulic
disc brake.

• The rear triangle of your bike rides freely on the roller. Be careful not to fall down while getting on or
off the bike. Use the handlebar to steady yourself but do not pull on the bars as this may cause the
bike to tip.

The best way to mount the trainer is to stand close to the side of the saddle. Center yourself low

and to the center of the bike, clip into one pedal then slowly swing your other leg over the bike and
clip into the second pedal.

Please Read Carefully Before Use

• Minoura recommends the use of a completely slick (no tread) tire to reduce noise and increase the

longevity of the tire and rollers.

• The FG220 comes equipped with a standard quick release skewer (Q/R) for the front fork mount.

Tighten the Q/R as you would your wheel to your bike, close it rmly and tightly.

If you are unsure, consult your local bike shop for help.

• Your rear tire must contact both rollers evenly. Adjust the center arm/frame exactly.

Incorrect adjustment will result in unbalanced resistance and poor bike stability.

• For your safety, place the FG220 on a at, even oor or surface. Make sure all legs are fully opened.

Make sure to check the trainer stability, especially when raising the front fork mount.

• DO NOT USE YOUR BRAKE TO REDUCE SPEED!

Doing so will decrease stability, cause your tire to burst or throw you off the bike. Simply reduce your

cadence and let the bike come to a natural stop.

• Keep children and pets away from the spinning wheel or moving parts.

• Minoura recommends use a mat underneath the trainer to protect the oor from sweat or stain from

the rubber feet.

• If you hear a strange noise or smell something unusual, immediately stop using the the trainer and

contact your Minoura dealer. Do not try to disassemble the product without consulting your dealer
or Minoura rst.

• Any warranty will be void if you use FG220 for other purpose than instructed.

Minoura offers 1-year limited warranty on this product from the date of your purchase for any
problem caused by manufacturer's defect. Natural wear will not be covered.
Any damage or problem caused by transporting process is not covered under warranty. Any damage
from shipping or moving must be made to the shipping company.
Read the enclosed "Minoura Limited Warranty Policy" card for more detail.
For the latest information, refer Minoura web site (http://www.minoura.jp).

- 2 -