Page 1
Masterbuilt Manufacturing, Inc.
1 Masterbuilt Ct.
Columbus, GA 31907
Customer Service 1-800-489-1581
www.masterbuilt.com
ASSEMBLY, CARE & USE MANUAL
WARNING & SAFETY INFORMATION
PROPANE SMOKER MODEL 20051311
THIS PRODUCT IS FOR OUTDOOR USE ONLY
Manual Code: 9805100014 032212-18JH
Tools needed for assembly: Adjustable Wrench, Phillips Head Screwdriver
CARBON MONOXIDE HAZARD WARNING
Burning wood chips gives off carbon
monoxide, which has no odor and can cause death.
DO NOT burn wood chips inside homes,
vehicles, tents, garages or any enclosed areas.
Use only outdoors where it is
well ventilated.
This manual contains important
information necessary for the proper assembly
and safe use of the appliance.
Read and follow all warnings and
instructions before assembling and using
the appliance.
Follow all warnings and instructions when
using the appliance.
Keep this manual for future reference.
Failure to follow these warnings and instructions properly could result in fi re or explosion, which
could cause property damage, personal injury, or death.
Page 2
DANGER DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open fl ame.
3. Open/remove door.
4. If odor continues, keep away from the
appliance and immediately call your
Fire Department.
1. Never operate this appliance unattended.
2. Never operate this appliance within 10 feet
(3m) of any structure, combustible material
or other gas cylinder.
3. Never operate this appliance within 25 feet
(7.5m) of fl ammable liquids.
4. If fi re should occur keep away from appliance
and immediately call your fi re department.
Do not attempt to extinguish an oil/grease
fi re with water.
LIMITED WARRANTY
Masterbuilt warrants its products to be free from defects in material and workmanship under proper
assembly, normal use and recommended care for 90 days from the date of original retail purchase.
Masterbuilt warranty does not cover paint fi nish as it may burn off during normal use.
Masterbuilt warranty does not cover rust of the unit.
Masterbuilt requires reasonable proof of purchase for warranty claims and suggests that you keep your
receipt. Upon the expiration of such warranty, all such liability shall terminate.
Within the stated warranty period, Masterbuilt, at its discretion, shall repair or replace defective components
free of charge with owner being responsible for shipping. Should Masterbuilt require return of component(s)
in question for inspection Masterbuilt will be responsible for shipping charges to return requested item.
This warranty excludes property damage sustained due to misuse, abuse, accident, damage arising out of
transportation, or damage incurred by commercial use of this product.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN FIRE, EXPLOSION OR BURN
HAZARD, WHICH COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
GENERAL WARNINGS AND SAFETY INFORMATION
• Unit is for outdoor use only.
• Never use inside enclosed areas such as patios, garages, buildings or tents.
• Never use inside recreational vehicles or on boats.
• Never operate unit under overhead construction such as roof coverings, carports, awnings, or
overhangs.
• Never use unit as a heater.
• Maintain a minimum distance of 10ft (3m) from overhead construction, walls, rails or other
structures.
• Keep a minimum 10ft (3m) clearance of all combustible materials such as wood, dry plants,
grass, brush, paper, or canvas.
• Keep appliance clear and free from combustible materials such as gasoline and other fl ammable
vapors and liquids.
• Use unit on a level, non-combustible, stable surface such as dirt, concrete, brick or rock.
• Keep children and pets away from unit at all times. Do NOT allow children to use unit.
• Unit has an open fl ame. Keep hands, hair, and face away from burner fl ame. Do NOT lean over
burner when lighting. Loose hair and clothing may catch fi re.
• Allow unit to cool below 115°F (46°C) before moving or storing.
• Avoid bumping or impacting unit.
• This unit is HOT while in use and during cooling process. Wear protective gloves/mitts.
• Use of alcohol, prescription or non-prescription drugs may impair user’s ability to properly
assemble or safely operate unit.
• Never use glass, plastic or ceramic cookware in unit.
• Do NOT allow anyone to conduct activities around unit during or following its use until it has
cooled.
• Accessory attachments not supplied by Masterbuilt Manufacturing, Inc. are not recommended.
• Never use unit for anything other than its intended use. This unit is NOT for commercial use.
• Use in accordance with local, state and federal fi re codes.
This expressed warranty is the sole warranty given by Masterbuilt and is in lieu of all other warranties,
expressed or implied including implied warranty, merchantability, or fi tness for a particular purpose.
Neither Masterbuilt nor the retail establishment selling this product, has authority to make any warranties or
to promise remedies in addition to or inconsistent with those stated above.
Masterbuilt’s maximum liability, in any event, shall not exceed the purchase price of the product paid by
the original consumer/ purchaser. Some states do not allow the exclusion or limitation of incidental or
consequential damages. In such a case, the above limitations or exclusions may not be applicable.
California residents only: Not withstanding this limitation of warranty, the following specifi c restrictions
apply; if service, repair, or replacement of the product is not commercially practical, the retailer selling the
product or Masterbuilt will refund the purchase price paid for the product, less the amount directly
attributable to use by the original buyer prior to the discovery of the nonconformity. Owner may take the
product to the retail establishment selling this product in order to obtain performance under warranty.
This expressed warranty gives you specifi c legal rights, and you may also have other rights which vary from
state to state.
Go Online www.masterbuilt.com
or complete and return to
Attn: Warranty Registration
Masterbuilt Mfg. Inc.
1 Masterbuilt Court - Columbus, GA 31907
Name: __________________________________ Address :___________________________ City:________________
State/Province: ________ Postal Code: ________________Phone Number: (_____) - ____________
E-mail Address:_______________________________________
*Model Number: ____________________ *Serial Number: ____________________
Purchase Date: _____- ______-_______ Place of Purchase: ____________________________________
*Model Number and Serial Number are located on silver label on back of unit.
1
18
Page 3
PORK OR BABY BACK RIBS
RECIPES
GENERAL WARNINGS AND SAFETY INFORMATION
MAPLE GLAZED HAM
2-4 lbs Pork or Baby Back Ribs
½ tbsp Salt
¼ cup Brown sugar
2 ½ tbsp Chili powder
1 ½ tbsp Ground cumin
2 tsp Cayenne pepper
2 tsp Black pepper (freshly ground)
2 tsp Garlic Powder
2 tsp Onion Powder
Hickory Chips
Mix ingredients and rub mixture on meat for 2 hours before
cooking. Allow meat to reach room temperature.
Cook ribs for 3 hours at 225°F (107°C) in preheated smoker
using hickory chips during the fi rst 2 hours.
After 3 hours remove the ribs and wrap in heavy foil.
Cook for an additional 1- 1 ½ hours.
5-7 lbs Ham Shank or Butt (Fully cooked, bone in)
1 ½ cup Maple syrup
1 tsp Ginger
¼ tsp Nutmeg
½ tsp Allspice
16 whole Cloves
1 can Pineapple slices (canned)
1 jar Maraschino Cherries
Hickory or Mesquite Chips
Remove thick skin and trim fat leaving no more than ½” thick
covering on ham. Score ham. Combine syrup, ginger, nutmeg,
and allspice in a small bowl. Place ham in large dish and baste
with syrup mixture. Let ham stand in syrup mixture for 1 or 2
hours basting frequently until at room temperature.
When ready to smoke remove ham from dish and stud with
cloves. Place ham in preheated 225°F (107°C) smoker. Cook for
about 2-3 hours. Baste with syrup mixture at least 2 times during
cooking time. Before last hour of smoking decorate ham with
canned pineapple and cherries and baste. Internal temperature
of ham should be at 130°F-140°F (54°C-60°C) when heated.
• Use 20LB (9kgs) gas cylinder that has protective collar (cylinder not included with unit).
• Installation of unit must conform with local codes or in the absence of local codes, with National
Fuel Gas Code, ANSIZ223.1/NFPA 54, Storage and Handling of Liquefi ed Petroleum Gasses,
ANSI/NFPA 58 or CSA B149.1, Natural Gas Installation Code; Propane Storage and Handling, CSA
B149.2; or the Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192; and Recreational
Vehicle Code, CSA Z240 RV Series as applicable.
• LP gas cylinder being used must be constructed and marked in accordance with specifi cations
for LP gas cylinders of the US Department of Transportation (DOT) or the Standard for Cylinders,
Spheres and Tubes for the Transportation for Dangerous Goods, CAN/CSA-B339.
• Always perform soapy water test (see “Soapy Water Test Instructions” in this manual)
EVERY TIME you use unit.
• Before each use check all nuts, screws and bolts to make sure they are tight and secure.
• Before each use inspect gas hose for signs of damage.
• Always disconnect gas cylinder from unit when not in use.
• Never attach/disconnect gas cylinder, move or alter gas fi ttings when unit is in operation.
• Never use gas cylinder if there is evidence of dents, gouges, bulges, fi re damage, erosion,
leakage, excessive rust, or other forms of visible external damage. This may be hazardous and
cylinder should be taken to a liquid propane supplier to be checked.
• Regulator and hose assembly supplied with unit MUST be used. For replacement parts, if
needed, contact Masterbuilt Customer Service at 1-800-489-1581.
• When lighting burner remove all smoker parts to prevent explosion from gas build up.
FOR MORE TANTALIZING RECIPES
AND COOKING TIPS VISIT US ONLINE AT
WWW.MASTERBUILT.COM
• If ignition does not take place within fi ve seconds using ignitor button, turn gas control valve to
off position and wait fi ve minutes and repeat lighting procedures.
• Keep fuel supply hose away from unit while in operation.
• Keep fuel supply hose away from any heated surface.
• Do NOT obstruct fl ow of combustion and ventilation. Keep ventilation openings of cylinder
enclosure free and clear of debris.
• When use is complete, always turn regulator control valve OFF fi rst, then gas cylinder valve OFF.
• Gas MUST be turned off at the supply cylinder when not in use.
• Do NOT store spare LP gas cylinder under or near unit. Gas cylinder safety relief valve may
overheat allowing gas to release causing fi re which may cause death or serious injury.
• Never fi ll cylinder over 80% full or cylinder may release gas causing fi re which may cause death
or serious injury.
• If you smell, hear or see gas escaping, immediately get away from gas cylinder and call the Fire
Department. Fire may cause death or serious injury.
• Place a dust cap on cylinder valve outlet whenever cylinder is not in use. Only install dust cap
provided with cylinder. Other caps or plugs may cause leaks.
• Cylinder MUST be stored outdoors, out of children’s reach and must NOT be stored in a building,
garage, or any other enclosed area.
17
• This appliance is not for frying turkeys.
2
Page 4
SOAPY WATER TEST WARNINGS & PROCEDURES
SMOKING CHART
WARNINGS
• Soapy Water Test MUST be performed each time gas cylinder is connected to burner/hose or each time it
is used.
• Soapy Water Test MUST be performed outdoors in well ventilated area.
• When performing Soapy Water Test keep smoker away from open fl ames, sparks or lit cigarettes.
• Smoker is designed to work with propane gas only. Only use gas cylinders marked propane with this unit.
This product will NOT operate with natural gas.
• Never use an open fl ame to test for gas leaks.
PREPARATION:
• Remove any cookware from smoker.
• Make sure regulator and gas cylinder valve to OFF position.
• Prepare soapy water solution: (1) part dish washing liquid (or more if desired), (3) parts water.
• Apply soapy water solution to gas cylinder valve, regulator and hose length up to burner.
Apply solution to
gas cylinder valve
Apply solution to hose regulator
and the full length of the hose
Apply solution underneath control
panel where burner and hose are
connected
Failed test will present bubbles as
shown below.
ITEM SIZE TEMP CHARCOAL WATER
BEEF
Pot Roast
(arm, top,
chuck, blade)
Brisket
4 - 5 lbs
(1.8-2.3kgs)
3 - 4 lbs
(1.4-1.8kgs)
200°F
(93°C)
200°F
(93°C)
7 - 8 lbs
(3.2-3.6kgs)
7 - 8 lbs
(3.2-3.6kgs)
PORK
Loin Roast
(bone in)
Loin Roast
(boneless)
Spare Ribs
3 - 4 lbs
(1.4-1.8kgs)
5 - 7 lbs
(2.3-3.2kgs)
3 - 5 lbs
(1.4-2.3kgs)
4 - 6 lbs
(1.8-2.7kgs)
7 - 10 lbs
(3.2-4.6kgs)
200°F
(93°C)
200°F
(93°C)
200°F
(93°C)
200°F
(93°C)
200°F
(93°C)
8 lbs
(3.6kgs)
8 lbs
(3.6kgs)
10 lbs
(4.6kgs)
8 - 10 lbs
(3.6-4.6kgs)
10 lbs
(4.6kgs)
POULTRY
Chicken
(2 whole)
Turkey
2 - 3 lbs ea
(0.9-1.4kgs)
8 - 10 lbs
(3.6-4.6kgs)
11 - 13 lbs
(5.0-5.9kgs)
200°F
(93°C)
200°F
(93°C)
200°F
(93°C)
5 - 7 lbs
(2.3-3.2kgs)
8 lbs
(3.6kgs)
8 - 10 lbs
(3.6-4.6kgs)
3 - 4 qts
(2.8-3.8l)
4 qts
(3.8l)
4 qts
(3.8l)
6 qts
(5.7l)
4 - 5 qts
(3.8-4.7l)
4 qts
(3.8l)
5 - 6 qts
(4.7-5.7l)
3 - 4 qts
(2.8-3.8l)
5 qts
(4.7l)
6 qts
(5.7l)
WOOD
CHIPS
2 - 3 cups
(0.56-0.83l)
3 cups
(0.83l)
2 cups
(0.56l)
3 cups
(0.83l)
3 cups
(0.83l)
3 cups
(0.83l)
3 cups
(0.83l)
2 cups
(0.56l)
3 cups
(0.83l)
3 cups
(0.83l)
COOK TIME INTERNAL TEMP
140°F (60°C) Rare
3 - 4 hrs
3 - 4.5 hrs
3.5 - 4.5 hrs
5 - 7 hrs
3.5 - 5.5 hrs 170°F (77°C)
2.5 - 3.5 hrs
3.5 - 5 hrs
2.5 - 3.5 hrs
4 - 6 hrs
6 - 7.5 hrs
160°F (71°C) Med
170°F (77°C) Well
170°F (77°C)
Well Done
170°F (77°C)
Well Done
Well Done
Well done when
meat pulls away
from bone
180°F (82°C)
(Leg moves
easily in joint)
185°F (85°C)
(Leg moves easily
in joint)
(Smoker shown on back for clarity only)
TESTING GAS VALVE:
• Turn gas cylinder valve ON and watch for bubbles. DO NOT LEAVE GAS ON MORE THAN
12 SECONDS. If bubbles appear, stop, turn gas cylinder OFF and retighten fi tting. Repeat test.
TESTING REGULATOR AND HOSE:
• AFTER gas cylinder valve has passed Soapy Water Test, turn gas cylinder valve ON, open regulator
control valve one full turn and check for bubbles at valve location, along full length of hose and at burner
connection. DO NOT LEAVE GAS ON MORE THAN 12 SECONDS. If bubbles appear, stop, turn
regulator valve OFF, turn gas cylinder OFF and retighten the connection that is leaking gas. If hose is
source of leak, STOP, do not use unit. Hose must be replaced.
• When test is complete, and there are no leaks, wait minimum of 5 minutes for gas fumes to diminish
before lighting cooker.
DURING ANY PORTION OF SOAPY WATER TEST IF BUBBLES CONTINUE TO
APPEAR, STOP, DO NOT USE UNIT. CONTACT LOCAL PROPANE DEALER OR
MASTERBUILT CUSTOMER SERVICE @ 1-800-489-1581.
Note: Use 20LB (9kgs) gas cylinder that has a protective collar with this unit.
Cylinder NOT included with this unit.
SEAFOOD
Salmon
Fish Fillets Full Grate
Shrimp,
Clams,
Crab Legs
6 - 7 lbs
(2.7-3.2kgs)
Full Grate
200°F
(93°C)
200°F
(93°C)
200°F
(93°C)
10 lbs
(4.6kgs)
5 lbs
(2.3kgs)
5 lbs
(2.3kgs)
5 - 6 qts
(4.7-5.7l)
3 qts
(2.8l)
3 qts
(2.8l)
3 cups
(0.83l)
1 - 2 cups
(0.28-0.56l)
1 - 2 cups
(0.28-0.56l)
4 - 6.5 hrs Flesh white,fl akes
when forked
1.5 - 2.5 hrs Flesh white,fl akes
when forked
1 - 2 hrs
Shrimp pink
Shells open
WILD GAME
Quail,
Dove, etc.
Pheasant,
Duck, etc.
12 - 16 birds
5 - 7 lbs
(2.3-3.2kgs)
200°F
(93°C)
200°F
(93°C)
7 - 10 lbs
(3.2-4.6kgs)
8 - 10 lbs
(3.6-4.6kgs)
4 qts
(3.8l)
4 - 5 qts
(3.8-4.7l)
2 - 3 cups
(0.56-0.83l)
2 - 3 cups
(0.56-0.83l)
2 - 4 hrs
4 - 5 hrs
Leg moves easily in
180-185°F
(82-85°C)
Well Done
• When outside temperature is cooler than 65°F (18°C) and/or altitude is above 3,500 feet (1067m),
additional cooking time may be required. To ensure that meat is completely cooked use a meat
thermometer to test internal temperature.
• Opening smoker door during cooking process may extend cooking time due to heat loss.
joint
3
16
Page 5
WOOD SMOKING GUIDE FOR MEATS
WARNING
WOOD FLAVOR POULTRY FISH HAM BEEF PORK LAMB
Hickory
Pungent, smoky, bacon-like fl avor
Mesquite
Sweet and delicate fl avor
Alder
Delicate, wood smoke fl avor
Pecan
Bold and hearty fl avor
Maple
Sweet, subtle fl avor
Apple
Sweet, delicate fl avor
Cherry
Sweet, delicate fl avor
PERFORM “SOAPY WATER TEST” BEFORE EACH USE. SEE “SOAPY WATER TEST” SECTION IN
MANUAL. EXTINGUISH ALL OPEN FLAMES BEFORE CONNECTING REGULATOR TO GAS
CYLINDER. TURN GAS OFF AFTER EACH USE.
REGULATOR, BURNER AND GAS VALVE CONNECTION & OPERATION
CLOCKWISE
12.25” (45cm)
APPROX.
YELLOW
BLUE
COUNTER
CLOCKWISE
17.75”
(45cm)
APPROX.
• Inspect hose before each use. If there are signs of wear, cuts, or leaks, replace
unit. DO NOT USE.
• Inspect burner before each use. Check burner and burner venturi tube for
insects and insect nests. A clogged tube can lead to a fi re beneath appliance.
• Connect hose regulator to LP Gas Cylinder
1. Make sure gas cylinder valve is closed. Turn knob clockwise until it stops.
2. Make sure control knob on smoker is in the “OFF” position.
3. Remove protective cap from gas cylinder and coupling nut if applicable.
4. Center and insert regulator nipple into valve outlet on gas cylinder as
shown in fi gure on the left. Turn regulator coupling nut clockwise until it
stops. DO NOT OVER TIGHTEN.
• Perform Soapy Water Test.
• To use turn gas cylinder ON, turn burner control knob clockwise and push ignitor
button to light.
• If ignition does not take place within fi ve seconds, turn gas control valve to off posi-
tion and wait fi ve minutes and repeat lighting procedures. If ignition still does not
occur, see match light directions below.
• After use turn burner control knob OFF, then turn gas cylinder OFF.
• Burner control knob adjusts burner fl ame. Turn control knob clockwise SLOWLY to
increase fl ame. Turn control knob counter-clockwise to decrease fl ame and shut
fl ame off.
• Visually check burner fl ame. A CORRECT FLAME should be blue with a small
amount of yellow at the tip. An INCORRECT FLAME is excessively yellow and
irregular. If an incorrect fl ame occurs, turn burner control knob to “OFF position,
turn off regulator and propane tank. Allow unit to cool and then clean burner.
Let burner completely dry before re-lighting.
WARNING
COMBUSTION BY-PRODUCT PRODUCED WHEN USING THIS PRODUCT CONTAINS CHEMICALS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS, OTHER REPRODUCTIVE
HARM, OR CANCER.
CALIFORNIA PROP 65
WARNING: THIS PRODUCT CONTAINS CHEMICALS, INCLUDING LEAD, KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. WASH HANDS
AFTER HANDLING.
15
MATCH LIGHT INSTRUCTIONS
1. Read all instructions and warnings before lighting.
2. Check gas control valve and gas cylinder valve to be certain it is in
OFF position before connecting to gas cylinder. Perform soapy
water test before each use.
3. Open door during lighting.
4. Turn gas control valve on, turn gas cylinder valve on.
5. Place a long, lit fi replace match stick close enough to burner to
ignite.
6. After each use, fi rst turn gas control valve off, then gas cylinder
valve off. Always allow unit to cool completely before touching,
moving or storing.
4
Page 6
STOP!
DO NOT RETURN TO RETAILER For Assembly Assistance, Missing or Damaged Parts
Call: MASTERBUILT Customer Service at 1-800-489-1581.
Please have Model Number and Serial Number available when calling.
These numbers are located on silver label on back of unit.
PARTS LIST
2
13
19
7
1
21
12
11
10
9
24
SMOKER OPERATION
1. Pre-soak wood chips in water for at least 30 minutes.
2. Before starting unit, place 1-2 cups (0.24l-0.56l) of wood chips in fl ame disk bowl. Never use more than
2 cups (0.56l) of wood chips at a time. Never use wood chunks.
3. Follow lighting instructions (see pg. 4) to light smoker.
4. With protective gloves on, place water bowl in position. Pour about 1 inch of water, juice, or vinegar into
water bowl. This will add fl avor and moisture to food and prevent it from drying out.
5. Place cooking grates in smoker. Position food in center.
• Wood chips must be used in order to produce smoke and create the smoke fl avor.
• Food needs to be in the center of cooking racks. This allows food drippings to go into the water
bowl.
• This is a smoker. There will be a lot of smoke produced when using wood chips. Smoke will escape
through seams and turn the inside of smoker black. This is normal.
• Do not open smoker door unless necessary. Opening smoker door causes heat to escape and may
3
17
23
6
20
16
8
27
5
22
4
26
25
PART NO QUANTITY DESCRIPTION PART NO QUANTITY DESCRIPTION
1 1 Smoker Body 15 1 Ignitor (pre-assembled)
2 1 Large Smoker Door w/ Logo
Plate
3 1 Air Damper
(pre-assembled)
4 2 Rear Legs 18 1 Grease Clip
5 1 Control Panel 19 2 Door Latch (pre-assembled)
6 1 Burner Box 20 1 Heat Shield
7 2 Door Handle 21 10 Cooking Grate Support
8 2 Body Handle 22 1 Matchstick w/Chain
9 1 Flame Disk Bowl 23 1 Regulator/Hose
10 1 Water Bowl 24 1 Grease Cup
11 1 Water Bowl Holder 25 1 Right Front Leg
12 4 Cooking Grate 26 1 Left Front Leg
13 1 Temperature Gauge w/ Beauty
Ring
14 1 Valve (pre-assembled)
16 1 Control Knob
(pre-assembled)
17 1 Burner (pre-assembled)
(pre-assembled)
27 1 Small Smoker Door
5
14
18
15
cause wood to fl are up. Closing the door will re-stabilize the temperature and stop fl are up.
• When door is opened, sometimes a fl are up may occur. Should wood chips fl are up immediately
close door, wait for wood chips to burn down then open door again.
• Do not leave old wood in the fl ame disk bowl. Flame disk bowl should be cleaned out prior to each
use to prevent ash buildup.
SAFE STORAGE & MAINTENANCE
• Inspect all hardware in assembled parts for tightness on a regular basis to ensure unit is in safe working
condition.
• ALWAYS allow unit to cool completely before handling.
• Clean unit, including special surfaces such as cooking grates with mild cleaning agents. Wipe outside of
unit with damp rag. DO NOT use oven cleaner.
• ALWAYS cover and store cold unit in a protected area.
• Unit is made of steel and may rust over time. If rusting occurs on outside surfaces, clean area with sand
paper or steel wool, then cover with heat resistant paint.
• NEVER USE PAINT ON INSIDE SURFACES OF UNIT.
14
Page 7
23
ASSEMBLY
STEP 13
When not in use, hang
regulator/hose (23) on body handle
(8) as shown.
(A)
M6x12
Phillips Screw
Qty-24
HARDWARE LIST
(B)
#10x3/8
Self-tapping Screw
Qty-4
(C)
M6x20
Phillips Screw
Qty-4
(D)
Wing Nut
(packed with temperature gauge)
Qty-1
8
PRESEASON INSTRUCTIONS
Curing your smoker will rid the unit of chemicals and oils left over by the manufacturing process
allowing them to burn off. Preseason smoker prior to fi rst use.
1. Perform soapy water test (see pg. 3).
2. Using a napkin or cloth, rub a light coat of cooking oil on cooking grates and inside smoker doors.
Make sure water pan is in place with NO WATER.
3. Fill flame disk bowl with 2 cups (0.56l) of wood chips and light smoker. Close door.
4. Let the smoker burn for about 30 minutes. Make sure temperature gets up to 400°F (204°C).
5. Allow unit to cool completely.
6. Reapply light coat of cooking oil on the grilling surface and inside of smoker door.
7. Relight smoker and burn the oil for 20 minutes.
• Cure your smoker periodically to prevent excessive rust.
REPLACEMENT PARTS LIST
PART NO REPLACEMENT PART ITEM NO
1 Body Kit 9905100022
2 Large Door with Logo
Plate
3 Air Damper Kit 9904090069
4 Rear Leg Kit 9905100002
5 Control Panel Kit 9905100004
6 Burner Box Kit 9905100005
7 Door Handle Kit 9905100025
8 Body Handle Kit 9905100003
9 Flame Disk Bowl 911060006
10 Water Bowl 9005100009
11 Water Bowl Holder 9005100007
12 Cooking Grate 911060003
13 Temperature Gauge Kit 9907090034
14 Valve Kit 990060291
15 Ignitor Assembly Kit 990060328
16 Control Knob 911060014
17 Burner 9005100011
18 Grease Clip 9005100025
19 Door Latch Kit 990050222
21 Cooking Grate Support 9005100006
22 Match Stick with Chain 908060003
23 Regulator/Hose 911060001
24 Grease Cup 9005100039
25 Right Front Leg Kit 9905100021
26 Left Front Leg Kit 9905100020
27 Small Smoker Door 9005100048
Hardware Kit 9903100022
Instruction Manual 9805100014
9005100047
13
SMOKER IS READY FOR USE
STOP!
DO NOT RETURN TO RETAILER For Assembly Assistance, Missing or Damaged Parts
Call: MASTERBUILT Customer Service at 1-800-489-1581.
Please have Model Number and Serial Number available when calling.
These numbers are located on silver label on back of unit.
6
Page 8
ASSEMBLY
ASSEMBLY
• BEFORE ASSEMBLY READ ALL INSTRUCTIONS CAREFULLY.
• ASSEMBLE UNIT ON A CLEAN, FLAT SURFACE.
• TOOLS NEEDED: ADJUSTABLE WRENCH, PHILLIPS HEAD SCREWDRIVER
Carefully position grill as shown.
A
4
Do not tighten screws all the
way. Leg frames may need to be
adjusted during assembly.
STEP 1
Attach rear legs (4), right front leg
(25) and left front leg (26) to
26
1
25
bottom of smoker body (1) using
phillips screws (A).
Do not fully tighten screws yet.
24
18
STEP 11
Insert small hook end of grease
clip (18) all of the way up through
large hole in bottom of smoker
body (1), turn grease clip clock-
1
wise/counter-clockwise so that it is
supported on small tab.
Position grease cup (24) on grease
clip so it rests snugly.
Grease cup is needed to collect
grease run-off.
Note: Clip may require adjustment
to fi t diameter of container.
26
STEP 2
Attach control panel (5) to right
front leg (25) as shown using
STEP 12
Hang matchstick (22) on side of
smoker body (1) as shown.
phillips screws (A).
Repeat on opposite side attaching
contol panel (5) to left front leg (26).
A
22
1
7
25
5
12
Page 9
ASSEMBLY
21
STEP 9
Slide cooking grates (12), onto
cooking grate supports (21).
ASSEMBLY
STEP 3
Position burner box (6) over center
hole in bottom of smoker body,
A
carefully aligning venturi over valve
orifi ce as shown. Attach burner box
to smoker body using phillips
screws (A).
21
12
STEP 10
Insert water bowl (10) into water
bowl holder (11) and slide water
bowl holder onto cooking grate
support (21).
Place fl ame disk bowl (9) into
smoker as shown.
6
Firmly attach ignition wire to piezo
ignitor on control panel as shown
in Figure B.
Venturi
Valve Orifi ce
Ignition Wire
Piezo Ignitor
Figure B
STEP 4
Attach heat shield (20) to burner
box (6) using self tapping screws
(B) as shown.
Tighten all hardware at this time.
B
20
11
10
11
9
B
8
Page 10
ASSEMBLY
ASSEMBLY
STEP 5
Mount body handle (8) to smoker
1
body (1) using phillips screws (A).
STEP 7
Insert door handle (7) into large
smoker door (2). Secure using
phillips screws (C).
Repeat step for small smoker
door (27).
8
A
C
2
7
27
C
7
STEP 6
Insert temperature gauge w/
beauty ring(13) into smoker door (2).
1
STEP 8
Insert cooking grate supports (21)
into smoker body (1).
Secure in place with wing nut (D).
2
D
13
21
9
10
Loading...