Page 1
DIGITAL VIDEO CAMERA
Camcorder
For General
Power supply : DC 6.3 V (Using AC Power Adapter/Charger)
DC 7.2 V
(Using battery pack)
Power consumption
LCD monitor off, viewfinder on : Approx. 4.3 W
LCD monitor on, viewfinder off : Approx. 5.3 W
Video light : Approx. 3.5 W
Dimensions (W x H x D) : 80 mm x 96 mm x 159 mm
(with the LCD monitor closed and the viewfinder pushed down)
Weight : Approx. 570 g (1.3 lbs)
Operating temperature :0°C to 40°C
Operating humidity : 35% to 80%
Storage temperature : –20°C to 50°C
Pickup : 1/4" CCD
Lens : F 1.8, f = 3.6 mm to 36 mm, 10:1 power zoom lens
Filter diameter : ø37 mm
LCD monitor : 2.5" diagonally measured, LCD panel/TFT active matrix system
Viewfinder : Electronic viewfinder with 0.24" black/white LCD
Speaker : Monaural
For Digital Video Camera
Format : DV format (SD mode)
Signal format : NTSC standard
Recording/Playback format : Video: Digital component recording
: Audio: PCM digital recording, 32 kHz 4-channel (12-bit),
48 kHz 2-channel (16-bit)
For Connectors
S :Y:1 V (p-p), 75 Ω, analog output
C : 0.29 V
(
p-p), 75 Ω, analog output
AV
Video output :1 V
(
p-p), 75 Ω, analog
Audio output : 300 mV (rms), 1 kΩ, analog, stereo
DV
Input/output : 4-pin, IEEE 1394 compliant
PC (DIGITAL PHOTO)
Digital still output : ø2.5 mm, 3-pole
JLIP/EDIT : ø3.5 mm, 4-pole
AC Power Adapter/Charger AA-V40KR
Power requirement : AC 110 V to 220 V`, 60 Hz
Power consumption :23 W
Output
Charge : DC 7.2 V
, 1.2 A
VTR : DC 6.3 V
, 1.8 A
Dimensions (W x H x D) : 68 mm x 38 mm x 110 mm
Weight : Approx. 250 g
Specifications shown are for SP mode unless otherwise indicated. E & O.E. Design and specifications
subject to change without notice.
Cassette : Mini DV cassette
Tape speed : SP: 18.8 mm/s
LP: 12.5 mm/s
Maximum recording time : SP: 80 min.
(using 80 min. cassette) LP: 120 min.
GR-DVL300KR
Regarding service information other than these sections, refer to the GR-DVL300U service manual (No. 86551).
Also, be sure to note important safety precautions provided in the service manual.
VICTOR COMPANY OF JAPAN, LIMITED
VIDEO DIVISION
Printed in Japan
S40894
SPECIFICATIONS
(The specifications shown pertain specifically to the model GR-DVL300KR)
This service manual is printed on 100% recycled paper.
COPYRIGHT
© 2000 VICTOR COMPANY OF JAPAN, LTD.
No. 86562
July 2000
Page 2
TABLE OF CONTENTS
DIFFERENT TABLE ................................................................................................................................................................ 1 to 3
4. CHARTS AND DIAGRAMS
4.1 TG/VDR SCHEMATIC DIAGRAM..............................................................................................................................4-1
4.2 BOARD INTERCONNECTIONS ................................................................................................................................4-2
4.3 CAMERA DSP SCHEMATIC DIAGRAM.................................................................................................................... 4-4
4.4 MAIN CIRCUIT BOARD.............................................................................................................................................4-6
4.5 JACK, REAR AND JUNCTION CIRCUIT BOARDS ................................................................................................ 4-12
5. PARTS LIST
5.1 PACKING AND ACCESSORY ASSEMBL Y <M1> ..................................................................................................... 5-1
5.2 FINAL ASSEMBL Y <M2> ........................................................................................................................................... 5-3
6. AC POWER ADAPTER CHARGER (AA-V40KR)
6.1 CABINET ASSEMBLY <MA> .....................................................................................................................................6-1
6.2 SCHEMATIC DIAGRAM ............................................................................................................................................6-2
6.3 CIRCUIT BOARD.......................................................................................................................................................6-4
6.4 ELECTRICAL PARTS LIST........................................................................................................................................ 6-5
The following table indicate main different points between models GR-DVL300U and GR-DVL300KR.
ITEM
AC POWER ADAPTER CHARGER AA-V40U AA-V40KR
The following table indicate different parts number between models GR-DVL300U and GR-DVL300KR.
PACKING AND ACCESSORY ASSEMBLY <M1> Note: As for IB (INSTRUCTIONS), refer to sec.5.
REF NO.
1 PACKING CASE LY31631-005A LY31631-025A
9 Q.CARD (JCA) YU10350 –
10 WARRANTY INF. BT-51005-4 –
11 REGIST. CARD BT-51020-2 –
23 LENS CAP LY42182-001A –
! 29 AC POWER ADAPTER CHARGER LY20591-001B LY20591-010A
FINAL ASSEMBLY <M2>
REF NO.
! 101 LOWER CASE ASSY LY20560-001B LY20560-004B
104 CASS.COVER ASSY L Y31609-001A L Y31609-003C
104C BKT (E.KNOB) * LY42173-001B
108 REAR COVER ASSY LY31596-001A LY31596-003B
111 UPPER CASE (2.5) ASSY LY20557-001A LY20557-003E
111A SHEET (EARTH) * Not used
111C SPACER, X2 * LY40664-001A
139 SCREW * QYSPSPT1725R
143 SCREW * QYSPSGT1760R
148 CAP (HOOD) ASSY – LY2182-002A
150 HOLDER (MECHA) ASSY * LY31618-001C
150B SPECIAL SCREW, X4 * LY30018-0B4A
214 SHEET * LY42583-001A
ITEM
ITEM
MODEL
MODEL
MODEL
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
Note: Mark – is not used. Mark is same as left. Mark * reference model was also changed.
1
Page 3
ELECTRONIC VIEWFINDER ASSEMBLY <M4>
REF NO.
356 HINGE(VF)ASSY * LY31602-001C
MONITOR ASSEMBLY <M5>
REF NO.
! 501 MONITOR COVER ASSY * LY20569-001B
MAIN BOARD ASSEMBLY <01>
REF NO.
PW MAIN BOARD ASSY * YB10277E-05
IC5601 IC (DIGITAL) * TC7S32FU
IC5602 IC (DIGITAL) * TC7S04FU
R2101 to R2105
R2205
R3007
R3201
R3202 MG RESISTOR * Not used
R3215
R3234
R3309
R3330
R4207 MG RESISTOR * NRSA6AJ-243W
R4301 MG RESISTOR * Not used
R4354
R4355
R5509 to R5511 MG RESISTOR * NRSA6AJ-470W
R5602 MG RESISTOR * NRSA6AJ-0R0W
RA4305
RA4306
C2203
C2205
C3702 CAPACITOR * NCB30JK-105X
C5601
C5602
L2601 to L2603 MG RESISTOR * Not used
OT2 SPACER(A) * LY30029-055B
ITEM
ITEM
ITEM
MG RESISTOR * NRSA6AJ-272W
NETWORK RESISTOR * Not used
CAPACITOR * NCB11CK-105X
CAPACITOR * NCBA1AK-104W
MODEL
MODEL
MODEL
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
Note: Mark – is not used. Mark is same as left. Mark * reference model was also changed.
2
Page 4
MONITOR BOARD ASSEMBLY <02>
REF NO.
PW1 MONITOR BOARD ASSY * YB10280E1-02
IC7101 IC * XCVVQ110CFB
R7109 CMF RESISTOR * NRVA63D-393X
R7110 CMF RESISTOR * NRVA63D-183X
R7114 MG RESISTOR * NRSA63J-153X
R7119 MG RESISTOR * NRSA63J-333X
R7121 MG RESISTOR * Not used
VR7101 TRIM RESISTOR, GAIN * Not used
VR7103 TRIM RESISTOR, GAMMA * NVP0016-223X
C7118 T CAPACITOR * Not used
CCD BOARD ASSEMBLY <04>
REF NO.
OT1
OT2
L1 FERRITE CORE * Not used
ITEM
ITEM
SPACER-A * Not used
MODEL
MODEL
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
JUNCTION BOARD ASSEMBLY <05>
REF NO.
PW2 JUNCTION BOARD ASSY * YB10278A2-02
JACK BOARD ASSEMBLY <06>
REF NO.
PW1 JACK BOARD ASSY * YB10278A1-02
D504
D505
REAR BOARD ASSEMBLY <07>
REF NO.
PW3 REAR BOARD ASSY * YB10278C3-02
R551
R552
OT1 PIN * LY42702-001A
ITEM
ITEM
ZENER DIODE * Not used
ITEM
MG RESISTOR * NRSA63J-331X
MODEL
MODEL
MODEL
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
GR-DVL300U GR-DVL300KR
Note: Mark – is not used. Mark is same as left. Mark * reference model was also changed.
3
Page 5
SECTION 6
AC POWER ADAPTER CHARGER (AA-V40KR)
SAFETY PRECAUTION
Parts identified by the ! symbol are critical for safety. Replace only with specified part numbers.
6.1 CABINET ASSEMBLY <MA>
1
6
3
5
MAIN &
TERMINAL ASSY <91>
5
2
4
#!REF No. PART No. PART NAME, DESCRIPTION
----------------------- ------------------------------ ----------------------------------------------------------------------------
✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽
4
RATING LABEL
CABINET ASSEMBLY <MA>
! 1 PTY20591-013 UPPER CASE ASSY
! 2 PTY20483-023 LOWER CASE
! 3 PTY20539-081 POWER CORD
4 YQ10531-011 SCREW,x2
5 PTY20545-055 SCREW,x3
6 PTY20591-053 SWITCH COVER
6-1
Page 6
6.2 SCHEMATIC DIAGRAM
NOTE:
When ordering parts, be sure to order according to
the Part Number indicated in the Parts List.
5
MAIN & TERMINAL
4
AC110
CN1
2200P
2200P
1221304
3
PC123YS
2
PC123YS
1
6-2
ABCD
Page 7
0.22
C35
0.22
TP15
Safety precautions
The components identified by the symbol
! are
critical for safety . For continued safety, replace safety
critical components only with manufacturer’s recommended parts.
CN2
TP16
Q27
UN2211
R60
10K
SV
SG
TERMINAL
SW1
SV
SG
EFG
H
6-3
Page 8
6.3 CIRCUIT BOARD
6-4
Page 9
6.4 ELECTRICAL PARTS LIST
#!REF No. PART No. PART NAME, DESCRIPTION
----------------------- ------------------------------ ----------------------------------------------------------------------------
✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽✽
MAIN & TERMINAL BOARD ASSY <91>
! PW1 PTY20591-503 MAIN & TERMINAL BOARD ASSY
! HS1 PTY20483-071 HEAT SINK A
! HS2 PTY20591-072 HEAT SINK B
OT1 PTY10067-551 SCREW
IC21 M61030AFP CHARGE COTROL IC 24pin SOP
Q1 FS2KM18A MOS FET
Q2 2SD2227 TRANSISTER
Q3 2SD2227 TRANSISTER
Q21 UN2211TX DIG.TRANSISTER
Q22 2SA1037AK/QR/-X CHIP TRANSISTER
Q23 2SB1592 TRANSISTER
Q24 2SA1037AK/QR/-X TRANSISTER
Q25 2SA1037AK/QR/-X TRANSISTER
Q26 2SA1037AK/QR/-X TRANSISTER
Q27 UN2211TX DIG TRANSISTOR
D1 S1WBA60 B.DIODE 600V 1A
D5 1SS244T77 DIODE 200V 6A
D6 1SS244T77 DIODE 200V 6A
D21 MA7D56 DIODE 60V 10A
ZD1 MTZJ12C-T2 ZENER DIODE 12V
ZD2 MTZJ6.2B-T2 ZENER DIODE 6.2V 500mW
ZD21 MTZJ12C-T2 ZENER DIODE 12V
ZD22 MTZJ12C-T2 ZENER DIODE 12V
ZD23 MTZJ12C-T2 ZENER DIODE 12V
ZD24 MTZJ12C-T2 ZENER DIODE 12V
ZD25 MA4047NM ZENER DIODE 4.7V 500mW
LED1 YQ10531-540 LED RED POWER
LED2 YQ10531-542 LED GREEN CHARGE
R1 QRN141J-105 RESISTOR 1MΩ 1/4W
R3 PTY10067-601 MF RESISTOR 0.62Ω 1W
R4 QRE141J-334Y RESISTOR 330kΩ 1/4W
R5 QRE141J-334Y RESISTOR 330kΩ 1/4W
R7 QRE141J-751Y RESISTOR 750Ω 1/4W
R8 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R9 NRSA02J-272X MG RESISTOR 2.7kΩ 1/10W
R10 NRSA02J-104X MG RESISTOR 100kΩ 1/10W
R11 NRSA02J-682X MG RESISTOR 6.8kΩ 1/10W
R12 QRE141J-181Y RESISTOR 180Ω 1/4W
R13 QRE141J-334Y RESISTOR 330kΩ 1/4W
R14 QRE141J-334Y RESISTOR 330kΩ 1/4W
R15 NRSA02J-182X MG RESISTOR 1.8kΩ 1/10W
R16 NRSA02J-753X MG RESISTOR 75kΩ 1/10W
R22 NRSA02J-621X MG RESISTOR 620Ω 1/10W
R23 PTY20539-605 MF RESISTOR 0.20Ω 2W
R24 NRSA02J-102X MG RESISTOR 1kΩ 1/10W
R25 NRSA02J-101X MG RESISTOR 100Ω 1/10W
R26 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R27 NRSA02J-102X MG RESISTOR 1kΩ 1/10W
R28 NRSA02J-151X MG RESISTOR 150Ω 1/10W
R29 PTY20539-601 MG RESISTOR 47.0kΩ 1/10W
R30 PTY20539-601 MG RESISTOR 47.0kΩ 1/10W
R31 NRSA02F-103X MG RESISTOR 10.0kΩ 1/10W
R32 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R33 NRSA02J-333X MG RESISTOR 33kΩ 1/10W
R34 PTY20539-601 MG RESISTOR 47.0kΩ 1/10W
R35 PTY20539-602 MG RESISTOR 11.0kΩ 1/10W
R36 NRSA02F-6192X MG RESISTOR 61.9kΩ 1/10W
R37 PTY20539-603 MG RESISTOR 1.0kΩ 1/10W
R38 PTY20539-601 MG RESISTOR 47.0kΩ 1/10W
R39 PTY20539-604 MG RESISTOR 1.3kΩ 1/10W
#!REF No. PART No. PART NAME, DESCRIPTION
----------------------- ------------------------------ ----------------------------------------------------------------------------
R40 PTY20450-200 MG RESISTOR 20.0kΩ 1/4W
R41 NRSA02F-1152X MG RESISTOR 11.5kΩ 1/10W
R42 NRSA02F-1152X MG RESISTOR 11.5kΩ 1/10W
R43 QRE141J-103Y MF RESISTOR 10kΩ 1/4W
R45 NRSA02J-222X MG RESISTOR 2.2kΩ 1/10W
R46 NRSA02J-472X MG RESISTOR 4.7kΩ 1/10W
R47 NRSA02J-221X MG RESISTOR 220Ω 1/10W
R48 NRSA02J-102X MG RESISTOR 1kΩ 1/10W
R49 NRSA02J-473X MG RESISTOR 47kΩ 1/10W
R50 NRSA02F-5622X MG RESISTOR 56.2kΩ 1/10W
R51 NRSA02F-5112X MG RESISTOR 51.1kΩ 1/10W
R52 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R53 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R54 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R55 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R56 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
R60 NRSA02J-103X MG RESISTOR 10kΩ 1/10W
! C1 PTY20292-303 CAPACITOR 0.068µF 275V
C2 YQ10626-402 E CAPACITOR 47µF 400V
C3 PTY10067-651 CAPACITOR 1500pF 250V
C4 NCB21CK-224X CAPACITOR 0.22µF 16V
C5 PTY10067-653 CAPACITOR 0.01µF 50V
C6 NCB21HK-391X CAPACITOR 390pF 50V
! C7 PTY20538-611 CAPACITOR 2200pF 250V
! C8 PTY20538-611 CAPACITOR 2200pF 250V
C9 NDC21HJ-680X CAPACITOR 68pF 50V
C10 NDC21HJ-151X CAPACITOR 150pF 50V
C11 NDC21HJ-151X CAPACITOR 150pF 50V
C21 PTY10067-657 CAPACITOR 0.01µF 250V
C22 PTY20292-321 E CAPACITOR 680µF 16V
C23 QETL1CM-227 E CAPACITOR 220µF 16V
C24 NCB21CK-224X CAPACITOR 0.22µF 16V
C25 NCF21EZ-104X CAPACITOR 0.1µF 25V
C26 NCB21CK-224X CAPACITOR 0.22µF 16V
C27 NCB21EK-473X CAPACITOR 0.047µF 25V
C28 NCB21HK-473X CAPACITOR 0.047µF 50V
C29 NCB21EK-104X CAPACITOR 0.1µF 25V
C30 NCF21EZ-104X CAPACITOR 0.1µF 25V
C31 NCB21HK-222X CAPACITOR 0.0022µF 50V
C32 QEHA1HM-475 E CAPACITOR 4.7µF 50V
C33 NCF21EZ-104X CAPACITOR 0.1µF 25V
C34 NCF21EZ-104X CAPACITOR 0.1µF 25V
C35 QFLA1HJ-224 F CAPACITOR 0.22µF 50V
! T1 PTY20538-801 SW TRANS
VR1 PTY20483-101 VOLUME 2kΩ
! F1 PTY20450-041 FUSE 1A 250V
JK1 YQ21032-301 DC JACK
! L1 PTY20450-401 LINE FILTER
L12 PTY10067-702 BEAD INDUCTOR
L21 PTY10067-703 COIL
! PHC1 PC123YS PHOTO COUPLER
SW1 PTY20545-662 SWITCH
WR1 PTY20591-052 FLAT CABLE (5P)
TB1 PTY20545-051 TERMINAL,x5
CN1 PTY20483-001 CONNECTOR
6-5
Loading...