Invacare 2GRTM, 2GTRTM, 2GTTM User Manual
Parts Catalog
Tilt and Recline (2GTR™)
Issued: Jun 25, 2008
Tarsys®
Tilt Only (2GT™)
Recline Only (2GR™)
For 2G/3G Storm Series® RWD
and Arrow® FWD
Powered Wheelchairs
Yes, you can. ™
Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the
bottom of the page or below specified charts.
Parts Catalog Usage Guide
To order call toll free 1-800-333-6900, or www.invacare.com
The information contained in this document is subject to change without notice. This catalog contains
service parts for Form No. 99-150. If you have any questions regarding this catalog, please contact one
of our Customer Service Representatives.
For Customer Service Support Call:
1-800-333-6900
For Faxed In Orders Call:
1-800-678-4682 or
1-440-366-0709
For Technical Service Call:
1-800-832-4707
Literature Can Be Found at:
www.invacare.com or
1-800-828-6272
SYMBOL DEFINITION
Examples:
A,B,C etc.
NOTE:
NLA
= Special Comments
= General information pertaining to that specific page
= No Longer Available
HARDWARE MEASUREMENTS
The measurements for the hardware will be listed as follows:
Screws, Bolts
Washers
Spacers
For your convenience, we have supplied an area for you to list your Invacare Representatives.
©2008 Invacare Corporation. Elyria, Ohio. Invacare, Yes, you can., the Blue Medallion Design, Storm Series, Arrow, Silhouette, Contour U, and Arrow are
registered trademarks and 2GT, 2GR, 2GTR, MKIV, Infinity, and Personal Back are trademarks of Invacare Corporation.
Otto Bock is a registered trademark owned by Otto Bock Orthopaedische Industrie GMBH & Co.. JAY Back is a registered trademark of Sunrise Medical
Diameter X Thread Count/Pitch X Length
Inside Diameter X Outside Diameter X Thickness
Inside Diameter X Outside Diameter X Length
Name Phone Numbers
HHG, Inc. Corporation
Form No.
99-150
1
Accessories, Back Hardware (Infinity, Personal, JAY, Silhouette, Contour U Backs w/ Extruded
Canes) (Profile Back w/ 7/8" Round Canes)
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
99-150
Description
Accessories, Arm Pads - Otto Bock ......................................................................................... 141
153
Accessories, Headrest Support Assembly - A.B.S. Curved and Profile Back .......................... 143
Accessories, Lateral Support Assembly ................................................................................... 145
Accessories, Miscellaneous .................................................................................................... 158
Accessories, Power Wheelchair Tool Kit .................................................................................. 156
Accessories, Vent Tray Assembly (FWD) ................................................................................ 150
Accessories, Vent Tray Assembly (RWD) ................................................................................ 147
Armrest Assembly - 2GR and 2GTR ........................................................................................ 85
Armrest Assembly - 2GT .......................................................................................................... 82
Back Assembly - V.S.R. Actuator Motor & Attaching Hardware - 2GR and 2GTR .................. 80
Back Assembly Attaching Hardware - A.B.S. Curved and Profile ............................................ 77
Back Cane (7/8" Round) and Spreader Bar Assembly - 2GT .................................................. 40
Back Cane and Spreader Bar Assembly - Recline Only and Tilt/ Recline ............................... 42
Back Cane and Spreader Bar Assembly - Tilt Only ................................................................. 37
Back, A.B.S. Curved w/o Hardware - 2GR/2GTR w/ V.S.R. (After 4/20/03) ............................ 70
Back, A.B.S. Curved w/o Hardware - 2GR/2GTR w/ V.S.R. (Before 4/21/03) ......................... 63
Back, A.B.S. Curved w/o Hardware - 2GT (After 10/31/00) ..................................................... 54
Back, A.B.S. Curved w/o Hardware - 2GT (Before 11/1/00) .................................................... 45
Back, Profile without Attaching Hardware ................................................................................ 75
Electronics - Mid-Line Swing Bracket Assembly ...................................................................... 134
2
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
99-150
Description
Electronics - MKIV TRCM 2G, MKIV TAC & 4-Way Switch ..................................................... 127
Electronics - MKIV TRCM 2G, MKIV TAC & 4-Way Switch For TRBKTS Option .................... 130
Electronics - Quad Link (QLA) After 10/30/05 .......................................................................... 139
Electronics - Quad Link Before 10/31/05 .................................................................................. 136
Electronics - Tilt Recline Single Switch (TRSS) ....................................................................... 125
Electronics - Tilt/ Recline Potentiometers and Hardware ......................................................... 132
Frame, Base Interface Hardware - 2GR (FWD) ....................................................................... 20
Frame, Base Interface Hardware - 2GR (RWD) ....................................................................... 9
Frame, Base Interface Hardware (Includes Tilt Actuator) - 2GT/2GTR (FWD) ........................ 18
Frame, Base Interface Hardware (Includes Tilt Actuator) - 2GT/2GTR (RWD) ....................... 13
Frame, Base Interface Hardware w/ TRBKTS Option - 2GR (RWD) ....................................... 11
Frame, Base Interface w/ TRBKTS Option (Includes Tilt Actuator) - 2GT/2GTR (RWD) ......... 15
Frame, Center Seat Assembly - 2GT ...................................................................................... 26
Frame, Center Seat Assembly (Includes Recline Actuator) - 2GR ......................................... 28
Frame, Center Seat Assembly (Includes Recline Actuator) - 2GTR ....................................... 30
Frame, Center Seat Attaching Hardware - (RWD and FWD) ................................................... 24
Frames, Side ............................................................................................................................ 22
Front Pivot Bracket and Links Kit ............................................................................................. 32
Front Rigging - Front Rigging Hanger Assembly - Sector, Pin and Genius Style .................... 93
Front Rigging - Legrest Support Push Rod Assembly .............................................................. 123
Front Rigging - Legrest Supports (Mechanical) - AT5544P ..................................................... 95
3
Front Rigging - Power Non-Articulating Legrest Kits - POWELR18/POWELR20
(9/15/01-4/30/02)
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No.
99-150
Description
Front Rigging - Legrest, Genius (Mechanical) .......................................................................... 97
Front Rigging - Power Articulating Legrest - ELRPW (5/1/02-7/26/04) .................................... 108
Front Rigging - Power Articulating Legrest - ELRPW (After 7/26/04) ....................................... 111
Front Rigging - Power Articulating Legrest - POWELR18/POWELR20 (Before 9/15/01) ........ 101
Front Rigging - Power Articulating Legrest Kits - ELRPW (5/1/02-7/26/04) ............................. 120
Front Rigging - Power Articulating Legrest Kits - ELRPW (After 7/26/04) ................................ 122
Front Rigging - Power Articulating Legrest Kits - POWELR18/POWELR20 (Before 9/15/01) . 116
Front Rigging - Power Articulating/Non-Articulating Legrest Harnesses and Hardware .......... 114
Front Rigging - Power Non-Articulating Legrest - POWELR18/POWELR20 (9/15/01-4/30/02)
Label Locations For TRBKTS Option ....................................................................................... 7
Packaging and Literature ......................................................................................................... 5
Seat Pan ................................................................................................................................... 34
Seat Pan Mounting Hardware .................................................................................................. 35
Shroud Covers, Controller ........................................................................................................ 90
Shroud Covers, Rear, Side, Lower Seat and V.S.R. Actuator ................................................. 88
TRBKTS Option Clarification Reference .................................................................................. 8
105
119
4
Packaging and Literature
Form No.
99-150
5
To order call toll free 1-800-333-6900, or www.invacare.com
Packaging and Literature
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1030364 Carton, Cover 1 11 B
1091514 Insert, Carton 1 12
40131X161 Insert, Plain Pad 1 23
1106472 Carton 1 14
1021149 Bag, Poly Zip-Lip (13" Long x 9" Wide) 1 15
1080876 Carton 1 16
1092284 Insert, Carton 1 17
40131X045 Carton 1 18
1091517 Carton 1 19
See Note See Footnote 1 110 D
1030362 Carton, Tray 1 211
1115174 Carton, Corner Reinforcement 1 412
00077X031 Warranty Card 1 1A
1134791 Manual, Owner's 3G Storm w/ MKIV Electronics 1 1A,B
1031682 Carton, Cover 1 1A,C
1030362 Carton, Tray 1 1A,C
A - Not Shown
B - All Systems
C - Complete Seating Systems with Chair Base
D - Wood skid not supplied
NOTE:
When adjusting or replacing parts, please refer to you Owner's Manual for assistance.
NOTE:
Form No.
99-150
6
To order call toll free 1-800-333-6900, or www.invacare.com
Label Locations For TRBKTS Option
Form No.
99-150
7
To order call toll free 1-800-333-6900, or www.invacare.com
TRBKTS Option Clarification Reference
TRBKTS Option was introduced 12/19/05 as an On-Chair option only for 3G RWD Storm Series models.
Form No.
99-150
8
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
Recline Only (2GR)
Form No.
99-150
9
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082873 Pivot Assembly, Rear 1 11
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 62
1086943 Bar, Spacer, Black 1 23
1070462 Screw, Hex Head Cap w/ Patch (5/16-18 x 7/8") 1 64
1082872 Bracket, Pivot, Front, Black 1 15 A
1086944 Screw, Socket Head Cap (5/16-18 x 3/4") 1 46
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 57
1082880 Support, Seat 1 28
1069724 T-Nut (5/16-18) 1 69
7930318 Screw, Phillips Pan Head (#4-40 x 1/2") 25 110
1070430 Bracket, Charger Connector, Black 1 111
P0870X000 Nut, Hex Keps (#4-40) 1 212
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
NOTE:
Recline Only (2GR)
Form No.
99-150
10
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
Recline Only (2GR) with TRBKTS Option
Form No.
99-150
11
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082873 Pivot Assembly, Rear 1 11
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 62
1086943 Bar, Spacer, Black 1 23
1070462 Screw, Hex Head Cap w/ Patch (5/16-18 x 7/8") 1 44
1082872 Bracket, Pivot, Front, Black 1 15
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 46
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 67
1082880 Support, Seat 1 28
1140342 Spacer, Seat Support Mounting 1 29
1069724 T-Nut (5/16-18) 1 610
1043627 Screw, Hex Head Cap with Patch (5/16-18 x 1-3/4") 1 211
1070430 Bracket, Charger Connector, Black 1 112
1140259 Kit, Front/Rear Tie-Down Brackets Mounting
Hardware
1 113 A
Screw, Hex Head (5/16-18 x 3/4") 1 414
Washer, Flat (5/16 x 5/8 x 1/16") 1 415
T-Nut (5/16-18) 1 416
Screw, Socket Head Cap with Patch (5/16-18 x
1-3/4")
1 417
Screw, Socket Head Cap (3/8-16 x 3/4") 1 218
1140263 Kit, Top Battery Support Bracket and Mounting
Hardware
1 119 B
Bracket, Top Battery Support 1 120
Washer, Flat (5/16 x 5/8 x 1/16") 1 721
Screw, Hex Head (5/16-18 x 5/8") 1 322
Screw, Hex Head Cap with Patch (5/16-18 x 3/4") 1 423
T-Nut (5/16-18) 1 424
1135963 Bracket, Battery Support, Black 1 125
1140260 Kit, Front Battery Support Bracket with Mounting
Hardware
1 126 C
Bracket, Battery Support, Black - Front 1 127
Washer, Flat (5/16 x 5/8 x 1/16") 1 328
Screw, Hex Head Cap w/ Patch (5/16-18 x 1/2") 1 329
A - Includes items 14-18
B - Includes items 20-23
C - Includes items 27-29
NOTE:
Recline Only (2GR) with TRBKTS Option
Form No.
99-150
To order call toll free 1-800-333-6900, or www.invacare.com
12
Base Frame Interface Hardware (RWD)
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No.
99-150
13
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082778 Actuator, Tilt - For All User Weight Limits 1 11 B
1026158 Locknut (5/16-18) 1 42
1031665 Screw, Socket Head Shoulder (3/8 x 1-1/2") 1 23
1082873 Pivot Assembly, Rear 1 14
1082760 Guidance Assembly, Linear 1 25
1117326 Screw, Socket Head Cap w/ Patch (5/16-18 x 7/8") 1 46
1091869 Screw, Socket Flat Head C'sunk with Patch (1/4-20
x 3/4")
1 67
1082877 Bar, Clamp, Black 1 28
1070398 Screw, Hex Head (5/16-18 x 1-1/2") 1 29
1039655 Bushing, Rubber 1 210
1070462 Screw, Hex Head Cap w/ Patch (5/16-18 x 7/8") 1 611
1082872 Bracket, Pivot, Front, Black 1 112 A
1086944 Screw, Socket Head Cap (5/16-18 x 3/4") 1 413
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 514
1082880 Support, Seat 1 215
1069724 T-Nut (5/16-18) 1 616
P0870X000 Nut, Hex Keps (#4-40) 1 217
1070430 Bracket, Charger Connector, Black 1 118
7930318 Screw, Phillips Pan Head (#4-40 x 1/2") 25 119
1070411 Bolt, Shoulder (3/8 x 2-1/2") 1 220
1098646 Bushing, Black (7/16 x 1/2 x 11/16") 1 221
1098645 Block, Black Tilt Angle 1 222
1140059 Kit, Actuator Braking Module w/ Instruction Sheet 1 123 C
1141508 Instruction Sheet, Actuator Braking Module 1 1D
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
B - Actuator Braking Module added to Tilt Actuator and is backward compatible to all systems made before 5/18/06. The
addition of the braking module eliminated the requirement of a Heavy Duty Tilt Actuator.
C - Actuator Braking Module can be assembled in the field on seating systems before 5/18/06 as well. Must verify with an
Invacare Technician when a kit is required.
D - Not Shown
NOTE:
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No.
99-150
To order call toll free 1-800-333-6900, or www.invacare.com
14
Base Frame Interface Hardware (RWD)
Tilt Only (2GT) and Tilt/Recline (2GTR) with TRBKTS Option
Form No.
99-150
15
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082778 Actuator, Tilt - For All User Weight Limits 1 11 D
1026158 Locknut (5/16-18) 1 42
1031665 Screw, Socket Head Shoulder (3/8 x 1-1/2") 1 23
1082873 Pivot Assembly, Rear 1 14
1082760 Guidance Assembly, Linear 1 25
1117326 Screw, Socket Head Cap w/ Patch (5/16-18 x 7/8") 1 46
1091869 Screw, Socket Flat Head C'sunk with Patch (1/4-20
x 3/4")
1 67
1082877 Bar, Clamp, Black 1 28
1070462 Screw, Hex Head Cap w/ Patch (5/16-18 x 7/8") 1 49
1082872 Bracket, Pivot, Front, Black 1 110
1021344 Screw, Socket Head Cap (5/16-18 x 1-1/2") 1 411
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 612
1082880 Support, Seat 1 213
1140342 Spacer, Seat Support Mounting 1 214
1069724 T-Nut (5/16-18) 1 615
1043627 Screw, Hex Head Cap with Patch (5/16-18 x 1-3/4") 1 216
1070430 Bracket, Charger Connector, Black 1 117
1140259 Kit, Front/Rear Tie-Down Brackets Mounting
Hardware
1 118 A
Screw, Hex Head (5/16-18 x 3/4") 1 419
Washer, Flat (5/16 x 5/8 x 1/16") 1 420
T-Nut (5/16-18) 1 421
Screw, Socket Head Cap with Patch (5/16-18 x
1-3/4")
1 422
Screw, Socket Head Cap (3/8-16 x 3/4") 1 223
1140263 Kit, Top Battery Support Bracket and Mounting
Hardware
1 124 B
Bracket, Top Battery Support 1 125
Washer, Flat (5/16 x 5/8 x 1/16") 1 726
Screw, Hex Head (5/16-18 x 5/8") 1 327
Screw, Hex Head Cap with Patch (5/16-18 x 3/4") 1 428
T-Nut (5/16-18) 1 429
1135963 Bracket, Battery Support, Black 1 130
1140260 Kit, Front Battery Support Bracket with Mounting
Hardware
1 131 C
Bracket, Battery Support, Black - Front 1 132
Washer, Flat (5/16 x 5/8 x 1/16") 1 333
Screw, Hex Head Cap w/ Patch (5/16-18 x 1/2") 1 334
1140059 Kit, Actuator Braking Module w/ Instruction Sheet 1 135 E
1141508 Instruction Sheet, Actuator Braking Module 1 1F
Tilt Only (2GT) and Tilt/Recline (2GTR) with TRBKTS Option
Form No.
99-150
16
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (RWD)
A - Includes items 19-23
B - Includes items 25-28
C - Includes items 32-34
D - Actuator Braking Module added to Tilt Actuator and is backward compatible to all systems manufactured before 5/18/06.
The addition of the braking module eliminated the requirement of a Heavy Duty Tilt Actuator.
E - Actuator Braking Module can be assembled in the field on seating systems manufactured before 5/18/06 as well. Must
verify with an Invacare Technician when a kit is required.
F - Not Shown
NOTE:
Tilt Only (2GT) and Tilt/Recline (2GTR) with TRBKTS Option
Form No.
99-150
To order call toll free 1-800-333-6900, or www.invacare.com
17
Base Frame Interface Hardware (FWD)
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No.
99-150
18
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware (FWD)
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082778 Actuator, Tilt - For All User Weight Limits 1 11 B
1026158 Locknut (5/16-18) 1 42
1031665 Screw, Socket Head Shoulder (3/8 x 1-1/2") 1 23
1082873 Pivot Assembly, Rear 1 14
1082760 Guidance Assembly, Linear 1 25
1117326 Screw, Socket Head Cap w/ Patch (5/16-18 x 7/8") 1 46
1091869 Screw, Socket Flat Head C'sunk with Patch (1/4-20
x 3/4")
1 67
1082877 Bar, Clamp, Black 1 28
1074133 Washer (5/16 x 3/4 x 1/16") 1 29
7930337 Screw, Hex Head Cap with Patch (5/16-18 x 1-1/4") 25 110
1095481 Plate, Wedge 1 211
1095479 Wedge, Seat Mounting 1 212
1086944 Screw, Socket Head Cap (5/16-18 x 3/4") 1 613
1061922 Screw, Hex Head Cap w/ Patch (5/16-18 x 1/2") 1 414
1082872 Bracket, Pivot, Front, Black 1 115 A
1039655 Bushing, Rubber 1 216
1070398 Screw, Hex Head (5/16-18 x 1-1/2") 1 217
1069724 T-Nut (5/16-18) 1 418
1070411 Bolt, Shoulder (3/8 x 2-1/2") 1 219
1098646 Bushing, Black (7/16 x 1/2 x 11/16") 1 220
1098645 Block, Black Tilt Angle 1 221
1140059 Kit, Actuator Braking Module w/ Instruction Sheet 1 122 C
1141508 Instruction Sheet, Actuator Braking Module 1 1D
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
B - Actuator Braking Module added to Tilt Actuator and is backward compatible to all systems manufactured before 5/18/06.
The addition of the braking module eliminated the requirement of a Heavy Duty Tilt Actuator.
C - Actuator Braking Module can be assembled in the field on seating systems manufactured before 5/18/06 as well. Must
verify with an Invacare Technician when a kit is required.
D - Not Shown
NOTE:
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No.
99-150
To order call toll free 1-800-333-6900, or www.invacare.com
19
Base Frame Interface Hardware
Recline Only (2GR)
Form No.
99-150
20
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082873 Pivot Assembly, Rear 1 11
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 62
1086943 Bar, Spacer, Black 1 23
1095481 Plate, Wedge 1 24
1086944 Screw, Socket Head Cap (5/16-18 x 3/4") 1 65
1095479 Wedge, Seat Mounting 1 26
1074133 Washer (5/16 x 3/4 x 1/16") 1 27
7930337 Screw, Hex Head Cap with Patch (5/16-18 x 1-1/4") 25 18
1061922 Screw, Hex Head Cap w/ Patch (5/16-18 x 1/2") 1 49
1082872 Bracket, Pivot, Front, Black 1 110 A
1069724 T-Nut (5/16-18) 1 411
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
NOTE:
Recline Only (2GR)
Form No.
99-150
21
To order call toll free 1-800-333-6900, or www.invacare.com
Side Frames
NOTE: A new cross beam may be required when changing seat width for a Recline Only or Tilt/Recline
system. See center seat frame assembly page.
Form No.
99-150
22
To order call toll free 1-800-333-6900, or www.invacare.com
Side Frames
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1087002 Hardware, Side Frame Mounting 1 11 A
7930333 Locknut (1/4-20) 25 12
1047449 Spacer (1/4 x 3/8 x 3/16") 1 43
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 44
1037610 Screw, Hex Head (1/4-20 x 1-5/8") 1 45
1086976 Side Frame w/ Arm Lock Assembly, 16"-17" Deep,
Right
1 16
1086977 Side Frame w/ Arm Lock Assembly, 16"-17" Deep,
Left
1 16
1086978 Side Frame w/ Arm Lock Assembly, 18"-19" Deep,
Right
1 16
1086979 Side Frame w/ Arm Lock Assembly, 18"-19" Deep,
Left
1 16
1086980 Side Frame w/ Arm Lock Assembly, 20"-21" Deep,
Right
1 16
1086981 Side Frame w/ Arm Lock Assembly, 20"-21" Deep,
Left
1 16
1086982 Side Frame w/ Arm Lock Assembly, 22" Deep, Right 1 16
1086983 Side Frame w/ Arm Lock Assembly, 22" Deep, Left 1 16
7930347 Pin Roll (5/64 x 5/8") 25 17 B
47471X074 Spring, Arm Lock 1 27 B
1028594 Pin, Arm Lock 1 27 B
1090768 Kit, Lock Handle w/Rivets (both LT & RT side) 2 17 B
A - Includes Items 2-5
B - Arm Lock Assembly
NOTE:
NOTE: A new cross beam may be required when changing seat width for a Recline Only or Tilt/Recline
system. See center seat frame assembly page.
Form No.
99-150
To order call toll free 1-800-333-6900, or www.invacare.com
23
Center Seat Frame Attaching Hardware
(RWD and FWD)
Form No.
99-150
24
To order call toll free 1-800-333-6900, or www.invacare.com
Center Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1026158 Locknut (5/16-18) 1 41
1031665 Screw, Socket Head Shoulder (3/8 x 1-1/2") 1 42
1070411 Bolt, Shoulder (3/8 x 2-1/2") 1 23
1098646 Bushing, Black (7/16 x 1/2 x 11/16") 1 24
1098645 Block, Black Tilt Angle 1 25
(RWD and FWD)
Form No.
99-150
25
To order call toll free 1-800-333-6900, or www.invacare.com
Center Seat Frame Assembly
Tilt Only (2GT)
Form No.
99-150
26
To order call toll free 1-800-333-6900, or www.invacare.com
Center Seat Frame Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1087010 Center Seat Frame Assembly, Short (16"-19" Deep) 1 11 A
1087011 Center Seat Frame Assembly, Long (20"-22" Deep) 1 11 A
1082874 Center Seat Frame, Short (16"-19" Deep) 1 12
1082875 Center Seat Frame, Long (20"-22" Deep) 1 12
1086590 Tilt Pivot Assembly, Right 1 13
1086591 Tilt Pivot Assembly, Left 1 13
1012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 84
1061922 Screw, Hex Head Cap w/ Patch (5/16-18 x 1/2") 1 25
1082876 Spacer (3/8 x 3/4 x 3/8") 1 26
1086595 Link, Tilt 1 27
1065214 Washer, Flat (3/8 x 11/16 x 1/16") 1 48
1086930 Ring, Retaining (3/8") 1 49
1091502 Guide, Tilt Rail 1 410
A - Includes Items 2-10
NOTE:
Tilt Only (2GT)
Form No.
99-150
27
To order call toll free 1-800-333-6900, or www.invacare.com
Center Seat Frame Assembly
Recline Only (2GR)
Form No.
99-150
28
To order call toll free 1-800-333-6900, or www.invacare.com
Center Seat Frame Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1086944 Screw, Socket Head Cap (5/16-18 x 3/4") 1 61
1082878 Bracket, Screw Support Acutator, Right 1 12
1082879 Bracket, Screw Support Acturator, Left 1 12
1026158 Locknut (5/16-18) 1 73
1031665 Screw, Socket Head Shoulder (3/8 x 1-1/2") 1 14
1082750 Actuator, Recline 1 15
1012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 146
1087022-NLA Link, Recline, Right 1 17 A,A1,B
1087023-NLA Link, Recline, Left 1 17 A,A1,B
1110497 Link, Recline 0 and 5 Degree Seat Tilt, Right 1 17 C
1110498 Link, Recline 0 and 5 Degree Seat Tilt, Left 1 17 C
1110499 Link, Recline 10 and 15 Degree Seat Tilt, Right 1 17 C
1110500 Link, Recline 10 and 15 Degree Seat Tilt, Left 1 17 C
1065214 Washer, Flat (3/8 x 11/16 x 1/16") 1 48
1086930 Ring, Retaining (3/8") 1 49
1082876 Spacer (3/8 x 3/4 x 3/8") 1 210
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 211
1079203 Decal, Warning Pinch Point 1 212
1091500 Kit, Connecting Slide Bracket w/ Decal, Black -
Right
1 113
1091501 Kit, Connecting Slide Bracket w/ Decal, Black - Left 1 113
1098944 Screw, Socket Head Cap w/ Patch (1/4-20 x 3/4") 1 414
1095352 Block, Gear Hold Down Upper 1 215
1091503 Bushing (1/4 x 1/2 x 7/16") 1 416
1026035 Locknut (#10-24) 1 417
1000212 Screw, Shoulder (1/4 x 1-1/4") 1 418
1095476 Assembly, Dual Roller Right 1 119 D
1095477 Assembly, Dual Roller Left 1 119 D
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
A1 - To maintain an existing, 5, 10, or 15 degree seat tilt, only recline links made after 5/19/02 are required.
B - Before 5/20/02
C - After 5/19/02
D - Includes 2 each of items 16-18
NOTE:
Recline Only (2GR)
Form No.
99-150
29
To order call toll free 1-800-333-6900, or www.invacare.com
Loading...