
IPL, 125RJ (EU,AUST,NZ), 2010-08, 545 10 34-34
125RJ (EU,AUST,NZ)
Spare parts
Ersatzteile
Pièces détachées
Reserve onderdelen
Repuestos
Reservdelar

Parts List No.
Date
9/15/09
1
2
3
4
545103434
Replaced
545103434 - 9/11/08
R
PARTS LIST
NOTE : Illustration may differ from actual model due to design changes.
MODEL
125RJ (EU/AUST/NZ)
Page:
1
10
11
9
8
7
6
5
12
13
14
15
16
17
18
WARNING
All repairs, adjustments and
maintenance not described in
the Operator’s Manual must be
performed by Qualified Service
Personnel.
19
20
Ref. Part No. Description
1. 545125301 Assy-Cable/Wire Harness
2. 545062001 Housing-Throttle - RH
3. 530016448 Screw
4. 530016449 Screw
5. 530016454 Spring-Trigger
6. 545066001 Trigger
7. 530059804 Lockout-Throttle
8. 545045601 Spring-Lockout
9. 545067001 Housing-Thottle - LH
10. 545049301 Switch
11. 530015820 Bolt
12. 545139701 Assy-Handle/J-Bar
13. 545113301 Clamp-Harness (upper)
14. 545056601 Clamp-Harness (lower)
15. 530015940 Screw
16. 530059185 Clamp - Handle
17. 530016152 Wingnut
18. 545081889 Kit-Driveshaft
(Incl. 28,29,32,34)
19. Flexshaft
20. 537216201 Harness-w/o warning
21. 545030901 Kit-Shield (Incl. 22,23,31)
22. 530052286 Limiter - Line
22
23
21
25
26
27
Ref. Part No. Description
23. 530015814 Screw
25. 503890101 Cup - Support
26. 537285601 Support - Flange
27. 503856301 Locknut - Blade
28. 530016014 Screw
29. 545003902 Screw
30. 537234901 Driver Disc
31. 530015771 Screw
32. 530057554 Bracket - Shield
33. 502285901 Pin - Locking
34. 530096295 Assy - Gearbox
31
32
33
28
34
29
30
Ref. Part No. Description
Not Shown
545005911 Decal-Warning
537312901 Guard - Transport
530031159 Wrench-Hex
502114602 Wrench-Spark Plug
= New Part Number For This IPL
= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)

Parts List No.
Date
9/15/09
25
26
30
36
545103434
Replaced
545103434 - 9/11/08
27
28
35
29
24
34
23
33
22
R
PARTS LIST
NOTE : Illustration may differ from actual model due to design changes.
18
20
38
17
15
14
16
39
13
12
40
11
41
42
10
43
59
57
60
7
8
9
61
62
58
56
55
44
19
21
31
32
37
45
63
54
MODEL
125RJ (EU/AUST/NZ)
Page:
2
1
2
3
4
5
6
66
67
65
64
68
Gasket
Kit
53
52
51
46
47
48
49
50
Ref. Part No. Description
1. 530150253 Filter
2. 530016101 Nut-Carb. Screw
3. 545084601 Air Box
4. 530057844 Lever - Choke
5. 545050402 Kit-Carb. Gasket (Incl 7,63)
6. 530035596 Adaptor-Carb.
7. 545008084 Kit-Gasket (foam)
8. 530016400 Bolt
9. 545001001 Cylinder
10. 952030201 Plug-Spark (RCJ-8Y)
11. 545050403 Kit-Crankshaft seal
12. 530016475 Washer-Starter
13. 545160301 Spring-Starter Cup
14. 545102303 Assy-Starter Cup
15. 530059800 Coupling-Starter
16. 530095646 Assy-Fuel Filter
17. 545081897 Kit-Fuel Line
18. 530150350 Assy-Cap w/ret.(Incl. 19)
19. 545008084 Kit-Gasket O-ring - Fuel Cap
20. 545105104 Assy-Fuel Tank
(Incl. 16,17,18,19)
21. 530057851 Shroud-Rear
22. 530016448 Screw
23. 545029901 Kit-Rope
24. 530150318 Handle-Starter
= New Part Number For This IPL
Ref. Part No. Description
25. 530016426 Screw
26. 545029603 Starter Hsg. w/eyelet
27. 545029801 Kit-Starter Spring
28. 545029701 Kit-Starter Pulley
29. 530016468 Screw
30. 545106301 Assy-Starter Hsg.(Incl.
23,24,26,27,28,29)
31. 530059780 Isolator-Tank
32. 530058982 Bolt-Muffler
33. 530015496 Screw
34. 530150440 Shield-Heat
35. 530016449 Screw
36. 545104901 Guard-Muffler
37. 545030501 Kit-Spark (Incl. 33)
38. 545057501 Assy-Muffler
39. 545008084 Kit-Gasket-Paper Met.
40. 530015897 Screw
41. 545046701 Module
42. 530039227 Assy-Leadwire
43. 530016456 Screw
44. 530016463 Washer
45. 530094189 Washer-Clutch
46. 545173401 Bearing - Thrust
47. 530016420 Washer - Thrust
48. 530016469 Screw
= Refer to the Service Reference Indicated for more information.(Located at the END of the IPL)
Ref. Part No. Description
49. 530016470 Screw
50. 530015768 Nut
51. 530016456 Screw
52. 545017501 Assy-Fan Housing
53. Assy-Clutch Drum
54. 545050405 Kit-Clutch Assy.
55. 530057852 Spacer
56. 530039242 Flywheel
57. 545054601 Crankcase
58. 545013401 Bearing
59. 545030001 Kit-Crankshaft
60. 530015162 Retainer-Piston Pin
61. 530019283 Ring-Piston
62. 545030301 Kit-Piston (Incl. 60,61)
63. 545008084 Kit-Gasket (adaptor seal)
64. 530015897 Screw
65. Kit-Carb. (Incl. 4,5)
66. 530057846 Cover-Air Box
530059796 Assy-Knob
67.
68. 545008084 Kit-Gasket
(Incl. 5,7,11,19,39,63)
Not Shown
530058709 Bulb-Purge

Parts List No.
545103434
Date
9/15/09
Service Reference
Note : Due to product improvements, your unit may have a different clutch drum assembly and flexshaft.
Replaced
545103434 - 9/11/08
NOTE : Illustration may differ from actual model due to design changes.
R
PARTS LIST
MODEL
125RJ (EU/AUST/NZ)
Page:
Please refer to the serial number on your unit and order the parts below.
Serial Number - 06282N and lower, please use the following parts:
Page 1, Ref.# 19 - 545081805 Kit - Clutch drum & flexshaft
Page 2, Ref.# 53 - 545081805 Kit - Clutch drum & flexshaft
Serial Number - 06283N and higher, please use the following parts:
Page 1, Ref.# 19 - 545007507 Flexshaft
Page 2, Ref.# 53 - 530150039 Assy-Clutch drum with adapter
Service Reference
Note : Due to product improvements, your unit may have a different carburetor.
Please refer to the serial number on your unit and order the parts below.
3
Serial Number - 07305N and lower, please use the following parts:
Page 2, Ref.# 65 - 545006062 Kit - Carburetor
Serial Number - 07306N and higher, please use the following parts:
Page 2, Ref.# 65 - 545081848 Kit - Carburetor