Hobart C64A Parts List

CATALOG OF

REPLACEMENT PARTS

MODEL C64A SERIES

DISHWASHERS

ML-103908 (R-L)
ML-103909 (L-R)

A product of HOBART CORPORATION 701 S. RIDGE AVENUE TROY, OHIO 45374-0001

FORM 18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

F-18366 Rev. B (February 2015) - 2 - © HOBART 2015

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

Table of Contents

5 CONTROL BOX

7 COMPONENT PANEL (CONTROL BOX)
11 WASH MOTOR & PUMP UNITS(2 UNITS REQD)
13 UNIT / CONVEYOR DRIVE
17 TRACK & CRADLE (WASH/RINSE SECTION)
19 WASH ARMS & TUBES (WASH/RINSE SECTION)
21 FILL & OUTSIDE RINSE PIPING
23 INSIDE METALLIC RINSE PIPING
25 INSIDE RINSE PIPING (NON METALLIC)
27 ACTUATOR MECHANISM & RINSE DRAIN OFF PAN
29 DRAIN UNIT (WASH/RINSE SECTION)
31 DOORS, CURTAINS, BAFFLES, & STRAINERS
33 VENT HOOD
35 EXTENDED HOOD
37 MISCELLANEOUS (WASH/RINSE SECTION)
41 LOW WATER PROTECTION (STEAM HEAT/WASH & RINSE TANK)
43 ELECTRIC HEAT
45 GAS HEAT BURNERS, FLUES, & WIREWAYS
49 GAS HEAT COMPONENTS
53 STEAM COILS (2 UNITS REQD)
55 STEAM COIL PIPING
59 STEAM INJECTOR & PREVIOUS CONSTRUCTION STEAM COIL PIPING
63 STEAM INJECTOR HEAT (2 UNITS REQUIRED)
65 DISH RACKS
67 TABLE LIMIT SWITCH

- 3 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

CONTROL BOX

F-18366 Rev. B (February 2015) - 4 -

CONTROL BOX

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

ILLUS.
PL-55288

10 NS-011-07 Mach Nut 6-32 Hex....................................................................................................................3

11 00-437041-3 Thermometer (8 Ft) (Final Rinse)...............................................................................................1

12 00-437041-4 Thermometer (11 Ft) (Rinse)......................................................................................................1

13 00-37041-4 Thermometer (11 Ft) (Wash)......................................................................................................1

14 00-812854 Label - Control Box (W/O Conveyor Dwell).............................................................................AR

15 00-812848 Label - Control Box (Conveyor Dwell).....................................................................................AR

16 00-087711-241-2 Switch - Rocker (DPDT) (Conveyor Dwell)................................................................................1

17 00-087711-228-1 Switch - Rocker (Motor On/Off)..................................................................................................1

18 00-087711-198-2 Switch - Rocker (Power On/Off).................................................................................................1

19 00-087711-241-2 Switch - Rocker (DPDT) (Timer)................................................................................................1

20 00-271840 Label - Timer..............................................................................................................................1

21 00-107218 Coupling - Thermometer Bulb....................................................................................................3

22 WS-012-40 Washer (SST).............................................................................................................................4

23 FP-053-05 Pipe Locknut 1/2 NPSL (SST)....................................................................................................3

24 00-435072 Gasket........................................................................................................................................1

25 WS-022-01 Washer.......................................................................................................................................6

26 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................6

27 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................6

28 00-814161 Label - Instruction.......................................................................................................................1

29 00-329408 Label - Instruction (Gas Heat)....................................................................................................1

30 00-437068 Control Box (Single Point Electrical Connection, Elec Heat Only).............................................1

31 SC-021-24 Mach Screw 10-24 x 5/8 Rd Hd.................................................................................................4

32 NS-031-16 Stop Nut 10-24 "Elastic" (SST)...................................................................................................4

33 00-276259-2 Circuit Breaker (20 Amp) (Used on 2240 V Machines)..............................................................1

34 00-276259-4 Circuit Breaker (40 Amp) (Used on 380-480 V Machines).........................................................1

35 FE-024-13 Bushing - Electrical 2-1/2...........................................................................................................1

36 NS-031-08 Stop Nut 8-32 "Special"..............................................................................................................4

37 00-526408 Tape - Foam............................................................................................................................AR

38 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

39 WS-017-06 Washer (SST).............................................................................................................................2

40 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

41 00-119031 Block - Terminal.........................................................................................................................1

42 00-118544-2 Lug - Grounding.........................................................................................................................1

43 SC-021-23 Mach Screw 10-24 x 1/2 Rd Hd.................................................................................................1

44 WL-007-12 Lockwasher #10 External Shakeproof........................................................................................1

45 NS-031-16 Stop Nut 10-24 "Elastic" (SST)...................................................................................................1

46 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

47 WS-022-01 Washer.......................................................................................................................................2

48 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

49 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

50 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

51 SC-041-05 Cap Screw 1/4-20 x 5/8 Hex Hd.................................................................................................4

PART NO. NAME OF PART AMT.

1 SC-053-05 Mach Screw 10-24 x 3/8 Truss Hd, Slotted................................................................................2

2 00-436755-1 Cover - Control Box (W/O Single Point Electrical Connection)..................................................1

3 00-437073-1 Cover - Control Box (W/Single Point Electrical Connection)......................................................1

4 00-355504-1 Fan (115 V)................................................................................................................................1

5 00-274884 Guard - Fan................................................................................................................................1

6 00-274947 Grommet....................................................................................................................................1

7 00-328137 Shield.........................................................................................................................................1

8 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................2

9 WL-006-42 Lockwasher #6 Medium.............................................................................................................3

FE-021-12 Plug - 1/2 Knockout (Plastic)...................................................................................................AR

FE-023-26 Plug - 1 Knockout (Plastic)......................................................................................................AR

- 5 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX)

F-18366 Rev. B (February 2015) - 6 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX)

ILLUS.
PL-55253

10 00-294325-015-1 Block - Terminal.........................................................................................................................1

11 SD-037-21 Self-Tapping Screw 8-32 x 1 Fil. Phil. Hd., Type F....................................................................2

12 00-118544-2 Lug - Grounding.........................................................................................................................2

13 SD-035-77 Self-Tapping Screw 1/4 -20 x 3/8 Phil. Pan Hd., Type TT..........................................................2

14 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................2

15 00-118544-2 Lug - Grounding (Electric Heat)..................................................................................................2

16 SD-035-77 Self-Tapping Screw 1/4 -20 x 3/8 Phil. Pan Hd., Type TT..........................................................2

17 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................2

18 00-294325-015-1 Block - Terminal (200-240 V., 380-480 V., 3 Ph.) (Electric Heat)...............................................2

19 00-294325-004-1 Block - Terminal (Not Shown) (200-240 V., 1 Ph.) (Electric Heat).............................................2

20 SD-037-21 Self-Tapping Screw 8-32 x 1 Phil. Fil Hd., Type F (Use with Item 18).......................................4

21 SD-008-36 Self-Tapping Screw 8-18 x 7/8 Phil. Rd. Hd., Type B (Use with Item 19)..................................4

22 00-294500-026-1 Transformer (75 VA) (Gas Heat)................................................................................................1

23 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................4

24 00-918322 Contactor (40 Amp., 3-Pole).......................................................................................................2

25 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................4

26 00-294677-5 Clamp - Wire (1-1/2 I.D.)............................................................................................................5

27 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................5

28 00-205113-1 Relay 3 P.D.T. (1CR, 3CR, & 4CR)............................................................................................3

29 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil. Pan Hd., Type B................................................................6

30 00-294677-4 Clamp - Wire (1 I.D.)..................................................................................................................2

31 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................2

32 00-087714-020-2 Relay (3.P.D.T.)..........................................................................................................................1

33 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil. Pan Hd., Type B................................................................2

34 00-087714-046-1 Contactor (Machines W/Vent Fan Control)................................................................................1

35 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil. Bind Hd., Type B...............................................................2

36 00-437103 Bracket.......................................................................................................................................1

37 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................2

38 WL-014-07 Lockwasher #10 External Shakeproof (SST).............................................................................2

39 00-294677-4 Clamp - Wire (1 I.D.)..................................................................................................................3

40 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................3

41 00-294500-046-1 Transformer (150 VA, 50/60 Hz.) Pilot Control...........................................................................1

42 00-294500-046-2 Transformer (300 VA) Pilot Control............................................................................................1

43 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................4

44 WL-014-07 Lockwasher #10 External Shakeproof (SST).............................................................................4

45 00-437070-1 Plug-On Module.........................................................................................................................1

46 00-087714-36 Relay Time Delay (Variable)......................................................................................................1

47 SD-036-13 Self-Tapping Screw 1/4 -20 x 1-1/4 Slotted Hex Washer Hd., Type T.......................................1

48 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

49 00-205113-1 Relay (3 P.D.T.)..........................................................................................................................2

50 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil. Pan Hd., Type B................................................................4

51 00-437102 Bracket - Relay Mounting...........................................................................................................2

52 SD-008-18 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................4

53 WL-014-05 Lockwasher #8 External Shakeproof (SST)...............................................................................4

54 00-435508 Base Plate..................................................................................................................................1

55 00-475458-1 Thermostat - Solid State (120 V.)...............................................................................................2

PART NO. NAME OF PART AMT.

1 00-294325-013-5 Block - Terminal.........................................................................................................................1

2 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil. Pan Hd., Type B................................................................2

3 00-918322 Contactor (40 Amp., 3-Pole) Contactor (40 Amp.) (3 Pole) (Machines W/Conveyor

Dwell).........................................................................................................................................1

4 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................2

5 00-294325-013-4 Block - Terminal (Machines W/Vent Fan Control)......................................................................1

6 00-437101 Bracket - Vent Fan Control.........................................................................................................1

7 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................2

8 WL-014-07 Lockwasher #10 External Shakeproof (SST).............................................................................2

9 SD-019-29 Self-Tapping Screw 6-20 x 1/2 Phil. Pan Hd., Type B................................................................2

- 7 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

COMPONENT PANEL

(CONTROL BOX)

ILLUS.
PL-55253

56 SC-098-07 Mach. Screw 4-40 x 1-3/4 Rd. Hd. (SST)...................................................................................6

57 WS-028-12 Washer.......................................................................................................................................2

58 00-087714-031-2 Relay Time Delay (5 Sec.).........................................................................................................1

59 SD-036-13 Self-Tapping Screw 1/4 -20 x 1-1/4 Slotted Hex Washer Hd., Type T.......................................1

60 WL-007-15 Lockwasher 1/4 External Shakeproof.........................................................................................1

61 00-294677-3 Clamp - Wire..............................................................................................................................1

62 SD-019-31 Self-Tapping Screw 8-18 x 1/2 Phil. Pan Hd., Type B................................................................1

63 FE-022-39 Fuse (1.5 Amp.) (250 V.)............................................................................................................1

64 FE-021-19 Fuse (3.2 Amp.) (250 V.) (50 Hz. & 50/60 Hz. Machines W/Blower Dryer &/or

65 FE-023-80 Fuse (3.0 Amp.) (250 V.) (Gas Heat).........................................................................................1

66 00-294676 P.C.B. - Terminal & Fuse...........................................................................................................1

67 SD-008-18 Self-Tapping Screw 8-18 x 3/8 Phil. Bind Hd., Type B...............................................................3

68 00-087713-041-2 Contactor (40 Amp.) (3 Pole).....................................................................................................1

69 SD-008-25 Self-Tapping Screw 10-16 x 3/8 Phil. Bind Hd., Type B.............................................................2

70 SC-053-05 Mach. Screw 10-24 x 3/8 Slotted Truss Hd. (SST)....................................................................6

71 WL-007-12 Lockwasher #10 External Shakeproof........................................................................................6

PART NO. NAME OF PART AMT.

Condenser).................................................................................................................................1

F-18366 Rev. B (February 2015) - 8 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 9 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

WASH MOTOR & PUMP UNITS(2 UNITS REQD)

F-18366 Rev. B (February 2015) - 10 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

WASH MOTOR & PUMP UNITS(2 UNITS REQD)

ILLUS.
PL-55254

10 00-274230-4 Motor (3 Ph., 50 Hz.) (2 HP).......................................................................................................1

11 00-274227-3 Adapter.......................................................................................................................................1

12 WL-006-22 Lockwasher 5/16 Light...............................................................................................................4

13 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

14 00-274227-6 Seal - Shaft.................................................................................................................................1

15 00-274227-12 Impeller & Sleeve (60 Hz.).........................................................................................................1

16 00-274227-7 Impeller & Sleeve (50 Hz.).........................................................................................................1

17 FE-024-61 Connector 45 Deg. (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)........................AR

18 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)........................AR

19 FE-008-10 1/2 Gasket Assy.........................................................................................................................1

20 00-274227-1 Pump Shell (Incls. Item 3)..........................................................................................................1

21 00-274246 Shroud........................................................................................................................................1

22 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................10

23 NS-015-11 Nut 5/16 -18 Hex......................................................................................................................10

24 00-119050 Gasket........................................................................................................................................1

25 00-749586 Hose - Discharge........................................................................................................................1

26 00-542337 Clamp - Hose.............................................................................................................................2

27 00-274227-4 Gasket........................................................................................................................................1

28 00-119051 Gasket........................................................................................................................................2

29 00-812776 Support Plate..............................................................................................................................2

30 00-328411 Tube - Discharge (RH) (Shown).................................................................................................1

31 00-328409 Tube - Discharge (LH)................................................................................................................1

32 00-812069 Bracket - Motor Support.............................................................................................................1

33 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd. (SST)....................................................................................2

34 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

35 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

PART NO. NAME OF PART AMT.

1 00-328362 Strainer - Pump..........................................................................................................................1

2 00-270968 Gasket - Wash Pipe...................................................................................................................1

3 00-274227-5 Stud.........................................................................................................................................AR

4 SC-041-29 Cap Screw 3/8 -16 x 7/8 Hex Hd. (SST)....................................................................................4

5 WS-006-44 Washer.......................................................................................................................................4

6 00-274227-2 Clamp.........................................................................................................................................1

7 00-274230-1 Motor (1 Ph., 60 Hz.) (2 HP).......................................................................................................1

8 00-274230-2 Motor (3 Ph., 60 Hz.) (2 HP).......................................................................................................1

9 00-274230-3 Motor (1 Ph., 50 Hz.) (2 HP).......................................................................................................1

- 11 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

UNIT / CONVEYOR DRIVE

F-18366 Rev. B (February 2015) - 12 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

UNIT / CONVEYOR DRIVE

ILLUS.
PL-55287

10 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

11 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

12 00-270937 Shaft - Crank..............................................................................................................................1

13 00-436879 Spacer - Bearing........................................................................................................................1

14 BB-021-19 Ball Bearing - Hoover NSK 6003................................................................................................1

15 00-270940 Seal - Upper Housing.................................................................................................................1

16 00-328083 Coupling - Motor.........................................................................................................................1

*17 00-274228-2 Insert - Coupling Service (Lovejoy).........................................................................................AR

*18 00-274228-1 Insert - Coupling Service (Browning).......................................................................................AR

19 00-270939 Seal - Lower Housing.................................................................................................................1

20 00-012430-40 Key 3/16 Sq. x 3/4 Lg.................................................................................................................1

21 00-270942 Gasket........................................................................................................................................1

22 00-274749 Housing Assy. (Incls. Items 12 thru 15,19,23,& 24)...................................................................1

23 BB-021-19 Ball Bearing - Hoover NSK 6003................................................................................................1

24 00-274748 Seal - Labyrinth..........................................................................................................................1

25 00-527042 Adhesive..................................................................................................................................AR

26 00-522696 Solvent....................................................................................................................................AR

27 00-474423 Flinger........................................................................................................................................1

28 00-437044-6 Motor - Conveyor Drive (200-230/460 V., 60 Hz.) (3 Ph.)(Incls. Items 38, 39, & 63)

29 00-437044-7 Motor - Conveyor Drive (200-240 V., 60 Hz., 1 Ph.) (Incls. Items 38, 39, & 63)........................1

30 00-437044-8 Motor - Conveyor Drive (200-240 V., 50 Hz., 1 Ph.) (Incls. Items 38, 39, & 63)........................1

31 00-437044-9 Motor - Conveyor Drive (220-240/380-415 V., 50 Hz., 3 Ph.)(Incls. Items 38, 39, & 63)

32 00-289256 Actuator - Switch........................................................................................................................1

33 NS-032-33 Stop Nut 1/4 -28 "Flexloc"..........................................................................................................1

34 SC-027-24 Mach. Screw 6-32 x 1-1/2 Rd. Hd..............................................................................................2

35 WL-010-22 Lockwasher #6 External Shakeproof..........................................................................................2

36 WS-002-06 Washer.......................................................................................................................................4

37 NS-010-06 Mach. Nut 6-32 Hex...................................................................................................................2

38 00-328379-1 Seal - Oil (Output Shaft-Shown).................................................................................................1

39 00-328379-2 Seal - Oil (Motor Drive Shaft).....................................................................................................1

40 00-087711-60-1 Switch - Interlock (Incls. Items 34 thru 37).................................................................................1

41 00-087711-260 Switch - Interlock (Incls. Items 42 thru 46).................................................................................1

42 FE-022-84 Strain Relief................................................................................................................................1

43 SC-127-89 Mach. Screw 10-24 x 3/4 Phil. Rd. Hd. (SST)............................................................................2

44 00-474488 Bracket - Switch.........................................................................................................................1

45 NS-031-16 Stop Nut 10-24 "Elastic" (SST)...................................................................................................2

46 SC-067-05 Mach. Screw 8-32 x 1/2 Hex Hd. (SST).....................................................................................2

47 NS-031-08 Stop Nut 8-32 Hex (SST)...........................................................................................................2

48 00-270927 Pilot Bearing...............................................................................................................................1

49 00-271083 Spacer - Overload......................................................................................................................1

50 WS-029-5 Washer.......................................................................................................................................4

51 00-436017 Bracket - Overload.....................................................................................................................1

52 SC-120-72 Cap Screw 5/16 -18 x 4-1/2 Hex Hd...........................................................................................1

53 00-436952 Spring - Overload.......................................................................................................................1

54 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd. (SST)..................................................................................2

55 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

PART NO. NAME OF PART AMT.

1 NS-032-35 Stop Nut 5/16 -18 "Flexloc"........................................................................................................1

2 00-474660 Slider - Crank Arm......................................................................................................................1

3 SC-041-20 Mach. Screw 5/16 -18 x 2-1/8 Truss Hd.....................................................................................1

4 NS-005-72 Washer.......................................................................................................................................1

5 00-012430-39 Key 3/16 Sq. x 3/8 Lg.................................................................................................................1

6 00-270943 Arm - Crank................................................................................................................................1

7 SC-050-01 Set Screw 1/4 -20 x 1/2 Square Hd. Cup Pt...............................................................................2

8 SC-041-13 Cap Screw 5/16 -18 x Hex Hd. (SST)........................................................................................4

9 WS-017-18 Washer.......................................................................................................................................4

...................................................................................................................................................1

...................................................................................................................................................1

- 13 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

UNIT / CONVEYOR DRIVE

ILLUS.
PL-55287

56 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

57 00-328027 Bracket - Motor...........................................................................................................................1

58 SC-041-31 Cap Screw 3/8 -16 x 1-1/4 Hex Hd.............................................................................................4

59 WL-006-29 Lockwasher 3/8 Hi-Collar...........................................................................................................4

60 NS-015-13 Nut 3/8 -16 Hex (SST)................................................................................................................4

61 FE-024-61 Connector 45 Deg. (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)...........................1

62 FE-024-65 Connector 90 Deg. (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)...........................1

63 00-274231-57 Key - 3/16 x 3/16 x 1-1/8 Lg.......................................................................................................1

64 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)...........................1

65 FE-024-61 Connector 45 Deg. (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)...........................1

66 FE-008-10 1/2 Gasket Assy.........................................................................................................................1

PART NO. NAME OF PART AMT.

* Parts must be matched with same vendor coupling.

F-18366 Rev. B (February 2015) - 14 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 15 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

TRACK & CRADLE

(WASH/RINSE SECTION)

F-18366 Rev. B (February 2015) - 16 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

TRACK & CRADLE

(WASH/RINSE SECTION)

ILLUS.
PL-55255

10 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................8

11 NS-015-11 Nut 5/16 -18 Hex.....................................................................................................................AR

12 WS-017-08 Washer (SST)..........................................................................................................................AR

13 WL-006-23 Lockwasher 5/16 Helical (SST)...............................................................................................AR

*14 WS-018-04 Washer (SST).............................................................................................................................8

*15 SC-041-31 Cap Screw 3/8 -16 x 1-1/4 Hex Hd.............................................................................................8

*16 NS-046-09 Nut 3/8 -16 Hex (SST)................................................................................................................8

*17 WL-006-28 Lockwasher 3/8 Helical..............................................................................................................8

*18 00-436704-1 Dog (Front, R-L) (Rear, L-R)......................................................................................................4

*19 00-436704-2 Dog - Not Shown (Front, L-R) (Rear, R-L).................................................................................4

20 SC-041-10 Cap Screw 5/16 -18 x 5/8 Hex Hd...........................................................................................AR

21 00-437047 Deflector - Silverware..............................................................................................................AR

*22 00-270983 Spacer........................................................................................................................................8

23 00-473231 Slider - Large..............................................................................................................................4

24 SC-041-15 Cap Screw 5/16 -18 x 1-1/4 Hex Hd...........................................................................................8

25 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................8

26 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................8

27 00-435938 Cradle.........................................................................................................................................1

28 00-271012 Baffle - Cradle Upper...............................................................................................................AR

29 SC-127-91 Mach Screw 1/4 -20 x 5/8 Flat Hd (SST).................................................................................AR

30 WS-003-47 Washer (SST)..........................................................................................................................AR

31 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

32 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

33 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST).................................................................................14

34 WS-017-01 Washer (SST)...........................................................................................................................18

35 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................18

36 NS-015-11 Nut 5/16 -18 Hex......................................................................................................................18

PART NO. NAME OF PART AMT.

1 00-435935-1 Rack Track.................................................................................................................................2

2 00-435975 Bracket - Track...........................................................................................................................2

3 SC-041-12 Cap Screw 5/16 -18 x 7/8 Hex Hd..............................................................................................6

4 WS-017-08 Washer (SST).............................................................................................................................4

5 WS-017-01 Washer (SST).............................................................................................................................4

6 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................6

7 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................6

8 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................8

9 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................8

00-435937-1 Cradle & Dog Assy L-R (Standard Racks Only)(Incls Items 14 thru 19, 22, & 27).....................1

00-435937-3 Cradle & Dog Assy R-L (Standard Racks Only)(Incls Items 14 thru 19, 22, & 27).....................1

00-437057-1 Rack Track Assy (Incls Items 1 & 23 thru 26)............................................................................2

* Quantities listed are for 20 x 20 racks

- 17 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

WASH ARMS & TUBES
(WASH/RINSE SECTION)

F-18366 Rev. B (February 2015) - 18 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

WASH ARMS & TUBES
(WASH/RINSE SECTION)

ILLUS.
PL-55256

10 WS-017-08 Washer (SST).............................................................................................................................4

11 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

12 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

13 00-435999 Wash Pipe (26-1/8 Door Height) (RH)........................................................................................1

14 00-435987 Wash Pipe (26-1/8 Door Height) (LH)........................................................................................1

15 00-437134 Wash Pipe (32-1/8 Door Height) (RH)........................................................................................1

16 00-437136 Wash Pipe (32-1/8 Door Height) (LH)........................................................................................1

17 SC-041-18 Cap Screw 5/16 -18 x 1-3/4 Hex Hd (SST)................................................................................8

18 WS-017-08 Washer (SST)...........................................................................................................................16

19 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................8

20 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................8

21 00-270968 Gasket - Wash Pipe...................................................................................................................2

*22 00-436002 Wash Arm - Lower (RH) (Shown)...............................................................................................1

*23 00-436000 Wash Arm - Lower (LH)..............................................................................................................1

24 00-436939-2 Catch - Adjustable (RH) (Shown)...............................................................................................1

25 00-436939-1 Catch - Adjustable (LH)..............................................................................................................1

26 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

27 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

28 WS-017-8 Washer.......................................................................................................................................4

29 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................4

30 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................4

31 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

32 WS-017-08 Washer (SST).............................................................................................................................4

33 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

34 00-274222 Support - Adjustable...................................................................................................................2

35 00-749416 Wash Arm - Lower (RH) (Shown)...............................................................................................1

36 00-749415 Wash Arm - Lower (LH)..............................................................................................................1

37 00-067500-110 "O" Ring......................................................................................................................................4

38 00-475589 Plug - Wash Arm (Used With Items 35, 37, 43, & 44)..............................................................12

39 00-067500-127 "O" Ring....................................................................................................................................12

40 00-749419 Wash Arm - Upper (RH) (Shown)...............................................................................................1

41 00-749417 Wash Arm - Upper (LH)..............................................................................................................1

42 00-436947-1 Hanger........................................................................................................................................4

43 SC-041-50 Cap Screw 1/4 -20 x 1/2 Hex Hd................................................................................................8

44 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................8

45 00-475087 Plug - Wash Arm (Used With Items 22, 23, 46, & 47)..............................................................12

*46 00-436945 Wash Arm - Upper (RH) (Shown)...............................................................................................1

*47 00-436946 Wash Arm - Upper (LH)..............................................................................................................1

PART NO. NAME OF PART AMT.

1 00-436007 Guide - Upper Wash Arm...........................................................................................................2

2 SC-125-27 Mach Screw 5/16 -18 x 3/4 Truss Hd (SST)...............................................................................4

3 WS-017-01 Washer (SST).............................................................................................................................4

4 NS-036-19 Stop Nut 5/16 -18 Hex................................................................................................................4

5 00-289760 Latch...........................................................................................................................................2

6 SC-041-01 Cap Screw 1/4 -20 x 3/4 Hex Hd................................................................................................4

7 NS-031-19 Stop Nut 1/4 -20 "Elastic" (SST).................................................................................................4

8 00-812819 Bracket.......................................................................................................................................2

9 SC-053-17 Mach Screw 5/16 -18 x 3/4 Truss Hd (SST)...............................................................................4

* Obsolete part number For replacement, use 35, 36, 40, or 41 with Items 38 &

39

- 19 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

F-18366 Rev. B (February 2015) - 20 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

FILL & OUTSIDE RINSE PIPING

ILLUS.
PL-55257

10 00-328247 Pressure Gauge - Water............................................................................................................1

11 00-436319 Petcock 1/4 ................................................................................................................................1

12 00-435968-1 Solenoid Valve 1/2 (115 V.) (Incls. Item 13)...............................................................................1

13 00-271839-1 Coil - Solenoid Valve..................................................................................................................1

14 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)...........................2

15 FE-024-61 Connector 45 Deg. (Non Metallic) "Sealtite" (1/2 Male Thd. x 1/2 Flex. Cnd.)...........................2

16 00-329831-2 Fill Piping - Outside (R-L)...........................................................................................................1

17 00-329831-1 Fill Piping - Outside (L-R)...........................................................................................................1

18 00-292909-2 Vacuum Breaker 1/2...................................................................................................................1

19 00-292910 Vacuum Breaker Float & Seal Assy...........................................................................................1

20 00-329829 Adapter & Elbow Weldment 1/2 ................................................................................................1

21 SC-041-15 Cap Screw 5/16 -18 x 1-1/4 Hex Hd...........................................................................................4

22 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

23 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

24 00-435972-2 Piping - Inside (RH)....................................................................................................................1

25 00-435972-1 Piping - Inside (LH).....................................................................................................................1

26 WL-013-16 Lockwasher 5/16 Internal Shakeproof (C64A Machines)...........................................................1

27 00-436718 Ground Strap (C64A Machines).................................................................................................1

28 FE-006-37 Elbow 90 Deg. Short (1/2 Male Thd. x 1/2 Thinwall) (C64A Machines).....................................2

29 FE-008-10 1/2 Gasket Assy. (C64A Machines)...........................................................................................2

30 FE-006-07 Lock Nut 1/2 (Cnd.) (C64A Machines).......................................................................................2

31 00-112007 Gasket (C64A Machines)...........................................................................................................1

32 00-288465 Lid & Gasket Assy. (Incls. Item 58)(C64A Machines)................................................................1

33 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil. Truss Hd., Type T(C64A Machines).................................4

34 NS-018-28 Jam Nut 1/2 -20 Hex Fin(C64A Machines).................................................................................1

35 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)(C64A Machines)..................................................1

36 WS-010-40 Washer - Thrust (C64A Machines).............................................................................................1

37 00-270926 Junction Box - Auto Fill (RH) (R-L)(C64A Machines) (C64A Machines)....................................1

38 00-436026 Junction Box - Auto Fill (LH) (L-R)(C64A Machines)(C64A Machines)......................................1

39 00-067500-72 "O" Ring (C64A Machines).........................................................................................................1

40 00-112467 Retainer - Float (C64A Machines)..............................................................................................1

41 00-271622 Probe & Switch Assy. (2 Wire) (Water Level) (C64A Machines)................................................1

42 RR-010-13 Retaining Ring.(C64A Machines)...............................................................................................1

43 00-122674 Float Assy.(C64A Machines)......................................................................................................1

44 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

45 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

46 WS-003-47 Washer (SST)..........................................................................................................................AR

47 00-067500-31 "O" Ring...................................................................................................................................AR

48 00-119244 Cap & Stud Assy.....................................................................................................................AR

49 00-435974 Bracket - Fill Piping....................................................................................................................1

50 SC-041-12 Cap Screw 5/16 -18 x 7/8 Hex Hd..............................................................................................2

51 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd. (SST)..................................................................................2

52 WS-029-05 Washer (SST).............................................................................................................................6

53 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

54 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

55 00-271002-01 Solenoid Valve 3/4 (115 V.) (Incls. Items 56 & 57).....................................................................1

56 00-271838 Service Kit - Solenoid Valve.......................................................................................................1

57 00-271839-01 Coil - Solenoid Valve..................................................................................................................1

58 00-328764 Adapter & Elbow Weldment.......................................................................................................1

59 00-067500-12 "O" Ring......................................................................................................................................4

PART NO. NAME OF PART AMT.

1 00-277112 Vacuum Breaker.........................................................................................................................1

2 00-118270 Service Kit - Vacuum Breaker....................................................................................................1

3 00-812956-2 Piping Sub-Assy. (R-L)...............................................................................................................1

4 00-812956-1 Piping Sub-Assy. (L-R)...............................................................................................................1

5 00-435967 Plate - Fill Piping........................................................................................................................1

6 00-186922 Line Strainer (Incls. Items 8, 9, & 10).........................................................................................1

7 00-186923 Plug - Branch..............................................................................................................................1

8 00-186924 Gasket - Branch Plug.................................................................................................................1

9 00-186925 Screen - Line Strainer................................................................................................................1

00-065890-85 Line - Splice (C64A Machines)...................................................................................................2

- 21 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

INSIDE METALLIC RINSE PIPING

F-18366 Rev. B (February 2015) - 22 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

INSIDE METALLIC RINSE PIPING

ILLUS.
PL-50781

10 00-122402-2 Flange........................................................................................................................................1

11 00-276407 Gasket - Rinse Pipe...................................................................................................................1

12 SC-053-16 Mach Screw 5/16 -18 x 5/8 Truss Hd.........................................................................................2

13 SC-053-15 Mach Screw 5/16 -18 x 1/2 Truss Hd (SST)...............................................................................2

14 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

15 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

16 00-271027-1 Lower Rinse Arm (R-L) 5 Nozzles (Incls Items 19, 20, & 23).....................................................1

17 00-271027-2 Lower Rinse Arm (L-R) 5 Nozzles (Incls Items 19, 20, & 23).....................................................1

18 00-81812 Nozzle - Rinse (Brass0) (0.078 Dia Orifice)...............................................................................6

19 00-022731-3 Nozzle - Rinse (SST) #50 Drill (0.070).......................................................................................5

20 FP-030-27 Lock Nut 1/2 NPSL Pipe (Brass)................................................................................................1

21 FP-029-08 Pipe Cap 1/2 (Brass)..................................................................................................................1

22 FP-030-27 Lock Nut 1/2 NPSL Pipe (Brass)................................................................................................1

23 FP-029-08 Pipe Cap 1/2 (Brass)..................................................................................................................1

24 FP-028-03 Pipe Plug 1/8 Sq Hd (Brass)......................................................................................................1

25 00-271088-1 Upper Rinse Arm (R-L) 6 Nozzles (Incls Items 18, 21, & 22).....................................................1

26 00-271088-2 Upper Rinse Arm (L-R) 6 Nozzles (Incls Items 18, 21, & 22).....................................................1

27 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

28 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

29 SC-053-18 Mach Screw 5/16 -18 x 7/8 Truss Hd (SST)...............................................................................2

30 00-67500-12 "O" Ring......................................................................................................................................1

31 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd...........................................................................................2

PART NO. NAME OF PART AMT.

1 00-329610-1 Final Rinse Outside Piping (R-L)................................................................................................1

2 00-329610-2 Final Rinse Outside Piping (L-R)................................................................................................1

3 00-067500-12 "O" Ring......................................................................................................................................2

4 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

5 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

6 00-435979-1 Final Rinse Inside Piping (R-L) (26 1/8 Door Height).................................................................1

7 00-435979-2 Final Rinse Inside Piping (L-R) (26 1/8 Door Height).................................................................1

8 00-437132-1 Final Rinse Inside Piping (R-L) (32 1/8 Door Height).................................................................1

9 00-437132-2 Final Rinse Inside Piping (L-R) (32 1/8 Door Height).................................................................1

- 23 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

INSIDE RINSE PIPING

(NON METALLIC)

F-18366 Rev. B (February 2015) - 24 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

INSIDE RINSE PIPING

(NON METALLIC)

ILLUS.
PL-55258

10 00-276407 Gasket - Rinse Pipe...................................................................................................................1

11 SC-053-16 Mach Screw 5/16 -18 x 5/8 Truss Hd.........................................................................................2

12 SC-053-15 Mach Screw 5/16 -18 x 1/2 Truss Hd (SST)...............................................................................2

13 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

14 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

15 00-435070 Mixer - Spiral..............................................................................................................................1

16 00-185781 Elbow - 1/2 x 90 Deg (PVC).......................................................................................................2

17 00-476504-1 Lower Rinse Arm (R-L) 7 Nozzles (Incls Items 23 & 24)............................................................1

18 00-476504-2 Lower Rinse Arm (L-R) 7 Nozzles (Incls Items 23 & 24)............................................................1

19 WL-006-16 Lockwasher 1/4 Helical (SST)....................................................................................................2

20 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

21 00-274570 Bracket.......................................................................................................................................1

22 SC-128-05 Mach Screw 1/4 -20 x 1/2 Fil Hd (SST)......................................................................................2

23 00-276380-2 Cap - Lower Rinse Arm..............................................................................................................1

24 00-476369 Nozzle - Rinse (SST) #50 Drill (0.070).......................................................................................7

25 00-081812-2 Nozzle - Rinse (SST) (0.078 Dia Orifice)...................................................................................6

26 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

27 WL-006-16 Lockwasher 1/4 Helical (SST)....................................................................................................2

28 00-274532-1 Bracket (R-L)..............................................................................................................................1

29 00-274532-2 Bracket (L-R)..............................................................................................................................1

30 SC-024-06 Mach Screw 1/4 -20 x 1/2 Fil Hd (SST)......................................................................................2

31 00-274535-1 Upper Rinse Arm (R-L) 6 Nozzles (Incls Items 25 & 41)............................................................1

32 00-274535-2 Upper Rinse Arm (L-R) 6 Nozzles (Incls Items 25 & 41)............................................................1

33 FP-085-51 Tee 1/2 x 1/2 x 1/2 NPT Schedule 80 PVC................................................................................2

34 00-274531-2 Tube (1 1/4 Lg)...........................................................................................................................1

35 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

36 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

37 00-274533 Flange........................................................................................................................................2

38 SC-053-18 Mach Screw 5/16 -18 x 7/8 Truss Hd (SST)...............................................................................2

39 00-067500-12 "O" Ring......................................................................................................................................1

40 00-067500-12 "O" Ring......................................................................................................................................2

41 00-276380-2 Cap - Upper Rinse Arm..............................................................................................................1

42 00-274531-3 Tube - Inside Rinse 15 1/8 Lg....................................................................................................1

PART NO. NAME OF PART AMT.

1 00-329608-1 Final Outside Rinse Piping (R-L)................................................................................................1

2 00-329608-2 Final Outside Rinse Piping (L-R)................................................................................................1

3 FP-028-03 Pipe Plug 1/8 Sq Hd (Brass)......................................................................................................2

4 SC-041-15 Cap Screw 5/16 -18 x 1 1/2 Hex Hd...........................................................................................2

5 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

6 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

7 00-274708 Tube - Inside Rinse (32 1/8 Door Height)...................................................................................1

8 00-274536 Tube - Inside Rinse (26 1/8 Door Height)...................................................................................1

9 00-122402-2 Flange........................................................................................................................................1

- 25 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

ACTUATOR MECHANISM & RINSE DRAIN OFF PAN

F-18366 Rev. B (February 2015) - 26 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

ACTUATOR MECHANISM & RINSE DRAIN OFF PAN

ILLUS.
PL-55259

10 NS-015-01 Nut 1/4 Hex (SST)......................................................................................................................2

11 00-329579-5 Rinse Pan Assy (L-R).................................................................................................................1

12 00-329579-6 Rinse Pan Assy (R-L).................................................................................................................1

13 00-812922-1 Strainer.......................................................................................................................................1

14 00-270996 Insulator - Switch........................................................................................................................1

15 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................2

16 00-749347 Switch - Reed Encapsulated......................................................................................................1

17 00-290160 Magnet (Dot Not Visible)............................................................................................................1

18 00-290159 Retainer - Magnet.......................................................................................................................1

19 SC-127-26 Mach. Screw 6-32 x 3/8 Rd Hd (SST)........................................................................................2

PART NO. NAME OF PART AMT.

1 00-436027 Actuator (L-R).............................................................................................................................1

2 00-436955 Actuator (R-L).............................................................................................................................1

3 WS-029-05 Washer (SST).............................................................................................................................2

4 NS-036-19 Stop Nut 5/16 -18.......................................................................................................................2

5 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

6 WS-017-08 Washer (SST).............................................................................................................................2

7 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................2

8 WS-003-49 Washer (SST).............................................................................................................................2

9 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

- 27 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

DRAIN UNIT

(WASH/RINSE SECTION)

F-18366 Rev. B (February 2015) - 28 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

DRAIN UNIT

(WASH/RINSE SECTION)

ILLUS.
PL-55289

*10 WL-006-07 Lockwasher #10 Helical (SST)...................................................................................................2

*11 WS-023-34 Washer.......................................................................................................................................2

*12 00-271070 Drain Lever (RH)........................................................................................................................1

*13 00-274096 Drain Lever (LH).........................................................................................................................1

*14 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

*15 00-436961 Lift Rod - Drain (LH)...................................................................................................................1

*16 00-436962 Lift Rod - Drain (RH)...................................................................................................................1

*17 WS-017-08 Washer (SST).............................................................................................................................2

*18 00-065958 Pull Rod......................................................................................................................................2

*19 NS-018-06 Jam Nut 5/16-18 Hex Fin...........................................................................................................2

*20 00-016269 Nut - Pull Rod Adjustor...............................................................................................................2

*21 NS-018-06 Jam Nut 5/16-18 Hex Fin...........................................................................................................2

*22 00-065958 Pull Rod......................................................................................................................................2

*23 NS-015-11 Nut 5/16-18 Hex (SST)...............................................................................................................2

*24 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

*25 00-67500-118 "O" Ring......................................................................................................................................2

*26 SC-041-17 Cap Screw 5/16-18 x 1 1/2 Hex Hd (SST).................................................................................2

*27 00-077466 Plug - Drain................................................................................................................................2

*28 WS-017-08 Washer (SST).............................................................................................................................2

*29 PC-005-02 Cotter Pin 1/16 x 1/2 (SST)........................................................................................................4

30 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

31 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

32 WS-017-01 Washer (SST).............................................................................................................................4

33 00-270952-2 Retainer......................................................................................................................................2

34 WS-017-01 Washer (SST).............................................................................................................................4

35 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

36 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

37 00-119099-2 Tube - Overflow..........................................................................................................................2

38 00-067500-120 "O" Ring......................................................................................................................................2

39 00-289464 Gasket - Drain............................................................................................................................2

40 00-270947 Sleeve - Drain Body...................................................................................................................2

41 00-289465 Drain Body..................................................................................................................................2

42 00-119116 Axle - Drain Lever.......................................................................................................................2

43 FP-028-32 Pipe Plug 2 Sq Hd......................................................................................................................1

44 WS-006-44 Washer.....................................................................................................................................12

45 WL-006-28 Lockwasher 3/8 Helical............................................................................................................12

46 SC-041-30 Cap Screw 3/8 -16 x 1 Hex Hd (SST)......................................................................................12

47 WS-022-01 Washer.......................................................................................................................................2

*48 WS-022-01 Washer.......................................................................................................................................2

*49 00-106283 Sleeve - Drain Valve Body.........................................................................................................1

50 00-328813 Bushing - Drain...........................................................................................................................2

51 00-274132-5 Drain Pipe - Wash/Rinse Section...............................................................................................1

52 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

*53 00-119116 Axle - Drain Lever.......................................................................................................................2

*54 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

55 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)................................................................................AR

56 WS-017-01 Washer (SST)..........................................................................................................................AR

57 WL-006-23 Lockwasher 5/16 Helical (SST)...............................................................................................AR

58 NS-015-11 Nut 5/16 -18 Hex.....................................................................................................................AR

PART NO. NAME OF PART AMT.

1 SC-021-22 Mach Screw 10-24 x 3/8 Rd Hd (SST).......................................................................................2

2 WL-006-07 Lockwasher #10 Helical (SST)...................................................................................................2

3 WS-023-34 Washer.......................................................................................................................................2

4 00-271070 Drain Lever (RH)........................................................................................................................1

5 00-274096 Drain Lever (LH).........................................................................................................................1

6 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

7 00-436953 Lift Rod Overflow (LH)................................................................................................................1

8 00-436954 Lift Rod Overflow (RH)...............................................................................................................1

*9 SC-021-22 Mach Screw 10-24 x 3/8 Rd Hd (SST).......................................................................................2

* Use in wash/rinse tank on machines with RS or PW

- 29 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

DOORS, CURTAINS, BAFFLES, & STRAINERS

F-18366 Rev. B (February 2015) - 30 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

DOORS, CURTAINS, BAFFLES, & STRAINERS

ILLUS.
PL-55260

10 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

11 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

12 00-436959-1 Baffle - Final Rinse (R-L)............................................................................................................1

13 00-435982-1 Baffle - Final Rinse (L-R)............................................................................................................1

14 00-271084 Splash Curtain (26 1/8 Door Height)..........................................................................................4

15 00-271084-2 Splash Curtain (32 1/8 Door Height)..........................................................................................4

16 00-120266-1 Curtain Rod................................................................................................................................4

17 00-120152-55 Splash Curtain Assy. (Incls. Items 14 & 16) (26 1/8 Door Height)..........................................AR

18 00-120152-56 Splash Curtain Assy. (Incls. Items 15 & 16) (32 1/8 Door Height)..........................................AR

19 00-112378-49 Door Slide (26 1/8 Door Height).................................................................................................4

20 00-112378-50 Door Slide (32 1/8 Door Height).................................................................................................4

21 00-185864 Catch - Door...............................................................................................................................2

22 PC-005-02 Cotter Pin 1/16 x 1/2 (SST)........................................................................................................2

23 00-012114 Pin..............................................................................................................................................2

24 00-120151-1 Splash Curtain (10-C1)...............................................................................................................1

25 00-120266-1 Curtain Rod................................................................................................................................1

26 SC-053-42 Mach. Screw 1/4 -20 x 5/8 Truss Hd. (SST)...............................................................................6

27 WS-022-01 Washer.......................................................................................................................................6

28 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................6

29 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................6

30 00-328065 Actuator - Lift Drain....................................................................................................................2

31 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................4

32 00-290160 Magnet.......................................................................................................................................2

33 00-290159 Retainer - Magnet.......................................................................................................................2

34 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................4

35 00-749347 Reed Mounting Board Assy........................................................................................................2

36 00-270996 Insulator - Switch........................................................................................................................2

37 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................4

38 00-328064-7 Door (26 1/8)..............................................................................................................................1

39 00-328079-7 Door (32 1/8)..............................................................................................................................1

40 00-271100 Bucket - Strainer.........................................................................................................................2

41 00-435941 Strainer - Front (RH)...................................................................................................................1

42 00-436034 Strainer - Rear (RH) (Not Shown)..............................................................................................1

43 00-435943 Strainer - Front (LH)...................................................................................................................1

44 00-435939 Strainer - Rear (LH) (Not Shown)...............................................................................................1

PART NO. NAME OF PART AMT.

1 00-435963-1 Baffle - Center............................................................................................................................1

2 00-289828 Bracket.......................................................................................................................................2

3 00-435962-1 Baffle - Center............................................................................................................................1

4 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd..............................................................................................10

5 WS-003-49 Washer (SST)...........................................................................................................................13

6 WL-006-17 Lockwasher 1/4 Helical (SST)..................................................................................................11

7 NS-015-01 Nut 1/4 -20 Hex (SST)..............................................................................................................11

8 SC-041-05 Mach. Screw 1/4 -20 x 5/8 Hex Hd. (SST).................................................................................2

9 WS-022-01 Washer.......................................................................................................................................2

- 31 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

VENT HOOD

F-18366 Rev. B (February 2015) - 32 -

VENT HOOD

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

ILLUS.
PL-55261

10 NS-031-19 Stop Nut 1/4 -20 "Elastic"(SST)................................................................................................11

PART NO. NAME OF PART AMT.

1 00-435799 Drip Shield Assy.........................................................................................................................1

2 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

3 NS-036-12 Stop Nut 3 /8 -24 "Elastic"..........................................................................................................1

4 00-75623 Damper - Vent Stack..................................................................................................................1

5 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

6 00-064919 Shaft - Damper...........................................................................................................................1

7 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

8 00-435794-1 Vent Hood Assy (Incls Items 1 thru 7)........................................................................................1

9 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd..............................................................................................11

- 33 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

EXTENDED HOOD

F-18366 Rev. B (February 2015) - 34 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

EXTENDED HOOD

ILLUS.
PL-55262

10 00-075621 Vent Stack Assy.........................................................................................................................1

11 SC-053-02 Mach Screw 10-24 x 1/2 Truss Hd (SST)...................................................................................8

12 NS-031-15 Stop Nut 10-24 "Elastic" (SST)...................................................................................................8

13 00-435799 Drip Shield Assy.........................................................................................................................1

14 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

15 NS-036-12 Stop Nut 3 /8 -24 "Elastic"..........................................................................................................1

16 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

17 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

18 00-075623 Damper - Vent Stack..................................................................................................................1

19 00-064919 Shaft - Damper...........................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-080553 Drip Shield Assy.........................................................................................................................1

2 00-079463-2 Extended Hood Assy..................................................................................................................1

3 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd..............................................................................................13

4 NS-031-19 Stop Nut 1/4 -20 "Elastic" (SST)...............................................................................................13

5 NS-036-12 Stop Nut 3/8 -24 "Elastic"...........................................................................................................1

6 SC-125-25 Mach Screw 6-32 x 3/4 Rd Hd (SST).........................................................................................3

7 00-075623 Damper - Vent Stack..................................................................................................................1

8 00-064919 Shaft - Damper...........................................................................................................................1

9 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................3

- 35 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

MISCELLANEOUS

(WASH/RINSE SECTION)

F-18366 Rev. B (February 2015) - 36 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

MISCELLANEOUS

(WASH/RINSE SECTION)

ILLUS.
PL-55263

10 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

11 00-436024 Plate - Junction Box Support......................................................................................................2

12 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................4

13 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

14 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

15 00-288465 Lid & Gasket Assy (Incls Item 16)..............................................................................................2

16 00-112007 Gasket........................................................................................................................................2

17 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T...............................................................8

18 00-271061 Support.......................................................................................................................................2

19 00-288946-2 Foot - Adjustable........................................................................................................................4

20 00-122577-2 Wire Tie......................................................................................................................................6

21 00-436941 Conduit - PVC (26 1/8 Door Height) (LH) (Electric and Steam Heat).........................................1

22 00-437131 Conduit - PVC (32 1/8 Door Height) (LH) (Electric and Steam Heat).........................................1

23 00-328470-1 Conduit - PVC (26 1/8 Door Height) (LH) (Gas Heat)................................................................1

24 00-328470-2 Conduit - PVC (32 1/8 Door Height) (LH) (Gas Heat)................................................................1

25 00-436037 Conduit - PVC (26 1/8 Door Height) (RH) (Electric and Steam Heat)........................................1

26 00-437130 Conduit - PVC (32 1/8 Door Height) (RH) (Electric and Steam Heat)........................................1

27 00-328469-1 Conduit - PVC (26 1/8 Door Height) (RH) (Gas Heat)................................................................1

28 00-328469-2 Conduit - PVC (32 1/8 Door Height) (RH) (Gas Heat)................................................................1

29 00-436888 Cover - Panel Notch...................................................................................................................2

30 SC-053-05 Mach Screw 10-24 x 3/8 Truss Hd, Slotted................................................................................2

31 WS-019-06 Washer.......................................................................................................................................2

32 NS-031-16 Stop Nut 10-24 "Elastic" (SST)...................................................................................................2

33 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

34 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

35 00-067500-31 "O" Ring......................................................................................................................................2

36 00-119254 Retainer - Cap............................................................................................................................2

37 00-119244 Cap & Stud Assy........................................................................................................................2

38 00-436031 Panel - Front Trim......................................................................................................................1

39 PB-004-08 Plug Button Heyco 2703..........................................................................................................AR

40 00-270923-4 Box - Junction (RH)....................................................................................................................1

41 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd................................................................................................2

42 WS-003-49 Washer (SST).............................................................................................................................2

43 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

44 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

45 SD-007-38 Self-Tapping Screw 8-18 x 1/4 Phil. Bndg. Hd., Type B.............................................................2

46 FE-008-44 Connector 45 Deg (3/4 Male Thd x 3/4 Thinwall).......................................................................1

47 FE-008-11 Gasket - Electrical......................................................................................................................1

48 FE-006-06 Lock Nut 3/4 ..............................................................................................................................1

49 FE-007-32 Connector - Conduit 3/4 TS........................................................................................................1

50 FE-009-07 Lock Nut 1 1/4............................................................................................................................4

51 00-294677-3 Clamp - Wire (3/4 ID)..............................................................................................................AR

52 NS-047-94 Lock Nut Special 3/16.............................................................................................................AR

53 00-270923-5 Box - Junction (LH).....................................................................................................................1

54 SC-041-05 Cap Screw 1/4 -20 x 5/8 Hex Hd................................................................................................2

55 WS-003-49 Washer (SST).............................................................................................................................2

PART NO. NAME OF PART AMT.

1 00-436032 Wireway - Horizontal..................................................................................................................1

2 WS-017-06 Washer (SST).............................................................................................................................4

3 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

4 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

5 00-271055 Wireway - Vertical......................................................................................................................1

6 SC-021-22 Mach Screw 10-24 x 3/8 Rd Hd (SST).......................................................................................1

7 WL-006-07 Lockwasher #10 Helical (SST)...................................................................................................1

8 WS-017-06 Washer (SST).............................................................................................................................2

9 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

- 37 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

MISCELLANEOUS

(WASH/RINSE SECTION)

ILLUS.
PL-55263

56 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

57 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

58 00-271057 Cap - Wireway............................................................................................................................2

59 SC-041-50 Cap Screw 1/4 -20 x 1/2 Hex Hd................................................................................................4

60 WS-022-01 Washer.......................................................................................................................................4

61 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

62 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

63 00-287625 Splash Shield.............................................................................................................................2

64 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

65 SC-053-02 Mach Screw 10-24 x 1/2 Truss Hd (SST)...................................................................................4

66 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................2

67 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

68 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

PART NO. NAME OF PART AMT.

F-18366 Rev. B (February 2015) - 38 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 39 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

LOW WATER PROTECTION

(STEAM HEAT/WASH & RINSE TANK)

F-18366 Rev. B (February 2015) - 40 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

LOW WATER PROTECTION

(STEAM HEAT/WASH & RINSE TANK)

ILLUS.
PL-50787

10 00-067500-72 "O" Ring......................................................................................................................................2

11 00-328472 Box - Steam Heat.......................................................................................................................2

12 WS-010-40 Washer - Thrust.......................................................................................................................AR

13 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)...........................................................................AR

14 NS-018-28 Jam Nut 1/2 -20 Hex Fin.........................................................................................................AR

15 00-288465 Lid & Gasket Assy (Incls Item 16)..............................................................................................2

16 00-112007 Gasket........................................................................................................................................2

17 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite"(1/2 Male Thd x 1/2 Flex Cnd)................................2

18 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite"(1/2 Male Thd x 1/2 Flex Cnd)................................1

19 FE-024-65 Connector 90 Deg (Non Metallic) "Sealtite"(1/2 Male Thd x 1/2 Flex Cnd)................................1

20 SD-012-20 Self-Tapping Screw 8-32 x 1/2 Phil Truss Hd, Type T...............................................................8

21 FE-024-67 Connector 90 Deg (Non Metallic) "Sealtite" (1 Male Thd x 1 Flex Cnd).....................................4

22 FE-008-12 Gasket........................................................................................................................................2

*23 00-119244-2 Cap..........................................................................................................................................AR

*24 00-067500-31 "O" Ring...................................................................................................................................AR

*25 WS-003-47 Washer (SST)..........................................................................................................................AR

*26 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

*27 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

PART NO. NAME OF PART AMT.

1 00-067500-72 "O" Ring...................................................................................................................................AR

2 00-271622 Probe & Switch Assy (2 Wire) (Water Level)...........................................................................AR

3 00-122674 Float Assy................................................................................................................................AR

4 00-112467 Retainer - Float........................................................................................................................AR

5 RR-010-13 Retaining Ring.........................................................................................................................AR

6 RR-010-13 Retaining Ring............................................................................................................................2

7 00-112467 Retainer - Float...........................................................................................................................2

8 00-271621 Probe & Switch Assy (4 Wire) (Temperature & Water Level).....................................................2

9 00-122674 Float Assy...................................................................................................................................2

00-294357-1 Connector................................................................................................................................AR

00-294357-2 Connector (Black)....................................................................................................................AR

00-065890-29 Connector - Insulated..............................................................................................................AR

* Use 1 set on CRS86A or CPW100A in place #1 thru 5 in wash tank & 1 set in

rinse tank on all units.

- 41 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

ELECTRIC HEAT

F-18366 Rev. B (February 2015) - 42 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

ELECTRIC HEAT

ILLUS.
PL-55290

10 00-435990-4 Heater - Tank Electric (15K W/Wash) (240 V., 50/60 Hz.) (1 Ph.).............................................1

11 00-435990-5 Heater - Tank Electric (15K W/Wash) (480 V., 60 Hz.) (3 Ph.)..................................................1

12 00-435990-6 Heater - Tank Electric (15K W/Wash) (380 V., 50 Hz.) (3 Ph.)..................................................1

13 00-271621 Switch & Probe Assy. (4-Wire) (Long)........................................................................................2

14 00-271622 Probe & Switch Assy. (2 Wire) (Water Level)..........................................................................AR

15 00-112467 Retainer- Float.........................................................................................................................AR

16 00-122674 Float Assy................................................................................................................................AR

17 WS-010-40 Washer - Thrust.......................................................................................................................AR

18 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)...........................................................................AR

19 NS-018-28 Jam Nut 1/2 -20 Hex Fin.........................................................................................................AR

20 00-067500-72 "O" Ring...................................................................................................................................AR

21 00-474512-3 Box - Electric Heat......................................................................................................................2

22 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd.........................................................................................12

23 WS-029-05 Washer (SST)...........................................................................................................................24

24 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................12

25 NS-015-11 Nut 5/16 -18 Hex......................................................................................................................12

26 00-271118-1 Plate - Mounting.........................................................................................................................2

27 00-271109 Gasket - Mounting......................................................................................................................2

28 00-474574-2 Lid & Gasket Assy. (Incls. Item 29)............................................................................................2

29 00-474569 Gasket (Lid)................................................................................................................................2

30 NS-031-15 Stop Nut 10-24 Hex (SST).......................................................................................................12

31 00-0271122 Bracket - Thermostat..................................................................................................................2

32 NS-031-15 Stop Nut 10-24 Hex (SST).........................................................................................................4

33 00-293946 Sleeve........................................................................................................................................2

34 00-271123 Protector - High Limit..................................................................................................................2

35 SC-021-08 Mach. Screw 6-32 x 3/8 Slotted Rd. Hd. (SST)..........................................................................4

36 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................4

*37 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

*38 NS-015-01 Nut 1/4 -20 Hex (SST).............................................................................................................AR

39 00-271168 Insulator - Terminal (Above 250 V.)...........................................................................................2

*40 00-119244-2 Cap..........................................................................................................................................AR

*41 00-067500-31 "O" Ring...................................................................................................................................AR

*42 WS-003-47 Washer (SST)..........................................................................................................................AR

43 SC-041-13 Cap Screw 5/16 -18 x 1 Hex Hd. (SST).....................................................................................4

44 WS-017-08 Washer (SST).............................................................................................................................4

45 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

46 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

47 RR-010-13 Retaining Ring.........................................................................................................................AR

48 FE-008-12 Gasket........................................................................................................................................2

49 FE-024-63 Connector 90 Deg. (Non Metallic) "Sealtite" (1 Male Thd. x 1 Flex. Cnd.).................................4

50 00-293598 Gasket - Heater Mounting..........................................................................................................2

PART NO. NAME OF PART AMT.

1 00-436907-1 Heater - Tank Electric (10K W/Rinse) (208 V., 60 Hz./200 V., 50 Hz.) (3 Ph.)..........................1

2 00-436907-2 Heater - Tank Electric (10K W/Rinse) (240 V., 50/60 Hz.) (3 Ph.).............................................1

3 00-436907-3 Heater - Tank Electric (10K W/Rinse) (208 V., 60 Hz./200 V., 50 Hz.) (1 Ph.)..........................1

4 00-436907-4 Heater - Tank Electric (10K W/Rinse) (240 V., 50/60 Hz.) (1 Ph.).............................................1

5 00-436907-5 Heater - Tank Electric (10K W/Rinse) (480 V., 60 Hz.) (3 Ph.)..................................................1

6 00-436907-6 Heater - Tank Electric (10K W/Rinse) (380 V., 50 Hz.) (3 Ph.)..................................................1

7 00-435990-1 Heater - Tank Electric (15K W/Wash) (208 V., 60 Hz./200 V., 50 Hz.) (3 Ph.)..........................1

8 00-435990-2 Heater - Tank Electric (15K W/Wash) (240 V., 50/60 Hz.) (3 Ph.).............................................1

9 00-435990-3 Heater - Tank Electric (15K W/Wash) (208 V., 60 Hz./200 V., 50 Hz.) (1 Ph.)..........................1

00-526454 Foam Tape..............................................................................................................................AR

00-545595 Sealer (1/8 Rd.).......................................................................................................................AR

00-294357-1 Connector................................................................................................................................AR

00-294357-2 Connector (Black)....................................................................................................................AR

00-065890-29 Connector - Insulated.................................................................................................................2

* Uses 1 set on CRS86A or CPW100A in place of #14 in wash tank & 1 set in

rinse tank on all units.

- 43 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

GAS HEAT BURNERS, FLUES, & WIREWAYS

F-18366 Rev. B (February 2015) - 44 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

GAS HEAT BURNERS, FLUES, & WIREWAYS

ILLUS.
PL-55291

10 FE-024-65 Connector 90 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)............................AR

11 FE-024-62 Connector - Conduit 3/4 (Non Metallic) "Sealtite"......................................................................2

12 FE-024-58 Connector Straight (Non Metallic) "Sealtite" (3/4 Male Thd x 3/4 Flex Cnd)..............................2

13 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)..............................1

14 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................1

15 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................4

16 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)..............................2

17 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................2

18 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)..............................2

19 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................2

20 00-328437 Cover - Wireway.........................................................................................................................2

21 WS-003-49 Washer (SST).............................................................................................................................2

22 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

23 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

24 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)..............................1

25 FE-024-65 Connector 90 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................1

26 PB-004-08 Plug Button Heyco 2703..........................................................................................................AR

27 WL-014-10 Lockwasher 1/4 External Shakeproof.........................................................................................1

28 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................1

29 00-328452-1 Cover - Wireway Channel (LH)..................................................................................................1

30 00-328452-2 Cover - Wireway Channel (RH)..................................................................................................1

31 SC-053-05 Mach Screw 10-24 x 3/8 Truss Hd, Slotted................................................................................4

32 00-328464 Channel - Wireway (LH).............................................................................................................1

33 FE-024-75 Bushing - Electrical Snap (1)......................................................................................................2

34 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)..............................2

35 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................2

36 00-436853 Ignitor Board 24 VAC.................................................................................................................2

37 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................8

38 00-271146-2 Cable - High Voltage..................................................................................................................2

39 00-328459 Cover - Ignitor Board..................................................................................................................2

40 SC-053-05 Mach Screw 10-24 x 3/8 Truss Hd, Slotted................................................................................2

41 00-294325-014-1 Block - Terminal.........................................................................................................................4

42 SC-021-15 Mach Screw 8-32 x 1/2 Rd Hd, Slotted......................................................................................8

43 00-328462-1 Bracket - Ignitor Board (LH).......................................................................................................1

44 00-328462-2 Bracket - Ignitor Board (RH).......................................................................................................1

45 SC-041-11 Cap Screw 5/16 -18 x 3/4 Hex Hd (SST)...................................................................................4

46 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

47 WS-017-01 Washer (SST).............................................................................................................................2

48 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................2

49 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................2

50 00-328455-1 Flue (LH)....................................................................................................................................1

51 00-328455-2 Flue (RH)....................................................................................................................................1

52 WS-003-49 Washer (SST)...........................................................................................................................10

53 WL-006-17 Lockwasher 1/4 Helical (SST)..................................................................................................10

54 NS-015-01 Nut 1/4 -20 Hex (SST)..............................................................................................................10

55 WS-003-49 Washer (SST).............................................................................................................................4

PART NO. NAME OF PART AMT.

1 00-328461 Channel - Wireway (RH)............................................................................................................1

2 SC-041-10 Cap Screw 5/16-18 x 5/8 Hex Hd...............................................................................................2

3 SC-041-11 Cap Screw 5/16-18 x 3/4 Hex Hd (SST)....................................................................................4

4 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................6

5 FE-024-58 Connector Straight (Non Metallic) "Sealtite" (3/4 Male Thd x 3/4 Flex Cnd)..............................2

6 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)..............................2

7 FE-024-61 Connector 45 Deg (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...............................2

8 FE-008-10 1/2 Gasket Assy.........................................................................................................................2

9 FE-024-57 Connector Straight (Non Metallic) "Sealtite" (1/2 Male Thd x 1/2 Flex Cnd)...........................AR

- 45 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

GAS HEAT BURNERS, FLUES, & WIREWAYS

ILLUS.
PL-55291

56 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

57 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

58 SC-053-02 Mach Screw 10-24 x 1/2 Truss Hd (SST).................................................................................10

59 00-328415 Liner - Shroud.............................................................................................................................2

60 00-328416 Insulation....................................................................................................................................2

61 00-328453-1 Shroud (LH)................................................................................................................................1

62 00-328453-2 Shroud (RH)...............................................................................................................................1

63 00-328454-1 Shroud Assy (LH) (Incls Items 58, 59, 60, & 61)........................................................................1

64 00-328454-2 Shroud Assy (RH) (Incls Items 48, 59, 60, & 62).......................................................................1

65 00-435952 Flange - Immersion Tube...........................................................................................................2

66 00-436100 Gasket........................................................................................................................................4

67 SC-121-43 Cap Screw 7/16 -14 x 1 3/4 Hex Hd.........................................................................................16

68 WS-021-07 Washer.....................................................................................................................................32

69 WL-019-77 Lockwasher 7/16 Medium........................................................................................................16

70 NS-047-97 Nut 7/16 -14 Hex......................................................................................................................16

71 00-328460-1 Tube - Immersion (LH)...............................................................................................................1

72 00-328460-2 Tube - Immersion (RH)...............................................................................................................1

PART NO. NAME OF PART AMT.

F-18366 Rev. B (February 2015) - 46 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 47 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

GAS HEAT COMPONENTS

F-18366 Rev. B (February 2015) - 48 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

GAS HEAT COMPONENTS

ILLUS.
PL-55292

*10 WL-006-17 Lockwasher 1/4 Helical (SST).................................................................................................AR

*11 NS-015-01 Nut 1/4-20 Hex (SST)..............................................................................................................AR

12 00-436792 Electrode Ignition - Natural Gas (Dim. 3 1/8) (Marked 665).......................................................2

13 00-436067 Electrode Ignition - L.P. Gas (Dim. 3 3/8) (Marked 662)............................................................2

14 SC-093-03 Mach. Screw 8-32 x 3/8 Slotted Pan Hd. (SST).........................................................................4

15 WL-014-05 Lockwasher #8 External Shakeproof (SST)...............................................................................4

16 00-435960-1 Plate Spacer...............................................................................................................................2

17 NS-018-28 Jam Nut 1/2-20 Hex (SST)......................................................................................................AR

18 WL-014-31 Lockwasher 1/2 External Shakeproof (SST)...........................................................................AR

19 WS-010-40 Washer - Thrust.......................................................................................................................AR

20 00-328649 Bracket - Orifice (Nat. Gas) (Shown) (Dim. 1/2) (Marked NAT).................................................2

21 00-436761 Bracket - Orifice (L.P. Gas) (Dim. 1/2) (Marked LP)...................................................................2

22 SC-121-43 Cap Screw 7/16 -14 x 1 3/4 Hex Hd.........................................................................................16

23 WS-021-07 Washer.....................................................................................................................................32

24 WL-019-77 Lockwasher 7/16 Medium........................................................................................................16

25 NS-047-97 Nut 7/16 -14 Hex......................................................................................................................16

26 00-328428 Plate - Adjusting.........................................................................................................................2

27 00-328427 Plate - Restrictor.........................................................................................................................2

28 00-328473 Gasket - Blower..........................................................................................................................2

29 00-328476-1 Blower - Motor............................................................................................................................2

30 SC-041-05 Cap Screw 1/4-20 x 5/8 Hex Hd.................................................................................................8

31 WL-014-10 Lockwasher 1/4 External Shakeproof.........................................................................................2

32 NS-031-21 Stop Nut - Special 1/4 -20 Hex...................................................................................................8

33 00-271122-2 Bracket - Thermostat..................................................................................................................2

34 SC-053-05 Mach. Screw 10-24 x 3/8 Slotted Truss Hd. (SST)....................................................................8

35 00-435701-3 Angle Fitting (Nat. Gas, 60 Hz.) #25 Drill (0.1495).....................................................................2

36 00-435701-4 Angle Fitting (Nat. Gas, 50 Hz.) #29 Drill (0.136).......................................................................2

37 00-435701-2 Angle Fitting (L.P. Gas 50/60 Hz.) #43 Drill (0.089)...................................................................2

38 00-271123 Protector - High Limit..................................................................................................................2

39 00-293946 Sleeve - Lead.............................................................................................................................2

40 SC-127-26 Mach. Screw 6-32 x 3/8 Phil. Rd. Hd. (SST)..............................................................................4

41 NS-031-50 Stop Nut 6-32 Hex (SST)...........................................................................................................4

42 00-328465 Box - Gas Heat (LH)...................................................................................................................1

43 00-328466 Box - Gas Heat (RH)..................................................................................................................1

44 00-087711-153-1 Switch - Limit..............................................................................................................................2

45 00-328508 Insulator - Switch........................................................................................................................2

46 00-328450 Plug - Rubber (Conduit).............................................................................................................8

47 00-328429 Gasket - Lid................................................................................................................................2

48 WS-019-06 Washer.......................................................................................................................................8

49 NS-031-16 Stop Nut 10-24 "Elastic" (SST)...................................................................................................8

50 00-435024 Eye.............................................................................................................................................2

51 00-328467-1 Lid - Gas Heat Box (Nat. Gas, 60 Hz.).......................................................................................2

52 00-328467-2 Lid - Gas Heat Box (Nat. Gas, 50 Hz.).......................................................................................2

53 00-328467-3 Lid - Gas Heat Box (L.P. Gas, 60 Hz.).......................................................................................2

54 00-328467-4 Lid - Gas Heat Box (L.P. Gas, 50 Hz.).......................................................................................2

55 00-328212 Bracket - Valve...........................................................................................................................2

PART NO. NAME OF PART AMT.

1 00-328495 Probe & Switch Assy(2 Wire)(Water Level)(Order 2 Jumper Wires # 328758).......................AR

2 00-271621 Switch & Probe Assy. (4-Wire) (Long)........................................................................................2

3 00-067500-72 "O" Ring...................................................................................................................................AR

4 00-112467 Retainer - Float........................................................................................................................AR

5 RR-010-13 Retaining Ring.........................................................................................................................AR

6 00-122674 Float Assy................................................................................................................................AR

*7 00-119244-2 Cap..........................................................................................................................................AR

*8 00-067500-31 "O" Ring...................................................................................................................................AR

*9 WS-003-47 Washer (SST)..........................................................................................................................AR

- 49 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

GAS HEAT COMPONENTS

ILLUS.
PL-55292

56 SC-041-10 Cap Screw 5/16-18 x 5/8 Hex Hd. (SST)...................................................................................4

57 WL-006-23 Lockwasher 5/16 Helical (SST)..................................................................................................4

58 NS-015-11 Nut 5/16 -18 Hex........................................................................................................................4

59 00-328440 Plate - Gas Line..........................................................................................................................2

60 SC-053-05 Mach. Screw 10-24 x 3/8 Slotted Truss Hd. (SST)....................................................................8

61 00-328425-2 Tube - Gas (LH Tank)................................................................................................................1

62 00-328425 Tube - Gas (RH Tank)................................................................................................................1

63 00-435702 Connector - Special....................................................................................................................2

64 00-328426-1 Gas Valve (Nat. Gas).................................................................................................................2

65 00-328426-2 Gas Valve (L.P. Gas, 60 Hz.).....................................................................................................2

66 00-328426-3 Gas Valve (L.P. Gas, 50 Hz.).....................................................................................................2

67 00-291988-3 Valve - Gas Cock.......................................................................................................................2

68 00-328421 Deflector - Flue...........................................................................................................................2

69 WS-003-49 Washer (SST).............................................................................................................................4

70 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................4

71 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................4

72 FP-035-94 Pipe 1/2 x 1 1/2 Lg. TBE............................................................................................................2

73 FP-019-33 Tee 3/4 x 3/4 x 1/2 Reducing.....................................................................................................1

74 FP-059-61 Pipe 1/2 x 1-1/4 TBE..................................................................................................................1

75 FP-022-11 Union - Pipe................................................................................................................................2

76 FP-059-61 Pipe 1/2 x 1-1/4 TBE..................................................................................................................2

77 FP-013-15 Elbow - Pipe 1/2 x 90 Deg..........................................................................................................2

78 FP-059-61 Pipe 1/2 x 1-1/4 TBE..................................................................................................................2

79 FP-059-61 Pipe 1/2 x 1-1/4 TBE..................................................................................................................1

80 FP-078-89 Elbow 3/4 NPT x 1/2 Reducing..................................................................................................1

81 FP-087-27 Nipple 3/4 x 61 TBE...................................................................................................................1

PART NO. NAME OF PART AMT.

00-294357-1 Connector...................................................................................................................................2

00-294357-2 Connector (Black).......................................................................................................................2

00-435538 Wire Harness - Ignitor Board......................................................................................................2

00-328758 Jumper Wire - Socket Type Connector (Use With Item 39).......................................................2

* Use 1 set on CCS,CRS86A/W or CPW100A/W in place of #1 in wash tank & 1

set in rinse tank on all units.

F-18366 Rev. B (February 2015) - 50 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 51 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM COILS

(2 UNITS REQD)

F-18366 Rev. B (February 2015) - 52 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM COILS

(2 UNITS REQD)

ILLUS.
PL-55264

10 FP-053-09 Lock Nut 3/4 NPSL Pipe (SST)..................................................................................................1

11 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

12 FP-059-64 Nipple 3/4 x 5 1/2 TBE...............................................................................................................1

13 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

14 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

15 00-118316 Steam Trap (0-20 PSI)...............................................................................................................1

16 00-118317 Steam Trap (21-50 PSI).............................................................................................................1

17 FP-052-09 Pipe Plug 3/4 Sq Hd (SST).........................................................................................................1

18 00-437158-1 Coil - Steam (LH Tank) (Shown)................................................................................................1

19 00-437158-2 Coil - Steam (RH Tank)..............................................................................................................1

20 FP-049-15 Elbow 3/4 x 90 Deg (SST)..........................................................................................................1

21 FP-054-44 Nipple 3/4 x 2 1/2 TBE (SST).....................................................................................................1

22 FP-087-11 Nipple 3/4 x 9 1/2 TBE (SST).....................................................................................................1

23 FP-049-15 Elbow 3/4 x 90 Deg (SST)..........................................................................................................1

24 FP-052-09 Pipe Plug 3/4 Sq Hd (SST).........................................................................................................1

25 FP-054-27 Nipple 3/4 x 1 3/8 TBE (SST).....................................................................................................1

26 FP-050-14 Union 3/4 (Grd Seat) (SST)........................................................................................................1

27 FP-054-27 Nipple 3/4 x 1 3/8 TBE (SST).....................................................................................................1

28 FP-049-15 Elbow 3/4 x 90 Deg (SST)..........................................................................................................1

29 FP-054-27 Nipple 3/4 x 1 3/8 TBE (SST).....................................................................................................1

PART NO. NAME OF PART AMT.

1 00-328823-1 Coil - Steam (LH Tank) (Shown)................................................................................................1

2 00-328823-2 Coil - Steam (RH Tank)..............................................................................................................1

3 FP-080-17 Pipe 3/4 x 2 TBE (1-1/2 RTOE) (SST).......................................................................................1

4 WS-013-45 Washer.......................................................................................................................................1

5 WS-013-45 Washer.......................................................................................................................................1

6 FP-053-09 Lock Nut 3/4 NPSL Pipe (SST)..................................................................................................1

7 FP-080-17 Pipe 3/4 x 2 TBE (1-1/2 RTOE) (SST).......................................................................................1

8 WS-013-45 Washer.......................................................................................................................................1

9 WS-013-45 Washer.......................................................................................................................................1

- 53 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM COIL PIPING

F-18366 Rev. B (February 2015) - 54 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM COIL PIPING

ILLUS.
PL-55266

10 FP-036-05 Nipple 3/4 x 3 TBE.....................................................................................................................1

11 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

12 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

13 00-270329-1 Solenoid Valve (120 V) (Incls Items 14 & 15).............................................................................1

14 00-270318-1 Coil - Solenoid Valve (120 V).....................................................................................................1

15 00-270336 Service Kit - Solenoid Valve.......................................................................................................1

16 FP-059-64 Nipple 3/4 x 5 1/2 TBE...............................................................................................................1

17 00-186922 Line Strainer (Incls Items 18, 19, & 20)......................................................................................1

18 00-186923 Plug - Branch..............................................................................................................................1

19 00-186924 Gasket - Branch Plug.................................................................................................................1

20 00-186925 Screen - Line Strainer................................................................................................................1

21 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

22 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

23 FP-036-05 Nipple 3/4 x 3 TBE.....................................................................................................................1

24 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

25 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

26 00-289783 Bracket - Pipe Support...............................................................................................................2

27 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

28 FP-036-95 Pipe 3/4 x 2 TBE........................................................................................................................1

29 FP-079-97 Elbow - Reducing 90 Deg 1 to 3/4..............................................................................................1

30 FP-075-90 Pipe 1 x 39-1/2 TBE...................................................................................................................1

31 SC-041-15 Cap Screw 5/16-18 x 1 1/4 Hex Hd..........................................................................................14

32 WS-017-08 Washer (SST)...........................................................................................................................28

33 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................14

34 NS-015-11 Nut 5/16-18 Hex (SST).............................................................................................................14

35 00-545595 Sealer (1/8 Rd)........................................................................................................................AR

36 00-328777 Plate - Inner................................................................................................................................2

37 00-435026 Gasket........................................................................................................................................2

38 00-271109 Gasket - Mounting......................................................................................................................2

39 00-328776 Plate - Outer...............................................................................................................................2

40 FP-019-76 Tee - Pipe 1 1/2 x 1 x 1..............................................................................................................1

41 FP-026-26 Bushing 1 to 3/4 ........................................................................................................................1

42 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

43 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

44 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

45 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

46 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

47 00-186922 Line Strainer (Incls Items 48, 49, & 50)......................................................................................1

48 00-186923 Plug - Branch..............................................................................................................................1

49 00-186924 Gasket - Branch Plug.................................................................................................................1

50 00-186925 Screen - Line Strainer................................................................................................................1

51 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

52 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

53 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

54 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

55 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

PART NO. NAME OF PART AMT.

1 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

2 FP-036-12 Nipple 3/4 x 7 3/4 TBE...............................................................................................................1

3 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

4 FP-036-05 Nipple 3/4 x 3 TBE.....................................................................................................................1

5 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

6 FP-036-03 Nipple 3/4 x 2 3/4 TBE...............................................................................................................1

7 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

8 FP-080-81 Nipple 3/4 x 8 1/4 TBE...............................................................................................................1

9 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

- 55 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM COIL PIPING

ILLUS.
PL-55266

56 00-270329-1 Solenoid Valve (120 V) (Incls Items 57 & 58).............................................................................1

57 00-270318-1 Coil - Solenoid Valve (120 V).....................................................................................................1

58 00-270336 Service Kit - Solenoid Valve.......................................................................................................1

59 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

60 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

61 FP-078-38 Nipple 3/4 x 3 3/4 TBE...............................................................................................................1

62 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

63 FP-036-05 Nipple 3/4 x 3 TBE.....................................................................................................................1

64 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

65 FP-036-12 Nipple 3/4 x 7 3/4 TBE...............................................................................................................1

66 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

PART NO. NAME OF PART AMT.

F-18366 Rev. B (February 2015) - 56 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 57 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM INJECTOR & PREVIOUS CONSTRUCTION STEAM COIL PIPING

F-18366 Rev. B (February 2015) - 58 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM INJECTOR & PREVIOUS CONSTRUCTION STEAM COIL PIPING

ILLUS.
PL-55265

10 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

11 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

12 00-270329-1 Solenoid Valve (120 V) (Incls Items 13 & 14).............................................................................1

13 00-270318-1 Coil - Solenoid Valve (120 V).....................................................................................................1

14 00-70336 Service Kit - Solenoid Valve.......................................................................................................1

15 FP-059-64 Nipple 3/4 x 5 1/2 TBE...............................................................................................................1

16 00-186922 Line Strainer (Incls Items 17, 18, & 19)......................................................................................1

17 00-186923 Plug - Branch..............................................................................................................................1

18 00-186924 Gasket - Branch Plug.................................................................................................................1

19 00-86925 Screen - Line Strainer................................................................................................................1

20 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

21 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

22 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

23 WL-006-17 Lockwasher 1/4 Helical (SST)....................................................................................................2

24 NS-015-01 Nut 1/4 -20 Hex (SST)................................................................................................................2

25 00-289783 Bracket - Pipe Support...............................................................................................................2

26 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

27 FP-036-95 Pipe 3/4 x 2 TBE........................................................................................................................1

28 FP-079-97 Elbow - Reducing 90 Deg 1 to 3/4..............................................................................................1

29 FP-075-90 Pipe 1 x 39-1/2 TBE...................................................................................................................1

30 SC-041-15 Cap Screw 5/16 -18 x 1 1/4 Hex Hd.........................................................................................14

31 WS-017-08 Washer (SST)...........................................................................................................................28

32 WL-006-23 Lockwasher 5/16 Helical (SST)................................................................................................14

33 NS-015-11 Nut 5/16 -18 Hex......................................................................................................................14

34 00-545595 Sealer......................................................................................................................................AR

35 00-435027 Plate...........................................................................................................................................2

36 00-435026 Gasket........................................................................................................................................2

37 00-271109 Gasket - Mounting......................................................................................................................2

38 00-271108 Plate - Mounting.........................................................................................................................2

39 FP-019-76 Tee-Pipe 1 1/2 x 1 x 1................................................................................................................1

40 FP-026-26 Bushing 1 to 3/4 ........................................................................................................................1

41 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

42 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

43 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

44 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

45 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

46 00-186922 Line Strainer (Incls Items 47, 48, & 49)......................................................................................1

47 00-186923 Plug - Branch..............................................................................................................................1

48 00-186924 Gasket - Branch Plug.................................................................................................................1

49 00-186925 Screen - Line Strainer................................................................................................................1

50 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

51 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

52 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

53 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

54 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

55 00-270329-1 Solenoid Valve (120 V) (Incls Items 56 & 57).............................................................................1

PART NO. NAME OF PART AMT.

1 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

2 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

3 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

4 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

5 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

6 00-074696 Check Valve (3/4).......................................................................................................................1

7 FP-036-95 Pipe 3/4 x 2 TBE........................................................................................................................1

8 FP-013-22 Elbow 3/4 x 90 Deg....................................................................................................................1

9 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

- 59 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM INJECTOR & PREVIOUS CONSTRUCTION STEAM COIL PIPING

ILLUS.
PL-55265

56 00-270318-1 Coil - Solenoid Valve (120 V).....................................................................................................1

57 00-270336 Service Kit - Solenoid Valve.......................................................................................................1

58 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

59 00-074696 Check Valve (3/4).......................................................................................................................1

60 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

61 FP-022-17 Union 3/4 (Grd Seat)..................................................................................................................1

62 FP-036-92 Nipple 3/4 x 1 3/8 TBE...............................................................................................................1

PART NO. NAME OF PART AMT.

F-18366 Rev. B (February 2015) - 60 -

NOTES

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

- 61 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM INJECTOR HEAT

(2 UNITS REQUIRED)

F-18366 Rev. B (February 2015) - 62 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

STEAM INJECTOR HEAT

(2 UNITS REQUIRED)

ILLUS.
PL-50790

PART NO. NAME OF PART AMT.

1 00-271110 Piping - Steam Injector (Incls. Items 2, 4, & 5)...........................................................................1

2 FP-085-05 Nipple 1 x 10 1/2 STOE (SST)...................................................................................................1

3 FP-080-22 Nipple 3 /4 x 6 1/4 Lg. (TBE) (SST)............................................................................................1

4 00-288671 Silent Water Heater Assy...........................................................................................................1

5 FP-054-44 Nipple 3/4 x 2 1/2 (TBE) (SST)...................................................................................................1

6 FP-049-15 Elbow 3/4 x 90 Deg. (SST).........................................................................................................1

00-546292 Sealer - Pipe............................................................................................................................AR

00-545595 Sealer (1/8 Rd)........................................................................................................................AR

- 63 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

DISH RACKS

F-18366 Rev. B (February 2015) - 64 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

DISH RACKS

ILLUS.
PL-50047

PART NO. NAME OF PART AMT.

1 00-315191 Rack - Peg (Packaged)..............................................................................................................1

2 00-315193 Rack - Combination (Packaged)................................................................................................1

00-295288 Peg Type Tray Rack (P1400) (Packaged).................................................................................1

00-276043 Rack Assy (250 Tx) (Tray & Bun Pans).....................................................................................1

- 65 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

TABLE LIMIT SWITCH

F-18366 Rev. B (February 2015) - 66 -

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

TABLE LIMIT SWITCH

ILLUS.
PL-53222

10 WS-023-06 Washer.......................................................................................................................................2

11 WL-006-06 Lockwasher 10 Light..................................................................................................................2

12 SC-053-02 Mach. Screw 10-24 x 1/2 Truss Hd. SST...................................................................................2

13 087326 Plate - Actuator...........................................................................................................................1

14 00-812936 Bracket - Interlock Switch...........................................................................................................1

15 FE-004-24 Cover - Junction Box..................................................................................................................1

16 FE-003-19 Box - Junction.............................................................................................................................1

17 SC-066-06 Mach. Screw 10-24 x 1/2 Phil. Truss Hd. (SST).........................................................................2

18 WL-006-06 Lockwasher 10 Light..................................................................................................................2

19 NS-011-18 Mach. Nut 10-24 Hex SST.........................................................................................................2

20 087332 Hinge Assy.................................................................................................................................1

PART NO. NAME OF PART AMT.

1 00-277559 Bracket.......................................................................................................................................1

2 00-064165-00003 Spring - Connection....................................................................................................................1

3 FE-006-37 Elbow 90 Deg.Short (1/2 Male Thd. x 1/2 Thinwall)...................................................................2

4 00-087711-060-1 Switch - Interlock........................................................................................................................1

5 SC-027-24 Mach. Screw 6-32 x 1-1/2 Slotted Rd. Hd. (Brass)....................................................................2

6 WS-002-06 Washer.......................................................................................................................................2

7 NS-010-06 Mach. Nut 6-32 Hex...................................................................................................................2

8 WL-014-03 Lockwasher 6 External Shakeproof............................................................................................2

9 00-081921 Mach. Screw 10-24 x 1/2 Trimmed Hex Hd...............................................................................2

078752-4 Retainer (7/16")..........................................................................................................................1

ML-103368-0000Z Table Limit Switch Assembly (Incls items 1 thru 20)..................................................................1

- 67 - F-18366 Rev. B (February 2015)

C64A (ML's - 103908, 103909) REPLACEMENT PARTS

FORM 18366 Rev. B FEBRUARY 2015 PRINTED IN U.S.A.