Harman Kardon HD-980-230 Service Manual

CONTENTS

harman/kardon Service Manual

HD 980/230

CD Player

BASIC SPECIFICATIONS 2 TROUBLESHOOTING GUIDE 3 PACKAGE LIST AND PARTS 4 EXPLODED VIEW 5 PARTS LIST 6

Released EU2009 Harman International Rev1, 05/2012 8500 Balboa Boulevard Northridge, Californi a 913 29

SEMICONDUCTOR PINOUTS 16 PCB DRAWINGS 30 BLOCK DIAGRAM 35 VERSION HISTORY 36 SCHEMATIC DIAGRAMS 37

Signal Format

Sampling Frequency 32 kHz to 96 kHz D/A Conversion Multibit Sigma-Delta modulator Oversampling 24-bit/176.4 kHz Sample Rate Convertor or

24-bit/96 kHz with HRS-Link, internal DAC.

Discrete Analog Output Section

Error Correction CIRC System Frequency Response 20 Hz – 20 kHz +0/-0.5 dB Total Harmonic Distortion (THD) <0,0009% @1 kHz Dynamic Range > 100 dB Signal-to-Noise Ratio > 110 dB Channel Separation > 100 dB Line-Output Level 2.0 V

General

Power Requirement 100-240 V 50/60 Hz Power Consumption <20 Watts (On)

<2 Watts (Standby)

Dimensions

Height 63mm Width 440mm Depth 332mm

Weight 3.8 kg

Depth measurement includes knobs, buttons and connection jacks. Height measurement includes feet and chassis. All features and specifications are subject to change without notice.

Harman Kardon is a registered trademark of Harman International Industries, Incorporated.

Technical Specifications

250 Crossways Park Drive, Woodbury, New York 11797 www.harmankardon.com Harman Consumer Group, Inc.: 2, route de Tours, 72500 Château-du-Loir, France © 2008 Harman Kardon, Incorporated Part 01.00.YS.SM1.E1798

harman/kardon

HD 980/230 Service Manual

Page 2 of 46

Troubleshooting Guide

ENGLISH

TROUBLE SHOOTING GUIDE

SYMPTOM

No lights on Front Panel

Remote does not appear to operate

Front panel lights, but CD does not play

Play indicator lights, but no sound is heard

Sound skips or stutters during play

Sound is continually distorted

ERROR lights up continuously

in the display

CAUSE

• No AC power

• Power Switch turned off

• Weak batteries

• Blocked sensor

• Disc upside down

• Poor connections

• Wrong source connected

• Disc may be damaged

• Surface vibrations

• Incorrect input

• Various

SOLUTION

• Make certain AC power cord is plugged into a live outlet.

• Turn on Power Switch.

• Install fresh batteries, observing polarity indications.

• Remove obstructions from the front panel sensor or connect a remote sensor to the

Remote In jack on the rear panel.

• Reload disc with label side facing up.

• Make certain connections are secure and made to the correct (e.g.,

CD) input.

• Select CD source on receiver or preamp.

• Try another disc.

• Isolate the unit from vibration by placing it on a firm surface or move it further away from speakers.

• Make certain that the analog

Audio Outputs ™ of the

CD player are connected to a line level audio input, NOT to a digital audio or phono input.

• Turn the unit off and on again. If the problem persists, turn the AC power to the CD player off and on.

harman/kardon

HD 980/230 Service Manual

Page 3 of 46

harman/kardon

HD 980/230 Service Manual

Page 4 of 46

harman/kardon

HD 980/230 Service Manual

Page 5 of 46

HD980 Component List

y

p

pp

(

)

(

)

harman/kardon

HD 980/230 Service Manual

Page 6 of 46

Serial No.: WA0034-01001~03440

01.00.SJ.HD980E003 plastic part HD980-Front panel HD980-RE01

01.00.SJ.HD980E004 plastic part HD980-Button I HD980-RE02

01.00.SJ.HD980E005 plastic part HD980-Button II HD980-RE03

01.00.SJ.HD980E006 plastic part

01.00.SJ.HD980E007 plastic part HD980-Lens HD980-RE05

01.00.SJ.HD980E008 VFD filter HD980-VFD filter HD980-RE06

01.00.SJ.HD980E009 plastic part HD980-Disc tray door HD980-RE07

HD980-Pedestal underla

HD980-RE04

01.00.SJ.HD980E010 plastic part

01.00.SJ.SK.E008 plastic part

0100WJTJHD980E001 Metals Part HD980-Chassis HD980-PT01 0100WJTJHD980E002 Metals Part HD980-Rear panel HD980-PT02 0100WJTJHD980E003 Metals Part HD980-Top cover HD980-PT03

0100WJTJHD980E004 Metals Part

0100WJTJHD980E005 Metals Part

0100WJTJHD980E006 Metals Part

01.00.WJ.TJ.E569 aluminium fastener

01.47.CNT.LJX7E768 Connect cable

01.47.CNT.ACX.E036 Connect cable

01.47.CNT.LJX3E037 Connect cable

01.47.CNT.LJX3E036 Connect cable

01.47.CNT.LJX7E612 Connect cable

01.47.CNT.LJX5E333 Connect cable

01.47.CNT.LJX5E334 Connect cable

01.47.CNT.LJX2E110 Connect cable

01.48.BPX.1.E189 flat cable

01.48.BPX.1.E045 flat cable 0.5*24P*180mmA

HD980-Power indicator lam 1000A-IR receiver

ort 5.5mm

su

HD980-Front panel bracket HD980-Aluminum veneer

HD980-Aluminum ally wrap for disc tray

ф3.5*40

2.54-3Y-3Y-220mm Be different side

Power cord with 300mm fixture (EU version

2.0-6Y-6Y-130mm

(Be different side)

UL20080 28AWG

2.0-5Y-5Y-240mm

(Be same side) (LG UL20080 28AWG

2.54-2.0-13Y-

240mm(Be same side 70mm(solder one end and grounding piece another end 80mm(solder one end and grounding piece another end

1.25-6Y-6Y-

180mm(Be same side

1.25*14P*100mmA(4/

8

shade

HD980-RE08

HD980-PT04

HD980-PT05

HD980-PT06

Connect Key board and SMPS board

Connect SMPS board and Rear panel

Connect Loader and Main board

Connect SMPS board and Main board

Connect Key board and SMPS board

Connect VFD board and Main board

Connect Key board and VFD board

Connect Main board and VFD board Connect Loarder and Main board

01.47.CNT.CTX.E027

01.15.JX.EDV34850 Loader DV34-850

Remot control transmission cable

φ3.5+φ3.5(single channel), black, 1.2m

SF-HD850G+DVDM06B

Part numbe

r

p

g

)

g

)

g

)

g

)

g

)

harman/kardon

HD 980/230 Service Manual

Page 7 of 46

01.00.FZ.QT.E409 PC piece HD980-H05

02.11HCD08M5563C01

02.15HCD08K5575C01

02.15HCD08K5576C01

02.19HCD06P1254C01

02.25.HD980

Description Specification Location.No. Note

Between Lens and

anel Main Board (semimanufactured Key Board (semimanufactured VFD Board (semimanufactured SMPS Board (semimanufactured Remote Control(manufactured

oods

Front

HCD08M-5563C01 2-layers

HCD08K-5575C01 2-layers

HCD08K-5576C01 2-layers

HCD06P-1254C01 1-layer

HD980

HD980 Component List for Main Board (5563C01)

R8 R9 R14 R26 R54

01.57.R.3.E000J Resistor, chip

01.57.R.3.E1R0J Resistor, chip

01.57.R.3.E220J Resistor, chip

01.57.R.3.E330J Resistor, chip

01.57.R.3.E470J Resistor, chip

01.57.R.3.E101J Resistor, chip

01.57.R.3.E241J Resistor, chip

01.57.R.3.E271J Resistor, chip

01.57.R.3.E391J Resistor, chip

01.57.R.3.E561J Resistor, chip

01.57.R.3.E102J Resistor, chip

01.57.R.3.E152J Resistor, chip

01.57.R.3.E202J Resistor, chip

01.57.R.3.E222J Resistor, chip

01.57.R.3.E472J Resistor, chip

01.57.R.3.E512J Resistor, chip

01.57.R.3.E622F Resistor, chip

01.57.R.3.E822F Resistor, chip

01.57.R.3.E103J Resistor, chip

01.57.R.3.E1182F Resistor, chip

01.57.R.3.E223J

01.57.R.3.E333J Resistor, chip

01.57.R.3.E473J Resistor, chip

01.57.R.3.E104J Resistor, chip

01.57.R.3.E105J Resistor, chip

01.57.R.4.E101F Resistor, chip

01.57.R.4.E331F Resistor, chip

01.57.R.4.E681F Resistor, chip

01.57.R.4.E202F Resistor, chip

Resistor, chip

0805-0Ω ±5%

0805-1Ω±5% 0805-22Ω±5% 0805-33Ω±5%

0805-47Ω±5%

0805-100Ω±5%

0805-240Ω±5% 0805-270Ω±5% 0805-390Ω±5% 0805-560Ω±5% 0805-1KΩ±5% 0805-1.5KΩ±5% 0805-2KΩ±5% 0805-2.2KΩ±5%

0805-4.7KΩ±5%

0805-5.1KΩ±5% 0805-6.2KΩ±1% 0805-8.2KΩ±1%

0805-10KΩ±5%

0805-11.8KΩ±1% 0805-22KΩ±5% 0805-33KΩ±5% 0805-47KΩ±5% 0805-100KΩ±5% 0805-1MΩ±5% 1206-100Ω±1%

1206-330Ω±1%

1206-680Ω±1% 1206-2KΩ±1%

R57 R60 R64 R71 R74 R79 R80 R85 R186 R67 R68 R69 R70

R27 R29 R121 R20 R114 R129 R130 R103 R104 R105 R107

R110 R111 R46 R47 R81 R84 R93 R94 R95 R123 R125 R43 R44 R96 R122

R137 R142 R97 R33 R49 R50 R12 R32 R112 R113 R52 R41 R21 R19 R62 R56 R58 R88 R17 R37 R42 R53 R115

R138 R145 R65 R22 R66 R63 (R5) R11 R15 (R16) R18 R34 R35 R36 R38 R39 R48 R72 R75 R77 R83 R86 R87 (R92) R108 R109 R116 R117 R118 R119 R120 R124 R140 R181 R182 R183 R185 R30 R28 R45 R55 R177 R180 R23 R24 R59 R61 R184 R73 R76 R78 R82 R51 R40 R154 R155 R170 R171 R147 R148 R152 R157 R161 R162 R163 R164 R168 R173 R178 R179 R150 R160 R166 R176 R153 R156 R169 R172

HD980 Component List for Main Board (5563C01)

p

harman/kardon

HD 980/230 Service Manual

Page 8 of 46

P/N Description Specification Location.No. Note

01.57.R.4.E272F Resistor, chip

01.57.R.4.E153F Resistor, chip

01.57.R.4.E473F Resistor, chip

01.57.R.4.E475J Resistor, chip

01.57.R.8.EP3304

01.54.CS.3E100N50V

01.54.CS.3E150N50V

01.54.CS.3E220N50V

01.54.CS.3E470N50V

01.54.CS.3E101N50V

01.54.CS.3E121N50V

01.54.CS.3E201N50V

01.54.CS.3E391N50V

01.54.CS.3E471N50V

01.54.CS.3E681N50V

01.54.CS.3E102X50V

01.54.CS.3E332X50V

01.54.CS.3E392X50V

01.54.CS.3E103X50V

01.54.CS.3E273Y50V

01.54.CS.3E473X50V

01.54.CS.3E104Y50V

Resistor, thick film chi

network Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi

Capacitor, multilayer ceramic, chip

1206-2.7KΩ±1%

1206-15KΩ±1%

1206-47KΩ±1% 1206-4.7MΩ±5%

0603-33Ω*4 ±5%

0805-10P NPO±5%/50V 0805-15P NPO±5%/50V 0805-22P NPO±5%/50V 0805-47P NPO±5%/50V 0805-100P NPO±5%/50V 0805-120P NPO±5%/50V 0805-200P NPO±5%/50V 0805-390P NPO±5%/50V 0805-470P NPO±5%/50V 0805-680P NPO±5%/50V 0805-102 X7R ±10%/50V 0805-332 X7R±10%/50V 0805-392 X7R±10%/50V 0805-103 X7R±10%/50V 0805-273 Y5V20+80%/50V 0805-473 X7R±10%/50V

0805-104 Y5V+8020%/50V

R151 R159 R167 R175 R89 R90 R91 R149 R165 R174 R158 R141 RN1 RN2 RN3 RN4 RN5 RN6 RN7

C85 C86 C87 C89

C26 C34

C113 C104

C20

C67 C69

C15

C21

C63 C62

C66 C65

C71

C23 C13

C16 C17 (C24)

C22

C14 C73 C74 C80

C19

C68

(C1) (C2) (C3) (C4) (C5) (C6) (C7) C8 (C9) (C10) C11 C12 C18 (C25) C27 C28 C30 C35 C38 C39 C40 C41 C42 C43 C44 C45 (C46) (C47) (C48) (C49) C50 C51 (C52) (C53) (C54) (C55) C56 C57 C58 C59 C60 C61 C64 C70 C72 (C76) C77 C79 C81 C82 (C83) C84 C90 C91 C92 C93 C107 C108 C109 C110 C111 C115 C116 C117

01.54.CS.3E105Y16V

01.54.CS.3E475Y16V

Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi

0805-105 Y5V20+80%/16V 0805-475 Y5V+8020%/16V

C32 C33 C36 C37 C78

C29 C31

HD980 Component List for Main Board (5563C01)

p

y

p

harman/kardon

HD 980/230 Service Manual

Page 9 of 46

P/N Description Specification Location.No. Note

01.54.CS.4E681N50V

01.54.CS.4E222X50V

01.34.CL.DE10U16VC

01.34.CLDE47U25VC1

Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, AL.electrol

Capacitor, AL.electrolytic

tic

1206-680P NPO±5%/50V 1206-222 X7R±10%/50V CD110-10UF/16V 5*11

CD110-47UF/25V 5*11

C102 C103 C112 C114

C105 C106

CE1

CE16 CE17 CE18 CE19 CE20 CE34 CE36 CE37 CE38 CE43 CE45 CE49

01.34.CLDE47U50VCD

01.34.CLDE100U10VD

01.34.CLDE220U10VD

01.13.L.L.S.E007

01.13.L.L.S.E362 Inductor,Weifengda WBR453232-220K-R L3

01.13.L.L.D.E081 Inductor WB1010-1 T1 DIP6 Coilcraft

01.13.L.Z.ESC100 Bead, chip,

01.41.D.PS.ELL4148 Diode LL4148 SMD

01.41.D.PSE30BQ040 Diode 30BQ040 SMD D2

01.41.D.WS.E6V2 Zener diode ZENER 6.2V 0.4W DZ1

01.42.Q.S.E123 MOSFET,DIODES BSS123 SMD MQ31 SOT-23

01.42.Q.S.E1035 Transistor,Panasonic 2SA1035 SMD

01.42.Q.S.EDTC343 Transistor,ROHM

01.42.Q.S.E2406 Transistor,Panasonic 2SC2406 SMD

01.42.Q.S.E1132 Transistor,ROHM 2SB1132 SMD Q1 Q2 MPT3

01.42.Q.S.E1664T Transistor,ROHM

01.42.Q.S.E3018 MOSFET,ROHM 2SK3018T106 SMD MQ9 MQ7 UMT3

01.42.Q.D.E8050 Transistor KTC8050-C/P DIP Q6 Q5 TO-92

01.42.Q.D.E8550 Transistor KTC8550-C/P DIP Q3 Q4 TO-92

01.00.JZ.E33868 Quartyz Crystal Unit

01.00.JZ.E225792 Crystal Oscillator 22.5792MHz/3.3V Y1

Capacitor, AL.electrolytic

Capacitor, AL.electrol Inductor, multilayer ceramic, chi

tic

CD110-47UF/50V

6.3*12

CD110-100UF/10V 5*12

CD110-220UF/10V 5*12

0805-10UH SMD L1 L2

1206-100Ω

DTC343TKT146 SMD

2SD1664T100R SMD

33.8688MHZ-49S20P

CE23 CE24 CE25 CE26 CE27 CE28 CE29 CE30 CE31 CE32 CE33

CE3 CE4 CE5 CE6 CE7 CE8 CE10 CE11 CE13 CE14 CE21 CE22 CE39 CE40 CE41 CE42 CE44 CE46 CE47 CE48 CE50 CE51 CE52 CE53 CE54 CE55 CE56 CE57

CE2 CE9 CE12 CE15

FB1 FB2 FB3 FB4 FB5 FB6 FB7 FB8 FB9 FB10 FB11 D1 D3 D4 D5 D6 D7 D8 D9 D10 D11 D12 D13 D14

Q11 Q12 Q13 Q15 Q18 Q21 Q22 Q24 Q27 Q30 Q32

Q17 Q26 SOT-23

Q14 Q16 Q19 Q20 Q23 Q25 Q28 Q29

Q10 Q8 MPT3

X1

DO-213AA

SMC Schottky diode 3A International Rectifier

SOT-23

HD980 Component List for Main Board (5563C01)

y

gg

p

g

r

g

r

p

r

g

j

harman/kardon

HD 980/230 Service Manual

Page 10 of 46

P/N Description Specification Location.No. Note

ADSP-

01.44.IC.S.EBF532S IC, ADI, Blackin DSP

01.46.IC.E7208G IC, Via, Servo chip VT7208, LQFP216 U1

01.46.ICEKH29LV040 IC, KH,Flash Memory

BF532SBSTZ400,LQ FP176

KH29LV040CQC70G, PLCC32

U6

U16

firmware burn-in; (Can be replaced by ATEML AT49BV040B70JU)

01.46.IC.E290011

0146ICHY57V641620E IC, Hynix, SDRAM

0146ICEM11B416256 IC, EliteMT, DRAM

01.44.IC.S.E5888

01.46.IC.E7414

01.46.IC.E74HCT245 IC,TI,TTL input buffer

01.44.IC.D.EPC817C

01.44.IC.S.E1117H IC, AAC, LDO

01.44.IC.S.E1117 IC, AAC, LDO

01.44.ICSEA11173V3 IC, AAC, LDO

01.44.IC.S.ELM393 IC, ST, Comparator LM393, SOP8 U11

01.44.IC.D.E7912

01.44.IC.D.E7812

01.46.IC.NJM5534

01.44.IC.S.E8740

01.44.IC.S.E9022

01.44.IC.S.E3522

01.43.E009

01.40.CON.DCZ.E121 Jack, IR in/out jack

01.40.CON.DCZ.E125

IC, AMIC, Flash memor

IC, Rohm, Actuator driver IC, Philips, Hex inverting Schmitt tri

IC, Sharp, Photoelectric Cou

IC, Fairchild, Voltage Re IC, Fairchild, Voltage Re IC, JRC, Operational am IC, Wolfsonw, DA converter IC, NS, Vacuum Fluorescent Display Filament Drive IC, AAT, Reset monitor Jack, Sharp, Fiber optic ouput jack with shutter

Jack, Coaxial output jack

er

ulato

lifie

AMIC A290011TL-70, PLCC32 HY57V641620ETP7,TSOP54 M11B416256A25J,SOJ40

BA5888FP, HSOP-28 U12

74HCT14D,SOIC14 U31 ;

SN74HCT245PWR,T SSOP20

PC817,DIP4 U23

ler

AZ1117H-5.0, SOT223 AZ1117H-ADJ, SOT223 AZ1117H-3.3, SOT223

L7912,TO-220 U10

L7812,TO-220 U8

NJM5534M,DMP8 U26 U28

WM8740SEDS, SSOP-28

LM9022, 8P, SO8 U13

AAT3522IGY-3.08200-T1, SOT-23

GP1FAV51TK0F JP1

SCJ351P00XS0B00 (BLACK), In-line Packa

AV1-8.4-6G JP2

e

U2 firmware burn-in

U30

U3

U14

U29

U7 U9

U4

U27

U5

JP4

Antiflaming,Oran ge, Gold-plated

ack

HD980 Component List for Main Board (5563C01)

p

y

ype)

p

harman/kardon

HD 980/230 Service Manual

Page 11 of 46

P/N Description Specification Location.No. Note

01.40.CON.DCZ.E046

01.40.CON.DPH.E024 Connector PH-5A CN3 Antiflaming

01.40.CON.DPH.E028 Connector PH-6A CN4 Antiflaming

01.40.CON.DPH.E047 Connector PH-13A CN1 Antiflaming

01.40.CON.S05.E007 FPC connector

0140CONS13FPC2.E00 FPC connector 1.25-14P CN6 Vertical Type

01.37.PCB.2.E5563C 5563C Main board 2-layers

Jack, Audio output jack

AV2-8.4-1G JP5

FPC-0.5-24P with u

ward touch

CN5 SMD

Antiflaming,Dow n red & up white, Gold-plated jack

HD980 Component List for Key Board (5575C01)

01.57.R.3.E000J Resistor, chip

01.57.R.3.E241J Resistor, chip

01.57.R.3.E471J Resistor, chip

01.57.R.3.E821J Resistor, chip

01.57.R.3.E472J Resistor, chip

01.57.R.3.E153J Resistor, chip

01.54.CS.3E220N50V

01.54.CS.3E104Y50V

01.54.CS.3E225Y16V

01.34.CL.DE47U16VB

01.34.CLDE100U10VB

01.41.D.PS.ELL4148 Diode LL4148 SMD D401

01.41.DFDE1L0392A2

01.42.Q.S.E8050 Transistor KTC8050 SMD Q402 SOT-23

01.42.Q.S.EC8550 Transistor KTC8550 SMD Q401 SOT-23

01.00.JZ.E04000 Quartyz Crystal Unit 4.000MHZ-49S-22P Y401

01.46.IC.E78P156 IC, ELAN, MCU

01.44.IC.D.E0038B IC, IR receiver HS0038B IR401

01.39.SW.QC.ED665A Touch switch 6*6*5(80g)

01.40CONS13AY1E011 Connector

01.40.CON.DTJ.E024 Connector TJC3-3A (CN404) Antiflaming

01.37.PCB.2.E5575C 5575C Key board 2-layers

Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, AL.electrol Capacitor, AL.electrol

LED, color is orange & white,DIP

tic

0805-0Ω ±5% 0805-240Ω±5% 0805-470Ω±5% 0805-820Ω±5%

0805-4.7KΩ±5%

0805-15KΩ±5% 0805-22P NPO±5%/50V 0805-104 Y5V+8020%/50V 0805-225 Y5V20+80%/16V CD11X-47UF/16V 5*7 CD11X-100UF/10V 5*7

1L0392A2W32CM00 2

EM78P156ELM,SOIC 18

1.25-6A(Horizontal T

R414 R415 R412 R404 R413 R402 R403 R406 R407

R408 R409 R410 R411 R401

C402 C403

C404 C405 C406

C401

CE402

CE401

LED401

U401 firmware burn-in

K401 K402 K403 K404 K405 K406 K407

(CN403) DIP

DIP

HD980 Component List for Key Board (5576C01)

P/N Description Specification Location.No. Note

01.57.R.3.E103J Resistor, chip

01.57.R.3.E203J Resistor, chip

01.54.CS.3E300N50V

01.54.CS.3E473X50V

01.54.CS.3E104Y50V

Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi Capacitor, multilayer ceramic, chi

0805-10KΩ±5% 0805-20KΩ±5%

0805-30P NPO±5%/50V 0805-473 X7R±10%/50V 0805-104 Y5V+8020%/50V

(R415) (R414)

(C411)

(C407) ( C415)

(C408 ) (C409)

HD980 Component List for Key Board (5576C01)

p

y

ype)

)

(

)

harman/kardon

HD 980/230 Service Manual

Page 12 of 46

P/N Description Specification Location.No. Note

01.54.CS.3E225Y16V

01.34.CL.DE47U16VB

01.41.D.PS.ELL4148 Diode LL4148 SMD (D402)

01.44.IC.S.E75711

01.16.E1302FA VFD VFD22-1302FA VFD401

01.39.SW.QC.ED665A Touch switch 6*6*5(80g) K408 DIP

01.40CONS13AY1E011 Connector

0140CONS13FPC2E002 FPC connector

01.37.PCB.2.E5576C 5576C VFD board 2-layers

Capacitor, multilayer ceramic, chi Capacitor, AL.electrol

IC, SANYO, VFD Driver

tic

0805-225 Y5V20+80%/16V CD11X-47UF/16V 5*7

LC75711NE,QFP64E (U402)

1.25-6A(Horizontal T

1.25-14P(Vertical Type and Single Contact

(C410)

(CE403)

(CN403) DIP

(CN401)

HD980 Component List for SMPS Board (1254C01)

01.57.R.C.ED100

01.57.R.C.ED470

01.57.R.C.ED101

01.57.R.C.ED221

01.57.R.C.ED681

01.57.R.C.ED102

01.57.R.C.ED222

01.57.R.C.ED512

01.57.R.C.ED103

01.57.R.C.ED473

01.57.R.C.EF683

01.57.R.C.EF364

01.57.R.C.ED105

01.57.R.R.E5D9 Thermistor NTC-5D-9 NTC

01.57.R.Y.E10K Varistor 10K.471 RV1

01.00.CDGYE104275V

01.00.CDGYE471400V

01.00.CDGYE102400V

01.00.CDCPE1031KV

01.00.CDDSE473/50V

FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM FIXED CARBON FILM

High-voltage metallized polyester film High-voltage metallized polyester film High-voltage metallized polyester film High-voltage metallized polyester film RADIAL LEADS MLCC

RT1/4W-10Ω

RT1/4W-47Ω

RT1/4W-100Ω

RT1/4W-220Ω

RT1/4W-680Ω

RT1/4W-1KΩ

RT1/4W-2.2KΩ

RT1/4W-5.1KΩ

RT1/4W-10KΩ

RT1/4W-47KΩ

RT1W-68KΩ 5%

RT1W-360KΩ

RT1/4W-1MΩ

104/275V X2(lead pitch: 15mm)

471/400V Y1(lead pitch:10mm)

102/400V Y1(lead pitch:10mm)

103/1KV(lead pitch:7.5mm)

473/50V X7R±10%

lead pitch:5.08mm

R4,R6

R21

R16

R13,R19,R20

R14

R26

R17,R18,R22

R23,R24,R25

R15

R5

R2

R3

R1

CX1

CY1,CY2

CY3

C1

C2,C13

HD980 Component List for SMPS Board (1254C01)

(

)

(

)

A

(

)

g

harman/kardon

HD 980/230 Service Manual

Page 13 of 46

P/N Description Specification Location.No. Note

01.00.CD.DS.E683

01.00.CD.DSE10450V

01.34.CLDE4U7160VD

01.34.CLDEH2U250VC

01.34.CLDEH47U25VD

01.34.CLDEH47U50VD

01.34.CLDE47U400VG

0134CLDE288100U25V

0134CLDE288220U16V

0134CLDE288220U25V

01.34CLDEH470U16VD

01.34CLDE1000U16VG

01.13.L.L.D.E090

01.13.L.L.D.E005 Bead, leaded fixed LH0810-20UH L6

01.13.L.L.D.E051 Bead, leaded fixed LH0608-22UH L3,L4,L5,L8

01.13.L.L.D.E086

01.41.D.PD.EIN4001 Diode IN4001,SOD81 D17

01.41.D.PD.EIN4007 Diode IN4007,SOD81 D1,D2,D3,D4

01.41.D.PD.EFR104 Diode

01.41.D.PD.EFR107 Diode

01.41.D.PD.EIN4148 Diode IN4148,DO-35 D14,D16,D18

01.41.D.PD.E21DQ10 Diode

01.41.D.PD.E31DQ06 Diode

01.41.D.PD.E1U08 Diode

01.41.D.WD.E16V Zener Diode 16V, In-line Package ZD1

01.41.D.WD.E18V Zener Diode 18V, In-line Package ZD2

01.42.Q.D.E5551 Transistor 2N5551,TO-92 Q1

01.42.Q.D.E8550 Transistor KTC8550-C/P,TO-92 Q3

01.42.Q.D.E9014 Transistor C9014,TO-92 Q2

RADIAL LEADS MLCC RADIAL LEADS MLCC

CAPACITOR,AL.ELE CTROLYTIC

Pulse transformer,Coilcraft

Common Mode Choke

683/50V X7R±10%

lead pitch:5.08mm

104/50V X7R±10%

lead pitch:5.08mm

CD288H-4.7UF/160V 8*12

CD288H-2.2UF/50V 5*11

KM470M025C110AP EC17,EC18

GF470M050E110A EC2

CD288H-47UF/400V 18*20

GF101M025E110A EC11,EC12

CD288H-220UF/16V

6.3*12

CD288H-220UF/25V 8*12

GF471M016F115A EC4

CD288H1000UF/16V 10*20

L520-10UH L7

LCL- ET20010

50MH

FR104, In-line Packa FR107, In-line Packa

21DQ10, In-line Packa 31DQ06, In-line Packa 1U08 , In-line Packa

e

C3

C10 C11 C12 C14 C15 C16

EC3

EC22

EC1

EC5,EC6,EC16,EC21

EC9,EC10,EC14,EC15

EC19,EC20

LF1 FLY, FuZhou

D6,D8,D10,D11,D13

D7

D12

D15

D5

CAPXON KF4R7M160F11 5 CAPXON GF2R2M050C11 0 CAPXON GF470M025C11 0 CAPXON GF470M050E11 0 CAPXON KM470M400K21 0 CAPXON GF101M025E11 0 CAPXON GF221M016E11 0 CAPXON GF221M025F11 5 CAPXON GF471M016F11 5 CAPXON GF102M015G16 0

HD980 Component List for SMPS Board (1254C01)

g

-

g

j

r

g

r

p

)

p

harman/kardon

HD 980/230 Service Manual

Page 14 of 46

P/N Description Specification Location.No. Note

01.44.IC.D.EMCR100

01.44.IC.D.E2659R IC, FAIRCHILD, FPS KA5M02659R, DIP8 IC1

01.44.IC.DEAZ431AZ

01.44.IC.D.EBA33

01.44.IC.D.ELM317T

01.44.IC.D.EL7805

01.44.IC.D.EPC817C

01.40.CON.DCZ.E131 Fuse Holder BLX-2A FU1 Antiflaming

01.38.FUSEDE1A250V Fuse T1A/250V FU1

01.13.L.R.E059

01.40.CON.DCZ.E129 Connector

01.40.CON.DTJ.E024 Connector TJC3-3A CN1 Antiflaming

01.40.CON.DTJ.E002 Connector TJC3-13A CN2 Antiflaming

01.00.WJ.TJ.E496 Radiator 12*16*23mm for IC3 Antiflaming

Silicon Controlled Rectifiers

IC, AAC, Adjustable Shunt Re IC, ROHM, Dropout Volta IC, NS, Positive

ustable Regulato

Ad IC, ST, Voltage Re IC, Sharp, Photoelectric Cou

Switching Power Transformer

ulator

e Regulator

ulato

ler

MCR100-6,TO-92 SC1

AZ431AZ-AE1TR, TO 92

BA33BCO,TO-220 IC6

LM317T, TO-220 IC5

L7805, TO-220 IC3

PC817, DIP4 PH1

BCK-EC2802 TR1 FLY, FuZhou

Vertical VH three holes two

ins(white

IC2

JP1 Antiflaming

01.00.WJ.QT.E041 3pins grounding piece M4 G1,G2,G3,G4

01.37.PCB.1.E1254C 1254C SMPS board 1-layer

HD980 Component List for Remote Control w/ Circuits Board(1782C)

P/N Descri

01.00.WJ.TH.E183

01.00.WJ.TH.E184

01.00.WJ.TH.E185

01.00.SJ.HD970E005

01.00.SJ.HD970E006

01.00.SJ.HD970E009

01.00.BP.QT.E085

01.00.BP.QT.E086

01.00.DD.QT.E012

01.00.DD.QT.E117

Anode Spring same as DVD25 Cathode Spring same as DVD25 Double role spring same as DVD25

Remote Control Top Case Remote Control Bottom Case

Cover for battery case RC indication plate (upper) HD980 RC indication plate (nether) HD980 RC conductive rubber (upper) same as HD950 RC conductive rubber (nether) same as HD970

tion Specification Location.No. Note

HD980 (tooling same as HD970) HD980 (tooling same as HD970) HD980 (tooling same as HD970)

01.57.R.4.E010J

01.57.R.3.E221J

01.54.CS.3.E101N

01.54.CS.3.E104Y

01.34.CLDE100U10VB

Resistor, chip 1Ω 1/6W 1206 5％ R1

Resistor, chip 220Ω 1/8W 0805 5％ R2 Capacitor, multilayer ceramic, chip Capacitor, multilayer ceramic, chip Capacitor,AL.electroly tic 100µF 10V 20％ C1 5*7

100PF 50V J NPO 0805 C3 C4

0.1μF 50V Z Y5V 0805 C2

HD980 Component List for Remote Control w/ Circuits Board(1782C)

p

harman/kardon

HD 980/230 Service Manual

Page 15 of 46

P/N Descri

IC, Princeton

01.44.IC.S.E970

01.41.D.PS.ELL4148

01.42.Q.S.E8050

01.41.D.FD.EHIR305

01.00.ZJ.TXQ.E009

01.00.FZ.ZZ.E009

02.25.HD9701782C

Technology Corp., IR encoder HD970, SMD U1

Diode LL4148, DO213AA Transistor,CHIP KTC8050, SOT-23 Q1

Transmitting diode

Ceramic Resonator Jumper 5mm J1 J2

1782C

tion Specification Location.No. Note

D1 D2 D3 D4 D5 D6 D7 D8

HIR305CAP, 2P, Inline Package LED Z455E, 2P, In-line Package X1

Remote control board(same as HD950)

ADSP-BF532SBSTZ400 LQFP176

harman/kardon

HD 980/230 Service Manual

Page 16 of 46

ADSP-BF531/ADSP-BF532

harman/kardon

HD 980/230 Service Manual

Page 17 of 46

Table 38. 176-Lead LQFP Pin Assignment (Numerically by Lead Number)

Lead No. Signal Lead No. Signal Lead No. Signal Lead No. Signal Lead No. Signal

1 GND 41 GND 81 TX 121 ADDR19 161 AMS0 2 GND 42 GND 82 RX 122 ADDR18 162 ARDY 3GND43GND83EMU 4VROUT144GND84TRST124 ADDR16 164 SA10 5 VROUT0 45 VDDEXT 85 TMS 125 ADDR15 165 SWE 6 VDDEXT 46 PF5 86 TDI 126 ADDR14 166 SCAS 7 GND 47 PF4 87 TDO 127 ADDR13 167 SRAS 8 GND 48 PF3 88 GND 128 GND 168 VDDINT 9 GND 49 PF2 89 GND 129 GND 169 CLKOUT 10 CLKIN 50 PF1 90 GND 130 GND 170 GND 11 XTAL 51 PF0 91 GND 131 GND 171 VDDEXT 12 VDDEXT 52 VDDINT 92 GND 132 GND 172 SMS 13 RESET 53 SCK 93 VDDEXT 133 GND 173 SCKE 14 NMI 54 MISO 94 TCK 134 VDDEXT 174 GND 15 GND 55 MOSI 95 BMODE1 135 ADDR12 175 GND 16 RTXO 56 GND 96 BMODE0 136 ADDR11 176 GND 17 RTXI 57 VDDEXT 97 GND 137 ADDR10 18 VDDRTC 58 DT1SEC 98 DATA15 138 ADDR9 19 GND 59 DT1PRI 99 DATA14 139 ADDR8 20 VDDEXT 60 TFS1 100 DATA13 140 ADDR7 21 PPI_CLK 61 TSCLK1 101 DATA12 141 ADDR6 22 PPI0 62 DR1SEC 102 DATA11 142 ADDR5 23 PPI1 63 DR1PRI 103 DATA10 143 VDDINT 24 PPI2 64 RFS1 104 DATA9 144 GND 25 VDDINT 65 RSCLK1 105 DATA8 145 VDDEXT 26 PPI3 66 VDDINT 106 GND 146 ADDR4 27 PF15 67 DT0SEC 107 VDDEXT 147 ADDR3 28 PF14 68 DT0PRI 108 DATA7 148 ADDR2 29 PF13 69 TFS0 109 DATA6 149 ADDR1 30 GND 70 GND 110 DATA5 150 ABE1 31 VDDEXT 71 VDDEXT 111 VDDINT 151 ABE0 32 PF12 72 TSCLK0 112 DATA4 152 AWE 33 PF11 73 DR0SEC 113 DATA3 153 ARE 34 PF10 74 DR0PRI 114 DATA2 154 AOE 35 PF9 75 RFS0 115 DATA1 155 GND 36 PF8 76 RSCLK0 116 DATA0 156 VDDEXT 37 PF7 77 TMR2 117 GND 157 VDDINT 38 PF6 78 TMR1 118 VDDEXT 158 AMS3 39 GND 79 TMR0 119 BG 159 AMS2 40 GND 80 VDDINT 120 BGH 160 AMS1

123 ADDR17 163 BR

Rev. D | Page 57 of 60 | August 2006

VT7208 LQFP 216

harman/kardon

HD 980/230 Service Manual

Page 18 of 46

KH29LV040CQC-70G PLCC-32

harman/kardon

HD 980/230 Service Manual

Page 19 of 46

A290011TL-70

PLCC-32

HY57V641620ETP-7 TSSOP-54

harman/kardon

HD 980/230 Service Manual

Page 20 of 46

M11B416256A SOJ-40

BA5888FP HSOP-28

harman/kardon

HD 980/230 Service Manual

Page 21 of 46

WM8740SEDS SSOP-28

SN74HCT245PWR TSSOP-20

harman/kardon

HD 980/230 Service Manual

Page 22 of 46

74HCT14D

SOIC14

NJM5534M DMP8

harman/kardon

HD 980/230 Service Manual

Page 23 of 46

LM393

SOP8

AZ1117-ADJ/3.3V/5V SOT-223

harman/kardon

HD 980/230 Service Manual

Page 24 of 46

LM9022 SOP8

EM78P156ELM-G SOIC18

harman/kardon

HD 980/230 Service Manual

Page 25 of 46

AAT3522 SOT-23

L7805/L7812 TO-220

harman/kardon

HD 980/230 Service Manual

Page 26 of 46

L7912

TO-220

BA33BCO TO-220

harman/kardon

HD 980/230 Service Manual

Page 27 of 46

LM317T

TO-220

KA5M02659R DIP8

harman/kardon

HD 980/230 Service Manual

Page 28 of 46

PC817

DIP4

AZ431AZ-ATRE1 TO-92

harman/kardon

HD 980/230 Service Manual

Page 29 of 46

LC75711NE

QFP64E

harman/kardon

HD 980/230 Service Manual

Page 30 of 46

harman/kardon

HD 980/230 Service Manual

Page 31 of 46

harman/kardon

HD 980/230 Service Manual

Page 32 of 46

harman/kardon

HD 980/230 Service Manual

Page 33 of 46

harman/kardon

HD 980/230 Service Manual

Page 34 of 46

D

harman/kardon

HD 980/230 Service Manual

Page 35 of 46

HD980 SMPS BOARD

C

High AC Voltage !

RV1

FNR10K471

!

CX1

!

104/~275V

R1

1M / 1/4W

!

T1AL125V(250V)

!

T1AL250V

ABOUT FUSE RATING:

T1AL250V

!

1

CY1

CY2

FU1

2

L

JP1

CON2-8 VH

AC Input

!

CAUTION:

RISK OF ELECTRIC SHOCK !

B

A

The Test Data Was Got By Playing a Commonly DVD Disk,

Note:

And It Was Only Provided For Reference.

1 2 3 4 56

1

N

471/~400V 471/~400V

EARTH

LF1

50mH

NTC

!

47uF/50V

EC2

CY3

!

102/~400V

D1-D4

IN4007

R3

1

360K / 1W

R6

10R

!

Drain GND

VCC

EC1

47u/400V

IC1 KA5L0365R

5

1

6

2

7

3

8

4

ZD1

16V

Q1

2N5551

ZD2

18V

High DC Voltage !

1

R2

68K/1W

D5

1U08

NC Drain

Drain

DrainFB

R4

10R

C2

473 / 25V

EC3

4.7uF/160V

R5

47K / 1/4W

C3

683 / 25V

D7

FR107

103/1KV

C1

D6

FR104

+5VSB

6

CN2

A +5V +5VSB

AGND

A +12V A -12V

AGND

D +5V D +5V

DGND

D +3.3V

DGND

M +5V

MGND/DGND

To MotherBoard

STANDBY +5VSB

DGND

CN1

D

C

B

A

REV 2.71254C

54321

2.2u/25V

20uH

IC3

LM7805

1

79L05(NC)

2

IC4

3

Vin

Vout

GND

EC6

2

1

3

Vin

Vout

GND

L4

EC10

EC12

Vout2Vin

ADJ

R13

1

220R

20uH

L5

IC5

LM317

3

R14

680R

L8

20uH

EC17

47u/25V

C14

104/25V

R25

5K1

2.2k

R22

R23

5K1

220u/16V

220u/16V(NC)

EC16

D14

EC18

EC8

220u/25V

100u/25V

D17

IN4001

C15

104/25V

Q3

8550

A +5V / 300mA

C10

104/25V

A -5V / 5.6mA

A+14.5V / 230mA

C11

104/25V

A-14.5V / 50mA

A +5V / 200mA (1A Max)

C12

104/25V

220u/10V

1N4148

R18

2.2K

DGNDDGND

+4.24V

1

Vin

BA033T

C13

473/25V

IC6

Vout

GND

2

R17

R26 1K

2.2K

EC21

+5.0V / 660 mA

+3.3V / 160mA

3

220u/10V

HD950 SMPS Schematic

L3

20uH

EC7

220u/16V(NC)

-7.5V / 5.6mA

+7.5V / 300mA

EC5

220u/16V

FR104

AGND

D8

EC4

470u/16V

D9

FR104(NC)

+14.5V / 230mA

FR104

D10

16

14

12

1

15

EC9

FR104

1N4148

R20

220R

DGND

EC11

EC14

C16

IC2

KA431

220u/25V

100u/25V

-14.5V / 50mA

220u/25V

R15

10K

EC19

1000u/16V

104/25V

L6

+7.5V / 200mA

20uH

EC15

220u/25V

SC1

MCR100-6

Q2

9014

R16

100R

EC22

L7

+5V / 660mA

10uH

EC20

1000u/16V

D16

1N4148

R21

47R

R24

5K1

14

AGND

DGND

13

D11

21DQ10

9

10

8

D12

RF104

D13

3

5

6

Imax=1.2A

11

7

PH1

!

10

DGND

PC817

G2G1

GND_WASHER

GND

R19

220R

G3 G4

D15

31DQ06

D18

5

harman/kardon

HD 980/230 Service Manual

Page 36 of 46

4

3

2

1

History

E E

D D

REV 1.0:

1.Make Pin1 of Y1 hang up.

2.Add R185 and C116, and both be valued "NA".

、

3.Add net mame "ATA_CS1#" "A[1..19]"

、

"VFD_STB"、"DATA/SDA"、"CLOCK/SCL"、"IR".

4.Delete net "MISO".

"ATA_CS0#"、"ATA_RDY"、"ATA_RST#"、"D[0..15]" and

5.Renamed net "CS_75710" as "CS_75711".

6.Connected Pin6 of T1 to "singal" net,and Connected Pin4 of T1 to "GND" net.

7.Delete U17A(74LCX125) and replace it with U15C(74LCX125).

8.Some Part Reference of components was changed, such as Capacitor, Electrolytic Capacitor, IC, connectors, MOSFET etc.

9.Deleted C49, and made pin4/pin5/pin6 of JP1 hung up.

REV 1.1:

1.Add R186,R187;

2.Connected PIN38 and PIN69 of U6;

3.Change Q3,Q4,Q5,Q6 into TO-92 Footprint;

4.Add TR1;

5.Change R56,R88 from 22K to 2.2K.

6.Change JP5.

C C

REV 1.2:

1.remove U15, U18, U19, U21, U22, U25;

2.R98, R99, R100, R101, R102, R128, R133, R136, R144, R132, R135, R143, R146, R126, R106, R127, R131, R134;

3.remove C95, C99, C100, C101;

4.connect MCLK_8740 to the oscillator at R129;

5.delete Isolation Transformer.

6.remove RJ45 connector.

7.Replace U15C with 74HCT14D.

8.Add C118, C119, C120, C121, C122, C123, and all Valued "NA".

9.Deleted C96, C97, C98, CE35, U24, and connected net "+3.3V" to L3.

B B

REV 1.3:

1.Add C124~C154;

2.Add D15

A A

5

4

3

2

Harman Kardon

Title

HD980 History

Size Document Number Rev

HD980

A3

Date: Sheet

drawn by

1

鄏

ABC PCB S Ch. du Saux 17 CH-1131 Tolochenaz

19Friday, September 19, 2008

of

l

5

harman/kardon

HD 980/230 Service Manual

Page 37 of 46

4

3

2

1

+12VA

E E

R151

R153

2K7

CE39

C110 100nF

CE44 100uF/10V

100uF/10V

+

1 2

+

1 2

CE40 100uF/10V

CE47 100uF/10V

+

1 2

+

1 2

CE48 100uF/10V

VoutL+

VoutL-

VmidL

ZERO

VoutR+

VoutR-

VmidR

FB11 100R

+

17 16

18

21

12 13

11

+5VA

CE42 100uF/10V

C108 100nF

+

1 2

C111 100nF

+

1 2

CE46 100uF/10V

+5VA

FB10 100R

CE41

100uF/10V

C107 100nF

D D

RST_8740#

DAC_LRCLK

DAC_BITCLK

DAC_SDATA

U27 WM8740SEDS

22

MCLK_8740

MUTE_8740#

25

23

R186 0R

+5VA

C C

B B

R187 NA

26 27 28

24

1 3 2

5

4

6

+

RST

LRCLK BITCLK SDATA

MCLK

MODE8X MUTE DIFFHW

CSBIWO

MISO/DM0 SCK/DM1 CS/I2S

MODE

12

81520

DVDD

DGND

71419

AVDD

AVDDL

AGND

AGNDL

1 2

9

AVDDR

AGNDR

10

2K

1%

R156 2K

1%

R169 2K

1%

R172 2K

1%

R159 2K7

1%

R167 2K7

1%

R175 2K7

1%

C102 680pF

NPO 5%

C103 680pF

NPO 5%

C112 680pF

NPO 5%

C114 680pF

NPO 5%

-12VA

+12VA

C118 NA

C119 NA

C121 NA

C122 NA

7

5

3

+

2

-

481

+12VA

-12VA

7

5

3

+

2

-

481

+12VA

+5VSTBY

R177 22K

R180 22K

23

MQ31 BSS123

R183 10K

1

A A

MUTE_OUT

1

R182 10K

E

Q30

B

2SA1035

C

2 3

R181 10K

1

R184 47K

E

Q32

B

2SA1035

C

2 3

-12VA

5

4

3

U26 NJM5534M

6

C104 22pF

U28 NJM5534M

6

C113 22pF

C109 100nF

C115 100nF

12

+

12

+

12

+

12

+

CE38 47uF/25V

2SA1035

R154 100R

1%

2SC2406

CE43

47uF/25V

CE45 47uF/25V

2SA1035

R170 100R

1%

2SC2406

CE49

47uF/25V

Q12

Q19

Q21

Q28

R147 330R

1%

E

1

B

C

2 3

R149 15K

1%

1

3 2

R161 330R

R163 330R

1%

E

1

B

C

2 3

R165 15K

1%

1

3 2

R178 330R

1%

1

Q16

2SC2406

1

Q25

2SC2406

1

B

R148 330R

1%

E

Q13

2SA1035

C

2 3

R150 680R

1%

E

Q15

2SA1035

C

2 3

3 2

R160 680R

1%

Q20 2SC2406

3 2

R162 330R

1%1%

R164 330R

1%

E

Q22

2SA1035

C

2 3

R166 680R

1%

E

Q24

2SA1035

C

2 3

3 2

R176 680R

1%

Q29 2SC2406

3 2

R179 330R

1%

Q14

1

2SC2406

3 2

TP29

R152 330R

1%

R157 330R

1%

E

Q18

1

B

2SA1035

C

2 3

Q23

1

2SC2406

R155 100R

1%

C120

JP5

3

1

C105

2.2nF

NA

NPO 5%

R158 47K

2

1%

C

4.7K

BE

1

Q17 DTC343TK

3

1

2

AV2-8.4-1G

3 2

TP30

R168 330R

1%

R173 330R

1%

E

Q27

1

B

2SA1035

C

2 3

R171 100R

1%

C106

C123

2.2nF

NA

NPO 5%

Title

Size Document Number Rev

2

Date: Sheet

R174 47K

1%

Harman Kardon

2

C

4.7K

BE

1

Q26 DTC343TK

3

drawn by

ABC PCB S Ch. du Saux 17 CH-1131 Tolochenaz

HD980 main board

5563C 1.3

A3

29Friday, September 19, 2008

1

鄏

l

of

5

harman/kardon

HD 980/230 Service Manual

Page 38 of 46

E E

D D

4

U31A 74HCT14D

SPDIF_OUT

1 2

U31D 74HCT14D

U31E 74HCT14D

89

U31F 74HCT14D

1011

3

U31B 74HCT14D

U31C 74HCT14D

5 6

+5V

147

13 12

43

C90 100nF

C91 100nF

+5V

R122 240R

47uF/25V

2

FB9 100R

CE34

TP26

R125 100R

R123 100R

1

JP2 AV1-8.4-6G

T1 WB1010-1

C92 100nF

12

+

C93 100nF

TP27

SIG

2

16

GND

1

34

3

2 1

R124 10K

JP1 VST5G

GND

VCC IN

TOP VIEW

SPDIF

456

L3 22uH

C C

B B

JP4 SCJ35PP00XS0B00

IN

OUT

PHONEJACK DUAL

A A

1

2 3

4

5 6

+3.3V

R137 270R

5

1 4

2

CE36 47uF/25V

U23 PC817

R141 4M7

R142 390R

12

+

3

1 4

C117 100nF

2 3

Q11

R145

2SA1035

4K7

Y1

22.5792MHz/3.3V

OUTVCC

NC GND

R138 4K7

1

B

E

C

12

R139 NA

+

CE37 47uF/25V

58

D14 LL4148

12

4

R129 33R

R130 33R

REMOTE_IR

R140 10K

+5VSTBY

MCLK_8740

MCLK_DSP

Harman Kardon

Title

HD980 main board

Size Document Number Rev

5563C 1.3

A3

3

2

Date: Sheet

39Friday, September 19, 2008

1

5

harman/kardon

HD 980/230 Service Manual

Page 39 of 46

RX_BITCLK

RX_LRCLK

E E

DAC_BITCLK

DAC_LRCLK

DAC_SDATA

SPDIF_OUT

D D

DRST#

DD[0..15]

C C

ATAPI BUS

DIOWR#

DIORD#

B B

IORDY

DA1

DA0

DA2 CS1FX# CS3FX#

C85 10pF

C86 10pF

C87 10pF

DD7 DD8 DD6 DD9

DD5 DD10 DD4 DD11

DD12

DD13

DD1 DD14 DD0 DD15

C88 NA

RX_SDATA

TP22

TP24

TP23

TP25

SCK

MOSI

R113 1K

R112 1K

R114 33R

RN2 4*33R

RN3 4*33R

RN4 4*33R

RN5 4*33R

RN6 4*33R

RN7 4*33R

C89 10pF

R103 47R R104 47R R105 47R

R107 47R

R110 47R R111 47R

D7

18

D8

27

D6

36

D9

45

D5

18

D10

27

D4

36

D11

45

D3DD3

18

D12

27

D2DD2

36

D13

45

D1

18

D14

27

D0

36

D15

45

18 27 36 45

4

ATA_RST#

D[0..15]

TP19

TP20

+3.3V

TP21

R115 4K7

U6B ADSP-BF532SBSTZ400

76

RSCLK0

75

RFS0

74

DR0PRI

73

DR0SEC

72

TSCLK0

69

TFS0

68

DT0PRI

67

DT0SEC

65

RSCLK1

64

RFS1

63

DR1PRI

62

DR1SEC

61

TSCLK1

60

TFS1

59

DT1PRI

58

DT1SEC

53

SCK

55

MOSI

54

MISO

82

RX

81

TX

R118 10K

R120 10K

R116 10K

R119 10K

R117 10K

A2

A1 A3

PF1/SPISEL1/TMRCLK

PF2/SPISEL2

PF3/SPISEL3/PPI_FS3

PF4/SPISEL4/PPI15 PF5/SPISEL5/PPI14 PF6/SPISEL6/PPI13 PF7/SPISEL7/PPI12

TMR1/PPI_FS1 TMR2/PPI_FS2

A[1..19]

PF0/SPISS

PF8/PPI11 PF9/PPI10 PF10/PPI9 PF11/PPI8 PF12/PPI7 PF13/PPI6 PF14/PPI5 PF15/PPI4

PPI0 PPI1 PPI2 PPI3

PPI_CLK

TMR0

51 50 49 48 47 46 38 37 36 35 34 33 32 29 28 27

22 23 24 26

21

79 78 77

SDQM0 SDQM1

CS_FLASH#

ATA_CS1# ATA_CS0#

OE_FLASH#

RE# WE#

ATA_RDY

+3.3V

D0 D1 D2 D3 D4 D5 D6 D7

D9 D10 D11

D13 D14 D15

IR_IN

3

U6A ADSP-BF532SBSTZ400

116

D0

115

D1

114

D2

113

D3

112

D4

110

D5

109

D6

108

D7

105

D8

104

D9

103

D10

102

D11

101

D12

100

D13

99

D14

98

D15

151

ABE0/SDQM0

150

ABE1/SDQM1

161

AMS0

160

AMS1

159

AMS2

158

AMS3

154

AOE

153

ARE

152

AWE

162

ARDY

163

BR

119

BG

120

BGH

14

NMI

96

BMODE0

95

BMODE1

+3.3V

R108 10K

R109 10K

CLKOUT

RESET

A10 A11 A12 A13 A14 A15 A16 A17 A18 A19

SCKE

SMS SRAS SCAS

SWE

SA10

CLKIN

XTALO

RTXI

RTXO

MUTE_8740# RST_8740#

CS_75711

MUTE_OUT

13

149

A1

148

A2

147

A3

146

A4

142

A5

141

A6

140

A7

139

A8

138

A9

137 136 135 127 126 125 124 123 122 121

169 173

172 167 166 165 164

10 11

17 16

RST#

A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19

R121 22R

MCLK_DSP

2

+3.3V

C82 100nF

12

+

CE50

100uF/10V

A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12

3

A1 A14 A15 A16 A17 A18 A19

A1 A2 A3 D2 A4 A5 A6 A7 A8 A9 A10

A12 A18 A19

SDQM0 SDQM1

12 11 10

9 8 7 6

5 27 26 23 25

4 28 29

3

2 30

1

32

A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18

16

U30 HY57V641620ETP-7

23

A0

24

A1

25

A2

26

A3

29

A4

30

A5

31

A6

32

A7

33

A8

34

A9

22

A10/AP

35

A11

20

BA0/A13

21

BA1/A12

38

CLK

37

CKE

19

CS

18

RAS

17

CAS

16

WE

15

DQML

39

DQMH

36

NC1

40

NC2

54

VSS

41

VSS

28

VSS

U16 KH29LV040CQC-70G

13

VCC

I/O0

14

I/O1

15

I/O2

17

I/O3

18

I/O4

19

I/O5

20

I/O6

21

I/O7

24

OE

31

WE

22

CE

GND

DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8

DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15

VCC

VCCQ VCCQ VCCQ VCCQ

VSSQ VSSQ VSSQ VSSQ

D0 D1 D2 D3 D4 D5 D6 D7

OE_FLASH# WE# CS_FLASH#

2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53

1 14 27

3 9 43 49

6 12 46 52

D0 D1D8

D3 D4 D5D12 D6 D7 D8 D9 D10 D11 D12 D13 D14 D15

+3.3V

C84 100nF

C83 100nF

1

A A

C142 100nF

C143 100nF

5

C144 100nF

C146 100nF

4

3

C154 100nF

C153 100nF

C151 100nF

C150 100nF

C148 100nF

C147 100nF

C149 100nF

C152 100nF

C145 100nF

2

Harman Kardon

Title

HD980 main board

Size Document Number Rev

5563C 1.3

A3

Date: Sheet

drawn by

1

鄏

ABC PCB S Ch. du Saux 17 CH-1131 Tolochenaz

49Friday, September 19, 2008

of

l

5

harman/kardon

HD 980/230 Service Manual

Page 40 of 46

E E

+5V_VFD

U13

C80 10nF

1 2

4

LM9022

SN SYS

-IN

VO2 GND

VDD+IN

VO1

8 7

63

5

D D

C C

R83 10K

R86 10K

R87 10K

C78 1uF

R88

2.2K

C79 100nF

4

CE25 47uF/50V

D6

LL4148

12

+

CE26 47uF/50V

1 2

D7

LL4148

12

+

CE27 47uF/50V

1 2

D8 LL4148

1 2

D5

LL4148

-29V

12

+

1 2

-26V

3

12

+

CE28 47uF/50V

1 2

D9

LL4148

12

+

CE29 47uF/50V

1 2

D10 LL4148

12

+

CE30 47uF/50V

1 2

D11 LL4148

12

+

CE31 47uF/50V

1 2

D12 LL4148

R80 0R

R85 0R

12

+

CE32 47uF/50V

1 2

D13 LL4148

2

CE23 47uF/50V

+

1 2

R82 100K

CE24 47uF/50V

+

1 2

47uF/50V

R81 100R

CE33

DZ1 ZENER 6.2V 0.4W

R84 100R

+

1 2

R89 15K

1

AC1

12

AC2

R91

R90

15K

D5V

CE51 100uF/10V

+

1 2

C81 100nF

U14 SN74HCT245PWR

19

G3

1

3EN1[BA] 3EN2[AB]

2

1

3 4 5 6 7 8 9 11

2

20

10

18

17 16 15 14 13 12

IR_IN

R97 390R

R93 100R R94 100R R95 100R

R96 240R

3

REMOTE_IR

VFD_STB DATA/SDA

D5V

CLOCK/SCL

IR

MOSI

SCK

R92 10K

+3.3V

4

B B

CS_75711

A A

5

CN6 CON14_1.25MM_DIP_2

14

13

12

11

10

9

8

7

6

5

4

3

2

1

SPI pull-up resistors assembled on front board

2

鄏

l

ABC PCB S Ch. du Saux 17

1

drawn by

CH-1131 Tolochenaz

59Friday, September 19, 2008

of

Harman Kardon

Title

HD980 main board

Size Document Number Rev

A3

5563C 1.3

Date: Sheet

5

harman/kardon

HD 980/230 Service Manual

Page 41 of 46

D D

4

3

2

1

VR_CD

MQ7

23

D

2SK3018

G

R78 100K

1

MQ9 2SK3018

G

1

A5V

R72 10K

R75

Q8

10K

2SD1664

1

0

CD

VR_CD

GIO6

1

VR_DVD

C C

GIO6

CD_DVD DVD

VR

R73 100K

A5V

3 2

R76 100K

R77 10K

Q10

1

2SD1664

3 2

D3 LL4148

S

1 2

R71 0R

CD_DVD

VR_DVD

23

D

D4 LL4148

S

1 2

R79 0R

P1

A5V

For PUH ViewFor PCB View

CN5 CON24_0.5MM

25 26

P24

B B

C76 100nF

24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

VRA

C77 100nF

R74 0R

A5V

VRA

TP15 TP17

TP16

CN7 CON2_2.0MM_DIP

2 1

TP18

RF01

VR_DVD VR_CD

F

E A D RF CD_DVD C B TR+ TRF+ F-

LDODVD

MDI LDOCD

F

E A D RF

C B TR+ TRF+ F-

This connector support SF-HD850G

A A

Harman Kardon

Title

HD980 main board

Size Document Number Rev

5563C 1.3

B

5

4

3

2

Date: Sheet

drawn by

1

ABC PCB S

鄏

Ch. du Saux 17 CH-1131 Tolochenaz

of

69Friday, September 19, 2008

l

5

harman/kardon

HD 980/230 Service Manual

Page 42 of 46

PVCC

CE22

D15 SS14

1 2

R44 240R

LOAD-

R49 560R

PVCC

12

+

C72 100nF

2

C62 390pF

FOO

FMO

F-

F+

C61 100nF

Q4 8550

8050

13

E

C

R43 240R

1 3

R56

2.2K

R62 2K2

F-

F+

13

E

Q3

B

8550

C

Q5 8050

1 3

CE21

100uF/10V

PVCC

12

+

C60 100nF

R46 100R Q6

470uF/16V

5

D D

C C

B B

A A

4

2

B

LOAD+

R47 100R

2

R50 560R

VRD

C65

470pF

VRD

C68 47nF

change from 2.2k

SLED-

SLED+

4

C63 390pF

FOFO1

FMSO1

R57 0R

R63 8K2

INTRAYOUTTRAY

Replace the BA6208

R66 8K2

C71 680pF

VRD

C64 100nF

R59 47K

C67 100pF

R67 1R R69 1R

C73 10nF

VRD

PVCC

SPIN+

R39 10K

R41 1K5

R45 22K

SPIN-

R48 10K

R52 1K5

R55 22K

1

2

3

4

5

6

7

8

9

10

11

12

13

14

3

U12 BA5888FP

VINFC

CFCERR1

CFCERR2

VINSL+

VINSL-

VOSL

VNFFC

VCC

PVCC1

PGND

VOSL-

VOSL+

VOFC-

VOFC+

3

GND

29

CTKERR1

CTKERR2

GND

30

R40 1M

3

2

R51 1M

5

6

STBY

BIAS

VINTK

VINLD

PREGND

PVCC2

VNFTK

PGND

VOLD-

VOLD+

VOTK-

VOTK+

D5V

+

-

+

-

28

27

26

25

24

23

22

21

20

19

18

17

16

15

8 4

U11A LM393

U11B LM393

1

C59 100nF

7

DMOEN

VRD

R60 0R

R61 47K

C69 100pF

PVCC

R68 1R R70 1R

R64 0R

C74 10nF

D5V

R42 4K7

R53 4K7

TOSO1

DMO1

GIO5

GIO4

VRD

SPIN-

SPIN+

TR-

TR+

2

C66 470pF

C70 100nF

CN3 CON5_2.0MM_DIP

1 2 3 4 5

LOADLOAD+

TRAYOUT#

TRAYIN#

C116 NA

This connector support SF-HD850

CN4

R58 2K2

R65 5K1

TRO

DMO

TR-

TR+

CON6_2.0MM_DIP

1 2 3 4 5 6

R54 0R

SPINSPIN+

LIMIT#

SLED+ SLED-

Harman Kardon

Title

HD980 main board

Size Document Number Rev

5563C 1.3

A3

Date: Sheet

1

drawn by

ABC PCB S鄏l Ch. du Saux 17 CH-1131 Tolochenaz

79Friday, September 19, 2008

of

5

harman/kardon

HD 980/230 Service Manual

Page 43 of 46

4

3

2

1

VT7208 RAM

220uF/10V

12

+

FB2 100R

CE2

PVCC

D+3.3V

A+14.5V

TP1

C51 100nF

CE17

47uF/25V

12

+

FB7 100R

CE12

220uF/10V

12

+

C38 100nF

D5V

TP10

12

C57 100nF

FB3 100R

CE5

100uF/10V

FB6 100R

CE10

100uF/10V

DSP & PERIPH.

+3.3V

C50

+

100nF

U8 KA7812

1 3

Vin Vout

PUH & ALPC BJT

TP3

A5V

12

+

C40 100nF

VFD DRIVER

TP8

+5V_VFD

12

+

C44 100nF

12

+

CE13

100uF/10V

TP12

GND

2

47uF/25V

OP-AMPS

CE18

CE3

100uF/10V

CE7

100uF/10V

D2 30BQ040

U7 AZ1117-ADJ

1

+12VA

12

C56 100nF

+

U4 AZ1117H-3.3

U9 AZ1117-ADJ

TP9

OUTIN

ADJ

1

ADJ

1

12

+

12

+

DSP CORE

4

TAB

23

OUTIN

ADJ

C124 100nF

U29 AZ1117H-5.0

CN1 CON13_2.0MM_DIP

1 2 3

A+5V

4 5 6 7 8 9 10 11 12 13

FB5 100R

220uF/10V

LOCATION-PAD for the board

M1

VIA_PAD4.0

VIA3 VIA_PAD4.0

E E

D D

C C

B B

MASTER CLOCK

TP7

12

CE9

+

1

1 2 3 4 5 6

789

1 2 3 4 5 6

789

A+5V +5VSTBY

A+14.5V A-14.5V

D+5V

D+3.3V

M+5V

+5V

M2

C43 100nF

1

VIA2 VIA_PAD4.0

VIA4 VIA_PAD4.0

D+5V

MOTOR CONTROL

TP11 FB8 100R

M+5V

CE15

220uF/10V

M3

1

1 2 3 4 5 6

789

1 2 3 4 5 6

789

TAB

+1.2V

ADJ

1

TAB

OUTIN

C45 100nF

12

+

OUTIN

4 23

CE14 100uF/10V

TAB

4 23

TP2

TP5

CE16

47uF/25V

R32 1K

R33 560R

100uF/10V

TP13

12

+

FB4 100R

CE4

CE6

CE8

12

TP4

12

WM8740

+5VA

+

2.0V

+

VCC3

VT7208 I/O

C39 100nF

3.3VA

C41 100nF

VDD

VT7208 CORE

C42 100nF

VT7208 CKT

C127 100nF

+3.3V

C129 100nF

+3.3V

R38 10K

C131 100nF

+3.3V

+1.2V

C132 100nF

U5

AAT3522

CE11 100uF/10V

R34 10K

R35 10KVIA1 R36 10K R37 4K7

CN2 CON7X2_2.54MM

1 3 5 7

9 11 13

C133 100nF

R31 NA

GND

1

12

+

C46 100nF

C47 100nF

C48 100nF

C49 100nF

C52 100nF

C53 100nF

C54 100nF

C55 100nF

+

CE52 100uF/10V

2 4 6 8 10 12 14

C126 100nF

TP6

32

RSTVCC

18

6 12 20 31 45 57 71 93

107 118 134 145 156 171

25 52 66 80

111 143 157 168

4

12

5

94 87 86 85 84 83

+1.2VD5V

C125

100nF

RST#

U6C ADSP-BF532SBSTZ400

VDDRTC

VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT VDDEXT

VDDINT VDDINT VDDINT VDDINT VDDINT VDDINT VDDINT VDDINT

VROUT VROUT

TCK TDO TDI TMS TRST EMU

C128 100nF

GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND

C130 100nF

1 2 3 7 8 9 15 19 30 39 40 41 42 43 44 56 70 88 89 90 91 92 97 106 117 128 129 130 131 132 133 144 155 170 174 175 176

12

CE19

+

47uF/25V

A A

AGNDPGNDDGND

5

A-14.5V

C58 100nF

4

1

GND

2 3

Vin Vout

KA7912 U10

CE20

47uF/25V

TP14

-12VA

12

+

ABC PCB S

鄏

Harman Kardon

Title

HD980 main board

Size Document Number Rev

5563C 1.3

Custom

3

2

Date: Sheet

drawn by

1

89Friday, September 19, 2008

l Ch. du Saux 17 CH-1131 Tolochenaz

of

5

harman/kardon

HD 980/230 Service Manual

Page 44 of 46

4

3

2

1

VCC3

DIOWR# DIORD#

IORDY

DA1 DA0 DA2

D D

C13 1nF

C14 10nF

C16 3.3nF

C17 3.3nF

C18 100nF

C29

4.7uF

P34_S

LA0

LA1 LA2

LA3

LA4 LA5

LA6

LA7 LA12 LA15

-ROMWE

P35_S

LA14

LA13

LA8

LA9

LA11

-LOE LA10 LD7

LD6

LD5

LD4

LD3

LD2 LD1

LD0

JITFO LPFO

RFDSLV SCO

R22 6K2

3.3VA

VRD VRA

VCC3

C35 100nF

VDD

C19 27nF

C30 100nF

D5V

C11

100nF

U2 A290011TL-70

LA7

C C

B B

LA6 LA5 LA4 LA3 LA2 LA1 LA0 LD0

12

+

CE56 100uF/10V

5 6 7 8

9 10 11 12 13

A7 A6 A5 A4 A3 A2 A1 A0 I/O0

R9 0R

R10 NA

D5V

LA15

LA12

LA16

123

4

A16

A15

A12

NC1

I/O1

I/O2

VSS

I/O3

14151617181920

LD4

LD1

LD2

LD3

-ROMWE

VCC

I/O4

LD5

P34_S

P35_S

R14 0R

P35_S

303132

WE

NC2

LA14

29

A14

LA13

28

A13

LA8

27

A8

LA9

26

A9

LA11

25

A11

-LOE

24

OE

LA10

23

A10

22

CE

LD7

21

I/O7

I/O5

I/O6

LD6

C15 120pF

R19

2K C20 47pF

R21

2K C21 200pF

■■■ NET "LDOCD", "LDODVD"---30-40mA.

A A

CS1FX# CS3FX#

VCC3 VCC3

R6 NA

U1 VT7208G

INT1#

163

INT1#

164

P34

165

RD#

166

P10

167

P11

168

P12

169

P13

170

VCC2

171

P14

172

P15

173

P16

174

P17

175

AH12

176

AH15

177

ROMWE#

178

P35

179

VSS1

180

AH14

181

AH13

182

VDD1

183

AH8

184

GND1

185

AH9

186

AH11

187

PSEN#

188

AH10

189

ADL7

190

VCC1

191

ADL6

192

ADL5

193

ADL4

194

ADL3

195

ADL2

196

ADL1

197

ADL0

198

PLLVSS

199

PLLVCC

200

AVSS1

201

JITFO

202

LPFO

203

AVCC1

204

RFDSLV

205

SCO

206

AGFU

207

AGFI

208

AGFR

209

AVSS2

210

OSP

211

OSN

212

AVCC2

213

RFOP

214

RFON

215

AVSS3

216

IREF

3.3VA

C31

4.7nF

A5V

R7

R8

NA

0R

INT0#

156

155

154

153

152

151

150

149

148

147

145

144

143

142

140

139

141

CS3FX#

CS1FX#

VCC3

146

DA2

DA0

DA1

VSS3

VDD2

GND2

INTRQ

IORDY

PDIAG#

DIORD#

DIOWR#

DMAACK#

157

158

159

160

161

162

P30

P31

ALE

WR#

VSS2

CSEL

INT0#

DASP#

VT7208

216-PIN LQFP

VRD

VRA

AVCC3

DVDRFIN

DVDRFIP

DVDINA

DVDINB

DVDINC

DVDIND

CDC/SC

CDD/SD

CDA/SA

CDB/SB

PEAK

RFRPSLV

RFRPDC/BD

RFRPAC/BD

IDSUBO

IDSUBI

TNI

FEO

AVSS4

2 3

C22 3.9nF

1

Q1 2SB1132R

1

Q2 2SB1132R

TPI

TNI

C24

3.3nF

C23 1nF

R23

R24

33K

C36 1uF

R28 11K8

C37 1uF

R30 11K8

123

43756789

10111213141516171918222423202128252627322931343539403841424445434748495051

C32 1uF

C33 1uF

A B C DRF E F MDI FMO TRO FOO DMO

R27 22R

L1 10uH

LDOCD

R29 22R

L2 10uH

LDODVD

DD1

DD14

DD15

DD0

135

138

137

136

134

DD0

DD1

DD14

DD15

VCC4

DMARQ

FLVL

MDI1

CSO

CEC

MDI2

LDO1

VRD VRD

R1 NA R2 NA R3 NA R4 NA R5 10K

DD12

DD13

DD3

DD2

128

133

132

130

131

129

DD3

DD2

DD13

DD12

VDD3

GND3

LDO2

TEO

TEZILP

AVCC4

AVSS5

DPD2

30

33

C25 100nF

1 2 3 B C E

2SB1132R(SOT89)

DD11

DD4

125

127

126

VSS4

DD11

DPD1

AVCC5

36

DD10

DD5

123

124

DD4

DD10

DPDVCC

DPDVSS

VCC3

DD9

122

DD5

AVSS6

R185 NA

DRST# TRAYOUT#

DD[0..15]

VCC3

VDD

DD7

DD8

PRST#

DD6

112

109

110

111

117

119

120

118

116

115

114

121

113

LO

RO

IEC

DD8

DD9

DD7

DD6

VCC5

PRST#

HRST#

DACVSS

DACVCC

DACVREF

TRAYOUT#

OUTTRAY

GIO7/IOCS16#

FMO

TRO

DMO

ADBG1

FOO

AVCC6

XTALVSS

XTALO

XTALI

XTALVCC

FGIN

ADBG2

HRFZC

DMOEN

524653

54

VCC3

R25 NA

R26 0R

VSS5

TRAYIN#

LIMIT#

EJECT#

PLAY#

INTRAY

GIO3

VCC6

GIO2/EA

VDD4

GIO5

GND4

GIO4

GIO6 GIO1 GIO0 VSS6

VCC7

RAS#

VSS7 CASH# CASL#

VCC8

MD10

MD11

MD12

VSS8

MD13

MD14

MD15

VCC3

108 107 106 105 104 103 102 101

LED

100 99 98 97 96 95 94 93 92 91 90 89 88

MA3

87

MA4

86

MA2

85

MA5

84

MA1

83

MA6

82 81

MA0

80

MA7

79

MA8

78 77

OE#

76

WE#

75 74 73 72

MD7

71

MD8

70

MD6

69

MD9

68 67

MD5

66 65

MD4

64 63

MD3

62 61 60

MD2

59 58

MD1

57 56

MD0

55

DMOEN

C26 15pF

2

3

1

C34 15pF

SMA3 SMA4 SMA2 SMA5 SMA1 SMA6

SMA0 SMA7 SMA8 RAS# OE# WE#

CASH# CASL# SMD7 SMD8 SMD6 SMD9

SMD5 SMD10 SMD4 SMD11 SMD3 SMD12

SMD2 SMD13 SMD1 SMD14 SMD0 SMD15

X1

33.8688MHz

TRAYIN# LIMIT#

OUTTRAY INTRAY

R11 10K

VDD

R15 10K

R16 10K R18 10K

VCC3

GIO5

GIO4

GIO6

CE53

100uF/10V

D5V

CASL# CASH# WE# OE#

RAS#

FB1 100R

12

+

CE57

100uF/10V

C136

100nF

4*33R

R20 33R

12

+

3.3VA VDD

C2

C1

C138

100nF

RN1

100nF

C3

CE55

C28 100nF

100nF

1 2

12

+

D5V

12

+

CE54

100uF/10V

C134

C141

100nF

R13

R12

NA

1K

CE1 10uF/16V

U3 M11B416256A-25J

29

LCAS

28

UCAS

13

WE

27

OE

14

RAS

16

A0

17

A1

18

A2

19

A3

22

A4

23

A5

24

A6

25

A7

26

A8

1 21

VCC GND

20

VCC3

100nF

100uF/10V

D1

LL4148

LCAS

18

UCAS

27

WE

36

OE

45

RAS

SMA0 SMA1 SMA2 SMD9 SMA3 SMA4 SMA5 SMA6 SMA7 SMA8

D5V_A42

C27

12

C135

C4

+

100nF

C137

C139

C140

100nF

DRST#

PRST#

C12

R17

100nF

4K7

2

I/O0

3

I/O1

4

M11B416256A-25J

I/O2

5

I/O3

7

I/O4

8

I/O5

9

I/O6

10

I/O7

31

I/O8

32

I/O9

33

I/O10

34

I/O11

36

I/O12

37

I/O13

38

I/O14

39

I/O15

356

GND2VCC2

40

GND3

C5

100nF

C8

100nF

SMD0 SMD1 SMD2 SMD3 SMD4 SMD5 SMD6 SMD7 SMD8

SMD10 SMD11 SMD12 SMD13 SMD14 SMD15

C6

100nF

C9

100nF

C7

100nF

VCC3

C10

100nF

5

Harman Kardon

Title

HD980 main board

Size Document Number Rev

5563C 1.3

A2

4

3

2

Date: Sheet

drawn by

CH-1131 Tolochenaz

99Friday, September 19, 2008

1

of

鄏

l

ABC PCB S Ch. du Saux 17

5

harman/kardon

HD 980/230 Service Manual

Page 45 of 46

4

3

2

1

5VON

IR401 HS0038B

D D

IR G VCC

123

DGND

IR

REMOTE_IR

C C

CN403 CON6_1.25MM_DIP_B

1 2 3 4 5 6

DGND

RB5 RA1 IR

REMOTE_IR

1 2

D401 LL4148

C401 2.2uF

STANDBY

R407

4.7K

R401 15K

Q401 8550

R402 4.7K

1

R412 300R

Function describe:

1. IR signal receive and transmit.

2. Detect functional button and transmit.

3. control power indicator.

4. control SMPS board go to standby.

5. control mute signal when power on and power off.

R408

4.7K

U401 EM78P156ELM

1

P52

2

P53

3

TCC

4

RESET

5

VSS

6

P60/INT

7

P61

8

P62

9

P63

R403 4.7K

R404 470R

R405 0R

R406 4.7K

5VON

E

C

B

C

E

3 2

2 3

R413 560R

B

1

Q402 8050

VPP

OSCI

OSCO

VDD

5VON

R409 4.7K R410 4.7K R411 4.7K

P51 P50

P67 P66 P65 P64

RA1 RA0

Y401

4.000MHZ

18 17 16 15 14 13 12 11 10

1 2

3

C402 22pF

12

RB7 RB6 RB5 RB4

+

C404 100nF

DGND DGND

C403 22pF

DGND

5VON

CE401 100uF/10V

1 3

K401 Standby

K403 Pause

K405 Prev

2 4

1 3

K407 Display

K404 Stop

K402 Play

K406 Next

2 4

1

2

B B

CN404 CON3_2.54MM_DIP

3

2

1

A A

5

STANDBY

5VON

DGND

5VON

C405 100nF

DGND

C406 100nF

12

+

CE402 100uF/10V

4

LED401 HFT503CPB0φ3

AMBERBLUE

3

DGND

PIN7 logic:

blue unmuteblue

amber amber

Title

Size Document Number Rev

A4

3

Date: Sheet

2

HD980 FRONT PANEL: Button board

PIN9 logic:

unmute

mute

5575C 1.1

mute

12Tuesday, May 06, 2008

of

1

5

harman/kardon

HD 980/230 Service Manual

Page 46 of 46

4

VFD401 VFD22-1302FA

3

2

1

VFD 12COLUMNS × 1LINE 5×7 DOT MATRIX

D D

CN401 CON14_1.25MM_DIP_2

10

12

14

1

2

3

4

5

6

7

8

9

10

11

12

13

14

AC1 AC2

-29V

REMOTE_IR VFD_STB DATA/SDA D5V

CLOCK/SCL

IR

D5V

C408 100nF

C409 100nF

DGND

12

+

CE403 47uF/10V

C407 47nF

5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7

AC

1G2G3G4G5G6G7G8G9G

1

2

53525150494847464544434241

G5

G3

G6

G4

G1

G2

G7

G8

G9

G10

10G

G11

11G

G12

P2P3P4P5P6P7P8P9P10

12G

13G

P1

36353433323130292827262524232221201918171615141312111098765434039385455

37

G13

AM1

AM2

AM3

AM4

AM5

AM6

AM8

AM9

AC2

DGND

G[1..13]

DGND

K408 Open/Close

1 3

2 4

RB5 RA1 IR

REMOTE_IR

R414 20K

C410

2.2uF

DGND

D5V

1 2

D402 LL4148

C411 30pF

VFD_STB CLOCK/SCL DATA/SDA

DGND

G6 G5 G4 G3 G2 G1

R415 10K

VFD_STB CLOCK/SCL DATA/SDA

-29V

G7

G9

G8

G10

G12

G11

G13

42

43

44

45

46

47

48

G9

G8

G7

G11

AM1

AM2

AM3

G10

AM4

AA8/G12

AM5

AM6

AA7/G13

AM7

49

G6

50

G5

51

G4

52

G3

53

G2

54

G1

55

VFL

56

TEST

57

VSS

58

SOCO

59

OSCI

60

VDD

61

RES

62

FCS

63

CLK

64

DATAI

C C

CN402 CON6_1.25MM_DIP_B

6 5 4 3 2 1

B B

123456789101112131415

7G 12G3G 10G 11G5G 8G1G 4G2G 6G 9G

P11

P12

P13

P14

P15

AM15

AM14

AM11

AM10

AM13

AM12

AM37

AM36

AM38

36

37

38

39

40

41

AA1

AA2

AA3

AA4/G16

AA5/G15

AA6/G14

LC75711NE

AM8

AM9

AM10

AM11

AM12

AM13

P16

AM17

AM16

AM35

AM34

34

35

AM35

AM14

P17

P18

AM18

AM33

33

AM33

AM34

AM15

AM16

16

P19

AM19

AM20

AM32 AM31 AM30 AM29 AM28 AM27 AM26 AM25 AM24 AM23 AM22 AM21 AM20 AM19 AM18 AM17

P20

AM21

P21

P22

P23

P24

AM24

AM23

AM22

U402 LC75711NE

32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17

P25

AM26

AM25

P26

AM27

P27

AM28

AM32 AM31 AM30 AM29 AM28 AM27 AM26 AM25 AM24 AM23 AM22 AM21 AM20 AM19 AM18 AM17

P28

AM29

P29

AM30

P30

AM31

P31

P32

P33

P34

AM34

AM32

AM33

AM[1..38]

P35

AM36

AM35

P36

AM37

P37

P38ACAC

AM38

AC1

DGND

C415 47nF

C412 20pF N/A

C414 20pF N/A

C413 20pF N/A

AM16

AM14

AM1

AM2

AM3

AM4

AM5 AM7

AM6

AM7

AM8

AM9

AM10

AM12

AM11

AM13

AM15

DGND

A A

Title

HD980 FRONT PANEL: VFD BOARD

5

Size Document Number Rev

A4

Date: Sheet

4

3

2

5576C 1.1

of

22Wednesday, December 19, 2007

1

Model

Serial number

Status

Action

PN used

HD 980/990

All

Rattle noise

Add damping pads

EDV3485ORATTLE

harman/kardon Service Bulletin

HD 980/HD 990 May 2012

Service bulletin # HK2012-002

To: All Harman Kardon Service Centers

Models: HD 980/990

Subject: Rattle noise

In the event you receive a unit with the complaint “Periodic mechanical noise from the CD player”.

Perform the following repair: Add damping pads to prevent rattling. Rattling noise is related to the spinning disc not being completely balanced or centric. Parts: Pads – Part number: EDV3485ORATTLE (5 sets of 4 pads).

Procedure:

Please mount 2x2 damping-pads as shown in the pictures.

Note: There should be no marks in the surface or stickers on the disc, causing imbalance when the disc is spinning. Even original discs may not be fully centric.

Harman International 8500 Balboa Blvd., Northridge, CA 91329, USA