Groen CNEB-36 User Manual

HYPLUS PRESSURE BOILER

PROJECT NAME:

LOCATION:

ITEM NO:

MODEL CNEB-24/36/48

HyPlus cabinet base electric boiler.

CONSTRUCTION: Cabinet base shall be

manufactured of stainless steel with louvered lift off front panel for access to boiler. Cabinet exterior shall be uniformly polished to a #3 finish with control face plates of smudge resistant polyester film.

CERTIFICATIONS: Cabinet-mounted boiler shall be

ASME Code constructed and National Board registered for operation up to 15 PSI. Electric boiler shall be UL listed. Unit shall be designed and manufactured to meet regulatory known health department sanitation codes.

CONTROLS: Electric boiler shall be supplied with

power ON switch, RESET light, start switch, low water sensor, pop safety valve, water level sight glass on front panel and an outside cabinet mounted pressure gauge.

WATER SUPPLY REQUIREMENTS:

Water Pressure: 30-60 PSI PH: 7 to 9 Hardness: less than 60 ppm TDS: 30-60 ppm Chlorine & Chloramine: less than 0.1 ppm Total Chloride: less than 30 ppm Silica: less than 12 ppm Undissolved Solids: less than 5 micron

ORIGIN OF MANUFACTURE:

Designed and manufactured in the United States.

QTY:

MODEL NO:

AIA NO:

SIS NO:

Electric boiler in stainless steel cabinet. (model CNEB-24 shown)

PERFORMANCE FEATURES: Unit shall shut off

if water level is low or the unit builds up too much pressure. When the power switch is turned “OFF” the boiler automatically drains after the water has cooled to 170 degrees F. Boiler shall be of 24, 36 or 48kw providing 2.2, 3.5 or 4.7 BHP of steam respectively (please specify).

INSTALLATION: Unit requires 208, 240 or 480 volt

hard wired electrical connection. Unit requires ½” NPT cold water supply line and 1-1/4” free venting drain.

STEAM SOURCE FOR EQUIPMENT:

Boiler is provided with a ½” NPT power take off valve. To ensure proper performance boiler must be properly sized to meet BHP requirements of equipment to be powered. Appropriate steam traps and piping must be professionally installed.

OPTIONS/ACCESSORIES:

Prison Package Delimer/Descaler Degreaser Field Drain Tempering Kit Interconnecting Piping 12’ Interconnecting Piping 6’ Flanged Feet

Puresteam Water Treatment System (extends warranty (1) year)

Puresteam Replacement Cartridge

Pre-filter System

Dual Water Connection

HyPlus

174283 RevB

Revised 09/15

174297 REV A

CNEB-24/36/48

888-994-7636, uniﬁedbrands.net