Fisher & Paykel Bgb132-bi, Bgb132, Bgb131, Bgb131-bi Owner's Manual
THE PROFESSIONAL SIDE BURNER
Installation, Use and Care Guide
MODELS:
BGB131
BGB132
BGB131-BI
BGB132-BI
A MESSAGE TO OUR CUSTOMERS
We are glad that you selected the professional side burner by DCS. Because this appliance contains features not
ound on any other burner, we recommend that you read this entire booklet before your first use. Keep it in a
f
handy place as it has answers to questions that may occur during future use.
eel free to contact us if we can help you. When you write please include the model and serial number of the
F
Burner. We thank you for buying the professional side burner and wish you many years of enjoyment.
To help serve you better, please fill out and submit your Product Registration by visiting our website at
www.dcsappliances.com and selecting “Customer Care” on the home page and then select “Product Registration”.
For your convenience, product questions can be answered by a DCS Customer Care Representative by phone:
1-888-936-7872, or email: customer.care@fisherpaykel.com.
NOTE: Please write the Model, Code and Serial Numbers on this page for references (located on the inside of the
left side of the appliance)
MODEL NUMBER CODE SERIAL NUMBER
NOTE: Inspect the product to verify that there is no shipping damage. If any damage is detected, call the shipper
and initiate a damage claim. DCS by Fisher & Paykel is not responsible for shipping damage.
DO NOT discard any packing material (box, pallet, straps) until the unit has been inspected.
WARNING!
Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
Read the installation, operating and maintenance instructions thoroughly before installing, using or servicing this
equipment.
WARNING!
If the information in this manual is not followed exactly
personal injur
y other appliance. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other
an
appliance.
y or death. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
, a fire or explosion may result causing property damage,
WARNING!
Do not try lighting this appliance without reading the “Lighting Instructions” section of this manual. This outdoor
cooking gas appliance is not intended to be installed in or on recreational vehicles , boats or in a non-ventilated
room. For outdoor use only.
FOR YOUR SAFETY
If You Smell Gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, immediately call your gas supplier or your fire department
Installation and service must be performed by a qualified installer, service agency or the gas supplier.
PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE.
1
TABLE OF CONTENTS
SAFETY PRACTICES AND PRECAUTIONS 3-4
INSTALLATION
Installation of Side Burner on 30” Grill 4-7
nstallation of Side Burner Built-in Model 8-9
I
Gas Hook-up 10-11
Leak Testing 12
Burner Adjustment 12
Installer Checklist 13
USING THE SIDE BURNER
Lighting Instructions 14
CARE AND MAINTENANCE 15
TROUBLESHOOTING 16
PARTS LIST
Single Side Burner - BGB131 & BGB131-BI 17
Double Side Burner - BGB132 & BGB132-BI 18
WIRING DIAGRAM
Single and Double Side Burner 19
SERVICE 20
WARRANTY 21-22
2
SAFETY PRACTICES & PRECAUTIONS
Improper use or installation is dangerous. Carefully follow these instructions.
■
Always remove the cover before lighting the professional side burner. Never use the side burner if a leak is
present.
■
Do not use a flame to check for gas leaks.
■
Do not let children use the side burner.
■
Do not leave children unattended near the side burner.
■
Never let children crawl or hang on the side burner.
■
Exercise care when operating the side burner. The burner grate can get hot enough to cause burns during
operation.
■
Never leave the side burner on unattended.
■
Always wait 5 minutes before relighting the burner to allow any accumulated gas to dissipate. Should the burner
go out during use, turn off the gas valve and wait 5 minutes before attempting to relight. Always follow the
lighting instructions. Never lean over a lit burner.
■
Never cook without the drip pan in place, pushed all the way to the rear of the burner box.
■
Use only in well ventilated areas.
■
Do not use in garages, breezeways, sheds, or other such enclosed areas.
■
Keep the area surrounding the side burner clear and free from combustible materials, gasoline, other flammable
liquids or vapors, charcoal lighter fluid, and trash.
■
Do not obstruct the flow of combustion and ventilation air to the side burner. On cart mounted units, keep area
beneath the burner free of debris. If the burner is built-in, do not store gas cylinders beneath the unit without
adequate ventilation.
WARNING!
Do not store items of interest to children above or at the back of any appliance. Children could be seriously injured
if they should climb onto the appliance to reach these items.
■
Keep the side burner covered when not in use.
■
Never connect an unregulated gas line to the side burner.
f the side bur
■
I
be checked for gas leaks and obstructions in the burner.
■
Thoroughly clean the side burner on a regular basis.
■
Only use the side bur
vice versa, a factory conversion kit (see page 10 for conversion kit information) is required.
NOTE:
duct must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of
o
This pr
Massachusetts.
ner has not been used for an extended period of time (over winter, for example) the unit should
e. To change from LP gas to natural, or
ner with the type of gas specified on the ra
ting pla
t
3
SAFETY PRACTICES & PRECAUTIONS
REAR
FRONT
IGNITION
BURNER
IGNITION
10 - 5/8 "
13
"
13
"
13
"
13
"
10 - 5/8 "
12-
3/4 "
15
-3/4"
10 -1/8"
23-
3/4"
10 -1/8"
26-
3/4"
Single Side Burner
Double Side Burner
2
"
2
"
SPIDER AND INSECT WARNING!
Spiders and insects can nest in the burner(s) or orifices of this or any other gas appliance, and can block or restrict
the burner. This can cause a flash back to the control panel. This is a very dangerous condition which can cause a
fire to occur, thereby damaging the unit and making it unsafe to operate.
You must inspect the burner(s) at least once a year or immediately if any of the following conditions occur:
1. The smell of gas in conjunction with the burner flames appearing yellow.
2. The side burner(s) does not reach temperature.
3. The side burner(s) heats unevenly.
4. The burner(s) make popping noises.
■
Do not attempt to disconnect any gas connections while your burner is in use, or the gas supply is on.
■
When the side burner is stored indoors the gas supply must be disconnected and, if using an LP gas cylinder, the
cylinder must be stored outdoors in a well-ventilated area.
■
Keep any electrical supply cord away from the heated surfaces of the professional side burner.
■
On cart mounted units, never move without first allowing the side burner and/or grill to cool and ensuring that
the gas supply is turned off. Fold the side shelf down, and push; never pull the grill.
■
Never use the side burner in a windy area.
INSTALLATION
INSTALLATION OF SIDE BURNER ONTO 30” CART (BGB 131/132 MODELS ONLY)
SIDE BURNER DIMENSIONS
FRONT
REAR
SIDE
4
FRONT
REAR
SIDE
INSTALLATION
INSTALLATION OF SIDE BURNER ON 30” CART
Important
!
Read all instructions before you begin. Do not jump ahead or skip any step. Side shelf must be removed prior
to installation.
CAUTION!
Some parts have sharp edges; care must be taken when handling the various components to avoid injury. Please,
read safety information provided in these instructions before beginning assembly. Wear gloves when handling.
GETTING STARTED
■
Remove packaging.
■
Remove side burner from inside and discard packing.
CONTENTS INCLUDED:
Your side burner is packaged in one box. The box
contains your side burner and a universal hardware kit
to be used for installation and may contain extra
hardware for your convenience.
Con
tents
Description Q
BGB131-BIL 1 70175
BGB131-BIN 1 70176
ty.
Par
t No.
Contents Qty. Part No.
Washer Flat
1/4x.938
Screw
1/4-20X1/2”
2
5 211323
4 211278
Screw #10
4 211371
Washer #10
4 211394
Nut #10
211375
BGB131L 1 70177
BGB131N 1 70515
BGB132-BIL 1 70178
BGB132-BIN 1 70179
BGB132L 1 70180
BGB132N 1 70604
Cover (131) 1 218614
Cover (132)
ip Pan
Dr
(131)
Drip Pan
(132)
te (131)
a
Gr
Grate (132) 1 220496
tion
nstruc
I
1
1 224826
1 237358
1 210645
1 238044
218613
Tools Required:
Shoulder Bolt
1/4-20x5/16
Screw
10-24x1/2
Pan Head
hillips -tip #2 A
P
10 mm
1
211442
2 211242
Eye Goggles
Work Gloves
Power Screwdriver or
Variable Speed Drill with
3/32” Allen Wrench
ench or S
r
W
ttachmen
ocket
t
5
INSTALLATION
INSTALLATION OF SIDE BURNER ON 30” CART
STEP 1
Remove the cover, grate, and drip pan from the side burner.
STEP 2
olt the support brackets to the grill cart side panel with (4) 1/4 x 20 bolts provided.
B
Note:
For the BGB131 side burner only, use (2) #10 sheet metal screws (211242) to bolt the back support bracket.
SUPPORT BRACKET
6
BOLT
FIG. 01
Loading...