Danfoss TRAVELMATE-DZ Instruction Manual

TRAVELMATE-DZ

Password: 123456

Instruction Manual

Please read these instructions and the Safety section carefully before using

Nexberg Pty Ltd T/a Evakool
16 Enterprise St CALOUNDRA
QLD 4551
Tel : [phone]
Fax : [phone]

your refrigerator.

NOTE:

Your fridge is preregistered with the
following user account for the APP.

User: 12345678900

1．Safety Instructions Page 2
2．Notes on using the product Page 2
3．Operation Page 2-4
4．WiFi Operation Page 5-13
5．Cleaning and Maintenance Page 14
6．Troubleshooting Page 14
7．Error Codes Page 15
8．Warranty Statement Page 16

1 | P a g e

TRAVELMATE-DZ

Instruction Manual

Features:

• Reliable cooling system – Danfoss compressor

• Efficient electronic technology, low energy consumption

• Multi-voltage system (DC 12-24 Volt) and (AC 100-120/220-240 Volt)

• Digital Battery Protection, protect your vehicle battery effectively

1.

Safety Instructions

• Warning: Do not touch exposed cables.

• Warning: Do not use fridge if you suspect any connections could be wet.

• When using the fridge in the vehicle or boat, please make sure the circuit being used is fused.

• Any installation of DC power systems should be handled by a qualified professional.

• Make sure the source voltage is correct. The technical data label has the voltage data.

• Do not place any electrical devices inside the refrigerator as moisture could harm these devices.

2.

Notes on using the product

 Your refrigerator requires good ventilation, especially around the vents of the refrigerator;

allow a gap of at least 200mm around the vents.

 Humidity inside the appliance can form frost and impair cooling.

Do not allow frost to build up. Never clean the appliance using a hose and never submerge the
unit in any liquid.

 Avoid placing your refrigerator near a heat source. This helps the refrigerator to work more

efficiently and keep the contents cool.

 Place the refrigerator on a flat surface and away from any edges. When using the fridge in a

vehicle, please use a fastening device to secure it.

3. Operation

 Power

a three stage battery protection. When the input voltage drops below the minimum, the
compressor will cut out; when the voltage comes back up to the cut-in value, the compressor
will restart automatically.

 Battery Protection: The Danfoss compressor requires approximately 11.0 Volts (12 Volt

System) or 23.0 Volts (24V System) to operate. If the voltage drops below this the fridge will
stop running.

 Cable Specification

The DC cables must have a suitable cross-section for their length, according to this table:

2 | P a g e

：：：：

The electronic control module controls the compressor motor and has the function of

*Note: The length is from the battery to the refrigerator.

Cable Area 12V Max Cable

[mm2] AWG [m] [ft.] [m] [ft.]

2.5 13 2.5 8 5 16
4 11 4 13 8 26
6 9 6 20 12 39

10 7 10 33 20 66

Length*

24V Max Cable

Length*

240 Volt Socket

ON / OFF Switch

Using the Fridge

• Temperature setting range：-18ºC～10ºC, 0ºF～50ºF

• Plug in the DC or AC power cable. Hold the ON/OFF switch for 4 seconds to run the fridge.

TRAVELMATE-DZ

Instruction Manual

12/24V Volt Socket

SET Button Display LCD + / - Buttons

USB Socket (0.5A) Emergency Switch

The LED display on the control panel will light up and the interior temperature will be
displayed.

• Press SET and then press the + and - buttons to adjust the temperature. Press the + button

to increase while the - button to decrease the temperature. To lock in the target temperature
press set twice or leave for 5 seconds. The display board will display the current temperature
inside the unit after the target temperature is set. After approximately 5 minutes the displayed
temperature will start to decrease.

• If the power supply is cut off, the refrigerator will switch off automatically and then

automatically switch on again when the unit receives power.

• To change the fridge between ºC and ºF. Press SET twice and then press - or + to change the

setting.

3 | P a g e

TRAVELMATE-DZ

Instruction Manual

• To change the battery voltage setting press the SET button until the VL is flashing and then

use the + or – buttons to change the setting. The three voltage settings are approximately as
follows :- (We advise to keep the setting on VL)

o VL – 11.0 Volts
o VM – 12.0 Volts
o VH – 12.5 Volts

• If dual zone unit; display panel will contain 2 Temperature Read-out’s. Press the Set button

once to set left bin temperature, twice to set right bin and thrice to set temperature mode.

4 | P a g e

TRAVELMATE-DZ

Instruction Manual

4.

WiFi OPERATION

The fridge has been designed with the latest technology. You are able to easily download the
EVAKOOL APP from the Google Play store or the Apple iTunes Store.

Once the APP is installed please follow these easy instructions to be able to control and monitor your
fridge.

SCREENSHOT SHOWING WIRELESS NETWORK CREATED BY THE FRIDGE

To use your Smartphone with your fridge you must first be on the same Wireless Network as the
fridge. The fridge creates its own wireless network which you must connect to in the settings of your
phone.

Once you have connected to the Wireless network and it states that you are connected you can now
proceed to pair your fridge with the APP.

5 | P a g e

TRAVELMATE-DZ

Password: 123456

Instruction Manual

PLEASE NOTE: You will not be able to use the internet while connected to the fridge.

To pair the fridge with the APP, follow these steps:-

a)

Open APP

b)

If the fridge is not automatically added then you will need to click the ADD button at the bottom
of the screen.

This will allow you to add your fridge and pair it with you phone/APP. The Fridge ID is the last six
numbers of the WiFi Network name so in this example the fridge ID is “750013”.

c)

You will then need to register a new login.

NOTE THAT THE FRIDGE COMES STANDARD WITH AN UPGRADED DEFAULT
USER NAME AND PASSWORD.

NOTE:

Your fridge is preregistered with the
following user account for the APP.

User: 12345678900

6 | P a g e

TRAVELMATE-DZ

Password: 123456

Instruction Manual

To register please fill out the fields:-

USER ID – An 11 digit number i.e. 12345678900

Type – You need to select “Average User” the upgrade registration will be provided by Evakool.

This can be obtained once your warranty is registered online by emailing [e-mail] and
requesting the upgrade code.

Password – Please choose a 6 digit number. i.e. 123456

Confirm Password – Re-Confirm the Password

Email – Enter your email address,

Fridge ID should be already filled in.

Then click Register.

7 | P a g e

Your fridge is preregistered with the
following user account for the APP.

NOTE:

User: 12345678900

TRAVELMATE-DZ

Instruction Manual

d)

You will then need to login using your registered details.

a) USER ID : xxxxxxxxxxx (As per your registration)
b) PASS : xxxxxx (As per your registration)

NOTE – If you would like to upgrade the APP to be able to change the temperature and
view the graph of voltage and temperature please follow the next steps.

8 | P a g e

TRAVELMATE-DZ

Instruction Manual

Click Settings and then click Account Upgrade.
Then Enter in your USER ID and the registration code provided to you by Evakool and then click
SAVE.

Your Account will now be upgraded.

e)

Once logged in you can view the fridge’s current running temperature and the voltage as well as
any error messages.

9 | P a g e

TRAVELMATE-DZ

Instruction Manual

f)

When you click the settings button a menu will extend out from the right hand side where
additional changes to the fridge can be made. Click the “Settings” Button.

There are various menus in this side menu each of which is detailed below:-

a) Settings – Change the temperature, ºC or ºF and also the low voltage battery cut out.
b) Graph – The fridge can log the temperature and voltage data. You can use this to make sure

your fridge is operating correctly.

c) On/Off – Switch your fridge on or off
d) Fridge Selection – ADD/DELETE current paired fridge

g)

You can change multiple settings on the below page :-

a) To change ºC to ºF simply click the button you want.
b) To change the temperature simply move the bar left or right.. If you are using a single zone

fridge then the left zone is the default zone.

c) To change the Low Voltage Protection click the letter corresponding to the setting you

require (LOW Recommended)

d) To save any changes click the SAVE button.

10 | P a g e

TRAVELMATE-DZ

Instruction Manual

GRAPHING

h)

The fridge is able to log data of the temperature and voltage recorded by the fridge. This can be
handy when trouble shooting. (E.g. If you have a problem once the fridge has been running for a
while you can review this data. Take a screenshot (Refer to Google on how to take a screenshot
with your model Smartphone) and then email it to Evakool for review, if necessary. )

The data is viewable after approximately 10 minutes of running. The maximum data recorded is
approximately 24 hours, worth.

Note: The temperatures recorded are in the walls so there may be some variation and delay
compared to air sensing thermometers.

Note: The voltages recorded are measured inside the fridge at the internal connectors so these will
be different to your battery/solar voltage readings.

Take note that you may have to zoom in or out to see the full graph. This can be done using your
fingers in a pinching motion.

11 | P a g e

TRAVELMATE-DZ

Instruction Manual

i)

The fridge can be switched on or off using the following screen.

12 | P a g e

TRAVELMATE-DZ

Instruction Manual

TROUBLESHOOTING THE WiFi APP

I can’t see or connect the Wireless network

• Make sure WiFi is turned-on, on your device.

• Make sure you are in range of the fridge (normally around 10-20 meters)

• Make sure you are not connected to a different Wireless network

• Try turning the fridge and your phone on and off

I can’t pair the fridge with the APP

• If you have followed the above steps and can confirm that you have connected to the fridge’s

wireless network then proceed if not refer to above troubleshooting on connecting phone to
fridge’s wireless network.

• Make sure the Fridge ID is the same as the Wireless network as on page 5.

• Make sure you are using the correct user ID and Password as per page 7. (Note C)

o If the above failed then follow the below steps:-

• Uninstall the APP. Close all APPs in the background.

• Turn both the fridge and the phone off.

• Turn both the fridge and the phone back on after a couple of minutes.

• Re-install the APP.

If you are still having problems please do not hesitate to contact Evakool.

13 | P a g e

TRAVELMATE-DZ

Instruction Manual

5. Cleaning and maintenance

• Clean the appliance inside and out with a damp cloth every week. If it is dirty, use

sodium bicarbonate dissolved in lukewarm water to clean the unit.

• Never use abrasive products, detergents or soap. After washing, rinse with clean water

and dry carefully. Do not leave the refrigerator off with food inside or lid closed.

• Never clean the appliance under running water. Do not use abrasive cleaning agents or

hard objects during cleaning as these can damage the refrigerator.

6. Troubleshooting

 The appliance is not turning on.

• Check the power supply

• Check whether the plug and the socket have a good connection.

• Check whether the fuse requires replacement

• Check whether the appliance has been turned on

 The food inside is frozen.

• The setting temperature is too low

 Bad performance in refrigeration

• The temperature setting is inappropriate

• The lid is unlocked/or open

• The lid seal is broken

• Problems arising from poor ventilation

• There is no room around the fridge and vents

• Too much food been placed inside the refrigerator

• There is too much warm product inside

• There is a heat source near the unit

 Hear the sound of water from inside the unit

• This is normal, due to the flow of the refrigerant.

 Unusual noise when refrigerator is working

• The refrigerator is not placed on a level surface

• Some part has come loose inside the refrigeration compartment (see a service agent)

14 | P a g e

TRAVELMATE-DZ

7.

Error Codes

Instruction Manual

Code Reason / Solution

ERR1 Thermistor is unplugged

- Contact Evakool

ERR2 Thermistor is short circuited

- Contact Evakool

E1 Low Voltage

- Please check the source voltage to ensure it is above

the cut out. Try lowering the voltage cut out setting to
LOW.

- The vehicle cabling may be inadequate/unsuitable,

please refer to cable specifications table for correct
cable thickness (Page 2)

- Try on a different power source

E2 Fan issue

- Fan is drawing too many Amps (Over 1 Amp) –

Contact Evakool

E3 Compressor Start Issues

- Unplug for 10 Minutes

- Try on a different power source.

- Possible Electronic Box or compressor fault – contact

Evakool

E4 The compressor speed is too low

- Unplug for 10 Minutes

- Reduce product load inside unit

- Move unit to a lower ambient temperature

- Clean vents / ensure clear air flow over compressor

E5 Ambient Temperature too high

- Clean vents / ensure clear air flow

- Fan Fault – Contact Evakool

15 | P a g e

TRAVELMATE-DZ

Instruction Manual

EVAKOOL TRAVELMATE FRIDGE FREEZER RANGE

Warranty Statement

TERMS & CONDITIONS

Nexberg Pty. Ltd. trading as EvaKool undertakes to the original purchaser that this product is sold free of defect in materials
and/or workmanship under normal use for a period of 60 months. Subject to the following: -

• The warranty period commences from the date of
purchase by the original purchaser from an
authorised EvaKool dealer.

• EvaKool will honour this warranty on presentation of
proof of purchase of the unit to EvaKool or its
approved service agent. The service agent may be
requested to provide EvaKool with a photocopy of
the proof of purchase to obtain approval to proceed
prior to warranty being honored.

• Evakool will not be held responsible for any costs
incurred in making a warranty claim.

• Please telephone [phone] for the name of an
authorized service agent or refer to list provided. It is
the purchaser’s responsibility to freight the unit to
and from the service agent.

• EvaKool will not be held responsible for any damage
or loss suffered or cost incurred whilst fridge is in
transit.

• Warranty repairs may only be carried out by an
authorised service agent. EvaKool will not reimburse
repair claims carried out by unauthorized service
agents. Any unauthorized tampering with any part of
the unit will automatically void the warranty.

• Service agents may charge a fee for viewing or
testing the unit. This is not covered by EvaKool or
this warranty and is payable at the service point
unless authorized by EvaKool.

• Any Evakool authorized service centre in Australia
will be able to carry out the service of your unit. If a
repair needs to be undertaken and is covered in
terms of this warranty a warranty authorization
number must be obtained prior to commencement of
any work.

• EvaKool will not accept a warranty claim if:

1. Modifications have been carried out to the unit
without EvaKool’s written authority.

2. Damage to or failure of the unit has been
caused in EvaKool’s opinion by incorrect,
extreme or unreasonable use.

3. Damage to or failure of the unit has been
caused in EvaKool’s opinion by misuse,
neglect, accident, impact or similar cause.
Refer the preventative maintenance guidelines.

• EvaKool has total discretion on the variation of the
warranty terms.

• Our goods come with guarantees that cannot be
excluded under the Australian Consumer Law. You
are entitled to a replacement or refund for major
failure and for compensation for any other
reasonably foreseeable loss or damage. You are
also entitled to have the goods repaired or replaced if
the goods fail to be of acceptable quality and the
failure does not amount to a major failure.

• The above warranty conditions are in addition to any
other rights and/or remedies as per the applicable
law.

• Failure to follow the guidelines/recommendations in
this manual may void the warranty.

• This warranty cannot be varied by others.

COMPLETE THE ENCLOSED WARRANTY CARD AND
RETURN WITHIN THIRTY (30) DAYS OF PURCHASE

POST or Register your product warranty

ONLINE at

www.evakool.com

16 | P a g e