Champion UH-200B, UH-200, UH-100B, UL-100 Part Manual
Part 9: REPLACEMENT PARTS
PART 9:
REPLACEMENT
PARTS
In This Part—
• Parts illustrations and replacement parts lists
Special Materials
The following solvents, sealants, and pipe compounds are required for repairs but are
not called out in the replacement parts list. The materials listed below are recommended
as standard issue for service technicians:
• Pipe sealant (Loctite® 565 or comparable) Champion P/N 106437
• Silicon sealant (732 RTV or comparable) Champion P/N 104827
• Thread sealing teflon tape, Champion P/N 106436
• Plumber’s putty (Compound 440 or comparable) Champion P/N 104889
• Heat Sink Compound (used on high limit thermostat) Champion P/N 110563
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
111
Part 9: REPLACEMENT PARTS
7
6
1
6
7
7
6
9
8
6
7
6
5
7
11
6
4
6
9
8
2
3
7
11
STUD
STUD
10
Figure 9.1-
Upper Hood Assembly and Control Cabinet
(All Models)
112
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Part 9: REPLACEMENT PARTS
UPPER HOOD ASSEMBLY
AND CONTROL CABINET
(ALL MODELS)
Fig. 9.1 Part
Item No. No. Part Description Qty.
1 322688 PANEL, TOP ................................................................................. 1
2 322660 PANEL, CONTROL...................................................................... 1
3 322684 CHANNEL, HARNESS ............................................................... 1
4 323413 BRACKET, HARNESS SUPPORT .............................................. 1
5 0503647 BUSHING, STRAIN RELIEF ...................................................... 1
6 107966 NUT, GRIP 10-32 W/NYLON INSERT ....................................... 8
7 107033 WASHER ...................................................................................... 8
8 107967 NUT, GRIP W/NYLON INSERT ................................................. 2
9 106026 WASHER, FLAT 1/4" ................................................................... 2
10 100007 SCREW, 10-32 X 3/8" TRUSS HD .............................................. 2
11 106486 WASHER, LOCK #10 SPLIT ...................................................... 4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
113
Part 9: REPLACEMENT PARTS
13
13
14
9
11
10
9
14
15
16
17
17
17
17
18
19
20
14
14
3
7
8
12
1
2
4
5
6
20
19
21
21
21
21
21
23
23
22
22
22
22
Figure 9.2-
Tank, Base, Guide Rails, and Panels
(UH-200B, UH-200)
114
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Part 9: REPLACEMENT PARTS
TANK, BASE, GUIDE RAILS, AND PANELS
(UH-200B, UH-200)
Fig. 9.2 Part
Item No. No. Part Description Qty.
1 322639 TANK ASSEMBLY ......................................................................... 1
2 322648 BASE ASSEMBLY .......................................................................... 1
3 108035 FOOT, LEVELING .......................................................................... 4
4 108036 CAP, LEVELING FOOT ................................................................. 4
5 322650 PANEL, RH FULL........................................................................... 1
6 322651 PANEL, LH FULL ........................................................................... 1
7 322649 PANEL, FRONT .............................................................................. 1
8 322682 DOOR, REAR ACCESS .................................................................. 1
9 322685 CHANNEL, FILLER ....................................................................... 2
10 112892 SHIELD, BASE, SIDE .................................................................... 1
11 112892 SHIELD, BASE, SIDE .................................................................... 1
12 112867 SHIELD, BASE, FRONT ................................................................ 1
13 112919 GASKET, BASE STRIP .................................................................. 4
14 107967 NUT, GRIP 1/4" W/NYLON INSERT ............................................ 4
15 322662 GUIDE, LH RAIL............................................................................ 1
16 322663 GUIDE, RH RAIL ........................................................................... 1
17 0501418 SCREW, 1/4-20 X 1/2" ROUND HD .............................................. 8
18 100778 SCREW, 1/4-20 X 3/8" TRUSS HD................................................ 2
19 107966 NUT, GRIP 10-32 W/NYLON INSERT .......................................... 2
20 107033 WASHER ......................................................................................... 2
21 100778 SCREW, 1/4-20 X 3/8" TRUSS HD ................................................ 6
22 106482 WASHER, LOCK 1/4" ..................................................................... 4
23 112920 GASKET, DOOR STRIP ................................................................. 2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
115
Part 9: REPLACEMENT PARTS
22
10
12
11
9
22
15
16
17
17
17
17
18
19
20
22
22
23
24
3
7
8
13
1
2
4
5
6
19
20
20
20
19
19
21
21
21
21
21
25
25
25
25
14
14
Tank, Base, Guide Rails, and Panels
Figure 9.3-
(UH-100B, UH-100, UL-100)
116
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Part 9: REPLACEMENT PARTS
TANK, BASE, GUIDE RAILS, AND PANELS
(UH-100B, UH-100, UL-100)
Fig. 9.3 Part
Item No. No. Part Description Qty.
1 322639 TANK ASSEMBLY .......................................................................... 1
2 322648 BASE ASSEMBLY .......................................................................... 1
3 108035 FOOT, LEVELING .......................................................................... 4
4 108036 CAP, LEVELING FOOT ................................................................. 4
5 322652 PANEL, RH HALF .......................................................................... 1
6 322653 PANEL, LH HALF .......................................................................... 1
7 322649 PANEL, FRONT .............................................................................. 1
8 322682 DOOR, REAR ACCESS .................................................................. 1
9 322686 CHANNEL, LH FILLER ................................................................. 1
10 322685 CHANNEL, FILLER ....................................................................... 1
11 112898 SHIELD, BASE, LH SIDE .............................................................. 1
12 112892 SHIELD, BASE, SIDE .................................................................... 1
13 112867 SHIELD, BASE, FRONT ................................................................ 1
14 112919 GASKET, STRIP ............................................................................. 4
15 322662 GUIDE, LH RAIL............................................................................ 1
16 322663 GUIDE, RH RAIL ........................................................................... 1
17 0501418 SCREW, 1/4-20 X 1/2" ROUND HD .............................................. 8
18 100778 SCREW, 1/4-20 X 3/8" TRUSS HD................................................ 2
19 107966 NUT, GRIP 10-32 W/NYLON INSERT .......................................... 2
20 107033 WASHER ......................................................................................... 2
21 100778 SCREW, 1/4-20 X 3/8" TRUSS HD ................................................ 6
22 107967 NUT, GRIP 1/4" W/NYLON INSERT ............................................ 4
23 322645 TRIM, TANK FRONT RH .............................................................. 1
24 322646 TRIM, TANK FRONT LH ............................................................... 1
25 106482 WASHER, LOCK 1/4" ..................................................................... 4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
117
Part 9: REPLACEMENT PARTS
4
5
6
7
8
6
4
1
2
3
11
9
10
7
Figure 9.4-
Door and Door Safety Switch Assembly
(All Models)
118
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Part 9: REPLACEMENT PARTS
DOOR AND DOOR SAFETY SWITCH ASSEMBLY
(ALL MODELS)
Fig. 9.4 Part
Item No. No. Part Description Qty.
1 322690 DOOR.............................................................................................. 1
2 112727 GASKET, DOOR ............................................................................ 1
3 111026 MAGNET, DOOR SAFETY ........................................................... 1
4 108954 NUT, GRIP 6-32 W/NYLON INSERT ........................................... 4
5 112659 SWITCH, MAGNETIC REED DOOR SAFETY........................... 1
6 106551 PIN, COTTER ................................................................................. 4
7 106026 WASHER ........................................................................................ 4
8 112543 SHOCK, DOOR .............................................................................. 2
9 112779 SCREW, 1/4-20 X 1-1/2" FLAT HD HEX SOCKET ..................... 2
10 322672 OUTER DOOR HINGE, LH .......................................................... 1
11 322635 OUTER DOOR HINGE, RH .......................................................... 1
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
119
Part 9: REPLACEMENT PARTS
16
15
14
1
4
2
3
18
17
To rinse aid
pump
To temperature/
pressure display bd.
in control cabinet
5
6
6
8
To outside lower
wash arm support
7
To upper
wash
arm support
6
To booster
outlet
UH-200B
or
To fill/rinse valve
UH-200
19
13
12
10
11
Figure 9.5-
Final Rinse Manifold Assembly
(UH-200B, UH-200)
11
10
9
120
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Part 9: REPLACEMENT PARTS
FINAL RINSE MANIFOLD ASSEMBLY
(UH-200B, UH-200)
Fig. 9.5 Part
Item No. No. Part Description Qty.
1 112741 HARNESS, PRESSURE TRANSDUCER ....................................... 1
2 112668 TRANSDUCER, PRESSURE .......................................................... 1
3 112731 O-RING, PRESSURE TRANSDUCER ........................................... 1
4 112612 THERMISTOR, TEMPERATURE PROBE ..................................... 1
5 112646 MANIFOLD, RINSE ........................................................................ 1
6 105994 CLAMP, HOSE ................................................................................. 3
7 112538 HOSE, UPPER RINSE ..................................................................... 1
8 112537 HOSE, LOWER RINSE.................................................................... 1
9 322668 BRACKET, RINSE MANIFOLD ..................................................... 1
10 107967 NUT, GRIP 1/4" W/NYLON INSERT ............................................. 2
11 106026 WASHER, 1/4" .................................................................................. 2
12 112536 HOSE, MOLDED (UH-200B) .......................................................... 1
13 112734 HOSE (UH-200)................................................................................ 1
14 112798 BARB, HOSE 1/2" NPT X 5/8" BRASS ........................................ 1
15 100500 BREAKER, VACUUM 1/2" ............................................................. 1
16 108349 KIT, REPAIR 1/2" VACUUM BREAKER ....................................... 1
17 107424 PLUG, 1/8"........................................................................................ 1
18 112763 FITTING, INJECTOR ...................................................................... 1
19 112883 TUBING (PUMP TO INJECTOR) (1/8 OD X 1/16 ID) .................. 1
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
121
Part 9: REPLACEMENT PARTS
(See final rinse manifold
for rinse aid injection point
on UH-200B, UH-200)
10
1
11
To detergent
pump
Water level probe and
detergent injection point
UH-200B, UH-200
16
17
13
To detergent
pump
REAR
6
7
2
3
4
LEFT SIDE
1
To rinse aid
12
LEFT SIDE
14
15
To booster outlet on UH-100B
or
fill/rinse valve on UH-100, UL-100
pump
To sanitizer
pump
(UL-100 Only)
8
6
7
REAR
2
5
LEFT SIDE
4
9
Fill chute and chemical injection point
UH-100B, UH-100, UL-100
Figure 9.6-
Chemical Injections Points, Water Level Probe Assembly (UH-200B, UH-200)
and Fill Chute Assembly (UH-100B, UH-100, UL-100)
122
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Part 9: REPLACEMENT PARTS
CHEMICAL INJECTION POINTS
WATER LEVEL PROBE ASSEMBLY (UH-200B, UH-200)
AND
FILL CHUTE ASSEMBLY (UH-100B, UH-100, UL-100)
Fig. 9.6 Part
Item No. No. Part Description Qty.
1 107424 PLUG 1/8" ....................................................................................... 1
2 100736 BOLT, 1/4" X 3/4" HEX HD ........................................................... 4
3 112632 PROBE, WATER LEVEL (UH-200B, UH-200) ............................. 1
4 0509048 GASKET (ALL MODELS) ............................................................ 1
5 106026 WASHER FLAT 1/4" ...................................................................... 11
6 100141 NUT, GRIP 1/4" W/NYLON INSERT ............................................ 4
7 106482 WASHER ........................................................................................ 4
8 112539 CHUTE, FILL (UH-100B, UH-100, UL-100) ................................ 1
9 112612 THERMISTOR, PROBE (UH-100B, UH-100, UL-100) ............... 1
10 112728 FITTING, COMPRESSION 1/8" NPT X 1/4" OD ......................... 1
11 112879 TUBING (UH-200B, UH-200) ....................................................... 1
12 112880 TUBING (UH-100B, UH-100, UL-100)......................................... 3
13 112906 CLAMP ........................................................................................... 1
14 112648 HOSE, MOLDED (UH-100B) ........................................................ 1
15 112852 HOSE (UH-100, UL-100) ............................................................... 1
16 107966 NUT, GRIP 10-32 W/NYLON INSERT ......................................... 1
17 107033 WASHER ........................................................................................ 1
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
123
Loading...