Bryant 580J'''(D User Manual

580J***(D,F)

SINGLE PACKAGE ROOFTOP
GAS HEATING/ELECTRIC COOLING UNIT

TWO ST AGE COOLING CAPACITY CONTROL WITH NOVATIONt COIL
SIZES 08, 12, 14 WITH PURONR (R--410A) REFRIGERANT

Submittal Data

DESCRIPTION

®

This product has been designed and manufac tured
to meet Energy S tar® criteria for energy efficiency.
However, proper refri gerant charge and proper ai r
flow are crit ical to achi eve rated capacity and ef fi­ciency. Installation of this product should follow all
manufacturer’s refrigerant charging and air flow in­structi ons. Failure to confirm proper charge and

air flow may reduc e en ergy eff i ciency and short­en equipment life.

580J***(D,F) units are high--efficiency, single--pac kaged
electric cooling, gas heating units that are pre--wired and
pre--charged with PuronR (R--410A) HFC refrigerant.
Units utilize an all aluminum flat micro--channel tube
with louvered fins condenser coil—NOVATIONt.The
units are factory tested in both heating and cooling modes.
These units meet the ASHRAE 90.1--2007 and Energy
Star minimum efficiency levels as well as also meeting
2010 efficiency standards.

STANDARD FEATURES

Base Unit

S Puron (R--410A) HFC refrigerant
S ARI certified efficiency levels up to 11.1 EER
S Rated in accordance with ARI Standard 360
S Designed in accordance with Underwriters’ Laboratories Std

1995 and listed by UL and UL, Canada

S Two--stage cooling capacity control
S Non --corrosive composite sloping design; side or center drain

condensate pan. Meets ASHRAE Standard 62

S Standard cooling operating range from 40_Fupto115_F

(4_Cupto46_C). Field installable accessory extends the
minimum down to --20_F(--29_C).

S Convertible from vertical to horizontal airflow for slab mounting
S Two--inch disposable return air filters
S Thru--the--bottom power and gas entry capability
S Single point gas and electric connections
S 24 --volt control circuit protected with resettable circuit breaker

and 75--VA transformer

S Belt drive, constant torque, permanently lubricated

evaporator–fan motor

S Totally enclosed condenser motors with permanently lubricated

bearings

S Low--pressure and high--pressure switches
S Full perimeter base rail with built--in rigging adapters and fork

truck slots

S Centralized Terminal Board for component and unit wiring

connections

Cabinet

S Access panels with easy grip handles and NO--STRIP screw

collar

S Pre--painted exterior panels and primer--coated interior panels

tested to 500 hours salt spray protection

S Fully insulated cabinet
S Tool--less filter access door

Refrigerant System

S Acutrolt refrigerant metering system
S Liquid line filter drier
S Scroll compressors with internal line--break overload protection
S Copper
S NOVATION all aluminum condenser coil
S Removable gauge line plugs for reading refrigerant pressure

tube, aluminum fin evaporator coil

with unit panels in place

Gas Heat

S IGC solid--state gas heat exchanger control for on-- board

diagnostics, anti--cycle protection, LED error code designation,
burner control logic and energy saving indoor fan motor delay

S Gas efficiencies up to 82%
S Designed in accordance with ANSI Z21.47 (design and test

standard for gas furnaces) and ANSI Z233.1 (National Fuel Gas
code relating to appliance installation requirements)

S Induced draft combustion
S Redundant gas valve, with up to 2 stages of heating
S Flame roll--out safety protector
S Solid--state electronic direct spark ignition system

Standard Warranty

S 15--year gas heat exchanger -- Stainless Steel
S 10--year gas heat exchanger -- Aluminized
S 5--year compressor
S 3 --year NOVATION condenser coil
S 1--year parts

580J***(D,F)

STANDARD FEATURES (cont.)

SUBMITTAL DATA

Job Na m e

Architect

Engineer

Contractor

Unit Designation

PERFORMANCE DATA

Unit Operating Weight lb

Cooling

Gross Total Capacity: Btuh

at Condenser Air Temperature _F
Gross Sensible Capacity: Btuh
Compressor Power Input: kW
Indoor Entering db _Fwb _F
Airflow External Static Pressure in.wg
Indoor Fan Motor Size Hp
Exhaust Fan Motor Size Hp

Curb Weight lb

Heating

Heating Capacity:
Stage 1 Btuh
Stage 2 Btuh
Heating Capacity Total Btuh
Stage 1 kW
Stage 2 kW
Heating Capacity Total kW

ELECTRICAL DATA

Power Supply to Unit Volts Phase Hz
Minimum Circuit Amps Maximum Overcurrent Protection

2

OPTIONS AND ACCESSORIES

FACTORY--INSTALLED OPTIONS (FIOPs)

j Open protocol RTU--MP controller communicates to

LON, MODBUS, BACNET and Johnson N2 protocols.

j Through the base connectors for gas and electric

conduit/piping

j Stainless steel gas heat exchanger (includes tubes,

vestibule plate and collector box)

j Economizer with dry bulb sensing and barometric

relief

j Economizer with enthalpy sensing and barometric

relief

j 2 position motorized outdoor air damper
j Non--fused disconnect
j Powered 115--volt convenience outlet
j Non--powered 115--volt convenience outlet
j High static evaporator fan motor
j Return Air smoke detector
j Supply Air smoke detector
j CO
j Condenser hail guard -- louvered style

sensor

2

OPTIONAL WARRANTIES

j Complete Unit Parts only up to 5 years
j Complete Unit Parts and Labor up to 5 years

Many other optional warranties are available.
See the Commercial Start--Up and Optional Extended
Warranty Price price pages for further information.

FIELD INSTALLED ACCESSORIES

j Economi$ert IV--electromechanical, gear driven with

Belimo actuator (2--10v DC signal) and controller

j Economi$ert2-- compatible with DDC controls; gear

driven with Belimo actuator (4--20mA) signal and
no controller

j Power e xhaust
j Two--position motorized outdoor air damper
j Manual outdoor air damper 25%
j Manual outdoor air damper 50%
j Roofcurb -- 14 inch (356mm) tall
j Roofcurb -- 24 inch (610mm) tall
j Thru--the--bottom connections--electrical only
j Thru--the--bottom connections--electrical and gas
j Condenser hail guard -- louvered style
j Flue shield
j Flue discharge deflector
j Liquid propane (LP) conversion kit
j High altitude conversion kit
j Phase monitor (loss of phase/phase reversal)
j Winter start kit, down to 25_F(--4_C)
j Low ambient head pressure controller,

downto0_F(--18_C)

j Low ambient head pressure controller,

down to --20_F(--29_C)

j Time Guard II compressor anti--cycle protection

Economizer Sensors

j Single Dry bulb control
j Differential Dry bulb control
j Single enthalpy control
j Differential enthalpy control
j CO
j CO
j CO

-- wall mounted

2

-- duct mounted

2

-- unit mounted

2

580J***(D,F)

3